Experimental study of a ceramic microsparging aeration system in a pilot-scale animal cell culture

The oxygen supply of cell cultures with the aid of free gas bubbles is an efficient process strategy in pharmaceutical production. If the cell-damaging impact of gas bubbles is reduced, direct aeration becomes a practical solution with scale-up potential and comparatively high oxygen transfer rates. In this paper a microsparging aeration system made of porous ceramic was compared with bubble-free membrane aeration. The sparging system was used for the long-term cultivation of mammalian cells in 2- to 100-L scale bioreactors and produced bubble sizes of 100-500 microm in diameter. Using a scale of 2.5 and 30 L, a cell density of 2.6 x 10(6) cells/mL was attained. When a 100-L scale was used, a density of 1.1 x 10(6) cells/mL was achieved, whereas a comparable membrane-aerated system showed a cell density of 2.2 x 10(6) cells/mL. At relatively low agitation rates of less than 70 rpm in the sparged bioreactors, a homogeneous and constant oxygen concentration was kept in the medium. As a result of the different foam-forming tendency caused by the lower gas flow of the ceramic sparger compared to that of the standard aeration systems, we were able to develop an appropriate process control strategy. Furthermore, oxygen transfer measurements for the common stainless steel sparger and the ceramic sparger showed a 3-fold higher oxygen transfer coefficient for the ceramic sparger.     

Efficient cellulase production by the filamentous fungus Acremonium cellulolyticus

Cellulase production was investigated in a culture of a strain of Acremonium cellulolyticus. The medium components were optimized for the improvement of cellulase production. The maximum production of cellulolytic enzymes was obtained in a medium containing (grams per liter) 50 Solka Floc, 5 (NH4)2SO4, 24 KH2PO4, 4.7 potassium tartrate hemihydrate, 1.2 MgSO4.7H2O, 1 Tween 80, 4 urea, 0.01 ZnSO4.7H2O, 0.01 MnSO4.6H2O, and 0.01 CuSO4.7H2O, with a pH of 4.0. In the flask culture, 15.5 filter paper units (FPU)/mL of maximum cellulase activity was obtained, 17.42 FPU/mL in a 7-L bioreactor, and 13.08 FPU/mL in a 50-L scale bioreactor for 4-8 d at 30 degrees C. Average production rates were 1.94 FPU/mL.d in flasks, 2.86 FPU/mL.d in the 7-L bioreactor, and 2.56 FPU/mL.d in the 50-L bioreactor. Cellulase production on a small scale was successfully reproduced in the 50-L pilot scale bioreactor. Saccharification activity from A. cellulolyticus was compared with cellulolytic enzymes produced by other strains. The A. cellulolyticus culture broth had a comparable saccharification yield in comparison with those of other Trichoderma enzymes (GC220 or Cellulosin T2) under the same total cellulase activity. Its saccharification yield (percent of released reducing sugar to used dried substrate) was 60%, and its glucose content was 83%.     

Effect of growth conditions on the production of manganese peroxidase by three strains of Bjerkandera adusta

We were looking for a strain of Bjerkandera adusta that produces high titres of manganese peroxidase under optimal conditions for large-scale enzyme purification. We have chosen two strains from the University of Alberta Microfungus Collection and Herbarium, UAMH 7308 and 8258, and compared the effects of growth conditions and medium composition on enzyme production with the well-characterized strain BOS55 (ATCC 90940). Of four types of cereal bran examined, rice bran at 3% (w/v) in 60 mM phosphate buffer pH 6 supported the highest levels of enzyme production. Using 100 mL medium in 500-mL Erlenmeyer flasks, maximum enzyme levels in the culture supernatant occurred after about 10 days of growth; 5.5 U x mL(-1) for UAMH 7308, 4.4 U x mL(-1) for UAMH 8258, and 1.7 U x mL(-1) for BOS55, where units are expressed as micromoles of Mn-malonate formed per minute. Growth as submerged cultures in 10-L stirred tank reactors produced 3.5 U x mL(-1) of manganese peroxidase (MnP) by UAMH 8258 and 2.5 U x mL(-1) of MnP by 7308, while enzyme production by BOS55 was not successful in stirred tank reactors but could be scaled up in 2-L shake flasks containing 400 mL rice bran or glucose-malt-yeast extract (GMY)-Mn-glycolate medium to produce MnP levels of 1.7 U x mL(-1). These results show that the two strains of B. adusta, UAMH 7308 and 8258, can produce between two and three times the manganese peroxidase level of B. adusta BOS55, that they are good candidates for scale up of enzyme production, and that the rice bran medium supports higher levels of enzyme production than most previously described media.     

High cell density and high monoclonal antibody production through medium design and rational control in a bioreactor

A simple feeding strategy was developed and successfully employed for nutritional control in a 2-L fed-batch culture of hybridoma cells. A previously developed stoichiometric model for animal cell growth was used to design a supplemental medium for feeding. Undialyzed fetal bovine serum and trace metals (Fe(2+), SeO(3) (2-), Li(+), Zn(2+), and Cu(2+)) were fed to the cells periodically in addition to the automatic feeding of other nutrients in the supplemental medium. In this study, the maximum viable cell density was increased from 6.3 x 10(6) to 1.7 x 10(7) cells/mL, and the culture span was extended from 340 to 550 hours. The final monoclonal antibody titer achieved was 2400 mg/L. The specific production rates for ammonia and lactate were further reduced from 0.0045 and 0.0048 in our previous fed-batch experiments to 0.0028 and 0.0036 mmol/10(9) cell h, respectively. Only 3.4% of the total glucose consumption was converted into lactate, compared to 67% in a conventional batch culture.     

Microcarrier culture of lepidopteran cell lines: implications for growth and recombinant protein production

Several microcarrier systems were screened with Sf-9 and High-Five cell lines as to their ability to support cell growth and recombinant (beta-galactosidase) protein production. Growth of both cell lines on compact microcarriers, such as Cytodex-1 and glass beads, was minimal, as cells detached easily from the microcarrier surface and grew as single cells in the medium. Cell growth was also problematic on Cytopore-1 and -2 porous microcarriers. Cells remained attached for several days inside the microcarrier pores, but no cell division and proliferation were observed. On the contrary, insect cells grew well in the interior of Fibra-Cel disks mainly as aggregates at points of fiber intersection, reaching final (plateau) densities of about 4 x 10(6) (Sf-9) and 2.7 x 10(6) (High-Five) cells mL(-1) (8 x 10(6) and 5.5 x 10(6) cells per cm(2) of projected disk area, respectively). Their growth was described well by the logistic equation, which takes into account possible inhibition effects. Beta-Galactosidase (beta-gal) production of Sf-9 cells on Fibra-Cel disks (infected at 3.3 x 10(6) cells mL(-1)) was prolonged (192 h), and specific protein production was similar to that of high-density free cell infection. Cultispher-S microcarriers were found to be a very efficient system for the growth of High-Five cells, whereas no growth of Sf-9 cells took place for the same system. Concentrations of about 9 x 10(6) cells mL(-1) were reached within 120 h, with cell growth in both microcarriers and aggregates, appearance of cellular bridges between microcarriers and aggregates, and eventual formation of macroaggregates incorporating several microcarriers. Specific protein productions after beta-gal baculovirus infection at increasing cell concentrations were almost constant, thus leading to elevated volumetric protein production: final beta-gal titers of 946, 1728, and 1484 U mL(-1) were obtained for infection densities of 3.4, 7.2, and 8.9 x 10(6) cells mL(-1), respectively.     

Rational scale-up of a baculovirus-insect cell batch process based on medium nutritional depth

We have developed a serum-free cell culture process utilizing a recombinant baculovirus (AcNPV) expression vector to infect Trichoplusia ni insect cells for the production of the human lysosomal enzyme, glucocerebrosidase. The enzyme, which is harvested as a secreted protein in this process, can serve as a replacement therapy for the genetic deficiency Gaucher disease. In the course of pilot scale-up of a batch glucocerebrosidase process from 25-mL working volume shaker flask units to 25-L working volume stirred bioreactor units, a semi-empirical model was developed for the rational determination of scaleable process parameters, including host cell density at infection, multiplicity of infection (MOI), and harvest time. A key assumption of the model is that maximum protein production is limited by the serum-free medium's nutritional capacity, which can, in turn, be determined from the growth of uninfected cells. For the host cell/medium combination used in this study, the nutritional limit was determined to be 1.3 x 10(7) to 1.7 x 10(7) viable-cell-days/mL. Based on this, the model predicts that optimal protein expression is consistent with a 4-day batch process where the host cell density at the time of infection is 1.5 x 10(6) to 2.0 x 10(6) cells/mL and the MOI is 0.09-0.3. These parameters were empirically confirmed to give the highest achievable batch product yield, first in shaker flasks and then at larger scales. The low MOI allows at least one population doubling to take place post viral addition, so that the effective infected cell density producing product generally exceeds 4 x 10(6) cells/mL. It was also interesting to note that this process consistently achieved the same level of maximum protein production at the 25-L bioreactor scale in 4 days compared to 5 days at the shaker flask scale. This may be attributable to better control of the culture environment in the bioreactor. Unlike some other lepidopteran insect cells, such as Sf-9, T. ni cells were found to produce significant levels of the inhibitory metabolites ammonia and lactate. Our results suggest that reduction and/or removal of inhibitory metabolites might be beneficial for infection of high-density cultures of these cells and might also facilitate application of more sophisticated culture strategies, including fed-batch. (c) 1996 John Wiley & Sons, Inc.     

Perfusion culture of hybridoma cells for hyperproduction of IgG(2a) monoclonal antibody in a wave bioreactor-perfusion culture system

A novel wave bioreactor-perfusion culture system was developed for highly efficient production of monoclonal antibody IgG2a (mAb) by hybridoma cells. The system consists of a wave bioreactor, a floating membrane cell-retention filter, and a weight-based perfusion controller. A polyethylene membrane filter with a pore size of 7 microm was floating on the surface of the culture broth for cell retention, eliminating the need for traditional pump around flow loops and external cell separators. A weight-based perfusion controller was designed to balance the medium renewal rate and the harvest rate during perfusion culture. BD Cell mAb Medium (BD Biosciences, CA) was identified to be the optimal basal medium for mAb production during batch culture. A control strategy for perfusion rate (volume of fresh medium/working volume of reactor/day, vvd) was identified as a key factor affecting cell growth and mAb accumulation during perfusion culture, and the optimal control strategy was increasing perfusion rate by 0.15 vvd per day. Average specific mAb production rate was linearly corrected with increasing perfusion rate within the range of investigation. The maximum viable cell density reached 22.3 x 105 and 200.5 x 105 cells/mL in the batch and perfusion culture, respectively, while the corresponding maximum mAb concentration reached 182.4 and 463.6 mg/L and the corresponding maximum total mAb amount was 182.4 and 1406.5 mg, respectively. Not only the yield of viable cell per liter of medium (32.9 x 105 cells/mL per liter medium) and the mAb yield per liter of medium (230.6 mg/L medium) but also the mAb volumetric productivity (33.1 mg/L.day) in perfusion culture were much higher than those (i.e., 22.3 x 105 cells/mL per liter medium, 182.4 mg/L medium, and 20.3 mg/L.day) in batch culture. Relatively fast cell growth and the perfusion culture approach warrant that high biomass and mAb productivity may be obtained in such a novel perfusion culture system (1 L working volume), which offers an alternative approach for producing gram quantity of proteins from industrial cell lines in a liter-size cell culture. The fundamental information obtained in this study may be useful for perfusion culture of hybridoma cells on a large scale.     

Use of a stationary bed reactor and serum-free medium for the production of recombinant proteins in insect cells.

Insect cells (Spodoptera frugiperda) have been cultured in a stationary bed reactor, packed with a fibrous polyester carrier. When the bioreactor was perfused with serum-supplemented medium, a cell density of 6 x 10(6) cells ml-1 packed carrier was reached. Scanning electron microscopy investigations have shown that the insect cells grew along the three-dimensionally oriented fibers of the Fibra-cel carrier. After infection of the logarithmically growing cells with a recombinant baculovirus (Autographa californica) containing the gene coding for beta-galactosidase, the medium in the bioreactor was changed to serum-free medium. At day 13 postinfection (p.i.), a beta-galactosidase level of 320 microgram ml-1 and, at day 17 p.i., a virus titer of 2.1 x 10(8) TCID50 units ml-1 (day 17 p.i.) were reached. In another bioreactor, operated in a similar way but with serum-containing medium, a beta-galactosidase concentration of 360 microgram ml-1 and a virus titer of 2.3 x 10(8) TCID50 units ml-1 were obtained. These results indicate the potential use of this production system for the production of recombinant protein and baculovirus in insect cells.     

昆虫细胞（Sf21）悬浮培养过程中生长限制性基质间歇补加技术的 …

基于ｒ２１昆虫细胞在浮过程中所表现出的生长代谢特征,提出以培养液中残糖浓度作为控制参数,并利用限制性基质（葡萄糖和蛋白水解物）的间歇补加技术调控细胞生长的方案。实际控制表明：与批培养相比,Ｓ１ｆ２１细胞在两种具代表性的昆虫水解物）的间歇补加调控细胞生长的方案。实际控制表明：与批培养相比,Ｓｆ２１细胞在两种具代表性的昆虫细胞培养基（ＩＰＬ－４１和ＴＣ－１００）中的生长期和稳定期部都到有效的延长。ＴＣ     

Culture of insect cells in helical ribbon impeller bioreactor

An 11-L helical ribbon impeller (HRI) bioreactor was tested for the culture of Spodoptera frugiperda (Sf-9) cells. This impeller and surface baffling ensured homogeneous mixing and high oxygen transfer through surface aeration and surface-induced babble generation. Serum-supplemented and serum-free cultures, using TNMFH and IPL/41 media, respectively, grew a similar specific growth rates(0.031 and 0.028 h(-1)) to maximum cell densities of 5.5 x 10(6)-6.0 x 10(6) cells. mL(-1) with viability exceeding 98% during exponential growth phase. Growth limitation coincided with glucose and glutamine depletion and production of significant amounts of alanine. The bioreactor was further tested under more stringent conditions by infecting a serum-free medium culture with a recombinant baculovirus. Heterologous protein production of approximately 35 mug per 10(6) cells was comparable to yields obtained in serum-free cultures grown in spinner flasks and petri dishes. Average specific oxygen up-take and carbon dioxide production rates of the serum-free culture prior to infection as measured by on-line mass spectroscopy were 0.20 mumol O(2)mu.(10(6) cells)(-1) h(-1) and 0.22 mumol CO(2) . (10(6) cells)(-1)h(-1) and increased by 30-40% during infection. Therefore, the mixing and oxygenation conditions of this bioreactor were suitable for insect cell culture and recombinant protein production, with limitation being mainly attributed to nutrient depletion and toxic by-product generation.     

On-line monitoring of human prostate cancer cells in a perfusion rotating wall vessel by near-infrared spectroscopy

PC-3 human prostate cancer cells have been cultivated in a rotating wall vessel in which glucose, lactate, and glutamine profiles were monitored noninvasively and in real time by near-infrared (NIR) spectroscopy. The calibration models were based on off-line spectra from tissue culture experiments described previously (Rhiel et al., Biotechnol Bioeng 77:73-82). Monitoring performance was improved by Fourier filtering of the spectra and initial off-set adjustment. The resulting standard errors of predictions were 0.95, 0.74, and 0.39 mM for glucose, lactate, and glutamine, respectively. The concentration of ammonia could not be accurately measured from the same spectra. In addition, metabolite uptake and production rates were determined for PC-3 prostate cancer cells during exponential growth in batch-mode cultivation. Cells grew with a doubling time of 21 h and consumed glucose and glutamine at rates of 6.8 and 1.8 x 10(-17) mol/cell.s, respectively. This resulted in lactate and ammonia production rates of 11.9 and 1.3 x 10(-17) mol/cell.s, respectively. Compared with other monitoring technologies, this technology has many advantages for spaceflights and stand-alone units; for instance, calibration can be performed at one time and then applied in a reagentless, low-maintenance way at a later time. The resulting concentration information can be incorporated into closed-loop control schemes, thereby leading to better in vitro models of in vivo behavior.     

High-density transient gene expression in suspension-adapted 293 EBNA1 cells

Large-scale transient gene expression (TGE) in mammalian cells is an attractive method to rapidly produce recombinant proteins for pre-clinical studies, with some processes reported to reach 100 L. However, the yield remains low, hardly over 20 mg protein/L, mainly because the current TGEs have been performed at low cell density (approximately 5 x 10(5) cells/mL). In this study, the strategy to improve TGE focuses on facilitating transfection at high cell density. A high-density perfusion culture of 293 EBNA1 cells was established in 2-L bioreactor using Freestyle 293 expression medium (Invitrogen, Singapore) to grow the cells for transfection. Transfection was then carried out at 1 x 10(7) cells/mL using polyethylenimine (PEI) as DNA carrier, at the optimized conditions of 6 microg DNA/10(7) cells and 1:3 DNA to PEI mass ratio. During the post-transfection phase, 80.8 mg/L of the model protein, EPO was obtained at day 5.5 post-transfection (130 mg total EPO production) using a fed-batch culture mode. In comparison, perfusion cultures using an enriched SFM II medium resulted in a longer post-transfection production phase (8 days), and 227 mg of EPO was produced in 10.7 L medium, showing that high-density TGE enables the production of several hundreds of milligrams of protein in a 2 L bioreactor. In addition, a protocol for economical plasmid preparation based on anion exchange was also established to satisfy TGE's demand in terms of quality and quantity. To the best of our knowledge, this is the first report of transient transfections at a high cell density of up to 1 x 10(7) cells/mL.     

Physiological characterization of Dunaliella sp. (Chlorophyta, Volvocales) from Yucatan, Mexico

Physiological responses of Dunaliella salina and Dunaliella viridis, isolated from solar saltworks on the Yucatan Peninsula, were studied. Optimal growth temperature for D. salina was 22 degrees C (3.06 x 10(6) cells mL(-1)) and 26 degrees C for D. viridis (4.04 x 10(6)cells mL(-1)). Total carotenoid content in D. salina increased with temperature to a maximum of 35.14 pg cell(-1) at 38 degrees C. Dunaliella salina alpha-carotene and beta-carotene content was 0.083+/-0.003 and 0.598+/-0.020 mg 100g dry wt(-1) respectively, whereas lower values were found in D. viridis cultured under same experimental conditions (0.018+/-0.002 and 0.136+/-0.012 mg 100g dry wt(-1) respectively). The highest specific growth rate in D. salina was obtained at 10% NaCl (0.28 d(-1)), while its cell volume increased from 524 to 2066.93 microm(3) when cultured from 10% to 35% NaCl. Maximum photosynthetic rates were attained when increasing from optimal growing temperature to 30 degrees C for D. viridis (108 n mol O(2)microg chl alpha h(-1)) and D. salina (139 n mol O(2)microg chl alpha h(-1)). Photosynthetic responses to temperature variations indicated physiological adjustments in both species, with higher acclimation in D. salina. Evaluation of physiological attributes of these species will be used for to carry out mass cultivation.     

Assessment of virus production and chloramphenicol acetyl transferase expression by insect cells in serum-free and serum-supplemented media using a temperature-sensitive baculovirus

Spodoptera frugiperda insect cells were grown in Sf-900 serum-free medium and two kinds of serum-supplemented media (IPL -41 and Grace's). The specific growth rates of uninfected cells were found to be 0.024, 0.35, and 0.034 h(-1) respectively, at 33 degrees C. The IPL -41 medium supported to highest maximum cell density (10.6 x 10(6) cells/mL) compared to 3.5 x 10(6) and 8.7 x 10(6) cells/mL with the Grace's and serum-free media, respectively. In temperature shifdown experiments with a temperature-sensitive baculo-virus (acts10YM1CAT), virus titer and chloramphenicol acetyl transferase (CAT) expression were highest in the IPL -41 (5.1 x 10(7) PFU/mL and 20000 U/mL). Use of Grace's medium gave higher virus titers than the serum-free medium (4.4 x 10(6) vs 4.1 x 10(5) PFU/mL) as well as higher CAT titers (7050 vs 1980 U/mL). Interestingly, in the three media used, the highest virus and CAT titers were obtained at MOI (multiplicity of infection) of 0.02 At MOI of 2.0 virtually no increase in virus of CAT titer was observed. This result is contrary to those obtained at constant-temperature (27 degrees C) infection and cell culture, in which higher virus titers and recombinant protein expression and obtained at higher MOI.     

High-level recombinant protein production in bioreactors using the baculovirus-insect cell expression system

In order to develop an efficient process for large-scale production of recombinant protein, various factors were studied which affect the productivity of Sf-9 (Spodoptera frugiperda) insect cells when using the baculovirus expression system. It was shown that upon infection with the Bac-BRV6L recombinant baculovirus, the level per cell of VP6 (a bovine rotavirus nucleocapsid protein) would drop 10-fold when host cell density at the time of infection increased from 2 x 10(6) to 3 x 10(6) cells/mL. The decrease was found to be totally reversible by culture medium renewal after infection, even when cells were infected at the stationary phase. Recombinant protein production was 4-6 times higher using TNMFH medium supplemented with 10% fetal bovine serum (FBS) than in IPL/41 serum-free medium. Fine-tuning of infection parameters in a 4-L surface-aerated bioreactor resulted in the production of typically 350 mg/L of VP6 protein, representing more than 25% of total cell proteins.     

Improvement of Panax notoginseng cell culture for production of ginseng saponin and polysaccharide by high density cultivation in pneumatically agitated bioreactors

A Panax notoginseng cell culture was successfully scaled up from shake flask to 1.0-L bubble column reactor and concentric-tube airlift reactor. High-density bioreactor batch cultivation was carried out using a modified MS medium. The maximum cell density in batch cultures reached 20.1, 21.0 and 24.1 g/L in the shake flask, bubble column and airlift reactors, respectively, and their corresponding biomass productivity was 950, 1140 and 1350 mg/(L x d) for each. The productivity of ginseng saponin was 70, 96 and 99 mg/(L x d) in the flask, bubble column and airlift reactors, respectively; and the polysaccharide productivity reached 104, 119 and 151 mg/(L x d) for each. Furthermore, a fed-batch cultivation strategy was developed on the basis of specific oxygen uptake rate (SOUR), i.e., sucrose feeding before a sharp decrease of SOUR, and the highest cell density of 29.7 g/L was successfully achieved in the airlift bioreactor on day 17 with a very high biomass productivity of 1520 mg/(L x d). The concentrations of ginseng saponin and polysaccharide reached about 2.1 and 3.0 g/L, respectively, and their productivity was 106 (saponin) and 158 mg/(L x d) (polysaccharide). This work successfully demonstrated the high-density bioreactor cultivation of P. notoginseng cells in pneumatically agitated bioreactors and the reproduction of the shake flask culture results in bioreactors. The cell density, biomass productivity, production titer and productivity of both ginseng saponin and polysaccharide obtained here were the highest that have been reported on a reactor scale for all the ginseng species.     

High-titer adenovirus vector production in 293S cell perfusion culture

Human 293S cells culture for recombinant adenovirus production is traditionally carried out in batch at a maximum of 6 x 10(5) cells/mL. A previous report demonstrated that fed-batch, applied to the adenovirus/293S cells system, improves the volumetric production of viral proteins by increasing the cell density at which cells can be infected, up to 2 x 10(6) cells/mL, without reducing the per-cell yield of product. To increase this cell density limit, the adenovirus production was performed in a perfusion system where the cells were separated by means of a tangential flow filtration device. 293S cell growth to 14 x 10(6) cells/mL was achieved in 10 days, at a medium renewal rate of 1 volume of medium per reactor volume and day (VVD). For adenovirus production, three 293S cell cultures were perfused at 1 VVD in parallel and infected at an average density of 8 x 10(6) cells/mL. One of the cultures was set at 37 degrees C and the two others at 35 degrees C. After a rapid initial cell loss, the average cell density stabilized at 5.75 x 10(6) cells/mL, 12 h postinfection, which was 8 times higher than the cell density in the batch control. This allowed the production of 3.2 x 10(9) infectious viral particles/mL (IVP/mL) at 37 degrees C and 7.8 x 10(9) IVP/mL at 35 degrees C, this last result being 5.5 times higher than the control. To our knowledge, this nonconcentrated titer is the highest value that has ever been published for adenovirus vector production. These observations lead to the conclusion that perfusion is an efficient tool to maintain, at high cell density, a specific production rate level sufficient to increase significantly the adenovirus volumetric production. Furthermore, it shows that perfusion at 35 degrees C can improve viral titer by 2.4-fold compared to 37 degrees C, in accordance with a previous study on adenovirus batch production.     

17β-雌二醇对延迟着床期小鼠子宫内膜基质细胞内钙的快速调节效应

本文旨在研究17β-雌二醇(17β-estradiol,E2)对延迟着床期小鼠子宫内膜基质细胞内钙振荡的影响和机制,探讨E2对着床期子宫内膜基质细胞是否存在非基因组快速作用.实验的第一部分,小鼠分为6组,每组4只,即0.1%二甲基亚砜(dimethylsulfoxide,DMSO)对照组、1×10-8mol/L牛血清白蛋白(bovine serum albumin,BSA)对照组、1×10-8mol/L E2组、1×10-8mol/L E2-BSA组、1×10-8mol/L E2 无钙液组、1×10-8mol/L E2 5μg/mL他莫西芬(tamoxifen)组.急性分离延迟着床小鼠孕第7天子宫内膜基质细胞,应用激光共聚焦显微镜技术实时检测各组基质细胞[Ca2 ]I的变化.实验的第二部分,分离7只延迟着床小鼠孕第7天子宫内膜基质细胞,用免疫荧光法检测1×10-8mol/L E2作用前和作用后5 min、15 min、30min细胞内磷酸化磷脂酶C(phospholipase C,PLC)的变化.基质细胞[Ca2 ]I的变化结果显示,在E2,E2-BSA和E2 无钙液组中[Ca2 ];均明显升高,15 min达到高峰,随后下降回到基础值.但DMSO和BSA组中[Ca2 ]I未见明显变化;加入传统雌激素胞浆受体阻断剂tamoxifen不能抑制E2引起的[Ca2 ]I升高.免疫荧光结果显示,加入1×10-8mol/L E2后,PLC的磷酸化水平升高,15 min达高峰(P<0.001),然后逐渐下降回到基础值.结果提示,E2对延迟着床小鼠子宫内膜基质细胞[Ca2 ]I的变化具有快速调节效应,该作用可能是通过非基因组途径实现的,与磷酸化PLC信号途径有关.     

Metabolic flux analysis of hybridoma cells in different culture media using mass balances

The estimation of the intracellular fluxes of mammalian cells using only the mass balances of the relevant metabolites is not possible because the set of linear equations defined by these mass balances is underdetermined. Either additional experimental flux data or additional theoretical constraints are required to find one unique flux distribution out of the solution space that is bound by the mass balances. Here, a method is developed using the latter approach. The uptake and production rates of amino acids, glucose, lactate, O(2), CO(2), NH(4), MAB, and the intracellular amino acid pools have been determined for two different steady-states. The cellular composition {total protein and protein composition, total lipids and fatty acid distribution, total carbohydrates, DNA and RNA} has been measured to calculate the requirements for biosynthesis. It is shown to be essential to determine the uptake/production rates of ammonia and either carbon dioxide or oxygen. In mammalian cells these are cometabolites of cyclic metabolic pathways. The flux distribution that is found using the Euclidean minimum norm as the additional theoretical constraint and taking either the CO(2) or the NAD(P)H mass balance into account is shown to be in agreement with the measured O(2) and CO(2) metabolic rates.The metabolic fluxes in hybridoma cells in continuous culture at a specific growth rate of 0.83 day(-1) are estimated for a medium with (optimal medium) and without (suboptimal medium) Primatone RL, an enzymatic hydrolysate of animal tissue that causes a more than twofold increase in cell density. It is concluded that (i)The majority of the consumed glucose (>90%) is channeled through the pentose-phosphate pathway in rapidly proliferating cells.(ii)Pyruvate oxidation and tricarboxylic acid (TCA) cycle activity are relatively low, i.e., 8% of the glucose uptake in suboptimal and 14% in optimal medium, respectively. Under both conditions, only a small fraction of pyruvate is further oxidized to CO(2).(iii)The flux from glutamate to alpha-ketoglutarate (catalyzed by glutamate dehydrogenase) is almost zero in medium with and even slightly reversed in medium without Primatone RL. Almost all glutamate enters the TCA cycle due to the action of transaminases.(iv)Transhydrogenation plays a significant role in hybridoma cells under our experimental conditions. NADPH is produced at relatively high rates (11 x 10(-12) to 13 x 10(-12) mol . cell(-1) . day(-1)) compared to other fluxes in both culture media. (c) 1996 John Wiley & Sons, Inc.     

A procedure for high-yield spore production by Bacillus subtilis

Bacillus subtilis spores have a number of potential applications, which include their use as probiotics and competitive exclusion agents to control zoonotic pathogens in animal production. The effect of cultivation conditions on Bacillus subtilis growth and sporulation was investigated in batch bioreactions performed at a 2-L scale. Studies of the cultivation conditions (pH, dissolved oxygen concentration, and media composition) led to an increase of the maximum concentration of vegetative cell from 2.6 x 10(9) to 2.2 x 10(10) cells mL(-)(1) and the spore concentration from 4.2 x 10(8) to 5.6 x 10(9) spores mL(-)(1). A fed-batch bioprocess was developed with the addition of a nutrient feeding solution using an exponential feeding profile obtained from the mass balance equations. Using the developed feeding profile, starting at the middle of the exponential growth phase and finishing in the late exponential phase, an increase of the maximum vegetative cell concentration and spore concentration up to 3.6 x 10(10) cells mL(-)(1) and 7.4 x 10(9) spores mL(-)(1), respectively, was obtained. Using the developed fed-batch bioreaction a 14-fold increase in the concentration of the vegetative cells was achieved. Moreover, the efficiency of sporulation under fed-batch bioreaction was 21%, which permitted a 19-fold increase in the final spore concentration, to a final value of 7.4 x 10(9) spores mL(-)(1). This represents a 3-fold increase relative to the highest reported value for Bacillus subtilis spore production.