Studies on the isolation of penicillin acylase from Escherichia coli by aqueous two-phase partitioning

A method of enzyme release and aqueous two-phase extraction is described for the separation of penicillin acylase from Escherichia coli cells. Butyl acetate, 12% (v/v), treatment combined with freeze-thawing gives up to 70% enzyme release. For polyethylene glycol (PEG) + phosphate two-phase extraction systems the enzyme purity and yield were rather low. Modified PEG, including PEG-ampicillin, PEG-aniline, PEG-phosphate, and PEG-trimethylamine, were synthesized and used in aqueous two-phase systems; PEG-trimethylamine is the most satisfactory. A system containing 12% (w/w) PEG4000, 8% (w/w) of which is PEG-trimethylamine, with 0.7M potasium phosphate at pH 7.2, resulted in the enzyme selective partition being greatly enhanced by charge directed effects. Possible mechanisms for the separation process are discussed. (c) 1992 John Wiley & Sons, Inc.     

Cryopreservation of human bone marrow‐derived mesenchymal stem cells with reduced dimethylsulfoxide and well‐defined freezing solutions

The aim of this study is to investigate the feasibility of using well defined, serum‐free freezing solutions with a reduced level of dimethylsulfoxide (DMSO) of 7.5, 5, and 2.5% (v/v) in the combination with polyethylene glycol (PEG) or trehalose to cryopreserve human bone marrow‐derived mesenchymal stem cells (hBMSCs), a main source of stem cells for cell therapy and tissue engineering. The standard laboratory freezing protocol of around 1°C/min was used in the experiments. The efficiency of 1,2‐propandiol on cryopreservation of hBMSCs was explored. We measured the post‐thawing cell viability and early apoptotic behaviors, cell metabolic activities, and growth dynamics. Cell morphology and osteogenic, adipogenic and chondrogenic differentiation capability were also tested after cryopreservation. The results showed that post‐thawing viability of hBMSCs in 7.5% DMSO (v/v), 2.5% PEG (w/v), and 2% bovine serum albumin (BSA) (w/v) was comparable with that obtained in conventional 10% DMSO, that is, 82.9 ± 4.3% and 82.7 ± 3.7%, respectively. In addition, 5% DMSO (v/v) with 5% PEG (w/v) and 7.5% 1,2‐propandiol (v/v) with 2.5% PEG (w/v) can provide good protection to hBMSCs when 2% albumin (w/v) is present. Enhanced cell viability was observed with the addition of albumin to all tested freezing solutions. © 2010 American Institute of Chemical Engineers Biotechnol. Prog., 2010     

Simultaneous production and partition of chitinase during growth of Serratia marcescens in an aqueous two-phase system

Summary Partition and production of the extracellular chitinase from Serratia marcescens were studied in PEG/dextran aqueous two-phase systems. The enzyme partitions into the bottom phase and the cells segregate into the top phase. The best system is 2% (w/v) PEG 20000 and 5% (w/v) dextran T500. The cell growth and enzyme production kinetics are similar in the aqueous two-phase system and in the polymer-free reference system. However, the maximum enzyme concentration in the former system is 1.5 times that in the latter one.     

Pre- and Postnatal Exposure to Moderate Levels of Ethanol Can Have Long-Lasting Effects on Hippocampal Glutamate Uptake in Adolescent Offspring

The developing brain is vulnerable to the effects of ethanol. Glutamate is the main mediator of excitatory signals in the brain and is probably involved in most aspects of normal brain function during development. The aim of this study was to investigate vulnerability to and the impact of ethanol toxicity on glutamate uptake signaling in adolescent rats after moderate pre and postnatal ethanol exposure. Pregnant female rats were divided into three groups and treated only with water (control), non-alcoholic beer (vehicle) or 10% (v/v) beer solution (moderate prenatal alcohol exposure—MPAE). Thirty days after birth, adolescent male offspring were submitted to hippocampal acute slice procedure. We assayed glutamate uptake and measured glutathione content and also quantified glial glutamate transporters (EAAT 1 and EAAT 2). The glutamate system vulnerability was tested with different acute ethanol doses in naïve rats and compared with the MPAE group. We also performed a (lipopolysaccharide-challenge (LPS-challenge) with all groups to test the glutamate uptake response after an insult. The MPAE group presented a decrease in glutamate uptake corroborating a decrease in glutathione (GSH) content. The reduction in GSH content suggests oxidative damage after acute ethanol exposure. The glial glutamate transporters were also altered after prenatal ethanol treatment, suggesting a disturbance in glutamate signaling. This study indicates that impairment of glutamate uptake can be dose-dependent and the glutamate system has a higher vulnerability to ethanol toxicity after moderate ethanol exposure In utero. The effects of pre- and postnatal ethanol exposure can have long-lasting impacts on the glutamate system in adolescence and potentially into adulthood.     

Use of chemically modified proteins to study the effect of a single protein property on partitioning in aqueous two-phase systems: Effect of surface charge

A series of charge-modified thaumatins with different values of surface charge were partitioned in aqueous two-phase systems (ATPS) to study the effect of surface charge as a single property on partitioning. Electrophoretic mobility of the proteins in titration curves was used as a measure of surface charge. Four modified proteins derived from thaumatin with the following values of isoelectric point: 8.70, 8.15, 5.60, and 4.50 were used for partitioning. The resolution of the systems in terms of protein surface charge was calculated. Partitioning of modified thaumatins in PEG 4000/dextran systems with phosphate buffer, Tris buffer, NaCl, KCl, and sulfate salts was carried out. Among the sulfate salts tested, the addition of 50 mM Li(2)SO(4) to the system buffered with phosphate gave the highest value of resolution for differences in surface protein charge (RSPC). It shows a decrease in the value of K (partition coefficient) with an increase in the protein's charge. The addition of 100 mM KCl to the system promoted the opposite effect on the RSPC value. Charge-modified proteins were partitioned in PEG/salt systems to investigate the ability of these systems for resolving differences in surface charge. The PEG/citrate system seemed to have almost no ability for resolving proteins on the basis of surface charge differences; PEG/phosphate systems had some capability for resolving differently charged proteins. The more negative proteins tended to have higher values of K than the more positively charged fractions. The use of charge-modified proteins allowed the investigation of the effect of protein surface charge on partitioning in aqueous two-phase systems independently from other protein parameters as they were prepared from a common parent protein thaumatin. This technique provides an interesting novel tool to investigate the effect of protein surface charge on partitioning in ATPS taking protein charge as an independent parameter. (c) 1996 John Wiley & Sons, Inc.     

Production of cyclodextrin homologues using aqueous two-phase system

Cyclodextrin homologues (CDs), produced by cyclodextrin glycosyltransferase (CGTase), were simultaneously partitioned in aqueous two-phase system (ATPS). Partition coefficients of CDs were measured in PEG/salt and PEG/dextran systems. Phosphate, citrate, sulfate were tested as salt. ATPS of PEG/salt and PEG/dextran had the partition coefficients of the CDs, larger than unity. However, PEG/dextran system was observed better than PEG/salt as CGTase activity decreased sharply with salt concentration. Enzymatic reaction occurred mainly in PEG-rich bottom phase because of the low partition coefficient of CGTase. The resulting CDs transferred to the PEG-rich top phase, obeying the diffusional partition. In the ATPS of 7% PEG (M.W. 20,000) and 9% dextran (M.W. 40,000), 7 mg/ml of CDs were obtained in top phase at 4.5 hours.     

BEHAVIOUR OF HORSERADISH PEROXIDASE IN AOT REVERSED MICELLES

The activity and stability of horseradish peroxidase (HRP) solubilised in AOT reversed micelles in isooctane and decalin was studied using guaiacol (2-methoxyphenol) as the electron donor.

The activity of the enzyme in both reversed micellar systems increases with the water content until reaching a maximum value that remains fairly constant for water contents higher than 3.05% (v/v) in isooctane and 2.20% in decalin. The effect of pH on the activity profile was studied in the system AOT/isooctane. The enzyme is fully active at pH 7 and 8 for water contents higher than 3.05% (v/v) but it was completely deactivated at pH 9. The effect of surfactant concentration on HRP activity was also investigated. At low water contents a strong dependence was observed, whilst no further activity increase was observed for water content values higher than 2.7% (v/v).

The stability of HRP was found to be strongly dependent on the water content of the system with higher levels of stability obtained for higher values of water content. HRP stability is also affected by the presence of substrates. Whilst the stability increases markedly when the enzyme is incubated with guaiacol, it does not appear to be so strongly affected by the presence of hydrogen peroxide, at the concentrations studied.     

Effects of carbohydrate source, polyethylene glycol and gellan gum concentration on embryonal-suspensor mass (ESM) proliferation and maturation of maritime pine somatic embryos

Summary The influence of carbon sources and polyethylene glycol combined with 0.45 and 0.9% (w/v) of gellan gum on the maturation of maritime pine somatic embryos was tested. The effect of the carbon source and polyethylene glycol varied widely between lines. One out of the five lines tested showed a striking response to polyethylene glycol (PEG) treatment; the addition of this osmoticum limited the embryonal-suspensor mass (ESM) proliferation while it enhanced the maturation rate. Conversely, the ESM proliferation was stimulated by PEG in the other lines without subsequent improvement of the maturation rate. The use of a high concentration of gellan gum (0.9%) improved the maturation of the five ESM lines. It was concluded that the most efficient culture medium to recover cotyledonary embryos from all lines is one supplemented with sucrose at 6% (w/v) and gellan gum at 0.9% (w/v) without PEG. The determining factor in the maturation of maritime pine somatic embryos is the genotype and/or the quality of ESM. The possible relationship between maturation performances and ESM morphology, particularly the suspensor organization, is discussed.     

Correlation for the partition behavior of proteins in aqueous two-phase systems: effect of surface hydrophobicity and charge

Correlations to describe the effect of surface hydrophobicity and charge of proteins with their partition coefficient in aqueous two-phase systems were investigated. Polyethylene glycol (PEG) 4000/phosphate, sulfate, citrate, and dextran systems in the presence of low (0.6% w/w) and high (8.8% w/w) levels of NaCl were selected for a systematic study of 12 proteins. The surface hydrophobicity of the proteins was measured by ammonium sulfate precipitation as the inverse of their solubility. The hydrophobicity values measured correlated well with the partition coefficients, K, obtained in the PEG/salt systems at high concentration of NaCl (r = 0.92-0.93). In PEG/citrate systems the partition coefficient correlated well with protein hydrophobicity at low and high concentrations of NaCl (r = 0.81 and 0.93, respectively). The PEG/citrate system also had a higher hydrophobic resolution than other systems to exploit differences in the protein's hydrophobicity. The surface charge and charge density of the proteins was determined over a range of pH (3-9) by electrophoretic titration curves; PEG/salt systems did not discriminate well between proteins of different charge or charge density. In the absence of NaCl, K decreased slightly with increased positive charge. At high NaCl concentration, K increased as a function of positive charge. This suggested that the PEG-rich top phase became more negative as the concentration of NaCl in the systems increased and, therefore, attracted the positively charged proteins. The effect of charge was more important in PEG/dextran systems at low concentrations of NaCl. In the PEG/dextran systems at lower concentration of NaCl, molecular weight appeared to be the prime determinant of partition, whereas no clear effect of molecular weight could be found in PEG/salt systems.     

Proton-linked transport systems as sensors of changes in the membrane surface potential

The kinetic properties of proton linked transport systems and their relation to the membrane surface potential were studied in yeast cells. (1) The negative surface potential of cells rich in anionic phospholipids was found to be 2-times higher than that of control cells; in agreement with their 2-fold increase in the anionic/zwitterionic phospholipid ratio (A/Z). (2) At low external concentration of substrates (high-affinity systems), higher uptake activities were observed for the anions, glutamate, aspartate and phosphate; the zwitterion glycine and the cations lysine and arginine, in both phosphatidylserine and phosphatidylinositol rich cells when compared to control cells. (3) On the other hand, at high external concentration of substrates (low-affinity systems), lower uptake activities were observed for glutamate, aspartate, phosphate and glycine in the cells rich in anionic phospholipids. (4) A decrease in Km without significant alteration in Vmax was found in the high-affinity transport systems that can be explained by the increase in proton concentration at the interface caused by the enhancement in negative surface charge of the cells rich in anionic phospholipids. (5) The mechanisms of the high-affinity proton linked transport systems are compatible with a model which is necessarily ordered, protons before anions. The low-affinity transport systems, on the other hand, follow a random order of binding. The transport systems studied behave as sensors of the changes in surface potential. The reduction of the surface potential reversed the transport alterations with the following sequence: monovalent cations less than divalent cations less than cationic local anesthetics.     

Isolation of plasmid DNA from cell lysates by aqueous two-phase systems

This work presents a study of the partitioning of a plasmid vector containing the cystic fibrosis gene in polyethylene glycol (PEG)/salt (K2HPO4) aqueous two-phase systems (ATPS). The plasmid was extracted from neutralized alkaline lysates using PEG with molecular weights varying from 200 to 8000. The effects of the lysate mass loaded to the ATPS (20, 40, and 60% w/w) and of the plasmid concentration in the lysate were evaluated. The performance of the process was determined by qualitative and quantitative assays, carefully established to overcome the strong interference of impurities (protein, genomic DNA, RNA), salt, and PEG. Plasmid DNA partitioned to the top phase when PEG molecular weight was lower than 400. The bottom phase was preferred when higher PEG molecular weights were used. Aqueous two-phase systems with PEG 300, 600, and 1000 were chosen for further studies on the basis of plasmid and RNA agarose gel analysis and protein quantitation. The recovery yields were found to be proportional to the plasmid concentration in the lysate. The best yields (>67%) were obtained with PEG 1000. These systems (with 40 and 60% w/w of lysate load) were able to separate the plasmid from proteins and genomic DNA, but copartitioning of RNA with the plasmid was observed. Aqueous two-phase systems with PEG 300 concentrated both plasmid and proteins in the top phase. The best system for plasmid purification used PEG 600 with a 40% (w/w) lysate load. In this system, RNA was found mostly in the interphase, proteins were not detected in the plasmid bottom phase and genomic DNA was reduced 7.5-fold.     

Aqueous two-phase systems containing urea: influence on phase separation and stabilization of protein conformation by phase components.

During recombinant Escherichia coli fermentation with high expression levels, inclusion bodies are often formed. Aqueous two-phase systems have been used in the presence of urea for the initial recovery steps. To investigate phase behavior of such systems we determined phase diagrams of poly(ethylene glycol) (PEG)/sodium sulfate/urea/water and PEG/dextran T-500 (DEX)/urea/phosphate buffer/water at different concentrations of urea and different molecular weight of PEG. PEG/Na2SO4 aqueous two-phase systems could be obtained including up to 30% w/w urea at 25 degrees C and PEG/dextran T-500 up to 35% w/w urea. The binodial was displaced toward higher concentrations with increasing urea concentrations. The partition coefficient of urea was near unity. An unstable mutant of T4-lysozyme with an amino acid replacement in the core (V149T) was used to analyze the effect of phase components on the conformation of the enzyme. We showed that partitioning of tryptophan was not dependent on the concentration of urea in the phase system.     

Enhanced discrimination in the partition of proteins by aqueous polymer two-phase systems

Aqueous polymer two-phase systems containing dextran T-500 and PEG 4000 can be prepared which are biphasic below 18 degrees C and monophasic at higher temperatures. Both liganded and unliganded forms of glutamate dehydrogenase and troponin, which have similar partition coefficients if the protein is added to a two-phase system at 4 degrees C, have widely differing partition coefficients if added to the same system in the monophasic state at 20 degrees C and subsequently cooled to 4 degrees C.     

Isolation and characterization of solvent-tolerant Pseudomonas putida strain T-57, and its application to biotransformation of toluene to cresol in a two-phase (organic-aqueous) system

Pseudomonas putida T-57 was isolated from an activated sludge sample after enrichment on mineral salts basal medium with toluene as a sole source of carbon. P. putida T-57 utilizes n-butanol, toluene, styrene, m-xylene, ethylbenzene, n-hexane, and propylbenzene as growth substrates. The strain was able to grow on toluene when liquid toluene was added to mineral salts basal medium at 10-90% (v/v), and was tolerant to organic solvents whose log P(ow) (1-octanol/water partition coefficient) was higher than 2.5. Enzymatic and genetic analysis revealed that P. putida T-57 used the toluene dioxygenase pathway to catabolize toluene. A cis-toluene dihydrodiol dehydrogenase gene (todD) mutant of T-57 was constructed using a gene replacement technique. The todD mutant accumulated o-cresol (maximum 1.7 g/L in the aqueous phase) when cultivated in minimal salts basal medium supplemented with 3% (v/v) toluene and 7% (v/v) 1-octanol. Thus, T-57 is thought to be a good candidate host strain for bioconversion of hydrophobic substrates in two-phase (organic-aqueous) systems.     

Efficient polycyclic aromatic hydrocarbons dihydroxylation in direct micellar systems

Optimization of whole-cell bioconversion of the polycyclic aromatic hydrocarbons (PAHs) anthracene, phenanthrene, and naphthalene to the enantiomerically pure corresponding cis-dihydroxydihydro derivatives by the Escherichia coli JM109 (pPS1778) recombinant strain, carrying the naphthalene dioxygenase and corresponding regulatory genes cloned from Pseudomonas fluorescens N3, in micellar systems, is presented. We show that direct microemulsion systems, where a nonionic surfactant such as 1.5% (v/v) Triton X-100 plus 0.6% to 1.0% (v/v) selected oils are able to solubilize the PAHs tested at relatively high concentrations (initial concentrations in the reaction medium > or =10 mM for naphthalene and phenanthrene and > or =2 mM for anthracene), and allow for more efficient substrate bioconversion. These media, while not affecting bacteria viability and performance, provide increased efficiency and final product yields (100% for naphthalene, >30% for anthracene, >60% for phenanthrene). The phase behavior of the direct microemulsion systems for the different substrates and oils utilized was monitored as a function of their volume fraction by light scattering experiments, and related to the bioconversion results. For anthracene and phenanthrene, the dihydroxylated products have an inhibitory effect on the conversion reactions, thus hindering complete turnover of the substrates. We ascertain that such inhibition is reversible because removal of the products formed allowed the process to start over at rates comparable to initial rates. To allow for complete conversion of the PAHs tested a stepwise or continuous separation of the product formed from the micellar reaction environment is being developed.     

Molecular templates for bio-specific recognition by low-energy electron beam lithography

Protein patterning has become an important topic as advances are made in biologically integrated devices and protein chip technology. Versatile and effective patterning requires substrates that can be quantified, with active presentation of proteins and control over protein density and orientation. Herein we describe a model system and the use of low-energy electron beam lithography to pattern molecular templates for immobilization of antibodies through ligand recognition. The templates were patterned over a background of poly(ethylene glycol) (PEG) modified silicon oxide (SiO _x ). These substrates were exposed to a low-voltage (2 keV) electron beam to remove PEG selectively from exposed regions. These regions were then functionalized with a dinitrophenyl (DNP) ligand and tested for specific binding of fluorescently labeled anti-DNP antibodies. The PEG modified regions in conjunction with ligand-presenting regions in the patterned arrays substantially reduces non-specific adsorption of proteins, yielding a specific/nonspecific ratio of approx 10. The surface coverage of the biologically active DNP groups on SiO _x and the amount of immobilized antibody on DNP were measured with a fluorescence-based, enzyme-linked immunosorbent assay. The specificity of the interaction between DNP ligand and fluorescently labeled anti-DNP antibodies was evaluated with fluorescence microscopy. This approach to patterning of molecular templates and assays for quantification are generally applicable to immobilization of any ligand-receptor pair on a wide range of substrates.     

Technical improvement in the purification of enzymes from red algae using an aqueous two-phase partitioning system

The effective elimination of phycobiliproteins from crude enzyme preparation of the red alga Caloglossa continua (Okamura) King et Puttock (Ceramiales, Florideophyceae) was investigated in an aqueous two‐phase partitioning system (ATPS) by changing the concentrations of polyethylene glycol (PEG) and ammonium sulfate (AS). The phycobiliproteins shifted from the AS‐rich lower phase to the PEG‐rich upper phase in high PEG and AS concentrations. The best ATPS condition for the elimination of phycobiliproteins from the lower phase was obtained by the combination of 20% (weight/volume; w/v) PEG and 16% (w/v) AS. However, the recovery of aldolase and mannitol‐1‐phos‐phatase activities was significantly reduced. For purification of the enzymes, a combination of 15% (w/v) PEG and 16% (w/v) AS was the best ATPS condition, because a high specific activity and recovery of the enzymes were obtained. Under these conditions, 98% of the phycobiliproteins were removed from the lower phase. Therefore, the ATPS proved to be a very useful method as a first step in the purification of enzymes from red algae.     

Plasmid transformation of Mycoplasma mycoides subspecies mycoides is promoted by high concentrations of polyethylene glycol.

The recent isolation and characterization of two plasmids from Mycoplasma mycoides subspecies mycoides has opened up new possibilities for studying mycoplasmal genetics. In order to facilitate the development of a genetic system in M. mycoides subsp. mycoides, parameters of polyethylene glycol (PEG)-mediated transformation were examined, as existing protocols prove very inefficient in this organism. The effects of PEG concentration, DNA concentration, presence of Ca2+ ions, and choice of buffers on the transformation of the Tn916-containing plasmid pAM120 into M. mycoides subsp. mycoides were examined. The stability of Tn916 in the M. mycoides subsp. mycoides chromosome was also evaluated. The optimal PEG concentration (53-62% (w/v)) in the transformation mixture was substantially higher than the PEG concentration reported to be optimal for transformation of other mycoplasmas (36% (w/v)). The PEG concentrations used here were also higher than the concentration used to promote transformation or fusion of gram-positive bacterial protoplasts. A necessity for the presence of Ca2+ ions for optimal transformation was shown, as was the possible involvement of cell culture growth stage. Our results demonstrate the need for expanding current transformation techniques for mycoplasmas. Studies also indicate that once Tn916 inserts into the M. mycoides subsp. mycoides chromosome, it can transpose to other sites at a relatively high frequency.     

Purification and stabilization of ricin B from tobacco hairy root culture medium by aqueous two-phase extraction

Ricin B (RTB), the non-toxic lectin subunit of ricin, is a promising mucosal adjuvant and carrier for use in humans. RTB fusion proteins have been expressed in tobacco hairy root cultures, but the secreted RTB component of these proteins was vulnerable to protease degradation in the medium. Moreover, castor bean purified RTB spiked into tobacco hairy root culture media showed significant degradation after 24 h and complete loss of product after 72 h. Aqueous two-phase extraction (ATPE) was tested for fast recovery of RTB not only to partially purify the protein but also to improve its stability. Two different polyethylene glycol (PEG)/salt/water systems including PEG/potassium phosphate and PEG/sodium sulfate, were studied. RTB was shown to be favorably recovered in PEG/sodium sulfate systems. Statistical analysis indicated that the ionic strength of the system and the sodium sulfate concentration were important in optimizing the partition coefficient of RTB. A selectivity of almost three could be achieved for RTB in optimized systems, and RTB partitioned in the PEG-rich phase exhibited extended stability. Therefore, ATPE was shown to be effective in initial recovery/purification and stabilization of RTB and may hold promise for other unstable secreted proteins from hairy root culture.     

Role of polymer–protein interaction on partitioning pattern of bovine pancreatic trypsinogen and alpha-chymotrypsinogen in polyethyleneglycol/sodium tartrate aqueous two-phase systems

The partitioning pattern of bovine trypsinogen (TRPz) and alpha-chymotrypsinogen (ChTRPz) was investigated in a low impact aqueous two-phase system formed by polyethyleneglycol (PEG) and sodium tartrate (NaTart) pH 5.00. ChTRPz exhibited higher partition coefficients than TRPz did in all the assayed systems. The decrease in PEG molecular weight and the increase in tie line length were observed to displace the partitioning equilibrium of both proteins to the top phase, while phase volume ratios in the range 0.5–1.5 showed not to affect protein partitioning behaviour. Systems formed by PEG of molecular weight 600 with composition corresponding to a high tie line length (PEG 12.93%, w/w and NaTart 21.20%, w/w) are able to recover most of both zymogens in the polymer-enriched phase. A crucial role of PEG–protein interaction in the partitioning mechanism was evidenced by isothermal calorimetric titrations. The major content of highly exposed tryptophan rests, present in ChTRPz molecule, could be considered to be determinant of its higher partition coefficient due to a selective charge transfer interaction with PEG molecule. A satisfactory correlation between partition coefficient and protein surface hydrophobicity was observed in systems formed with PEGs of molecular weight above 4000, this finding being relevant in the design of an extraction process employing aqueous two-phase systems.