Simultaneous Saccharification and Fermentation of Hydrothermal Pretreated Lignocellulosic Biomass: Evaluation of Process Performance Under Multiple Stress Conditions

Industrial lignocellulosic bioethanol processes are exposed to different environmental stresses (such as inhibitor compounds, high temperature, and high solid loadings). In this study, a systematic approach was followed where the liquid and solid fractions were mixed to evaluate the influence of varied solid loadings, and different percentages of liquor were used as liquid fraction to determine inhibitor effect. Ethanol production by simultaneous saccharification and fermentation (SSF) of hydrothermally pretreated Eucalyptus globulus wood (EGW) was studied under combined diverse stress operating conditions (30–38 °C, 60–80 g of liquor from hydrothermal treatment or autohydrolysis (containing inhibitor compounds)/100 g of liquid and liquid to solid ratio between 4 and 6.4 g liquid in SSF/g unwashed pretreated EGW) using an industrial Saccharomyces cerevisiae strain supplemented with low-cost byproducts derived from agro-food industry. Evaluation of these variables revealed that the combination of temperature and higher solid loadings was the most significant variable affecting final ethanol concentration and cellulose to ethanol conversion, whereas solid and autohydrolysis liquor loadings had the most significant impact on ethanol productivity. After optimization, an ethanol concentration of 54 g/L (corresponding to 85 % of conversion and 0.51 g/Lh of productivity at 96 h) was obtained at 37 °C using 60 % of autohydrolysis liquor and 16 % solid loading (liquid to solid ratio of 6.4 g/g). The selection of a suitable strain along with nutritional supplementation enabled to produce noticeable ethanol titers in quite restrictive SSF operating conditions, which can reduce operating cost and boost the economic feasibility of lignocellulose-to-ethanol processes.     

厌氧氨氧化菌混培物生长及代谢动力学研究

研究了厌氧氨氧化菌混培物的动力学特性.测得细胞产率系数1.573mgVS(mmolNH4+)-1;细胞衰减常数0.052mgVS(g@VS@d)-1.厌氧氨氧化菌混培物的最大氨氧化速率1.320～2.761mmol(gVS@d)-1,最大亚硝酸盐转化(反硝化)速率14.497mmol(gVS@d)-1.厌氧氨氧化菌混培物利用氨的Km值1.801～4.215mmol@L-1,利用亚硝酸盐的Km值0.468mmol@L-1.氨自身的抑制常数38.018～98.465mmol@L,实际最大氨氧化速率的氨浓度16.656mmol@L-1.亚硝酸盐对厌氧氨氧化的抑制常数5.401～11.995mmol@L-1.厌氧氨氧化的最适pH7.605.厌氧氨氧化的最适温度30℃.Vmaxa、Kma、Kia和Kin的活化能依次为37.316、30.239、33.695和30.473kJ@mol-1.     

Engineering and Two-Stage Evolution of a Lignocellulosic Hydrolysate-Tolerant Saccharomyces cerevisiae Strain for Anaerobic Fermentation of Xylose from AFEX Pretreated Corn Stover

The inability of the yeast Saccharomyces cerevisiae to ferment xylose effectively under anaerobic conditions is a major barrier to economical production of lignocellulosic biofuels. Although genetic approaches have enabled engineering of S. cerevisiae to convert xylose efficiently into ethanol in defined lab medium, few strains are able to ferment xylose from lignocellulosic hydrolysates in the absence of oxygen. This limited xylose conversion is believed to result from small molecules generated during biomass pretreatment and hydrolysis, which induce cellular stress and impair metabolism. Here, we describe the development of a xylose-fermenting S. cerevisiae strain with tolerance to a range of pretreated and hydrolyzed lignocellulose, including Ammonia Fiber Expansion (AFEX)-pretreated corn stover hydrolysate (ACSH). We genetically engineered a hydrolysate-resistant yeast strain with bacterial xylose isomerase and then applied two separate stages of aerobic and anaerobic directed evolution. The emergent S. cerevisiae strain rapidly converted xylose from lab medium and ACSH to ethanol under strict anaerobic conditions. Metabolomic, genetic and biochemical analyses suggested that a missense mutation in GRE3, which was acquired during the anaerobic evolution, contributed toward improved xylose conversion by reducing intracellular production of xylitol, an inhibitor of xylose isomerase. These results validate our combinatorial approach, which utilized phenotypic strain selection, rational engineering and directed evolution for the generation of a robust S. cerevisiae strain with the ability to ferment xylose anaerobically from ACSH.     

厌氧氨氧化反应器的启动研究

目的：对UASB-生物膜反应器进行厌氧氨氧化反应的启动研究。方法：以自配含氨氮和亚硝氮的废水为进水,以氧化沟工艺城市污水处理厂回流污泥为接种污泥。结果：反应器内部菌群进行了竞争,在运行至第66d时氨氮、亚硝酸盐氮的去除率分别达到了60.4%、58.7%,同时有硝酸盐氮生成,表明厌氧氨氧化反应已经成为反应器内的主导反应。结论：厌氧氨氧化反应器实现了快速启动。     

Measuring Biomass and Carbon Stock in Resprouting Woody Plants

Resprouting multi-stemmed woody plants form an important component of the woody vegetation in many ecosystems, but a clear methodology for reliable measurement of their size and quick, non-destructive estimation of their woody biomass and carbon stock is lacking. Our goal was to find a minimum number of sprouts, i.e., the most easily obtainable, and sprout parameters that should be measured for accurate sprout biomass and carbon stock estimates. Using data for 5 common temperate woody species, we modelled carbon stock and sprout biomass as a function of an increasing number of sprouts in an interaction with different sprout parameters. The mean basal diameter of only two to five of the thickest sprouts and the basal diameter and DBH of the thickest sprouts per stump proved to be accurate estimators for the total sprout biomass of the individual resprouters and the populations of resprouters, respectively. Carbon stock estimates were strongly correlated with biomass estimates, but relative carbon content varied among species. Our study demonstrated that the size of the resprouters can be easily measured, and their biomass and carbon stock estimated; therefore, resprouters can be simply incorporated into studies of woody vegetation.     

厌氧氨氧化工艺的微生物学特性

厌氧氨氧化工艺是废水生物脱氮研究领域里近年来出现的新工艺,有良好的应用前景。本文就该研究领域里的一些最新进展做一简要介绍。主要内容包括相关微生物的分离及鉴定,工艺机理以及应用前景。     

Continuous Ethanol Fermentation of Pretreated Lignocellulosic Biomasses,Waste Biomasses,Molasses and Syrup Using the Anaerobic,Thermophilic Bacterium Thermoanaerobacter italicus Pentocrobe 411

Lignocellosic ethanol production is now at a stage where commercial or semi-commercial plants are coming online and, provided cost effective production can be achieved, lignocellulosic ethanol will become an important part of the world bio economy. However, challenges are still to be overcome throughout the process and particularly for the fermentation of the complex sugar mixtures resulting from the hydrolysis of hemicellulose. Here we describe the continuous fermentation of glucose, xylose and arabinose from non-detoxified pretreated wheat straw, birch, corn cob, sugar cane bagasse, cardboard, mixed bio waste, oil palm empty fruit bunch and frond, sugar cane syrup and sugar cane molasses using the anaerobic, thermophilic bacterium Thermoanaerobacter Pentocrobe 411. All fermentations resulted in close to maximum theoretical ethanol yields of 0.47–0.49 g/g (based on glucose, xylose, and arabinose), volumetric ethanol productivities of 1.2–2.7 g/L/h and a total sugar conversion of 90–99% including glucose, xylose and arabinose. The results solidify the potential of Thermoanaerobacter strains as candidates for lignocellulose bioconversion.     

肌苷发酵液絮凝除菌体的研究

目前国内肌苷生产厂家普遍采用的提取方法是“双柱法”,即先用阳离子柱吸附,然后再用炭柱吸附。该方法不但周期长,工作量大,能耗高,而且提取收率低,一般只有60％左右,使我国肌苷的生产成本大大提高。因此,寻求新的提取方法,降低生产成本,是肌苷生产厂家及有关科技人员所共同关注的问题。肌苷发酵液的除菌体就是新法提取的步骤之一,它可以省去阳离子吸附柱,直接采用炭柱吸附,采用此法可使提取周期大大缩短,降低能耗,提高提取收率。 肌苷菌体较难清除,本研究采用能耗低、易操作,工作量小的絮凝方法,所用的絮凝剂为天然无毒物质,因此沉淀菌体可用作饲料蛋白,起到一举两得的作用。     

Denitrification and Ammonia Formation in Anaerobic Coastal Sediments

Simultaneous determinations of nitrogen gas production, ammonia, and particulate organic nitrogen formation in the coastal sediments of Mangoku-Ura, Simoda Bay, and Tokyo Bay were made by using the ¹⁵N-label tracer method. The rate of nitrogen gas production in the sediment surface layer was about 10⁻² μg atom of N per g per h, irrespective of the location of the sediments examined. [¹⁵N]ammonia and -particulate organic nitrogen accounted for 20 to 70% of the three products, and after several hours of incubation, the major fraction of nondenitrified ¹⁵N in Mangoku-Ura and Simoda Bay sediments was recovered as ammonia. In Tokyo Bay sediments, particulate organic nitrogen was produced at a greater rate than was ammonia. The reduction rate data suggest that the pathway of nitrate reduction to ammonia is important in coastal sediments.     

厌氧发酵产氢微生物的研究进展

厌氧发酵法生物制氢在国内外受到了普遍关注, 对产氢起核心作用的微生物又成为了研究的重点课题。论述了厌氧发酵产氢微生物的研究进展, 分别对厌氧产氢细菌的发酵类型、产氢能力、菌种选育、基因改良等进行了介绍, 结合国内外研究现状, 对厌氧发酵产氢微生物研究目前存在的问题进行了总结和展望。     

玉米芯发酵法生物制氢

在批式培养试验中, 以牛粪堆肥为天然产氢菌源, 玉米芯为底物, 通过厌氧发酵生产氢气。系统考察了底物预处理条件、初始pH值和底物浓度对玉米芯产氢能力的影响。在初始pH 8.0, 1.0%盐酸预处理底物30 min, 底物浓度10 g/L的最佳产氢条件下, 玉米芯最大产氢能力〔每克TVS（总挥发性固体物）产氢量〕和最大产氢速率（每克TVS每小时产氢量）分别为107.9 mL /g、4.20 mL/g·h-1。玉米芯经酸预处理后半纤维素含量由42.2%下降至3.0%, 而酸预处理的玉米芯产氢前后纤维素、半纤维素和木质素含量只有少量变化。产氢菌主要用酸预处理产生的可溶性糖产氢, 故底物的酸预处理对玉米芯的发酵产氢非常重要。用傅里叶变换红外光谱(FTIR)分析显示酸预处理和产氢过程中玉米芯的特征峰发生变化, 酸预处理过程降解了底物纤维素的无定形区和半纤维素, 产氢微生物对纤维素的结晶区有破坏作用。     

厌氧发酵产氢微生物的研究进展

厌氧发酵法生物制氢在国内外受到了普遍关注, 对产氢起核心作用的微生物又成为了研究的重点课题。论述了厌氧发酵产氢微生物的研究进展, 分别对厌氧产氢细菌的发酵类型、产氢能力、菌种选育、基因改良等进行了介绍, 结合国内外研究现状, 对厌氧发酵产氢微生物研究目前存在的问题进行了总结和展望。     

Two Pathways of Glutamate Fermentation by Anaerobic Bacteria

Two pathways are involved in the fermentation of glutamate to acetate, butyrate, carbon dioxide, and ammonia-the methylaspartate and the hydroxyglutarate pathways which are used by Clostridium tetanomorphum and Peptococcus aerogenes, respectively. Although these pathways give rise to the same products, they are easily distinguished by different labeling patterns of the butyrate when [4-(14)C]glutamate is used as substrate. Schmidt degradation of the radioactive butyrate from C. tetanomorphum yielded equally labeled propionate and carbon dioxide, whereas nearly all the radioactivity of the butyrate from P. aerogenes was recovered in the corresponding propionate. This procedure was used as a test for the pathway of glutamate fermentation by 15 strains (9 species) of anaerobic bacteria. The labeling patterns of the butyrate indicate that glutamate is fermented via the methylaspartate pathway by C. tetani, C. cochlearium, and C. saccarobutyricum, and via the hydroxyglutarate pathway by Acidaminococcus fermentans, C. microsporum, Fusobacterium nucleatum, and F. fusiformis. Enzymes specific for each pathway were assayed in crude extracts of the above organisms. 3-Methylaspartase was found only in clostridia which use the methylaspartate pathway, including Clostridium SB4 and C. sticklandii, which probably degrade glutamate to acetate and carbon dioxide by using a second amino acid as hydrogen acceptor. High levels of 2-hydroxyglutarate dehydrogenase were found exclusively in organisms that use the hydroxyglutarate pathway. The data indicate that only two pathways are involved in the fermentation of glutamate by the bacteria analyzed. The methylaspartate pathway appears to be used only by species of Clostridium, whereas the hydroxyglutarate pathway is used by representatives of several genera.     

玉米芯发酵法生物制氢

在批式培养试验中, 以牛粪堆肥为天然产氢菌源, 玉米芯为底物, 通过厌氧发酵生产氢气。系统考察了底物预处理条件、初始pH值和底物浓度对玉米芯产氢能力的影响。在初始pH 8.0, 1.0%盐酸预处理底物30 min, 底物浓度10 g/L的最佳产氢条件下, 玉米芯最大产氢能力〔每克TVS（总挥发性固体物）产氢量〕和最大产氢速率（每克TVS每小时产氢量）分别为107.9 mL /g、4.20 mL/g·h-1。玉米芯经酸预处理后半纤维素含量由42.2%下降至3.0%, 而酸预处理的玉米芯产氢前后纤维素、半纤维素和木质素含量只有少量变化。产氢菌主要用酸预处理产生的可溶性糖产氢, 故底物的酸预处理对玉米芯的发酵产氢非常重要。用傅里叶变换红外光谱(FTIR)分析显示酸预处理和产氢过程中玉米芯的特征峰发生变化, 酸预处理过程降解了底物纤维素的无定形区和半纤维素, 产氢微生物对纤维素的结晶区有破坏作用。     

Anaerobic Growth of Corynebacterium glutamicum via Mixed-Acid Fermentation

Corynebacterium glutamicum, a model organism in microbial biotechnology, is known to metabolize glucose under oxygen-deprived conditions to l-lactate, succinate, and acetate without significant growth. This property is exploited for efficient production of lactate and succinate. Our detailed analysis revealed that marginal growth takes place under anaerobic conditions with glucose, fructose, sucrose, or ribose as a carbon and energy source but not with gluconate, pyruvate, lactate, propionate, or acetate. Supplementation of glucose minimal medium with tryptone strongly enhanced growth up to a final optical density at 600 nm (OD₆₀₀) of 12, whereas tryptone alone did not allow growth. Amino acids with a high ATP demand for biosynthesis and amino acids of the glutamate family were particularly important for growth stimulation, indicating ATP limitation and a restricted carbon flux into the oxidative tricarboxylic acid cycle toward 2-oxoglutarate. Anaerobic cultivation in a bioreactor with constant nitrogen flushing disclosed that CO₂ is required to achieve maximal growth and that the pH tolerance is reduced compared to that under aerobic conditions, reflecting a decreased capability for pH homeostasis. Continued growth under anaerobic conditions indicated the absence of an oxygen-requiring reaction that is essential for biomass formation. The results provide an improved understanding of the physiology of C. glutamicum under anaerobic conditions.