Utilization of methanol by a catalase-negative mutant of Hansenula polymorpha

Summary In methanol-utilizing yeasts, catalase is an essential enzyme for the destruction of hydrogen peroxide generated by methanol oxidase (E.C. 1.1.3.13). It was found however that a catalase-negative mutant of Hansenula polymorpha is able to consume methanol in the presence of glucose in continuous cultures. At a dilution rate of 0.1 h^-1, stable continuous cultures could be obtained during growth on methanol/glucose mixtures with a molar ratio of methanol/glucose between 0 to 2.4. In these cultures methanol oxidase was induced up to a level of 40% of that obtained in the wild-type strain. The hydrogen peroxide-decomposition activity of the mutant was studied in more detail by pulsing methanol to samples of steady-state cultures. Only after the addition of excess methanol the hydrogen peroxide-decomposing system became saturated, and the cells excreted hydrogen peroxide. This was accompanied by excretion of formaldehyde and a rapid loss of viability. The presence of extracellular catalase during a methanol pulse prevented the loss of viability. The nature of the alternative hydrogen peroxide-decomposing enzyme system remains to be elucidated. Its capacity strongly depended on the cultivation conditions and pretreatment of the cells. Cells grown on formaldehyde/glucose mixtures showed a lower methanol tolerance than those grown on the methanol/glucose mixtures. Freeze-drying of cells drastically enhanced the excretion of hydrogen peroxide, probably as a result of an inactivation of the decomposing system.     

Methanol dissimilation in Xanthobacter H4-14: activities, induction and comparison to Pseudomonas AM1 and Paracoccus denitrificans

Methanol dissimilatory enzymes detected in the methanol autotroph Xanthobacter H4-14 were a typical phenazine methosulphate-linked methanol dehydrogenase, a NAD+-linked formate dehydrogenase, and a dye-linked formaldehyde dehydrogenase that could be assayed only by activity stains of polyacrylamide gels. This same methanol dehydrogenase activity was found in ethanol-grown cells and was apparently utilized for ethanol oxidation. Formaldehyde dehydrogenase activities were investigated in Paracoccus denitrificans, Xanthobacter H4-14, and Pseudomonas AM1. P. denitrificans contained a previously reported NAD+-linked, GSH-dependent activity, but both Xanthobacter H4-14 and Pseudomonas AM1 contained numerous activities detected by activity stains of polyacrylamide gels. Induction studies showed that in Xanthobacter H4-14, a 10 kDal polypeptide, probably a dehydrogenase-associated cytochrome c, was co-induced with methanol dehydrogenase, but the formaldehyde and formate dehydrogenases were not co-regulated. Analogous induction experiments revealed similar patterns in P. denitrificans, but no evidence for co-regulation of dissimilatory activities in Pseudomonas AM1.     

Oxidation of C1-compounds in Pseudomonas C.

Extracts of Pseudomonas C grown on methanol as a sole carbon and energy source contain a methanol dehydrogenase activity which can be coupled to phenazine methosulfate. This enzyme catalyzes two reactions namely the conversion of methanol to formaldehyde (phenazine methosulfate coupled) and the oxidation of formaldehyde to formate (2,6-dichloroindophenol-coupled). Activities of glutathione-dependent formaldehyde dehydrogenase (NAD+) and formate dehydrogenase (NAD+) were also detected in the extracts. The addition of D-ribulose 5-phosphate to the reaction mixtures caused a marked increase in the formaldehyde-dependent reduction of NAD+ or NADP+. In addition, the oxidation of [14C]formaldehyde to CO2, by extracts of Pseudomonas C, increased when D-ribulose 5-phosphate was present in the assay mixtures. The amount of radioactivity found in CO2, was 6;8-times higher when extracts of methanol-grown Pseudomonas C were incubated for a short period of time with [1-14C]glucose 6-phosphate than with [U-14C]glucose 6-phosphate. These data, and the presence of high specific activities of hexulose phosphate synthase, phosphoglucoisomerase, glucose-6-phosphate dehydrogenase and 6-phosphogluconate dehydrogenase indicate that in methanol-grown Pseudomonas C, formaldehyde carbon is oxidized to CO2 both via a cyclic pathway which includes the enzymes mentioned and via formate as an oxidation intermediate, with the former predominant.     

Methanol metabolism in yeasts: Regulation of the synthesis of catabolic enzymes

The regulation of the synthesis of four dissimilatory enzymes involved in methanol metabolism, namely alcohol oxidase, formaldehyde dehydrogenase, formate dehydrogenase and catalase was investigated in the yeasts Hansenula polymorpha and Kloeckera sp. 2201. Enzyme profiles in cell-free extracts of the two organisms grown under glucose limitation at various dilution rates, suggested that the synthesis of these enzymes is controlled by derepression — represion rather than by induction — repression. Except for alcohol oxidase, the extent to which catabolite repression of the catabolic enzymes was relieved at low dilution rates was similar in both organisms. In Hansenula polymorpha the level of alcohol oxidase in the cells gradually increased with decreasing dilution rate, whilst in Kloeckera sp. 2201 derepression of alcohol oxidase synthesis was only observed at dilution rates below 0.10 h^–1 and occurred to a much smaller extent than in Hansenula polymorpha.Derepression of alcohol oxidase and catalase in cells of Hansenula polymorpha was accompanied by synthesis of peroxisomes. Moreover, peroxisomes were degraded with a concurrent loss of alcohol oxidase and catalase activities when excess glucose was introduced into the culture. This process of catabolite inactivation of peroxisomal enzymes did not affect cytoplasmic formaldehyde dehydrogenase.     

Derepression and partial insensitivity to carbon catabolite repression of the methanol dissimilating enzymes inHansenula polymorpha

Summary The regulation of the synthesis of alcohol oxidase, catalase, formaldehyde dehydrogenase, and formate dehydrogenase was investigated in the methanol-utilizing yeastHansenula polymorpha during growth on different carbon and energy sources. When cells were grown on glucose, the enzymes of the dissimilatory methanol metabolism were not detected during the exponential phase of growth, but were formed in the late stationary phase without addition of methanol. Moreover, the enzymes were synthesized during growth on sorbitol, glycerol, ribose, and xylose. It was shown that the carbon catabolite insensitivity of the synthesis of methanol-specific enzymes is not limited to substrates that are slowly metabolized.     

Steady-state kinetics of formaldehyde dehydrogenase and formate dehydrogenase from a methanol-utilizing yeast, Candida boidinii.

Initial velocity studies and product inhibition studies were conducted for the forward and reverse reactions of formaldehyde dehydrogenase (formaldehyde: NAD oxidoreductase, EC 1.2.1.1) isolated from a methanol-utilizing yeast Candida boidinii. The data were consistent with an ordered Bi-Bi mechanism for this reaction in which NAD+ is bound first to the enzyme and NADH released last. Kinetic studies indicated that the nucleoside phosphates ATP, ADP and AMP are competitive inhibitors with respect to NAD and noncompetitive inhibitors with respect to S-hydroxymethylglutathione. The inhibitions of the enzyme activity by ATP and ADP are greater at pH 6.0 and 6.5 than at neutral or alkaline pH values. The kinetic studies of formate dehydrogenase (formate:NAD oxidoreductase, EC 1.2.1.2) from the methanol grown C. boidinii suggested also an ordered Bi-Bi mechanism with NAD being the first substrate and NADH the last product. Formate dehydrogenase the last enzyme of the dissimilatory pathway of the methanol metabolism is also inhibited by adenosine phosphates. Since the intracellular concentrations of NADH and ATP are in the range of the Ki values for formaldehyde dehydrogenase and formate dehydrogenase the activities of these main enzymes of the dissimilatory pathway of methanol metabolism in this yeast may be regulated by these compounds.     

Oxidation of C1-compounds in Pseudomonas C

Extracts of Pseudomonas C grown on methanol as sole carbon and energy source contain a methanol dehydrogenase activity which can be coupled to phenazine methosulfate. This enzyme catalyzes two reactions namely the conversion of methanol to formaldehyde (phenazine methosulfate coupled) and the oxidation of formaldehyde to formate (2,6-dichloroindophenol-coupled). Activities of glutathione-dependent formaldehyde dehydrogenase (NAD⁺) and formate dehydrogenase (NAD⁺) were also detected in the extracts.The addition of d-ribulose 5-phosphate to the reaction mixtures caused a marked increase in the formaldehyde-dependent reduction of NAD⁺ or NADP⁺. In addition, the oxidation of [¹⁴C]formaldehyde to CO₂, by extracts of Pseudomonas C, increased when d-ribulose 5-phosphate was present in the assay mixtures.The amount of radioactivity found in CO₂, was 6.8-times higher when extracts of methanol-grown Pseudomona C were incubated for a short period of time with [1-¹⁴C]glucose 6-phosphate than with [U-¹⁴C]glucose 6-phosphate.These data, and the presence of high specific activities of hexulose phosphate synthase, phosphoglucoisomerase, glucose-6-phosphate dehydrogenase and 6-phosphogluconate dehydrogenase indicate that in methanol-grown Pseudomonas C, formaldehyde carbon is oxidized to CO₂ both via a cyclic pathway which includes the enzymes mentioned and via formate as an oxidation intermediate, with the former predominant.     

Regulation of alcohol oxidase synthesis in Hansenula polymorpha: Oversynthesis during growth on mixed substrates and induction by methanol

The regulation of the synthesis of alcohol oxidase, catalase, formaldehyde dehydrogenase and formate dehydrogenase was investigated in the methanol-utilizing yeast Hansenula polymorpha. The organism was found to synthesize immunologically identical alcohol oxidases during growth on glycerol and methanol. Growth on glycerol, however, was not dependent on the alcohol oxidase, as was shown with a mutant without alcohol oxidase protein. Similarly it was shown with a catalase activity negative mutant that high catalase activity during growth on glycerol was not a prerequisite for the utilization of this substrate, though absolutely required for growth on methanol.Experiments were conducted with mixed substrates to study the influence of methanol on alcohol oxidase synthesis. In batch cultures, growth on ribose plus methanol resulted in an enhanced rate of alcohol oxidase synthesis as compared to ribose alone. In continuous cultures, (D=0.1 h^-1) addition of methanol to glycerol-, glucose-, or sorbose-limited cultures gave rise to increased alcohol oxidase activity of up to 20 U/mg, which is about by 2 times higher than the specific activity used for growth on methanol alone. The increase in specific activity of the dissimilatory enzymes on the mixed substrates is partly due to methanol per se, as was shown by a mutant unable to dissimilate or assimilate methanol.     

Oxidative and assimilative enzyme activities in continuous cultures of the obligate methylotrophMethylobacillus flagellatum

In methanol-limited continuous cultures of the obligate methylotrophic bacteriumMethylobacillus flagellatum grown at rates from 0.05 to 0.63 h^-1, and also in an oxyturbidostat culture ofM. flagellatum growing at the rate of 0.73 h^-1, levels of methanol dehydrogenase, enzymes of formaldehyde oxidation (both linear and cyclic) and assimilation (RuMP cycle), a number of intermediary metabolism and TCA cycle enzymes and also dye-linked formaldehyde dehydrogenase were determined. It was shown that the activities of dissimilatory enzymes, with the exception of dye-linked formaldehyde dehydrogenase, decreased with increasing growth rate. Activities of assimilative enzymes and activities of the TCA cycle enzymes detected as well as the dye-linked formaldehyde dehydrogenase activity, increased with increasing growth rate. A periplasmic location was shown for the latter enzyme and a role in formaldehyde detoxification was proposed.     

Dimethylsulfone as a growth substrate for novel methylotrophic species of Hyphomicrobium and Arthrobacter

Dimethylsulfone is a major product of the chemical oxidation in the atmosphere of the principal biogenic sulfur gas, dimethylsulfide, but no studies have been reported on the mechanisms for its microbiological degradation. Three novel strains of bacteria have been isolated from enrichment cultures provided with dimethylsulfone as the only carbon and energy substrate. These are novel facultatively methylotrophic species of Hyphonmicrobium and Arthobacter, capable of growth on a range of one-carbon substrates. Cell-free extracts contained activities of enzymes necessary for a reductive/oxidative pathway for dimethylsulfone degradation: membrane-bound-dimethylsulfone and dimethylsulfoxide reductases, dimethylsulfide monooxygenase, and methanethiol oxidase. Enzymatic evidence is also presented for the subsequent oxidation of formaldehyde by formaldehyde and formate dehydrogenases in the Hyphomicrobium strain and by a dissimilatory ribulose monophosphate cycle in the Arthrobacter strains. The strains also grew on dimethylsulfoxide and dimethylsulfide, and dimethylsulfide-grown bacteria oxidized dimethylsulfide and dimethylsulfoxide but not dimethylsulfone. Formaldehyde assimilation was effected in the Hyphomicrobium strain by the serine pathway, but enzymes of the ribulose monophosphate cycle for formaldehyde assimilation were present in the Arthrobacter strains grown on dimethylsulfone. In contrast, one of the Arthrobacter strains was shown to switch to the serine pathway during growth on methanol. Growth yields on dimethylsulfone and formaldehyde were consistent with the occurrence of the serine pathway in Hyphomicrobium strain S1 and the ribulose monophosphate cycle in Arthrobacter strain TGA, and with the proposed reductive pathway for dimethylsulfone degradation in both.     

Effect of growth conditions on enzyme activities,intracellular kinetics and biomass yields of a new RuMP-type methylotroph (T15)

Summary A new methylotrophic strain (T15), which employs the ribulose monophosphate (RuMP) cycle of formaldehyde assimilation, was isolated on the basis of high in vitro activities of formaldehyde and formate dehydrogenases (19 and 678 mU per mg protein, respectively). Serial subculturing of the strain in batch cultures, on 4 g/l CH₃OH for 6 months, led to loss of substantial percentages of the NAD-linked formaldehyde (25%) and formate (98%) dehydrogenases. The activities of these two enzymes were partially recovered when cells were grown continuously at very low dilution rate (0.03 h^–1). We found large variations (40 to 1000%) in the activities of other key enzymes of carbon-substrate oxidation (both linear and cyclic) and assimilation, in batch cultures with pure and mixed substrates, and in continuous cultures of different dilution rates. Key intracellular reaction rates, including those of the cyclic and linear substrate oxidation, were measured in vivo using a ¹⁴C-tracer technique in both continuous and batch cultures. The results indicate significant variations in these reaction rates, particularly those of linear and cyclic carbon oxidation. Overall, the cyclic oxidation appears to be employed to a larger (although not predominant) extent in strain T15 compared with another RuMP strain (L3) we have previously examined. T15 exhibits high biomass yields (up to 0.63 g cells per g CH₃OH) and growth rates (up to 0.46 h^–1) on CH₃OH in batch cultures. CH₃NH₂ can also be utilized as a substrate. In continuous culture, T15 could be grown at dilution rates up to 0.36 h^–1 with a corresponding biomass yield of 0.4. Examination of a large number of data on the biomass yields of strains T15 and L3 reveals that the large variations in yields derive from the variable branching of carbon flow between linear and cyclic oxidation and assimilation, rather than changes in the biosynthetic efficiency of carbon incorporation into biomass.     

Effect of formaldehyde on growth of obligate methylotroph Methylobacillus flagellatum in a substrate non-limited continuous culture

The ribulose monophosphate cycle methylotroph Methylobacillus flagellatum was grown under oxyturbidostat conditions on mixtures of methanol and formaldehyde. Formaldehyde when added at low concentration (50 mg/l) increased the methanol consumption and the yield of biomass. The presence of 150–300 mg/l of formaldehyde resulted in an increase of the growth rate from 0.74 to about 0.79–0.82 h^-1. The presence of 500 mg/l of formaldehyde in the inflow decreased culture growth characteristics. Activities of methanol dehydrogenase and enzymes participating in formaldehyde oxidation and assimilation were measured. The enzymological profiles obtained are discussed.Abbreviations MDH methanol dehydrogenase - NAD-linked FDDH NAD-linked formaldehyde dehydrogenase - DLFDDH dye-linked formaldehyde dehydrogenase - DLFDH dye-linked formate dehydrogenase - GPDH glucose-6-phosphate dehydrogenase - PGDH 6-phosphogluconate dehydrogenase - RuMP cycle ribulose monophosphate cycle     

Physiological characterisation of a pyruvate-carboxylase-negative Saccharomyces cerevisiae mutant in batch and chemostat cultures

A prototrophic pyruvate-carboxylase-negative (Pyc-) mutant was constructed by deleting the PYC1 and PYC2 genes in a CEN.PK strain of Saccharomyces cerevisiae. Its maximum specific growth rate on ethanol was identical to that of the isogenic wild type but it was unable to grow in batch cultures in glucose-ammonia media. Consistent with earlier reports, growth on glucose could be restored by supplying aspartate as a sole nitrogen source. Ethanol could not replace aspartate as a source of oxaloacetate in batch cultures. To investigate whether alleviation of glucose repression allowed expression of alternative pathways for oxaloacetate synthesis, the Pyc- strain and an isogenic wild-type strain were grown in aerobic carbon-limited chemostat cultures at a dilution rate of 0.10 h-1 on mixtures of glucose and ethanol. In such mixed-substrate chemostat cultures of the Pyc- strain, steady-state growth could only be obtained when ethanol contributed 30% or more of the substrate carbon in the feed. Attempts to further decrease the ethanol content of the feed invariably resulted in washout. In Pyc- as well as in wild-type cultures, levels of isocitrate lyase, malate synthase and phospho-enol-pyruvate carboxykinase in cell extracts decreased with a decreasing ethanol content in the feed. Nevertheless, at the lowest ethanol fraction that supported growth of the Pyc- mutant, activities of the glyoxylate cycle enzymes in cell extracts were still sufficient to meet the requirement for C4-compounds in biomass synthesis. This suggests that factors other than glucose repression of alternative routes for oxaloacetate synthesis prevent growth of Pyc-mutants on glucose.     

Physiological responses of a methylotrophic bacterium after sudden shifts from C-limited chemostat to C-excess batch growth conditions

The response of steady-state continuous cultures of Methylobacterium sp. RXM to the addition of methanol pulses was studied. The increase of methanol concentration in the medium did not result in cell death under any of the conditions tested. When the growth rate of the steady-state cultures was low ( D = 0.046 h⁻¹), the specific growth rate increased. When the concentration of methanol in the pulse was increased from 36 mmol l⁻¹ to 280 mmol l⁻¹, uncoupled growth occurred and the molar cell yield decreased. Conversely, steady-state cultures at high growth rate ( D = 0.2 h⁻¹) showed a decrease in both specific growth rate and molar cell yield after the addition of the methanol pulses (32 and 164 mmol 1⁻¹). For all conditions, formaldehyde and formate were excreted into the medium but the levels did not exceed 1.13 mmol 1⁻¹ Slow-growing cultures were characterized by cells with high derepressed specific activities of methanol dehydrogenase and low specific activities of formaldehyde and formate dehydrogenases, fast-growing cells had lower specific activity for methanol dehydrogenase and higher activities of formaldehyde and formate dehydrogenases, resulting in the excretion of lower concentrations of formaldehyde and formate.
It is concluded that slow-growing cultures are more stable than fast-growing cultures for low methanol concentration fluctuations, and it is expected that maximum growth yields throughout the fermentation time are better achieved under the former conditions. However, for large fluctuations in the substrate concentration, the bacterial metabolic responses were identical both for slow-growing and fast-growing cultures.     

Energetics of mixotrophic and autotrophic C1-metabolism by Thiobacillus acidophilus

Although the facultatively autotrophic acidophile Thiobacillus acidophilus is unable to grow on formate and formaldehyde in batch cultures, cells from glucose-limited chemostat cultures exhibited substrate-dependent oxygen uptake with these C₁-compounds. Oxidation of formate and formaldehyde was uncoupler-sensitive, suggesting that active transport was involved in the metabolism of these compounds. Formate- and formaldehyde-dependent oxygen uptake was strongly inhibited at substrate concentrations above 150 and 400 M, respectively. However, autotrophic formate-limited chemostat cultures were obtained by carefully increasing the formate to glucose ratio in the reservoir medium of mixotrophic chemostat cultures. The molar growth yield on formate (Y=2.5 g ·mol^-1 at a dilution rate of 0.05 h^-1) and RuBPCase activities in cell-free extracts suggested that T. acidophilus employs the Calvin cycle for carbon assimilation during growth on formate. T. acidophilus was unable to utilize the C₁-compounds methanol and methylamine. Formate-dependent oxygen uptake was expressed constitutively under a variety of growth conditions. Cell-free extracts contained both dye-linked and NAD-dependent formate dehydrogenase activities. NAD-dependent oxidation of formaldehyde required reduced glutathione. In addition, cell-free extracts contained a dye-linked formaldehyde dehydrogenase activity. Mixotrophic growth yields were higher than the sum of the heterotrophic and autotrophic yields. A quantitative analysis of the mixotrophic growth studies revealed that formaldehyde was a more effective energy source than formate.     

Methanol and ethanol utilization in methylotrophic yeast Pichia pinus wild-type and mutant strains

In the wild-type strain of methylotrophic yeast Pichia pinus diauxic growth is observed during cultivation in medium containing a mixture of methanol and ethanol: firstly, slow phase of ethanol utilization is revealed and, secondly, a fast phase of methanol consumption is shown. Diauxic growth is observed also in ecr1 mutant, impaired in ethanol-induced catabolite repression of methylotrophic metabolism enzymes, but the order of utilization of the alcohols is inverted in this mutant. Such succession of alcohols utilization in both strains correlates well with the sequence of synthesis of microbody enzymes which catalyze key reactions of C₁- and C₂-metabolism. On the contrary, simultaneous utilization of methanol and ethanol from the mixture, as well as synchronous synthesis of both peroxisomal and glyoxisomal enzymes is observed in adh1 mutant which has reduced alcohol dehydrogenase activity. The strong differences between the wild-type strain and adh1 mutant were observed also in the kinetics of specific activity changes for C₁-metabolizing enzymes, localized in cytosol. In the wild-type strain during growth on methanol and ethanol mixture such changes correlate with the sequence of alcohol utilization. At the same time, in adh1 mutant the activities of formaldehyde dehydrogenase and formate dehydrogenase during the growth on the alcohols mixture are as high as during growth on methanol only, but the activity of dihydroxyacetone kinase is as low as under the growth on ethanol and is lower than on methanol.     

Pathways leading to and from serine during growth of Pseudomonas AM1 in C1 compounds or succinate

1. The following enzymes of the phosphorylated pathway of serine biosynthesis have been found in methanol- and succinate-grown Pseudomonas AM1: phosphoglycerate dehydrogenase, phosphoserine-alpha-oxoglutarate aminotransferase and phosphoserine phosphohydrolase. Their specific activities were similar in the organism grown on either substrate. 2. A procedure for preparation of auxotrophic mutants of Pseudomonas AM1 is described involving N-methyl-N'-nitro-N-nitrosoguanidine as mutagen and a penicillin enrichment step. 3. A mutant, M-15A, has been isolated that is unable to grow on methanol and that lacks phenazine methosulphate-linked methanol dehydrogenase. The mutant is able to grow on methylamine, showing that the amine is not oxidized by way of methanol. 4. Loss of methanol dehydrogenase activity in mutant M-15A led to loss of phenazine methosulphate-linked formaldehyde dehydrogenase activity showing that the same enzyme is probably responsible for both activities. 5. A mutant, 20B-L, has been isolated that cannot grow on any C(1) compound tested but can grow on succinate. 6. Mutant 20B-L lacks hydroxypyruvate reductase, and revertants that regained the ability to grow on methanol, methylamine and formate contained hydroxypyruvate reductase activity at specific activities similar to that of the wild-type organism. This shows that hydroxypyruvate reductase is necessary for growth on methanol, methylamine and formate but not for growth on succinate. 7. The results suggest that during growth of Pseudomonas AM1 on C(1) compounds, serine is converted into 3-phosphoglycerate by a non-phosphorylated pathway, whereas during growth on succinate, phosphoglycerate is converted into serine by a phosphorylated pathway.     

甲醇/山梨醇共混流加诱导改变毕赤酵母生产猪α干扰素过程的代谢产能途径强化发酵性能

旨在探讨毕赤酵母生产猪α干扰素过程的代谢产能规律及其对发酵性能的影响。在10 L罐下,开展了不同诱导条件下的毕赤酵母高效发酵生产猪α干扰素过程的代谢酶学和能量再生分析研究。结果表明:甲醇单独诱导条件下、将诱导温度从30℃降低到20℃,胞内醇氧化酶(AOX)、甲醛脱氢酶(FLD)和甲酸脱氢酶(FDH)的比活性增加显著,细胞的甲醇代谢和甲醛异化产能能力、猪α干扰素抗病毒活性大幅提高,最高抗病毒活性达到1.4×106IU/mL,约为30℃诱导条件下的10倍。30℃、甲醇/山梨醇共混流加下,主要供能途径由甲醇单独诱导时的甲醛异化代谢转向TCA循环,甲醛异化供能途径被弱化、毒副产物甲醛的生成积累得到抑制,走向目标蛋白合成途径的甲醇分配比例得到提高。此时,最高抗病毒活性达到1.8×107IU/mL,是30℃甲醇单独诱导下最高活性的100倍以上。更加重要的是,共混流加诱导可以在常温、使用空气供氧的条件下进行,发酵成本明显下降、整体发酵性能改善显著。     

Effects of elemental sulfur on the metabolism of the deep-sea hyperthermophilic archaeon Thermococcus strain ES-1: characterization of a sulfur-regulated, non-heme iron alcohol dehydrogenase.

The strictly anaerobic archaeon Thermococcus strain ES-1 was recently isolated from near a deep-sea hydrothermal vent. It grows at temperatures up to 91 degrees C by the fermentation of peptides and reduces elemental sulfur (S(o)) to H2S. It is shown here that the growth rates and cell yields of strain ES-1 are dependent upon the concentration of S(o) in the medium, and no growth was observed in the absence of S(o). The activities of various catabolic enzymes in cells grown under conditions of sufficient and limiting S(o) concentrations were investigated. These enzymes included alcohol dehydrogenase (ADH); formate benzyl viologen oxidoreductase; hydrogenase; glutamate dehydrogenase; alanine dehydrogenase; aldehyde ferredoxin (Fd) oxidoreductase; formaldehyde Fd oxidoreductase; and coenzyme A-dependent, Fd-linked oxidoreductases specific for pyruvate, indolepyruvate, 2-ketoglutarate, and 2-ketoisovalerate. Of these, changes were observed only with ADH, formate benzyl viologen oxidoreductase, and hydrogenase, the specific activities of which all dramatically increased in cells grown under S(o) limitation. This was accompanied by increased amounts of H2 and alcohol (ethanol and butanol) from cultures grown with limiting S(o). Such cells were used to purify ADH to electrophoretic homogeneity. ADH is a homotetramer with a subunit M(r) of 46,000 and contains 1 g-atom of Fe per subunit, which, as determined by electron paramagnetic resonance analyses, is present as a mixture of ferrous and ferric forms. No other metals or acid-labile sulfide was detected by colorimetric and elemental analyses. ADH utilized NADP(H) as a cofactor and preferentially catalyzed aldehyde reduction. It is proposed that, under So limitation, ADH reduces to alcohols the aldehydes that are generated by fermentation, thereby serving to dispose of excess reductant.