高糖和氮源对鼠李糖乳杆菌(Lactobacillus rhamnosus)L-乳酸发酵的影响

鼠李糖乳杆菌经实验室耐高糖高酸选育,能够在高糖浓度下高效高产L-乳酸。以酵母粉为氮源和生长因子,葡萄糖初始浓度分别为120 g/L和146 g/L,摇瓶培养120h,L-乳酸产量分别为104g/L和117.5g/L,L-乳酸得率分别为86.7%和80.5%。高葡萄糖浓度对菌的生长和乳酸发酵有一定的抑制。增加接种量,在高糖浓度发酵条件下,可以缩短发酵时间,但对增加乳酸产量效果不明显。乳酸浓度对鼠李糖乳杆菌生长和产酸有显著的影响。初始乳酸浓度到达70g/L以上时,鼠李糖乳杆菌基本不生长和产酸,葡萄糖消耗也被抑制。酵母粉是鼠李糖乳杆菌的优良氮源,使用其它被测试的氮源菌体生长和产酸都有一定程度的下降。用廉价的黄豆粉并补充微量维生素液,替代培养基中的酵母粉,可以使产酸浓度和碳源得率得以基本维持。     

丙酮酸对细菌L-乳酸发酵的促进作用

研究了丙酮酸在不同浓度和添加时间对LactobacilluscaseiL 乳酸发酵过程中葡萄糖转化率和L 乳酸产量的影响。结果表明 ,当丙酮酸的添加量为 30g·L- 1 时 ,L 乳酸的产量达到 74g·L- 1 。在 72h的发酵周期内 ,丙酮酸在 2 4h和 42h添加的效果好于其他时间添加。     

Growth and end product formation of two psychrotrophic Lactobacillus spp. and Brochothrix thermosphacta ATCC 11509T at different pH values and temperatures

Lactobacillus viridescens, Lactobacillus sp. strain 173 (homofermentative), and Brochothrix thermosphacta ATCC 11509T were studied at different pH values and temperatures in aerobic and anaerobic batch cultures. The growth rates were higher in aerobic than in anaerobic cultures. L. viridescens grew faster at pH 5.8 than at pH 6.3, whereas the opposite was true for B. thermosphacta. Lactobacillus sp. strain 173 was inhibited in air or at 8 degrees C in anaerobic culture. B. thermosphacta did not grow in anaerobic culture at pH 5.3. The following variations in growth yields were found in the different environments studied: Lactobacillus sp. strain 173, 23 to 25 g (dry weight) per mol of glucose consumed; L. viridescens, 11 to 23 g/mol; B. thermosphacta, 16 to 38 g/mol. In air, L. viridescens produced D-lactic acid, ethanol, and acetic acid, whereas no acetic acid was produced anaerobically. Acetic acid and ethanol together constituted 41 to 48% of the total product yield irrespective of pH and temperature. Lactobacillus sp. strain 173 produced a racemic mixture of D- and L-lactic acid at pH 6.3, whereas the proportion of L-lactic acid was higher than that of D-lactic acid at pH 5.3. In air, product formation of B. thermosphacta varied from a domination of L-lactic acid to increasing yields of acetoin, acetic acid, 2,3-butanediol and isovaleric acid. The effect of pH and temperature on product formation was difficult to separate from the effect of O2 availability in aerobic cultures. However, it was indicated that more 2,3-butanediol and less acetoin were produced with a decreasing temperature.(ABSTRACT TRUNCATED AT 250 WORDS)     

L-lactic acid production by Lactobacillus casei fermentation with corn steep liquor-supplemented acid-hydrolysate of soybean meal

Batch and fed-batch fermentation studies were performed to evaluate the potential of corn steep liquor (CSL)-supplemented acid-hydrolysate of soybean meal (AHSM) as an alternative to yeast extract (YE) for the production of L-lactic acid by Lactobacillus casei LA-04-1. The CSL-supplemented AHSM gave an outstanding result in supporting L-lactic acid production from glucose. In the exponential fed-batch fermentation, the concentration, yield and productivity of L-lactic acid were 162.5 g/L, 89.7% and 1.69 g/L per h, respectively, which were lower than those with 20 g/L YE (180 g/L, 90.3%, 2.14 g/L per h) after 96 h of fermentation. However, the raw material cost of the nitrogen resource was estimated as only 25% of that using the YE.     

Growth and end product formation of two psychrotrophic Lactobacillus spp. and Brochothrix thermosphacta ATCC 11509T at different pH values and temperatures.

Lactobacillus viridescens, Lactobacillus sp. strain 173 (homofermentative), and Brochothrix thermosphacta ATCC 11509T were studied at different pH values and temperatures in aerobic and anaerobic batch cultures. The growth rates were higher in aerobic than in anaerobic cultures. L. viridescens grew faster at pH 5.8 than at pH 6.3, whereas the opposite was true for B. thermosphacta. Lactobacillus sp. strain 173 was inhibited in air or at 8 degrees C in anaerobic culture. B. thermosphacta did not grow in anaerobic culture at pH 5.3. The following variations in growth yields were found in the different environments studied: Lactobacillus sp. strain 173, 23 to 25 g (dry weight) per mol of glucose consumed; L. viridescens, 11 to 23 g/mol; B. thermosphacta, 16 to 38 g/mol. In air, L. viridescens produced D-lactic acid, ethanol, and acetic acid, whereas no acetic acid was produced anaerobically. Acetic acid and ethanol together constituted 41 to 48% of the total product yield irrespective of pH and temperature. Lactobacillus sp. strain 173 produced a racemic mixture of D- and L-lactic acid at pH 6.3, whereas the proportion of L-lactic acid was higher than that of D-lactic acid at pH 5.3. In air, product formation of B. thermosphacta varied from a domination of L-lactic acid to increasing yields of acetoin, acetic acid, 2,3-butanediol and isovaleric acid. The effect of pH and temperature on product formation was difficult to separate from the effect of O2 availability in aerobic cultures. However, it was indicated that more 2,3-butanediol and less acetoin were produced with a decreasing temperature.(ABSTRACT TRUNCATED AT 250 WORDS)     

Study of the micro-organisms associated with the fermented bread (khamir) produced from sorghum in Gizan region, Saudi Arabia

Traditional bread (khamir) was made from sorghum flour of two local varieties, Bayadh and Hamra. The bread was prepared by mixing the sorghum flour with water and spices (onion, garlic, lemon juice and fenugreek) in a 1:0.8 (w/w) ratio and fermented for 24 h at 30 degrees C. Two other fermentations were carried out using an inoculum from the previous fermentation. The micro-organisms were isolated from different plates and identified using different characterization systems. Both total bacterial populations and lactic acid bacteria increased with fermentation time and reached the highest number at 16 h (first fermentation) and at 8 h (second and third fermentation). The content of lactic acid was increased with time to reach 1.2%, but the increase was higher for the second and third fermentations (1.6% each). The pH dropped with time from 6.77 to 4.35 in the first fermentation and from 6.65 to 4.18, and 6.57-3.93, in the second and third fermentations, respectively. The microorganisms, which were isolated and characterized during the 24 h fermentation, included: bacteria (Pediococcus pentosaceus, Lactobacillus brevis, Lact. lactis subsp. lactis, Lact. cellobiosus, Klebsiella oxytoca, Kl. pneumoniae, Enterobacter aerogenes, Ent. sakazakii, Serratia marcescens and Ser. odourifera), moulds (Penicillium sp., Rhizopus sp., Aspergillus niger, Alternaria sp., Fusarium sp. and Mucor sp.) and yeasts (Candida parapsilosis, C. orvegnsis and Rhodotorula glutinis).     

利用天然纤维废弃物发酵生产L-乳酸的研究

为了降低L-乳酸的生产成本,更好的实现生物质秸秆的资源化,利用天然纤维素依次接种经离子注入诱变处理的木聚糖酶高产菌黑曲霉P602和米根霉RL6041高产菌进行固、液体二次发酵的方法,将其转化成用于工业生产的L-乳酸。结果表明:本实验条件下,未经过任何化学预处理的秸秆等物质接种黑曲霉P602进行固体发酵,产生的木聚糖酶活力为6 320 IU/g干(培养)基,纤维素酶活力为29 IU/g干基;加入100 mL水浸提后,产生的还原糖浓度为14.07 g/L,纤维物质糖化率为79.45%。取滤液接入米根霉RL6041进行液体发酵后,生成乳酸的量为7 g/L,糖酸转化率为47.6%,以(NH4)2SO4作为氮源时,最佳氮源浓度为3 g/L。     

木糖发酵生产高纯度D-乳酸大肠杆菌工程菌LHY02的构建

高效利用木糖发酵生产D-乳酸或其他生物质产品,是充分利用木质纤维素的一个关键问题。以高效利用木糖产L-乳酸的Escherichia coli WL204为出发菌株,采用RED基因置换技术将ldhL基因置换为ldhA基因,获得一株能利用木糖产D-乳酸的大肠杆菌工程菌株Escherichia coli LHY02,该菌株利用10%木糖发酵,D-乳酸产量达到84.4 g/L,产物光学纯度达到99.5%。此外,该菌株仍然具有较好的利用葡萄糖产D-乳酸的能力。     

1株能利用高粱汁产L-乳酸的菌株鉴定及培养基优化

以产L-乳酸的菌株A2为对象,采用16S rRNA基因测序法结合菌株的表型特征进行鉴定,以甜高粱汁为主要培养基质,采用响应面设计软件对该菌种的发酵培养基进行优化。结果表明,A2菌株为Lactobacillus plantarum S4,优化得到的甜高粱汁培养基配比为甜高粱汁327. 83 g/L,蛋白胨1. 67 g/L,磷酸氢二钾4. 7 g/L,硫酸锰0. 17 g/L,在此培养基配比下,Lactobacillus plantarum S4厌氧发酵68 h后,L-乳酸产量达(61. 20±1. 36) g/L,L-乳酸/葡萄糖转化率(90. 74±2. 28)%,L-乳酸/蔗糖转化率(47. 20±1. 81)%。     

THE EFFECT OF TEMPERATURE ON L-LACTIC ACID PRODUCTION AND METABOLITE DISTRIBUTION OF Lactobacillus casei

The effect of temperature on the growth and L-lactic acid production of Lactobacillus casei G-03 was investigated in a 7-L bioreactor. It was found that the maximum specific growth rate (0.27 hr^?1) and L-lactic acid concentration (160.2 g L^?1) were obtained at a temperature of 41°C. Meanwhile, the maximum L-lactic acid yield, productivity, and dry cell weight were up to 94.1%, 4.44 g L^?1 hr^?1, and 4.30 g L^?1, respectively. At lower or higher temperature, the Lactobacillus casei G-03 showed lower acid production and biomass. Moreover, the main metabolite distribution of strain G-03 response to variations in temperatures was studied. The results suggested that temperature has a remarkable effect on metabolite distribution, and the maximum carbon flux toward lactic acid at the pyruvate node was obtained at 41°C, which had the minimum carbon flux toward acetic acid.     

一株产生L-乳酸的米根霉

为获得理想的L-乳酸产生菌,选择适合根霉属微生物生长的土样,利用溴甲酚绿平板结合摇瓶复筛的方法得到了一株有一定L-乳酸积累能力的米根霉Rhizopus oryzae CS323。摇瓶发酵试验显示,在未优化发酵条件的情况下发酵48h,米根霉CS323L-乳酸积累量达到50.1g/L,是一株有良好改造潜力的L-乳酸产生菌,适合作为进一步诱变育种的出发菌株。     

双极膜电渗析分离发酵液中L-乳酸

采用三室型双极膜电渗析装置将发酵液中的L-乳酸钠转化为L-乳酸。探讨操作电压、流速、进料L-乳酸钠质量浓度等工艺参数对转化过程的影响,考察电渗析过程参数对转化率、物料损失率、电流效率和能耗等技术指标的影响。在最优操作条件下（流速40L／h,电压15V）对2L的100．25g／L乳酸钠发酵液进行分批重复电渗析处理。结果表明：整个过程的转化率为81．22％,损失率为1．5％,能耗为0．81kW·h／kg,电流效率为91．8％,得到的L-乳酸质量浓度可达144．31g／L．电渗析残液补糖后可回到发酵罐中用于发酵生产L-乳酸.     

米根霉利用纯糖和不同预处理玉米秸秆酶解糖生产L-乳酸

通过单因素实验设计,优化米根霉摇瓶发酵产L-乳酸。在此基础上,以蒸气爆破和碱处理玉米秸秆酶解液为混合C源,与纯糖对比,研究不同预处理玉米秸秆混合C源对米根霉发酵产L-乳酸的影响。结果显示:在初始葡萄糖质量浓度100g/L、(NH4)2SO4质量浓度2g/L、接种量6%(体积分数)、转速170r/min、发酵12h后添加30g/LCaCO3的条件下,米根霉发酵产L-乳酸质量浓度为69.15g/L。米根霉发酵不同预处理玉米秸秆酶解混合C源,木糖的存在影响了米根霉的C代谢网络,降低L乳酸的产量。     

Modeling of lactic acid fermentation of leguminous plant juices

Lactic acid fermentation of leguminous plant juices was modeled to provide a comparative efficiency assessment of the previously selected strains of lactic acid bacteria as potential components of starter cultures. Juices of the legumes fodder galega, red clover, and alfalfa were subjected to lactic acid fermentation in 27 variants of experiment. Local strains (Lactobacillus sp. RS 2, Lactobacillus sp. RS 3, and Lactobacillus sp. RS 4) and the collection strain Lactobacillus plantarum BS 933 appeared the most efficient (with reference to the rate and degree of acidogenesis, ratio of lactic and acetic acids, and dynamics of microflora) in fermenting fodder galega juice; Lactobacillus sp. RS 1, Lactobacillus sp. RS 2, Lactobacillus sp. RS 3, Lactobacillus sp. RS 4, and L. plantarum BS 933 were the most efficient for red clover juice. Correction of alfalfa juice fermentation using the tested lactic acid bacterial strains appeared inefficient, which is explainable by its increased protein content and a low level of the acids produced during fermentation.     

Isolation and Characterization of Microorganisms Associated with the Traditional Sorghum Fermentation for Production of Sudanese Kisra

Sorghum flour obtained from Sudan was mixed with water in a 1:2 (wt/vol) ratio and fermented at 30°C for 24 h. The bacterial populations increased with fermentation time and reached a plateau at approximately 18 h. At the end of 24 h, sorghum batter pH had dropped from 5.95 to 3.95 and the batter had a lactic acid content of 0.80%. The microbial population during the 24 h of fermentation consisted of bacteria (Pediococcus pentosaceus, Lactobacillus confusus, Lactobacillus brevis, Lactobacillus sp., Erwinia ananas, Klebsiella pneumoniae, and Enterobacter cloacae), yeasts (Candida intermedia and Debaryomyces hansenii), and molds (Aspergillus sp., Penicillium sp., Fusarium sp., and Rhizopus sp.). P. pentosaceus was the dominant microorganism at the end of the 24-h fermentation. When three consecutive fermentations using an inoculum from the previous fermentation were carried out, the bacterial population increase plateaued at 9 h. The microbial populations in these fermentations were dominated by P. pentosaceus.     

玉米芯稀酸水解及L-乳酸发酵研究

对玉米芯稀硫酸水解条件及糖化液发酵L-乳酸进行了初步研究。结果表明,玉米芯木聚糖最适水解条件为2%H2SO_4、120℃、30 min、固液比1:10,糖化液还原糖含量可达40.8 g/L,主要成分为木塘。细菌A-19可以利用水解液中的葡萄糖和木糖产酸,最适发酵条件为45℃、pH 6.5,从45℃～51℃、pH 5.5～pH 6.5产量均较高。用未浓缩的水解液发酵24 h,L-乳酸产量为30.6g/L,残糖为1.6 g/L,糖酸转化率为82.6%;用浓缩1倍的水解液发酵48 h,L-乳酸产量为41.4 g/L,残糖4.1g/L,糖酸转化率为68.2%,在发酵48 h后继续补料发酵至72 h(补料液为浓缩3倍的水解液),L-乳酸产量为50.9 g/L,残糖6.3 g/L,糖酸转化率为71.8%。该研究为利用木质纤维素生产L-乳酸奠定了一定基础。     

The use of alternative technologies to develop malolactic fermentation in wine

The development of the malolactic fermentation, bioconversion of L-malic acid to L-lactic acid, is a difficult and time-consuming process that does not always proceed favorably under the natural conditions of wine. Traditional fermentations are used worldwide to produce high-quality wines, although delay or failure is not an unusual outcome. During recent years several technologies have been proposed to induce biological deacidification of wines by using malolactic bacteria, principally Oenococcus oeni and Lactobacillus sp. These alternative technologies usually involve the use of high densities of cells or enzymes, free or immobilized onto different matrices. Immobilization materials, several types of bioreactors, and the properties of many specific systems are discussed in this review.     

微白黄链霉菌G-1发酵液抗真菌特性研究和发酵条件优化

为明确微白黄链霉菌(Streptomyces albidoflavus)G-1发酵液抗真菌特性和较优发酵条件,本研究采用平板对峙法、生长速率法、单因素试验、RDA分析和响应面CCD设计分别对其抗真菌特性、产抗菌物质关键限制因子和发酵条件较优组合进行了探究.结果 表明:S.albidoflavus G-1发酵液对马铃薯早...     

基于三步荧光定量PCR技术揭示不同产区白酒酿造系统中Lactobacillus sp.的分布特征

[背景]Lactobacillus sp.是一株存在于白酒酿造系统中的功能微生物,但是针对Lactobacillus sp.的定量方法及其在中国白酒酿造系统中的分布尚未被研究。[目的]建立一种基于特异性引物的荧光定量PCR定量方法,并应用于实际生产检测,揭示Lactobacillus sp.在中国白酒酿造系统中的分布特征。[方法]基于16S rRNA基因序列设计特异性引物,并通过PCR验证引物特异性;优化荧光定量PCR反应程序,提高引物扩增效率;定量分析所采集样本中Lactobacillus sp.的含量,揭示Lactobacillus sp.在中国白酒酿造系统中的分布特征。[结果]设计了一对扩增产物大小为445 bp的特异性引物。通过优化扩增条件,构建含有变性、退火、延伸过程的三步荧光定量PCR方法,该方法扩增线性较强,R²>0.99;灵敏度高,定量限为17.9 copies/μL;重复性好,Ct值的变异系数小于1%。跟踪检测全国10个产区代表产地的白酒酿造系统,其中8个产区均检测到Lactobacillus sp.,在相同产地不同酿造工艺的酿造系统中均检...     

Different inhibition of Lactobacillus delbrueckii subsp. bulgaricus by D- and L-lactic acid: effects on lag phase, growth rate and cell yield

Inhibition of Lactobacillus bulgaricus by lactic acids at constant pH is governed by two factors: the total concentration of lactic acids and the D/L ratio of lactic acid stereoisomers. L-Lactic acid is more inhibitory than the D-isomer, the latter being the only isomer produced by Lact. bulgaricus. The major inhibitory effect is an extremely prolonged lag phase (2–39 h for the range 0–25 g 1^-1 added lactic acids). Added lactic acids reduce the maximum cell concentration obtained in pH controlled fermentations, but have virtually no effect on maximum specific growth rate and on the yield of biomass on produced lactic acid. The added lactic acids have no effect on the growth-related ATP consumption nor on the non-growth related ATP consumption. The culture is heterogeneous since a part of the culture is unable to grow in the presence of L-lactic acid. A different inhibitory effect of D- and L-lactic acid has implications for yoghurt manufacture and potential for improved food preservation.