The Effect of Salt Stress on the Production of Canthaxanthin and Astaxanthin by Chlorella zofingiensis Grown Under Limited Light Intensity

The fresh water green microalga Chlorella zofingiensisis known to accumulate ketocarotenoids – primarily astaxanthin but also canthaxanthin – when grown under stress conditions of high light irradiance and low nitrogen. We found that salt stress can replace light stress with respect to inducing carotenoid production: cells of C. zofingiensis grown under low light irradiance and subjected to salt and low nitrogen stress accumulated higher amounts of total secondary carotenoids than those growing under high light and low nitrogen stress. Furthermore, C. zofingiensis growing under conditions of salt stress and low light accumulated higher amounts of canthaxanthin than astaxanthin. It is suggested that for canthaxanthin accumulation under salt stress, light is not a limiting factor, but for astaxanthin accumulation high light irradiance is mandatory. These results may be applied in the future for the commercial production of canthaxanthin by C. zofingiensis in systems in which light availability is poor.     

Changes in the proportion of endogenous osmotic solutes accumulated by Chlorella emersonii in the light and dark

Abstract. The type of endogenous osmotic solute accumulated by Chlorella emersonii grown at high external osmotic pressure (π_ext) depended on the light/dark conditions: proline accumulated to high concentrations in cells in the light, while sucrose accumulated to high concentrations in the dark. These findings were made during the alternating light dark cycles used to obtain synchronized cultures, i.e. cultures containing cells at only one stage of development at any one time. Similar decreases in proline and increases in sucrose in the dark were found for cells previously grown in continuous light to obtain non-synchronized cultures, i.e. cultures containing cells at all stages of development.
In cultures synchronized at 200 mol m ⁻³ NaCl (π_ext= 1.01 MPa), recently divided 'daughter cells' at the beginning of the light periods contained 60 mol m⁻³ proline and 100mol m⁻³ sucrose, while mature cells towards the end of light periods contained 130 mol m proline and 20 mol m⁻³ sucrose. The changes in proline and sucrose which occurred in synchronized cultures were due mainly to light/dark conditions and to a much lesser extent to different stages of cell development. The proportion of proline to sucrose in daughter cells collected from non-synchronized cultures in continuous light was not different from the proportion in heterogeneous populations of cells.
Results are discussed in relation to the accumulations of two, rather than one, endogenous osmotic solute and to growth reductions of C. emersonii exposed to high external osmotic pressures.     

Effects of accumulation of 3-O-methylglucose on growth and osmotic regulation in Chlorella emersonii

Abstract. The effect of accumulation of 3- O -methylglucose (MG) on growth and steady-stale concentrations of the endogenous osmotic solutes proline and sucrose was studied in Chlorella emersonii grown at external osmotic pressure (II) of 0.08-1.64 MPa. NaCL was used as osmoticum. The total solute content of the cells was manipulated by supplying 2 mol m⁻³ MG for 4 and 48 h. MG accumulated to 50–230 mol m⁻³ within 4h and was not metabolized. Uptake of MG resulted in decreases in concentrations of proline and sucrose, the two solutes mainly responsible for osmotic adaptation of C. emersonii to high II. After 4 or 48 h growth in the presence of MG, the decreases in concentration of proline and sucrose were as predicted from the contribution of MG to the total solute content of the cell.     

Reconstruction of the astaxanthin biosynthesis pathway in rice endosperm reveals a metabolic bottleneck at the level of endogenous β-carotene hydroxylase activity

Astaxanthin is a high-value ketocarotenoid rarely found in plants. It is derived from β-carotene by the 3-hydroxylation and 4-ketolation of both ionone end groups, in reactions catalyzed by β-carotene hydroxylase and β-carotene ketolase, respectively. We investigated the feasibility of introducing an extended carotenoid biosynthesis pathway into rice endosperm to achieve the production of astaxanthin. This allowed us to identify potential metabolic bottlenecks that have thus far prevented the accumulation of this valuable compound in storage tissues such as cereal grains. Rice endosperm does not usually accumulate carotenoids because phytoene synthase, the enzyme responsible for the first committed step in the pathway, is not present in this tissue. We therefore expressed maize phytoene synthase 1 (ZmPSY1), Pantoea ananatis phytoene desaturase (PaCRTI) and a synthetic Chlamydomonas reinhardtii β-carotene ketolase (sCrBKT) in transgenic rice plants under the control of endosperm-specific promoters. The resulting grains predominantly accumulated the diketocarotenoids canthaxanthin, adonirubin and astaxanthin as well as low levels of monoketocarotenoids. The predominance of canthaxanthin and adonirubin indicated the presence of a hydroxylation bottleneck in the ketocarotenoid pathway. This final rate-limiting step must therefore be overcome to maximize the accumulation of astaxanthin, the end product of the pathway.     

Increase in Chlorella strains calorific values when grown in low nitrogen medium

The calorific value of five strains of Chlorella grown in Watanabe and low-nitrogen medium was determined. The algae were grown in small (2L) stirred tank bioreactors and the best growth was obtained with Chlorella vulgaris with a growth rate of 0.99 d(-1) and the highest calorific value (29 KJ/g) was obtained with C. emersonii. The cellular components were assayed at the end of the growth period and the calorific value appears to be linked to the lipid content rather than any other component.     

Effects of external NaCI, and of changes in turgor pressure and volume, on K+ concentrations in Chlorella emersonii

Summary. Soluble potassium concentrations were determined for the slightly vacuolated, unicellular, walled alga Chlorella emersonii. Sap of cells grown in 1 mol m⁻³ NaCI contained 140 mol m⁻³ K⁺ and sap of cells grown in 125, 200, and 335 mol m⁻³ NaCI contained 160-180 mol m⁻³ K ⁺.
The possible regulation of K ⁺ concentrations by a system of lurgor and volume maintenance was investigated by supplying 3-0-methylglucose. This solute accumulates to 85-230 mol m⁻³ in C. emersonii , but is not metabolized. Accumulation of 3-0-methylglucose increased the volume of cells grown at both low and high NaCI by about 10%. Furthermore, accumulation of 3-0-methylglucose also increased turgor pressures of cells grown in 1 and 125 mol m⁻³ NaCI by 0.3 and 0.2 MPa, respectively. (Similar measurements were not attempted for cells grown in 200 and 335 mol m⁻³ NaCI, because of the insensitivity of available methods to measure turgor pressure of cells exposed to high external osmotic pressures.)
At all NaCI concentrations, the K ⁺ concentrations of cells which had accumulated 3-0-methylglucose were only 10-20 mol m⁻³ lower than K⁺ in cells which had not been supplied with 3-0-methylglucose. In contrast, accumulation of 3-0-methylglucose greatly decreased concentrations of the endogenous osmotic solutes, proline and sucrose, which accumulated in cells grown in 125 mol m⁻³ and higher NaCI concentrations.
It is concluded that K⁺ concentrations in Chlorella emersonii are not controlled by a system of turgor and volume maintenance.     

Improvement of a CrtO-type of beta-carotene ketolase for canthaxanthin production in Methylomonas sp

Two types of non-homologous beta-carotene ketolases (CrtW and CrtO) were previously described. We report improvement of a CrtO-type of beta-carotene ketolase for canthaxanthin production in a methylotrophic bacterium, Methylomonas sp. 16a, which could use the C1 substrate (methane or methanol) as sole carbon and energy source. The crtO gene from Rhodococcus erythropolis was improved for canthaxanthin production in an E. coli strain engineered to produce high titer carotenoids by error-prone PCR mutagenesis followed by in vitro recombination. The best mutants from protein engineering could produce approximately 90% of total carotenoids as canthaxanthin in the high titer E. coli strain compared to approximately 20% canthaxanthin produced by the starting gene. Canthaxanthin production in Methylomonas was also significantly improved to approximately 50% of total carotenoids by the mutant genes. Further improvement of canthaxanthin production to approximately 93% in Methylomonas was achieved by increased expression of the best mutant gene. Some mutations were found in many of the improved genes, suggesting that these sites, and possibly the regions around these sites, were important for improving the crtO's activity for canthaxanthin production.     

Effect of nutritional regime on accumulation of cobalt, manganese and zinc by green microalgae

Abstract Accumulation of cobalt, manganese and zinc by the algae Chlorella emersonii, Chlamydomonas reinhardtii and Scenedesmus obliquus has been characterized under photoautotrophic, photoheterotrophic and chemoheterotrophic nutritional regimes. All three species accumulated smaller amounts of Co²⁺, Mn²⁺ and Zn²⁺ under chemoheterotrophic and photoheterotrophic conditions than under photoautotrophic conditions except in the case of cobalt accumulation by C. reinhardtii where there was little difference in the amount of cobalt accumulated under any of the nutritional regimes. Decreased accumulation of the three metals by C. emersonii and C. reinhardtii largely resulted from a decrease in the initial biosorptive phase of uptake whereas the decrease in Mn²⁺ and Zn²⁺ accumulation by C. reinhardtii under chemoheterotrophic and photoheterotrophic conditions was due to a decrease in the slow energy-dependent phase of uptake.     

Culture of microalgae Chlorella minutissima for biodiesel feedstock production

Microalgae are among the most promising of non‐food based biomass fuel feedstock alternatives. Algal biofuels production is challenged by limited oil content, growth rate, and economical cultivation. To develop the optimum cultivation conditions for increasing biofuels feedstock production, the effect of light source, light intensity, photoperiod, and nitrogen starvation on the growth rate, cell density, and lipid content of Chlorella minutissima were studied. The fatty acid content and composition of Chlorella minutissima were also investigated under the above conditions. Fluorescent lights were more effective than red or white light‐emitting diodes for algal growth. Increasing light intensity resulted in more rapid algal growth, while increasing the period of light also significantly increased biomass productivity. Our results showed that the lipid and triacylglycerol content were increased under N starvation conditions. Thus, a two‐phase strategy with an initial nutrient‐sufficient reactor followed by a nutrient deprivation strategy could likely balance the desire for rapid and high biomass generation (124 mg/L) with a high oil content (50%) of Chlorella minutissima to maximize the total amount of oil produced for biodiesel production. Moreover, methyl palmitate (C16:0), methyl oleate (C18:1), methyl linoleate (C18:2), and methyl linolenate (C18:3) are the major components of Chlorella minutissima derived FAME, and choice of light source, intensity, and N starvation impacted the FAME composition of Chlorella minutissima. The optimized cultivation conditions resulted in higher growth rate, cell density, and oil content, making Chlorella minutissima a potentially suitable organism for biodiesel feedstock production. Biotechnol. Bioeng. 2011;108: 2280–2287. © 2011 Wiley Periodicals, Inc.     

Tetraphenylphosphonium (TPP+) is not suitable for the assessment of electrical potentials in Chlorella emersonii

Abstract. For Chlorella emersonii , plausible membrane potentials between –80 and –120 mV were calculated from the distribution of the lipophilic cation tetraphenylphosphonium (TPP⁺) between the cells and the medium. Furthermore, these calculated membrane potentials were influenced in a way expected from the literature, by different metabolic conditions induced by light or dark, anaerobiosis, glucose, and by inhibition or uncoupling of electron transport.
Nevertheless, the experiments presented here indicate that TPP⁺ is unsuitable as a probe for electrical potentials, at least in Chlorella emersonii. The reasons for this conclusion are as follows:

• 1. 

  Much of the incorporated TPP⁺-¹⁴C could not be exchanged against unlabelled TPP⁺.
• 2. 

  The uptake of TPP⁺-¹⁴C was very slow and exhibited complex rather than simple saturation kinetics.
• 3. 

  A large adsorption of TPP⁺-¹⁴C took place even after the cells were killed; the adsorption by living cells was only 20–60% higher than with killed cells. Furthermore, the adsorption by killed cells showed kinetics similar to living cells.

     

Effect of culture conditions on canthaxanthin production by Dietzia natronolimnaea HS-1

This study investigated the effects of various culture parameters (carbon sources, temperature, initial pH of culture, NaCl concentration, and light) on the growth and canthaxanthin production by Dietzia natronolimnaea HS-1. The results showed that the most effective carbon source for growth and canthaxantin production was glucose, and the best pH and temperature were 7 and 31 degrees C, respectively. In addition, the biomass and canthaxanthin production increased in a medium without NaCl and in the presence of light. Under the optimized conditions, the maximum biomass, total carotenoid, and canthaxanthin production were 6.12 +/- 0.21 g/l, 4.51 +/- 0.20 mg/l, and 4.28 +/- 0.15 mg/l, respectively, in an Erlenmeyer flask system, yet increased to 7.25 g/l, 5.48 mg/l, and 5.29 mg/l, respectively, in a batch fermenter system.     

High molecular weight lipids from the trilaminar outer wall (TLS)-containing microalgae Chlorella emersonii, Scenedesmus conmmunis and Tetraedron minimum

High molecular weight lipids were isolated from Chlorella emersonii, Scenedesmus communis and Tetraedron minimum, thin trilaminar outer wall (TLS)-containing freshwater microalgae producing an insoluble non-hydrolysable biopolymer (i.e. algaenan). Molecular weight determination by gel permeation chromatography indicated that their molecular weights range from ca. 400 to 2000 Da. Flash pyrolysis with in situ methylation using tetramethylammonium hydroxide (TMAH) and alkaline hydrolysis showed that the high molecular weight lipids isolated from C. emersonii and S. communis are mainly composed of saturated n-C26 and n-C28 fatty acids and alcohols and of saturated n-C30 and n-C32 alpha,omega-diols and omega-hydroxy acids. In contrast the high molecular weight lipids isolated from T. minimum are predominantly composed of long-chain fatty acids and omega-hydroxy acids. Aromatic moieties were also identified in small amounts in the thermochemolysate and in the hydrolysate. Chemical structural models containing long-chain mono- and polyesters were proposed for the high molecular weight lipids isolated from the three microalgae in agreement with analytical and spectroscopic data. Structural similarity between the outer cell wall of these microalgae and the cuticular membrane of higher plants is suggested.     

Structure and function characterization of the phytoene desaturase related to the lutein biosynthesis in Chlorella protothecoides CS-41

Phytoene desaturase is the key enzyme involved in the biosynthesis pathway of lutein. The unicellular microalga, Chlorella protothecoides CS-41, had been selected for the heterotrophic production of high concentrations of lutein. In this study, a cDNA copy of the pds gene from C. protothecoides was obtained using the rapid amplification of cDNA ends (RACE) technique. Phylogenetic analysis of the deduced amino acid sequence revealed that the phytoene desaturases derived from the algal family. Expression of the pds gene in Escherichia coli produced a single protein of 61 kDa. The PDS activity of the expressed protein was confirmed by the production of ζ-carotene as the result from the action of the enzyme’s desaturation activity, which was identified by high-performance liquid chromatography and heterologous complementation analysis. Using random and site-directed mutagenesis, a single amino acid mutation (N144D) was identified and confirmed. This mutant encodes an inactive enzyme, which implies that amino acid 144 is crutial to the activity of the PDS enzyme. Therefore, by gene cloning and expression in prokaryotic cells, the gene for ζ-carotene production or as part of the biosynthetic pathway of lutein had been characterized from Chlorella protothecoides CS-41.     

Acetohydroxy Acid Synthase Activity in Chlorella emersonii under Auto- and Heterotrophic Growth Conditions

Acetohydroxyacid synthase (AHAS) activity was studied in the green unicellular alga Chlorella emersonii. This activity and its regulation was compared in the algae grown autotrophically and heterotrophically on glucose in the dark. No evidence for the existence of more than one enzyme was found. The activity in crude extracts from either heterotrophically or autotrophically grown cells showed a K_m for pyruvate of 9 millimolar, a 22-fold preference for 2-ketobutyrate over pyruvate as the second substrate, 50% inhibition by 0.5 millimolar valine, and 50% inhibition by 0.3 micromolar sulfometuron methyl (SMM). Spontaneous mutants of the alga resistant to SMM were isolated, which appeared to be single gene mutants containing SMM-resistant AHAS activity. Hence, AHAS appears to be the sole direct target site of SMM in C. emersonii. The fact that the mutants had equivalent SMM resistance under auto- and heterotrophic conditions further supports the conclusion that the same enzyme functions under both physiological regimes. The addition of valine and isoleucine leads to partial relief of SMM inhibition of biomass increase, but not of SMM inhibition of cell division.     

Effects of accumulation of 3-O-methylglucose on levels of endogenous osmotic solutes in Chlorella emersonii

Abstract. Regulation of the concentration of osmotic solutes was studied in Chlorella emersonii grown at external osmotic pressures (II) ranging between 0.08 and 1.64MPa. NaCl was used as osmoticum. The total solute content of the cells was manipulated by applying 2 mol m⁻³ 3- O -methylglucose (MG), which was not metabolized, and accumulated at concentrations ranging between 60 and 230 mol m⁻³ within 4 h after its addition to the medium. Methylglucose uptake resulted in decreases in concentrations of proline and sucrose, the two solutes mainly responsible for osmotic adaptation of C. emersonii to high external II. The responses were consistent with the hypothesis that proline and sucrose concentrations are controlled by a system of osmotic regulation, with turgor and/or volume as a primary signal. Short-term experiments showed that even very small increases in turgor and/or volume, due to accumulation of methylglucose, resulted in large decreases in proline and sucrose. Over the first 30-60 min the total solute concentration in the cells increased by at most 15 osmol m⁻³ which would represent an increase in turgor pressure of at most 0.04 M Pa. Yet, the decreases in proline and sucrose were as fast as those in cells exposed to a sudden decrease of 0.25 MPa in external II, when the turgor pressure would have increased by at least 0.15 MPa. High concentrations of methylglucose in cells grown at high II did not affect the rapid synthesis of proline and sucrose which started when the cells were transferred to yet higher II. Thus, methylglucose had no direct effects on proline and sucrose metabolism, and it has been assumed that it acted solely as an inert osmotic solute within the cell.     

Carotenoid biosynthesis and overproduction in Corynebacterium glutamicum

ABSTRACT: BACKGROUND: Corynebacterium glutamicum contains the glycosylated C50 carotenoid decaprenoxanthin as yellow pigment. Starting from isopentenyl pyrophosphate, which is generated in the non-mevalonate pathway, decaprenoxanthin is synthesized via the intermediates farnesyl pyrophosphate, geranylgeranyl pyrophosphate, lycopene and flavuxanthin. RESULTS: Here, we showed that the genes of the carotenoid gene cluster crtE-cg0722-crtBIYeYfEb are co-transcribed and characterized defined gene deletion mutants. Gene deletion analysis revealed that crtI, crtEb, and crtYeYf, respectively, code for the only phytoene desaturase, lycopene elongase, and carotenoid C45/C50 epsilon-cyclase, respectively. However, the genome of C. glutamicum also encodes a second carotenoid gene cluster comprising crtB2I2-1/2 shown to be co-transcribed, as well. Ectopic expression of crtB2 could compensate for the lack of phytoene synthase CrtB in C. glutamicum DeltacrtB, thus, C. glutamicum possesses two functional phytoene synthases, namely CrtB and CrtB2. Genetic evidence for a crtI2-1/2 encoded phytoene desaturase could not be obtained since plasmid-borne expression of crtI2-1/2 did not compensate for the lack of phytoene desaturase CrtI in C. glutamicum DeltacrtI. The potential of C. glutamicum to overproduce carotenoids was estimated with lycopene as example. Deletion of the gene crtEb prevented conversion of lycopene to decaprenoxanthin and entailed accumulation of lycopene to 0.03 +/- 0.01 mg/g cell dry weight (CDW). When the genes crtE, crtB and crtI for conversion of geranylgeranyl pyrophosphate to lycopene were overexpressed in C. glutamicum DeltacrtEb intensely red-pigmented cells and an 80 fold increased lycopene content of 2.4 +/- 0.3 mg/g CDW were obtained. CONCLUSION: C. glutamicum possesses a certain degree of redundancy in the biosynthesis of the C50 carotenoid decaprenoxanthin as it possesses two functional phytoene synthase genes. Already metabolic engineering of only the terminal reactions leading to lycopene resulted in considerable lycopene production indicating that C. glutamicum may serve as a potential host for carotenoid production.     

PEST sequences in cAMP-dependent protein kinase subunits of the aquatic fungus Blastocladiella emersonii are necessary for in vitro degradation by endogenous proteases

During Blastocladiella emersonii germination, the regulatory (R) and the catalytic (C) subunits of the cAMP-dependent protein kinase (PKA) are rapidly and concurrently degraded, after PKA activation in response to a transient increase in intracellular cAMP levels. The possibility that PEST sequences could be acting as proteolytic recognition signals in this process was investigated, and high score PEST sequences were found in both B. emersonii R and C subunits. Deletions in the PEST sequences were obtained by site-directed mutagenesis and the different PKA subunits were independently expressed in Escherichia coli. Proteolysis assays of the various R and C recombinant forms, using B. emersonii cell extracts as the source of proteases, showed a strong correlation between the presence of high score PEST sequences and susceptibility to degradation. Furthermore, the amino-terminal sequence of the proteolytic fragments indicated that the cleavage sites in both subunits are located at or near the PEST regions. The PEST sequence in B. emersonii C subunit, which when deleted or disrupted leads to resistance to proteolysis, is entirely contained in the 72-amino-acid extension located in the N-terminus of the protein. C subunit mutants carrying deletions in this region displayed little difference in their kinetic properties or enzyme thermostability. These results suggest that the N-terminal extension may only play a role in C subunit degradation.