发酵性丝孢酵母HWZ004利用水稻秸秆水解液发酵产油脂

为高效利用水稻秸秆中的纤维素和半纤维素产油脂,采用稀酸预处理和酶水解两步法对水稻秸秆进行水解,然后以水解液为碳源,培养发酵性丝孢酵母Trichosporon fermentans HWZ004产微生物油脂。结果表明,经简单overliming法脱毒后水稻秸秆水解液中乙酸、糠醛和5-羟甲基糠醛的浓度分别为0.4 g/L、0.1 g/L和0.05 g/L。只需添加少量氮源和微量CuSO4?5H2O,该水解液即可满足T. fermentans HWZ004发酵产油脂的要求。发酵最适接种量、初始pH和温度分别是5.0％、7.0和25 ℃。T. fermentans HWZ004在优化条件下培养7 d的生物量、油脂含量和油脂产量分别是26.4 g/L,52.2％和13.8 g/L;油脂得率系数为17.0,大大高于驯化前菌株T. fermentans CICC 1368在脱毒水稻秸秆半纤维素水解液中的对应值 (11.9)。所产油脂的脂肪酸组成与植物油相似,不饱和脂肪酸含量达70％以上,宜作为生物柴油的生产原料。     

亚硫酸盐甘蔗渣浆酶解液发酵制备乙醇

以亚硫酸盐甘蔗渣浆酶解液作为原料,利用C. shehatae发酵制取燃料乙醇。结果表明：还原糖最适初始质量浓度为葡萄糖140 g/L、木糖60 g/L、酶解液总糖80 g/L。利用初始葡萄糖55.06 g/L、木糖11.18 g/L、纤维二糖4.51 g/L的亚硫酸盐甘蔗渣浆酶解液发酵,经18 h获得乙醇22.98 g/L。乙醇得率为67.23%,葡萄糖利用率为99.27%,木糖利用率为32.96%,C. shehatae适合作为蔗渣为原料的乙醇发酵菌株。     

响应面法优化木薯淀粉发酵生产单细胞油脂工艺

采用响应面分析法对发酵性丝孢酵母菌株以木薯淀粉水解液为原料合成微生物油脂的培养条件进行优化。首先利用Plackett-Burman试验设计确定影响油脂产量的主要因素,在此基础上再利用Box-Behnken试验设计及响应面分析法对其进行条件优化。结果表明,发酵温度、C/N、pH对油脂产量具有显著影响,产油脂的最佳发酵条件为:发酵温度28.78°C、C/N 126.18、pH 6.69,油脂产量达到14.88g/L,比优化前提高了28.6%。同时,气相色谱分析表明,微生物油脂脂肪酸组成成分主要包括棕榈酸、硬脂酸、油酸、亚油酸酯等,是优良的生物柴油制备原料。     

Beneficial Effect of Corncob Acid Hydrolysate on the Lipid Production by Oleaginous Yeast Trichosporon dermatis

In this work, corncob acid hydrolysate and its simulated medium whose sugar composition was the same as the corncob acid hydrolysate were used as fermentation substrate for lipid production by oleaginous yeast Trichosporon dermatis. On the corncob acid hydrolysate, after 7 days of fermentation, the biomass, lipid content, lipid yield, and lipid coefficient of T. dermatis were 17.3 g/L, 40.2%, 7.0 g/L, and 16.5%, respectively. Interestingly, during the lipid fermentation on the corncob acid hydrolysate, glucose, xylose, arabinose, and even acetic acid could be well utilized as carbon sources by T. dermatis. Surprisingly, the lipid yield (7.0 g/L) of T. dermatis on the corncob acid hydrolysate was much higher than that (3.8 g/L) on the simulated medium, in spite of the fact that the lipid coefficient (17.4%) on the simulated medium was a little higher. This phenomenon further showed that lignocellulosic acid hydrolysate was a suitable substrate for lipid fermentation by T. dermatis. This work would help the comprehensive utilization of lignocellulosic biomass for lipid production.     

甘蔗渣和糖蜜混合发酵制备燃料丁醇

以抗逆突变株Clostridium beijerinckii IB4为研究对象,葡萄糖为C源,对其进行补料分批发酵过程的优化,同时将该优化工艺应用于甘蔗渣和糖蜜混合发酵制备燃料丁醇。结果表明:在5 L发酵罐中,先加入作为还原糖的甘蔗渣酸解糖液10 g/L,16 h后补加甘蔗糖蜜30 g/L,于35℃、100 r/min发酵50 h,丁醇和总溶剂产量分别达到11.1和15.3 g/L,丁醇比例高达72.5%。     

酵母发酵蔗渣半纤维素水解物生产木糖酶

采用二次正交旋转组合设计研究了蔗渣半纤维素水解过程中硫酸浓度与液 固比对木糖收率的影响。回归分析表明 ,这两个因素与木糖的收率之间存在显著的回归关系。通过回归方程优化水解条件 ,当硫酸浓度 2 .4g L ,液 固 =6 .2 ,在蒸汽压力 2 .5× 10 4Pa的条件下水解 2 .5h ,10 0g蔗渣可水解生成木糖约 2 4g。大孔树脂吸附层析处理蔗渣半纤维素水解物 ,能有效地减少其中的酵母生长抑制物含量 ,显著改善水解物的发酵性能。用大孔树脂在pH 2条件下处理过的蔗渣半纤维素水解物作基质 ,含木糖 2 0 0g L ,产木糖醇酵母菌株CandidatropicalisAS2 .1776发酵 110h耗完基质中的木糖 ,生成木糖醇 12 7g L ,产物转化率 0 .6 4(木糖醇g 木糖g) ,产物生成速率 1.15g L·h .     

利用甘蔗糖蜜发酵生产花生四烯酸的研究

通过培养高山被孢霉利用糖蜜来发酵生产花生四烯酸(ARA),研究了不同甘蔗糖蜜预处理方法对ARA发酵生产的影响。研究表明:H2SO4法是最利于ARA发酵生产的糖蜜预处理方法。利用预处理的甘蔗糖蜜发酵生产ARA,通过单因素实验设计,确定了最优的培养条件,包括初始还原糖80 g/L,N源6 g/L,接种量20%,初始pH6.0和培养温度25℃,在此条件下发酵,干细胞质量、油脂含量、ARA产量和糖利用率分别达到28.5 g/L、11.7g/L、3.68 g/L和94.5%。     

Enhanced production of raw starch degrading enzyme using agro-industrial waste mixtures by thermotolerant Rhizopus microsporus for raw cassava chip saccharification in ethanol production

In the present study, solid-state fermentation for the production of raw starch degrading enzyme was investigated by thermotolerant Rhizopus microsporus TISTR 3531 using a combination of agro-industrial wastes as substrates. The obtained crude enzyme was applied for hydrolysis of raw cassava starch and chips at low temperature and subjected to nonsterile ethanol production using raw cassava chips. The agro-industrial waste ratio was optimized using a simplex axial mixture design. The results showed that the substrate mixture consisting of rice bran:corncob:cassava bagasse at 8?g:10?g:2?g yielded the highest enzyme production of 201.6?U/g dry solid. The optimized condition for solid-state fermentation was found as 65% initial moisture content, 35°C, initial pH of 6.0, and 5?×?10⁶ spores/mL inoculum, which gave the highest enzyme activity of 389.5?U/g dry solid. The enzyme showed high efficiency on saccharification of raw cassava starch and chips with synergistic activities of commercial α-amylase at 50°C, which promotes low-temperature bioethanol production. A high ethanol concentration of 102.2?g/L with 78% fermentation efficiency was achieved from modified simultaneous saccharification and fermentation using cofermentation of the enzymatic hydrolysate of 300?g raw cassava chips/L with cane molasses.     

Efficient lipid production with Trichosporon fermentans and its use for biodiesel preparation

Effects of medium components and culture conditions on biomass and lipid production of Trichosporon fermentans were studied. The optimal nitrogen source, carbon source and C/N molar ratio were peptone, glucose and 163, respectively. The favorable initial pH of the medium and temperature were 6.5 and 25 degrees C. Under the optimized conditions, a biomass of 28.1 g/l and a lipid content of 62.4% could be achieved after culture for 7 days, which were much higher than the original values (19.4 g/l and 50.8%) and the results reported by other groups. T. fermentans could grow well in pretreated waste molasses and a lipid yield of 12.8 g/l could be achieved with waste molasses of 15% total sugar concentration (w/v) at pH 6.0, representing the best result with oleaginous microorganisms on agro-industrial residues. Addition of various sugars to the pretreated molasses could efficiently enhance the accumulation of lipid and the lipid content reached as high as above 50%. Similar to vegetable oils, the lipid mainly contains palmitic acid, stearic acid, oleic acid and linoleic acid and the unsaturated fatty acids amount to about 64% of the total fatty acids. The microbial oil with an acid value of 5.6 mg KOH/g was transesterified to biodiesel by base catalysis after removal of free fatty acids and a high methyl ester yield of 92% was obtained.     

玉米芯稀酸水解及L-乳酸发酵研究

对玉米芯稀硫酸水解条件及糖化液发酵L-乳酸进行了初步研究。结果表明,玉米芯木聚糖最适水解条件为2%H2SO_4、120℃、30 min、固液比1:10,糖化液还原糖含量可达40.8 g/L,主要成分为木塘。细菌A-19可以利用水解液中的葡萄糖和木糖产酸,最适发酵条件为45℃、pH 6.5,从45℃～51℃、pH 5.5～pH 6.5产量均较高。用未浓缩的水解液发酵24 h,L-乳酸产量为30.6g/L,残糖为1.6 g/L,糖酸转化率为82.6%;用浓缩1倍的水解液发酵48 h,L-乳酸产量为41.4 g/L,残糖4.1g/L,糖酸转化率为68.2%,在发酵48 h后继续补料发酵至72 h(补料液为浓缩3倍的水解液),L-乳酸产量为50.9 g/L,残糖6.3 g/L,糖酸转化率为71.8%。该研究为利用木质纤维素生产L-乳酸奠定了一定基础。     

采用玉米秸秆水解糖和玉米浆发酵生产丁二酸

研究了以玉米秸秆水解糖为碳源,不同氮源条件下琥珀酸放线杆菌Actinobacillus succinogenesSF-9的丁二酸发酵产酸能力。结果表明玉米浆可以替代酵母膏作为丁二酸发酵的廉价氮源。厌氧摇瓶丁二酸发酵单因素试验,得到在初糖浓度50 g/L时,玉米浆的较佳用量为20 g/L。在5 L搅拌罐上,考察了不同初始玉米秸秆水解糖浓度对A.succinogenes SF-9发酵生产丁二酸的影响,结果显示高初始秸秆糖浓度对琥珀酸放线杆菌的生长有抑制作用。采用补料分批发酵,发酵60 h丁二酸的产量达到42.7g/L,丁二酸产率82.7%,生产强度0.81 g/(L·h)。丁二酸的产量和生产强度较分批发酵有明显提高。     

双液相体系强化氧传递促进微生物油脂生产

文中通过添加氧载体正十二烷进行双液相发酵来提高发酵性丝孢酵母利用木薯淀粉水解液生产微生物油脂的产量。结果表明,在摇瓶发酵液中添加氧载体,能明显缓解发酵过程中的氧限制程度。在2 L发酵罐中添加1%正十二烷进行双液相高密度发酵,其发酵生物量和油脂产量分别达到101.2 g/L和50.28 g/L。气相色谱分析表明,添加了氧载体发酵的微生物油脂中含有更高的饱和脂肪酸含量。     

Fermentation of Detoxified Acid-Hydrolyzed Pyrolytic Anhydrosugars into Bioethanol with <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis> 2.399

Pyrolysate obtained from the pyrolysis of waste cotton is a source of fermentable sugars that could be fermented into bioethanol fuel and other chemicals via microbial fermentation. However, pyrolysate is a complex mixture of fermentable and non-fermentable substrates causing inhibition of the microbial growth. The aim of this study was to detoxify the hydrolysate and then ferment it into bio-ethanol fuel in shake flasks and fermenter applying yeast strain Saccharomyces cerevisiae 2.399. Pyrolysate was hydrolyzed to glucose with 0.2 M sulfuric acid, neutralized with Ba(OH)₂ followed by treatment with ethyl acetate and activated carbon to remove fermentation inhibitors. The effect of various fermentation parameters such as inoculum concentration, pH and hydrolysate glucose was evaluated in shake flasks for optimum ethanol fermentation. With respect to inoculum concentration, 20% v/v inoculum i.e. 8.0 × 10⁸–1.2 × 10⁹ cells/mL was the optimum level for producing 8.62 ± 0.33 g/L ethanol at 9 h of fermentation with a maximum yield of 0.46 g ethanol/g glucose. The optimum pH for hydrolysate glucose fermentation was found to be 6.0 that produced 8.57 ± 0.66 g/L ethanol. Maximum ethanol concentration, 14.78 g/L was obtained for 4% hydrolysate glucose concentration after 16 h of fermentation. Scale-up studies in stirred fermenter produced much higher productivity (1.32 g/L/h^–1) compared to shake flask fermentation (0.92 g/L/h^–1). The yield of ethanol reached a maximum of 91% and 89% of the theoretical yield of ethanol in shake flasks and fermenter, respectively. The complex of integrated models of development was applied, that has been successfully tested previously for the mathematical analysis of the fermentation processes.     

皮状丝孢酵母B3利用木薯淀粉发酵生产微生物油脂

对皮状丝孢酵母B3以木薯淀粉水解液为碳源发酵生产微生物油脂培养条件进行了优化,并在2 L发酵罐中对菌体生长和油脂积累进行了考察。摇瓶实验表明,木薯淀粉水解液的浓度高于90 g/L时不利于菌体的生长和油脂积累,皮状丝孢酵母B3发酵生产微生物油脂的最适氮源及其浓度、最适C/N比和pH分别为酵母提取物3.0 g/L、116、6.0,在此条件下培养144 h菌体生物量、油脂产量和油脂含量分别达到15.2 g/L、6.22 g/L和40.9％;在2 L发酵罐中分批发酵44 h后菌体生物量、油脂产量和油脂含量分别达28.7 g/L、12.27 g/L和42.8％。以皮状丝孢酵母B3所产油脂制备生物柴油,其主要组成包括棕榈酸甲酯、硬脂酸甲酯、油酸甲酯、亚油酸甲酯等,且理化特性符合相关国家标准,可作为一种有潜力的化石燃料替代品。     

Ultrasonic pretreatment and acid hydrolysis of sugarcane bagasse for succinic acid production using Actinobacillus succinogenes

Immense interest has been devoted to the production of bulk chemicals from lignocellulose biomass. Diluted sulfuric acid treatment is currently one of the main pretreatment methods. However, the low total sugar concentration obtained via such pretreatment limits industrial fermentation systems that use lignocellulosic hydrolysate. Sugarcane bagasse hemicellulose hydrolysate is used as the carbon and nitrogen sources to achieve a green and economical production of succinic acid in this study. Sugarcane bagasse was ultrasonically pretreated for 40 min, with 43.9 g/L total sugar obtained after dilute acid hydrolysis. The total sugar concentration increased by 29.5 %. In a 3-L fermentor, using 30 g/L non-detoxified total sugar as the carbon source, succinic acid production increased to 23.7 g/L with a succinic acid yield of 79.0 % and a productivity of 0.99 g/L/h, and 60 % yeast extract in the medium could be reduced. Compared with the detoxified sugar preparation method, succinic acid production and yield were improved by 20.9 and 20.2 %, respectively.     

假丝酵母发酵玉米芯半纤维素水解液生产木糖醇

采用一株驯化过的假丝酵母(Candida sp.)直接发酵经过简单脱毒处理的玉米芯半纤维素水解液生产木糖醇。确定了水解液的最适浓缩倍数在3.0～3.72的范围内。利用正交实验,确定了摇瓶分批发酵工艺条件的最适组合为：摇床转速180r/min,起始C/N为50,起始pH 5.5,接种量5% (体积比)。在此基础上,重点研究了在发酵罐中通气量对酵母发酵玉米芯水解液生产木糖醇的影响。结果表明采用先高后低的分段通气发酵在木糖醇得率方面明显优于恒定通气发酵;其中,在0～24h,3.75 L/min;24～108h,1.25 L/min的分段通气条件下(装液量为2.5L),木糖醇得率(木糖醇/木糖,g/g) 达到0.75 g/g。该结果将有助于建立一种高效的、大规模的利用玉米芯半纤维素水解液发酵生产木糖醇的工艺。     

Xylitol formation by Candida guilliermondii grown in a cane bagasse hemicellulosic hydrolysate: Effect of aeration and inoculum adaptation

The xylose conversion into by Candida guilliermondii was evaluated in sugar cane bagasse hemicellulosic hydrolysate. The effect of air flow rates of 0.4, 0.6 and 0.8 vvm cn xylitol formation was studied. In addition, inoculum previously adapted to the hydrolysate was also tested in the fermentation carried out at 0.6 vvm. The results showed that xylitol production depends markedly on the aeration rate and on the previous adaptation of the yeast to the hydrolysate. When the highest productivity of xylitol was 0.39 g/l × h. However, during the fermentation carried out at an air flow rate of 0.6 vvm with adapted inoculum, the productivity increased to 0.65 g/l × h. Furthermore, the adapted cells performed quite well in the presencel of acetic concentrations of about 4.5 g/l in the medium.     

A strain of <Emphasis Type="Italic">Meyerozyma guilliermondii</Emphasis> isolated from sugarcane juice is able to grow and ferment pentoses in synthetic and bagasse hydrolysate media

The search for new microbial strains that are able to withstand inhibitors released from hemicellulosic hydrolysis and are also still able to convert sugars in ethanol/xylitol is highly desirable. A yeast strain isolated from sugarcane juice and identified as Meyerozyma guilliermondii was evaluated for the ability to grow and ferment pentoses in synthetic media and in sugarcane bagasse hydrolysate. The yeast grew in xylose, arabinose and glucose at the same rate at an initial medium pH of 5.5. At pH 4.5, the yeast grew more slowly in arabinose. There was no sugar exhaustion within 60 h. At higher xylose concentrations with a higher initial cell concentration, sugar was exhausted within 96 h at pH 4.5. An increase of 350 % in biomass was obtained in detoxified hydrolysates, whereas supplementation with 3 g/L yeast extract increased biomass production by approximately 40 %. Ethanol and xylitol were produced more significantly in supplemented hydrolysates regardless of detoxification. Xylose consumption was enhanced in supplemented hydrolysates and arabinose was consumed only when xylose and glucose were no longer available. Supplementation had a greater impact on ethanol yield and productivity than detoxification; however, the product yields obtained in the present study are still much lower when compared to other yeast species in bagasse hydrolysate. By the other hand, the fermentation of both xylose and arabinose and capability of withstanding inhibitors are important characteristics of the strain assayed.     

An novel immobilization method of Saccharomyces cerevisiae to sorghum bagasse for ethanol production

Natural sorghum bagasse without any treatment was used to immobilize Saccharomyces cerevisiae at 0.6+/-0.2g dry cell weight (DCW)/g dry sorghum bagasse weight (DSW) through solid-state or semi-solid state incubation. The scanning electron microscopy (SEM) of the carriers revealed the friendship between yeast cells and sorghum bagasse are adsorption and embedding. The ethanol productivity of the immobilized cells was 2.24 times higher than the free cells. In repeated batch fermentation with an initial sugar concentration of 200g/L, nearly 100% total sugar was consumed after 16 h. The ethanol yield and productivity were 4.9 g/g consumed sugar on average and 5.72 g/(Lh), respectively. The immobilized cell reactor was operated over a period of 20 days without breakage of the carriers, while the free cell concentration in the effluent remained less than 5 g/L thoughout the fermentation. The maximum ethanol productivity of 16.68 g/(Lh) appeared at the dilution rate of 0.3h(-1).     

Use of elephant grass (Pennisetum purpureum) acid hydrolysate for microbial oil production by Trichosporon cutaneum

Elephant grass (Pennisetum purpureum) dilute acid hydrolysate contains 34.6?g/L total sugars. The potential of lipid production by oleaginous yeast Trichosporon cutaneum grown on elephant grass acid hydrolysate was investigated for the first time. During the fermentation process on the elephant grass acid hydrolysate, glucose, xylose, and arabinose could be well utilized as carbon sources by T. cutaneum. Interestingly, xylose was almost no use before glucose was consumed completely. This illustrated that simultaneous saccharification of xylose and glucose by T. cutaneum did not occur on elephant grass acid hydrolysate. The highest biomass, lipid content, lipid yield, and lipid coefficient of T. cutaneum were measured after the sixth day of fermentation and were 22.76?g/L, 24.0%, 5.46?g/L, and 16.1%, respectively. Therefore, elephant grass is a promising raw material for microbial oil production by T. cutaneum.