Effects of inclusion with blue lupins (Lupinus angustifolius) in broiler diets and enzyme supplementation on production performance, digestibility and dietary AME content

An experiment with broiler chickens was conducted to study the effect of inclusion of blue lupins and exogenous enzyme to broiler diets on the apparent metabolisable energy (AME), digestibility and performance. Two basal diets were formulated: a non-lupin diet A based on soya bean meal and maize, and a diet B where parts of soya bean meal and maize were substituted with blue lupin (200 g/kg). The two basal diets were fed either alone or, for diet B in combination with different enzyme preparations (Bio-Feed Plus, lactase, two galactanases (Gal-I and Gal-II)). The experiment was performed in battery cages with 648 male broiler chickens, where eight experimental diets were fed to the chickens from 7 to 21 days of age and weight gain and feed intake were measured during the period. At the end of the experiment, three chickens from each pen were slaughtered and the content from jejunum and ileum was separately collected and pooled and used for measurement on intestinal viscosity. For measurements of the apparent metabolisable energy and the apparent digestibility, excreta were collected at 22–24 days of age and ileal contents collected at 25–26 days from the remaining chickens.

Substitution of soya bean meal and maize with blue lupin depressed weight gain (9%) and feed conversion ratio (12%) significantly. Feed intake of the lupin-based diets was not decreased. The protein in lupin was digested to the same extent as the protein from soya bean meal, the coefficient of ileal apparent digestibility being on average 0.75. However, the high content of the non-starch polysaccharides (NSP; 450 g/kg) in lupin depressed the apparent digestibility of the organic matter by approximately 10%. The AME_n of the non-lupin diet was 14.01 MJ/kg dry matter (DM) compared to a value of 13.11 MJ/kg DM in the lupin control diet. Improvements in the measured parameters were seen with some of the enzymes. Gal-I, and Gal-II in combination with lactase were the most efficient enzymes concerning improvement in AME_n and performance. Weight gain was increased by 3.5–5.5% by addition with these enzymes. Gal-I increased the AME_n significantly to 13.65 MJ/kg, a value not significantly different from the AME_n of the non-lupin diet. There was no effect of addition with the different enzymes on the coefficients of apparent digestibility of organic matter measured in the ileum, whereas addition with Gal-I to the lupin diet increased the apparent digestibility of organic matter over the total tract by 3%. The mode of action of the galactanases has been to hydrolyse the galactan in the NSP cell wall of lupins to galactose and dimers of galactose, which are energy-yielding to poultry. From the results obtained, it can be indicated that Gal-I increased the energy utilisation of the lupin-based diet, confirmed by the improved AME_n content and performance.