Microfiltration of yeast suspensions with self-cleaning spiral vortices: possibilities for a new membrane module design

A novel method of producing controlled vortices was used to reduce both concentration polarization and membrane fouling during microfiltration of Saccharomyces cerevisiae broth suspensions. The method involves flow around a curved channel at a sufficient rate so as to produce centrifugal instabilities (called Dean vortices). These vortices depolarize the build-up of suspended particles such as yeast cells at the membrane-solution interface and allow for increased membrane permeation rates. Various operating conditions under which such vortices effectively reduced cake build-up of suspended particles such as yeast cells at the membrane-solution interface and allow for increased membrane permeation rates. Various operating conditions under which such vortices effectively reduced cake build-up during microfiltration of 0 to 0.55 dry wt% yeast broth were investigated. Flux improvements of over 60% for 0.25 dry wt% yeast broth for flow with over that without Dean vortices were observed. This beneficial effect increased with increasing retentate flow rate and increasing transmembrane pressure and decreased with increasing concentration of suspended matter. Similar behavior was observed whether the cells were viable of killed. the improvement in flux in the presence over that in the absence of vortices correlated well with centrifugal force or azimuthal velocity squared. The relative cake resistances increased with reservoir yeast concentration. These values with vortices increased from 62% to 75% of that without vortices with increasing yeast concentration. The ratio of the cake thicknesses in the limiting case (at high feed concentration) was 3.25. These results suggest that self-cleaning spiral vortices could be effective in maintaining good and steady microfiltration performance with cell suspensions other than those tested. (c) 1995 John Wiley & Sons, Inc.     

Protein fractionation using electrostatic interactions in membranel filtration

One of the critical factors limiting the development of membrane systems for protein fractionation has been the poor selectivity that has generally been obtained with these membrane devices. We have demonstrated that it is possible to dramatically improve the selectivity of available membrane systems by exploiting the different electrostatic interactions between the two proteins and the membrane. The separation factor for the albumin-hemoglobin system could be increased to more than 70 simply by reducing the salt concentration and adjusting the pH to around 7 (near the isoelectric point of hemoglobin). This very high selectivity was a direct result of the strong electrostatic exclusion of the charged albumin from the membrane pores under these conditions. This high selectivity makes it possible to very effectively separate these albumin-hemoglobin mixtures using membrane filtration, and this was demonstrated experimentally using both a simple batch filtration process and a continuous diafiltration system. The hemoglobin recovery in the diafiltration experiment was greater than 70% after a 3-diavolume filtration, with the Hb purification factor being around 100 under these conditions. These results clearly demonstrate the potential of membrane systems for the fractionation of proteins even with very similar molecular weights. (c) 1995 John Wiley & Sons, Inc.     

Properties of microfiltration membranes: Mechanisms of flux loss in the recovery of an enzyme

The transmission and rate of filtration of the enzyme yeast alcohol dehydrogenase (YADH) has been studied at capillary pore microfiltration membranes. Photon correlation spectroscopy (PCS) with nanometer resolution showed that the enzyme existed as discreate molecules only for a narrow range of pH and ionic strength. Under such conditions, the transmission of the enzyme was high. However, the rate of filtration still decreased continuously with time. Analyssis of the time dependence of the rate of filtration indicated that this decrease was due to in-pore enzyme deposition at low concentration ("standard blocking model") and suface depositon at high concentration ("cake filtration model"). Use of atomic force microscopy (AFM) gave unequivocal and quantitative confirmation of these inferences. The work shows the great advantage of using advanced physical characterization techniques, both for the identification of the optimum conditions for filtration (PCS) and for the elucidation of mechanisms giving rise to inefficiencies in the filtration process (AFM). (c) 1995 John Wiley & Sons, Inc.     

Identification of a cDNA/Protein Leading to an Increased P i -uptake in Xenopus laevis Oocytes

In a previous report we documented an increased Na⁺-dependent transport of inorganic phosphate (P _i ) in Xenopus laevis oocytes injected with mRNA isolated from rabbit duodenum (Yagci et al., Pfluegers Arch. 422:211–216, 1992; ref 24). In the present study we have used expression cloning in oocytes to search for the cDNA/mRNA involved in this effect. The identified cDNA (provisionally named PiUS; for P _i -uptake stimulator) lead to a 3-4-fold stimulation of Na⁺-dependent P _i -uptake (10ng cRNA injected, 3–5 days of expression). Na⁺-independent uptake of P _i was also affected but transport of sulphate and l-arginine (in the presence or absence of sodium) remained unchanged. The apparent K _m -values for the induced Na⁺-dependent uptake were 0.26 ± 0.04 mm for P _i and 14.8 ± 3.0 mm for Na⁺. The 1796 bp cDNA codes for a protein of 425 amino acids. Hydropathy analysis suggests a lack of transmembrane segments. In vitro translation resulted in a protein of 60 kDa and provided no evidence of glycosylation. In Northern blots a mRNA of ∼2 kb was recognized in various tissues including different intestinal segments, kidney cortex, kidney medulla, liver and heart. Homology searches showed no similarity to proteins involved in membrane transport and its control. In conclusion, we have cloned from a rabbit small intestinal cDNA library a novel cDNA encoding a protein stimulating P _i -uptake into Xenopus laevis oocytes, but which is not a P _i -transporter itself. Received: 31 July 1996/Revised: 16 October 1996     

Crystals of an antibody FV fragment against an integral membrane protein diffracting to 1.28 Å resolution

The F_v fragment of a monoclonal antibody, 7E2 (IgG₁, κ, murine), which is directed against the integral membrane protein cytochrome c oxidase (EC 1.9.3.1) from Paracoccus denitrificans, was cloned and produced in Escherichia coli. Crystals suitable for highresolution X-ray analysis were obtained by microdialysis under low salt conditions. The crystals belong to the orthorhombic space group P2₁2₁2₁ with unit cell dimensions of a = 51.51 Å, b = 56.15 Å, c = 99.86 Å (1 Å = 0.1 nm) and contain one F _v fragment per asymmetric unit. Using synchrotron radiation diffraction data were collected up to 1.28 Å resolution. This high resolution is very unusual for a heterodimeric protein. The crystals should open the way for refining not only the atomic positions, but also for obtaining information about internal dynamics. © 1995 Wiley-Liss, Inc.     

The preservation of Mycoplasma capricolum cell intactness after phospholipase A2 treatment

(1) By treating Mycoplasma capricolum cells with phospholipase A₂ about 80% of membrane phospholipids were rapidly hydrolyzed. The rate and extent of hydrolysis (at 37°C) were the same in intact cells and in isolated unsealed membranes. (2) Due to the low endogenous lysophospholipase activity detected in M. capricolum, phospholipase A₂ treatment resulted in the accumulation of lysophospholipids and free fatty acids. The free fatty acids were efficiently extracted from the cells by 1% bovine serum albumin whereas the lysophospholipids were almost fully retained within the cell membrane. (3) Following phospholipase A₂ treatment in the presence of 1% bovine serum albumin, cell intactness was preserved as indicated by the constant absorbance of the cell suspension and the retention of nucleic acids and NADH dehydrogenase activity within the cells. The treated cells showed, however, a slight decrease in K⁺ content and a decrease in cell viability. Viability was fully preserved after phospholipase A₂ treatment of cells grown with exogenous sphingomyelin. (4) Adapting M. capricolum to a cholesterol-poor medium resulted in a marked decrease in the cholesterol to phospholipid molar ratio (from about 1.1 to 0.3). Phospholipase A₂ treatment of the cholesterol-poor cells resuted in cell lysis. Cell lysis was induced in the cholesterol-rich cells by hydrolysing the lysophospholipids accumulated following phospholipase A₂ treatment. (5) It is suggested that after phospholipase A₂ treatment of M. capricolum cells, a relatively stable cell membrane is maintained and cell intactness is preseved due to the interaction of cholesterol, present in high amount in this membrane, with the lysophospholipids formed.     

Inhibition of phosphate transport in human erythrocytes by water-soluble carbodiimides

Phosphate entry into human erythrocytes is irreversibly inhibited by treatment of the cells with the water-soluble carbodiimides 1-ethy1-3-(3-dimethylaminopropyl)carbodiimide hydrochloride (EDC) and 1-cyclohexyl-3-(2-morpholinoethyl)-carbodiimide metho-p-toluene sulfonate (CMC) in the absence of added nucleophile. EDC is the more potent inhibitor (40% inhibition, 2 mM EDC, 5 min, 37°C, 50% hematocrit, pH 6.9), while more than 20 mM CMC is required to give the same inhibition under identical conditions. EDC inhibition is temperature-dependent, being complete in 5 min at 37°C, and sensitive to extracellular pH. At pH 6.9 only 50% of transport is rapidly inhibited by EDC, but at alkaline pH over 80% of transport is inhibited. Inhibition is not prevented by modification of membrane sulfhydryl groups but is decreased in the presence of 4,4′-dinitrostilbene-2,2′-disulfonic acid (DNDS), a reversible competitive inhibitor of anion transport. EDC treatment leads to crosslinking of erythrocyte membrane proteins, but differences between the time course of this action and inhibition of transport indicate that most transport inhibition is not due to crosslinking of membrane proteins.     

Radiation inactivation of membrane proteins: Molecular weight estimates in situ and after Triton X-100 solubilization

Target size analysis by radiation inactivation is widely used for molecular weight determination of membrane enzymes and receptors in situ without the need for prior solubilization or purification. However, since most molecular weight data available in the literature on membrane proteins involve the use of detergents for solubilization, the target sizes of membrane proteins in situ and after solubilization by detergent treatment have been compared. Using data from the literature and personal results, three different types of behavior of membrane proteins in presence of detergents were found: (i) uncoupling of subunits (electric eel acetylcholinesterase, placental steroid sulfatase, and human nonspecific β-glucosidase); (ii) coupling of protein molecules (mouse liver neuraminidase, and rat liver insulin receptor regulatory component); and (iii) no major change in quaternary structure (rat liver insulin receptor, kidney γ-glutamyltransferase, asialoglycoprotein receptor, insulin degrading enzyme, and human leucocyte neuraminidase). For all these proteins, there is a statistically significant increase in target size of about 24% over the value obtained in situ without detergent. A relatively large body of literature data involving a variety of membrane proteins, membrane types, and irradiation conditions (electron accelerators or ⁶⁰Co sources, and proteins irradiated in lyophilized form or frozen solution) was examined, and it was concluded that target sizes of membrane proteins, irradiated in the presence of Triton X-100, should be diminished by a factor of about 24% to obtain the molecular weight value.     

Effective cryoprotection of thylakoid membranes by ATP

Freezing of isolated spinach thylakoids in the presence of NaCl uncoupled photophosphorylation from electron flow and increased the permeability of the membranes to protons. Addition of ATP prior to freezing diminished membrane inactivation. On a molar basis, ATP was at least 100 times more effective in protecting thylakoids from freezing damage than low-molecularweight carbohydrates such as sucrose and glucose. The cryoprotective effectiveness of ATP was increased by Mg²⁺. In the absence of carbohydrates, preservation of thylakoids during freezing in 100 mM NaCl was saturated at about 1–2 mM ATP, but under these conditions membranes were not fully protected. However, in the presence of small amounts of sugars which did not significantly prevent thylakoid inactivation during freezing, ATP concentrations considerably lower than 0.5 mM caused nearly complete membrane protection. Neither ADP nor AMP could substitute for ATP. These findings indicate that cryoprotection by ATP cannot be explained by a colligative mechanism. It is suggested that ATP acts on the chloroplast coupling factor, either by modifying its conformation or by preventing its release from the membranes. The results are discussed in regard to freezing injury and resistance in vivo.Abbreviations CF₁ chloroplast coupling factor - Hepes 4-(2-hydroxyethyl)-1-piperazineethanesulfonic acid - PMS phenazine methosulfate - Tris 2-amino-2-(hydroxymethyl)-1,3-propandiol     

Lack of invaginations of the plasma membrane during budding and cell division of Saccharomyces cerevisiae and Schizosaccharomyces pombe

Abstract The plasma membrane of Saccharomyces cerevisiae and Schizosaccharomyces pombe in stationary phase had abundant invaginations. A round uninvaginated area emerged before budding when S. cerevisiae cells were given fresh medium. Middle-sized buds had some invaginations, whereas the neck between the bud and mother had very few. S. pombe which has neither the neck nor the predetermined position to divide had no uninvaginated ring area even in long cells during elongation in fresh medium. However, an uninvaginated ring area emerged as the earliest noticeable stage of cytokinesis. The uninvaginated state of the plasma membrane appeared to be correlated with budding and cell division.