Simultaneous fermentation of D-xylose and glucose byCandida shehatae

Summary Mixtures of xylose and glucose were anaerobically fermented with the yeastCandida shehatae. Cells previously grown aerobically on glucose fermented glucose and xylose sequentially. Cells grown aerobically on xylose fermented glucose and xylose simultaneously, with no lag in xylose consumption. The best results were obtained with cells grown aerobically on xylose and inoculated into a 7525 mixture. 25 g/L of ethanol and 25 g/L of xylitol were obtained from 120 g/L of carbohydrates within 50 hours.     

Co-fermentation of a mixture of glucose and xylose to ethanol by Zymomonas mobilis and Pachysolen tannophilus

This research was designed to maximize ethanol production from a glucose-xylose sugar mixture (simulating a sugar cane bagasse hydrolysate) by co-fermentation with Zymomonas mobilis and Pachysolen tannophilus. The volumetric ethanol productivity of Z. mobilis with 50 g glucose/l was 2.87 g/l/h, giving an ethanol yield of 0.50 g/g glucose, which is 98% of the theoretical. P. tannophilus when cultured on 50 g xylose/l gave a volumetric ethanol productivity of 0.10 g/l/h with an ethanol yield of 0.15 g/g xylose, which is 29% of the theoretical. On optimization of the co-fermentation with the sugar mixture (60 g glucose/l and 40 g xylose/l) a total ethanol yield of 0.33 g/g sugar mixture, which is 65% of the theoretical yield, was obtained. The co-fermentation increased the ethanol yield from xylose to 0.17 g/g. Glucose and xylose were completely utilized and no residual sugar was detected in the medium at the end of the fermentation. The pH of the medium was found to be a good indicator of the fermentation status. The optimum conditions were a temperature of 30°C, initial inoculation with Z. mobilis and incubation with no aeration, inactivation of bacterium after the utilization of glucose, followed by inoculation with P. tannophilus and incubation with limited aeration.     

The effect of anaerobiosis on the induced synthesis of β-galactosidase in non-growingEscherichia coli

Depending on conditions of aeration maltose and glucose were found to exhibit different effects on the inducible synthesis of β-galactosidase in aerobically grown cells ofEscherichia coli starving for an exogenous source of nitrogen; both saccharides repressed the synthesis of the enzyme under aerobic conditions, while the above-mentioned saccharides were essential for the enzyme synthesis under anaerobic conditions. The presence of maltose in the medium resulted in the repression of the enzyme synthesis in anaerobically grown cells starving for an exogenous nitrogen source under anaerobic conditions. The synthesis of β-galactosidase-specific messenger RNA was completely blocked and the synthesis of the enzyme proper considerably inhibited in aerobically grown cells incubated anaerobically in a medium without nitrogen and carbon sources.     

Ethanol production from d-xylose in batch fermentations with Candida shehatae: process variables

Summary These studies examined several process variables important in scaling up the fermentation of xylose by Candida shehatae. Inoculum age and cell density were particularly influential. Young (24-h) inocula fermented xylose to ethanol two to three times as fast as older (48- or 72-h) inocula. With all three inocula ages, the initial fermentation rates were essentially linear with cell density, up to 4 g dry wt cells L^-1. Above that cell density, the ethanol production rate appeared to be oxygen limited, particularly with 24-h old cells. Aeration also played a role in xylose utilization. The fermentation proceeded under both aerobic and anaerobic conditions, but xylose was not completely utilized anaerobically. With aeration, 25% more ethanol was formed in about one third the time than without aeration. Ethanol yields were similar under the two conditions. Cell growth on xylose was observed in the absence of oxygen. Cells went through essentially one doubling in 24 h. Based on the sugar consumed, a Y _ATP of 9.9 was obtained. Slow continuous feeding of glucose significantly increased the xylose utilization rate.Maintained in cooperation with the University of Wisconsin, Madison, Wisconsin, USA     

Anaerobic iron uptake by Escherichia coli.

Assimilation and uptake of iron in anaerobic cultures of Escherichia coli were supported by iron supplied as ferrienterobactin, ferrichrome, and ferrous ascorbate; however, as in the aerobic cultures, ferrichrome A was a poor iron source. Albomycin inhibited both aerobically and anaerobically grown cells. The siderophore outer membrane receptor proteins FepA and FhuA were produced under anaerobic iron-deficient conditions. Anaerobic transport of ferrienterobactin and ferrichrome was inhibited by KCN and dinitrophenol. The Km for ferrienterobactin uptake in anaerobically grown cells was 0.8 microM, and the Vmax was 38 pmol/min per mg, compared with 0.1 microM and 80 pmol/min per mg, respectively, in aerobically grown cells.     

Increase of xylitol production rate by controlling redox potential in Candida parapsilosis

The effect of redox potential on xylitol production by Candida parapsilosis was investigated. The redox potential was found to be useful for monitoring the dissolved oxygen (DO) level in culture media, especially when the DO level was low. An increase in the agitation speed in a 5 L fermentor resulted in an increased culture redox potential as well as enhanced cell growth. Production of xylitol was maximized at a redox potential of 100 mV. As the initial cell concentration increased from 8 g/L to 30 g/L, the volumetric productivity of xylitol increased from 1.38 g/L. h to 4.62 g/L. h. A two-stage xylitol production strategy was devised, with stage 1 involving rapid production of cells under well-aerated conditions, and stage 2 involving cultivation with reduced aeration such that the culture redox potential was 100 mV. Using this technique, a final xylitol concentration of 180 g/L was obtained from a culture medium totally containing 254.5 g/L xylose in a 3,000 L pilot scale fermentor after 77 h fermentation. The volumetric productivity of xylitol during the fermentation was 2.34 g/L. h.     

Minimal metabolic engineering of Saccharomyces cerevisiae for efficient anaerobic xylose fermentation: a proof of principle

When xylose metabolism in yeasts proceeds exclusively via NADPH-specific xylose reductase and NAD-specific xylitol dehydrogenase, anaerobic conversion of the pentose to ethanol is intrinsically impossible. When xylose reductase has a dual specificity for both NADPH and NADH, anaerobic alcoholic fermentation is feasible but requires the formation of large amounts of polyols (e.g., xylitol) to maintain a closed redox balance. As a result, the ethanol yield on xylose will be sub-optimal. This paper demonstrates that anaerobic conversion of xylose to ethanol, without substantial by-product formation, is possible in Saccharomyces cerevisiae when a heterologous xylose isomerase (EC 5.3.1.5) is functionally expressed. Transformants expressing the XylA gene from the anaerobic fungus Piromyces sp. E2 (ATCC 76762) grew in synthetic medium in shake-flask cultures on xylose with a specific growth rate of 0.005 h(-1). After prolonged cultivation on xylose, a mutant strain was obtained that grew aerobically and anaerobically on xylose, at specific growth rates of 0.18 and 0.03 h(-1), respectively. The anaerobic ethanol yield was 0.42 g ethanol x g xylose(-1) and also by-product formation was comparable to that of glucose-grown anaerobic cultures. These results illustrate that only minimal genetic engineering is required to recruit a functional xylose metabolic pathway in Saccharomyces cerevisiae. Activities and/or regulatory properties of native S. cerevisiae gene products can subsequently be optimised via evolutionary engineering. These results provide a gateway towards commercially viable ethanol production from xylose with S. cerevisiae.     

Aerobiosis and the hemoprotein content of photosynthetic bacteria

Summary Rhodospirillum rubrum and Rhodopseudomonas spheroides, grown under various degrees of illumination, aeration, and iron deprivation, have been assayed for their content of cytochrome c, RHP, catalase, total iron, bacteriochlorophyll, and carotenoids.Concentrations of bacteriochlorophyll and carotenoids were consistent with the findings of Cohen-Bazire et al. (1957).Total iron content, which ranged from 0.017 to 0.04% of the dry weight, reflected the content of the principal hemoproteins but exceeded the amount of iron in these hemoproteins.The catalase content of R. rubrum, on a dry weight basis, was 0.0005% for cells grown anaerobically in the light, and 0.0028% for cells grown in darkness with vigorous aeration; that of Rps. spheroides was 0.006% and 0.25%, respectively. The catalase content in both species rose with increasingly vigorous aeration.Cytochrome c in both species, and RHP in R. rubrum, attained the same levels in cells grown under vigorous aeration as in cells grown anaerobically in the light. In cells grown under limited aeration the levels of these substances were about 50% higher. In Rps. spheroides the RHP content was greatest in cells grown anaerobically, falling under gentle aeration and declining further under more vigorous aeration.Iron deficiency caused a decrease in the catalase content of cells grown anaerobically in the light but not in cells grown aerobically. The content of cytochrome c and of RHP was diminished by iron depletion in aerobic cultures, but not in anaerobic cultures.operated by Union Carbide Corporation for the U.S.Atomic Rnergy Commission.     

Fed-batch xylitol production with recombinantXYL-1-expressingSaccharomyees cerevisiae using ethanol as a co-substrate

The bioconversion of xylose into xylitol in fed-batch fermentation with a recombinantSaccharomyces cerevisiae strain, transformed with the xylose-reductase gene ofPichia stipitis, was studied. When only xylose was fed into the fermentor, the production of xylitol continued until the ethanol that had been produced during an initial growth phase on glucose, was depleted. It was concluded that ethanol acted as a redox-balance-retaining co-substrate. The conversion of high amounts of xylose into xylitol required the addition of ethanol to the feed solution. Under O₂-limited conditions, acetic acid accumulated in the fermentation broth, causing poisoning of the yeast at low extracellular pH. Acetic acid toxicity could be avoided by either increasing the pH from 4.5 to 6.5 or by more effective aeration, leading to the further metabolism of acetic acid into cell mass. The best xylitol/ethanol yield, 2.4 gg^–1 was achieved under O₂-limited conditions. Under anaerobic conditions ethanol could not be used as a co-substrate, because the cell cannot produce ATP for maintenance requirements from ethanol anaerobically. The specific rate of xylitol production decreased with increasing aeration. The initial volumetric productivity increased when xylose was added in portions rather than by continuous feeding, due to a more complete saturation of the transport system and the xylose reductase enzyme.     

Changes in enzyme activities and distributions during glucose de-repression and respiratory adaptation of anaerobically grown Saccharomyces carlsbergensis

1. During anaerobic glucose de-repression the respiration rate of whole cells of Saccharomyces carlsbergensis remained constant and was insensitive to antimycin A but was inhibited by 30% by KCN. Aeration of cells for 1 h led to increased respiration rate which was inhibited by 80% by antimycin A or KCN. 2. Homogenates were prepared from sphaeroplasts of anaerobically grown, glucose de-repressed cells and the distribution of marker enzymes was investigated after zonal centrifugation on sucrose gradients containing MgCl(2). These homogenates contained no detectable cytochrome c oxidase or catalase activity. The complex density distributions of NADH- and NADPH-cytochrome c oxidoreductases and adenosine triphosphatase(s) [ATPase(s)] were very different from those of anaerobically grown, glucose-repressed cells. 3. The specific activity of total ATPase was lowered and sensitivity to oligomycin decreased from 58 to 7% during de-repression. 4. Cytochrome c oxidase and catalase activities were detectable in homogenates of cells after 10min aeration. Zonal centrifugation indicated complex, broad sedimentable distributions of all enzyme activities assayed; the peaks of activity were at 1.27g/ml. 5. Centrifugation of homogenates of cells adapted for 30min and 3 h indicated a shift of density of the major sedimentable peak from 1.25g/ml (30min) to 1.235g/ml (3 h). After 30min adaptation a minor zone of oligomycin-sensitive ATPase and 15% of the total cytochrome c oxidase activities were detected at rho=1.12g/l; these particles together with those of higher density containing cytochrome c oxidase, ATPase and NADH-cytochrome c oxidoreductase activities were all sedimented at 10(5)g-min. 6. Electron microscopy indicated that the mitochondria-like structures of anaerobically grown, glucose-de-repressed cells were similar to those of repressed cells. After 10min of respiratory adaptation highly organized mitochondria were evident which resembled the condensed forms of mitochondria of aerobically grown, glucose-de-repressed cells. High-density zonal fractions of homogenates of cells after adaptation also contained numerous electron-dense vesicles 0.05-0.2mum in diameter. 7. The possibility that the ;promitochondria' of anaerobically grown cells may not be the direct structural precursors of fully functional mitochondria is discussed.     

Xylitol Production from D‐Xylose at Different Oxygen Transfer Coefficients in a Batch Bioreactor

Conversion of D‐xylose to xylitol by Candida boidinii NRRL Y‐17213 was studied under anaerobic and oxygen limited conditions by varying the oxygen transfer coefficient k_La. Shake flask experiments were used to provide the preliminary information required to perform experiments in a bioreactor. The yeast did not grow under fully anaerobic conditions, but anaerobic formations of xylitol, ethanol, ribitol, and glycerol were observed as well as D‐xylose assimilation of 11 %. In shake flasks, with an initial D‐xylose concentration of 50 g/L, an increase in k_La from 8 to 46 h^–1 resulted in a faster growth, higher rate of substrate uptake and lower yields of products. The highest xylitol productivity (0.052 g/L h) was attained at k_La = 8 h^–1. At k_La = 46 h^–1, 98.6 % of D‐xylose was consumed and mainly converted to biomass. Using 130 g/L D‐xylose, k_La was varied in the fermenter from 26 to 78 h^–1. The percentage of consumed D‐xylose increased from 31 % at k_La = 26 h^–1 to 93–94 % at all other aeration levels. Biomass yield increased with k_La, whereas ethanol, ribitol, and glycerol yields exhibited an opposite dependence on the oxygenation level. The most favorable oxygen transfer coefficient for xylitol formation, in the fermenter, was k_La = 47 h^–1 when its concentration (57.5 g/L) surpassed ethanol accumulation by 3.6‐fold, and the glycerol plus ribitol by 10‐fold. Concurrently, xylitol yield and productivity reached 0.45 g/g and 0.26 g/L h, respectively. The volumetric xylitol productivity was affected more by changes in the aeration than the corresponding yield.     

The effect of aeration on xylose fermentation by Candida shehatae and Pachysolen tannophilus

Summary The ability of a Candida shehatae and a Pachysolen tannophilus strain to ferment D-xylose to ethanol was evaluated in defined and complex media under different levels of aeration. Aeration enhanced the ethanol productivity of both yeasts considerably. C. shehatae maintained a higher fermentation rate and ethanol yield than P. tannophilus over a wide range of aeration levels. Ethanol production by C. shehatae commenced during the early stage of the fermentation, whereas with P. tannophilus there was a considerable lag between the initiation of growth and ethanol production. Both yeasts produced appreciable quantities of xylitol late in the fermentation. P. tannophilus failed to grow under anoxic conditions, producing a maximum of only 0.5 g · l^-1 ethanol. In comparison, C. shehatae exhibited limited growth in anoxic cultures, and produced ethanol much more rapidly. Under the condition of aeration where C. shehatae exhibited the highest ethanol productivity, the fermentation parameters were: maximum specific growth rate, 0.15 h^-1; maximum volumetric and specific rates of ethanol production, 0.7 g (l · h)^-1 and 0.34 g ethanol (g cells · h)^-1 respectively; ethanol yield, 0.36 g (g xylose)^-1. The best values obtained with P. tannophilus were: maximum specific growth rate, 0.14 h^-1; maximum volumetric and specific rates of ethanol production, 0.22 g (l · h)^-1 and 0.07 h^-1 respectively; ethanol yield coefficient, 0.28. Because of its higher ethanol productivity at various levels of aeration, C. shehatae has a greater potential for ethanol production from xylose than P. tannophilus.     

Repeated-batch fermentations of xylose and glucose-xylose mixtures using a respiration-deficient Saccharomyces cerevisiae engineered for xylose metabolism

Xylose-fermenting Saccharomyces strains are needed for commercialization of ethanol production from lignocellulosic biomass. Engineered Saccharomyces cerevisiae strains expressing XYL1, XYL2 and XYL3 from Pichia stipitis, however, utilize xylose in an oxidative manner, which results in significantly lower ethanol yields from xylose as compared to glucose. As such, we hypothesized that reconfiguration of xylose metabolism from oxidative into fermentative manner might lead to efficient ethanol production from xylose. To this end, we generated a respiration-deficient (RD) mutant in order to enforce engineered S. cerevisiae to utilize xylose only through fermentative metabolic routes. Three different repeated-batch fermentations were performed to characterize characteristics of the respiration-deficient mutant. When fermenting glucose as a sole carbon source, the RD mutant exhibited near theoretical ethanol yields (0.46 g g(-1)) during repeated-batch fermentations by recycling the cells. As the repeated-batch fermentation progressed, the volumetric ethanol productivity increased (from 7.5 to 8.3 g L(-1)h(-1)) because of the increased biomass from previous cultures. On the contrary, the mutant showed decreasing volumetric ethanol productivities during the repeated-batch fermentations using xylose as sole carbon source (from 0.4 to 0.3 g L(-1)h(-1)). The mutant did not grow on xylose and lost fermenting ability gradually, indicating that the RD mutant cannot maintain a good fermenting ability on xylose as a sole carbon source. However, the RD mutant was capable of fermenting a mixture of glucose and xylose with stable yields (0.35 g g(-1)) and productivities (0.52 g L(-1)h(-1)) during the repeated-batch fermentation. In addition, ethanol yields from xylose during the mixed sugar fermentation (0.30 g g(-1)) were higher than ethanol yields from xylose as a sole carbon source (0.21 g g(-1)). These results suggest that a strategy for increasing ethanol yield through respiration-deficiency can be applied for the fermentation of lignocellulosic hydrolyzates containing glucose and xylose.     

Effect of culture conditions on the NADH/NAD ratio and total amounts of NAD(H) in chemostat cultures of Enterococcus faecalis NCTC 775

Abstract Enterococcus faecalis was grown in chemostat culture on various energy sources at dilution rates ranging from 0.05 h⁻¹ to 0.5 h⁻¹, under both aerobic and anaerobic conditions. NADH/NAD ratios and total nicotinamide adenine dinucleotide pool size (NAD(H)) were determined. It was found that the NADH/NAD ratio was controlled by the steady state product concentrations rather than by the degree of reduction of the energy source. Highest ratios were observed when NADH was reoxidized via ethanol formation, whereas in aerobic cultures, in which predominantly acetate was produced and oxidation of NADH occurred via the NADH oxidase, ratios were lowest. Addition of ethanol to the medium resulted in an increase of the NADH/NAD ratio, both aerobically and anaerobically. The total amount of NAD(H) was found to be influenced by the culture conditions. Under anaerobic conditions, the NADH oxidation (NAD reduction) rate appeared to correlate with the total amount of nicotinamide nucleotides. In contrast, no effect of the culture conditions on the total amount of NAD(H) was observed in aerobically grown cells.     

Microbial production of xylitol from D-xylose and sugarcane bagasse hemicellulose using newly isolated thermotolerant yeast Debaryomyces hansenii

A thermotolerant yeast capable of fermenting xylose to xylitol at 40°C was isolated and identified as a strain of Debaryomyces hansenii by ITS sequencing. This paper reports the production of xylitol from D-xylose and sugarcane bagasse hemicellulose by free and Ca-alginate immobilized cells of D. hansenii. The efficiency of free and immobilized cells were compared for xylitol production from D-xylose and hemicellulose in batch culture at 40°C. The maximum xylitol produced by free cells was 68.6 g/L from 100 g/L of xylose, with a yield of 0.76 g/g and volumetric productivity 0.44 g/L/h. The yield of xylitol and volumetric productivity were 0.69 g/g and 0.28 g/L/h respectively from hemicellulosic hydrolysate of sugarcane bagasse after detoxification with activated charcoal and ion exchange resins. The Ca-alginate immobilized D. hansenii cells produced 73.8 g of xylitol from 100 g/L of xylose with a yield of 0.82 g/g and volumetric productivity of 0.46 g/L/h and were reused for five batches with steady bioconversion rates and yields.     

休哈塔假丝酵母HDYXHT-01利用木糖生产乙醇的发酵工艺优化

采用Plackett-Burman (PB) 方法和中心组合设计 (Ccentral composit design,CCD) 对休哈塔假丝酵母Candida shehataeHDYXHT-01利用木糖发酵生产乙醇的工艺进行优化。PB试验设计与分析结果表明：硫酸铵、磷酸二氢钾、酵母粉和接种量是影响木糖乙醇发酵的4个关键因素,以乙醇产量为响应目标,采用CCD和响应面分析法 (Response surface methodology,RSM),确定了木糖乙醇发酵的最佳工艺为：硫酸铵1.73 g/L、磷酸二氢钾3.56 g/L、酵母粉2.62 g/L和接种量5.66％,其他发酵条件为：木糖80 g/L,MgSO4·7H2O 0.1 g/L,pH 5.0,培养温度30 ℃,装液量100 mL/250 mL,摇床转速140 r/min,发酵时间48 h,在该条件下发酵液中乙醇产量可以达到26.18 g/L,比未优化前提高了1.15倍。     

Development of Respiration and Mitochondria in Mucor genevensis After Anaerobic Growth: Absence of Glucose Repression

Respiration and mitochondria in Mucor genevensis, a facultatively anaerobic dimorphic mold, have been studied in aerobically and anaerobically grown cells and in anaerobically grown cells adapting to aerobic conditions. Respiration in hyphae continues at a high level during aerobic growth but drops rapidly on exhaustion of glucose. In anaerobically grown yeastlike cells, containing no recognizable aerobic cytochromes, a small cyanide-insensitive respiration occurs. Mitochondria with well defined cristae are visible in negative contrast after KMnO(4) fixation of stringently anaerobic cells containing low amounts of fatty acid of which 10% or less are unsaturated. On aeration of anaerobically grown cells, respiratory capacity and cytochromes develop rapidly, even in the presence of 10% glucose, indicating that glucose does not repress development of respiration. However, mycelium formation by adapting yeastlike cells is repressed by high glucose concentration. In adapting cells, apparent changes in mitochondrial ultrastructure appear to be more related to changes in fixation properties of cells than to changes in the structure of mitochondria.     

Xylitol production by immobilized recombinant Saccharomyces cerevisiae in a continuous packed-bed bioreactor

Continuous xylitol production with two different immobilized recombinant Saccharomyces cerevisiae strains (H475 and S641), expressing low and high xylose reductase (XR) activities, was investigated in a lab-scale packed-bed bioreactor. The effect of hydraulic residence time (HRT; 1.3-11.3 h), substrate/cosubstrate ratio (0.5 and 1), recycling ratio (0, 5, and 10), and aeration (anaerobic and oxygen limited conditions) were studied. The cells were immobilized by gel entrapment using Ca-alginate as support and the beads were treated with Al(3+) to improve their mechanical strength. Xylose was converted to xylitol using glucose as cosubstrate for regeneration of NAD(P)H required in xylitol formation and for generation of maintenance energy. The stability of the recombinant strains after 15 days of continuous operation was evaluated by XR activity and plasmid retention analyses. Under anaerobic conditions the volumetric xylitol productivity increased with decreasing HRT with both strains. With a recycling ratio of 10, volumetric productivities as high as 3.44 and 5.80 g/L . h were obtained with the low XR strain at HRT 1.3 h and with the high XR strain at HRT 2.6 h, respectively. However, the highest overall xylitol yields on xylose and on cosubstrate were reached at higher HRTs. Lowering the xylose/cosubstrate ratio from 1 to 0.5 increased the overall yield of xylitol on xylose, but the productivity and the xylitol yield on cosubstrate decreased. Under oxygen limited conditions the effect of the recycling ratio on production parameters was masked by other factors, such as an accumulation of free cells in the bioreactor and severe genetic instability of the high XR strain. Under anaerobic conditions the instability was less severe, causing a decrease in XR activity from 0.15 to 0.10 and from 3.18 to 1.49 U/mg with the low and high XR strains, respectively. At the end of the fermentation, the fraction of plasmid bearing cells in the beads was close to 100% for the low XR strain; however, it was significantly lower for the high XR strain, particularly for cells from the interior of the beads. (c) 1996 John Wiley & Sons, Inc.     

Continuous fermentation of feed streams containing D-glucose and D-xylose in a two-stage process utilizing immobilized Saccharomyces cerevisiae and Pachysolen tannophilus

In the U.S., forest and crop residues contain enough glucose and xylose to supply 10 times the country's usage of ethanol and ethylene, but an efficient fermentation scheme is lacking,(1,2,3) To develop a strategy for process design, specific ethanol productivities and yields of Pachysolen tannophilus NRRL Y-2460 and Saccharomyces cerevisiae NRRL Y-2235 were compared. Batch cultures and continuous stirred reactors (CSTR) loaded with immobilized cells were fed glucose and xylose. As expected from previous reports, Y-2235 fermented glucose but not xylose. Y-2460 consumed both sugars but fermented glucose inefficiently relative to Y-2235, and it suffered a diauxic lag lasting 10-20 h when given a sugar mixture. Immobilized Y-2235 exhibited increasing productivity but constant yield with in creasing glucose concentration. In contrast, Y-2460 exhibited an optimum productivity at 30-40 g/L xylose and a declining yield with increasing xylose concentration. Immobilized Y-2235 tolerated more than 100 g/L ethanol while the productivity and yield of Y-2460 fell by 80 and 58%, respectively, as ethanol reached 50 g/L. A 38.8-g/L ethanol stream could be produced as 103 g/L xylose was continuously fed to Y-2460. If it was blended with a 274 g/L glucose stream to give a composite of 23.7 g/L ethanol and 107 g/L glucose, Y-2235 could en rich the ethanol to 75 g/L. Taken together these results suggest use of a two-stage continuous reactor for pro cessing xylose and glucose from lignocellulose. An immobilized Y-2460 CSTR (or cascade) would convert the hemicellulose hydrolyzate. Then downstream, an immobilized Y-2235 plug flow reactor would enrich the hemicellulose-derived ethanol to more than 70 g/L upon addition of cellulose hydrolyzate.     

Biotechnological production of xylitol in a three-phase fluidized bed bioreactor with immobilized yeast cells in Ca-alginate beads

Cells of Candida guilliermondii entrapped in Ca-alginate beads were used for xylitol production, from concentrated hemicellulose hydrolyzate of sugarcane bagasse, in a fluidized bed bioreactor (FBR). The maximum xylitol concentration 28.9 g xylitol/L was obtained at a high aeration rate of 600 mL/min after 70 h of fermentation, indicating that the use of high aeration rate in this system is favored for better oxygen transfer into the immobilized cells. The specific xylitol productivity and the xylitol yield were of 0.4 g xylitol/L.h and 0.58 g xylitol/g xylose respectively. The immobilization efficiency at the end of the fermentation was of 65 %. After 90 h of fermentation xylitol productivity and yield decreased to 0.25 g xylitol/L.h and 0.47 g xylitol/g xylose respectively, indicating the beginning of xylitol consumption by the yeast. The use of FBR system with immobilized cells presented high xylitol yield and productivity.