Respirometric 13C flux analysis, Part I: design, construction and validation of a novel multiple reactor system using on-line membrane inlet mass spectrometry

A novel method for (13)C flux analysis based on on-line CO(2) labeling measurements is presented. This so-called respirometric (13)C flux analysis requires multiple parallel (13)C labeling experiments using differently labeled tracer substrates. In Part I of the work, a membrane-inlet mass spectrometry-based measurement system with 6 parallel reactors with each 12 ml liquid volume and associated experimental and computational methods for the respirometric (13)C data acquisition and evaluation are described. Signal dynamics after switching between membrane probes follow exactly first-order allowing extrapolation to steady state. Each measurement cycle involving 3 reactors takes about 2 min. After development of a dynamic calibration method, the suitability and reliability of the analysis was examined with a lysine-producing mutant of Corynebacterium glutamicum using [1-(13)C(1)], [6-(13)C(1)], [1,6-(13)C(2)] glucose. Specific rates of oxygen uptake and CO(2) production were estimated with an error less than +/-0.3 mmol g(-1) h(-1) and had +/-3% to +/-10% deviations between parallel reactors which is primarily caused by inaccuracies in initial biomass concentration. The respiratory quotient could be determined with an uncertainty less than +/-0.02 and varied only +/-3% between reactors. Fractional labeling of CO(2) was estimated with much higher precision of about +/-0.001 to +/-0.005. The detailed statistical analysis suggested that these data should be of sufficient quality to allow physiological interpretation and metabolic flux estimation. The obtained data were applied for the respirometric (13)C metabolic flux analysis in Part II.     

Metabolic flux analysis of CHO cells at growth and non-growth phases using isotopic tracers and mass spectrometry

Chinese hamster ovary (CHO) cells are the main platform for production of biotherapeutics in the biopharmaceutical industry. However, relatively little is known about the metabolism of CHO cells in cell culture. In this work, metabolism of CHO cells was studied at the growth phase and early stationary phase using isotopic tracers and mass spectrometry. CHO cells were grown in fed-batch culture over a period of six days. On days 2 and 4, [1,2-¹³C] glucose was introduced and the labeling of intracellular metabolites was measured by gas chromatography-mass spectrometry (GC–MS) at 6, 12 and 24 h following the introduction of tracer. Intracellular metabolic fluxes were quantified from measured extracellular rates and ¹³C-labeling dynamics of intracellular metabolites using non-stationary ¹³C-metabolic flux analysis (¹³C-MFA). The flux results revealed significant rewiring of intracellular metabolic fluxes in the transition from growth to non-growth, including changes in energy metabolism, redox metabolism, oxidative pentose phosphate pathway and anaplerosis. At the exponential phase, CHO cell metabolism was characterized by a high flux of glycolysis from glucose to lactate, anaplerosis from pyruvate to oxaloacetate and from glutamate to α-ketoglutarate, and cataplerosis though malic enzyme. At the stationary phase, the flux map was characterized by a reduced flux of glycolysis, net lactate uptake, oxidative pentose phosphate pathway flux, and reduced rate of anaplerosis. The fluxes of pyruvate dehydrogenase and TCA cycle were similar at the exponential and stationary phase. The results presented here provide a solid foundation for future studies of CHO cell metabolism for applications such as cell line development and medium optimization for high-titer production of recombinant proteins.     

Metabolic profiling by 13C-NMR spectroscopy: [1,2-13C2]glucose reveals a heterogeneous metabolism in human leukemia T cells

Metabolic profiling is defined as the simultaneous assessment of substrate fluxes within and among the different pathways of metabolite synthesis and energy production under various physiological conditions. The use of stable-isotope tracers and the analysis of the distribution of labeled carbons in various intermediates, by both mass spectrometry and NMR spectroscopy, allow the role of several metabolic processes in cell growth and death to be defined. In the present paper we describe the metabolic profiling of Jurkat cells by isotopomer analysis using (13)C-NMR spectroscopy and [1,2-(13)C(2)]glucose as the stable-isotope tracer. The isotopomer analysis of the lactate, alanine, glutamate, proline, serine, glycine, malate and ribose-5-phosphate moiety of nucleotides has allowed original integrated information regarding the pentose phosphate pathway, TCA cycle, and amino acid metabolism in proliferating human leukemia T cells to be obtained. In particular, the contribution of the glucose-6-phosphate dehydrogenase and transketolase activities to phosphoribosyl-pyrophosphate synthesis was evaluated directly by the determination of isotopomers of the [1'-(13)C], [4',5'-(13)C(2)]ribosyl moiety of nucleotides. Furthermore, the relative contribution of the glycolysis and pentose cycle to lactate production was estimated via analysis of lactate isotopomers. Interestingly, pyruvate carboxylase and pyruvate dehydrogenase flux ratios measured by glutamate isotopomers and the production of isotopomers of several metabolites showed that the metabolic processes described could not take place simultaneously in the same macrocompartments (cells). Results revealed a heterogeneous metabolism in an asynchronous cell population that may be interpreted on the basis of different metabolic phenotypes of subpopulations in relation to different cell cycle phases.     

Integrated 13C-metabolic flux analysis of 14 parallel labeling experiments in Escherichia coli

The use of parallel labeling experiments for ¹³C metabolic flux analysis (¹³C-MFA) has emerged in recent years as the new gold standard in fluxomics. The methodology has been termed COMPLETE-MFA, short for complementary parallel labeling experiments technique for metabolic flux analysis. In this contribution, we have tested the limits of COMPLETE-MFA by demonstrating integrated analysis of 14 parallel labeling experiments with Escherichia coli. An effort on such a massive scale has never been attempted before. In addition to several widely used isotopic tracers such as [1,2-¹³C]glucose and mixtures of [1-¹³C]glucose and [U-¹³C]glucose, four novel tracers were applied in this study: [2,3-¹³C]glucose, [4,5,6-¹³C]glucose, [2,3,4,5,6-¹³C]glucose and a mixture of [1-¹³C]glucose and [4,5,6-¹³C]glucose. This allowed us for the first time to compare the performance of a large number of isotopic tracers. Overall, there was no single best tracer for the entire E. coli metabolic network model. Tracers that produced well-resolved fluxes in the upper part of metabolism (glycolysis and pentose phosphate pathways) showed poor performance for fluxes in the lower part of metabolism (TCA cycle and anaplerotic reactions), and vice versa. The best tracer for upper metabolism was 80% [1-¹³C]glucose+20% [U-¹³C]glucose, while [4,5,6-¹³C]glucose and [5-¹³C]glucose both produced optimal flux resolution in the lower part of metabolism. COMPLETE-MFA improved both flux precision and flux observability, i.e. more independent fluxes were resolved with smaller confidence intervals, especially exchange fluxes. Overall, this study demonstrates that COMPLETE-MFA is a powerful approach for improving flux measurements and that this methodology should be considered in future studies that require very high flux resolution.     

Rational design of 13C-labeling experiments for metabolic flux analysis in mammalian cells

ABSTRACT: BACKGROUND: 13C-Metabolic flux analysis (13C-MFA) is a standard technique to probe cellular metabolism and elucidate in vivo metabolic fluxes. 13C-Tracer selection is an important step in conducting 13C-MFA, however, current methods are restricted to trial-and-error approaches, which commonly focus on an arbitrary subset of the tracer design space. To systematically probe the complete tracer design space, especially for complex systems such as mammalian cells, there is a pressing need for new rational approaches to identify optimal tracers. RESULTS: Recently, we introduced a new framework for optimal 13C-tracer design based on elementary metabolite units (EMU) decomposition, in which a measured metabolite is decomposed into a linear combination of so-called EMU basis vectors. In this contribution, we applied the EMU method to a realistic network model of mammalian metabolism with lactate as the measured metabolite. The method was used to select optimal tracers for the two free fluxes in the system, the oxidative pentose phosphate pathway (oxPPP) flux and anaplerosis by pyruvate carboxylase (PC). Our approach was based on sensitivity analysis of EMU basis vector coefficients with respect to free fluxes. Through efficient grouping of coefficient sensitivities, simple tracer selection rules were derived for high-resolution quantification of the fluxes in the mammalian network model. The approach resulted in a significant reduction of the number of possible tracers and the feasible tracers were evaluated using numerical simulations. Two optimal, novel tracers were identified that have not been previously considered for 13C-MFA of mammalian cells, specifically [2,3,4,5,6-13C]glucose for elucidating oxPPP flux and [3,4-13C]glucose for elucidating PC flux. We demonstrate that 13C-glutamine tracers perform poorly in this system in comparison to the optimal glucose tracers. CONCLUSIONS: In this work, we have demonstrated that optimal tracer design does not need to be a pure simulation-based trial-and-error process; rather, rational insights into tracer design can be gained through the application of the EMU basis vector methodology. Using this approach, rational labeling rules can be established a priori to guide the selection of optimal 13C-tracers for high-resolution flux elucidation in complex metabolic network models.     

Glucose production, gluconeogenesis, and hepatic tricarboxylic acid cycle fluxes measured by nuclear magnetic resonance analysis of a single glucose derivative

A triple-tracer method was developed to provide absolute fluxes contributing to endogenous glucose production and hepatic tricarboxylic acid (TCA) cycle fluxes in 24-h-fasted rats by (2)H and (13)C nuclear magnetic resonance (NMR) analysis of a single glucose derivative. A primed, intravenous [3,4-(13)C(2)]glucose infusion was used to measure endogenous glucose production; intraperitoneal (2)H(2)O (to enrich total body water) was used to quantify sources of glucose (TCA cycle, glycerol, and glycogen), and intraperitoneal [U-(13)C(3)] propionate was used to quantify hepatic anaplerosis, pyruvate cycling, and TCA cycle flux. Plasma glucose was converted to monoacetone glucose (MAG), and a single (2)H and (13)C NMR spectrum of MAG provided the following metabolic data (all in units of micromol/kg/min; n = 6): endogenous glucose production (40.4+/-2.9), gluconeogenesis from glycerol (11.5+/-3.5), gluconeogenesis from the TCA cycle (67.3+/-5.6), glycogenolysis (1.0+/-0.8), pyruvate cycling (154.4+/-43.4), PEPCK flux (221.7+/-47.6), and TCA cycle flux (49.1+/-16.8). In a separate group of rats, glucose production was not different in the absence of (2)H(2)O and [U-(13)C]propionate, demonstrating that these tracers do not alter the measurement of glucose turnover.     

Modeling and experimental design for metabolic flux analysis of lysine-producing Corynebacteria by mass spectrometry

Experimental design of (13)C-tracer studies for metabolic flux analysis with mass spectrometric determination of labeling patterns was performed for the central metabolism of Corynebacterium glutamicum comprising various flux scenarios. Ratio measurement of mass isotopomer pools of Corynebacterium products lysine, alanine, and trehalose is sufficient to quantify the flux partitioning ratios (i) between glycolysis and pentose phosphate pathways (Phi(PPP)), (ii) between the split pathways in the lysine biosynthesis (Phi(DH)), (iii) at the pyruvate node (Phi(PC)), and reversibilities of (iv) glucose 6-phosphate isomerase (zeta(PGI)), (v) at the pyruvate node (zeta(PC/PEPCK)), and (vi) of transaldolase and transketolases in the PPP. Weighted sensitivities for flux parameters were derived from partial derivatives to quantitatively evaluate experimental approaches and predict precision for estimated flux parameters. Deviation of intensity ratios from ideal values of 1 was used as weighting function. Weighted flux sensitivities can be used to identify optimal type and degree of tracer labeling or potential intensity ratios to be measured. Experimental design for lysine-producing strain C. glutamicum MH 20-22B (Marx et al., Biotechnol. Bioeng. 49, 111-129, 1996) and various potential mutants with different alterations in the flux pattern showed that specific tracer labelings are optimal to quantify a certain flux parameter uninfluenced by the overall flux situation. Identified substrates of choice are [1-(13)C]glucose for the estimation of Phi(PPP) and zeta(PGI) and a 1 : 1 mixture of [U-(12)C/U-(13)C]glucose for the determination of zeta(PC/PEPCK). Phi(PC) can be quantified by feeding [4-(13)C]glucose or [U-(12)C/U-(13)C]glucose (1 : 1), whereas Phi(DH) is accessible via [4-(13)C]glucose. The sensitivity for the quantification of a certain flux parameter can be influenced by superposition through other flux parameters in the network, but substrate and measured mass isotopomers of choice remain the same. In special cases, reduced labeling degree of the tracer substrate can increase the precision of flux analysis. Enhanced precision and flux information can be achieved via multiply labeled substrates. The presented approach can be applied for effective experimental design of (13)C tracer studies for metabolic flux analysis. Intensity ratios of other products such as glutamate, valine, phenylalanine, and riboflavin also sensitively reflect flux parameters, which underlines the great potential of mass spectrometry for flux analysis.     

Optimization of 13C isotopic tracers for metabolic flux analysis in mammalian cells

Mammalian cells consume and metabolize various substrates from their surroundings for energy generation and biomass synthesis. Glucose and glutamine, in particular, are the primary carbon sources for proliferating cancer cells. While this combination of substrates generates static labeling patterns for use in (13)C metabolic flux analysis (MFA), the inability of single tracers to effectively label all pathways poses an obstacle for comprehensive flux determination within a given experiment. To address this issue we applied a genetic algorithm to optimize mixtures of (13)C-labeled glucose and glutamine for use in MFA. We identified tracer combinations that minimized confidence intervals in an experimentally determined flux network describing central carbon metabolism in tumor cells. Additional simulations were used to determine the robustness of the [1,2-(13)C(2)]glucose/[U-(13)C(5)]glutamine tracer combination with respect to perturbations in the network. Finally, we experimentally validated the improved performance of this tracer set relative to glucose tracers alone in a cancer cell line. This versatile method allows researchers to determine the optimal tracer combination to use for a specific metabolic network, and our findings applied to cancer cells significantly enhance the ability of MFA experiments to precisely quantify fluxes in higher organisms.     

Application of MALDI-TOF MS to lysine-producing Corynebacterium glutamicum: a novel approach for metabolic flux analysis.

In the present work, a novel comprehensive approach of (13)C-tracer studies with labeling measurements by MALDI-TOF MS, and metabolite balancing was developed to elucidate key fluxes in the central metabolism of lysine producing Corynebacterium glutamicum during batch culture. MALDI-TOF MS methods established allow the direct quantification of labeling patterns of low molecular mass Corynebacterium products from 1 microL of diluted culture supernatant. A mathematical model of the central Corynebacterium metabolism was developed, that describes the carbon transfer through the network via matrix calculations in a generally applicable way and calculates steady state mass isotopomer distributions of the involved metabolites. The model was applied for both experimental planning of tracer experiments and parameter estimation. Metabolic fluxes were calculated from stoichiometric data and from selected mass intensity ratios of lysine, alanine, and trehalose measured by MALDI-TOF MS in tracer experiments either with 1-(13)C glucose or with mixtures of (13)C6/(12)C6 glucose. During the phase of maximum lysine production C. glutamicum ATCC 21253 exhibited high relative fluxes into the pentose phosphate pathway of 71%, a highly reversible glucose-6-phosphate isomerase, significant backfluxes from the tricarboxylic acid cycle to the pyruvate node consuming the lysine precursor oxaloacetate, 36% net flux of anaplerotic carboxylation and 63% contribution of the dehydrogenase branch in the lysine biosynthetic pathway. Due to the straightforward and simple measurements of selected labeling patterns by MALDI-TOF MS sensitively reflecting the flux parameters of interest, the presented approach has an excellent potential to extend metabolic flux analysis from single experiments with enormous experimental effort to a broadly applied technique.     

Elucidating the role of copper in CHO cell energy metabolism using 13C metabolic flux analysis

¹³C‐metabolic flux analysis was used to understand copper deficiency‐related restructuring of energy metabolism, which leads to excessive lactate production in recombinant protein‐producing CHO cells. Stationary‐phase labeling experiments with U‐¹³C glucose were conducted on CHO cells grown under high and limiting copper in 3 L fed‐batch bioreactors. The resultant labeling patterns of soluble metabolites were measured by GC‐MS and used to estimate metabolic fluxes in the central carbon metabolism pathways using OpenFlux. Fluxes were evaluated 300 times from stoichiometrically feasible random guess values and their confidence intervals calculated by Monte Carlo simulations. Results from metabolic flux analysis exhibited significant carbon redistribution throughout the metabolic network in cells under Cu deficiency. Specifically, glycolytic fluxes increased (25%–79% relative to glucose uptake) whereas fluxes through the TCA and pentose phosphate pathway (PPP) were lower (15%–23% and 74%, respectively) compared with the Cu‐containing condition. Furthermore, under Cu deficiency, 33% of the flux entering TCA via the pyruvate node was redirected to lactate and malate production. Based on these results, we hypothesize that Cu deficiency disrupts the electron transport chain causing ATP deficiency, redox imbalance, and oxidative stress, which in turn drive copper‐deficient CHO cells to produce energy via aerobic glycolysis, which is associated with excessive lactate production, rather than the more efficient route of oxidative phosphorylation. © 2015 American Institute of Chemical Engineers Biotechnol. Prog., 31:1179–1186, 2015     

Metabolic flux analysis in Escherichia coli by integrating isotopic dynamic and isotopic stationary 13C labeling data

The novel concept of isotopic dynamic 13C metabolic flux analysis (ID-13C MFA) enables integrated analysis of isotopomer data from isotopic transient and/or isotopic stationary phase of a 13C labeling experiment, short-time experiments, and an extended range of applications of 13C MFA. In the presented work, an experimental and computational framework consisting of short-time 13C labeling, an integrated rapid sampling procedure, a LC-MS analytical method, numerical integration of the system of isotopomer differential equations, and estimation of metabolic fluxes was developed and applied to determine intracellular fluxes in glycolysis, pentose phosphate pathway (PPP), and citric acid cycle (TCA) in Escherichia coli grown in aerobic, glucose-limited chemostat culture at a dilution rate of D = 0.10 h(-1). Intracellular steady state concentrations were quantified for 12 metabolic intermediates. A total of 90 LC-MS mass isotopomers were quantified at sampling times t = 0, 91, 226, 346, 589 s and at isotopic stationary conditions. Isotopic stationarity was reached within 10 min in glycolytic and PPP metabolites. Consistent flux solutions were obtained by ID-13C MFA using isotopic dynamic and isotopic stationary 13C labeling data and by isotopic stationary 13C MFA (IS-13C MFA) using solely isotopic stationary data. It is demonstrated that integration of dynamic 13C labeling data increases the sensitivity of flux estimation, particularly at the glucose-6-phosphate branch point. The identified split ratio between glycolysis and PPP was 55%:44%. These results were confirmed by IS-13C MFA additionally using labeling data in proteinogenic amino acids (GC-MS) obtained after 5 h from sampled biomass.     

Examination of primary metabolic pathways in a murine hybridoma with carbon-13 nuclear magnetic resonance spectroscopy

Primary metabolism of a murine hybridoma was probed with (13)C nuclear magnetic resonance (NMR) spectroscopy. Cells cultured in a hollow fiber bioreactor were serially infused with [1-(13)C] glucose, [2-(13)C] glucose, and [3-(13)C] glutamine. In vivo spectroscopy of the culture was used in conjunction with off-line spectroscopy of the medium to determine the intracellular concentration of several metabolic intermediates and to determine fluxes for primary metabolic pathways. Intracellular concentrations of pyruvate and alanine were very high relative to levels observed in normal quiescent mammalian cells. Estimates made from labeling patterns in lactate indicate that 76% of pyruvate is derived directly from glycolysis; some is also derived from the malate shunt, the pyruvate/melate shuttle associated with lipid synthesis and the pentose phosphate pathway. The rate of formation of pyruvate from the pentose phosphate pathway was estimated to be 4% of that from glycolysis; This value is a lower limit and the actual value may be higher. Incorporation of pyruvate into the tricarboxylic acid (TCA) cycle appears to occur through only pyruvate dehydrogenase; no pyruvate carboxylase activity was detected. The malate shunt rate was approximately equal to the rate of glutamine uptake. The rate of incorporation of glucosederived acetyl-CoA into lipids was 4% of the glucose uptake rate. The TCA cycle rate between isocitrate and alpha-ketoglutarate was 110% of the glutamine uptake rate. (c) 1994 John Wiley & Sons, Inc.     

Parallel labeling experiments with [U-(13)C]glucose validate E. coli metabolic network model for (13)C metabolic flux analysis

(13)C-metabolic flux analysis (MFA) is a widely used method for measuring intracellular metabolic fluxes in living cells. (13)C MFA relies on several key assumptions: (1) the assumed metabolic network model is complete, in that it accounts for all significant enzymatic and transport reactions; (2) (13)C-labeling measurements are accurate and precise; and (3) enzymes and transporters do not discriminate between (12)C- and (13)C-labeled metabolites. In this study, we tested these inherent assumptions of (13)C MFA for wild-type E. coli by parallel labeling experiments with [U-(13)C]glucose as tracer. Cells were grown in six parallel cultures in custom-constructed mini-bioreactors, starting from the same inoculum, on medium containing different mixtures of natural glucose and fully labeled [U-(13)C]glucose, ranging from 0% to 100% [U-(13)C]glucose. Macroscopic growth characteristics of E. coli showed no observable kinetic isotope effect. The cells grew equally well on natural glucose, 100% [U-(13)C]glucose, and mixtures thereof. (13)C MFA was then used to determine intracellular metabolic fluxes for several metabolic network models: an initial network model from literature; and extended network models that accounted for potential dilution effects of isotopic labeling. The initial network model did not give statistically acceptable fits and produced inconsistent flux results for the parallel labeling experiments. In contrast, an extended network model that accounted for dilution of intracellular CO(2) by exchange with extracellular CO(2) produced statistically acceptable fits, and the estimated metabolic fluxes were consistent for the parallel cultures. This study illustrates the importance of model validation for (13)C MFA. We show that an incomplete network model can produce statistically unacceptable fits, as determined by a chi-square test for goodness-of-fit, and return biased metabolic fluxes. The validated metabolic network model for E. coli from this study can be used in future investigations for unbiased metabolic flux measurements.     

Metabolic flux analysis of CHO cells in perfusion culture by metabolite balancing and 2D [13C, 1H] COSY NMR spectroscopy

The physiological state of CHO cells in perfusion culture was quantified by determining fluxes through the bioreaction network using ¹³C glucose and 2D-NMR spectroscopy. CHO cells were cultivated in a 2.5 L perfusion bioreactor with glucose and glutamine as the primary carbon and energy sources. The reactor was inoculated at a cell density of 8×10⁶ cells/mL and operated at ～10×10⁶ cells/mL using unlabeled glucose for the first 13 days. The second phase lasted 12 days and the medium consisted of 10% [U-¹³C]glucose, 40% labeled [1-¹³C]glucose with the balance unlabeled. After the culture attained isotopic steady state, biomass samples from the last 3 days of cultivation were considered representative and used for flux estimation. They were hydrolyzed and analyzed by 2D [¹³C, ¹H] COSY measurements using the heteronuclear single quantum correlation sequence with gradients for artifacts suppression. Metabolic fluxes were determined using the 13C-Flux software package by minimizing the residuals between the experimental and the simulated NMR data. Normalized residuals exhibited a Gaussian distribution indicating good model fit to experimental data. The glucose consumption rate was 5-fold higher than that of glutamine with 41% of glucose channeled through the pentose phosphate pathway. The fluxes at the pyruvate branch point were almost equally distributed between lactate and the TCA cycle (55% and 45%, respectively). The anaplerotic conversion of pyruvate to oxaloacetate by pyruvate carboxylase accounted for 10% of the pyruvate flux with the remaining 90% entering the TCA cycle through acetyl-CoA. The conversion of malate to pyruvate catalyzed by the malic enzyme was 70% higher than that for the anaplerotic reaction catalyzed by pyruvate carboxylase. Most amino acid catabolic and biosynthetic fluxes were significantly lower than the glycolytic and TCA cycle fluxes. Metabolic flux data from NMR analysis validated a simplified model where metabolite balancing was used for flux estimation. In this reduced flux space, estimates from these two methods were in good agreement. This simplified model can routinely be used in bioprocess development experiments to estimate metabolic fluxes with much reduced analytical investment. The high resolution flux information from 2D-NMR spectroscopy coupled with the capability to validate a simplified metabolite balancing based model for routine use make ¹³C-isotopomer analysis an attractive bioprocess development tool for mammalian cell cultures.     

Comparative study on central metabolic fluxes of <Emphasis Type="Italic">Bacillus megaterium</Emphasis> strains in continuous culture using <Superscript>13</Superscript>C labelled substrates

Fluxes of central carbon metabolism [glycolysis, pentose phosphate pathway (PPP), tricarboxylic acid cycle (TCA cycle), biomass formation] were determined for several Bacillus megaterium strains (DSM319, WH320, WH323, MS941) in C- and N-limited chemostat cultures by ¹³C labelling experiments. The labelling patterns of proteinogenic amino acids were analysed by GC/MS and therefrom flux ratios at important nodes within the metabolic network could be calculated. On the basis of a stoichiometric metabolic model flux distributions were estimated for the different B. megaterium strains used at various cultivation conditions. Generally all strains exhibited similar metabolic flux distributions, however, several significant changes were found in (1) the glucose flux entering the PPP via the oxidative branch, (2) the reversibilities within the PPP, (3) the relative fluxes of pyruvate and acetyl-CoA fed to the TCA cycle, (4) the fluxes around the pyruvate node involving a futile cycle.     

Rates of flux through the pentose cycle in perfused rat liver. A procedure for the calculation of rates of substrate flux from 14CO2 production from [1-14C]glucose

A method for the determination of substrate flux through the pentose cycle was developed employing [1-14C]glucose in experiments with perfused rat livers. The method consists first of a kinetic analysis which differentiates between the production of 14CO2 from [1-14C]glucose via the pentose cycle and via the citrate cycle and, second of a calculation of the specific radioactivity of the hexose monophosphate pool from measured rates of glycolysis and the specific radioactivity of lactate released into the perfusate. The method was validated by experiments comparing the results of tracer infusions with [1-14C]glucose, [6-14C]glucose and [3-14C]pyruvate. In livers from fed rats perfused with 10 mM glucose, the rate of substrate flux through the pentose cycle was around 0.2 mumol X min-1 X g-1; it was about 20% of the substrate flux via glycolysis. The kinetic data were inconsistent with the existence of an L-type pentose cycle in liver.     

Shewanella oneidensis MR-1 fluxome under various oxygen conditions

The central metabolic fluxes of Shewanella oneidensis MR-1 were examined under carbon-limited (aerobic) and oxygen-limited (microaerobic) chemostat conditions, using 13C-labeled lactate as the sole carbon source. The carbon labeling patterns of key amino acids in biomass were probed using both gas chromatography-mass spectrometry (GC-MS) and 13C nuclear magnetic resonance (NMR). Based on the genome annotation, a metabolic pathway model was constructed to quantify the central metabolic flux distributions. The model showed that the tricarboxylic acid (TCA) cycle is the major carbon metabolism route under both conditions. The Entner-Doudoroff and pentose phosphate pathways were utilized primarily for biomass synthesis (with a flux below 5% of the lactate uptake rate). The anaplerotic reactions (pyruvate to malate and oxaloacetate to phosphoenolpyruvate) and the glyoxylate shunt were active. Under carbon-limited conditions, a substantial amount (9% of the lactate uptake rate) of carbon entered the highly reversible serine metabolic pathway. Under microaerobic conditions, fluxes through the TCA cycle decreased and acetate production increased compared to what was found for carbon-limited conditions, and the flux from glyoxylate to glycine (serine-glyoxylate aminotransferase) became measurable. Although the flux distributions under aerobic, microaerobic, and shake flask culture conditions were different, the relative flux ratios for some central metabolic reactions did not differ significantly (in particular, between the shake flask and aerobic-chemostat groups). Hence, the central metabolism of S. oneidensis appears to be robust to environmental changes. Our study also demonstrates the merit of coupling GC-MS with 13C NMR for metabolic flux analysis to reduce the use of 13C-labeled substrates and to obtain more-accurate flux values.     

Metabolic-flux analysis of continuously cultured hybridoma cells using (13)CO(2) mass spectrometry in combination with (13)C-lactate nuclear magnetic resonance spectroscopy and metabolite balancing

Protein production of mammalian-cell culture is limited due to accumulation of waste products such as lactate, CO(2), and ammonia. In this study, the intracellular fluxes of hybridoma cells are measured to determine the amount by which various metabolic pathways contribute to the secretion of waste products derived from glucose. Continuously cultured hybridoma cells are grown in medium containing either 1-(13)C-, 2-(13)C-, or 6-(13)C-glucose. The uptake and production rates of amino acids, glucose, ammonia, O(2), and CO(2) as well as the cellular composition are measured. In addition, the (13)C distribution of the lactate produced and alanine produced by the hybridomas is determined by (1)H-NMR spectroscopy, and the (13)CO(2)/(12)CO(2) ratio is measured by on-line mass spectrometry. These data are used to calculate the intracellular fluxes of the glycolysis, the pentose phosphate pathway, the TCA cycle, and fluxes involved in amino acid metabolism. It is shown that: (i) approximately 20% of the glucose consumed is channeled through the pentose shunt; (ii) the glycolysis pathway contributes the most to lactate production, and most of the CO(2) is produced by the TCA cycle; (iii) the pyruvate-carboxylase flux is negligibly small; and (iv) the malic-enzyme flux is estimated to be 10% of the glucose uptake rate. Based on these flux data suggestions are made to engineer a more efficient glucose metabolism in mammalian cells.     

Characterization of central carbon metabolism of Streptococcus pneumoniae by isotopologue profiling

The metabolism of Streptococcus pneumoniae was studied by isotopologue profiling after bacterial cultivation in chemically defined medium supplemented with [U-(13)C(6)]- or [1,2-(13)C(2)]glucose. GC/MS analysis of protein-derived amino acids showed lack of (13)C label in amino acids that were also essential for pneumococcal growth. Ala, Ser, Asp, and Thr displayed high (13)C enrichments, whereas Phe, Tyr, and Gly were only slightly labeled. The analysis of the labeling patterns showed formation of triose phosphate and pyruvate via the Embden-Meyerhof-Parnas pathway. The labeling patterns of Asp and Thr suggested formation of oxaloacetate exclusively via the phosphoenolpyruvate carboxylase reaction. Apparently, α-ketoglutarate was generated from unlabeled glutamate via the aspartate transaminase reaction. A fraction of Phe and Tyr obtained label via the chorismate route from erythrose 4-phosphate, generated via the pentose phosphate pathway, and phosphoenolpyruvate. Strikingly, the data revealed no significant flux from phosphoglycerate to Ser and Gly but showed formation of Ser via the reverse reaction, namely by hydroxymethylation of Gly. The essential Gly was acquired from the medium, and the biosynthesis pathway was confirmed in experiments using [U-(13)C(2)]glycine as a tracer. The hydroxymethyl group in Ser originated from formate, which was generated by the pyruvate formate-lyase. Highly similar isotopologue profiles were observed in corresponding experiments with pneumococcal mutants deficient in PavA, CodY, and glucose-6-phosphate dehydrogenase pointing to the robustness of the core metabolic network used by these facultative pathogenic bacteria. In conclusion, this study demonstrates the dual utilization of carbohydrates and amino acids under in vitro conditions and identifies the unconventional de novo biosynthesis of serine by pneumococci.     

Metabolic flux variation of Saccharomyces cerevisiae cultivated in a multistage continuous stirred tank reactor fermentation environment.

The technique of metabolic flux analysis was implemented to elucidate the flux balancing of Saccharomyces cerevisiae cultivated in a multistage continuous stirred tank reactor fermentation environment. The results showed that the majority of the substrate (97.70 +/- 0.49%) was funneled into the glycolytic pathway, while the remainder was subdivided between the pentose phosphate pathway and pathways for polysaccharide synthesis. At the pyruvate node, 87.30 +/- 1.38% of the flux was channeled through the reaction governed by pyruvate decarboxylase. Fluxes through the pyruvate dehydrogenase bypass were maintained at a constant level (82.65 +/- 1.47%) irrespective of the configuration of the fermentation setup. Activity through the TCA "cycle" was replenished by the reaction catalyzed by pyruvate carboxylase and by the transport of cytosolic oxaloacetate across the mitochondrial membrane. The CO(2) evolution rate varied as fermentation progressed; however, the yield coefficient of CO(2) remained at a constant value. Although a constant yield of ethanol (0.42 g of ethanol/g of glucose) was obtained, operations of the TCA cycle were gradually switched from partially reductive to partially oxidative pathways from the first fermenter to the fourth fermenter.