Effect of polycyclic aromatic hydrocarbons on laccase production by white rot fungus <Emphasis Type="Italic">Pleurotus ostreatus</Emphasis> D1

The effect of polycyclic aromatic hydrocarbons (PAHs) on the time course of laccase production by the fungus Pleurotus ostreatus D1 under conditions of submerged cultivation on Kirk’s medium has been studied. It has been shown that phenanthrene, fluoranthene, pyrene, and chrysene actively induce this enzyme, whereas fluorene and anthracene had a smaller effect. Addition of Mn²⁺ ions to cultivation medium elevates the laccase activity twofold and more in the presence of all the studied PAHs. Electrophoresis under nondenaturing conditions demonstrates induction of additional laccase forms by xenobiotics. Ligninolytic peroxidase activities are undetectable under the conditions used.     

Influence of PAHs on ligninolytic enzymes of the fungus <Emphasis Type="Italic">Pleurotus ostreatus</Emphasis> D1

Polycyclic aromatic hydrocarbons (PAHs), their derivatives, and their degradation products were assayed for the ability to enhance activities of ligninolytic enzymes (laccase and versatile peroxidase) of the fungus Pleurotus ostreatus D1. The activities of both laccase and versatile peroxidase were induced by the PAHs, their derivatives, and their degradation products. Laccase was produced mostly in the first 7–10 days, whereas the production of versatile peroxidase began after 5–7 days of cultivation. Non-denaturing PAGE showed the presence of additional forms of laccase and versatile peroxidase in the presence of the xenobiotics in the cultivation medium. The difference in the production time for these enzymes may reflect that laccases are involved in the first stages of PAHs degradation and that versatile peroxidase can be necessary for oxidation of some degradation products. This is the first report on versatile peroxidase induction by PAHs and their derivatives.     

不同栽培基质对糙皮侧耳不同发酵方式下产漆酶活性的影响

为了比较糙皮侧耳栽培种在不同常规栽培基质上的漆酶活性,分析更适合糙皮侧耳生长的栽培基质,以1株糙皮侧耳Pleurotus ostreatus栽培菌株为研究材料,研究在固态和液态发酵条件下添加木屑、玉米芯和棉籽壳这3种栽培基质后,对其产漆酶活性的影响。结果表明,不同栽培基质对糙皮侧耳漆酶活性具有极显著的影响（P<0.001）;不同发酵方法对糙皮侧耳漆酶活性也具有极显著的影响（P<0.001）,仅第2天差异不显著。固体发酵与液体发酵条件下,糙皮侧耳在棉籽壳培养基上所检测到的漆酶活性均高于在木屑或者玉米芯培养基上,表明棉籽壳对提高糙皮侧耳漆酶活性的诱导能力更强。此外,糙皮侧耳在棉籽壳培养基上能够快速分泌漆酶,表明棉籽壳对缩短糙皮侧耳漆酶分泌时间的诱导能力更强。     

Effect of different cultivation conditions and inducers on the production of laccase by the litter-dwelling fungal isolate Fusarium incarnatum LD-3 under solid substrate fermentation

The litter-dwelling fungus Fusarium incarnatum LD-3 has been identified as a novel producer of laccase. The present work was oriented towards the optimization of various cultivation conditions for maximizing laccase production under solid substrate fermentation. The process parameters were optimized by the “one factor at a time” approach. Maximum laccsase production was obtained at pH 5.0 and at a temperature of 28 °C with 60 % moisture content using rice bran as a substrate. The laccase production was enhanced in the presence of aromatic inducer, i.e. ortho-dianisidine at a concentration of 0.5 mM. Laccase production was further increased by 52.56 % when the medium was supplemented with 2 % (v/v) alcohol. Among the various amino acids tested as a growth factor and nitrogen source, D-Serine and DL-2 Amino n-butyric acid, DL-Alanine and L-Glycine were found to be the most suitable for laccase production. The highest laccase production (1,352.64 U/g) was achieved under optimized conditions, and was 2.1-fold higher than the unoptimized conditions. Thus, the novel litter-dwelling fungal isolate Fusarium incarnatum LD-3 seems to be an efficient producer of laccase and can be further exploited for biotechnological applications. This is the first report on the optimization of cultivation conditions and inducers for laccase production from Fusarium incarnatum LD-3.     

Degradation of fluorene and fluoranthene by the basidiomycete <Emphasis Type="Italic">Pleurotus ostreatus</Emphasis>

The dependence of the degree of fluorene and fluoranthene degradation by the fungus Pleurotus ostreatus D1 on the culture medium composition has been studied. Polycyclic aromatic hydrocarbons (PAHs) have been transformed in Kirk’s medium (under conditions of laccase production) with the formation of a quinone metabolite and 9-fluorenone upon the use of fluoranthene and fluorene as substrates, respectively. More complete degradation with the formation of an intermediate metabolite, phthalic acid that has undergone subsequent utilization, has occurred in basidiomycete-rich medium (under the production of both laccase and versatile peroxidase). The formation of phthalic acid as a metabolite of fluoranthene degradation by lignolytic fungi has been revealed for the first time. The data allow the supposition that both extracellular laccase and laccase on the mycelium surface can participate in the initial stages of PAH metabolism, while versatile peroxidase is necessary for the oxidation of the formed metabolites. A scheme of fluorene metabolism by Pleurotus ostreatus D1 is suggested.     

粗毛栓菌(Trametes hirsuta) D2固态发酵山核桃蒲壳产漆酶的营养条件研究

【目的】为提高漆酶产量,降低生产成本,以山核桃蒲壳作为基质,对粗毛栓菌D2固态发酵产漆酶的营养条件进行研究。【方法】对不同碳源、氮源、碳氮比、蒲壳含量对漆酶产量的影响进行分析。【结果】山核桃蒲壳是粗毛栓菌生长的良好载体,能够促进漆酶的合成。粗毛栓菌D2漆酶固态发酵培养基干物质组成为:山核桃蒲壳40%(质量比),玉米粉24%(质量比),菜籽饼粉36%(质量比)。发酵6 d时,漆酶活性为126.8 U/g干基。【结论】粗毛栓菌固态发酵山核桃蒲壳产漆酶具有效率高,生产成本低的优点,具有潜在的工业化应用前景。     

Biocatalytic decolourisation of molasses by Phanerochaete chrysosporium

Bioremediation potential of Phanerochaete chrysosporium strains NCIM 1073, NCIM 1106 and NCIM 1197 to decolourise molasses in solid and liquid molasses media was studied. Strains varied in the pattern of molasses decolourisation on solid medium by Giant colony method. Under submerged cultivation conditions, strain NCIM 1073 did not decolourise molasses while, strains NCIM 1106 and NCIM 1197 could decolourise molasses up to 82% and 76%, respectively. Under stationary cultivation conditions, none of the strains could decolourise molasses. This was overcome by increasing the surface area of the culture in flat bottom glass bottles under stationary cultivation conditions. Under submerged cultivation conditions, growth was more or less same in all strains. However, the lignin peroxidase and manganese peroxidase activities were significantly less in the strain NCIM 1073. Under stationary cultivation conditions, none of the strains could produce enzymes lignin peroxidase, manganese peroxidase and laccase. However, all of them could produce lignin peroxidase and manganese peroxidase when cultivated in flat bottom glass bottles under stationary cultivation conditions.     

Degradation of Polycyclic Aromatic Hydrocarbons by Crude Extracts from Spent Mushroom Substrate and its Possible Mechanisms

Biodegradation of polycyclic aromatic hydrocarbons (PAHs) by pure laccase has been reported, but the high cost limited its application in environmental bioremediation. Here, we reported a study about PAHs degradation by crude extracts (CEs) containing laccase, which were obtained by extracting four spent mushroom (Agaricus bisporus, Pleurotus eryngii, Pleurotus ostreatus, and Coprinus comatus) substrates. The results showed that anthracene, benzo[a]pyrene, and benzo[a]anthracene were top three degradable PAHs by CEs while naphthalene was most recalcitrant. The PAHs oxidation was enhanced in the presence of 2,2-azino-bis-(3-ethylbenzothiazoline-6-sulfonic acid) (ABTS). Laccase included in CE might play a major role in PAHs degradation. The maximum degradation rate of anthracene and benzo[a]pyrene was observed by using crude extracts from P. eryngii while the highest laccase activities were found in crude extracts from A. bisporus, moreover, crude extracts from P. eryngii, which contained less laccase activities, degraded more anthracene and benzo[a]pyrene than pure laccase with higher laccase activities. The lack of correlation between laccase activity and PAHs degradation rate indicated that other factors might also influence the PAHs degradation. Boiled CEs were added to determine the effect on PAHs degradation by laccase. The results showed that all four boiled CEs had improved the PAHs oxidation. The maximum improvement was observed by adding CEs from P. eryngii. It suggested that some mediators indeed existed in CEs and CEs from P. eryngii contained most. As a result, CEs from P. eryngii has the most application potential in PAHs bioremediation.     

Laccase induction in fungi and laccase/N-OH mediator systems applied in paper mill effluent

There has been increasing interest in extracellular enzymes from white rot fungi, such as lignin and manganese peroxidases, and laccases, due to their potential to degrade both highly toxic phenolic compounds and lignin. The optimum cultivation conditions for laccase production in semi-solid and liquid medium by Trametes versicolor, Trametes villosa, Lentinula edodes and Botrytis cinerea and the effects of laccase mediator system in E1 effluent were studied. The higher laccase activity (12756 U) was obtained in a liquid culture of T. versicolor in the presence of 1 mM of 2,5-xylidine and 0.4 mM copper salt as inducers. The effluent biotreatments were not efficient in decolorization with any fungal laccases studied. Maximum phenol reduction was approximately 23% in the absence of mediators from T. versicolor. The presence of 1-hydroxybenzotriazole did not increase phenol reduction. However, acetohydroxamic acid, which was not degraded by laccase, acted very efficiently on E1 effluent, reducing 70% and 73% of the total phenol and total organic carbon, respectively. Therefore, acetohydroxamic acid could be applied as a mediator for laccase bioremediation in E1 effluent.     

Increased production of laccase by <Emphasis Type="Italic">Cerrena unicolor</Emphasis> in submerged liquid cultures

The wood-degrading basidiomycete Cerrena unicolor C-139 has been suggested as a potential producer of the industrially important enzyme laccase. Basic culture parameters influencing the enzyme synthesis in shaken-flask and aerated bioreactor cultures were evaluated to improve the yields of the process. Production of extracellular laccase was considerably enhanced by the addition of Cu²⁺ in the micromolar range to a carbon-sufficient and nitrogen-sufficient culture medium (C/N = 16.69). When an optimised medium containing glucose (10 g/L) and l-asparagine (1.5 g/L) was used, and enzyme synthesis was stimulated by addition of 10 μM Cu²⁺ to the culture medium on days 3, 6 and 9, maximal laccase productivity obtained after 17 days’ cultivation in shaken flask cultures was above 100,000 nkat/L. In fermenter fungal cultures, the influence of stabilisation of medium pH on laccase activity was additionally studied. The use of a bioreactor with an automatic pH control set at pH 6.5 after 48-h incubation resulted in the enzyme activity of 65,000 nkat/L after 8 days’ cultivation.     

New ways to increasing the yield of laccase from Panus tigrinus fungi

We optimized the conditions for production of laccase by lignolytic fungi Panus tigrinus 8/18. 2,4-Dimethylphenol was used as an aromatic inductor. The addition of 2,4-dimethylphenol and 2 mM CuSO4 to a rich medium was followed by a tenfold increase in the yield of this enzyme. Additional treatment of the medium with perftoran (oxygen-carrying agent) and immobilization of the fungus on polycaproamide fibers increased significantly laccase activity in the medium. The conditions for cultivation of P. tigrinus fungi were optimized. It allowed us to increase laccase activity in the medium by 25 times (compared to activity of the enzyme obtained with previously described methods).     

Influence of cultivation conditions on pyrene degradation by the fungus Pleurotus Ostreatus D1

For the first time the dependence of completeness of pyrene degradation by the white-rot fungus Pleurotus ostreatus D1 on cultivation conditions was found. In Kirk’s medium about 65.6 ± 0.9% of the initial pyrene was metabolized after 3 weeks, with pyrene-4,5-dihydrodiol accumulating. This process was accompanied by laccase production only. In basidiomycetes rich medium, P. ostreatus D1 metabolized up to 89.8 ± 2.3% of pyrene within 3 weeks without pyrene-4,5-dihydrodiol accumulation throughout the time of cultivation. Phenanthrene and phthalic acid were identified as the metabolites produced from pyrene degradation under these conditions. Accumulation of phenanthrene with its subsequent disappearance was observed. One more metabolite probably was the product of phenanthrene degradation. Pyrene metabolism in basidiomycetes rich medium was accompanied first by laccase and tyrosinase production and later by versatile peroxidase production. The cell-associated activities of laccase, tyrosinase, and versatile peroxidase were found. The data obtained indicate that both enzymes (laccase and versatile peroxidase) are necessary for complete degradation of pyrene. Furthermore, both cell-associated and extracellular laccases can catalyse the first stages of pyrene degradation, and versatile peroxidase can be necessary for oxidation of the resulting metabolites.     

Induction of laccase production inCyathus bulleri under shaking and static culture conditions

Laccase production byCyathus bulleri was lower in lignins and phenolic compounds as compared to malt extract medium (8 U/mL) which increased significantly on supplementing these compounds with malt extract. Of the different lignins and phenolic compounds, Reax, lignin and orcinol exhibited maximum laccase formation (12 and 68 U/mL, respectively) under static culture conditions, while sugars repressed it. Laccase activity inC. bulleri was higher under static than under shaking cultivation conditions. Moreover, agitation repressed laccase formation even in the presence of inducers.     

Polycyclic Aromatic Hydrocarbon Metabolism by White Rot Fungi and Oxidation by Coriolopsis gallica UAMH 8260 Laccase

We studied the metabolism of polycyclic aromatic hydrocarbons (PAHs) by using white rot fungi previously identified as organisms that metabolize polychlorinated biphenyls. Bran flakes medium, which has been shown to support production of high levels of laccase and manganese peroxidase, was used as the growth medium. Ten fungi grown for 5 days in this medium in the presence of anthracene, pyrene, or phenanthrene, each at a concentration of 5 μg/ml could metabolize these PAHs. We studied the oxidation of 10 PAHs by using laccase purified from Coriolopsis gallica. The reaction mixtures contained 20 μM PAH, 15% acetonitrile in 60 mM phosphate buffer (pH 6), 1 mM 2,2′-azinobis-(3-ethylbenzthiazoline-6-sulfonate) (ABTS), and 5 U of laccase. Laccase exhibited 91% of its maximum activity in the absence of acetonitrile. The following seven PAHs were oxidized by laccase: benzo[a]pyrene, 9-methylanthracene, 2-methylanthracene, anthracene, biphenylene, acenaphthene, and phenanthrene. There was no clear relationship between the ionization potential of the substrate and the first-order rate constant (k) for substrate loss in vitro in the presence of ABTS. The effects of mediating substrates were examined further by using anthracene as the substrate. Hydroxybenzotriazole (HBT) (1 mM) supported approximately one-half the anthracene oxidation rate (k = 2.4 h⁻¹) that ABTS (1 mM) supported (k = 5.2 h⁻¹), but 1 mM HBT plus 1 mM ABTS increased the oxidation rate ninefold compared with the oxidation rate in the presence of ABTS, to 45 h⁻¹. Laccase purified from Pleurotus ostreatus had an activity similar to that of C. gallica laccase with HBT alone, with ABTS alone, and with 1 mM HBT plus 1 mM ABTS. Mass spectra of products obtained from oxidation of anthracene and acenaphthene revealed that the dione derivatives of these compounds were present.     

Production of Laccase and Optimization of Its Production by Bacillus sp. Using Distillery Spent Wash as Inducer

A bacillus sp. isolated from the sediments of a distillery mill was used for laccase production under optimized culture conditions. The distillery effluent was used as an inducer for overproduction of laccase by employing the Taguchi approach. Screening of different medium components and their effect on laccase production was studied using an M-16 orthogonal array. The formation of laccase was considerably increased by addition of 1 mM copper sulfate (51.95 U/ml), which was further enhanced by the use of different inducers. The usefulness of the Taguchi method for optimization of culture conditions was investigated with five selected factors at four levels, and it was observed that the optimized medium resulted in a 9-fold increase in extracellular laccase production compared with the control. The optimized medium composition for laccase production was dextrose (1%), tryptone (0.1%), CuSO₄ (1 mM), and an inducer (distillery effluent 10% [v/v]) at pH 7, which altogether resulted in 107.32 U/ml extracellular laccase activity. Hence, the Taguchi approach proved to be a reliable tool in optimizing culture conditions and achieving the best possible combination for enhanced laccase production.     

Physiologo-biochemical properties of a strain of Beijerinckia mobilis 1phi Phn+--a degrader of polycyclic aromatic hydrocarbons

Beijerinckia mobilis 1f capable of degrading polycyclic aromatic hydrocarbons (PAHs) was isolated from a soil contaminated with creosote. Strain 1f could utilize phenanthrene and naphthalene as the sole sources of carbon. The mean rate of phenanthrene degradation during culture growth was 7-8 micrograms/(ml h). After cultivation under nonselective conditions, strain 1f retained its ability to degrade phenanthrene. Cometabolism considerably widened the range of PAHs that could be transformed by strain 1f. The strain was able to grow in a mineral medium with creosote as the sole source of carbon. After 30 days of cultivation in this medium, the total concentration of PAHs decreased from 665.5 mg/l to 170 mg/l.     

多环芳烃的真菌漆酶转化及污染土壤修复技术

漆酶可以转化多种有机污染物,在环境保护领域具有广泛的应用潜力。二十年来,通过多学科协同研究,对真菌漆酶转化多环芳烃的机制、特征等各方面的认识不断深入。基于漆酶等真菌木质素分解酶的污染土壤修复技术不断发展,并逐渐走向田间应用。本文首先介绍了真菌漆酶的一般作用机制与多环芳烃转化特征,结合我们的相关研究提出了漆酶作用下多环芳烃在土壤中的迁移模式;其次介绍了利用漆酶氧化原理修复污染农田土壤的潜力,着重对利用农业废弃物进行真菌生物刺激的修复实践进行了评述;最后,就漆酶转化多环芳烃基础研究中的若干重要问题进行了思考,并展望了真菌及其漆酶系统在污染土壤修复应用中的发展方向。     

Enhanced production of laccase in <Emphasis Type="Italic">Coriolopsis rigida</Emphasis> grown on barley bran in flask or expanded-bed bioreactor

In this work, the effect on laccase activity of adding xylidine, veratryl alcohol and copper sulphate to cultures of Coriolopsis rigida under submerged cultivation conditions have been investigated. The highest activities (approximately 6 × 10⁵ nkat/l) were obtained when the inducers copper sulphate (2 mM) and xylidine (10 mM) were added simultaneously. In addition, operating in the optimal conditions, it was possible to maintain the sustained production of laccase (around 3 × 10⁵ nkat/l) for successive repeated batch cultures in an expanded-bed laboratory scale bioreactor. On the other hand, in vitro phenol degradation by laccase obtained in the bioreactor was studied with/without an effective mediator 1-hydroxybenzotriazol (HBT). The presence of a radical mediator plays an important role inducing the degradation of phenol, and without mediator the polymerization of phenol was detected.     

Degradation of polycyclic aromatic hydrocarbons (2–7 rings) under microaerobic and very-low-oxygen conditions by soil fungi

Soil fungi were studied regarding their ability to degrade polycyclic aromatic hydrocarbons (PAHs) and produce ligninolytic enzymes under microaerobic and very-low-oxygen conditions. Several PAHs were used as substrates for soil fungi under microaerobic and very-low-oxygen conditions. Activities of lignin-peroxidase, manganese-peroxidase, and laccase were monitored over a 30-day period. PAH degradations were analyzed using C₁₈ reversed-phase HPLC. Low-molecular-weight PAHs (LMW-PAHs, 2–3 rings) were degraded most extensively by Aspergillus sp., Trichocladium canadense, and Fusarium oxysporum. When growing on high-molecular-weight PAHs (HMW-PAHS, 4–7 rings), the highest degradations were reached by T. canadense, Aspergillus sp., Verticillium sp., and Achremonium sp. In this study, these fungi revealed a great capability to degrade a broad range of PAHs under low-oxygen conditions. In addition, lignolytic enzyme activities were observed during fungal growth on these compounds. These results suggest fungi have the ability to bioremediate PAH-contaminated soils and that they use these compounds as carbon sources for growth.