Rapid decolorization of azo dyes by crude manganese peroxidase from Schizophyllum sp. F17 in solid-state fermentation

The production of ligninolytic enzymes by the fungus Schizophyllum sp. F17 using a cost-effective medium comprised of agro-industrial residues in solid-state fermentation (SSF) was optimized. The maximum activities of the enzymes manganese peroxidase (MnP), laccase (Lac), and lignin peroxidases (LiP) were 1,200, 586, and 109 U/L, respectively, on day 5 of SSF. In vitro decolorization of three structurally different azo dyes by the extracellular enzymes was monitored to determine its decolorization capability. The results indicated that crude MnP, but not LiP and Lac, played a crucial role in the decolorization of azo dyes. After optimization of the dye decolorization system with crude MnP, the decolorization rates of Orange IV and Orange G, at an initial dye concentration of 50 mg/L, were enhanced to 76 and 57%, respectively, after 20 min of reaction at pH 4 and 35°C. However, only 8% decolorization of Congo red was observed. This enzymatic reaction system revealed a rapid decolorization of azo dyes with a low MnP activity of 24 U/L. Thus, this study could be the basis for the production and application of MnP on a larger scale using a low-cost substrate.     

Production of lignocellulose-degrading enzymes employing <Emphasis Type="Italic">Fusarium solani</Emphasis> F-552

In this work, capability of Fusarium solani F-552 of producing lignocellulose-degrading enzymes in submerged fermentation was investigated. The enzyme cocktail includes hydrolases (cellulases, xylanases, and proteinases) as well as ligninolytic enzymes: manganese-dependent peroxidase (MnP), lignin peroxidase (LiP), and laccase (Lac). To our knowledge, this is the first report on production of MnP, LiP, and Lac together by one F. solani strain. The enzyme productions were significantly influenced by application of either lignocellulosic material or chemical inducers into the fermentation medium. Among them, corn bran significantly enhanced especially productions of cellulases and xylanases (248 and 170 U/mL, respectively) as compared to control culture (11.7 and 29.2 U/mL, respectively). High MnP activity (9.43 U/mL, control 0.45 U/mL) was observed when (+)-catechin was applied into the medium, the yield of LiP was maximal (33.06 U/mL, control 2.69 U/mL) in gallic acid, and Lac was efficiently induced by, 2,2′-azino-bis-[3-ethyltiazoline-6-sulfonate] (6.74 U/mL, not detected in control). Finally, in order to maximize the ligninolytic enzymes yields, a novel strategy of introduction of mild oxidative stress conditions caused by hydrogen peroxide into the fermentation broth was tested. Hydrogen peroxide significantly increased activities of MnP, LiP, and Lac which may indicate that these enzymes could be partially involved in stress response against H₂O₂. The concentration of H₂O₂ and the time of the stress application were optimized; hence, when 10 mmol/L H₂O₂ was applied at the second and sixth day of cultivation, the MnP, LiP, and Lac yields reached 21.67, 77.42, and 12.04 U/mL, respectively.     

Potential of ligninolytic enzymatic complex produced by white‐rot fungi from genus Trametes isolated from Bulgarian forest soil

Because of the crucial role of ligninolytic enzymes in a variety of industrial processes, the demand for a new effective producer has been constantly increasing. Furthermore, information on enzyme synthesis by autochthonous fungal strains is very seldom found. Two fungal strains producing ligninolytic enzymes were isolated from Bulgarian forest soil. They were identified as being Trametes trogii and T. hirsuta. These two strains were assessed for their enzyme activities, laccase (Lac), lignin peroxidase (LiP) and Mn‐dependent peroxidase (MnP) in culture filtrate depending on the temperature and the type of nutrient medium. T. trogii was selected as the better producer of ligninolytic enzymes. The production process was further improved by optimizing a number of parameters such as incubation time, type of cultivation, volume ratio of medium/air, inoculum size and the addition of inducers. The maximum activities of enzymes synthesized by T. trogii was detected as 11100 U/L for Lac, 2.5 U/L for LiP and 4.5 U/L for MnP after 14 days of incubation at 25°C under static conditions, volume ratio of medium/air 1:6, and 3 plugs as inoculum. Among the supplements tested, 5% glycerol increased Lac activity to a significant extent. The addition of 1% veratryl alcohol had a positive effect on MnP.     

EXTRACELLULAR LIGNINOLYTIC ENZYMES PRODUCTION BY Pleurotus eryngii ON AGROINDUSTRIAL WASTES

Pleurotus eryngii (DC.) Gillet (MCC58) was investigated for its ligninolytic ability to produce laccase (Lac), manganese peroxidase (MnP), aryl alcohol oxidase (AAO), and lignin peroxidase (LiP) enzymes through solid-state fermentation using apricot and pomegranate agroindustrial wastes. The reducing sugar, protein, lignin, and cellulose levels in these were studied. Also, the production of these ligninolytic enzymes was researched over the growth of the microorganism throughout 20 days, and the reducing sugar, protein, and nitrogen levels were recorded during the stationary cultivation at 28 ± 0.5°C. The highest Lac activity was obtained as 1618.5 ± 25 U/L on day 12 of cultivation using apricot. The highest MnP activity was attained as 570.82 ± 15 U/L on day 17 in pomegranate culture and about the same as apricot culture. There were low LiP activities in both cultures. The maximum LiP value detected was 16.13 ± 0.8 U/L in apricot cultures. In addition, AAO activities in both cultures showed similar trends up to day 17 of cultivation, with the highest AAO activity determined as 105.99 ± 6.3 U/L on day 10 in apricot cultures. Decolorization of the azo dye methyl orange was also achieved with produced ligninolytic enzymes by P. eryngii using apricot and pomegranate wastes.     

Effect of carbon and nitrogen limitation on lignin peroxidase and manganese peroxidaseproduction by Phanerochaete flavido-alba

The ligninolytic enzymes lignin peroxidase (LiP) and manganese dependent peroxidase(MnP), were detected in extracellular fluids of Phanerochaete flavido-alba FPL 106507cultures under carbon or nitrogen limitation. MnP activities were found to be higher than LiPactivities under all growth conditions tested. Higher titres of both peroxidases were obtainedunder carbon limitation in excess nitrogen. Isoelectric points (pIs) observed after FPLC and IEFof concentrated extracellular fluids revealed more acidic pIs for LiP enzymes obtained innitrogen-limited cultures than those in carbon-limited cultures. However, the change in thelimiting growth factor does not significantly affect MnP pIs.     

白腐菌木质素降解酶及其在木质素降解过程中的相互作用

木质素是一类不易降解的生物物质,在自然界中,白腐真菌对木质素的降解能力最强.白腐真菌降解木质素主要依靠分泌的三种酶:木质素过氧化物酶(Lip)、锰过氧化物酶(MnP)和漆酶(Lac).对白腐真菌分泌的三种木质素降解酶在性质、分布等方面进行了比较,系境地介绍三种木质素降解酶的催化作用,并阐述其在木质素降解过程中的相互作用.     

Homology models of two isozymes of manganese peroxidase: Prediction of a Mn(II) binding site

The three-dimensional structures of two isozymes of manganese peroxidase (MnP) have been predicted from homology modeling using lignin peroxidase as a template. Although highly homologous, MnP differs from LiP by the requirement of Mn(II) as an intermediate in its oxidation of substrates. The Mn(II) site is absent in LiP and unique to the MnP family of peroxidases. The model structures were used to identify the unique Mn(II) binding sites, to determine to what extent they were conserved in the two isozymes, and to provide insight into why this site is absent in LiP. For each isozyme of MnP, three candidate Mn(II) binding sites were identified. Energy optimizations of the three possible Mn(II) enzyme complexes allowed the selection of the most favorable Mn(II) binding site as one with the most anionic oxygen moieties best configured to act as ligands for the Mn(II). At the preferred site, the Mn(II) is coordinated to the carboxyl oxygens of Glu-35, Glu-39, and Asp-179, and a propionate group of the heme. The predicted Mn(II) binding site is conserved in both isozymes. Comparison between the residues at this site in MnP and the corresponding residues in LiP shows that two of the three anionic residues in MnP are replaced by neutral residues in LiP, explaining why LiP does not bind Mn(II). © 1994 Wiley-Liss, Inc.     

Production and characterization of ligninolytic enzymes ofBjerkandera adusta grown on wood meal/wheat bran culture and production of these enzymes using a rotary-solid fermenter

Manganese peroxidase (MnP) and lignin peroxidase (LiP) were produced by growing a white-rot fungusBjerkandera adusta statically, on a wood meal/wheat bran culture in flasks. MnP and LiP reached their maximum activity after 6 and 19 days of inoculation, respectively. Both MnP and LiP are thought to be important enzymes in lignin biodegradation byB. adusta. Ion exchange chromatography showed thatB. adusta produced a single LiP and a single MnP enzyme in wood meal/wheat bran culture. These enzymes were separated and characterized. The molecular weight of MnP was 46,500 with a pl of 3.9. The molecular weight of LiP was estimated to be 47,000 with a pl of 3.5. Spectral analysis demonstrated that both enzymes are heme proteins. Production of these enzymes was also achieved using a rotarysolid culture fermenter. MnP, LiP and veratryl alcohol oxidase were produced byB. adusta in the fermenter.     

PRODUCTION OF LIGNINOLYTIC ENZYMES BY SOLID-STATE FERMENTATION USING Pleurotus eryngii

Pleurotus eryngii (DC.) Gillet (MCC58) was investigated for its ability to produce various ligninolytic enzymes such as laccase (Lac), manganese peroxidase (MnP), aryl alcohol oxidase (AAO), and lignin peroxidase (LiP) by solid-state fermentation (SSF), which was carried out using a support substrate from the fruit juice industry. The chemical content of grape waste from this industry was studied. Also, the production patterns of these extracellular enzymes were researched during the growth of the organism for a period of 20 days and the protein, reducing sugar, and nitrogen levels were monitored during the stationary cultivation. The highest Lac activity was obtained as 2247.62 ± 75 U/L on day 10 in the presence of 750 µM Mn²⁺, while the highest MnP activity was attained as 2198.44 ± 65 U/L on day 15 in the presence of 500 µM Mn²⁺. Decolorization of methyl orange and reactive red 2 azo dyes was also achieved with ligninolytic enzymes, produced in SSF of P. eryngii.     

Effect of copper ions on the ligninolytic enzyme complex and the antioxidant enzyme activity in the white-rot fungus Trametes trogii 46

White-rot fungi of the Phylum Basidiomycota are quite promising in ligninolytic enzyme production and the optimization of their synthesis is of particular significance. The aim of this study was to investigate the effect of enhanced concentration of copper (Cu) ions (25–1000 μg/ml) on the activity of the ligninolytic enzyme complex (laccase, Lac; lignin peroxidase, LiP; Mn-peroxidase, MnP) in Trametes trogii 4₆, as well as the changes in the antioxidant cell response. All concentrations tested reduced significantly in growth and glucose consumption. Cu ions affected the ligninolytic enzyme activity in a dose dependent manner. Concentrations in the range of 25–100 μg/ml strongly stimulated Lac production (a 5–6-fold increase compared to the control). LiP activity was also induced by Cu, with the peak value being recorded following exposure to 50 μg/ml metal ions. In contrast, the addition of Cu ions had a positive effect on MnP activity at a concentration higher than 100 μg/ml. The maximum enzyme level was achieved at 1000 μg/ml. The results obtained on superoxide dismutase and catalase activities indicated that exposure of T. trogii 4₆ mycelia to Cu ions promoted oxidative stress. Both enzyme activities were co-ordinately produced with Lac and LiP but not co-ordinately with MnP.     

Fungal metabolism of environmentally persistent compounds: Substrate recognition and metabolic response

Mechanism of lignin biodegradation caused by basidiomycetes and the history of lignin biodegradation studies were briefly reviewed. The important roles of fungal extracellular ligninolytic enzymes such as lignin and manganese peroxidases (LiP and MnP) were also summarized. These enzymes were unique in their catalytic mechanisms and substrate specificities. Either LiP or MnP system is capable of oxidizing a variety of aromatic substrates via a one-electron oxidation. Extracellular fungal system for aromatic degradation is non-specific, which recently attracts many people working in a bioremediation field. On the other hand, an intracellular degradation system for aromatic compounds is rather specific in the fungal cell. Structurally similar compounds were prepared and metabolized, indicating that an intracellular degradation strategy consisted of the cellular systems for substrate recognition and metabolic response. It was assumed that lignin-degrading fungi might be needed to develop multiple metabolic pathways for a variety of aromatic compounds caused by the action of non-specific ligninolytic enzymes on lignin. Our recent results on chemical stress responsible factors analyzed using mRNA differential display techniques were also mentioned.     

Cu(II)对一株镰刀菌形态发育及木质素酶系活性的影响

本试验采用室内摇瓶培养,通过添加不同浓度的Cu(II),研究了Cu(II)对降解菌Fusarium sp. ZH-H2形态发育及木质素酶系活性的影响,以期诱导提高木质素酶系的活性。结果表明,当Cu(II)浓度为0.50mmol/L时,菌丝生物量最高达0.38g,菌丝团呈洁白平滑球状且数量最多,此浓度下木质素过氧化物酶（lignin peroxidase,LiP）活性峰值也达到最高,为28 315.41U/L,当Cu(II)浓度为2.00mmol/L时,有利于诱导锰过氧化物酶（manganese peroxidase,MnP）和漆酶（laccase,Lac）的代谢,最高峰值分别为1 612.90U/L、7 829.12U/L,并且明显缩短了峰值的形成时间,浓度过高或过低则对3种木质素酶系活性产生抑制效应,为下一步分子生物学研究奠定了基础。     

Ligninolytic Enzymes of the White Rot Basidiomycete Trametes trogii

The white rot fungus Trametes trogii strain BAFC 463 produced laccase, manganese peroxidase, lignin peroxidase and cellobiose dehydrogenase, as well as two hydrogen peroxide‐producing activities: glucose oxidizing activity and glyoxal oxidase. In high‐N (40 mM N) cultures, the titres of laccase, MnP and GLOX were 27 (6.55 U/ml), 45 (403.00 mU/ml)and 8 (32,14 mU/ml) fold higher, respectively, than those measured in an N‐limited medium. This is consistent with the fact that the ligninolytic system of T. trogii is expressed constitutively. Lower activities of all the enzymes tested were recorded upon decreasing the initial pH of the medium from 6.5 to 4.5. Adding veratryl alcohol improved GLOX production, while laccase activity was stimulated by tryptophan. Supplying Tween 80 strongly reduced the activity of both MnP and GLOX, but increased laccase production. The titre of MnP was affected by the concentration of Mn in the culture medium, the highest levels were obtained with 90 μM Mn (II). LiP activity, as CDH activity, were detected only in the mediumsupplemented with sawdust. In this medium, laccase production reached a maximum of 4.75 U/ml, MnP 747.60 mU/ml and GLOX 117.11 mU/ml. LiP, MnP and GLOX activities were co‐induced, attaining their highest levels at the beginning of secondary metabolism, but while MnP, laccase, GLOX and CDH activities were also present in the primary growth phase, LiP activity appears to beidiophasic. The simultaneous presence of high ligninolytic and hydrogen peroxide producing activities in this fungus makes it an attractive microorganism for future biotechnological applications.     

Production of the ligninolytic enzymes by immobilized <Emphasis Type="Italic">Phanerochaete chrysosporium</Emphasis> in an air atmosphere

Summary The production of the ligninolytic enzymes by Phanerochaete chrysosporium immobilized on polyurethane foam cubes in air was investigated by adopting different sizes and amounts of the carriers, different medium C/N ratios and different glucose-feeding strategies. No lignin peroxidase (LiP) activity was observed under nitrogen limitation (C/N ratio, expressed as glucose/NH₄⁺, 56/2.2 mM) with two sizes and three amounts of the carriers, while comparable levels of manganese peroxidase (MnP) activities were detected only in non-immersed cultures with two sizes of the carriers. A non-immersed state also stimulated LiP formation under carbon limitation (C/N ratio 28/44 mM). High peak activities of LiP, 197 and 164 U/l, were obtained in non-immersed cultures under carbon limitation at the C/N ratios of 28/44 and 56/44 mM, respectively, the occurrence of the activities coinciding with the complete consumption of glucose. A very low level of MnP was measured at the C/N ratio of 28/44 mM compared with the similar activities at 56/2.2 and 56/44 mM. An addition of 2 g glucose/l after its complete depletion improved both the production of LiP and MnP markedly in non-immersed culture at the initial C/N ratio of 28/44 mM, whereas a replenishment of 5 g/l, still enhancing the formation of MnP, inhibited the production of LiP first before the later reactivation. It is suggested that non-immersed liquid culture under carbon limitation reinforced by a suitable glucose feeding strategy is one potential way to realize high production of the ligninolytic enzymes by P. chrysosporium in air.     

黄孢原毛平革菌木素过氧化物酶类在天然木素降解中作用的研究

通过诱变得到十一株木素过氧化物酶酶活降低的黄孢原毛平革菌（Ｐｈａｎｅｒｏｃｈａｅｔｅｃｈｒｙｓｏｓｐｏｒｉｕｍ）突变株,用灰色理论分析了其木素过氧化物酶类的产生与木素降解能力间的相关性,并从中筛选到一株木素过氧化物酶缺陷、锰过氧化物酶酶活明显降低的突变株,其木素降解能力为原始菌株的８０％左右。该菌粗酶液作用于纤维素酶酶解杉木木素和天然褐腐木素,可产生小分子的木素降解产物,此反应不需Ｈ２Ｏ２参与。红外光谱分析表明粗酶液对木素的作用主要为氧化作用,因此推测此突变株粗酶液中含有不同于木素过氧化物酶和锰过氧化物酶的与木素氧化降解有关的酶类     

Production,partial purification and characterization of ligninolytic enzymes from selected basidiomycetes mushroom fungi

In recent years, many research on the quantity of lignocellulosic waste have been developed. The production, partial purification, and characterisation of ligninolytic enzymes from various fungi are described in this work. On the 21st day of incubation in Potato Dextrose (PD) broth, Hypsizygus ulmarius developed the most laccase (14.83 × 10⁻⁶ IU/ml) and manganese peroxidase (24.11 × 10⁻⁶ IU/ml), while Pleurotus florida produced the most lignin peroxidase (19.56 × ⁻⁶ IU/ml). Laccase (Lac), lignin peroxidase (LiP), and manganese peroxidase (MnP), all generated by selected basidiomycetes mushroom fungi, were largely isolated using ammonium sulphate precipitation followed by dialysis. Laccase, lignin peroxidase, and manganese peroxidase purification findings indicated 1.83, 2.13, and 1.77 fold purity enhancements, respectively. Specific activity of purified laccase enzyme preparations ranged from 305.80 to 376.85 IU/mg, purified lignin peroxidase from 258.51 to 336.95 IU/mg, and purified manganese peroxidase from 253.45 to 529.34 IU/mg. H. ulmarius laccase (376.85 IU/mg) with 1.83 fold purification had the highest specific activity of all the ligninolytic enzymes studied, followed by 2.13 fold purification in lignin peroxidase (350.57 IU/mg) and manganese peroxidase (529.34 IU/mg) with 1.77-fold purification. Three notable bands with molecular weights ranging from 43 to 68 kDa and a single prominent band with a molecular weight of 97.4 kDa were identified on a Native PAGE gel from mycelial proteins of selected mushroom fungus. The SDS PAGE profiles of the mycelial proteins from the selected mushroom fungus were similar to the native PAGE. All three partially purified ligninolytic isozymes display three bands in native gel electrophoresis, with only one prominent band in enzyme activity staining. The 43 kDa, 55 kDa, and 68 kDa protein bands correspond to laccase, lignin peroxidase, and manganese peroxidase, respectively.     

百草枯对木质素降解菌产酶及其生物化学变化的影响

为研究外源活性氧对木质素降解菌的影响,本实验对外源百草枯诱导下的杂色云芝(Coriolus versicolor)产酶及其生物化学过程进行了研究。将一定浓度的百草枯加入培养7 d的杂色云芝菌培养液中,连续培养148 h,测定其胞外木质素降解酶、胞内抗氧化酶的活性及生物化学参数的变化。与对照相比,30μmol/L的百草枯能够显著促进杂色云芝锰依赖过氧化物酶(MnP)、木质素过氧化物酶(LiP)和漆酶(Lac)的活性,3种酶活性分别提高了1.3、7和2.5倍;在连续培养的前48 h,30μmol/L的百草枯促进了胞内超氧化物歧化酶(SOD)、过氧化氢酶(CAT)的活性。百草枯对于胞外木质素降解酶活性的促进作用比对胞内抗氧化酶活性的促进作用明显。百草枯的加入促进了胞外酚类化合物与甲醛的浓度的增加,而丙二醛的浓度在培养的前24 h内增加,随后下降。结果表明,百草枯的加入对白腐菌产生了氧化胁迫,但菌株的抗氧化系统能够有效地进行氧化剂的清除,从而阻止氧化剂对机体的氧化伤害。百草枯作为外源氧化胁迫剂,可以增加木质素降解酶活性,有利于木质素的降解。     

Solid-state production of lignin peroxidase (LiP) and manganese peroxidase (MnP) by Phanerochaete chrysosporium using steam-exploded straw as substrate

In the used media mainly consisting of steam-exploded wheat straw, the straw, which could replace expensive veratryl alcohol, might act not only as nutrient, but also as inducer of lignin enzymes. The activities of the enzymes lignin peroxidase (LiP) and manganese peroxidase (MnP) in solid-state fermentation (SSF) were far higher than in submerged fermentation (SmF). Under optimal conditions of SSF, the maximum activities of the enzymes Lip and MnP were 2600 and 1375 U/L, respectively. Thus, this would pave the way for production and application of lignin enzymes on a large scale.     

The selective visualization of lignin peroxidase,manganese peroxidase and laccase,produced by white rot fungi on solid media

A visual method for the selective screening of lignin degrading enzymes, produced by white rot fungi (WRF), was investigated by the addition of coloring additives to solid media. Of the additives used in the enzyme production media, guaiacol and RBBR could be used for the detection of lignin peroxidase (LiP), manganese peroxidase (MnP) and laccase. Syringaldazine and Acid Red 264 were able for the detection of both the MnP and laccase, and the LiP and laccase, respectively, and a combination of these two additives was able to detect each of the ligninases produced by the WRF on solid media.