Synthesis of glycerides and esters by fungal cell-bound enzymes in continuous reactor systems

Summary The synthesis of glycerides and fatty esters using the cell-bound lipolytic enzymes of fungal mycelia is described. Use of organic solvents for substrate solution and a solid-phase enzyme system enable high conversions to be obtained continuously in packed bed and stirred tank reactors.     

东北红豆杉细胞两液相培养中紫杉醇释放行为研究

在东北红豆杉细胞悬浮培养中,分别研究了稀土化合物(硫酸铈铵)、有机溶剂(油酸和邻苯二甲酸二丁脂)和稀土化合物与有机溶剂的协同作用对紫杉醇释放的影响。在此基础上深入研究了在东北红豆杉细胞两液相培养中,紫杉醇释放率随不同的有机溶剂(烷烃、有机酸、醇和脂)、有机溶剂的体积分数、有机溶剂的加入时间和有机溶剂相毒性的变化规律。结果表明分别加入稀土化合物和有机溶剂都明显促进紫杉醇的释放,特别是有机溶剂更显著促进紫杉醇的释放。但在东北红豆杉细胞两液相培养中,稀土化合物加入不能进一步促进紫杉醇的释放。因此两液相培养中有机溶剂本身就是很好的产物释放剂。紫杉醇的释放率由对照组的40%提高到75%以上。     

Extremely stable and versatile carboxylesterase from a hyperthermophilic archaeon

We have found that the hyperthermophilic archaeon Pyrobaculum calidifontis VA1 produced a thermostable esterase. We isolated and sequenced the esterase gene (est(Pc)) from strain VA1. est(Pc) consisted of 939 bp, corresponding to 313 amino acid residues with a molecular mass of 34,354 Da. As est(Pc) showed significant identity (30%) to mammalian hormone-sensitive lipases (HSLs), esterase of P. calidifontis (Est) could be regarded as a new member of the HSL family. Activity levels of the enzyme were comparable or higher than those of previously reported enzymes not only at high temperature (6,410 U/mg at 90 degrees C), but also at ambient temperature (1,050 U/mg at 30 degrees C). The enzyme displayed extremely high thermostability and was also stable after incubation with various water-miscible organic solvents at a concentration of 80%. The enzyme also exhibited activity in the presence of organic solvents. Est of P. calidifontis showed higher hydrolytic activity towards esters with short to medium chains, with p-nitrophenyl caproate (C(6)) the best substrate among the p-nitrophenyl esters examined. As for the alcoholic moiety, the enzyme displayed esterase activity towards esters with both straight- and branched-chain alcohols. Most surprisingly, we found that this Est enzyme hydrolyzed the tertiary alcohol ester tert-butyl acetate, a feature very rare among previously reported lipolytic enzymes. The extreme stability against heat and organic solvents, along with its activity towards a tertiary alcohol ester, indicates a high potential for the Est of P. calidifontis in future applications.     

A thermoactive uropygial esterase from chicken: purification, characterisation and synthesis of flavour esters

A lipolytic activity was located in the chicken uropygial glands, from which a carboxylesterase (CUE) was purified. Pure CUE has an apparent molecular mass of 50 kDa. The purified esterase displayed its maximal activity (200 U/mg) on short-chain triacylglycerols (tributyrin) at a temperature of 50°C. No significant lipolytic activity was found when medium chain (trioctanoin) or long chain (olive oil) triacylglycerols were used as substrates. The enzyme retained 75% of its maximal activity when incubated during 2h at 50°C. The NH(2)-terminal amino acid sequence showed similarities with the esterase purified recently from turkey pharyngeal tissue. Esterase activity remains stable after its incubation during 30 min in presence of organic solvents such as hexane or butanol. CUE is a serine enzyme since it was inactivated by phenylmethanesulphonyl fluoride (PMSF), a serine-specific inhibitor. The purified enzyme, which tolerates the presence of some organic solvent and a high temperature, can be used in non-aqueous synthesis reactions. Hence, the uropygial esterase immobilised onto CaCO(3) was tested to produce the isoamyl and the butyl acetate (flavour esters). Reactions were performed at 50°C in presence of hexane. High synthesis yields of 91 and 67.8% were obtained for isoamyl and butyl acetate, respectively.     

Catalytic properties of mycelium-bound lipases from <Emphasis Type="Italic">Aspergillus niger</Emphasis> MYA 135

A constitutive level of a mycelium-bound lipolytic activity from Aspergillus niger MYA 135 was strongly increased by 97% in medium supplemented with 2% olive oil. The constitutive lipase showed an optimal activity in the pH range of 3.0–6.5, while the mycelium-bound lipase activity produced in the presence of olive oil had two pH optima at pH 4 and 7. Interestingly, both lipolytic sources were cold-active showing high catalytic activities in the temperature range of 4–8°C. These mycelium-bound lipase activities were also very stable in reaction mixtures containing methanol and ethanol. In fact, the constitutive lipase maintained almost 100% of its activity after exposure by 1 h at 37°C in ethanol. A simple methodology to evaluate suitable transesterification activities in organic solvents was also reported.     

Lipase activity in Thermus thermophilus HB8: Purification and characterization of the extracellular enzyme

In this study, the lipolytic activity of Thermus thermophilus HB8 was examined. The addition of various oils increased the production of extracellular lipolytic activity, while a combination of olive oil and glucose increased both extracellular and intracellular lipolytic activity. The oxygen transfer rate had a significant influence on both biomass and production of extra- or intra-cellular lipolytic activity. The formation of white halos due to the hydrolysis of oleic acid ester (Tween 80) in agar plates containing Nile Blue and the formation of Ca²⁺-oleate indicated the secretion of lipase. When the cell-free supernatant of cells grown in basal reach medium or the corresponding intracellular extract were electrophoresed under denatured and renatured conditions, using ??-naphthyl acetate and Fast Blue RR, major bands at 56 kDa or 62 and 32 kDa were observed, respectively. The 56 kDa extracellular enzyme was partial purified and characterized. Its peak of activity occurred at 80°C and pH 7.0, while the T_1/2 was 1 h at 100°C. The K _m of the partial purified enzyme was 1 mM and the V _max was 0.044 U/mL/min when using p-nitrophenyl laurate as substrate. The presence of Ca²⁺ and Hg²⁺ stimulated lipase activity, whereas Zn²⁺, Co²⁺, or EDTA inhibited lipase activity. The highest activity was observed in the presence of coconut oil and p-nitrophenyl laurate (pNPL). Purified lipase was the most stable in the presence of various organic solvents, such as pentanol, chloroform and n-dodecane. Because of the superior thermostability and stability in the presence of organic solvents of T. thermophilus extracellular lipase, this lipase holds great promise for use in industrial applications.     

Purification, characterization, and molecular cloning of organic-solvent-tolerant cholesterol esterase from cyclohexane-tolerant Burkholderia cepacia strain ST-200

Extracellular cholesterol esterase of Burkholderia cepacia strain ST-200 was purified from the culture supernatant. Its molecular mass was 37 kDa. The enzyme was stable at pH 5.5–12 and active at pH 5.5–6, showing optimal activity at pH 7.0 at 45°C. Relative to the commercially available cholesterol esterases, the purified enzyme was highly stable in the presence of various water-miscible organic solvents. The enzyme preferentially hydrolyzed long-chain fatty acid esters of cholesterol, except for that of cholesteryl palmitate. The enzyme exhibited lipolytic activity toward various p-nitrophenyl esters. The hydrolysis rate of p-nitrophenyl caprylate was enhanced 3.5- to 7.2-fold in the presence of 5–20% (vol/vol) water-miscible organic solvents relative to that in the absence of organic solvents. The structural gene encoding the cholesterol esterase was cloned and sequenced. The primary translation product was predicted to be 365 amino acid residues. The mature product is composed of 325 amino acid residues. The amino acid sequence of the product showed the highest similarity to the lipase LipA (87%) from B. cepacia DSM3959.     

The Effect of Organic Solvents on the Appearance of Bacterial Nuclei

Treatment of bacterial smears with organic solvents was found to produce a typical appearing nuclei which could lead to false interpretation of nuclear events. The crystal violet nuclear stain, which does not utilize organic solvents or acid hydrolysis, was used as a basis of comparison. Acid hydrolysis also was observed to affect the appearance of the nucleus. It is concluded that caution should be used in interpreting nuclear structure and activity in bacterial cells, especially when organic solvents or acid hydrolysis are involved in the staining technic.     

Elimination of Salmonellae from Animal Glandular Products

Methods for the elimination of salmonellae from selected powdered pharmaceuticals of animal glandular origin were studied. Terminal heat treatment under carefully controlled conditions was effective for pancreatin-a powder containing proteolytic, amylolytic, and lipolytic enzymes prepared from hog pancreas glands. Use of this method resulted in a significant reduction in the number of salmonella-positive batches and also reduced the testing procedures required to confirm the absence of viable salmonellae among the majority of samples tested. Powders such as stomach substance and thyroid, in which the biological activity is not enzyme in nature, were treated successfully with acidified organic solvents. Other methods were investigated but were not suitable because of a deleterious effect on the biological activity or physical properties of the product or an inability to effect salmonella elimination.     

EXTRACELLULAR LIPOLYTIC ENZYME ACTIVITY OF A NEWLY ISOLATED DEBARYOMYCES HANSENII

A strain isolated from waste of a milk products plant and exhibited extracellular lipolytic activity was identified as Debaryomyces hansenii by 5.8S rRNA and 28S rRNA gene sequence analyses. Lipolytic activity was assayed spectrophotometrically by using p-nitrophenylpalmitate. Higher specific lipolytic activities were obtained in the presence of tristearin (0.68 U/mg prot), oleic acid (0.56 U/mg prot), and soybean oil (0.36 U/mg prot) than other triglycerides, fatty acids, and vegetable oils considered as carbon sources. Cheese whey appeared to be a good alternative to lipidic substances for lipolytic activity. Among various organic and inorganic nitrogen sources, soy flour was found to attain the lipolytic activity similar to that provided by universal yeast medium components. This work is the first report on the discussion of lipolytic activity enhancement by D. hansenii through modulating the cultivation medium. It also proposes low cost medium nutrients that could be of industrial value and could serve as basal nutrients for further optimization studies on the lipase production by D. hansenii.     

Stabilization of Candida antarctica lipase B in hydrophilic organic solvent by rational design of hydrogen bond

Enzymatic reactions conducted in organic solvents have many advantages. However, organic solvent molecules may replace water molecules at the protein surface and penetrate into the enzyme, which could lead to the denaturation of the enzyme or changes in its reaction kinetics and substrate specificity. Thus, it is important to enhance the stability of enzymes in organic solvents. To date, there has been no efficient rational approach developed to enhance enzyme stability in hydrophilic solvents. We developed a rational approach to enzyme design. The design rules were established by investigating stable mutants from previous studies of directed evolution. Candida antarctica lipase B (CalB) was used as a target enzyme due to its versatile applications in organic solvents. The N97Q, N264Q, and D265E mutants of CalB showed higher organic solvent stability than the wild type.     

<Emphasis Type="Italic">Acinetobacter</Emphasis> lipases: molecular biology,biochemical properties and biotechnological potential

Lipases (EC 3.1.1.3) have received increased attention recently, evidenced by the increasing amount of information about lipases in the current literature. The renewed interest in this enzyme class is due primarily to investigations of their role in pathogenesis and their increasing use in biotechnological applications [38]. Also, many microbial lipases are available as commercial products, the majority of which are used in detergents, cosmetic production, food flavoring, and organic synthesis. Lipases are valued biocatalysts because they act under mild conditions, are highly stable in organic solvents, show broad substrate specificity, and usually show high regio- and/or stereo-selectivity in catalysis. A number of lipolytic strains of Acinetobacter have been isolated from a variety of sources and their lipases possess many biochemical properties similar to those that have been developed for biotechnological applications. This review discusses the biology of lipase expression in Acinetobacter, with emphasis on those aspects relevant to potential biotechnology applications.     

Stability and activity of cross-linking enzyme crystals of cyclodextrin glucanotransferase isolated from Bacillus macerans

Recently, a new technique using cross-linking enzyme crystals (CLECs) was introduced in the field of enzyme technology. CLECs are solid crystalline particles which are insoluble in both water and organic solvents. Chemical cross-linking of the enzyme crystals preserves the catalytic activity even in harsh conditions such as at high temperature, at extreme pH, in organic solvents, and in the presence of proteases and radical chemicals. CLECs of cyclodextrin glucanotransferase (CGTase) could be useful biocatalysts because they were stable at elevated temperature, in organic solvents, and in the presence of enzyme inactivation surfactant. They also maintained their activity against protein-digesting enzyme.     

Functional expression,extracellular production,purification, structure modeling and biochemical characterization of Carica papaya lipase 1

Carica papaya latex has been reported to contain lipolytic activity since 1925, nevertheless the efforts to isolate lipolytic enzymes directly from the latex matrix have been unsuccessful. Nowadays papaya genome is known and heterologous expression is an alternative to overcome this problem. Therefore, in this study, Carica papaya lipase 1 sequence (CpLip1) has been identified in papaya genome and for the first time, functionally expressed using Pichia pastoris as host system. Purification of the recombinant enzyme was carried out by affinity chromatography and reached a 7-fold purification factor with 25 U/mg in the purified fraction. Interestingly, homology modeling with lipases of known structure revealed homology with microbial lipases. The biochemical characterization of the purified enzyme shows that CpLip1 hydrolyzed preferentially long-chain triglycerides, it has an optimal pH of 8.5 and an optimal temperature of 35 °C. Finally, the study of its stability in organic solvents showed that, as many lipases, CpLip1 activity is affected in polar solvents. This contribution opens the possibility of studying the catalytic performance of pure CpLip1 in several reactions, and a better understanding of the role of lipases in Carica papaya.     

A novel halophilic lipase, LipBL, showing high efficiency in the production of eicosapentaenoic acid (EPA)

Background

Among extremophiles, halophiles are defined as microorganisms adapted to live and thrive in diverse extreme saline environments. These extremophilic microorganisms constitute the source of a number of hydrolases with great biotechnological applications. The interest to use extremozymes from halophiles in industrial applications is their resistance to organic solvents and extreme temperatures. Marinobacter lipolyticus SM19 is a moderately halophilic bacterium, isolated previously from a saline habitat in South Spain, showing lipolytic activity.

Methods and Findings

A lipolytic enzyme from the halophilic bacterium Marinobacter lipolyticus SM19 was isolated. This enzyme, designated LipBL, was expressed in Escherichia coli. LipBL is a protein of 404 amino acids with a molecular mass of 45.3 kDa and high identity to class C β-lactamases. LipBL was purified and biochemically characterized. The temperature for its maximal activity was 80°C and the pH optimum determined at 25°C was 7.0, showing optimal activity without sodium chloride, while maintaining 20% activity in a wide range of NaCl concentrations. This enzyme exhibited high activity against short-medium length acyl chain substrates, although it also hydrolyzes olive oil and fish oil. The fish oil hydrolysis using LipBL results in an enrichment of free eicosapentaenoic acid (EPA), but not docosahexaenoic acid (DHA), relative to its levels present in fish oil. For improving the stability and to be used in industrial processes LipBL was immobilized in different supports. The immobilized derivatives CNBr-activated Sepharose were highly selective towards the release of EPA versus DHA. The enzyme is also active towards different chiral and prochiral esters. Exposure of LipBL to buffer-solvent mixtures showed that the enzyme had remarkable activity and stability in all organic solvents tested.

Conclusions

In this study we isolated, purified, biochemically characterized and immobilized a lipolytic enzyme from a halophilic bacterium M. lipolyticus, which constitutes an enzyme with excellent properties to be used in the food industry, in the enrichment in omega-3 PUFAs.     

Production of a thermostable extracellular lipase by Kluyveromyces marxianus

Kluyveromyces marxianus was grown in submerged culture in a complex medium with several potential inducers of lipolytic activity (triacylglycerols, fatty acids). The highest extracellular lipolytic enzyme production (about 80 U ml^–1 in 3 d) was obtained when the medium was supplemented with 2 g urea l^–1 plus 5 g tributyrin l^–1. Addition of surfactants (1 g l^–1) did not improve production. The lipase had a high thermal stability in aqueous solution (73% residual activity after 9 d at 50 °C, 16 min half-life time at 100 °C). It was also stable at acidic pH and showed good tolerance to organic solvents (70% residual activity after 2 d in n-hexane of cyclohexane).     

Stability and structure of Penicillium chrysogenum lipase in the presence of organic solvents

Abstract

The present work describes the enzymatic properties of Penicillium chrysogenum lipase and its behavior in the presence of organic solvents. The temperature and pH optima of the purified lipase was found to be 55?°C and pH 8.0 respectively. The lipase displayed remarkable stability in both polar and non-polar solvents upto 50% (v/v) concentrations for 72?h. A structural perspective of the purified lipase in different organic solvents was gained by using circular dichroism and intrinsic fluorescence spectroscopy. The native lipase consisted of a predominant α-helix structure which was maintained in both polar and non-polar solvents with the exception of ethyl butyrate where the activity was decreased and the structure was disrupted. The quenching of fluorescence intensity in the presence of organic solvents indicated the transformation of the lipase microenviroment P. chrysogenum lipase offers an interesting system for understanding the solvent stability mechanisms which could be used for rationale designing of engineered lipase biocatalysts for application in organic synthesis in non-aqueous media.     

Kinetics of two-liquid-phase Taxus cuspidata cell culture for production of Taxol

The effects of different organic solvents (paraffin, organic acid, alcohol and ester) and their volumetric fractions on the cell growth and Taxol production were studied in two-liquid-phase and the two-stage culture. A kinetic model, incorporated the effects of the toxicity of organic solvents was developed for two-liquid-phase culture of Taxus cuspidata in the two-stage Taxol production. The results showed that the proposed kinetic model could fit the experimental data satisfactorily. The results also showed that Taxol production could reach the optimal value when 10-logP was in the range of 2 to 5 and the volumetric fraction of the organic solvents at the corresponding the highest Taxol production should be lower when 10-logP was high.     

Novel organic solvent-responsive expression vectors for biocatalysis: application for development of an organic solvent-tolerant biodesulfurizing strain

Biodesulfurization is an attractive alternative to hydrodesulfurization for lowering the sulfur content of petroleum products. However, the fuel oils are toxic to microorganisms, which have seriously hindered the application of biodesulfurization. Here, a solvent-tolerant desulfurizing bacterium, Pseudomonas putida DS23, was developed using one of the organic solvent-responsive expression vectors newly constructed for biocatalysis, in which gene expression could be regulated in an organic solvent-dependent fashion. The biodesulfurizing activity of P. putida DS23 could be induced by all the organic solvents used. P. putida DS23 cells induced by n-hexane were able to degrade 56% of 0.5 mM DBT in 12 h in the biphasic reaction containing 33.3% (v/v) n-hexane, while the strain induced by isopropyl β-D-1-thiogalactopyranoside could only degrade 26% of 0.5 mM DBT. These results suggested that use of the constructed organic solvent-responsive expression vectors can facilitate the biphasic biocatalysis involving organic solvents.     

Industrial potential of organic solvent tolerant bacteria

Most bacteria and their enzymes are destroyed or inactivated in the presence of organic solvents. Organic solvent tolerant bacteria are a relatively novel group of extremophilic microorganisms that combat these destructive effects and thrive in the presence of high concentrations of organic solvents as a result of various adaptations. These bacteria are being explored for their potential in industrial and environmental biotechnology, since their enzymes retain activity in the presence of toxic solvents. This property could be exploited to carry out bioremediation and biocatalysis in the presence of an organic phase. Because a large number of substrates used in industrial chemistry, such as steroids, are water-insoluble, their bioconversion rates are affected by poor dissolution in water. This problem can be overcome by carrying out the process in a biphasic organic-aqueous fermentation system, wherein the substrate is dissolved in the organic phase and provided to cells present in the aqueous phase. In bioprocessing of fine chemicals such as cis-diols and epoxides using such cultures, organic solvents can be used to extract a toxic product from the aqueous phase, thereby improving the efficiency of the process. Bacterial strains reported to grow on and utilize saturated concentrations of organic solvents such as toluene can revolutionize the removal of such pollutants. It is now known that enzymes display striking new properties in the presence of organic solvents. The role of solvent-stable enzymes in nonaqueous biocatalysis needs to be explored and could result in novel applications.