Cross-flow ultrafiltration of proteins through asymmetric polysulfonic membranes: I. Retention curves and pore size distributions

Flux and retention of 0.1%w/w aqueous solutions of several proteins [lysozyme, pepsin, bovine serum albumin (BSA), lipase, and gamma-globulin] with molecular weights of 14.6, 36, 67, 801 and 150 kDa are studied when they are tangentially filtered, with transmembrane pressure differences until 1 MPa and circulation velocities in the re-tentate loop from 0.04 to 1.98 m/s (laminar regime), through two asymmetric polysulfone commercial membranes (E-100 with a nominal pore size of 0.01 mum and E-500 with a nominal pore size of 0.04 mum). Results are analyzed with the film theory for the concentration-polarization phenomenon, obtaining the mass transfer coefficient along with the apparent and true retention coefficients for the cell used, as a function of the feed circulation velocity and the molecular weight of the solute. The standard retention curves lead to pore size distributions differing from the nominal ones. These differences can be attributed to the modifications of the membranes when they are in operational conditions, probably due to protein adsorption. (c) 1995 John Wiley & Sons, Inc.     

Protein recovery from cell debris using rotary and tangential crossflow microfiltration

Protein recovery from a bacterial lysate was accomplished using microfiltration membranes in a flat crossflow filter and in a cylindrical rotary filter. Severe membrane fouling yielded relatively low long-term permeate flux values of 10(-4)-10(-3) cm/s (where I cm/s = 3.6 x 10(4) L/m(2) - h). The permeate flux was found to be nearly independent of transmembrane pressure and to increase with increasing shear rate and decreasing solids concentration. The flux increased with shear to approximately the one-third power or greater for the flat filter and the one-half power or greater for the rotary filter; the stronger dependence for the rotary filter is thought to result from Taylor vortices enhancing the back transport of debris carried to the membrane surface by the permeate flow. The average protein transmission or sieving coefficient was measured at approximately 0.6, but considerable scatter in the transmission data was observed. The largest sieving coefficients were obtained for dilute suspensions at high shear rate. The rotary filter provided higher fluxes than did the flat filter for dilute suspensions, but not for concentrated suspensions. (c) 1995 John Wiley & Sons, Inc.     

Operational patterns affecting lactic acid production in ultrafiltration cell recycle bioreactor

Lactic acid production with cell recycling on an ultrafiltration tubular membrane reactor was studied; higher lactic acid concentrations as well as productivities were obtained under long-term fermentations compared with other high cell density systems. Different operational conditions, namely dilution rates and start-up modes, were assessed. Performances were very different at the three different dilution rates tested (D = 0.20 h(-1), D = 0.40 h(-1), or D = 0.58 h(-1)). The different behaviours are discussed and factors responsible for them are presented. The best way to operate for lactic acid production is chosen, the dilution rate of D = 0.40 h(-1) being the one providing the best overall performance. On the other hand, results show that of the two start-up modes tested, continuous start (membrane open) permits higher permeabilities throughout the operational runs than batch start (membrane closed). Operational stability was found to be directly associated with membranes that work at "steady state," the membrane permeability being kept around 15 L/m(2) h. Optimized cell bleed can improve time of operation if such membrane permeability can be maintained for a longer time. A comparison of results with those obtained in other lactic acid production systems is presented; such comparison shows that this tubular ultrafiltration membrane cell recycle reactor presents three important advantages: (1) concomitant lactic acid concentrations and productivities; (2) long periods of operation at reasonable permeabilities; and (3) good mechanical stability permitting the use of steam sterilization. (c) 1995 John Wiley & Sons, Inc.     

l-Fucose residues on cellulose-based dialysis membranes: Quantification of membrane-associatedl-fucose and analysis of specific lectin binding

Contact of mononuclear human leukocytes with cellulose dialysis membranes may result in complement-independent cell activation, i.e. enhanced synthesis of cytokines, prostaglandins and an increase in 2-microglobulin synthesis. Cellular contact activation is specifically inhibited by the monosaccharidel-fucose suggesting that dialysis membrane associatedl-fucose residues are involved in leukocyte activation. In this study we have detected and quantitatedl-fucose on commercially-available cellulose dialysis membranes using two approaches. A sensitive enzymatic fluorescence assay detectedl-fucose after acid hydrolysis of flat sheet membranes. Values ranged from 79.3±3.6 to 90.2±5.0 pmol cm^–2 for Hemophan® or Cuprophan® respectively. Enzymatic cleavage of terminal -l-fucopyranoses with -l-fucosidase yielded 7.7±3.3 pmoll-fucose per cm² for Cuprophan. Enzymatic hydrolysis of the synthetic polymer membranes AN-69 and PC-PE did not yield detectable amounts ofl-fucose. In a second approach, binding of the fucose specific lectins ofLotus tetragonolobus andUlex europaeus (UEAI) demonstrated the presence of biologically accessiblel-fucose on the surface of cellulose membranes. Specific binding was observed with Cuprophan®, and up to 2.6±0.3 pmoll-fucose per cm² was calculated to be present from Langmuir-type adsorption isotherms. The data presented are in line with the hypothesis that surface-associatedl-fucose residues on cellulose dialysis membranes participate in leukocyte contact activation.     

The Lipid Peroxidation Product, 4-Hydroxy-2-trans-Nonenal, Alters the Conformation of Cortical Synaptosomal Membrane Proteins

Abstract: Alzheimer's disease (AD) is widely held to be a disorder associated with oxidative stress due, in part, to the membrane action of amyloid β-peptide (Aβ). Aβ-associated free radicals cause lipid peroxidation, a major product of which is 4-hydroxy-2- trans -nonenal (HNE). We determined whether HNE would alter the conformation of synaptosomal membrane proteins, which might be related to the known neurotoxicity of Aβ and HNE. Electron paramagnetic resonance spectroscopy, using a protein-specific spin label, MAL-6(2,2,6,6-tetramethyl-4-maleimidopiperidin-1-oxyl), was used to probe conformational changes in gerbil cortical synaptosomal membrane proteins, and a lipid-specific stearic acid label, 5-nitroxide stearate, was used to probe for HNE-induced alterations in the fluidity of the bilayer domain of these membranes. Synaptosomal membranes, incubated with low concentrations of HNE, exhibited changes in protein conformation and bilayer order and motion (fluidity). The changes in protein conformation were found to be concentration- and time-dependent. Significant protein conformational changes were observed at physiologically relevant concentrations of 1–10 µ M HNE, reminiscent of similar changes in synaptosomal membrane proteins from senile plaque- and Aβ-rich AD hippocampal and inferior parietal brain regions. HNE-induced modifications in the physical state of gerbil synaptosomal membrane proteins were prevented completely by using excess glutathione ethyl ester, known to protect neurons from HNE-caused neurotoxicity. Membrane fluidity was found to increase at higher concentrations of HNE (50 µ M ). The results obtained are discussed with relevance to the hypothesis of Aβ-induced free radical-mediated lipid peroxidation, leading to subsequent HNE-induced alterations in the structure and function of key membrane proteins with consequent neurotoxicity in AD brain.     

Interaction of Gila monster venom with secretin receptors in rat pancreatic membranes

The stimulatory effect of Gila monster venom on adenylate cyclase activity in rat pancreatic membranes was compared to that of porcine secretin and porcine VIP. The maximal effect exerted by the venom was identical to that of VIP but significantly lower than that of secretin. The effect of Gila monster venom could, however, be attributed to its interaction with secretin receptors rather than with VIP receptors, at variance with its previously described action on guinea pig pancreatic acini. Adenylate cyclase activation by both Gila monster venom and secretin in rat pancreatic membranes was, indeed: (1) dose-dependently inhibited by two secretin fragments secretin-(4-27) and secretin-(7-27), and (2) more severely depressed than VIP stimulation, after pretreating pancreatic membranes with dithiothreitol (DTT).     

Characterization of neurotensin binding to rat gastric smooth muscle receptor sites

The binding of monoiodo 125I-Trp11-neurotensin to purified rat gastric fundus smooth muscle plasma membranes was characterized. Specific binding of ligand in subcellular fractions from rat fundus smooth muscle showed a distribution that paralleled that of several plasma membrane marker enzymes. 125I-Trp11-neurotensin binding to smooth muscle plasma membranes at 25 degrees C was maximal at 30 min, reversible and saturable. Scatchard analysis of equilibrium data indicated the existence of two classes of binding sites with dissociation constants (Kd) of 56 pmol and 1.92 nM, and corresponding binding capacities (Bmax) of 6.6 fmol/mg and 11.4 fmol/mg of membrane protein. Analogues and fragments of neurotensin competed for 125I-Trp11-neurotensin binding with a rank order of potency similar to that previously reported for their contracting effect in rat fundus strips. Na+ decreased in a concentration dependent manner the binding of labelled ligand to the high affinity site. At 100 mM, Na+ induced a 6-fold increase in the IC50 of neurotensin for inhibition of 125I-Trp11-neurotensin binding. At this concentration of Na+, the IC50 for neurotensin was 1 nM, a value close to the Kd of the low affinity site.     

Feedback inhibition of sodium uptake in K+-depolarized toad urinary bladders

Ouabain-blocked toad urinary bladders were maintained in Na⁺-free mucosal solutions, and a depolarizing solution of high K⁺ activity containing only 5 mM Na⁺ on the serosal side. Exposure to mucosal sodium (20 mM activity) evoked a transient amiloride-blockable inward current, which decayed to near zero within one hour. The apical sodium conductance increased in the initial phase of the current decay and decreased in the second phase. The conductance decrease required Ca²⁺ to be present on the serosal side and was more rapid when the mucosal Na⁺ activity was higher. At 20 mM mucosal Na⁺ and 3 mM serosal Ca²⁺ the initial (maximal) rate of inhibition amounted to 20% in 10 min. The conductance decrease could be accelerated by raising the serosal Ca²⁺ activity to 10 mM. The inhibition reversed on lowering the serosal Ca²⁺ to 3 μM and, in addition, the mucosal Na⁺ to zero. Exposure of the mucosal surface to the ionophore nystatin abolished the Ca²⁺ sensitivity of the transcellular conductance, showing that the Ca²⁺-sensitive conductance resides in the apical membrane. The data imply that in the K⁺-depolarized epithelia, cellular Ca²⁺, taken up from the serosal medium by means of a Na⁺-Ca²⁺ antiport, cause feedback inhibition by blockage of apical Na⁺ channels. However, the rate of inhibition is small, such that this regulatory mechanism will have little effect at 1 mM serosal Ca²⁺ and less than 20 mM cellular Na⁺.     

Transport of mercury compounds across bimolecular lipid membranes: effect of lipid composition, pH and chloride concentration

The use of bimolecular lipid membranes (BLM) as model membrane allows the analysis of the transport of mercury compounds across the lipidic barriers of biological membranes. The results of flux measurements show that two mercury compounds--HgCl2 and CH3HgCl--cross the BLM but the overall permeabilities are dependent on the pH of the aqueous media, and are not apparently influenced by the different phospholipid constituents of the bilayers. On the other hand, electrical measurements show that, function of the chemical speciation, the transport of this metal is done essentially in the neutral form.     

The fluidity of plasma membranes from ethanol-treated rat liver

Summary Male Wistar rats were maintained for 35–40 days on a liquid diet containing 36% of calories as ethanol. Ethanol was replaced by carbohydrates in the isocaloric diet fed to control animals. The effect of ethanol consumption has been studied on the fluorescence polarization of rat liver plasma membranes and artificial lipid vesicles and on the lipid composition of the membranes. Fluorescence polarization in both membranes and vesicles was determined using DPH and TMA-DPH as fluorescence markers; from these data, the polarization term (r_o/r–1)^–1 and flow activation energy (E) were calculated. The ethanol consumption induces a more fluid environment within the membrane core of liver plasma membranes; the ethanol-fed rat membranes are more resistant to the in vitro effect of ethanol disordering the membrane structure. Vesicles obtained with lipids from either control membranes or ethanol-fed rat membranes were treated with ethanol and the changes in polarization paralleled to those exhibited by the membranes. The absence of phase transitions and of E changes was also shown in temperature-dependence studies. The lower cholesterol content found in ethanol-fed rat plasma membranes might be responsible for observed variations in the microviscosity.Abbreviation OG octyl -D-glucopyranoside