Improvement of the yield of physiologically active oligosaccharides in continuous hydrolysis of chitosan using immobilized chitosanases

The continuous production of chitosan oligosaccharides using a packed-bed enzyme reactor was investigated as to the effects of the operation conditions on the yield of pentamers and hexamers of chitosan oligosaccharides. A column reactor packed with immobilized chitosanases prepared by the multipoint attachment method was used for continuous hydrolysis of chitosan. In this reactor, the decrease of the yield of the target intermediate oligosaccharides due to axial mixing was negligible. The surface enzyme density of the support and flow rate of the substrate solution significantly affected the maximum yield of pentamers and hexamers. These effects were summarized as a correlation with the Damk?hler number (Da), defined as the ratio of the maximum reaction rate to the maximum mass transfer rate. The optimum condition was determined based on Da. Under the optimized condition (Da = 0.12), pentamers and hexamers could be produced continuously for a month with a yield of over 35% (7 kg/m(3) in concentration).     

Relationships between the molecular structure and moisture-absorption and moisture-retention abilities of carboxymethyl chitosan. II. Effect of degree of deacetylation and carboxymethylation

Carboxymethyl chitosans (CM-chitosan) of various degrees of deacetylation (DD 28-95%) and substitution (DS 0.15-1.21) were successfully prepared from N-acetylchitosans in NaOH of varying concentrations. Infrared spectroscopy (IR), elemental analysis, potentiometric titration, 13C NMR, X-ray diffraction and gel-permeation chromatographic (GPC) techniques were used to characterize their molecular structures. The moisture-absorption (R(a)) and -retention (R(h)) abilities of CM-chitosan are closely related to the DD and DS values. Under conditions of high relative humidity, the maximum R(a) and R(h) were obtained at DD values of about 50%, and when the DD value deviated from 50%, R(a) and R(h) decreased. Under dry conditions, when the DD value was 50%, the R(h) was the lowest. With the DS value increasing, R(a) and R(h) increased. However, further increase of the DS value above 1.0 reduced the increasing tendency of R(a) and R(h), and even some decreases in R(a) and R(h) were observed. Intermolecular hydrogen bonds play a very important role in moisture-absorption and retention ability of CM-chitosan.     

Fast and efficient synthesis of a novel homologous series of L-fucosylated trisaccharides using the Helix pomatia alpha-(1-->2)-L-galactosyltransferase

The alpha-(1-->2)-L-galactosyltransferase from the albumen gland of the vineyard snail Helix pomatia exhibits high alpha-(1-->2)-L-fucosyltransferase activity and can be used to transfer L-fucose from GDP-L-fucose to terminal, non-reducing D-galactose residues of an oligosaccharide, thus providing facile access to a range of H-antigen-containing oligosaccharides. The enzymatic glycosylation was applied here on a milligram scale to a series of disaccharide acceptor substrates. Apparently the site of interglycosidic linkage between the terminal and subterminal acceptor sugar units is of little or no consequence. The homologous series of trisaccharides thus produced were fully characterised by NMR analysis of their peracetates.     

Effect of Chitosan on Systemic Viral Infection and Some Defense Responses in Potato Plants

The development and the possible mechanism of the chitosan-induced resistance to viral infection were investigated in potato plants. The plants were sprayed with a solution of chitosans (1 mg/ml) with the mol wt of 3, 36, and 120 kD. After 1, 2, 3, or 4 days, the treated leaves were cut off and mechanically infected with the potato virus X (PVX). The disks cut out from the inoculated leaves were used for determining virus accumulation, callose content, and ribonuclease and -1,3-glucanase activities. In another set of experiments, the plants were infected with PVX within 1, 4, or 8 days after chitosan treatment, and the number of systemically infected plants was determined. It was found that, a day after treatment, the plants acquired a resistance to viral infection. The disks from the chitosan-treated leaves, as compared to the control, accumulated less amount of virus. The chitosan treatment also significantly decreased the number of systemically infected plants as compared to the control. After 2–3 days, the resistance disappeared or even gave way to an increased susceptibility to the infection; subsequently, the resistance increased again. The extent of the resistance correlated with the callose content and the level of ribonuclease activity observed on the infection day. The resistance towards the infection with PVX is probably mediated by the callose and ribonuclease induction. The cultivation of test-tube potato plants from the cuttings previously infected with PVX on the chitosan-containing nutrient medium did not eradicate the viral infection from the plants.     

Chemo-enzymatic synthesis of the glycosylated alpha-mating factor of Saccharomyces cerevisiae and analysis of its biological activity

The effect of glycosylation on a bioactive peptide was studied using yeast Saccharomyces cerevisiae alpha-mating factor, which is composed of 13 amino acids. In this study, we prepared glycosylated alpha-mating factor by chemo-enzymatic synthesis. At first, N-acetylglucosaminyl alpha-mating factor (Trp-His-Trp-Leu-Gln(GlcNAc)-Leu-Lys-Pro-Gly-Gln-Pro-Met-Tyr) was chemically synthesized by the solid-phase method. Then, using the transglycosylation activity of Mucor hiemalis endo-beta-N-acetylglucosaminidase, we synthesized glycosylated alpha-mating factor with a glutamine-linked sialo complex type oligosaccharide. The biological activity of alpha-mating factor derivatives was examined by means of a growth arrest assay using secreted-protease-defective a cells of S. cerevisiae. The results showed that the bioactivity of glycosylated alpha-mating factor was lower than that of native alpha-mating factor. However, when sialic acid was removed from the complex type sugar chain of glycosylated alpha-mating factor, its bioactivity was recovered. Glycosylated alpha-mating factor exhibited higher resistance against proteolysis than native alpha-mating factor. It was found that the bioactivity of N-acetylglucosaminyl alpha-mating factor was higher than that of alpha-mating factor. Circular dichroism studies indicated that a slight change in the structure of alpha-mating factor may influence its activity.     

Chitosan isolation from the chitosan-glucan complex of fungal cell wall using amylolytic enzymes

The chitosan/glucan complex isolated from the mycelia of the fungus, Gongronella butleri USDB 0201 can be cleaved with a heat-stable -amylase at 65 °C for 3 h. This results in the removal of the glucan side chain and gives a chitosan solution with 100 times lower turbidity. It is proposed that chitosan and glucan chains are bound by an (1 to 4) glucosidic bond. Both fungal chitosan and fungal glucan have been purified separately.     

Chitosan oligosaccharides, dp 2-8, have prebiotic effect on the Bifidobacterium bifidium and Lactobacillus sp

In order to investigate the prebiotic potential of chitosan oligosaccharide (COS), prepared by enzymatic hydrolysis of fully deacetylated chitosan polymer, the effect of COS on bacterial growth was studied. The degree of polymerization (dp) of COS was determined by MALDI-ToF mass spectrometry, and the COS was found to be composed of dimer (33.6%), trimer (16.9%), tetramer (15.8%), pentamer (12.4%), hexamer (8.3%), heptamer (7.1%), and octamer (5.9%). The minimum inhibitory concentrations (MIC) of chitosan polymer against lactic acid bacteria and bifidobacteria were below 0.31%. However, this only applied to two strains, the other bacteria tested grew on MRS broth containing 5% COS. The effects of COS on the growth of bifidobacteria and lactic acid bacteria were compared with those of fructo-oligosaccharide (FOS). FOS was found to have a growth stimulatory effect on only three strains: Bifidobacterium bifidium, B. infantis and Lactobacillus casei. However, COS stimulated the growth of most Lactobacillus sp. and B. bifidium KCTC 3440. The amount of the growth and the specific growth rate of B. bifidium increased with increasing COS concentration. The cultivation time required to obtain maximum growth was reduced to about 25% in MRS broth supplemented with 0.2-0.4% COS. These results demonstrate that COS has considerable bifidogenic potential. Both cell growth and specific growth rates of L. brevis in MRS broth supplemented with 0.1% COS increased by 25%. The present study shows that COS stimulates the growth of some enteric bacteria, and that COS has potential use as a prebiotic health-food.     

Cloning and expression of sucrose phosphorylase gene from Bifidobacterium longum in E. coli and characterization of the recombinant enzyme

A DNA fragment, which complemented the growth of E. coli both on M9 medium containing raffinose and on LB medium containing ampicillin, IPTG and 5-bromo-4-chloro-3-indoxyl--d-galactoside, was isolated from the genomic library of Bifidobacterium longum SJ32, which had been digested with EcoRI. In the cloned DNA fragment, a gene encoding a sucrose phosphorylase (splP) and a partially cloned putative sucrose regulator gene (splR) were identified using the deletion analysis and sequence analysis. A 56 kDa protein was synthesized in E. coli and partially purified by DEAE-ion exchange chromatography. The partially purified enzyme did not react with melibiose, melezitoze and raffinose but did with sucrose. It had transglucosylation activity in addition to hydrolytic activity.     

In vitro oligosaccharide synthesis using intact yeast cells that display glycosyltransferases at the cell surface through cell wall-anchored protein Pir

A glycosyltransferase was fused to the yeast cell wall protein Pir, which forms the Pir1-4 protein family and is incorporated into the cell wall by an unknown linkage to be displayed at the yeast cell surface. We first expressed the PIR1-HA-gma12+ fusion, in which gma12+ encodes alpha-1,2-galactosyltransferase from the fission yeast Schizosaccharomyces pombe under the Saccharomyces cerevisiae GAPDH promoter. The alpha-1,2-galactosyltransferase activity was detected at the surface of the intact cells that produce Pir1-HA-Gma12 fusion. To further demonstrate sequential oligosaccharide synthesis, two plasmids containing PIR1-HA-KRE2 and PIR2-FLAG-MNN1 fusion genes were constructed in which KRE2 and MNN1 encode alpha-1,2-mannosyltransferase and alpha-1,3-mannosyltransferase from S. cerevisiae, respectively. The intact yeast cells transformed with these two plasmids added mannoses initially with an alpha-1,2 linkage and subsequently with an alpha-1,3 linkage to the alpha-1,2-mannobiose acceptor in the presence of a GDP-mannose donor, demonstrating that Pir1 and Pir2 can be used as anchors to simultaneously immobilize several glycosyltransferases at the yeast cell surface. Based on the high acceptor specificity of glycosyltransferases, we propose a simple in vitro method for oligosaccharide synthesis using the yeast intact cell as a biocatalyst.     

A novel GlcNAcalpha1-HPO3-6Gal(1-1)ceramide antigen and alkylated inositol-phosphoglycerolipids expressed by the liver fluke Fasciola hepatica

The acidic (glyco)lipids of the parasitic liver fluke Fasciola hepatica exhibited two different phosphate-containing species, designated AL-I and AL-II, which were analyzed by MALDI-TOF MS, ESI MS, NMR, methylation analysis, and combined GC-MS in conjunction with HF treatment. AL-I was structurally determined as 1-O-hexadecyl-sn-glycerol-3-phosphoinositol, an ether bond variant of lysophosphatidylinositol. The structure of AL-II was shown to be GlcNAcalpha1-HPO3-6Gal(1-1)ceramide. Ceramide analysis revealed as major components 2-hydroxyoctadecanoic acid [18:0(2-OH)] together with C18- and C20-phytosphingosines. AL-II was apparently highly antigenic and strongly recognized by both animal- and human-F. hepatica infection sera. Furthermore, inhibition ELISAs revealed that the unusual antigenic determinant GlcNAcalpha1-HPO3- phosphate might have a potential in the serodiagnosis of F. hepatica infections.