Effect of natural zeolite on methane production for anaerobic digestion of ammonium rich organic sludge

The effect of an inorganic additive on the methane production from NH(4+)-rich organic sludge during anaerobic digestion was investigated using different kinds of inorganic adsorbent zeolites (mordenite, clinoptilolite, zeolite 3A, zeolite 4A), clay mineral (vermiculite), and manganese oxides (hollandite, birnessite). The additions of inorganic materials resulted in significant NH4+ removals from the natural organic sludge ([NH4+]=1, 150 mg N/l), except for the H-type zeolite 3A and birnessite. However, an enhanced methane production was only achieved using natural mordenite. Natural mordenite also enhanced the methane production from the sludge with a markedly high NH4+ concentration (4500 mg N/l) during anaerobic digestion. Chemical analyses of the sludge after the digestion showed considerable increases in the Ca2+ and Mg2+ concentrations in the presence of natural mordenite, but not with synthetic zeolite 3A. The effect of Ca2+ or Mg2+ addition on the methane production was studied using Na(+)-exchanges mordenite and Ca2+ or Mg(2+)-enriched sludge. The simultaneous addition of Ca2+ ions and Na(+)-exchanged mordenite enhanced the methane production; the amount of produced methane was about three times greater than that using only the Na(+)-exchanged mordenite. In addition, comparing the methane production by the addition of natural mordenite or Ca2+ ions, the methane production with natural mordenite was about 1.7 times higher than that with only Ca2+ ions. The addition of 5% and 10% natural mordenite were suitable condition for obtaining a high methane production. These results indicated that the Ca2+ ions, which are released from natural mordenite by a Ca2+/NH4+ exchange, enhanced the methane production of the organic waste at a high NH4+ concentration. Natural mordenite has a synergistic effect on the Ca2+ supply as well on the NH4+ removal during anaerobic digestion, which is effective for the mitigation of NH4+ inhibition against methane production.     

Enhanced Methane Production from Anaerobic Digestion of Disintegrated and Deproteinized Excess Sludge

To improve biogas yield and methane content in anaerobic digestion of excess sludge from the wastewater treatment plant, the sludge was disintegrated by using various methods (sonication, alkaline and thermal treatments). Since disintegrated sludge contains a high concentration of soluble proteins, the resulting metabolite, ammonia, may inhibit methane generation. Therefore, the effects of protein removal from disintegrated sludge on methane production were also studied. As a result, an obvious enhancement of biogas generation was observed by digesting disintegrated sludge (biogas yield increased from 15 to 36 ml/g COD_added·day for the raw excess sludge and the sonicated sludge, respectively). The quality of biogas was also improved by removing proteins from the disintegrated sludge. About 50% (w/w) of soluble proteins were removed from the suspension of disintegrated sludge by salting out using 35 g MgCl₂·6H₂O/l and also by isoelectric point precipitation at pH 3.3. For deproteinized sludge, methane production increased by 19%, and its yield increased from 145 ml/g COD_removed to 325 ml/g COD_removed. Therefore, the yield and quality of biogas produced from digestion of excess sludge can be enhanced by disintegrating the sludge and subsequent protein removal. Revisions requested 14 November 2005; Revisions received 13 January 2006     

Ultrasonic sludge disintegration for enhanced methane production in anaerobic digestion: effects of sludge hydrolysis efficiency and hydraulic retention time

Hydrolysis of waste activated sludge (WAS) has been regarded as the rate limiting step of anaerobic sludge digestion. Therefore, in this study, the effect of ultrasound and hydraulic residence time during sludge hydrolysis was investigated with the goal of enhancing methane production from anaerobic digestion (AD). WAS was ultrasonically disintegrated for hydrolysis, and it was semi-continuously fed to an anaerobic digesters at various hydraulic retention times (HRTs). The results of these experiments showed that the solids and chemical oxygen demand (COD) removal efficiencies when using ultrasonically disintegrated sludge were higher during AD than the control sludge. The longer the HRT, the higher the removal efficiencies of solids and COD, while methane production increased with lower HRT. Sludge with 30% hydrolysis produced 7 × more methane production than the control sludge. The highest methane yields were 0.350 m(3)/kg volatile solids (VS)(add) and 0.301 m(3)/kg COD(con) for 16 and 30% hydrolyzed sludge, respectively. In addition, we found that excess ultrasound irradiation may inhibit AD since the 50% hydrolyzed sludge produced lower methane yields than 16 and 30% hydrolyzed sludge.     

Enhancing post anaerobic digestion of full-scale anaerobically digested sludge using free nitrous acid treatment

In some wastewater treatment plants (WWTPs), the ever increasing production of sludge with the expanding population overloaded the anaerobic digestion which compromises the sludge reduction efficiency. Post anaerobic digestion of anaerobically digested sludge (ADS) has been applied to enhance sludge reduction, however, to a very limited extent. This study verified the effectiveness of free nitrous acid (FNA i.e. HNO₂) pre-treatment on enhancing full-scale ADS degradation in post anaerobic digestion. The ADS collected from a full-scale WWTP was subject to FNA treatment at concentrations of 0.77, 1.54, 2.31, 3.08, and 3.85 mg N/L for 24 h followed by biochemical methane potential tests. The FNA treatment at all concentrations resulted in an increase (from 1.5–3.1 % compared to the control) in sludge reduction with the highest improvement achieved at 0.77 mg HNO₂-N/L. The FNA treatment at this concentration also resulted in the highest increase in methane production (40 %) compared to the control. The economic analysis indicates that FNA treatment is economically attractive for enhancing post anaerobic digestion of full-scale ADS.     

Enhancement on biodegradation and anaerobic digestion efficiency of activated sludge using a dual irradiation process

A dual irradiation process involving aerobic thermophilic irradiation pretreatment (ATIP) and intermittent irradiation anaerobic digestion was developed to improve the digestion of waste-activated sludge. First, the effect of ATIP on further anaerobic digestion of activated sludge in batch mode was investigated. When exposed to ATIP for 24 h, the digestion reactor gave the highest methane yield, removed the most dissolved organic carbon (DOC) and showed the most effective reduction of VS compared to other irradiation times. This process was further enhanced by using an anaerobic fluidised-bed reactor packed with carbon felt in semi-continuous mode for digesting the pretreated activated sludge under intermittent irradiation conditions. Dual irradiation for 24 h followed by 60 min of anaerobic irradiation processing per day turned out to be optimal. This resulted in 65.3% of VS reduction, 83.9% of DOC removal ratio and 538 ml/g-VS of methane yield.     

Pretreatment of municipal waste activated sludge for volatile sulfur compounds control in anaerobic digestion

The effect of combination of mechanical and chemical pretreatment of municipal waste activated sludge (WAS) prior to anaerobic digestion was studied using a laboratory scale system with an objective to decrease volatile sulfur compounds in biogas and digested sludge. Mechanical pretreatment was conducted using depressurization of WAS through a valve from a batch pretreatment reactor pressurized at 75 ± 1 psi, while combined pretreatments were conducted using six different dosages of hydrogen peroxide (H₂O₂) and ferrous chloride (FeCl₂) along with mechanical pretreatment. About 37-46% removal of H₂S in biogas occurred for different combined pretreatment conditions. Sludge solubilization achieved due to the mechanical pretreatment increased total cumulative methane production by 8-10% after 30 days during the biochemical methane potential (BMP) test. The pretreatment also improved dewaterability in terms of time to filter (TTF), and decreased methyl mercaptan generation potential of the digested sludge.     

Petroleum coke supplementation for enhanced biogas production and phosphate removal under mesophilic conditions

The use of carbon-based conductive materials has been shown to lead to an increase in biogas and methane yields during anaerobic digestion (AD). The effect of these additives on AD using synthetic substrates has been extensively studied, yet their significance for wastewater sludge digestion has not been adequately investigated. Therefore, the aim of this research was to optimize the concentration of petroleum coke (PC) that is a waste by-product of oil refineries, for the anaerobic digestion of wastewater sludge and investigation of phosphate removal in the AD process in the mesophilic temperature range. According to the results of the experiments, supplementing reactors with PC could significantly improve biogas and methane production. Supplementation of reactors with 1.5 g/L PC led to 23.40 ± 0.26% and 42.55 ± 3.97% increase in biogas production and methane generation, respectively. Moreover, the average volatile solids (VS), phosphate, and chemical oxygen demand (COD) removals were 43.43 ± 0.73, 46.74 ± 0.77%, and 60.40 ± 0.38%, respectively.     

Thermophilic anaerobic digestion of high strength wastewaters

Investigations on the thermophilic anaerobic treatment of high-strength wastewaters (14-65 kg COD/m(3)) are presented. Vinasse, the wastewater of alcohol distilleries, was used as an example of such wastewaters. Semicontinuously fed digestion experiments at high retention times revealed that the effluent quality of digestion at 55 degrees C is comparable with that at 30 degrees C at similar loading rates. The amount of methane formed per kilogram of vinasse drops almost linearly with increasing vinasse concentrations. This can be attributed to increasing concentrations of inhibitory compounds, resulting in increasing volatile fatty acid (VFA) concentrations in the effluent. The treatment of vinasse was also investigated using upflow anaerobic sludge blanket (UASB) reactors. Thermophilic granular sludge, cultivated on sucrose, was used as seed material. The sludge required a 4-month adaptation period, during which the size of the sludge granules decreased significantly. However, the settling characteristics remained satisfactory. After adaptation, high loading and methane generation rates could be accommodated at satisfactory treatment efficiencies, namely, 86.4 kg COD/m(3) day and 26 m(3) CH(4)(STP)/m(3) day, respectively. As in the semicontinuously fed digesters, the effluent VFA concentrations were virtually independent of the loading rates applied, indicating that the toxicity of the vinasse is more important than the loading rate in determining the efficiency of the conversion of vinasse to methane.     

Selective desorption of carbon dioxide from sewage sludge for in situ methane enrichment--part I: pilot-plant experiments

In situ methane enrichment in anaerobic digestion of sewage sludge has been investigated by experiments and by modeling. In this first part, the experimental work on the desorption of carbon dioxide and methane from sewage sludge is reported. The bubble column, had a diameter of 0.3 m and a variable height up to 1.8 m. At operation the dispersion height in the column was between 1 and 1.3 m. Outdoor air was used. The column was placed close to a full-scale sewage sludge digester, at a municipal wastewater treatment plant. The digester was operated at mesophilic conditions with a hydraulic retention time of about 20 days. The bubble column was operated to steady-state, at which carbon dioxide concentration and alkalinity were determined on the liquid side, and the concentration of carbon dioxide and methane on the gas side. Thirty-eight experiments were performed at various liquid and gas flow rates. The experimental results show that the desorption rates achieved for carbon dioxide ranges from 0.07 to 0.25 m(3) CO(2)/m(3) sludge per day, which is comparable to the rate of generation by the anaerobic digestion. With increasing liquid flow rate and decreasing gas flow rate the amount of methane desorbed per amount of carbon dioxide desorbed increases. The lowest methane loss achieved is approximately 2% of the estimated methane production in the digestion process.     

Stability and inhibition of anaerobic processes caused by insufficiency or excess of ammonia nitrogen

Ammonia increases buffer capacity of methanogenic medium in mesophilic anaerobic reactor thus increasing the stability of anaerobic digestion process. Optimal ammonia concentration ensures sufficient buffer capacity while not inhibiting the process. It was found out in this paper that this optimum depends on the quality of anaerobic sludge under investigation. The optimal concentrations for methanogens were 2.1, 2.6 and 3.1 g/L of ammonia nitrogen in dependence on inoculum origin. High ammonia nitrogen concentration (4.0 g/L) inhibited methane production, while low ammonia nitrogen concentration (0.5 g/L) caused low methane yield, loss of biomass (as VSS) and loss of the aceticlastic methanogenic activity. It was found out that negative effect of low ammonia nitrogen concentration on biomass is caused not only by low buffer capacity but also by insufficiency of nitrogen as nutrient. It was also found out that anaerobic sludge with higher ammonia nitrogen concentration (4.2 g/L) tolerates even concentration of volatile fatty acids (160 mmol/L) which causes inhibition of the process with low ammonia nitrogen concentration (0.2 g/L).     

Improved performance of anaerobic digestion ofSpirulina maxima algal biomass by addition of carbon-rich wastes

Mixtures of carbon-rich wastes andS. maxima algal biomass increase markedly the performance of anaerobic digestion. A mixture of 507 sewage sludge and algae increases the methane yield and the productivity over twofold. Peat hydrolyzate and sewage sludge, when added to algae, have shown a synergistic effect and spent sulfite liquor added at concentrations over 307 V/V has inhibited methanogenic activity.     

添加厨余垃圾对剩余污泥厌氧消化产沼气过程的影响

为提高剩余污泥厌氧消化的沼气产量和甲烷含量,研究了厨余垃圾的不同添加量对剩余污泥厌氧消化性能的影响。结果表明,在35℃下,随着剩余污泥中厨余垃圾添加量的增加,厌氧消化系统中碳氮质量比（C／N）、胞外多聚物（EPS）等生理生化指标均有不同程度的改善。其中当剩余污泥与厨余垃圾质量比为2：1时,混合有机废弃物中沼气产量和甲烷含量均达到最大值,每克挥发性固体（VS）产生了156．56mL沼气,甲烷体积分数为67．52％,分别比剩余污泥单独厌氧消化时的产气量提高了5倍和1．5倍。     

The use of ultrasound and gamma-irradiation as pre-treatments for the anaerobic digestion of waste activated sludge at mesophilic and thermophilic temperatures

The effect of ultrasound and gamma-irradiation used as pre-treatments for the anaerobic digestion of waste activated sludge at both mesophilic and thermophilic temperatures was examined. Untreated activated sludge was also subjected to anaerobic digestion at these temperatures as a control. The sonication time was 90 s using a Soniprep 150 (MSE Scientific Instruments) which operated at 23 kHz and had been adjusted to give an output of 47 W and the gamma-irradiation dose was 500 krad. The digesters were operated in a semi-continuous mode, being fed with fresh sludge every 24 h at hydraulic retention times (HRT) of 8, 10 and 12 days. Over the 24 h period the differences between the digesters, in terms of volatile solids (VS) reductions and biogas production, were not statistically significant for any particular set of conditions. Thermophilic digestion performed better than mesophilic digestion in terms of biogas production, VS reductions (except at HRT of 8 days) and specific methane yields and the optimum retention time was 10 days, at both temperatures. When gas production over the initial eight hours (probably the hydrolytic stage) was examined, it was found that the gas production rates for pre-treated sludges were higher than those for untreated sludges. This was most pronounced at thermophilic temperatures and a HRT of 10 days. Sonication did not affect the numbers of faecal coliforms in the sludge. However, gamma-radiation caused a 3-log reduction and, when coupled with mesophilic digestion, gave a product which contained < 100 g(-1) TS. Thermophilic anaerobic digestion produced sludges which contained < 1 g(-1) TS irrespective of any pre-treatment.     

Psychrophilic methane fermentation of excess sludge by enrichment culture

This study was carried out to determine the possibility of the psychrophilic methane fermentation of the excess sludge produced from fish-processing wastewater treatment. Three different kinds of seed sludge, named M seed sludge, K seed sludge and KL seed sludge were used for batch methane fermentation in Erlenmeyer flasks. M seed sludge was mesophilic, while the other two were prepared in our laboratory by soil collection to obtain a psychrophilic biological community. The effects of temperature on the total volume of biogas generated and on the rate of biogas generation were examined. The activity of K seen sludge with respect to gas yield at 15°C was found to be 1.6-fold higher than that of M seed sludge. Enrichment techniques were then used to accumulate psychrophilic bacteria in KL seed sludge, and the activity at 15°C increased by about two times due to these techniques. Comparison of the three kinds of seed sludge indicates that methane fermentation at low temperature may be feasible, and therefore further study to isolate the psychrophilic bacteria in anaerobic digestion is needed.     

Stable performance of anaerobic digestion in the presence of a high concentration of propionic acid

An automatically controlled, glucose-fed, anaerobic digester was deliberately inhibited by addition of phenol. To overcome the phenol inhibition the feed dilution rate was lowered in such a way that the methane yield from glucose was kept the same as that under normal conditions. The concentrations of acetic and butyric acids remained below 100 mg/l, however, propionic acid accumulated to 2,750 mg/l. Phenol apparently inhibited all tropic groups of organisms and it was shown that the propionic acid was formed from the metabolism of phenol. From the nature of the operating strategy, it was deduced that the digester continued to convert all the glucose that was supplied to methane showing that propionic acid accumulation did not inhibit conversion of glucose to methane. Therefore, propionic acid accumulation may be an effect and not a cause of inhibition of the anaerobic digestion process.     

Enhancement of biochemical methane potential from excess sludge with low organic content by mild thermal pretreatment

Excess sludge with low organic content always led to the failure of anaerobic digestion for methane production. Recently, the mild thermal pretreatment, which is usually operated at temperatures below 120 °C, has drawn much attention due to less energy consumption and no chemical addition. In this study the effect of mild thermal pretreatment (50–120 °C) on the solubilization and methane potential of excess sludge with a low concentration of organic matters was investigated. Experimental results showed that the concentration of soluble organic matters increased gradually with temperature during the mild thermal pretreatment of excess sludge. Biochemical methane potential experiments demonstrated that the potential of methane production from excess sludge was greatly enhanced by mild thermal pretreatment, and under the conditions of pretreatment temperature 100 °C and digestion time 20 d the methane yield was as high as 142.6 ± 2.5 mL/g of volatile solids. Mechanism investigation on the enhancement of methane production from excess sludge exhibited that the consumptions of sludge protein and carbohydrate, the adenosine 5′-triphosphate content of anaerobic microorganisms, the activities of key enzymes related to anaerobic digestion, and the amount of methanogens were all improved by mild thermal pretreatment, in correspondence with the production of methane.     

Influence of hydraulic retention time on anaerobic digestion of pretreated sludge

Continuous anaerobic digestion of waste activated sludge pretreated at low temperatures below 100°C increased methane generation by 30%. pH values of the digestion mixture increased, approximately from 0.3 to 0.55 by pretreatment, although its volatile fatty acids concentration was greater than the control. An abrupt increase in propionate : acetate ratio in digestion stage (e.g. from less than 1:1 to over 3.5 :1), provided a reliable indicator for impending failure.This revised version was published online in October 2005 with corrections to the Cover Date.     

明胶/纳米SiO2复合膜的体外抑菌试验

本实验测定了明胶、纳米SiO2、明胶/纳米SiO2复合膜对6种供试菌的抑菌效果,结果表明,明胶不具有抑菌作用;纳米SiO2对供试菌具有较好的抑茵效果;20种明胶/纳米SiO2复合膜材料中,有11种复合膜对供试菌具有较强的抑菌效果.用琼脂平板稀释法测定了具有较强抑菌作用复合膜的最低抑菌浓度(MIC),结果表明,最低抑菌浓度因膜的配比和菌种类型的不同而有所差异,为16.0 mg/mL～256.0 mg/mL.复合膜对蜡样芽孢杆菌的最低抑菌浓度(MIC)最大(256.0 mg/mL),而对其他供试菌相对较低,为64.0 mg/mL～128.0 mg/mL.     

Ebselen suppresses late airway responses and airway inflammation in guinea pigs

Although ebselen, a seleno-organic compound, inhibits inflammation in various animal models, its efficacy as an anti-asthma drug remains to be clarified. In this study, we investigated the inhibitory effect of ebselen on a guinea pig asthma model. Ebselen was orally administered at dosages of 1-20 mg/kg 2 h before an ovalbumin (OA) challenge, and then airway responses, airway inflammation, the generation of superoxide, H(2)O(2), and nitrotyrosine, and the induction of inducible nitric oxide synthase (iNOS) were evaluated. Sensitized animals challenged with OA aerosol showed dual airflow limitations, i.e., immediate and late airway responses (IAR and LAR). Ebselen significantly inhibited LAR at dosages greater than 10 mg/kg, but did not inhibit IAR at any dosage. Bronchoalveolar lavage (BAL) examination showed that airway inflammation was significantly suppressed by ebselen at 10 mg/kg. The generation of superoxide and H(2)O(2) occurred on endothelial cells of LAR bronchi, and was inhibited by 10 mg/kg of ebselen. Superoxide generation was inhibited by diphenyleneiodonium chloride (DPI), a NAD(P)H oxidase inhibitor, but not by allopurinol, a xanthine oxidase inhibitor. Immunoreactivities for iNOS and nitrotyrosine were also observed on endothelial cells of LAR bronchi and were abolished in ebselen-treated animals. The present findings suggest that ebselen can be applied as a new therapeutic agent for asthma. The possible mechanisms by which ebselen inhibits LAR likely involve suppression of oxidant formation and iNOS induction in endothelial cells.     

Anaerobic waste-activated sludge digestion-a bioconversion mechanism and kinetic model

The anaerobic bioconversion of raw and mechanically lysed waste-activated sludge was kinetically investigated. The hydrolysis of the biopolymers, such as protein, which leaked out from the biological sludge with ultrasonic lysis, was a first-order reaction in anaerobic digestion and the rate constant was much higher that the decay rate constant of the raw waste activated sludge. An anaerobic digestion model that is capable of evaluating the effect of the mechanical sludge lysis on digestive performance was developed. The present model includes four major biological processes-the release of intracellular matter with sludge lysis; hydrolysis of biopolymers to volatile acids; the degradation of various volatile acids to acetate; and the conversion of acetate and hydrogen to methane. Each process was assumed to follow first order kinetics. The model suggested that when the lysed waste-activated sludge was fed, the overall digestive performance remarkably increased in the two-phase system consisting of an acid forming process and a methanogenic process, which ensured the symbiotic growth of acetogenic and methanogenic bacteria. (c) 1993 Wiley & Sons, Inc.