Sensitivity of aflatoxin b1 to ionizing radiation.

Aflatoxin B1 in a 5-micrograms/ml water solution was sensitive to ionizing radiation. Inactivation was assayed by the Ames microsome mutagenicity test and confirmed by thin-layer chromatography. Destruction of aflatoxin B1 had already begun at 2.5 kilograms (kGy; 1 kGy = 0.1 Mrad), but a dose exceeding 10 kGy was necessary for total destruction.     

Validating a Low Dose Gamma Irradiation Process for Sterilizing Allografts Using ISO 11137 Method 2B

This paper describes the validation of an allograft sterilization method specifically designed for the processing methods used at AlloSource in Centennial, CO. The methods used for this validation followed ISO Standard 11137, Method 2B. Three hundred allografts, collected from three defined production batches were dosed using a series of five incremental doses, beginning at 1 kGy and increasing by 1 kGy until 5 kGy was achieved. Following sterilization dosing, each allograft test article was analyzed using a sterility test to identify any viable microorganisms. The number of positive sterility samples was used to calculate the verification dose (1.27 kGy), which was then verified by an additional batch of 100 allografts. The results from this validation indicate that sterility (10⁻⁶ SAL) on human allograft tissue using gamma ⁶⁰Co radiation can be achieved when a dose of at least 9.2 kGy is employed.     

Radiation inactivation of some food-borne pathogens in fish as influenced by fat levels

The influence of low (0·39–1·1%), medium (4·25%) and high (7·1–32·5%) fat levels in fish on radiation inactivation of four food-borne pathogens was investigated. Cells of Listeria monocytogenes 036, Yersinia enterocolitica F5692, Bacillus cereus and Salmonella typhimurium at logarithmic phase were inoculated in 10% fish homogenates and subjected to gamma irradiation at ice temperature (0–1 °C) with doses ranging from 0·05 to 0·8 kGy. The radiation survival curves of L. monocytogenes and B. cereus were characterized by shoulders, while a tailing effect was depicted by cells of Y. enterocolitica and B. cereus . The D₁₀ values in kGy calculated on the exponential part of the curve ranged from 0·2 to 0·3, 0·15 to 0·25, 0·1 to 0·15 and 0·09 to 0·1 for L. monocytogenes 036, B. cereus, Salm. typhimurium and Y. enterocolitica F5692, respectively. This order (D₁₀) of radiation resistance of each organism was not affected by the fat content of the fish. Inoculated pack studies carried out separately with each pathogen in fatty (Indian sardine, 7·1%) and lean (Golden anchovy, 0·39%) fish showed no difference in their survival after exposure to 1 kGy and 3 kGy doses, which corroborated the above observation. The practical significance of these results in the application of the technology is discussed.     

Inactivation of Bacillus endospores in envelopes by electron beam irradiation

The anthrax incidents in the United States in the fall of 2001 led to the use of electron beam (EB) processing to sanitize the mail for the U.S. Postal Service. This method of sanitization has prompted the need to further investigate the effect of EB irradiation on the destruction of Bacillus endospores. In this study, endospores of an anthrax surrogate, B. atrophaeus, were destroyed to demonstrate the efficacy of EB treatment of such biohazard spores. EB exposures were performed to determine (i) the inactivation of varying B. atrophaeus spore concentrations, (ii) a D10 value (dose required to reduce a population by 1 log10) for the B. atrophaeus spores, (iii) the effects of spore survival at the bottom of a standardized paper envelope stack, and (iv) the maximum temperature received by spores. A maximum temperature of 49.2 degrees C was reached at a lethal dose of approximately 40 kGy, which is a significantly lower temperature than that needed to kill spores by thermal effects alone. A D10 value of 1.53 kGy was determined for the species. A surface EB dose between 25 and 32 kGy produced the appropriate killing dose of EB between 11 and 16 kGy required to inactivate 8 log10 spores, when spore samples were placed at the bottom of a 5.5-cm stack of envelopes.     

Gamma radiation resistance of Bacillus anthracis spores

The aim of the presented study was determined the effectiveness of action the gamma radiation on water suspension B. anthracis spores. The irradiation was performed using a Cobalt 60 (Co 60) source, by using single and fractionary irradiation doses. In the investigations was used B. anthracis stain "Sterne" 34F2. The obtained results show, that gamma radiation effectively inactivates B. anthracis spores. On the efficiency of sterilization process influence the irradiation's method and the number of spores in 1 ml suspension. In the suspension 1.5 x 10(9) spore in 1 ml, sporicidal doses gamma radiation amount to 25.0 kGy (single dose) or 41.5 kGy (fractionary dose). The volume suspension about definite inoculum of spores, subjected working the gamma rays has not influence on sporicidal effectiveness of radiation sterilization.     

Inactivation of Bacillus Endospores in Envelopes by Electron Beam Irradiation

The anthrax incidents in the United States in the fall of 2001 led to the use of electron beam (EB) processing to sanitize the mail for the U.S. Postal Service. This method of sanitization has prompted the need to further investigate the effect of EB irradiation on the destruction of Bacillus endospores. In this study, endospores of an anthrax surrogate, B. atrophaeus, were destroyed to demonstrate the efficacy of EB treatment of such biohazard spores. EB exposures were performed to determine (i) the inactivation of varying B. atrophaeus spore concentrations, (ii) a D₁₀ value (dose required to reduce a population by 1 log₁₀) for the B. atrophaeus spores, (iii) the effects of spore survival at the bottom of a standardized paper envelope stack, and (iv) the maximum temperature received by spores. A maximum temperature of 49.2°C was reached at a lethal dose of ~40 kGy, which is a significantly lower temperature than that needed to kill spores by thermal effects alone. AD₁₀ value of 1.53 kGy was determined for the species. A surface EB dose between 25 and 32 kGy produced the appropriate killing dose of EB between 11 and 16 kGy required to inactivate 8 log₁₀ spores, when spore samples were placed at the bottom of a 5.5-cm stack of envelopes.     

The influence of the irradiation regime upon mycotoxins production under experimental conditions

The paper handles the problem of the inactivation of the toxinogenic strain Aspergillus flavus following the application of gamma radiation to wheat. The amount of the applied dose and of the absorbed dose of ionizing radiation upon the inhibition of mycelium growth and toxin production were defined. The aflatoxin B1 was determined by extracting in chloroform and developed on Silufol R within the choroform; aceton system. The applied doses of gamma radiation (3-30 kGy) have show that the absorbed dose does not inhibit aflatoxin production. By combining the action of gamma radiation with humidity of the wheat (humidity 13-15%; 25% irradiation 6 kGy) an inactivation was reached. With the help of toxicologico-genetical tests (the Dominant Lethal Mutations Test, the Three Generations Test) the influence was traced of contaminated, irradiated substrates upon the health of experimental animals. It follows from the results obtained that in long-term feeding with contaminated wheat irradiated by gamma rays no positive mutagenic activity has been recorded. It allows to presume that wheat of humidity of 25% contaminated by a weakly toxigenic strain Aspergillus flavus irradiated by a dose of 6 kGy, and wheat of a humidity of 13-15%, contaminated by a strongly toxinogenic strain of Aspergillus flavus, irradiated by a dose of 6 kGy, are no genetic risk for white rats.     

Differential susceptibility of alpha A- and alpha B-crystallin to gamma-ray irradiation

Alpha-crystallin, a major protein of all vertebrate lenses, consists of two different subunits, alpha A and alpha B, which form polymeric aggregates with an average molecular mass of 300-800 kDa. Both the alpha A and alpha B subunit have a molecular mass of about 20 kDa. It is not known why alpha crystallin aggregates comprise two different subunits, given that the physicochemical properties of these proteins are very similar. The present study compares the susceptibility of the alpha A and alpha B subunits to gamma-rays. We prepared a recombinant form of human alpha A- and alpha B-crystallin and then irradiated the proteins with gamma-rays. Based on far-UV CD spectra, alpha A-crystallin retained beta-sheet conformation after gamma irradiation up to 3.0 kGy, whereas alpha B-crystallin lost beta-sheet conformation upon exposure to gamma irradiation at >1.0 kGy. Size exclusion chromatography showed that the aggregation and polydispersity of recombinant alpha A-crystallin increased slightly after >1.0 kGy irradiation. In contrast, irradiation of alpha B-crystallin at 1.0 kGy resulted in the formation of huge aggregates and a marked increase in heterogeneity. We have also compared the chaperone activities of gamma-irradiated alpha A- and alpha B-crystallin aggregates. The activity of irradiated alpha A-crystallin was retained while that of the irradiated alpha B-crystallin was became inactive after irradiation of >0.5 kGy. Our results indicate that alpha A-crystallin is more stable to gamma irradiation than alpha B-crystallin.     

The influence of gamma radiation and substrate on mycotoxin production by Fusarium culmorum IMI 309344

Mycotoxin production (deoxynivalenol (DON), acetyl deoxynivalenol (A DON) and zearalenone) by Fusarium culmorum inoculated on to maize (heat sterilized, irradiation sterilized and non-sterile) and irradiated to 1 kGy or 3 kGy, or unirradiated, was investigated over a period of time. Lowest mycotoxin production was observed on non-sterile maize which may be due to the presence of a competitive microflora on non-sterile maize. In general, mycotoxin production was higher on heat-sterilized grain as compared to irradiation-sterilized maize. It was suggested that this pattern of mycotoxin production was possibly caused by changes in the grain brought about by autoclaving, which favoured mycotoxin production and possibly induced changes in irradiation-sterilized maize which inhibited mycotoxin production. On sterile maize, there was no significant difference in DON production by unirradiated, 1 kGy and 3 kGy irradiated cultures up to 56 d of incubation; between days 56 and 77 of incubation, DON production increased rapidly with largest increases occurring in irradiated (1 kGy and 3 kGy) cultures. On non-sterile grain, neither DON nor A DON were detected in unirradiated cultures of F. culmorum but were detected in cultures irradiated to 1 kGy and 3 kGy. In practice grain should be stored under conditions of temperature and moisture content which prevent fungal growth. However, in this study, the grain was stored under conditions that were approaching ideal for growth of the test organism. The results highlight that irradiation disinfestation of grain must be combined with good grain handling practices so that excessive mycotoxin production can be prevented during storage.     

Validation and Substantiation of 25 kGy as Sterilization Dose for Lyophilized Human Amnion Membrane

The validation and substantiation of sterilization dose for lyophilized human amnion membrane by gamma irradiation delivered by Co⁶⁰ source were investigated. The validation experiments were conducted according to ISO 13409 method B. A total of 120 human amnion membranes were collected. Of these, 10 membranes were used for estimation of bioburden and 20 membranes were used for the individual sterility test at verification dose. The average bioburden per product unit with sample item portion (SIP = 1) for lyophilized human amnion membrane was 572 cfu. The verification dose experiments were done at dose of 8.1 kGy and the results of sterility tests showed that human amnion membrane got one positive. Consequently, the sterilization dose of 25 kGy was confirmed and substantiated.     

Influencing of ionizing radiation on herpes simplex virus and its genome

The effects of cobalt-60 gamma-rays, 10 MeV electrons and 52 MeV deutrons on the survival of plaque-forming ability has been studied in various strains of herpes simplex virus (HSV). The results show that the D0 for the loss of plaque-forming ability in different HSV strains lies in the range 1-3 kGy. Irradiation of isolated HSV-1 DNA with cobalt-60 gamma-rays resulted in damage, as indicated by electrophoresis of purified viral DNA and by restriction endonuclease analysis, at doses of 1 kGy, with complete loss of structure at doses above 4 kGy. The infectivity of the irradiated naked DNA was lost at doses above 4 kGy, but after irradiation of the intact virus some plaque-forming ability was retained after doses of 10 or even 40 kGy. Thus the organization within the viral capsid may play a protective role by modifying the severity of the radiation damage, and preserving at least some degree of infectivity.     

Inactivation of Escherichia coli O157:H7 in Apple Juice by Irradiation

Three strains (932, Ent-C9490, and SEA13B88) of Escherichia coli O157:H7 were used to determine the effectiveness of low-dose gamma irradiation for eliminating E. coli O157:H7 from apple juice or cider and to characterize the effect of inducing pH-dependent, stationary-phase acid resistance on radiation resistance. The strains were grown in tryptic soy broth with or without 1% dextrose for 18 h to produce cells that were or were not induced to pH-dependent stationary-phase acid resistance. The bacteria were then transferred to clarified apple juice and irradiated at 2°C with a cesium-137 irradiator. Non-acid-adapted cells had radiation D values (radiation doses needed to decrease a microbial population by 90%) ranging from 0.12 to 0.21 kGy. D values increased to 0.22 to 0.31 kGy for acid-adapted cells. When acid-adapted SEA13B88 cells were tested in five apple juice brands having different levels of suspended solids (absorbances ranging from 0.04 to 2.01 at 550 nm), radiation resistance increased with increasing levels of suspended solids, with D values ranging from 0.26 to 0.35 kGy. Based on these results, a dose of 1.8 kGy should be sufficient to achieve the 5D inactivation of E. coli recommended by the National Advisory Committee for Microbiological Criteria for Foods.     

Effect of dose-rate and dose fractionation on radiation-induced hemolysis of human erythrocytes.

Human erythrocytes suspended in an isotonic Na-phosphate buffer, pH 7.4 (hematocrit 2%) were exposed under air to gamma radiation at a dose rates of 2.2 kGy.h-1 and 4.2 kGy.h-1. The dose-response curves for hemolysis of erythrocytes indicated that the process of hemolysis is inversely related to the dose-rate. At both dose-rates we observed a reduced level of hemolysis, when erythrocytes were irradiated with a split dose (0.4 kGy + 2.3 kGy with an interval time between the subsequent exposures from 1 to 4 h) in comparison with the same single dose (2.7 kGy). The maximal effect of fractionation was observed when the interfraction time was equal to 3.5 h. The influence of the interfraction temperature on this effect was observed. The results obtained indicate that enucleated human erythrocytes under suitable radiation conditions are capable of repairing radiation damage which leads to hemolysis.     

Evaluation of Gamma-Radiation Inactivation of a Bioterrorism Agent, <Emphasis Type="Italic">Bacillus anthracis</Emphasis> Spores,on Different Materials

Decontamination of suspected packages, such as sealed envelopes, liquids and tools that are likely contaminated with biological agents is of great importance. In this study, we aimed to determine the gamma radiation dose required for the decontamination of paper, fabric and liquid materials without causing any damage to the structure of these materials. Each study group included 11 pieces of paper, fabric and sterile saline contaminated with 0.8 × 10⁵ virulent Bacillus anthracis (B. anthracis) spores. These specimens were exposed to doses of 5.49, 11.58, 17.21, 21.75, 27 and 33.1 kilogray (kGy) of gamma radiation from a cobalt-60 source. After irradiation of all the samples, a viability assessment of the B. anthracis spores was performed. It was found that full decontamination was achieved with 11.58 kGy on the paper samples and 17.21 kGy on the fabric and liquid samples. It was concluded that a dose of 20 kGy of gamma radiation may be recommended for the inactivation of B. anthracis for some surfaces when especially sensitive and valuable materials cannot be wet decontaminated were exposed. In addition, serologic and molecular assays of the suspected packets can be performed for forensic purposes without damaging existing evidence in a bioterror incident.     

The restoration of the enzyme activity of chernozem soil after gamma-irradiation

The Influence of gamma-radiation by dozes 1, 5, 10 and 20 kGy on enzyme activity of ordinary chemozem were studied. Dynamics of the restoration of the enzyme activity after the influence of gamma-radiation in model experiments in 3, 30, 90 and 180 days was investigated. The doze 1 kGy did no statistically significant influence on the investigated enzymes. Dehydrogenase is more radiosensitive enzyme than catalase. Values of the saccharase activity differed a significant variation so in most cases it has not been registered statistically significant changes. In 90-180 days of the incubation enzymes activity was restored up to control values. Dehydrogenase activity in 180 days in variants with dozes 10 and 20 kGy was restored up to a level of the control, over variants with dozes 1 and 5 kGy--is higher than the control over 78% and 23% accordingly. Saccharase activity in 180 days after the influence of gamma-radiation with a doze 20 kGy was on 61% lower than the control.     

Effect of gamma irradiation on human cortical bone transplants contaminated with enveloped and non-enveloped viruses.

In the production of bone grafts intended for transplantation, basic safety measures to avoid the transmission of pathogens are selection and serological screening of donors for markers of virus infections. As an additional safety tool we investigated the effect of gamma irradiation on the sterility of human bone diaphysis transplants and evaluated its impact on the virus safety of transplants. Model viruses were included in the study to determine the dose necessary to achieve a reduction factor for the infectivity titres of at least 4 log(10) at a temperature of -30+/-5 degrees C. The following viruses were used: human immunodeficiency virus type 2 (HIV-2), hepatitis A virus (HAV), and poliovirus (PV-1), and the following model viruses: pseudorabies virus (PRV) as a model for human herpesviruses, bovine viral diarrhoea virus (BVDV) for HCV, and bovine parvovirus (BPV) for parvovirus B19. A first approach was to determine the D(10) values (kGy) for the different viruses (virus inactivation kinetics: BPV 7.3; PV-1 7.1; HIV-2 7.1; HAV 5.3; PRV 5.3; BVDV <3.0 kGy). Based on these results, inactivation of these viruses was studied in experimentally contaminated human bone transplants (femoral diaphyses). For BPV, the most resistant one of the viruses studied, a dose of approximately 34 kGy was necessary to achieve a reduction of infectivity titres of 4 log(10). We therefore recommend a dose of 34 kGy for the sterilisation of frozen bone transplants.     

Ionizing-radiation resistance in the desiccation-tolerant cyanobacterium Chroococcidiopsis

The effect of X-ray irradiation on cell survival, induction, and repair of DNA damage was studied by using 10 Chroococcidiopsis strains isolated from desert and hypersaline environments. After exposure to 2.5 kGy, the percentages of survival for the strains ranged from 80 to 35%. In the four most resistant strains, the levels of survival were reduced by 1 or 2 orders of magnitude after irradiation with 5 kGy; viable cells were recovered after exposure to 15 kGy but not after exposure to 20 kGy. The severe DNA damage evident after exposure to 2.5 kGy was repaired within 3 h, and the severe DNA damage evident after exposure to 5 kGy was repaired within 24 h. The increase in trichloroacetic acid-precipitable radioactivity in the culture supernatant after irradiation with 2.5 kGy might have been due to cell lysis and/or an excision process involved in DNA repair. The radiation resistance of Chroococcidiopsis strains may reflect the ability of these cyanobacteria to survive prolonged desiccation through efficient repair of the DNA damage that accumulates during dehydration.     

Effect of gamma irradiated hyaluronic acid on acetaminophen induced acute hepatotoxicity

The hepatoprotective efficacy of irradiated hyaluronic acid (HA) on acetaminophen (APAP) induced acute hepatotoxicity was investigated. BALB/c mice (4-6 weeks of age) were pretreated with unirradiated HA (UIHA), 5 and 50 kGy gamma irradiated HA (GIHA) for 14 days and were dosed APAP (500 mg/kg b.wt). After 9h of APAP dosing animals were euthanized. The degree of acute hepatotoxicity was measured by aspartate aminotransferase (AST) and alanine aminotransferase (ALT). The expression of interferon-gamma (IFN-gamma) in serum and alpha-and mu-class of gluthathione-S-transferase (GSTs), CYP 2E1 class of cytochrome monooxygenase and glutathione (GSH) in liver were quantified. Histological evaluation was done by Hematoxiylin and Eiosin staining, Periodic acid schiffs staining, Manson trichrome staining and histological scorings were done. The degree of acute hepatotoxicity was markedly lower in UIHA and 5 kGy than in 50 kGy GIHA pretreated group and there was negligible difference between 5 and 50 kGy GIHA pretreated group. The expression of interferon-gamma (IFN-gamma) was significantly (P<0.05) suppressed in 5 and 50 kGy GIHA pretreated group. Histological scorings showed a significant protection of liver in UIHA and 5 kGy GIHA pretreated mice. Expression of alpha class GSTs was significantly increased in 5 and 50 kGy GIHA pretreated group. To conclude suppression of IFN-gamma and increase in alpha-class GSTs expression may exert a protective role in acute hepatotoxicity of APAP and 5 kGy GIHA showed comparable protective effect to that of UIHA.     

Ionizing-Radiation Resistance in the Desiccation-Tolerant Cyanobacterium Chroococcidiopsis

The effect of X-ray irradiation on cell survival, induction, and repair of DNA damage was studied by using 10 Chroococcidiopsis strains isolated from desert and hypersaline environments. After exposure to 2.5 kGy, the percentages of survival for the strains ranged from 80 to 35%. In the four most resistant strains, the levels of survival were reduced by 1 or 2 orders of magnitude after irradiation with 5 kGy; viable cells were recovered after exposure to 15 kGy but not after exposure to 20 kGy. The severe DNA damage evident after exposure to 2.5 kGy was repaired within 3 h, and the severe DNA damage evident after exposure to 5 kGy was repaired within 24 h. The increase in trichloroacetic acid-precipitable radioactivity in the culture supernatant after irradiation with 2.5 kGy might have been due to cell lysis and/or an excision process involved in DNA repair. The radiation resistance of Chroococcidiopsis strains may reflect the ability of these cyanobacteria to survive prolonged desiccation through efficient repair of the DNA damage that accumulates during dehydration.     

Destruction of Bacillus anthracis strain Sterne 34F2 spores in postal envelopes by exposure to electron beam irradiation

AIMS: To determine the irradiation dose necessary to reduce the populations of Bacillus anthracis spores in a dry medium in postal envelopes. METHODS AND RESULTS: Bacillus anthracis Sterne 34F2 spores were dispersed in non-fat dry milk and then placed into standard business postal envelopes. The spores were treated with a sequence of irradiation doses to determine the decimal reduction value (D10) in kiloGrays (kGy). The average D10 value was 3.35 +/- 0.02 kGy. CONCLUSIONS: An irradiation dose of 40.2 kGy would be required to result in a process equivalent to the thermal canning process (12 D10 reduction) to eliminate Clostridium botulinum spores. SIGNIFICANCE AND IMPACT OF THE STUDY: Irradiation is an effective means of reducing or eliminating B. anthracis spores in a dry medium in postal envelopes.