Change of extracellular cAMP concentration is a sensitive reporter for bacterial fitness in high-cell-density cultures of Escherichia coli

Guanosine-3',5'-tetraphosphate (ppGpp) and sigmaS, two regulators of the starvation response of Escherichia coli, have received increasing attention for monitoring cell physiological changes in production processes, although both are difficult to quantify. The kinetics of cAMP formation and degradation were not yet investigated in such processes, although the complex regulation of cAMP by synthesis, release, and degradation in connection with straightforward methods for analysis renders it a highly informative target. Therefore, we followed the cAMP concentration in various nonrecombinant and in four different recombinant glucose-limited fed-batch processes in different production scales. The intracellular cAMP concentration increases strongly at the end of the batch phase. Most cAMP is released to the cultivation medium. The rates of accumulation and degradation of extracellular cAMP are growth-rate-dependent and show a distinct maximum at a growth rate of about 0.35 h(-1). At very low growth rates, below 0.05 h(-1), extracellular cAMP is not produced but rather degraded, independent of whether this low growth rate is caused by glucose limitation or by the high metabolic load of recombinant protein production. In contrast to intracellular cAMP, which is highly unstable, analysis of extracellular cAMP is simpler and the kinetics of accumulation and degradation reflect well the physiological situation, including unlimited growth, limitation, and severe starvation of a production host.     

Glucose overflow metabolism and mixed-acid fermentation in aerobic large-scale fed-batch processes with Escherichia coli

Industrial 20-m³-scale and laboratory-scale aerobic fed-batch processes with Escherichia coli were compared. In the large-scale process the observed overall biomass yield was reduced by 12% at a cell density of 33 g/l and formate accumulated to 50 mg/l during the later constant-feeding stage of the process. Though the dissolved oxygen signal did not show any oxygen limitation, it is proposed that the lowered yield and the formate accumulation are caused by mixed-acid fermentation in local zones where a high glucose concentration induced oxygen limitation. The hypothesis was further investigated in a scale-down reactor with a controlled oxygen-limitation compartment. In this scale-down reactor similar results were obtained: i.e. an observed yield lowered by 12% and formate accumulation to 238 mg/l. The dynamics of glucose uptake and mixed-acid product formation (acetate, formate, d-lactate, succinate and ethanol) were investigated within the 54 s of passage time through the oxygen-limited compartment. Of these, all except succinate and ethanol were formed; however, the products were re-assimilated in the oxygen-sufficient reactor compartment. Formate was less readily assimilated, which accounts for its accumulation. The total volume of the induced-oxygen-limited zones was estimated to be 10% of the whole liquid volume in the large bioreactor. It is also suggested that repeated excretion and re-assimilation of mixed-acid products contribute to the reduced yield during scale-up and that formate analysis is useful for detecting local oxygen deficiency in large-scale E. coli processes. Received: 7 November 1998 / Received revision: 4 February 1999 / Accepted: 5 February 1999     

营养条件对pcDNA3\|HBS质粒DNA生产的影响

为了考查营养条件对质粒DNA的生产影响,采用不同的培养基培养含pcDNA33－HBS质粒的大肠杆菌JM109。实验结果表明：碳源、氮源质粒DNA产量有明显的影响。葡萄糖是质粒合成过程中较佳的碳源,蛋白胨是较佳的氮源。在MP9P培养基中,选择适合的硫酸铵浓度对质粒DNAR的生产有一定作用。由于Gly,Asp,Glu能提供合成核苷酸的氮源,在M9G培养基中添加1．2g/L的Asp,1.0g/L的Glu和0．4g/L的Gly后,经20h培养,质粒产量可达25mg/L。外源核苷也影响质粒DNA的产量,通过添加0．4g/L胞革与胸苷的混合物（摩尔比为1：1）到M9P培养基中,质粒DNA的产量可达35mg／L。     

Effects of Molybdate and Selenite on Formate and Nitrate Metabolism in Escherichia coli

The effects of adding molybdate and selenite to a glucose-minimal salts medium on the formation of enzymes involved in the anaerobic metabolism of formate and nitrate in Escherichia coli have been studied. When cells were grown anaerobically in the presence of nitrate, molybdate stimulated the formation of nitrate reductase and a b-type cytochrome, resulting in cells that had the capacity for active nitrate reduction in the absence of formate dehydrogenase. Under the same conditions, selenite in addition to molybdate was required for forming the enzyme system which permits formate to serve as an effective electron donor for nitrate reduction. When cells were grown anaerobically on a glucose-minimal salts medium without nitrate, active hydrogen production from formate as well as formate dehydrogenase activity depended on the presence of both selenite and molybdate. The effects of these metals on the formation of formate dehydrogenase was blocked by chloramphenicol, suggesting that protein synthesis is required for the increases observed. It is proposed that the same formate dehydrogenase is involved in nitrate reduction, hydrogen production, and in aerobic formate oxidation.     

A study on medium chain length-polyhydroxyalkanoate accumulation in Escherichia coli harbouring phaC1 gene of indigenous Pseudomonas sp. LDC-5

AIMS: This study is mainly focused on the heterologous expression and accumulation of polyhydroxyalkanoates (PHA) in Escherichia coli. METHODS AND RESULTS: PHA synthase gene (phaC1) from indigenous Pseudomonas sp. LDC-5 was amplified by PCR and cloned in E. coli (Qiagen EZ competent cells). The recombinant E. coli was analysed and confirmed for its expression of phaC1 gene by phase contrast microscopy, Western blot analysis and spectral studies (Fourier-transform infrared spectroscopy). It was further evaluated for its accumulation in different carbon and nitrogen sources. The accumulation of PHA (3.4 g l(-1)) was enhanced in the medium supplemented with glycerol and fish peptone compared to the other carbon and nitrogen sources used in this study. CONCLUSIONS: This study would enable the reduction of cost of PHA production. SIGNIFICANCE AND IMPACT OF THE STUDY: An important part of this study is that E. coli harbouring partial phaC1 gene could accumulate medium chain length PHA significantly. The results demonstrated that the E. coli strain could be a potential candidate for the large-scale production of polymer. The conditions for the higher yield and productivity will be optimized in the next phase using fermentation studies.     

Cloning of hydrogenase genes and fine structure analysis of an operon essential for H2 metabolism in Escherichia coli.

Escherichia coli has two unlinked genes that code for hydrogenase synthesis and activity. The DNA fragments containing the two genes (hydA and hydB) were cloned into a plasmid vector, pBR322. The plasmids containing the hyd genes (pSE-290 and pSE-111 carrying the hydA and hydB genes, respectively) were used to genetically map a total of 51 mutant strains with defects in hydrogenase activity. A total of 37 mutants carried a mutation in the hydB gene, whereas the remaining 14 hyd were hydA. This complementation analysis also established the presence of two new genes, so far unidentified, one coding for formate dehydrogenase-2 (fdv) and another producing an electron transport protein (fhl) coupling formate dehydrogenase-2 to hydrogenase. Three of the four genes, hydB, fhl, and fdv, may constitute a single operon, and all three genes are carried by a 5.6-kilobase-pair chromosomal DNA insert in plasmid pSE-128. Plasmids carrying a part of this 5.6-kilobase-pair DNA (pSE-130) or fragments derived from this DNA in different orientations (pSE-126 and pSE-129) inhibited the production of active formate hydrogenlyase. This inhibition occurred even in a prototrophic E. coli, strain K-10, but only during an early induction period. These results, based on complementation analysis with cloned DNA fragments, show that both hydA and hydB genes are essential for the production of active hydrogenase. For the expression of active formate hydrogenlyase, two other gene products, fhl and fdv are also needed. All four genes map between 58 and 59 min in the E. coli chromosome.     

Identification of a new gene, molR, essential for utilization of molybdate by Escherichia coli.

A mutation in a new gene, molR, prevented the synthesis in Escherichia coli of molybdoenzymes, including the two formate dehydrogenase isoenzymes, nitrate reductase and trimethylamine-N-oxide reductase. This phenotype was suppressed by supplementing the media with molybdate. Thus, the molR mutant was phenotypically similar to previously described chlD mutants, thought to be defective in molybdate transport. The molR gene is located at 65.3 min in the E. coli chromosome, in contrast to the chlD gene, which maps at 17 min and thus can be readily distinguished. The molR gene is also cotransducible with a hitherto unidentified gene essential for the production of 2-oxoglutarate from isocitrate, designated icdB (located at 66 min). The molR mutant strain SE1100 also failed to produce the hydrogenase component of formate hydrogenlyase (HYD3) in molybdate-unsupplemented media. The amount of molybdate required by strain SE1100 for the production of parental levels of formate hydrogenlyase activity was dependent on the growth medium. In Luria-Bertani medium, this value was about 100 microM, and in glucose-minimal medium, 1.0 microM was sufficient. In low-sulfur medium, this value decreased to about 50 nM. The addition of sulfate or selenite increased the amount of molybdate needed for the production of formate hydrogenlyase activity. These data suggest that in the absence of the high-affinity molybdate transport system, E. coli utilizes sulfate and selenite transport systems for transporting molybdate, preferring sulfate transport over the selenite transport system.     

Dideoxynucleoside triphosphates inhibit a late stage of SV40 DNA replicationin vitro

Summary The role of DNA polymerases in the replication of SV40 DNA was studied using a T-antigen-dependent assay supplemented with a human KB cell extract. Inhibition of DNA polymerase α by addition of aphidicolin or monoclonal antibodies prevented DNA synthesis, confirming the requirement for this enzyme in replication. The replication process was unaffected by ddTTP at a concentration (5 μM) inhibitory to DNA polymerases β and γ, however, higher concentrations of ddTTP (200 μM) caused an apparent accumulation of relaxed circular plasmid with a concomitant decrease in DNA synthesis. An analysis of this replication intermediate indicated that it was formed during the replication reaction and that the replicative cycle was nearly complete. A kinetic study of ddTTP inhibition strongly suggested DNA polymerase ε (PCNA-independent DNA polymerase δ) was the target of the inhibitor and that this enzyme functions during the final stages of DNA replication.     

The use of flow cytometry to detect nucleic acids attached to the surface of Escherichia coli in high cell density fed-batch processes

E. coli was grown in an aerobic fed-batch process for the production of a recombinant protein (rhGH). The cells were examined by flow cytometry and PI (propidium iodide) staining. The fluorescence of the PI-stained cells increased with increasing concentrations of DNA in the medium. Furthermore, DNA and RNA attached to the cell could partly be degraded with DNase/RNase and the fluorescence decreased. Formate excretion during the aerobic processes may be due to DNA and possibly also RNA attached to the cell surface, so creating diffusion resistance.     

Effects of oleate and insulin on the production rates and cellular mRNA concentrations of apolipoproteins in HepG2 cells

We have reported previously that, in HepG2 cells, there is a lack of coordinate induction of triglyceride and apolipoprotein (apo) production by oleate and that insulin inhibits the production of triglyceride-rich, apoB-containing lipoproteins. The aim of the present study was to determine whether the effects of oleate and insulin on the net accumulation of apolipoproteins, specifically apoB, were related to their cellular mRNA concentrations. It was first established that the production of triglyceride-rich, apoB-containing lipoproteins and the concentration of mRNA for apolipoproteins A-I, A-II, B, and E were not affected by increasing the glucose concentration of medium from 5.5 to 20 mM. Oleate and insulin had no effect on either the accumulation in the medium or the cellular mRNA concentration of apolipoproteins A-I and A-II. On the other hand, the addition of oleate caused a two- to threefold increase in the accumulation of triglycerides in the medium without significantly affecting either the rates of accumulation or cellular mRNA levels of apolipoproteins B and E. In the presence of insulin, there was a dose-dependent decrease in the net accumulation of triglycerides and apoB and, to a lesser extent, cholesteryl esters and apoE. This inhibitory effect of insulin on the accumulation of triglycerides and apoB was partially abolished after a prolonged exposure of cells to insulin. Under these experimental conditions and at all concentrations tested, insulin had no effect on the cellular concentration of mRNA for either apoB or apoE.(ABSTRACT TRUNCATED AT 250 WORDS)     

Novel whole-cell biocatalysts with recombinant hydroxysteroid dehydrogenases for the asymmetric reduction of dehydrocholic acid

Ursodeoxycholic acid is an important pharmaceutical so far chemically synthesized from cholic acid. Various biocatalytic alternatives have already been discussed with hydroxysteroid dehydrogenases (HSDH) playing a crucial role. Several whole-cell biocatalysts based on a 7α-HSDH-knockout strain of Escherichia coli overexpressing a recently identified 7β-HSDH from Collinsella aerofaciens and a NAD(P)-bispecific formate dehydrogenase mutant from Mycobacterium vaccae for internal cofactor regeneration were designed and characterized. A strong pH dependence of the whole-cell bioreduction of dehydrocholic acid to 3,12-diketo-ursodeoxycholic acid was observed with the selected recombinant E. coli strain. In the optimal, slightly acidic pH range dehydrocholic acid is partly undissolved and forms a suspension in the aqueous solution. The batch process was optimized making use of a second-order polynomial to estimate conversion as function of initial pH, initial dehydrocholic acid concentration, and initial formate concentration. Complete conversion of 72?mM dehydrocholic acid was thus made possible at pH?6.4 in a whole-cell batch process within a process time of 1?h without cofactor addition. Finally, a NADH-dependent 3α-HSDH from Comamonas testosteroni was expressed additionally in the E. coli production strain overexpressing the 7β-HSDH and the NAD(P)-bispecific formate dehydrogenase mutant. It was shown that this novel whole-cell biocatalyst was able to convert 50?mM dehydrocholic acid directly to 12-keto-ursodeoxycholic acid with the formation of only small amounts of intermediate products. This approach may be an efficient process alternative which avoids the costly chemical epimerization at C-7 in the production of ursodeoxycholic acid.     

Electrochemical study of proton translocation function of hydrogenase 3

The oxidation of formate associated with fast acidification of medium by whole Escherichia coli cells lacking both hya and hyb hydrogenases was studied. The extent of acidification was dependent on the amount of formate added. An average H+/formate ratio of 1.3 was obtained. The proton release was inhibited by carbonyl cyanide m-chlorophenylhydrazone. Inverted vesicles of E. coli were found to translocate protons upon oxidation of formate at pH 6.5. The extent of alkalization was also dependent on the amount of formate added. The maximum H+/formate ratio for this reaction was close to 0.6. Formate oxidation by inverted vesicles from E. coli (delta hya delta hyb) was sensitive to the protonophore carbonyl cyanide m-chlorophenylhydrazone. It was supposed that the hydrogenase 3 (hyc) component of E. coli formate hydrogen lyase is responsible for the translocation of protons at low pH.     

Production of Extracellular Polysaccharide Matrix by Zoogloea ramigera

Zoogloea ramigera 115 synthesized large amounts of matrix polymer from fructose, galactose, glucose, lactose, mannose, soluble starch, and sucrose when these carbohydrates were used as supplements to a chemically defined medium. All of them supported polymer synthesis to the extent that cultures thickened to a gel. Concentration of carbohydrate nutrients in the range 0.5 to 2.0% was not a critical factor in determining eventual total thickening to a gel, except in relation to the incubation time required. Glucose disappeared from the growth medium rapidly and correlated with increasing cell growth and poly-beta-hydroxybutyrate (PHB) accumulation. PHB concentration decreased as extracellular polymer was synthesized, suggesting a link between PHB and extracellular polymer production.     

Active accumulation of tetracycline by Escherichia coli

1. At low concentrations of tetracycline (10mug/ml) net accumulation of the drug by Escherichia coli cells ceased after 7-10min. 2. At higher concentrations of tetracycline (>30mug/ml) the period of net accumulation of the drug was significantly extended. 3. The efflux of tetracycline from E. coli cells transferred from medium containing 10mug of tetracycline/ml to drug-free medium was a rapid temperature-dependent process and was accelerated by 2,4-dinitrophenol. 4. As the concentration of tetracycline in the preloading phase was increased, the rate of subsequent efflux of the drug progressively declined. The efflux of drug from cells preloaded in medium containing 200mug of tetracycline/ml was negligible, although efflux was readily provoked by 2,4-dinitrophenol, by N-ethylmaleimide or by omission of glucose from the medium. 5. The initial rate of uptake of tetracycline by E. coli cells was linearly proportional to the concentration of tetracycline in the medium up to the maximum concentration of drug obtainable under the experimental conditions used (400mug/ml, 0.83mm). 6. Although N-ethylmaleimide strongly inhibited the accumulation of tetracycline by E. coli, no evidence was obtained for the direct involvement of thiol groups in the transport process. It was concluded that N-ethylmaleimide inhibited accumulation by interruption of the energy supply of the cells. 7. Osmotic shock of E. coli cells did not significantly affect the influx of tetracycline, but promoted both efflux of tetracycline and cell lysis in cells treated with a high concentration of tetracycline. 8. A study of the distribution of tetracycline among the subcellular fractions of penicillin-induced spheroplasts preincubated with various concentrations of tetracycline indicated that 60-70% of the accumulated tetracycline was in the high-speed supernatant fraction. Sephadex chromatography showed that the tetracycline of this fraction was present as the free drug. Sephadex chromatography of a detergent extract of the membrane fraction, however, indicated that a significant proportion of the tetracycline radioactivity of this fraction was apparently bound to some macromolecular component. 9. Cellulose phosphate paper chromatography of cold-acid extracts of spheroplasts preloaded with tetracycline indicated that the accumulated drug was chemically unchanged. 10. Membrane preparations isolated from osmotically lysed penicillin-induced spheroplasts showed a temperature-dependent binding of tetracycline that was not energy-dependent and was not inhibited by N-ethylmaleimide. The binding process was stimulated by omitting Mg(2+) from the medium, but conversely was profoundly inhibited by EDTA. 11. The relevance of these findings to the probable mechanism of active tetracycline accumulation by E. coli is discussed.     

The carboxyl terminal domain of Escherichia coli DNA topoisomerase I confers higher affinity to DNA

Limited digestion of E. coli DNA topoisomerase I with trypsin or papain generated a DNA-binding domain of MW 14,000 corresponding to the carboxyl terminal of the enzyme. This fragment binds to single-stranded DNA agarose as tightly as the intact enzyme. It required around 400 mM NaCl for elution. A truncated topoisomerase that lacks this C-terminal domain was purified. It was eluted from the single-stranded DNA agarose column at around 150 mM NaCl. Although the truncated enzyme could relax negatively supercoiled DNA as efficiently as the intact enzyme at low ionic strength, its processivity was more sensitive to increasing salt concentration. Measurement of binding to fluorescent etheno-M13 DNA also demonstrated that the presence of the C-terminal domain confers higher affinity to DNA for the enzyme.     

Germ line recombination may be primarily a manifestation of DNA repair processes.

Several kinds of DNA repair and reactivation processes have been found to occur by recombination in E. coli and its phages. Recombinational repair appears to be a major mechanism for overcoming lesions induced by various agents including ultraviolet light, X-rays, [³²P]-decay, nitrous acid and psoralen-plus-light. When the lesions caused by the above agents are not repaired by recombinational repair or other accurate repair modes they generally lead to lethality. However a minority of these unrepaired lesions lead to mutations through replication errors or error-prone repair. In higher organisms accumulation of unrepaired lethal lesions or mutations in somatic cells may cause aging. Perpetuation of a species depends on preventing accumulation of these types of defects in the germ line. It is proposed that the recombinational acts occurring during meiosis may largely reflect the recombinational removal or repair of DNA lesions to conserve the germ line. It is further suggested that the repair function of recombination may be as significant as the better studied function of recombination, the generation of diversity. The ubiquitous occurrence of recombination in the biological world implies that it arose very early in evolution. The possibility that recombination initially arose as a repair process is discussed.     

Use of Pleurotus dryinus for lignocellulolytic enzymes production in submerged fermentation of mandarin peels and tree leaves

It has been shown that the wood-rotting mushroom Pleurotus dryinus IBB 903 is able to effectively produce cellulases, xylanase, laccase, and manganese peroxidase in submerged fermentation of mandarin peels and tree leaves. Gradual increasing of lignocellulosic substrates concentration from 1 to 4–6% enhanced enzyme accumulation in culture liquid. A simple and inexpensive medium containing mandarin peels and yeast extract as sole carbon and nitrogen sources allowed simultaneous production of high levels of both hydrolases and oxidases by P. dryinus IBB 903. Supplementation of this medium by copper and manganese caused earlier and faster accumulation of laccase and manganese peroxidase increasing their yield by 1.5 and 7.5 times, respectively. In addition, by adding manganese to the medium it is possible to regulate the ratio of laccase and MnP in enzyme preparation. The presence of lignocellulosic substrate is the requisite for MnP production by P. dryinus IBB 903 since there was no production of MnP when mushroom has been cultivated in the synthetic medium with different carbon source. Among carbon source tested only utilization of glucose resulted to 21-fold increase of fungus laccase specific activity compared to control medium without carbon source. Carboxymethyl cellulase and xylanase appeared to be inducible enzymes.     

Polyamines and the Accumulation of Ribonucleic Acid in Some Polyauxotrophic Strains of Escherichia coli

The cellular accumulations of polyamines and ribonucleic acid (RNA) were compared in the polyauxotrophic mutants of Escherichia coli strain 15 TAU and E. coli K-12 RC(re1) met(-) leu(-). Putrescine, spermidine, and their monoacetyl derivatives were the main polyamines in both strains, when grown in glucose-mineral medium. No significant degradation of either (14)C-putrescine or (14)C-spermidine was found in growing cultures of strain 15 TAU, which requires thymine, arginine, and uracil for growth. Experiments with this organism showed that in a variety of different incubation conditions, which included normal growth, amino acid starvation, inhibition by chloramphenicol or streptomycin, or thymine deprivation, a close correlation was seen between the intracellular accumulation of unconjugated spermidine and RNA. In the presence of arginine, the antibiotics stimulated the production of putrescine and spermidine per unit of bacterial mass. Deprivation of arginine also resulted in an increase in the production of putrescine per unit of bacterial mass, most of which was excreted into the growth medium. However, in this system the antibiotics reduced the synthesis of putrescine. Furthermore, streptomycin caused a rapid loss of cellular putrescine into the medium. The latter effect was not seen in anaerobic conditions or in a streptomycin-resistant mutant of 15 TAU. Methionine added to the growth medium of growing TAU not only markedly increased the total production of spermidine, but also increased both the intracellular concentration of spermidine and the accumulation of RNA. Exogenous spermidine extensively relaxed RNA synthesis in amino acid-starved cultures of 15 TAU. Analysis in sucrose density gradients showed that the RNA accumulated in the presence of spermidine was ribosomal RNA.Cells of E. coli K-12 RC(rel) met(-) leu(-), grown in a complete medium, had approximately the same ratio of free spermidine to RNA as did strain 15 TAU. However, the relaxed strain showed a much lower ratio of putrescine to spermidine than the stringent 15 TAU. Omission of methionine stopped spermidine synthesis and markedly increased both the intracellular accumulation and the total production of putrescine. It seems that a high intracellular level of spermidine acts as a feedback inhibitor in the biosynthesis of putrescine in this strain. The hypothesis that the intracellular concentration of polyamines may participate in the control of the synthesis of ribosomal RNA in bacteria is discussed.