Inactivation of animal viruses during sewage sludge treatment

Using a previously developed filter adsorption technique, the inactivation of a human rotavirus, a coxsackievirus B5, and a bovine parvovirus was monitored during sludge treatment processes. During conventional anaerobic mesophilic digestion at 35 to 36 degrees C, only minor inactivation of all three viruses occurred. The k' values measured were 0.314 log10 unit/day for rotavirus, 0.475 log10 unit/day for coxsackievirus B5, and 0.944 log10 unit/day for parvovirus. However, anaerobic thermophilic digestion at 54 to 56 degrees C led to rapid inactivation of rotavirus (k' greater than 8.5 log10 units/h) and of coxsackievirus B5 (k' greater than 0.93 log10 unit/min). Similarly, aerobic thermophilic fermentation at 60 to 61 degrees C rapidly inactivated rotavirus (k' = 0.75 log10 unit/min) and coxsackievirus B5 (k' greater than 1.67 log10 units/min). Infectivity of parvovirus, however, was only reduced by 0.213 log10 unit/h during anaerobic thermophilic digestion and by 0.353 log10 unit/h during aerobic thermophilic fermentation. Furthermore, pasteurization at 70 degrees C for 30 min inactivated the parvovirus by 0.72 log10 unit/30 min. In all experiments the contribution of temperature to the total inactivation was determined separately and was found to be predominant at process temperatures above 54 degrees C. In conclusion, the most favorable treatment to render sludge hygienically safe from the virological point of view would be a thermal treatment (60 degrees C) to inactivate thermolabile viruses, followed by an anaerobic mesophilic digestion to eliminate thermostable viruses that are more sensitive to chemical and microbial inactivations.     

Inactivation of Salmonella during anaerobic digestion of sewage sludge

The inactivation of Salmonella duesseldorf in sewage sludge during anaerobic digestion was investigated at 35 and 48°C with mean retention periods of between 10 and 20 days. Digesters were fed daily with raw sludge containing added Salm. duesseldorf after removal of digested sludge. During steady operation, the levels of Salm. duesseldorf in the digested and the feed sludge were determined and their specific rates of decay were estimated. The latter were: (i) greater at 48°C than at 35°C for the same retention time; (ii) similar for retention periods greater than 15 d, but lower for 10 d; (iii) greater when the level of salmonellas in the feed was lower. Gas production, a measure of steady state, was gradually lost when the mean retention period was reduced to 6.7 d. In experiments in which a single dose of Salm. duesseldorf was added to digesting sludge, the inactivation appeared to follow first-order kinetics at 35°C and the decimal decay rate, 1.6/d, was similar to that in the daily feeding experiments (1.4/d) with larger and similar inocula of Salm. duesseldorf. At 48°C, however, the rate of inactivation declined with decreasing time from inoculation suggesting that the culture contained cells differing in thermal resistance. The degrees and rates of inactivation of salmonellas in those experiments were greater than in full-scale digesters, because the latter seldom operated under conditions ideal for inactivation or because indigenous salmonellas are more resistant.     

Inactivation of enteric viruses in wastewater sludge through dewatering by evaporation.

The effect of dewatering on the inactivation rates of enteric viruses in sludge was determined. For this study, water was evaporated from seeded raw sludge at 21 degrees C, and the loss of viral plaque-forming units was measured. Initial results with poliovirus showed that recoverable infectivity gradually decreased with the loss of water until the solids content reached about 65%. When the solids content was increased from 65 to 83%, a further, more dramatic decrease in virus titer of greater than three orders of magnitude was observed. This loss of infectivity was due to irreversible inactivation of poliovirus because viral particles were found to have released their RNA molecules which were extensively degraded. Viral inactivation in these experiments may have been at least partially caused by the evaporation process itself because similar effects on poliovirus particles were observed in distilled water after only partial loss of water by evaporation. Coxsackievirus and reovirus were also found to be inactivated in sludge under comparable conditions, which suggests that dewatering by evaporation may be a feasible method of inactivating all enteric viruses in sludge.     

Inactivation of enteric viruses in wastewater sludge through dewatering by evaporation.

The effect of dewatering on the inactivation rates of enteric viruses in sludge was determined. For this study, water was evaporated from seeded raw sludge at 21 degrees C, and the loss of viral plaque-forming units was measured. Initial results with poliovirus showed that recoverable infectivity gradually decreased with the loss of water until the solids content reached about 65%. When the solids content was increased from 65 to 83%, a further, more dramatic decrease in virus titer of greater than three orders of magnitude was observed. This loss of infectivity was due to irreversible inactivation of poliovirus because viral particles were found to have released their RNA molecules which were extensively degraded. Viral inactivation in these experiments may have been at least partially caused by the evaporation process itself because similar effects on poliovirus particles were observed in distilled water after only partial loss of water by evaporation. Coxsackievirus and reovirus were also found to be inactivated in sludge under comparable conditions, which suggests that dewatering by evaporation may be a feasible method of inactivating all enteric viruses in sludge.     

Inactivation of indigenous viruses in raw sludge by air drying

Air drying of raw sludge caused inactivation of indigenous viruses. A gradual loss of infectivity occurred with the loss of water until the solids content reached about 80%. A more rapid decline of viral infectivity occurred with further dewatering.     

Inactivation by gamma irradiation of animal viruses in simulated laboratory effluent.

Several animal viruses were treated with gamma radiation from a 60Co source under conditions which might be found in effluent from an animal disease laboratory. Swine vesicular disease virus, vesicular stomatitis virus, and blue-tongue virus were irradiated in tissues from experimentally infected animals. Pseudorabies virus, fowl plague virus, swine vesicular disease virus, and vesicular stomatitis virus were irradiated in liquid animal feces. All were tested in animals and in vitro. The D10 values, that is, the doses required to reduce infectivity by 1 log10, were not apparently different from those expected from predictions based on other data and theoretical considerations. The existence of the viruses in pieces of tissue or in liquid feces made no difference in the efficacy of the gamma radiation for inactivating them. Under the "worst case" conditions (most protective for virus) simulated in this study, no infectious agents would survive 4.0 Mrads.     

Effect of seeding during thermophilic composting of sewage sludge.

Serological analysis of the O and K antigens was performed on 324 isolates of Vibrio parahaemolyticus obtained from three hydrobiologically dissimilar aquatic environments. Only 50.9% of the strains could be serotyped. The largest number of untypable strains and the lowest serological diversity were observed from the freshwater collection. Three serotypes, O2:K28, O5:K17, and O2:K3, dominated among all biotopes. There appears to be some distinction between serotypes of environmental and clinical origins.     

Occurrence of Aspergillus fumigatus during composting of sewage sludge.

Aspergillus fumigatus, a medically important fungal opportunist and respiratory allergen, was isolated from woodchips and sewage sludge used in the production of compost at the U.S. Department of Agriculture's composting research facility in Beltsville, Md. It was also regularly isolated as a dominant fungus during forced aeration composting and after 30 days in an unaerated stationary curing pile; in both cases, the fungus was found in pile zones with temperatures less than 60 degrees C. Compost stored outdoors in stationary unaerated piles from 1 to 4 months after screening out of woodchips contained easily detectable amounts of A. fumigatus in the exterior pile zones (0- to 25-cm depths). Semiquantitative studies of the airspora at the composting site revealed that A. fumigatus constituted 75% of the total viable mycoflora captured. At locations 320 m to 8 km from the compost site, the fungus constituted only 2% of the total viable mycoflora in the air. Of 21 samples of commercially available potting soil, one had levels of A. fumigatus nearly equivalent to those of 1-month-old storage compost; 15 others had lower but detectable levels.     

Occurrence of Aspergillus fumigatus during composting of sewage sludge.

Aspergillus fumigatus, a medically important fungal opportunist and respiratory allergen, was isolated from woodchips and sewage sludge used in the production of compost at the U.S. Department of Agriculture's composting research facility in Beltsville, Md. It was also regularly isolated as a dominant fungus during forced aeration composting and after 30 days in an unaerated stationary curing pile; in both cases, the fungus was found in pile zones with temperatures less than 60 degrees C. Compost stored outdoors in stationary unaerated piles from 1 to 4 months after screening out of woodchips contained easily detectable amounts of A. fumigatus in the exterior pile zones (0- to 25-cm depths). Semiquantitative studies of the airspora at the composting site revealed that A. fumigatus constituted 75% of the total viable mycoflora captured. At locations 320 m to 8 km from the compost site, the fungus constituted only 2% of the total viable mycoflora in the air. Of 21 samples of commercially available potting soil, one had levels of A. fumigatus nearly equivalent to those of 1-month-old storage compost; 15 others had lower but detectable levels.     

Inactivation by ionizing radiation of Salmonella enteritidis serotype montevideo grown in composed sewage sludge.

S. enteritidis ser. montevideo were grown in composted sewage sludge to levels of approximately 10(9)/g. These bacteria were found to be inactivated by ionizing radiation at approximately the same rate (30 krads/log) as Salmonella species in liquid digested sludge.     

Human pathogenic viruses at sewage sludge disposal sites in the Middle Atlantic region.

Human enteric viruses were detected in samples of water, crabs, and bottom sediments obtained from two sewage sludge disposal sites in the Atlantic Ocean. Viruses were isolated from sediments 17 months after the cessation of sludge dumping. These findings indicate that, under natural conditions, viruses can survive for a long period of time in the marine environment and that they may present potential public health problems to humans using these resources for food and recreation. The isolation of viruses in the absence of fecal indicator bacteria reinforces previous observations on the inadequacy of these bacteria for predicting the virological quality of water and shellfish.     

Inactivation by gamma irradiation of animal viruses in simulated laboratory effluent

Several animal viruses were treated with gamma radiation from a 60Co source under conditions which might be found in effluent from an animal disease laboratory. Swine vesicular disease virus, vesicular stomatitis virus, and blue-tongue virus were irradiated in tissues from experimentally infected animals. Pseudorabies virus, fowl plague virus, swine vesicular disease virus, and vesicular stomatitis virus were irradiated in liquid animal feces. All were tested in animals and in vitro. The D10 values, that is, the doses required to reduce infectivity by 1 log10, were not apparently different from those expected from predictions based on other data and theoretical considerations. The existence of the viruses in pieces of tissue or in liquid feces made no difference in the efficacy of the gamma radiation for inactivating them. Under the "worst case" conditions (most protective for virus) simulated in this study, no infectious agents would survive 4.0 Mrads.     

Elimination of human enteric viruses during conventional waste water treatment by activated sludge

The present study was undertaken to determine if viruses were selectively eliminated during waste water treatment. Human enteric viruses were detected at all steps of treatment in a conventional activated sludge waste water treatment plant. Liquid overlays and large volume sampling with multiple passages on BGM cells permitted the detection of poliovirus (serotypes 1, 2, and 3), coxsackievirus B (serotypes 1, 2, 3, 4, and 5), and echovirus (serotypes 3, 14, and 22), as well as reoviruses. The mean virus concentration was 95.1 most probable number of infectious units per litre (mpniu/L) in raw sewage, 23.3 in settled water, 1.4 in effluent after activated sludge treatment, and 40.3 mpniu/L in sludge samples. All samples of raw sewage and settled water, 79% of effluent water, and 94% of sludge samples contained viruses. The mean reduction was 75% after settling and 98% after activated sludge treatment. Poliovirus type 3 was rarely isolated after the activated sludge treatment, but was still detected in about one-third of the sludge samples. Reoviruses and coxsackieviruses were detected at similar rates from all samples and appear to be more resistant to the activated sludge treatment than poliovirus type 3. Poliovirus types 1 and 2 were present in almost every sample of raw sewage and settled water and still found in about half of the effluent and sludge samples, indicating a level of resistance similar to that of reoviruses and coxsackieviruses.     

Inactivation of plant and animal viruses by proanthocyanidins from Alpinia zerumbet extract

Alpinia zerumbet (Pers.) B.L. Burtt and R.M. Smith belongs to the Alpinia genus in the Zingiberaceae family. In East Asia, Alpinia zerumbet has been widely used as food and traditional medicine. Previously, we identified proanthocyanidins (PACs), an anti-plant-virus molecule in A. zerumbet, using Nicotiana benthamiana and tomato mosaic virus (ToMV). Here, we found that PACs from A. zerumbet, apple, and green tea effectively inhibited ToMV infection. Additionally, the PACs from A. zerumbet exhibited greater antiviral activity than those from apple and green tea. The PACs from A. zerumbet also effectively inactivated influenza A virus and porcine epidemic diarrhea virus (PEDV), which acts as a surrogate for human coronaviruses, in a dose-dependent manner. The results from the cytopathic effect assays indicated that 0.1 mg/ml PACs from A. zerumbet decreased the titer of influenza A virus and PEDV by >3 log. These findings suggested that the direct treatment of viruses with PACs from A. zerumbet before inoculation reduced viral activity; thus, PACs might inhibit infections by an influenza virus, coronaviruses, and plant viruses.     

Inactivation of poliovirus in digested sludge.

The effect of anaerobically digested sludge on poliovirus during incubation at temperatures between 28 and 4 C was studied. Although virus was fully recoverable from sludge, its infectivity decreased in proportion to the time and temperature of incubation. The rate ranged from greater than 1 log per day at 28 C to about 1 log every 5 days at 4 C. The mechanism of inactivation was studied at the lower temperature where the sedimentation coefficients of most inactivated particles were not detectably modified. The ribonucleic acid (RNA) of these particles appeared to have been nicked and had an average sedimentation value about 70% that of RNA from infectious virus. Since the specific infectivity of RNA from particles recovered from sludge was directly proportional to that of the particles from which it was extracted, loss of infectivity was probably due to inactivation of RNA. Some breakdown was also found in the two largest viral proteins of inactivated particles. Thus, the mechanism of inactivation may be cleavage of viral proteins followed by nicking of encapsulated RNA. Because no virucidal activity was found in raw sludge, this component of digested sludge appears to be a product of the digestion process.     

Inactivation of poliovirus in digested sludge.

The effect of anaerobically digested sludge on poliovirus during incubation at temperatures between 28 and 4 C was studied. Although virus was fully recoverable from sludge, its infectivity decreased in proportion to the time and temperature of incubation. The rate ranged from greater than 1 log per day at 28 C to about 1 log every 5 days at 4 C. The mechanism of inactivation was studied at the lower temperature where the sedimentation coefficients of most inactivated particles were not detectably modified. The ribonucleic acid (RNA) of these particles appeared to have been nicked and had an average sedimentation value about 70% that of RNA from infectious virus. Since the specific infectivity of RNA from particles recovered from sludge was directly proportional to that of the particles from which it was extracted, loss of infectivity was probably due to inactivation of RNA. Some breakdown was also found in the two largest viral proteins of inactivated particles. Thus, the mechanism of inactivation may be cleavage of viral proteins followed by nicking of encapsulated RNA. Because no virucidal activity was found in raw sludge, this component of digested sludge appears to be a product of the digestion process.     

Effect of seeding during thermophilic composting of sewage sludge

The effect of seeding on the thermophilic composting of sewage sludge was examined by measuring the changes in CO2 evolution rates and microbial numbers. Although the succession of thermophilic bacteria and thermophilic actinomycetes clearly reflected the effect of seeding, no clear difference was observed in the overall rate of composting or quality of the composted product.     

Sampling strategy for detecting viruses in a sewage treatment plant.

A study of pollutant flows was carried out at a wastewater treatment plant in Nancy, France, which used activated-sludge treatment. To carry out observation of hourly flow variation, a sampling strategy needs to be defined. A comparison between two methods of sampling was conducted: dip samples every 2 h over a period of 24 h and one 24-h composite sample were taken from raw and treated wastewater and then analyzed for enteroviruses, fecal coliforms, chemical oxygen demand, biochemical oxygen demand, and suspended solids. The results showed that the hourly variations of these pollutants in the effluents are in good agreement with expectations based upon the customers' usage and the characteristics of the wastewater network. Significant correlations were found between all tested parameters and enteroviruses in raw wastewater. After biological treatment, no correlation remained in treated wastewater between viruses and other parameters. As for the two sampling methods, a rather good representation of the daily load was given by the composite mode of sampling as concerns physicochemical and microbiological parameters. Biological treatment removed an average of 83% of viruses.     

Inactivation of viruses with photoactive compounds.

The transmission of human immunodeficiency virus (HIV-1) and other enveloped virus by blood transfusion is a major concern. Photosensitive dyes such as hematoporphyrin derivative (HPD), dihematoporphyrin ether (DHE), benzoporphyrin derivatives (BPD), extended ring porphyrins, sapphyrins and texaphyrins, and various cyanines were used with viral cultures to test the feasibility of using those light-excitable dyes to kill virus. A photodynamic flow cell was used to irradiate viral suspensions or viral infected cells in culture media or in whole blood. Herpes virus (HSV-1) was used to screen compounds. Effective compounds were subsequently tested for their ability to kill HIV-1, CMV, and SIV in culture medium and in blood and proved to effectively kill free virus and infected cells at significant viremias. Irradiation was achieved with a filtered xenon light source and/or tunable dye laser. Concentrations of dyes at 10 times viral kill dose were irradiated in blood which was tested for damage to erythrocytes (RBC), platelets, and blood proteins. No damage to RBC, complement factors, and immunoglobulins was evident immediately after photodynamic treatment. Platelet condition is minimally modified with time. Photodynamic treatment of blood appears to be a feasible means of eradicating virus and some protozoans from blood.