Immobilization of acetylcholinesterase on gold nanoparticles embedded in sol-gel film for amperometric detection of organophosphorous insecticide

A simple method to immobilize acetylcholinesterase (AChE) on silica sol-gel (SiSG) film assembling gold nanoparticles (AuNPs) was proposed, thus a sensitive, fast and stable amperometric sensor for quantitative determination of organophosphorous insecticide was developed. The large quantities of hydroxyl groups in the sol-gel composite provided a biocompatible microenvironment around enzyme molecule and stabilized its biological activity to a large extent. The immobilized AChE could catalyze the hydrolysis of acetylthiocholine chloride (ATCl) with a Kmapp value of 450 microM to form thiocholine, which was then oxidized to produce detectable single with a linear range of 10-1000 microM. AuNPs catalyzed the electro-oxidation of thiocholine, thus increasing detection sensitivity. Based on the inhibition of organophosphorous insecticide on the enzymatic activity of AChE, using monocrotophos as a model compound, the conditions for detection of the insecticide were optimized. The inhibition of monocrotophos was proportional to its concentration ranging from 0.001 to 1 microg/ml and 2 to 15 microg/ml, with the correlation coefficients of 0.9930 and 0.9985, respectively. The detection limit was 0.6 ng/ml at a 10% inhibition. The developed biosensor exhibited good reproducibility and acceptable stability, thus providing a new promising tool for analysis of enzyme inhibitors.     

An acetylcholinesterase biosensor for determination of low concentrations of Paraoxon and Dichlorvos

The characterization of an economic and ease-to-use carbon paste acetylcholinesterase (AChE) based biosensor to determine the concentration of pesticides Paraoxon and Dichlorvos is discussed. AChE hydrolyses acetylthiocholine (ATCh) in thiocoline (TC) and acetic acid (AA). When AChE is immobilized into a paste carbon working electrode kept at +410 mV vs. Ag/AgCl electrode, the enzyme reaction rate using acetylthiocholine chloride (ATCl) as substrate is monitored as a current intensity. Because Paraoxon and Dichlorvos inhibit the AChE reaction, the decrease of the current intensity, at fixed ATCl concentration, is a measure of their concentration. Linear calibration curves for Paraoxon and Dichlorvos determination have been obtained. The detection limits resulted to be 0.86 ppb and 4.2 ppb for Paraoxon and Dichlorvos, respectively, while the extension of the linear range was up 23 ppb for the former pesticide and up to 33 ppb for the latter. Because the inhibited enzyme can be reactivated when immediately treated with an oxime, the biosensor reactivation has been studied when 1,1'-trimethylene bis 4-formylpyridinium bromide dioxime (TMB-4) and pyridine 2-aldoxime methiodide (2-PAM) were used. TMB-4 resulted more effective. The comparison with the behavior of similar AChE based biosensors is also presented.     

Flow analysis for determination of paraoxon with use of immobilized acetylcholinesterase reactor and new type of chemiluminescent reaction

A highly sensitive flow analysis method for determination of acetylcholinesterase (AChE) inhibitors like organophosphorous pesticides using a new chemiluminescent reaction was developed and optimized. This method is fast, sensitive, and cheap, because it requires only one enzyme and its substrate. The system incorporates a reactor with immobilized AChE on controlled pore glass (CPG) and a chemiluminometric detector. Variations in enzyme activity due to inhibition are measured from the changes of concentrations of thiocholine produced when the substrate (acetylthiocholine chloride) is pumped before and after the passage of the solution containing the pesticide through the immobilized AChE reactor. Thiocholine is determined by a new chemiluminescent reaction with luminol in the presence of potassium ferricyanide. The percentage inhibition of enzyme activity is correlated to the pesticide concentration. The inhibited enzyme is reactivated by 10 mM pyridine-2-aldoxime methiodide (2-PAM). The experimental conditions were first optimized for activity determination of the effect of pH, flow rates, and Tris concentrations. For the measurement of AChE inhibition, the appropriate concentration of the substrate is selected such that the rate of noninhibited reaction can be considered unchanged and could be used as a reference. For optimization of experimental conditions for inhibition, several parameters of the system are studied and discussed: flow rate, enzyme-pesticide contact time, luminol concentration, ferricyanide concentration, 2-PAM concentration, and configuration of the FIA manifold. Paraoxon, an organophosphorous pesticide was tested. For an inhibition time of 10 min the calibration graph is linear from 0.1 to 1 ppm paraoxon with a relative standard deviation (n = 5) of 4.6% at 0.5 ppm. For an inhibition time of 30 min the calibration graph is linear from 25 to 250 ppb paraoxon.     

Immobilization of Thermoanaerobium brockii alcohol dehydrogenase on SBA-15

The activity of Thermoanaerobium brockii alcohol dehydrogenase (TBADH) adsorbed on mesoporous silica SBA-15 was compared with that of the free enzyme in water and in biphasic system (water phase up to 50% v/v water). TBADH was active at a water concentration ≥10% v/v. In the reduction reaction of sulcatone to sulcatol carried out in biphasic systems, the yield obtained with SBA-15-adsorbed TBADH was up to 5.5-fold higher than that with the free enzyme, which suggests a higher stability of the immobilized enzyme toward the organic solvent. The nature of the organic solvent substantially influenced the degree of conversion that, for example, was 7.4% in toluene and 31.6% in petroleum ether.     

Ultra-sensitive biosensor based on mesocellular silica foam for organophosphorous pesticide detection

A sensitive amperometric acetylcholinesterase (AChE) biosensor was fabricated based on mesocellular silica foam (MSF), which functioned as both an enzyme immobilization matrix and a solid phase extraction (SPE) material for the preconcentration of target molecules. The hydrophilic interface, the good mechanical/chemical stability, and the suitable pore dimension of MSF provided the entrapped AChE a good environment to well maintain its bioactivity at basic condition. The AChE immobilized in MSF showed improved catalytic ability for the hydrolysis of acetylthiocholine, as evidenced by the increasing of the oxidation current of thiocholine, the enzymatic catalytic hydrolysis production of acetylthiocholine. In addition, the MSF with large surface area showed a modest adsorption capacity for monocrotophos, a model organophosphate used in this study, via the hydrogen bond or physical adsorption interaction. The combination of the SPE and the good enzyme immobilization ability in MSF significantly promoted the sensitivity of the biosensor, and the limit of detection has lowered to 0.05 ng/mL. The biosensor exhibited accuracy, good reproducibility, and acceptable stability when used for garlic samples analysis. The strategy may provide a new method to fabricate highly sensitive biosensors for the detection of ultra-trace organophosphorous pesticide infield.     

Covalent immobilization of acetylcholinesterase on a novel polyacrylic acid‐based nanofiber membrane

In this study, polyacrylic acid‐based nanofiber (NF) membrane was prepared via electrospinning method. Acetylcholinesterase (AChE) from Electrophorus electricus was covalently immobilized onto polyacrylic acid‐based NF membrane by demonstrating efficient enzyme immobilization, and immobilization capacity of polymer membranes was found to be 0.4 mg/g. The novel NF membrane was synthesized via thermally activated surface reconstruction, and activation with carbonyldiimidazole upon electrospinning. The morphology of the polyacrylic acid‐based membrane was investigated by scanning electron microscopy, Fourier Transform Infrared Spectroscopy, and thermogravimetric analysis. The effect of temperature and pH on enzyme activity was investigated and maxima activities for free and immobilized enzyme were observed at 30 and 35°C, and pH 7.4 and 8.0, respectively. The effect of 1 mM Mn²⁺, Ni²⁺, Cu²⁺, Zn²⁺, Mg²⁺, Ca²⁺ ions on the stability of the immobilized AChE was also investigated. According to the Michaelis–Menten plot, AChE possessed a lower affinity to acetylthiocholine iodide after immobilization, and the Michaelis–Menten constant of immobilized and free AChE were found to be 0.5008 and 0.4733 mM, respectively. The immobilized AChE demonstrated satisfactory reusability, and even after 10 consecutive activity assay runs, AChE maintained ca. 87% of its initial activity. Free enzyme lost its activity completely within 60 days, while the immobilized enzyme retained approximately 70% of the initial activity under the same storage time. The favorable reusability of immobilized AChE enables the support to be employable to develop the AChE‐based biosensors.     

Comparison of pesticide sensitivity by electrochemical test based on acetylcholinesterase biosensor

Based on the change in electrochemical behavior of enzymatic activity induced by pesticide, a novel electrochemical method has been devised for investigation of pesticide sensitivity using acetylcholinesterase (AChE) biosensor. Because of the excellent biocompatibility and good stability of chitosan matrix, it prevented leakage of the AChE from electrode. Multiwall carbon nanotube (MWNT) promoted electron transfer reaction at a lower potential and catalyzed the electro-oxidation of thiocholine, thus amplifying the sensitivity and amperometric response of the biosensor. Four pesticides of carbaryl, malathion, dimethoate and monocrotophos were selected to discuss their inhibition efficiencies to AChE. The inhibition curves were similar to Michealis-Menten and the Michealis-Menten constants (Km) were calculated to be 0.96 microM, 1.78 microM, 1.97 microM and 4.28 microM, respectively. Ninety-five percent reactivation of the inhibited AChE could be regenerated using pralidoxime iodide within 8 min. The proposed electrochemical pesticide sensitivity test exhibited high sensitivity, low cost and simplified procedures, which is a promising new tool for comparison of pesticide sensitivity and for selection of the most efficient enzyme inhibitors.     

Fabrication of an organic–inorganic nanocomposite carrier for enzyme immobilization based on metal–organic coordination

An organic–inorganic nanocomposite which combined mesoporous silica SBA-15 and chitosan using a carboxyl functionalized ionic liquid as the bridging agent (SBA@CS) was successfully fabricated, and was used to immobilize porcine pancreas lipase (PPL) by physical adsorption, cross-linking and metal–organic coordination, respectively. The as-prepared carriers were characterized by scanning electron microscopy, Fourier transform infrared and energy-dispersive X-ray spectroscopy. Compared with immobilization onto the pure mesoporous silicon material SBA-15, all the batches of PPL immobilized onto organic–inorganic nanocomposites showed higher activity, improved stability and reusability as well as better resistance to pH and temperature changes. Among the immobilized PPLs, immobilization based on Co²⁺ coordination (SBA@CS-Co-PPL) produced the best enzymatic properties. The maximum immobilization efficiency and specific activity of 79.6% and 1975.8 U g⁻¹ were obtained with SBA@CS-Co, separately. More importantly, the activity of immobilized enzyme can still maintain 84.0% after 10 times of reuse. These results demonstrated that thus prepared organic–inorganic nanocomposite could be an ideal carrier for enzyme immobilization by metal–organic coordination.     

Immobilization of acetylcholinesterase in nanofibrous PVA/BSA membranes by electrospinning

Electrospinning, a simple and versatile method to fabricate nanofibrous supports, has attracted continuous attention in the field of enzyme immobilization. In this study, acetylcholinesterase (AChE) has been successfully immobilized in PVA nanofibers via electrospinning of a mixture of AChE, BSA as an enzyme stabilizing additive and PVA. The maximum activity recovery of immobilized AChE was about 40%. In comparison with free enzyme, the immobilized AChE showed improved stability while retaining a considerable amount of activity at lower pH values. Moreover, the immobilized AChE retained >34% of its initial activity when stored at 30°C for 100 days and retained 70% of its initial activity after ten consecutive reactor batch cycles.     

Asymmetric distribution of acetylcholinesterase in gravistimulated maize seedlings

Acetylcholinesterase (AChE) activity has previously been studied by this laboratory and shown to occur at the interface between the stele and cortex of the mesocotyl of maize (Zea mays L.) seedlings. In this work we studied the distribution of AChE activity in 5-d-old maize seedlings following a gravity stimulus. After the stimulus, we found an asymmetric distribution of the enzyme in the coleoptile, the coleoptile node, and the mesocotyl of the stimulated seedlings using both histochemical and colorimetric methods for measuring the hydrolysis of acetylthiocholine. The hydrolytic capability of the esterase was greater on the lower side of the horizontally placed seedlings. Using the histochemical method, we localized the hydrolytic capability in the cortical cells around the vascular stele of the tissues. The hydrolytic activity was inhibited 80 to 90% by neostigmine, an inhibitor of AChE. When neostigmine was applied to the corn kernel, the gravity response of the seedling was inhibited and no enzyme-positive spots appeared in the gravity-stimulated seedlings. We believe these results indicate a role for AChE in the gravity response of maize seedlings.     

Enhancing the catalytic properties of porcine pancreatic lipase by immobilization on SBA-15 modified by functionalized ionic liquid

The mesoporous silica SBA-15 was modified by carboxyl-functionalized ionic liquid (COOH-IL-SBA). The prepared support was used to immobilize porcine pancreatic lipase (PPL) by physical adsorption (PPL-COOH-IL-SBA) and covalent attachment (PPL-CON-IL-SBA). Enzymatic properties of the immobilized PPL were investigated in the triacetin hydrolysis reaction. It was found that carboxyl functionalized ionic liquid modification of the support surface was an effective method to improve the properties of immobilized PPL. Incorporating into the functionalized SBA-15 made PPL more resistant to temperature and pH changes, compared with PPL immobilized on parent SBA-15 (PPL-SBA). Especially, after the covalent attachment to a functionalized support, the stability of PPL was improved obviously, which retained 81.25% and 52.50% of the original activity after incubation for 20 days and four times recycling, respectively, whereas PPL-SBA exhibited only 58.80% and 27.78% of the original activity under the same conditions. In addition, physical and chemical properties of the supports and immobilized PPL were characterized by small-angle X-ray powder diffraction (SAXRD), Fourier transform infrared spectroscopy (FT-IR), scanning electron microscope (SEM), nitrogen adsorption, nuclear magnetic resonance (NMR) and thermogravimetry (TG). The images and data confirmed chemical modification in SBA-15 and PPL immobilization on the tested support.     

Determination of organophosphorous pesticides by a novel biosensor based on localized surface plasmon resonance

Liquid and gas chromatography are commonly used to measure organophosphorus pesticides. However, these methods are relatively time consuming and require a tedious sample pretreatment. Here, we applied the localized surface plasmon resonance (LSPR) of gold nanoparticles covalently coupled with acetylcholinesterase (AChE) to create a biosensor for detecting an example of serial signals responding to paraoxon in the range of 1-100 ppb by an AChE modified LSPR sensor immersing in a 0.05 mM ACh solution. The underlying mechanism is that paraoxon prevents acetylcholine chloride (ACh) reacting with AChE by destroying the OH bond of serine in AChE. We found that the AChE modified LSPR sensors prepared by incubation with 12.5 mU/mL of AChE in phosphate buffer solution at pH 8.5 room temperature for 14 h have the best linear inhibition response with a 0.234 ppb limit of paraoxon detection. A 14% of inhibition on the sensor corresponds to the change of paraoxon concentration from 1 to 100 ppb. The sensor remained 94% of its original activity after six cycles of inhibition with 500 ppb paraoxon followed with reactivation of AChE by 0.5 mM 2-pyriding-aldoxime methoiodide (2-PAM). In addition, the sensor retains activity and gives reproducible results after storage in dry state at 4 degrees C for 60 days. In conclusion, we demonstrated that the AChE modified LSPR sensors can be used to determine the concentration of paraoxon biosensor with high sensitive and stable characteristics.     

Isolation and immobilization of alkaline protease on mesoporous silica and mesoporous ZSM-5 zeolite materials for improved catalytic properties

Alkaline protease from brinjal leaf (Solanum melongena) having milk clotting activity has been purified to 9.44 fold to a final specific activity of 45.71 U/mg. SDS-PAGE of the final preparation revealed a single protein band of approx 14 kDa. Purified enzyme was characterized and was successfully immobilized into the amorphous mesoporous silica (SBA-15) and crystalline mesoporous zeolite (Nano-ZSM-5) using entrapment method. Maximum immobilization of 63.5% and 79.77% was obtained with SBA-15 and Nano-ZSM-5, respectively. This protocol serves as a novel approach for bioprocesses, mainly as milk coagulant for local dairy products and particularly, cheese making, and opens the new dimension of further research and other innovation.     

Choline derivatives and sodium fluoride protect acetylcholinesterase against irreversible inhibition and aging by DFP and paraoxon

A light addressable potentiometric sensor was used to measure acetylcholinesterase (AChE) activity in order to evaluate the protective effects of quaternary compounds and NaF against enzyme phosphorylation and aging by two organophosphates. The use of the immobilized AChE made possible the quick removal of reagents (i.e., organophosphate, 2-pralidoxime, and protectant), thereby permitting accurate determination of AChE activity before and after phosphorylation and aging. Paraoxon was 15-fold more potent in inhibiting AChE than DFP, while the percent aging following phosphorylation by diiso-propylfluorophosphate (DFP) was much higher. Sodium fluoride (NaF), the most effective protectant against phosphorylation and aging, and the quaternary ammonium compounds reduced significantly AChE inhibition by DFP and paraoxon, to similar degrees. Even though the percent AChE activity that was lost to aging was reduced by these agents, aging as a percent of phosphorylated AChE was not reduced. Thus, their major effect was in reducing the percent AChE phosphorylation, which consequently resulted in reduction of total aged AChE. The finding that quaternary ammonium compounds protect against phosphorylation is consonant with the proposed presence of the active site of AChE in an aromatic gorge.     

Erythrocyte antioxidant enzymes in toxicological evaluation of commonly used organophosphate pesticides

Erythrocytes are excellent models for the study of interactions of xenobiotics with biomembranes. Present work is designed to study the in vitro effects of some organophosphates (ethion, chlorpyrifos, dimethoate and monocrotophos) on rat erythrocytes. Treatment of erythrocytes with organophosphates resulted in decreased erythrocyte glucose-6-phosphate dehydrogenase (G-6-PD) activity, whereas activities of glutathione-s-transferase (GST) and glutathione reductase (GR) were increased. Reduced Glutathione (GSH) content of RBCs was decreased after treatment with the pesticides. Increased activities of GST and GR were due to induction of natural defense mechanism of erythrocytes against the toxicity of the pesticides. Membrane bound enzymes like acetylcholinesterase (AChE), Na(+)-K(+)-ATPase and Ca(2+)-ATPase were also inhibited. Altered activities of these enzymes along with decreased GSH content indicate increased oxidative stress in erythrocytes after treatment with organophosphates.     

Immobilization of alkaline serine endopeptidase from Bacillus licheniformis on SBA-15 and MCF by surface covalent binding

An industrial enzyme, alkaline serine endopeptidase, was immobilized on surface modified SBA-15 and MCF materials by amide bond formation using carbodiimide as a coupling agent. The specific activities of free enzyme and enzyme immobilized on SBA-15 and MCF were studied using casein (soluble milk protein) as a substrate. The highest activity of free enzyme was obtained at pH 9.5 while this value shifted to pH 10 for SBA-15 and MCF immobilized enzyme. The highest activity of immobilized enzymes was obtained at higher temperature (60 °C) than that of the free enzyme (55 °C). Kinetic parameters, Michaelis–Menten constant (K_m) and maximum reaction velocity (V_max), were calculated as K_m = 13.375, 11.956, and 8.698 × 10^?4 mg/ml and V_max = 0.156, 0.163 and 0.17 × 10^?3 U/mg for the free enzyme and enzyme immobilized on SBA-15 and MCF, respectively. The reusability of immobilized enzyme showed 80% of the activity retained even after 15 cycles. Large pore sized MCF immobilized enzyme was found to be more promising than the SBA-15 immobilized enzyme due to the availability of larger pores of MCF, which offer facile diffusion of substrate and product molecules.     

Development of acetylcholinesterase silica sol-gel immobilized biosensor--an application towards oxydemeton methyl detection

An amperometric silica sol-gel film immobilized biosensor doped with acetylcholinesterase was fabricated in the laboratory finding application in organophosphate detection based on enzyme inhibition. The substrate used was acetylthiocholine chloride and thiocholine released from the enzymatic hydrolysis was electrochemically oxidized giving larger anodic current at 0.5-0.6 V (versus Ag/AgCl reference). The dependencies of the current response on pH, enzyme loading and thermal stability of the developed biosensor were evaluated. The analytical performance of enzyme electrode towards substrate and inhibitor was investigated. Oxydemeton methyl was taken as a model compound for the inhibition studies. Linear calibration for oxydemeton methyl was obtained in the range of 2-200 ppb under the optimized conditions following an incubation time of 20 min. Treatment of the inhibited enzyme with pyridine-2-aldehyde restored 92% of its original activity. The sensor stored at -20 degrees C had a good storage and operational stability retaining 85% of its original activity for 60 successive measurements.     

Immobilization of chloroperoxidase on mesoporous materials for the oxidation of 4,6-dimethyldibenzothiophene,a recalcitrant organic sulfur compound present in petroleum fractions

The catalytic potential of chloroperoxidase (CPO) immobilized on mesoporous materials was evaluated for the oxidation of 4,6-dimethyldibenzothiophene in water/acetonitrile mixtures. Two different types of materials were used for the immobilization: a metal containing Al-MCM-41 material with a pore size of 26 A and SBA-16 materials with three different pore sizes: 40, 90 and 117 A. The SBA-16 40 A did not retain any CPO. The nature and the pore size of the material affected the catalytic activity of the enzyme as well as its stability. Compared to the free enzyme, the thermal stability of CPO at 45 degrees C was two and three times higher than when immobilized on Al-MCM-41 and SBA-16 90 A, respectively.     

Amperometric biosensor based on enzymes immobilized in hybrid mesoporous membranes for the determination of acetylcholine

Acetylcholine sensor is successfully prepared by using immobilized enzymes, i.e., acetylcholinesterase and choline oxidase within separate hybrid mesoporous silica membranes with 12 nm pore diameter (F127M). The measurement was based on the detection of hydrogen peroxide produced by two sequential enzyme reactions. The determination range and the response time are 6.0–800 μM and within approximately 3 min, respectively. The sensor is very stable compared to free enzymes and 80% of the initial response was maintained even after storage for 80 days. These results show that two enzymes are successfully immobilized and well stabilized, and at the same time, two sequential enzyme reactions efficiently proceed within the separate hybrid mesoporous membranes. Further, we studied the possible detection of organophosphorus pesticides in terms of the inhibition of acetylcholinesterase activity, i.e., the decrease of current response, and demonstrated that the nanomolar concentrations of pesticide (DZN-oxon) can be detected with our sensor.