Comparative analysis of Cryptosporidium, Giardia and indicator bacteria during sewage sludge hygienization in various composting processes

AIMS: To evaluate the suitability of Clostridium perfringens, Escherichia coli and enterococci as indicator organisms for Cryptosporidium and Giardia in treated sludge. METHODS AND RESULTS: Occurrence of Cryptosporidium oocysts and Giardia cysts, detected and enumerated by direct immunofluorescence microscopy, were compared with counts of indicator bacteria during six different sewage sludge hygienization processes, including closed reactor and open windrow composting, and sludge sanitation by quicklime or peat addition. No statistical correlation existed between the counts of indicator bacteria, Cl. perfringens, E. coli, and enterococci and occurrence of Cryptosporidium or Giardia. In sludge end-products, Giardia cysts were detected more frequently than Cryptosporidium oocysts. SIGNIFICANCE OF THE STUDY: Direct analysis is the best method to confirm the presence of (oo)cysts in sludge.     

城市污泥强制通风堆肥过程中的生物学和化学变化特征

采用间竭式强制通风堆肥法进行的肥堆体积约4m3,堆肥时间为53d的污泥堆肥试验表明,堆肥的第2天即达高温阶段(≥55℃)并能保持8d,平均最高温度达68℃,局部温度达74℃.粪大肠杆菌由开始时的1.41×105个·g-1降至试验结束时的2.32×101个·g-1.污泥堆肥过程中挥发性固体,总有机C、水溶性有机C、固体有机 C/N比和水溶性有机 C/有机 N比下降明显,而 N、P及重金属含量有所升高.随着堆肥的进程,在前1周堆肥过程中产生的氨氮大幅下降,硝酸盐含量随之升高.相应地,pH在第1周内升高,随后降低.堆肥40d左右,水芹(Lepidiumsativum L.)种子发芽指数即可达 80%.综合堆肥过程中堆温和化学与生物学变化特点,表明污泥堆肥在40d左右基本上接近腐熟,50d后达到完全腐熟.产品外观呈黑褐色,蓬松,无明显异味.     

Bio-degradation of olive mill wastewater sludge by its co-composting with agricultural wastes

The use of maize straw (MS) or cotton waste (CW) as bulking agents in the composting of olive mill wastewater (OMW) sludge was compared by studying the organic matter (OM) mineralisation and humification processes during composting and the characteristics of the end products. Both composts were prepared in a pilot-plant using the Rutgers static-pile system. The use of CW instead of MS to compost OMW sludge extended both the thermophilic and bio-oxidative phases of the process, with higher degradation of polymers (mainly lignin and cellulose), a greater formation of nitrates, higher total nitrogen losses and a lower biological nitrogen fixation. The CW produced a compost with a more stabilised OM and more highly polymerised humic-like substances. In the pile with CW and OMW sludge, OM losses followed a first-order kinetic equation, due to OM degradation being greater at the beginning of the composting and remaining almost constant until the end of the process. However, in the pile with MS and OMW sludge this parameter followed a zero-order kinetic equation, since OM degraded throughout the process. The germination index indicated the reduction of phytotoxicity during composting.     

Transformation of spent broiler litter from exogenous matter to compost in a sub-tropical context

Composting, an environmentally-sound treatment option for confined animal feeding operations (CAFO)-derived wastes, provides opportunities for stabilisation and hygienisation. A 110-day systematic composting study investigated Salmonella presence and survival of total coliforms, faecal coliforms, Escherichia coli and faecal enterococci in three experimental windrows consisting of SBL/bagasse mixture in a close-sided roofed facility. Salmonella was absent throughout the experiment. Log(10) reductions of -6.98, -8.03, -8.18 and -5.96 occurred in TC, FC, E. coli and FE concentrations respectively. As expected, FE exhibited resistance to high temperature compared to E. coli especially for the first 21 days. Temperature histories revealed hygienisation attainment. Differences in mean, representing benchmark stages of composting, were highly significant (P<0.05) for all pathogen indicators. VSRed (%) proved effective in depicting system progress. Final respiration rate of 0.000206 mg CO(2)g(-1) organic-C day(-1) with no phytotoxicity showed the stability achieved. Besides stabilisation, quantitative analysis of the sanitisation potential of composting is elemental for hygienic compliance.     

Inactivation of indicators and pathogens in cattle feedlot manures and compost as determined by molecular and culture assays

Accurate and conservative information about pathogen inactivation rates is needed as the basis for safe manure management on beef cattle feedlots. The survival of indicators and pathogens in faecal pen manure, stockpiled manure and manure compost was measured with autochthonous indicator bacteria (Escherichia coli, Clostridium perfringens, enterococci, total coliforms) and pathogens (Listeria monocytogenes, Campylobacter jejuni) using culture and/or real-time quantitative PCR (qPCR) methods. Additionally, the manures were incubated at 20, 37, 50 and 60 °C in microcosms to quantify the persistence of autochthonous microorganisms and selected process performance surrogates (Clostridium sporogenes, green fluorescent protein-labelled E. coli and L. monocytogenes). Estimated qPCR cell counts indicated that up to four orders of magnitude more target cells were present compared with the culturable counts. Corresponding T(90) estimates were up to sixfold higher. This study demonstrates the benefits of nucleic acid-based quantification of pathogen inactivation in cattle manures and concludes that the concurrent analysis of microorganisms by molecular and culture methods provides complementary value.     

Sludge stabilization by composting: a Jordanian case study

Municipal sludge handling is a major problem facing wastewater treatment plants due to the high costs of treatment and disposal. This issue is of special importance in Jordan because of the critical economic situation as well as the lack of financial support for such nonprofit projects. This study investigates the possibility of solving this problem by testing a method of sludge stabilization that requires minimum initial and operating costs. The method tested here is sludge stabilization by composting which is an attempt to transform sludge into a safe, nuisance free, humus like product that can be applied safely to land and can become a source of income that would recover the costs of processing. Two types of composting systems were tested in this study, aerated static pile and windrow. Results obtained indicate that composting of dried sludge was not possible due to the extremely low moisture content; which was overcome by sludge seeding and mixing with amendment and bulking agents. This resulted in efficient stabilization and reduction of the amount of organic matter in the final compost. The experimental results obtained also indicate that both systems (aerated static pile and windrow) are efficient. The organic content of the sludge was reduced in the windrow system by 46% and in the aerated static pile by 66%. In addition, the total volatile solids had decreased in the windrow and the aerated pile by 26 and 73%, respectively. The heavy metals content of the final compost was examined and found to comply with the international standards.     

Factors influencing chemical quality of composted poultry waste

The need for organic recycling is justified in the case of poultry waste because after ensuring hygienization there is a chance of obtaining a compost with substantial fertilizer value. Organic recycling of slaughter waste has its justification in sustainable development and retardation of resources. In the research being described, composting of hydrated poultry slaughterhouse waste with maize straw was carried out. Combinations with fodder yeast and postcellulose lime were also introduced in order to modify chemical and physicochemical properties of the mixtures. The experiment was carried out within 110 days in 1.2 × 1.0 × 0.8 m laboratory reactors. Temperature of the biomass was recorded during composting, and the biomass was actively aerated through a perforated bottom.Composting of substrates selected in such a way caused losses of some elements in gaseous form, an increase in concentration of other elements, and changes in relationships between elements. The ability to select substrates influences compost quality. This ability is determined by chemical indicators. Among other things, compost evaluation based on carbon to nitrogen ratio shows the intensity of the composting process and possible nitrogen losses. The addition of slaughter waste to maize straw reduced the content of individual fractions of carbon in the composts, whereas the addition of postcellulose lime intensified that process. The addition of fodder yeast significantly increased the phosphorus content in the compost. Since iron compounds were used in the processing of poultry carcasses, composts that were based on this material had an elevated iron content. The applied postcellulose lime significantly increased the copper, zinc, chromium, nickel, and lead contents. Proper selection of substrates for composting of hydrated poultry slaughterhouse waste allows to obtain a compost with chemical properties that create favorable conditions for natural application of that compost. Addition of large quantities of postcellulose lime to the composting process leads to obtaining an organic-mineral substratum for cultivation or to obtaining an agent that improves soil properties.     

Response of compost maturity and microbial community composition to pentachlorophenol (PCP)-contaminated soil during composting

Two composting piles were prepared by adding to a mixture of rice straw, vegetables and bran: (i) raw soil free from pentachlorophenol (PCP) contamination (pile A) and (ii) PCP-contaminated soil (pile B). It was shown by the results that compost maturity characterized by water soluble carbon (WSC), TOC/TN ratio, germination index (GI) and dehydrogenase activity (DA) was significantly affected by PCP exposure, which resulted in an inferior degree of maturity for pile B. DGGE analysis revealed an inhibited effect of PCP on compost microbial abundance. The bacteria community shifts were mainly consistent with composting factors such as temperature, pH, moisture content and substrates. By contrast, the fungal communities were more sensitive to PCP contamination due to the significant correlation between fungal community shifts and PCP removal. Therefore, the different microbial community compositions for properly evaluating the degree of maturity and PCP contamination were suggested.     

The study of the aerobic bacterial microbiota and the biotoxicity in various samples of olive mill wastewaters (alpechin) during their composting process

Five different piles were prepared by mixing olive mill wastewater (alpechin) and alpechin sludge with two bulking agents (cotton waste and maize straw) and two organic wastes with high content of nitrogen (sewage sludge and poultry manure), which were composted by the Rutgers static pile composting system in a pilot plant. The aim of this work was to study the evolution of total nitrogen and different forms of organic matter and evaluate the variation in the aerobic bacterial microbiota present and biotoxicity during the composting process.In piles prepared with alpechin, the use of the maize straw as a bulking agent reduced the nitrogen losses whereas the use of sewage sludge, instead of poultry manure, with cotton waste originated the highest degradation of organic matter. In piles prepared with alpechin sludge a similar evolution of the composting process was observed. There were not great variations during composting in the aerobic bacterial microbiota present in the mixtures. However, the pile prepared with alpechin sludge and maize straw was only one to present bacteria capable of growing in alpechin, and the toxicity study showed that this was only present in the starting mixtures.     

Evolution of the pathogen content during co-composting of winery and distillery wastes

The aim of this study was to monitor some microbial indicators and pathogen contents (sulphite reducers clostridia, total enterobacteriaceae, total coliforms, faecal coliforms (Escherichia coli), enterococci, Staphylococcus aureus and Salmonella spp.) throughout the co-composting of wastes from the winery and distillery industry with other organic residues, as well as the effect of the composting system used. Seven different piles using mixtures of winery-distillery wastes with other organic materials were prepared. P1 and P2 were made using grape stalk (GS), grape marc (GM), exhausted grape marc (EGM) and sewage sludge (SS), whereas in P3 and P4 were also used exhausted grape marc with cow manure (CW) and poultry manure (PM), respectively, using the Rutgers system. Additionally, P2 was watered with vinasse (V). The rest of piles (P5, P6 and P7) were prepared with grape marc, exhausted grape marc, cow manure and poultry manure, using the turning system. The effectiveness of the composting process to reduce the pathogen content was higher in the static aerated piles than in those elaborated with the turning. The relatively high temperatures (50-60 degrees C) reached in some of the piles produced a notable decrease in some microbial groups, such as total and faecal coliforms (E. coli), but the characteristics of the raw materials used notably influenced the pathogen contents of the end-product.     

Monitoring respiration and biological stability during sludge composting with a modified dynamic respirometer

A static electrolytic respirometer was adapted to work under dynamic conditions using an internal airflow recirculation system that passed air through sludge/straw solid mixtures. Airflow reduced oxygen transfer limitations and increased the maximum respiration rate and k_La values, indicating that the observed value may have been close to the actual biodegradation rate. Airflow caused sludge drying, so the sample moisture was controlled by air humidification. To apply the optimised respirometric technique, a pilotscale composting process was developed. Some commonly used respiration indices (RI₂₄, AT₄) were used to measure the final compost stability. RI₂₄ indices without airflow were underestimated during the thermophilic composting stage. Once the easily biodegradable carbon was consumed, the static and dynamic RI₂₄ indices were nearly identical. Because of the dynamic procedure, the respiration rate was likely controlled by the biochemical reaction and not by the mass transfer. The respiration indices indicated that the final compost was unstable.     

Two-phase olive mill waste composting: enhancement of the composting rate and compost quality by grape stalks addition

Two-phase olive mill waste (TPOMW) is a semisolid sludge generated by the olive oil industry. Its recycling as a soil amendment, either unprocessed or composted, is being promoted as a beneficial agricultural practice in the Mediterranean area. One of the major difficulties when composting TPOMW is the compaction of the material due to its dough-like texture, which leads to an inadequate aeration. For this reason, the addition of bulking agents is particularly important to attain a proper composting process. In this study we followed the evolution of two composting mixtures (A and B) prepared by mixing equal amounts of TPOMW and sheep litter (SL) (in a dry weight basis). In pile B grape stalks (GS) were added (10% dry weight) as bulking agent to study their effect on the development of the composting process and the final compost quality. The incorporation of grape stalks to the composting mixture changed the organic matter (OM) degradation dynamics and notably reduced the total amount of lixiviates. The evolution of several maturation indices (C/N, germination index, water soluble carbon, humification indices, C/N in the leachates) showed a faster and improved composting process when GS were added. Moreover, chemical (NH₄ ⁺, NO₃ ⁻, cation exchange capacity, macro and micronutrients, heavy metals) and physical properties (bulk and real densities, air content, total water holding capacity, porosity) of the final composts were analysed and confirmed the superior quality of the compost where GS were added.     

Occurrence and levels of indicators and selected pathogens in different sludges and biosolids

AIMS: Determine the occurrence and levels of pathogens and indicators in raw and treated sludges and compare their persistence after two different treatments. METHODS AND RESULTS: Helminth ova, Cryptosporidium spp., Salmonella spp., enteroviruses, and bacterial and viral indicators were determined in raw sludges and biosolids produced after mesophilic and thermophilic treatments. Except Salmonella, all of the parameters were quantified. Helminth ova were found at very low concentrations even in raw sludges. Viable Cryptosporidium oocysts were still present in most samples of treated sludges. Faecal coliforms, spores of sulphite-reducing clostridia (SSRC), and somatic coliphages were the only indicators with values above their detection limits in most of the samples. CONCLUSIONS: Pathogens were still detected in some treated sludge samples. SSRC were the most resistant micro-organisms to treatments and hence may be an indicator for the reduction of protozoan oocysts. Somatic coliphages constitute an alternative as viral indicators due to their detection in sludges before and after treatment. SIGNIFICANCE AND IMPACT OF THE STUDY: Because of the persistence of some pathogens after sludge treatments, additional indicators are needed. SSRC and somatic coliphages are good candidates. Easy and inexpensive methods for the determination of these indicators are feasible both in industrialized and developing countries.     

Characteristics of rice straw and sewage sludge as composting materials in Valencia (Spain)

This work supports the idea that composting can be useful for minimizing the rice straw and sewage sludge environmental impact. Several physical, chemical and microbiological properties of these raw materials were analyzed. The characteristics of the rice straw were complementary to those of the sewage sludge for the application of composting. The C/N ratios suitable for a rapid increased in microbial activity were the lowest (17-24). A temperature of 62 degrees C during 48 h removed pathogenic microorganisms from rice straw and sewage sludge mixture. The results obtained in the present work suggested that these materials could be use in the composting process.     

Composting of pulp and paper mill fly ash with wastewater treatment sludge

Wastewater treatment sludge and power boiler fly ash were combined and composted in mixed and static windrows 50 m long, 4 m high and 6 m wide. Moisture content was maintained above 50%. The final compost had a pH of 8.5, contained high concentrations of specific nutrients, and an average C:N ratio of 43:1. All metal, PCB, chlorophenol and PAH concentrations were below levels stipulated by local regulations. Over the first 8 weeks of the composting period dioxin concentration decreased by 45% to 41 pg/g TEQ. Leachate tests indicated minimal (<0.1 mg/l Cu and Pb; <50 mg/l Na, P, and SO₄⁻²) leaching of contaminants from the composted material. Application of compost (8 cubic yards/acre) at a sod farm improved soil characteristics as measured by a number of parameters. The dioxin concentration in the final soil/compost mixture was 3 pg/g TEQ, allowing the soil/compost mixture to be classified as agricultural soil. It was concluded that composting produced an acceptable soil conditioner attractive for large volume users of inexpensive soil material (sod farms, golf courses, land reclamation sites).     

Occurrence of Listeria sp and L monocytogenes in sewage sludge used for land application: effect of dewatering,liming and storage in tank on survival of Listeria species

The application of sewage sludge to agricultural land is widely used in France. To determine the impact of sludge treatments, concentrations of Listeria sp., Listeria monocytogenes and faecal indicators were monitored in five types of sludge from three sewage treatment plants in Angers (France) and its suburbs over a 1-year period. On the whole, bacteria were reduced in numbers through sludge treatments. Apart from liming, which leads to reduced levels of bacteria below detection limits, other sludge treatments did not eliminate Listeria sp. and faecal indicators. Listeria sp. and L. monocytogenes were found respectively in 87% and 73% of dewatered sludges and in 96% and 80% of sludges stored in tanks. Concentrations of L. monocytogenes, ranging from 0.15 to 20 MPN g(-1) dry matter in dewatered sludge and from 1 to 240 MPN g(-1) dry matter in sludge stored in tanks, did not show seasonal variations. Spreading of sanitised sludge onto agricultural land results in the addition of 10(6)-10(8) L. monocytogenes per hectare per year, which may contribute to the increase in the dissemination of this pathogenic species in the environment.     

Occurrence of Aspergillus fumigatus during composting of sewage sludge.

Aspergillus fumigatus, a medically important fungal opportunist and respiratory allergen, was isolated from woodchips and sewage sludge used in the production of compost at the U.S. Department of Agriculture's composting research facility in Beltsville, Md. It was also regularly isolated as a dominant fungus during forced aeration composting and after 30 days in an unaerated stationary curing pile; in both cases, the fungus was found in pile zones with temperatures less than 60 degrees C. Compost stored outdoors in stationary unaerated piles from 1 to 4 months after screening out of woodchips contained easily detectable amounts of A. fumigatus in the exterior pile zones (0- to 25-cm depths). Semiquantitative studies of the airspora at the composting site revealed that A. fumigatus constituted 75% of the total viable mycoflora captured. At locations 320 m to 8 km from the compost site, the fungus constituted only 2% of the total viable mycoflora in the air. Of 21 samples of commercially available potting soil, one had levels of A. fumigatus nearly equivalent to those of 1-month-old storage compost; 15 others had lower but detectable levels.     

Quantification of pathogenic micro-organisms in the sludge from treated hospital wastewater

The sludge from hospital waste treatment facilities is a potential source of infectious organisms. The average numbers of micro-organisms in the sludge of hospital wastewater in Taiwan were as follows: total count 8·1 × 10⁷ cfu g⁻¹ (dry weight of sludge), and 1·4 × 10⁶, 3·6 × 10⁵, 1·6 × 10⁵, 2·2 × 10⁵ and 5·5 × 10⁴ cfu g⁻¹ (dry weight of sludge) for total coliforms, faecal coliforms, faecal streptococci, Pseudomonas aeruginosa and Salmonella spp., respectively . Salmonella spp. were detected in 37% (10 of 27) of the sludges from hospital wastewaters. Therefore, the treatment of such sludge to reduce pathogenic micro-organisms should be considered.     

Effect of bioaugmentation and nitrogen supplementation on composting of paddy straw

A composting experiment was conducted to evaluate the effect of a hyperlignocellulolytic fungal consortium and different nitrogen amendments on paddy straw composting in terms of changes in physicochemical and biological parameters. A fungal consortium comprising four lignocellulolytic mesophilic fungal cultures was used as inoculum for bioaugmentation of paddy straw in perforated pits. The comparative effect of farmyard manure (FYM), soybean trash, poultry litter and urea on the composting process was evaluated at monthly intervals in terms of physicochemical (pH, EC, available P, C:N ratio and humus content) and biological (enzymatic and microbial activity) parameters. The compost prepared from bioaugmented paddy straw composting mixture, with poultry manure as nitrogen supplement attained desirable C:N ratio in 1 month and displayed least phytotoxicity levels along with higher production of β-1,4-Exoglucanase. The combined activity of the autochthonous composting microbiota as well as the externally applied fungal inoculum accelerated the composting process of paddy straw. Supplementation of paddy straw with poultry manure in 8:1 ratio was identified as the best treatment to hasten the composting process. This study highlights the importance of application of fungal inoculum and an appropriate N-amendment such as poultry manure for preparation of compost using a substrate having high C:N ratio, such as paddy straw.     

Occurrence of Aspergillus fumigatus during composting of sewage sludge.

Aspergillus fumigatus, a medically important fungal opportunist and respiratory allergen, was isolated from woodchips and sewage sludge used in the production of compost at the U.S. Department of Agriculture's composting research facility in Beltsville, Md. It was also regularly isolated as a dominant fungus during forced aeration composting and after 30 days in an unaerated stationary curing pile; in both cases, the fungus was found in pile zones with temperatures less than 60 degrees C. Compost stored outdoors in stationary unaerated piles from 1 to 4 months after screening out of woodchips contained easily detectable amounts of A. fumigatus in the exterior pile zones (0- to 25-cm depths). Semiquantitative studies of the airspora at the composting site revealed that A. fumigatus constituted 75% of the total viable mycoflora captured. At locations 320 m to 8 km from the compost site, the fungus constituted only 2% of the total viable mycoflora in the air. Of 21 samples of commercially available potting soil, one had levels of A. fumigatus nearly equivalent to those of 1-month-old storage compost; 15 others had lower but detectable levels.