Radiation biology and inherited sterility of light brown apple moth (Lepidoptera: Tortricidae): developing a sterile insect release program

The radiation biology of two geographically isolated populations of the light brown apple moth [Epiphyas postvittana (Walker)] was studied in Australia and New Zealand as an initiation of a SIT/F1 sterility program. Pharate and < or = 2 d pre-emergence pupae were exposed to increasing radiation doses up to a maximum dose of 300 Gy. Fertility and other life history parameters were measured in emerging adults (parental) and their progeny (F1-F3 adults). Parental fecundity was significantly affected by increasing irradiation dose in pharate pupae only. For both populations, parental egg fertility declined with increasing radiation. This was most pronounced for the irradiated parental females whose fertility declined at a higher rate than of irradiated males. At 250 Gy, females < or = 2 d preemergence pupae produced few larvae and no adults at F1. No larvae hatched from 250 Gy-irradiated female pharate pupae. At 300 Gy, males still had residual fertility of 2-5.5%, with pharate pupae being the more radio-sensitive. Radiation-induced deleterious inherited effects in offspring from irradiated males were expressed as increased developmental time in F1 larvae, a reduction in percent F1 female survival, decreased adult emergence and increased cumulative mortality over subsequent generations. Males irradiated at > or = 150 Gy produced few but highly sterile offspring at F1 and mortality was > 99% by F2 egg.     

Attractiveness and competitiveness of irradiated light brown apple moths

The sterile insect technique (SIT) potentially provides a socially acceptable approach for insect eradication of new pest incursions. The light brown apple moth, Epiphyas postvittana (Walker) (Lepidoptera: Tortricidae), was discovered in Berkeley (CA, USA) in 2006, leading to an incursion response that included this technology. In this study, we assessed factors affecting mating success from a bisex release of irradiated moths: effects of radiation dose on male multiple mating, male flight competition, female sex pheromone titre and attractiveness of irradiated females to males, and identification of successful mating in vineyards of either irradiated or wild males (identified by isotope analysis of spermatophores from sentinel females). There was a significant negative relationship between male radiation dose and mating frequency. In head‐to‐head flights of irradiated males against non‐irradiated males to a pheromone lure in a wind tunnel, irradiated males reached the lure first only 31% of the time. With increasing radiation dose, the production of the major sex pheromone component in females, (E)‐11‐tetradecenyl acetate, dropped, from 0.7 ± 0.1 ng per female in non‐irradiated females to 0.2 ± 0.07 ng per female when irradiated at 300 Gy. Male catch was reduced to 11% of control females in traps containing females irradiated at 300 Gy. Isotope analysis of spermatophores found in the bursa copulatrix of females indicated that mating success of irradiated males inside the live (entry‐only) traps containing virgin females was lower (13.1 ± 3.3%) than suggested by male catch (21.2 ± 3.8%) in pheromone traps, the current standard for assessing field competitiveness. Impacts of irradiation on male and female moth fitness should be taken into account to improve estimates of irradiated to wild male E. postvittana overflooding ratios needed for population suppression.     

Gamma irradiation as a quarantine treatment for apples infested by codling moth (Lep., Tortricidae)

Abstract: Effects of gamma radiation on the fifth instar codling moth, Cydia pomonella (L.), larvae were examined. Mature larvae were exposed to a series of gamma radiation doses ranging from 50 to 250 Gy and survival to pupae and adults was examined. The results showed that pupation and adult emergence decreased with increasing radiation dose. The results also showed that diapausing larvae were more sensitive to irradiation treatment than non-diapausing larvae, and females were more sensitive than males. A dose of 150 Gy reduced adult emergence to less than 2% in non-diapausing larvae, while a dose of 200 Gy completely prevented it. Furthermore, none of the emerging moths exposed to a dose of 150 Gy were females; at 100 Gy dose, the percentage of females was less than 14%. Irradiating larvae in apple fruit in a small-scale laboratory experiment produced similar results. Tests in which >100 000 larvae (in the fifth instar) were irradiated in an artificial rearing medium with a dose of 200 Gy resulted in no adult emergence. Similar results were also obtained when >32 000 larvae in the same stage were exposed in apple fruit to the same dose. The results indicate that the use of ionizing radiation as a quarantine treatment for codling moth infested fruits is feasible and requires a relatively low dose.     

Comparative fitness of irradiated light brown apple moths (Lepidoptera: Tortricidae) in a wind tunnel, hedgerow, and vineyard

Light brown apple moth, Epiphyas postvittana (Walker) (Lepidoptera: Tortricidae), is the target of the sterile insect technique, but reduced moth fitness from irradiation lowers the effective overflooding ratio of sterile to wild moths. New measures of insect quality are being sought to improve field performance of irradiated insects, thus improving the cost effectiveness of this technique. Male pupae were irradiated at intervals between 0 and 300 Gy, and adult flight success was assessed in a wind tunnel equipped with flight track recording software. A dose response was evident with reduced successful search behaviors at higher irradiation doses. Irradiation at 250 Gy reduced arrival success to 49% of untreated controls, during 2-min assays. Mark-release-recapture of males irradiated at 250 Gy indicated reduced male moth recapture in hedgerows (75% of control values of 7.22% +/- 1.20 [SEM] males recaptured) and in vineyards (78% of control values 10.5% +/- 1.66% [SEM] recaptured). Males dispersed similar distances in both habitats, and overflooding ratios dropped off rapidly from the release point in both landscapes. Transects of traps with central releases proved to be an efficient method for measuring the quality of released males. Relative field performance of moths was greater than suggested by wind tunnel performance, which could be due to time differences between the two assays, two-minute wind tunnel tests compared with days in the field treatments. Release strategies involving ground releases should consider the effect of limited postrelease dispersal. Aerial release could solve this problem and warrants investigation.     

Irradiation of Anastrepha obliqua (Diptera: Tephritidae) revisited: optimizing sterility induction

The effects of irradiation doses increasing from 0 to 100 Gy (1 Gy is energy absorbed in J kg(-1) of irradiated material) on fertility, flight ability, survival, and sterile male mating performance were evaluated for mass-reared Anastrepha obliqua (Macquart). High sterility values (> 98.2%) for irradiated males were obtained for doses as low as 25 Gy. Egg hatch was inhibited for irradiated males crossed with irradiated females at a low dose of 20 Gy. However, we estimated that to achieve 99.9% sterility (standard goal of many sterile insect technique programs), irradiation doses had to be increased to a dose between 50 and 75 Gy. At doses of 25 Gy and greater, we observed a decreasing trend in adult flight ability and an increasing trend in adult mortality. Such differences were greater for pupae irradiated at a young age compared those irradiated 24 h before emergence. Our single most relevant finding was that sterility induction (i.e., oviposition of nonfertilized eggs) was two times greater for males irradiated at low doses (40 Gy) than for males irradiated at high doses (80 Gy) when used at a 3:1:1 sterilized male to fertile male to fertile female ratio. Males irradiated at high doses may have been outcompeted by unirradiated males when courting unirradiated females. Implications of our findings for sterile insect technique programs are discussed.     

Orientation of field populations ofBrachymeria intermedia [Hym.: Chalcididae], to host and host-habitat cues

Brachymeria intermedia (Nees), a pupal parasitoid of the gypsy moth, was caught in the field using plexiglas traps coated with Tangletrap (2). Significantly greater numbers of females were collected in traps baited with gypsy moth pupae than in traps with male or femaleB. intermedia or traps painted yellow.B. intermedia collected in traps during the first 3 weeks of native gypsy moth pupation were primarily female. A preponderance of males were caught during the fourth week. The hyperparasite,Brachymeria compsilurae (Cwfd) was also trapped in small numbers. Gypsy moth pupae were hung in interior and exterior areas of woodland sites. A greater number ofB. intermedia emerged from pupae in woodland edge sites than from pupae in interior woodland sites.     

Radiation biology and inherited sterility in false codling moth (Lepidoptera: Tortricidae)

False codling moth, Cryptophlebia leucotreta (Meyrick), male and female mature pupae and newly emerged adults were treated with increasing doses of gamma radiation and either inbred or out-crossed with fertile counterparts. For newly emerged adults, there was no significant relationship between dose of radiation and insect fecundity when untreated females were mated to treated males (N female by T male). However, fecundity of treated females mated to either untreated (T female by N male) or treated males (T female by T male) declined as the dose of radiation increased. A similar trend was observed when mature pupae were treated. The dose at which 100% sterility was achieved in treated females mated to untreated males (T female by N male) for both adults and pupae was 200 Gy. In contrast, newly emerged adult males treated with 350 Gy still had a residual fertility of 5.2% when mated to untreated females, and newly emerged adult males that were treated as pupae had a residual fertility of 3.3%. Inherited effects resulting from irradiation of parental (P1) males with selected doses of radiation were recorded for the F1 generation. Decreased F1 fecundity and fertility, increased F1 mortality during development, and a significant shift in the F1 sex ratio in favor of males was observed when increasing doses of radiation were applied to the P1 males.     

Effect of irradiation on Mexican leafroller (Lepidoptera: Tortricidae) development and reproduction

The effects of irradiation on egg, larval, and pupal development, and adult reproduction in Mexican leafroller, Amorbia emigratella Busck (Lepidoptera: Tortricidae), were examined. Eggs, neonates, early instars, late instars, early pupae, and late pupae were irradiated at target doses of 60, 90, 120, or 150 Gy, or they were left untreated as controls in replicated factorial experiments. Survival to the adult stage was recorded. Tolerance to radiation increased with increasing age and developmental stage. A radiation dose of 90 Gy applied to neonates and early instars prevented adult emergence. A dose of 150 Gy was not sufficient to prevent adult emergence in late instars or pupae. The effect of irradiation on sterility was examined in late pupae and adult moths. For progeny produced by insects treated as late pupae, a total of three out of 3,130 eggs hatched at 90 Gy, 0 out of 2,900 eggs hatched at 120 Gy, and 0 out of 1,700 eggs hatched at 150 Gy. From regression analysis, the dose predicted to prevent egg hatch from the progeny of irradiated late pupae was 120 Gy, with a 95% confidence interval of 101-149 Gy. The late pupa is the most radiotolerant stage likely to occur with exported commodities; therefore, a minimum absorbed radiation dose of 149 Gy (nominally 150 Gy) has potential as a quarantine treatment. Reciprocal crosses between irradiated and unirradiated moths demonstrated that males were more radiotolerant than females. Irradiation of female moths at a target dose of 90 Gy before pairing and mating with irradiated or unirradiated males resulted in no viable eggs, whereas irradiated males paired with unirradiated females produced viable eggs at 90 and 150 Gy.     

Effects of X‐ray irradiation on development and reproduction of the oriental tobacco budworm,Helicoverpa assulta (Lepidoptera: Noctuidae)

All stages of the life cycle of Helicoverpa assulta were irradiated with X‐rays to determine the inhibitory dose for development and reproduction to serve as a quarantine treatment. The 100‐Gy dose was effective for irradiation of eggs and larvae, and the 200‐Gy dose was effective for pupae and mixed‐sex adults. When either adult males or females were irradiated, however, 500 Gy was required to prevent the F1 eggs from hatching, and thus single‐sex adults required much higher doses of X‐ray irradiation. To gather confirmatory data applicable to phytosanitary quarantine regulations, pupae—the immature stage most resistant to X‐ray irradiation—were placed inside paprika in boxes for exportation and were irradiated with 300 Gy as a small‐scale confirmatory test. The dose given to 1,007 individual pupae resulted in 12.62 % survival, and 1.79 % of pupae emerged as normal adults; however, these adults produced only a few eggs that did not hatch, suggesting that a minimum dose of 300 Gy of X‐ray irradiation will provide quarantine security for immature H. assulta in paprika exports.     

Susceptibility of potato tuber moth (Lepidoptera: Gelechiidae) to postharvest gamma irradiation

Gamma irradiation doses applied to inhibit potato sprouting were tested against potato tuber moth larval and pupal stages. Young larvae and pupae were more susceptible to irradiation injuries than older ones. When larvae of different ages were exposed to doses > or = 100 Gy, only 13-35% pupated, but no adult emergence was obtained. The exposure of 1-1.5- or 3-3.5-d-old pupae to 150 Gy induced high level of sterility and remarkable reduction in female mating ability and fecundity, whereas the reduction was less noticeable for 5-5.5-d-old pupae. Postharvest gamma irradiation of potatoes could be considered as an efficient control approach against potato tuber moth larval and pupal infestations.     

Irradiation of adult Epiphyas postvittana (Lepidoptera: Tortricidae): egg sterility in parental and F1 generations

Adult Epiphyas postvittana Walker were irradiated using a Cobalt 60 source to determine the dose needed to achieve complete egg sterility of mated female moths, and egg sterility of female moths mated to F1 generation males. Adult male and female E. postvittana were irradiated at 100, 200, 250, and 300 Gy and their fertility (when crossed with normal moths) was compared with nonirradiated moths. Viable progeny (determined by egg hatch) were found at doses of 100 and 200 Gy, but very little at 250 and 300 Gy. In particular, there was no survival of female progeny into the F1 generation. Males irradiated at 250 and 300 Gy had very low egg eclosion rates (2.25 and 1.86% at 250 and 300 Gy, respectively) when mated with normal females. The F2 generation from those male progeny had a mean percent hatched of < 1.02%. Based on our results, a dose of 250-300 Gy is recommended for irradiation of E. postvittana adults used for sterile insect technique (SIT) if sterility of parental moths is the desired outcome. Our data also suggests that inclusion of F1 hybrid sterility rather than parental generation sterility into programs using the SIT may allow for doses lower than what we have reported, especially during initial phases of an eradication program where increase fitness of moths might be desirable. Further research is needed to verify the use of F1 hybrid sterility in light brown apple moth SIT programs.     

Effect of electron beam irradiation on developmental stages of Plutella xylostella (Lepidoptera: Plutellidae)

The effect of electron beam irradiation on each developmental stage of diamondback moth, Plutella xylostella L. (Lepidoptera: Plutellidae), was examined. Eggs, larvae, pupae, and adults were irradiated at target doses of 30, 50, or 100 Gy or they were left untreated as controls in replicated experiments. When eggs and pupae were irradiated with 100 Gy, emergence rates greatly decreased and, although some adults laid eggs, they did not hatch. Egg hatching of irradiated larvae and adult decreased with increasing irradiation doses. However, electron beam irradiation did not kill P. xylostella directly. Adult longevity was not affected. Reciprocal crosses between irradiated and unirradiated moths demonstrated that females were more radiosensitive than males in hatchability; however, the difference was not significant. In addition, electron beam-irradiated larvae showed typical DNA fragmentation in a dose-dependent manner compared with cells from unirradiated larvae. Our findings suggest that electron beam irradiation induces abnormal development and reproduction of P. xylostella; therefore, it may contribute to effective disinfestation and quarantine treatments of P. xylostella.     

Female‐targeted attractant containing pear ester for Synanthedon myopaeformis

When testing pear ester (ethyl‐2,4‐decadienoate) + acetic acid (PEAA) lures to catch codling moths, Cydia pomonella (L.) (Lepidoptera: Tortricidae), in Hungary, significant catches of the apple clearwing moth, Synanthedon myopaeformis (Borkhausen) (Lepidoptera: Sesiidae), were also recorded. This sesiid is one of the most important pests of apple in Europe. Pear ester plus acetic acid lures were attractive to S. myopaeformis no matter whether the two compounds were provided in separate dispensers or mixed together in a single dispenser, and a large percentage (40–80%) of the clearwing moths caught were females. In all cases, traps baited with binary combinations of PEAA caught far more than traps baited with either of the compounds presented alone. Traps with PEAA lures in some tests caught (females and males together) up to ca. 20% of the catch in traps baited with the synthetic apple clearwing moth sex attractant (all males). Consequently, the PEAA lure shows potential for future practical applications as a female‐targeted lure. To our knowledge, this is the first report of attractiveness of a lure containing pear ester for non‐tortricid Lepidoptera. Our finding suggests that the compound may be exploited as a host location stimulus by a wider array of insects than was indicated previously.     

Performance of irradiated Teia anartoides (Lepidoptera: Lymantriidae) in urban Auckland, New Zealand

The Australian moth Teia anartoides Walker has been the target of a major eradication program in Auckland, New Zealand. Information on cold torpor and dispersal was needed to help interpret catches of sterile and wild males in female-baited delta traps operated in a grid of up to 1,696 traps at 500-m spacings across the city. Laboratory experiments indicated male flight was enabled at temperatures above 17 degrees C (confirmed by field trapping of wild and recaptured moths). Male survival in the field or in field cages was determined to be limited to approximately 4 d. Sterilization of males for dispersal studies was achieved by exposing male pupae to either 160 or 100 Gy by using 1.25 MeV gamma rays from a Cobalt source, before release as fluorescent-dyed emerged adults. Dispersal was determined by recapture of males in the trapping grid of 1,696 delta traps baited with virgin female moths and placed at spacings of 50-500 m. Irradiated sterile males dispersed up to a maximum recorded distance of 4,500 m (160 Gy) and 10,000 m (100 Gy). At 100 Gy, the median dispersal distance was 300 m, with 90% of males dispersing 1,600 m or less.     

Is lack of mating competitiveness in spring linked to mating asynchrony between wild and mass‐reared codling moths from an operational sterile insect programme?

Mating competitiveness and pheromone trap catches of mass‐reared, male codling moth, Cydia pomonella (L.) (Lepidoptera: Tortricidae), from the Osoyoos, British Columbia, Canada, mass‐rearing facility operated by the Okanagan‐Kootenay Sterile Insect Release Board, were compared to wild males using mark–release–recapture field experiments in spring, summer, and autumn at Summerland, British Columbia. In spring, significantly more wild diapause males mated with tethered, wild females than did non‐irradiated (0 Gy) or irradiated (100 or 250 Gy) non‐diapause, mass‐reared males. A lower dose of radiation did not improve mating competitiveness, nor catches of mass‐reared males released in spring. Median mating time for wild males was approximately 45 min earlier than mass‐reared males with most wild males (70.5%) mating before sunset and mass‐reared males mating at or shortly after sunset in spring. Superior mating competitiveness of wild males in spring was mirrored by greater recapture rates in pheromone‐baited traps. In summer, mating competitiveness of mass‐reared moths improved relative to wild males and there was a significant inverse relationship between radiation dose (0, 100, and 250 Gy) and competitiveness of mass‐reared males. In autumn, untreated, wild males were significantly more responsive to pheromone traps than non‐diapausing mass‐reared males receiving 250 Gy of radiation. Mass‐reared males, subjected to diapause‐inducing conditions as larvae and emerged from diapause before this irradiation treatment, were recaptured significantly more often than similarly irradiated, non‐diapause, mass‐reared males, but not more than untreated, diapause wild males. We hypothesize that differences between wild and mass‐reared males in daily timing or speed of responses to natural or synthetic pheromone sources under montane weather patterns typical of spring in British Columbia may partially explain poor activity of sterile males, and low sterile : wild overflooding ratios during spring when measured using pheromone traps by the sterile insect release programme in British Columbia.     

Factors influencing the effectiveness of an attracticide formulation against the Oriental fruit moth, Grapholita molesta

An attracticide formulation, LastCall?OFM, was tested against the Oriental fruit moth Grapholita molesta (Busck) (Lepidoptera: Tortricidae) in replicated small plot field trials in apple, Malus domestica (Borkhausen), orchards in South‐eastern Pennsylvania, USA. Attracticide treatments were applied using a calibrated hand pump, and treated plots were compared to similar untreated plots. Male moth activity was monitored using virgin female‐baited traps, and the potential for reduction in mating activity was assessed using sentinel virgin females. A comparison of application rates showed that 1500 droplets per ha of the attracticide formulation was as effective as 3000 droplets per ha, and both application rates reduced captures in synthetic pheromone‐baited traps for prolonged periods. Droplets placed either at high or low positions within the canopy significantly reduced trap capture and mating with sentinel females. In addition, the only sentinel females that mated in the treated plots were located in the untreated portion of the tree canopy. Mate finding behaviour was equally disrupted by formulations with and without insecticide. Therefore, under the test conditions, the mechanism by which the attracticide formulation worked was by disruption of male orientation, and not by the removal of males due to insecticide poisoning. Two field cage experiments tested the impact of population density on the competitiveness of the attracticide formulation compared to virgin females. A significant proportion of males were captured in female‐baited traps at the highest female‐to‐droplet ratio tested. Equal proportions of males were captured in attracticide‐baited traps at male moth densities of 10, 20, 40, and 80 males per cage. These results clarify some of the factors influencing the effectiveness and possible mechanisms of an attracticide management tactic against the Oriental fruit moth.     

Effect of anti‐hail nets on Cydia pomonella behavior in apple orchards

Over the last 10 years, the use of nets to protect pome fruit from hailstorms has increased. In this study, we investigated the effect of these nets on the behavior of the codling moth, Cydia pomonella (L.) (Lepidoptera: Tortricidae), a major pest of apple, Malus domestica Borkh. (Rosaceae). Experiments were carried out in net‐covered and uncovered apple orchards treated with conventional insecticides. The number of codling moth males caught in pheromone‐ and virgin female‐baited traps was significantly reduced in net‐covered compared to uncovered plots. In addition, inhibition of mating by the net was demonstrated by significant reductions in mating of tethered virgin females. Fruit injury was consistently lower in net‐covered plots vs. uncovered plots. Because of the reductions in male trap catch, the reduced female mating frequency, and the lower level of damage, we conclude that flat anti‐hail nets have a disruptive effect on the reproductive behavior of the codling moth.     

Monitoring codling moth (Lepidoptera: Tortricidae) with passive interception traps in sex pheromone-treated apple orchards

Male and female codling moth, Cydia pomonella (L.), were monitored with passive interception traps (PI-traps) in apple orchards treated with sex pheromone dispensers. The proportion of mated females recaptured by PI-traps was significantly higher than the proportion released after the release of both sexes into a codling moth-infested orchard. However, no significant difference occurred between the proportion of mated females recaptured and released when only females were released into uninfested orchards. Replicated nine-tree apple plots situated either on the edge or in the center ofpheromone-treated apple orchards were monitored with PI-traps during first moth flight in 1995 and during both flights in 1996. Moths caught on PI-traps were predominately males. The first male moths were captured 7-10 d before females during the first flight in both years. Initial capture of virgin and mated females on PI-traps coincided in 1995. Mated females were captured 14 d after the first virgin females in 1996. The mean proportion of females that were mated ranged from 32 to 55% during the first flight and 85 to 92% during the second flight. Moth catch and fruit injury were significantly higher in the edge versus the center plots. The numbers of total and female moths caught with PI-traps were significantly correlated with fruit injury for each generation. The percentage of female moths caught on PI-traps that were mated was 32% lower and the mean oocyte load of all females was 42% higher in a pheromone-treated apple orchard than in the untreated crabapple grove monitored during May and June 1997.     

Combined approaches using sex pheromone and pear ester for behavioural disruption of codling moth (Lepidoptera: Tortricidae)

Attractive properties of pear ester, ethyl (E,Z)‐2,4‐decadienoate, and codlemone, (E,E)‐8,10‐dodecadien‐1‐ol, the sex pheromone of codling moth, Cydia pomonella (L.), were utilized in experiments on behavioural disruption of mating. Standard dispensers loaded with codlemone alone or in combination with pear ester (combo) were applied at 500–1000/ha. Larger (10‐fold) combo dispensers (Meso) were evaluated at a rate of 80/ha. The addition of microencapsulated pear ester, PE‐MEC, sprayed with insecticides at 30 ml/ha was also evaluated. Male moth catches in unmated female‐baited traps were lower in standard combo dispenser than in codlemone dispenser–treated plots. Female moth catch in traps baited with the combination of pear ester, codlemone and acetic acid was lower in standard combo dispenser than in codlemone dispenser–treated plots. In 12 comparative experiments spanning from 2006 to 2012, male moth catch in unmated female‐baited traps was consistently and significantly lower in combo than in codlemone dispenser–treated plots. Male catch in codlemone‐baited traps did not differ between dispenser treatments in eight studies from 2006 to 2009. These results emphasize the benefit of alternatively using traps baited with unmated females over codlemone lures for the analysis of dispenser activity. Fruit injury was significantly reduced with the addition of PE‐MEC to insecticide applications across untreated and dispenser treatments. Proportion of unmated females trapped was higher in standard combo dispenser than in codlemone dispenser–treated and untreated plots. Similarly, the proportion of unmated females caught was higher in the Meso combo dispenser than in nearby or distant codlemone dispenser–treated plots. These field studies conducted in apple over 3 years demonstrate that adding pear ester both to pheromone dispensers, either standard or Meso, and to supplementary insecticide sprays can provide a significant increase in the disruption of sexual communication, reductions in female mating and reductions in fruit injury.     

Fecundity,fertility and reproductive recovery of irradiated Queensland fruit fly Bactrocera tryoni

Pupae of the Queensland fruit fly or Q‐fly Bactrocera tryoni (Froggatt) are irradiated routinely to induce reproductive sterility in adults for use in sterile insect technique programmes. Previous studies suggest that adult sexual performance and survival under nutritional and crowding stress are compromised by the current target dose of radiation for sterilization (70–75 Gy), and that improved mating propensity and survival under stress by irradiated males may be achieved by reducing the target sterilization dose without reducing the level of induced sterility. This raises the question of the amount by which the irradiation dose can be reduced before residual fertility becomes unacceptable. The present study measures the levels of residual fertility in male and female irradiated Q‐flies at different irradiation doses (20, 30, 40, 50, 60 and 70 Gy), and investigates the possibility that fecundity and fertility increase between 10–15 and 30–35 days post emergence. Male flies require a higher dose than females to induce sterility, with no residual fertility found in females irradiated at doses of 50 Gy or above, and no residual fertility found in males irradiated at doses of 60 Gy or above. Irradiated females are more fecund at 30–35 days post emergence than at 10–15 days. However, fertility does not increase between 10 and 15 days post emergence and 30–35 days, even at doses below 50 Gy. The present study shows that there is scope to reduce the target sterilization dose for Q‐flies below that of the current dose range (70–75 Gy) at the same time as retaining an adequate safety margin above radiation doses at which residual fertility can be expected.