Strain improvement for enhanced production of cellulase in <Emphasis Type="Italic">Trichoderma viride</Emphasis>

The filamentous fungi Trichoderma species produce extracellular cellulase. The current study was carried out to obtain an industrial strain with hyperproduction of cellulase. The wild-type strain, Trichoderma viride TL-124, was subjected to successive mutagenic treatments with UV irradiation, low-energy ion beam implantation, atmospheric pressure non-equilibrium discharge plasma (APNEDP), and N-methyl-N′-nitro-N-nitrosoguanidine to generate about 3000 mutants. Among these mutants, T. viride N879 strain exhibited the greatest relevant activity: 2.38-fold filter paper activity and 2.61-fold carboxymethyl cellulase, 2.18-fold β-glucosidase, and 2.27-fold cellobiohydrolase activities, compared with the respective wild-type activities, under solid-state fermentation using the inexpensive raw material wheat straw as a substrate. This work represents the first application of APNEDP in eukaryotic microorganisms.     

低温纤维素酶菌株CNY086选育及发酵培养基优化(Ⅱ)

自渤海湾海泥中分离21株低温纤维素酶产生菌。其中菌株CNY01为绿色木霉(Trichoderma viride), 酶活力为67.30 U/mL。以该菌株为出发菌株, 经UV、DES等诱变, 选育出高产突变菌株CNY086, 酶活力为92.17 U/mL。该突变菌株低温纤维素酶发酵具有遗传稳定性。通过单因素和正交实验确定突变菌株CNY086低温纤维素酶发酵最适培养基: 秸秆粉1.20%、麸皮0.70%、硫酸铵0.50%、磷酸二氢钾0.55%, 上述条件下CNY086菌株酶活力达到108.55 U/mL。     

真空微波诱变结合化学诱变选育酸性纤维素酶高产菌株

以酸性纤维素酶产生菌绿色木霉（Trichoderma viride）WL0512作为原始出发菌株,首先经自然分离筛选出一株产酶较稳定的菌株TVN-18,其羧甲基纤维素酶活（CMC酶活）达2765．8U／g,滤纸酶活（FPA酶活）达48．5U／g。再经真空微波和甲基磺酸乙酯（EMS）逐级诱变处理,获得了一株高产、稳产酸性纤维素酶的E6—1菌株,其CMC酶活达4396．6U／g,FPA酶活达126．0U／g,分别是菌株TVN-18的1．59倍和2．60倍。通过对固态发酵培养基麸皮和稻草比例、料水比以及初始pH值的优化,突变株的产酶能力进一步得到提高,其产的CIVIC酶活和FPA酶活分别提高了22．3％和22．4％。     

Production of extracellular enzymes in mutants isolated from trichoderma viride unable to hydrolyze cellulose.

Mutant strains not producing cellulases were induced and isolated from the cellulolytic fungus Trichoderma viride. Enrichment of mutants was carried out with the aid of nystatin selection. Mutants were shown to lack the ability to hydrolyze both soluble and crystalline cellulose. Mannanase and xylanase activities were also absent, indicating a common regulation for all these enzymes in T. viride. In some strains aryl-beta-glucosidase activity was also missing. Mutants grew normally, but the amount of proteins secreted into the medium was very low, and in most cases these proteins were qualitatively different from the proteins of the parent strain.     

Enhanced Cellulase Production by a Mutant of Trichoderma viride

A mutant strain that secretes twice as much cellulase as its parent was obtained by irradiating conidia of Trichoderma viride QM 6a with a linear accelerator.     

Production of extracellular enzymes in mutants isolated from trichoderma viride unable to hydrolyze cellulose

Mutant strains not producing cellulases were induced and isolated from the cellulolytic fungus Trichoderma viride. Enrichment of mutants was carried out with the aid of nystatin selection. Mutants were shown to lack the ability to hydrolyze both soluble and crystalline cellulose. Mannanase and xylanase activities were also absent, indicating a common regulation for all these enzymes in T. viride. In some strains aryl-beta-glucosidase activity was also missing. Mutants grew normally, but the amount of proteins secreted into the medium was very low, and in most cases these proteins were qualitatively different from the proteins of the parent strain.     

Cellulase and beta-glucosidase production by a basidiomycete species.

The optimisation of cellulase and beta-glucosidase production by a basidiomycete species was studied and cellulase and cellobiase production by this and Trichoderma viride (and its mutants) in shake flasks were compared. The former produced an active cellulase comparable to that of T. viride when tested on filter paper, carboxymethylcellulose, and cotton; however, it produced 20 to 26 times larger amounts of cellobiase. Both cellulase and beta-glucosidase were obtained in good yield only when cellulose was the carbon source. The production of these enzymes was not repressed by readily assimilated carbon sources in the presence of cellulose. Only traces of cellulase and beta-glucosidase were formed on glucose, fructose, maltose, and cellobiose although good growth was obtained on these substrates. These enzymes were not induced on sophorose, lactose, mannitol, or glycerol and growth was poor on these substrates. Cellobiose octaacetate was a less effective inducer of cellulase and beta-glucosidase than was cellulose.     

Screening of some wild fungal isolates for cellulolytic activities

Six wild fungal strains, Trichoderma viride, T. harzianum, Gliocladium virens, Aspergillus terreus, A. niger and Tiarosporella phaseolina , isolated from decomposed jute stacks and diseased jute stem, were tested for their cellulolytic and hemicellulolytic activities and compared with T. reesei MCG 77. Filter paper cellulase production by all these wild strains were lower than those produced by T. reesei while some strains ( T. viride, T. harzianum and G. virens ) possessed carboxymethyl cellulase, β-glucosidase, xylanase and β-xylosidase activities comparable to T. reesei. A. terreus and A. niger produced 3·2 and 1·2 times respectively, greater β-glucosidase activity compared to T. reesei when grown on microcrystalline cellulose.     

Effect of nitrogen sources on cellulase biosynthesis by a mutant strain of Trichoderma viride 44

The effect of various nitrogen sources on cellulase biosynthesis by the mutant strain Trichoderma viride 44 was examined. This strain may utilized nitrogen in the nitrate, ammonium of organic form. When cultivating this strain, it appears advantageous to add to the nutrient medium yeast and yeast lyzates as well as their mixture with ammonium sulfate. Cellulase reached its maximum activity of 20.2, 21.5 and 23.2 mu/ml when grown on the medium containing ammonium phosphate, peptone and brewing yeast plus ammonium sulfate, respectively. It is useful to apply nitrogen in its organic forms in small quantities and in combination with mineral forms. The nitrogen presence in the medium is necessary only at the exponential stage of fungal growth. The lack of nitrogen in the stationary stage characterized by the maximum cellulase formation does not inhibit an increase in the enzyme activity.     

表面活性剂对绿色木霉产纤维素酶影响

利用绿色木霉,以稻草为唯一碳源,采用液态发酵的方法,分别加入生物表面活性剂鼠李糖脂和化学表面活性剂Tween 80,重点研究了生物表面活性剂对绿色木霉产纤维素酶的影响。实验分析了加入不同浓度的表面活性剂时滤纸酶活、羧甲基纤维素酶活、微晶纤维素酶活及酶液的表面张力随时间的变化情况。结果表明,添加鼠李糖脂能够促进绿色木霉产酶,分别使滤纸酶活、羧甲基纤维素酶活、微晶纤维素酶活最大提高了1.08倍,1.6倍和1.03倍。与Tween 80相比,鼠李糖脂促进产酶的效果明显优于Tween 80。     

Secretion of cellulase and beta-glucosidase by Trichoderma viride ITCC-1433 in submerged culture on different substrates.

Trichoderma viride ITCC-1433 produces high yields of cellulase and especially beta-glucosidase when grown in submerged culture on different carbon sources. Cellulase synthesis was strongly repressed in the presence of glucose and only a low constitutive activity of beta-glucosidase and carboxymethylcellulase, but no Avicelase, could be demonstrated when culturing T. viride on glucose. With carboxymethylcellulose (CMC) as a substrate the secretion of enzyme as well as growth depended on the degree of substitution, but in general CMC cannot be regarded either as a powerful inducer or as a carbon source. With insoluble cellulose, maximum enzyme production and activities were obtained using an alkali-treated cellulose powder. On this substrate the excretion of soluble protein into the culture broth increased and the protein concentration corresponded to cellulolytic activities.     

Mutants of the white-rot fungus Sporotrichum pulverulentum with increased cellulase and β-d-glucosidase production

This paper reports the isolation of mutants of the white-rot fungus Sporotrichum pulverulentum and the results of a survey of enzymic activity among these mutants. The strains were screened for extracellular cellulase [see 1,4-(1,3;1,4)-β-d-glucan 4-glucanohydrolase, EC 3.2.1.4] and β-d-glucosidase (β-d-glucoside glucohydrolase, EC 3.2.1.21) production in shake flask experiments. Apart from strain 63-2, strains 6, 63, 9, L5, E-1 and UV-18 showed equal or higher endo-1,4-β-d-glucanase (cellulase), filter paper-degrading and β-d-glucosidase activities than S. pulverulentum. The cellulase activity obtained, measured as filter paper activity, was comparable to that reported for Trichoderma reesei QM9414. However, the β-d-glucosidase activity was about six times higher than for the QM9414 strain. The pH and temperature-activity profiles of crude β-d-glucosidase preparations from the various strains were determined and were found to be identical. The thermal stability at pH 4.5 and 40°C was 5 days for all these preparations.     

Kinetic study of partially purified cellulase enzyme produced by Trichoderma viride FCBP-142 and its hyperactive mutants

Cellulases are the enzymes that cleave beta-1,4 linkages of cellulose, and carbohydrate that is main part of plants' cell walls. Presently, cellulase isolation and partial purification was executed through ammonium sulfate precipitation. The isolated protein of parental and derived mutants conferred molecular weights of 30, 45 and 55 kDa. The optimum temperature for maximal cellulase activity was 50 degrees C with Ea for substrate hydrolysis of 77.73, 83.97 and 83.14 kJ mol(-1) and temperature quotient of 1.0020, 1.0022 and 1.0022 by Trichoderma viride FCBP-142, Tv-UV-5.6 and Tv-Ch-4.3, respectively. The enzyme was stable at 50 degrees C for about 60 min but rapid denaturation occurred above 55 degrees C. The enzyme showed optimum activity at pH 4.0 and involved two types of acidic and basic limbs with pKa1 and pKa2. The pKa1 of active site presented a significant shift from 2.55 to 2.9 and 3.1 by Tv-UV-5.6 and Tv-Ch-4.3, respectively in comparison to parental strain. Likewise, pKa2 moved from 6.05 to 6.5 and 6.4. Enzyme kinetics displayed Michaelis-Menten constant Km 0.6, 0.5 and 0.28 mg mL(-1) and Vmax value of 8.33, 10 and 9.09 Units mL(-1) for parental, Tv-UV-5.6 and Tv-Ch-4.3, respectively.     

Low-molecular-weight xylanase from Trichoderma viride.

An endo-1,4-beta-xylanase (1,4-beta-D-xylan xylanohydrolase, EC 3.2.1.8) has been isolated from a commercial preparation of Trichoderma viride. The molecular weight was 22,000 by sodium dodecyl sulfate-polyacrylamide gel electrophoresis, and the pI value was 9.3. The xylanase was a true xylanase without cellulase activity. When the N-terminal amino acid sequence of the first 50 residues was compared with that of a xylanase from Schizophyllum commune, strong evidence for homology was found, with more than 50% amino acid identity. T. viride xylanase also possessed extensive identity with a proposed amino-terminal consensus sequence of xylanases from bacteria.     

多靶向沉默里氏木霉碳代谢阻遏物对纤维素酶活性和表达的调控研究

【目的】构建多靶向siRNA表达载体对里氏木霉碳阻遏抑制因子CRE1、CRE2、CRE3和CRE4进行同时多靶向siRNA干扰,以研究其对里氏木霉纤维素酶基因表达的调控作用。【方法】根据此前研究筛选出沉默cre1、cre2、cre3和cre4基因的4个最佳siRNA序列,设计并构建了A多靶向表达载体,另根据cre1、cre2、cre3和cre4基因中所含有的5个共有序列设计并构建了B多靶向表达载体,将两者转化至里氏木霉QM9414。经筛选后分别在48 h和120 h对各转化子进行纤维素酶酶活力测试(CMC活力测试和滤纸酶酶活力测试)及利用qPCR检测相关基因的表达。【结果】通过RT-qPCR测定结果表明,两种表达载体均可同时抑制里氏木霉的分解代谢物阻遏基因cre1、cre2、cre3和cre4的表达,纤维素酶活力比出发菌株明显升高,多靶向抑制菌株的CMC酶活和滤纸酶活比出发菌株平均提高了1.95倍和2.66倍。纤维素酶基因cbh1和egl1的表达水平比出发菌株也有明显提升,平均提高了3.83倍和3.95倍。纤维素酶相关基因xyr1的表达水平与出发菌株相比也明显上升,平均提高了2.78倍。【结论】多靶向沉默里氏木霉的碳代谢阻遏蛋白有利于解除葡萄糖效应,提高非还原糖的利用,从而提高纤维素酶的产量,使纤维素酶的表达得到更大的提升,为里氏木霉表达纤维素酶在分解代谢物阻遏基因调控方面提供了实验依据和新的技术思路。     

Low-molecular-weight xylanase from Trichoderma viride

An endo-1,4-beta-xylanase (1,4-beta-D-xylan xylanohydrolase, EC 3.2.1.8) has been isolated from a commercial preparation of Trichoderma viride. The molecular weight was 22,000 by sodium dodecyl sulfate-polyacrylamide gel electrophoresis, and the pI value was 9.3. The xylanase was a true xylanase without cellulase activity. When the N-terminal amino acid sequence of the first 50 residues was compared with that of a xylanase from Schizophyllum commune, strong evidence for homology was found, with more than 50% amino acid identity. T. viride xylanase also possessed extensive identity with a proposed amino-terminal consensus sequence of xylanases from bacteria.     

青霉的纤维素酶抗降解物阻遏突变株的选育

从土样中筛出一株生长快,产纤维素酶较高的斜卧青霉(Penicillium decumbens114-2)。能在全纤维素(hlocellulose)双层平板上形成清晰的透明圈。摇瓶培养的滤纸酶活可达8.8mg 葡萄糖/ml.h。 114-2菌株(其纤维素酶合成可为葡萄糖所阻遏)经UV和NG诱变处理后,在含葡萄糖的全纤维素平板上筛选到多株仍能形成明显透明圈的突变株。其中JN15和JU1在含葡萄糖的全纤维素液体培养基中,在残余葡萄糖浓度为 1％左右时,滤纸酶活可分别达到7.3 和13.9mg葡萄糖ml·h。这是出发株114-2和纤维素酶高产菌株木霉EA_3-867和QM9414所不能的。在不加阻遏剂的对比试验中,两个突变株的纤维素酶产量都比较高。其中,JU1的滤纸、CMC和棉花酶活分别达到33mg葡萄糖/ml·h,234mg葡萄糖/ml·h和86mg葡萄糖/ml·24h。     

Semiquantitative Plate Assay for Determination of Cellulase Production by Trichoderma viride

A plate clearing assay was devised to screen for high-producing cellulase mutants of Trichoderma viride. The method employs (i) the use of either rose bengal or oxgall to limit colony size and (ii) Phosfon D (tributyl-2, 4-dichloroben-zylphosphonium chloride) to enhance cellulase detection, in combination with acid-swollen cellulose on agar plates. The method was used to isolate constitutive cellulase mutants of T. viride and should prove useful for isolating high-producing mutants from a range of organisms. This technique has been also used to determine the concentration at which glucose and glycerol inhibit cellulase synthesis by catabolite repression in the wild-type strains.     

Screening of highly cellulolytic fungi and the action of their cellulase enzyme systems

Over 100 strains of wood-rotting fungi were compared for their ability to degrade wood blocks. Some of these strains were then assayed for extracellular cellulase [1,4-(1,3;1,4)-β- -glucan 4-glucanohydrolase, EC 3.2.1.4] activity using a variety of different solid media containing carboxymethyl cellulose or acid swollen cellulose. The diameter of clearing on these plates gave an approximate indication of the order of cellulase activities obtained from culture filtrates of these strains. Trichoderma strains grown on Vogels medium gave the highest cellulase yields. The cellulase enzyme production of T. reesei C30 and QM9414 was compared with that of eight other Trichoderma strains. Trichoderma strain E58 had comparable endoglucanase and filter paper activities with the mutant strains while the β- -glucosidase [β- -glucoside glucohydrolase, EC 3.2.1.21] activity was approximately six to nine times greater.     

Properties of cellulase immobilized on agarose gel with spacer

Cellulase produced by fungus Trichoderma viride was immobilized on agarose beads (Sepharose 4B) activated by cyanogen bromide and also on activated agarose beads that contained spacer arm (activated CH-Sepharose 4B and Affi-Gel 15). The CMCase activity retained by immobilized cellulase on activated Sepharose containing the spacer tended to be higher than that immobilized without spacer, although the extent of protein immobilization was lower. Also, the higher substrate specificity for cellulase immobilized on beads with spacer was obtained for cellobiose, acid-swollen cellulose, or cellulose powder. The hydrolysis product from their substrates was mainly glucose.