Energetics and regulations of formate and hydrogen metabolism by Methanobacterium formicicum

Accumulation of formate to millimolar levels was observed during the growth of Methanobacterium formicicum species on H₂–CO₂. Hydrogen was also produced during formate metabolism by M. formicicum. The amount of formate accumulated in the medium or the amount H₂ released in gas phase was influenced by the bicarbonate concentration. The formate hydrogenlyase system was constitutive but regulated by formate. When methanogenesis was inhibited by addition of 2-bromoethane sulfonate, M. formicicum synthesized formate from H₂ plus HCO _inf3 ^sup- or produced H₂ from formate to a steady-state level at which point the Gibbs free energy (G) available for formate synthesis or H₂ production was approximately -2 to -3 kJ/reaction. Formate conversion to methane was inhibited in the presence of high H₂ pressure. The relative rates of conversion of formate and H₂ were apparently controlled by the G available for formate synthesis, hydrogen production, methane production from formate and methane production from H₂. Results from ¹⁴C-tracer tests indicated that a rapid isotopic exchange between HCOO^- and HCO _inf3 ^sup- occurred during the growth of M. formicicum on H₂–CO₂. Data from metabolism of ¹⁴C-labelled formate to methane suggested that formate was initially split to H₂ and HCO _inf3 ^sup- and then subsequently converted to methane. When molybdate was replaced with tungstate in the growth media, the growth of M. formicicum strain MF on H₂–CO₂ was inhibited although production of methane was not Formate synthesis from H₂ was also inhibited.     

Acetate formation from CO and CO2 by cell extracts of Peptostreptococcus productus (strain Marburg)

Cell extracts of Peptostreptococcus productus (strain Marburg) obtained from CO grown cells mediated the synthesis of acetate from CO plus CO₂ at rates of 50 nmol/min × mg of cell protein. ¹⁴CO was specifically incorporated into C₁ of acetate. No label exchange occurred between ¹⁴C₁ of acetyl-CoA and CO, indicating that ¹⁴CO incorporation into acetate was by net synthesis rather than by an exchange reaction. In acetate synthesis from CO plus CO₂ the latter substrate could be replaced to some extent by formate or methyl tetrahydrofolate as the methyl donor. The methyl group of methyl cobalamin was incorporated into acetate ony at very low activities. The cell extracts contained high levels of enzyme activities involved in acetate or cell carbon synthesis from CO₂. The following enzymic activities were detected: CO: methyl viologen oxidoreductase, formate dehydrogenase, formyl tetrahydrofolate synthetase, methenyl tetrahydrofolate cyclohydrolase, methylene tetrahydrofolate dehydrogenase, methylene tetrahydrofolate reductase, phosphate acetyltransferase, acetate kinase, hydrogenase, NADPH: benzyl viologen oxidoreductase, and pyruvate synthase. Some kinetic and other properties were studied.     

Revealing formate production from carbon monoxide in wild type and mutants of Rnf- and Ech-containing acetogens,Acetobacterium woodii and Thermoanaerobacter kivui

Acetogenic bacteria have gained much attraction in recent years as they can produce different biofuels and biochemicals from H₂ plus CO₂ or even CO alone, therefore opening a promising alternative route for the production of biofuels from renewable sources compared to existing sugar-based routes. However, CO metabolism still raises questions concerning the biochemistry and bioenergetics in many acetogens. In this study, we focused on the two acetogenic bacteria Acetobacterium woodii and Thermoanaerobacter kivui which, so far, are the only identified acetogens harbouring a H₂-dependent CO₂ reductase and furthermore belong to different classes of ‘Rnf’- and ‘Ech-acetogens’. Both strains catalysed the conversion of CO into the bulk chemical acetate and formate. Formate production was stimulated by uncoupling the energy metabolism from the Wood–Ljungdahl pathway, and specific rates of 1.44 and 1.34 mmol g⁻¹ h⁻¹ for A. woodii ∆rnf and T. kivui wild type were reached. The demonstrated CO-based formate production rates are, to the best of our knowledge, among the highest rates ever reported. Using mutants of ∆hdcr, ∆cooS, ∆hydBA, ∆rnf and ∆ech2 with deficiencies in key enzyme activities of the central metabolism enabled us to postulate two different CO utilization pathways in these two model organisms.     

Hydrogenase 3 but not hydrogenase 4 is major in hydrogen gas production by Escherichia coli formate hydrogenlyase at acidic pH and in the presence of external formate

Fermenting Escherichia coli is able to produce formate and molecular hydrogen (H₂) when grown on glucose. H₂ formation is possessed by two hydrogenases, 3 (Hyd-3) and 4 (Hyd-4), those, in conjunction with formate dehydrogenase H (Fdh-H), constitute distinct membrane-associated formate hydrogenylases. At slightly alkaline pH (pH 7.5), the production of H₂ was found to be dependent on Hyd-4 and the F₀F₁-adenosine triphosphate (ATPase), whereas external formate increased the activity of Hyd-3. In this study with cells grown without and with external formate H₂ production dependent on pH was investigated. In both types of cells, H₂ production was increased after lowering of pH. At acidic pH (pH 5.5), this production became insensitive either to N,N′-dicyclohexylcarbodiimide or to osmotic shock and it became largely dependent on Fdh-H and Hyd-3 but not Hyd-4 and the F₀F₁-ATPase. The results indicate that Hyd-3 has a major role in H₂ production at acidic pH independently on the F₀F₁-ATPase.     

Expression of NAD<Superscript>+</Superscript>-dependent formate dehydrogenase in <Emphasis Type="Italic">Enterobacter aerogenes</Emphasis> and its involvement in anaerobic metabolism and H<Subscript>2</Subscript> production

An expression system for NAD⁺-dependent formate dehydrogenase gene (fdh1), from Candida boidinii, was constructed and cloned into Enterobacter aerogenes IAM1183. With the fdh1 expression, the total H₂ yield was attributed to a decrease in activity of the lactate pathway and an increase of the formate pathway flux due to the NADH regeneration. Analysis of the redox state balance and ethanol-to-acetate ratio in the fdhl-expressed strain showed that increased reducing power arose from the reconstruction of NADH regeneration pathway from formate thereby contributing to the improved H₂ production.     

Effect of tungsten and molybdenum on growth of a syntrophic coculture of <Emphasis Type="Italic">Syntrophobacter fumaroxidans</Emphasis> and <Emphasis Type="Italic">Methanospirillum hungatei</Emphasis>

The effect of tungsten (W) and molybdenum (Mo) on the growth of Syntrophobacter fumaroxidans and Methanospirillum hungatei was studied in syntrophic cultures and the pure cultures of both the organisms. Cells that were grown syntropically were separated by Percoll density centrifugation. Measurement of hydrogenase and formate dehydrogenase levels in cell extracts of syntrophically grown cells correlated with the methane formation rates in the co-cultures. The effect of W and Mo on the activity of formate dehydrogenase was considerable in both the organisms, whereas hydrogenase activity remained relatively constant. Depletion of tungsten and/or molybdenum, however, did not affect the growth of the pure culture of S. fumaroxidans on propionate plus fumarate significantly, although the specific activities of hydrogenase and especially formate dehydrogenase were influenced by the absence of Mo and W. This indicates that the organism has a low W or Mo requirement under these conditions. Growth of M. hungatei on either formate or H₂/CO₂ required tungsten, and molybdenum could replace tungsten to some extent. Our results suggest a more prominent role for H₂ as electron carrier in the syntrophic conversion of propionate, when the essential trace metals W and Mo for the functioning of formate dehydrogenase are depleted.     

A functional Wood–Ljungdahl pathway devoid of a formate dehydrogenase in the gut acetogens Blautia wexlerae,Blautia luti and beyond

Species of the genus Blautia are typical inhabitants of the human gut and considered as beneficial gut microbes. However, their role in the gut microbiome and their metabolic features are poorly understood. Blautia schinkii was described as an acetogenic bacterium, characterized by a functional Wood–Ljungdahl pathway (WLP) of acetogenesis from H₂ + CO₂. Here we report that two relatives, Blautia luti and Blautia wexlerae do not grow on H₂ + CO₂. Inspection of the genome sequence revealed all genes of the WLP except genes encoding a formate dehydrogenase and an electron-bifurcating hydrogenase. Enzyme assays confirmed this prediction. Accordingly, resting cells neither converted H₂ + CO₂ nor H₂ + HCOOH + CO₂ to acetate. Carbon monoxide is an intermediate of the WLP and substrate for many acetogens. Blautia luti and B. wexlerae had an active CO dehydrogenase and resting cells performed acetogenesis from HCOOH + CO₂ + CO, demonstrating a functional WLP. Bioinformatic analyses revealed that many Blautia strains as well as other gut acetogens lack formate dehydrogenases and hydrogenases. Thus, the use of formate instead of H₂ + CO₂ as an interspecies hydrogen and electron carrier seems to be more common in the gut microbiome.     

Transient Production of Formate During Chemolithotrophic Growth of Anaerobic Microorganisms on Hydrogen

The homoacetogenic bacteria Acetobacterium woodii, A. carbinolicum, Sporomusa ovata, and Eubacterium limosum, the methanogenic archaeon Methanobacterium formicicum, and the sulfate-reducing bacterium Desulfotomaculum orientis all produced formate as an intermediate when they were growing chemolithoautotrophically with H₂ and CO₂ as sources of energy, electrons, and carbon. The sulfate-reducing bacterium Desulfovibrio vulgaris grew chemolithoheterotrophically with H₂ and CO₂ using acetate as carbon source, but also produced formate when growth was limited by sulfate. All these bacteria were also able to grow on formate as energy source. Formate accumulated transiently while H₂ was consumed. The maximum formate concentrations measured in cultures of A. woodii and A. carbinolicum were proportional to the initial H₂ partial pressure, giving a ratio of about 0.5 mM formate per 10 kPa H₂. The methanogen Methanobacterium bryantii, on the other hand, was unable to grow on formate and did not produce formate during chemolithoautotrophic growth on H₂. The results indicate that the ability to utilize formate, that is, to possess a formate dehydrogenase, was the precondition for the production of formate during chemolithotrophic growth on H₂. Received: 24 November 1998 / Accepted: 30 December 1998     

Formate production and utilization by methanogens and by sewage sludge consortia — interference with the concept of interspecies formate transfer

Pure cultures of H₂/CO₂- and formate-utilizing methanogens or mixed consortia of sewage sludge generated some formate from H₂/CO₂ at H₂ partial pressure in the gas phase above 200 kPa. At decreasing H₂ partial pressure the formate was taken up again and converted to methane. If methanogenesis was inhibited by bromoethanesulphonic acid (BESA) or a high redox potential (–180 to –200 mV), formate-utilizing methanogens produced high amounts of formate from H₂/CO₂. No formate was excreted by the species, which could only utilize H₂/CO₂ for methanogenesis. In contrast, H₂ formation from formate was observed in cultures of Methanobacterium thermoformicicum and M. formicicum. Measurable amounts were, however, only formed if its immediate utilization for methane production was inhibited by BESA. In the light of the data on formate formation from H₂/CO₂ and its re-utilization by all formate-utilizing methanogens, the concept of interspecies formate transfer of Thiele and Zeikus should be reconsidered. In pure cultures of methanogens or complex ecosystems with excess H₂, formate formation seemed to serve more as a means of disposal of surplus reducing power than for H₂ transfer. Correspondence to: J. Winter     

H2 production of Rhodospirillum rubrum during adaptation to anaerobic dark conditions

Rhodospirillum rubrum is able to produce H₂ during fermentation anaerobically in the dark in two ways, namely through formate hydrogen lyase and through the nitrogenase. After chemotrophic preculture aerobically in the dark formate hydrogen lyase was synthesized after a lag phase, whilst after phototrophic preculture a slight activity was present from the beginning of the anaerobic dark culture. During fermentation metabolism its activity increased noticeably. Hydrogen production through the nitrogenase occurred if the nitrogenase had been activated during phototrophic preculture. It ceased during fermentation metabolism after about 3 1/2 h anaerobic dark culture. The CO insensitive H₂ production by the nitrogenase could be partially inhibited by N₂. Potential activity of this system, however, remained and could be increased under conditions of nitrogenase induction. It seems therefore possible that synthesis of nitrogenase under N-deficiency can occur during fermentation metabolism in the same way as the formation of the photosynthetic apparatus in order to prepare for subsequent phototrophic metabolism.Abbreviations CAP chloramphenicol - DSM Deutsche Sammlung von Mikroorganismen, Göttingen - FHL formate hydrogen lyase - O.D optical density - PFL pyruvate formate lyase     

Influence of external electron acceptors and of CO and H2 on the xylose metabolism ofBacteroides xylanolyticus X5.1

WhenBacteroides xylanolyticus X5-1 was grown on xylose in batch culture, acetate, ethanol, H₂, CO₂ and formate were the main fermentation products. CO inhibited H2 formation byB. xylanolyticus X5-1. As a result, the product formation shifted to more ethanol and formate and less acetate. Furthermore, less biomass was produced. H2 had almost no effect on the product formation from xylose. In batch cultures, dihydroxyacetone, acetone, acetoin and acetol could act as electron acceptors during xylose metabolism. The electron acceptors were reduced to their corresponding alcohols. The product formation from xylose byB. xylanolyticus X5-1 shifted to mainly acetate and CO₂, and an increased biomass yield was obtained. H₂, ethanol and formate were no longer produced. In continuous cultures not only 1,2-propanediol was formed from acetol, but also acetone. The NADP-dependent ethanol dehydrogenase that was present in xylosegrown continuous-culture cells, was repressed when the organism was grown in the presence of acetol. However, another alcohol dehydrogenase was induced for reduction of the external electron acceptor.     

Butyrate oxidation by Syntrophospora bryantii in co-culture with different methanogens and in pure culture with pentenoate as electron acceptor

Syntrophospora bryantii degraded butyrate in co-culture with methanogens that can use both H₂ and formate for growth, but not in co-culture with methanogens that metabolize only H₂, suggesting that in suspended cultures formate may be a more important electron carrier in the syntrophic degradation of butyrate than H₂. Syntrophic butyrate oxidation was inhibited by the addition of 20 mm formate or the presence of 130 kPa H₂. In the absence of methanogens, S. bryantii is able to couple the oxidation of butyrate to acetate with the reduction of pentenoate to valerate. Under these conditions, up to 300 Pa H₂ was measured in the gas phase and up to 0.3 mm formate in the liquid phase. S. bryantii was unable to grow syntrophically with the aceticlastic methanogen Methanothrix soehngenii. However in triculture with Methanospirillum hungatei and Methanothrix soehngenii, S. bryantii degraded butyrate faster than in a biculture with only M. hungatei. Hydrogenase and formate dehydrogenase activities were demonstrated in cell-free extracts of S. bryantii.     

Pyruvate fermentation in light-grown cells ofRhodospirillum rubrum during adaptation to anaerobic dark conditions

Pyruvate fermentation inRhodospirillum rubrum (strains F₁, S₁, and Ha) was investigated using cells precultured on different substrates anaerobically in the light and than transferred to anaerobic dark conditions. Pyruvate formate lyase was always the key enzyme in pyruvate fermentation but its activity was lower than in cells which have been precultured aerobically in darkness. The preculture substrate also had a clear influence on the pyruvate formate lyase activity. Strains F₁ and S₁ metabolized the produced formate further to H₂ and CO₂. A slight production of CO₂ from pyruvate, without additional H₂-production, could also be detected. It was concluded from this that under anaerobic dark conditions a pyruvate dehydrogenase was also functioning. On inhibition of pyruvate formate lyase the main part of pyruvate breakdown was taken over by pyruvate dehydrogenase.When enzyme synthesis was inhibited by chloramphenicol, propionate production in contrast to formate production was not affected. Protein synthesis was not significant during anaerobic dark culture. Bacteriochlorophyll. however, showed, after a lag phase, a clear rise.Abbreviations Bchl Bacteriochlorophyll - CoA Coenzyme A - DSM Deutsche Sammlung von Mikroorganismen (Göttingen) - OD optical density - PHBA poly--hydroxybutyric acid - R Rhodospirillum     

Plasmids in carboxydotrophic bacteria: physical and restriction analysis

Twenty species and strains of aerobic CO-oxidizing bacteria were screened for the occurrence of plasmids. Six of them harbored plasmids between 45 and 558kb. Megaplasmids of 428 and 558 kb were resolved in Alcaligenes carboxydus. Restriction digest patterns of plasmids from different carboxydotrophic bacteria were dissimilar. However, the patterns obtained with the plasmids from the strains OM5, OM4 and OM2 of Pseudomonas carboxydovorans were very much the same. The nine cured mutants of P. carboxydovorans OM5, as well as the deletion mutant OM5-29, could not grow chemolithotrophically with CO or H₂ plus CO₂, as they were devoid of CO dehydrogenase, hydrogenase and ribulose bisphosphate carboxylase. The deletion mutant OM5-24 retained the ability to grow with CO. It could not grow with H₂ plus CO₂ and was devoid of H₂ase. The data suggest the residence of structural and/or regulatory genes of CODH, H₂ase and RuBPCx on plasmid pHCG3 of P. carboxydovorans.Abbreviations CODH carbon monoxide dehydrogenase - CRM cross reacting material - EMS ethyl methane sulfonate - H₂ase hydrogenase - kb kilobase - NTG N-methyl-N-nitro-N-nitrosoguanidine - RuBPCx ribulose bisphosphate carboxylase - SDS sodium dodecylsulfate     

Formate-Dependent H2 Production by the Mesophilic Methanogen Methanococcus maripaludis

Methanococcus maripaludis, an H₂- and formate-utilizing methanogen, produced H₂ at high rates from formate. The rates and kinetics of H₂ production depended upon the growth conditions, and H₂ availability during growth was a major factor. Specific activities of resting cells grown with formate or H₂ were 0.4 to 1.4 U·mg⁻¹ (dry weight). H₂ production in formate-grown cells followed Michaelis-Menten kinetics, and the concentration of formate required for half-maximal activity (K_f) was 3.6 mM. In contrast, in H₂-grown cells this process followed sigmoidal kinetics, and the K_f was 9 mM. A key enzyme for formate-dependent H₂ production was formate dehydrogenase, Fdh. H₂ production and growth were severely reduced in a mutant containing a deletion of the gene encoding the Fdh1 isozyme, indicating that it was the primary Fdh. In contrast, a mutant containing a deletion of the gene encoding the Fdh2 isozyme possessed near-wild-type activities, indicating that this isozyme did not play a major role. H₂ production by a mutant containing a deletion of the coenzyme F₄₂₀-reducing hydrogenase Fru was also severely reduced, suggesting that the major pathway of H₂ production comprised Fdh1 and Fru. Because a Δfru-Δfrc mutant retained 10% of the wild-type activity, an additional pathway is present. Mutants possessing deletions of the gene encoding the F₄₂₀-dependent methylene-H₄MTP dehydrogenase (Mtd) or the H₂-forming methylene-H₄MTP dehydrogenase (Hmd) also possessed reduced activity, which suggested that this second pathway was comprised of Fdh1-Mtd-Hmd. In contrast to H₂ production, the cellular rates of methanogenesis were unaffected in these mutants, which suggested that the observed H₂ production was not a direct intermediate of methanogenesis. In conclusion, high rates of formate-dependent H₂ production demonstrated the potential of M. maripaludis for the microbial production of H₂ from formate.     

Selective methanol or formate production during continuous CO2 fermentation by the acetogen biocatalysts engineered via integration of synthetic pathways using Tn7-tool

Methanol-resistant mutant acetogen Clostridium sp. MT1424 originally producing only 365 mM acetate from CO₂/CO was engineered to eliminate acetate production and spore formation using Cre-lox66/lox71-system to power subsequent methanol production via expressing synthetic methanol dehydrogenase, formaldehyde dehydrogenase and formate dehydrogenase, three copies of each, assembled in cluster and integrated to chromosome using Tn7-based approach. Production of 2.2 M methanol was steady (p < 0.005) in single step fermentations of 20 % CO₂ + 80 % H₂ blend (v/v) 25 day runs each in five independent repeats. If the integrated cluster comprised only three copies of formate dehydrogenase the respective recombinants produced 95 mM formate (p < 0.005) under the same conditions. For commercialization, the suggested source of inorganic carbon would be CO₂ waste of IGCC power plant. Hydrogen may be produced in situ via powered by solar panels electrolysis.     

H2 production from CO, formate or starch using the hyperthermophilic archaeon, Thermococcus onnurineus

The hyperthermophilic archaeon, Thermococcus onnurineus, was grown in media supplemented with either CO, formate, or starch. H₂ was produced with each substrate with respective maximum rates of 1.55, 3.83 and 2.66 mmol H₂/l h. The yields (mol H₂/mol substrate) were 0.98, 1 and 3.13, respectively. This microbe is the first example where a single microorganism can grow and produce H₂ using CO, formate or starch as substrate.     

Influence of Metronidazole, CO, CO2, and Methanogens on the Fermentative Metabolism of the Anaerobic Fungus Neocallimastix sp. Strain L2

The effects of metronidazole, CO, methanogens, and CO₂ on the fermentation of glucose by the anaerobic fungus Neocallimastix sp. strain L2 were investigated. Both metronidazole and CO caused a shift in the fermentation products from predominantly H₂, acetate, and formate to lactate as the major product and caused a lower glucose consumption rate and cell protein yield. An increased lactate dehydrogenase activity and a decreased hydrogenase activity were observed in cells grown under both culture conditions. In metronidazole-grown cells, the amount of hydrogenase protein was decreased compared with the amount in cells grown in the absence of metronidazole. When Neocallimastix sp. strain L2 was cocultured with the methanogenic bacterium Methanobrevibacter smithii, the fermentation pattern changed in the opposite direction: H₂ and acetate production increased at the expense of the electron sink products lactate, succinate, and ethanol. A concomitant decrease in the enzyme activities leading to these electron sink products was observed, as well as an increase in the glucose consumption rate and cell protein yield, compared with those of pure cultures of the fungus. Low levels of CO₂ in the gas phase resulted in increased H₂ and lactate formation and decreased production of formate, acetate, succinate, and ethanol, a decreased glucose consumption rate and cell protein yield, and a decrease in most of the hydrogenosomal enzyme activities. None of the tested culture conditions resulted in changed quantities of hydrogenosomal proteins. The results indicate that manipulation of the pattern of fermentation in Neocallimastix sp. strain L2 results in changes in enzyme activities but not in the proliferation or disappearance of hydrogenosomes.