颗粒厌氧污泥中的产氢产乙酸细菌研究

本文报道颗粒厌氧污泥中产氢产乙酸细菌的含量及存在方式。在正常运行状态,随着颗粒污泥的培养和生长、产氢产乙酸细菌含量维持在10⁷-10⁸个/ml.一旦厌氧反应器“酸化”,颗粒污泥性能变差,产氢产乙酸细菌急剧下降,减小到约10⁵个/ml.比正常状态低2-3个数级,说明细菌生长受到了不可逆抑制。电镜观察表明,产氢产乙酸细菌的分布不是随机的,它们以微菌落方式存在并排列有序。除了与甲烷短杆菌互营共生外,还发现了一种和甲烷丝菌间的新型互营共生关系,分析     

高活性厌氧颗粒污泥稳定性及基质代谢和种间氢转移的研究

选择了几种废水形成的厌氧污泥,进行了稳定性、基质代谢及种间氢转移的研究.颗粒化的污泥对盐、pH、酶作用、温度、压力等外界条件影响有一定的抗性,在丙酸代谢中,丙酸对颗粒污泥抑制浓度可达1000mg/L,而絮状污泥在500mg/L就被明显抑制,并比较了两者的最大比产甲烷速率和氢酶活性,在种间氢转移实验中,乙醇对颗粒污泥的抑制浓度比絮状污泥要高,颗粒污泥在各方面的性能都明显优于絮状污泥,还对颗粒污泥的物理特性及保存方式进行了初步研究.     

Isolation of hydrogen-producing bacteria from granular sludge of an upflow anaerobic sludge blanket reactor

H₂-producing bacteria were isolated from anaerobic granular sludge. Out of 72 colonies (36 grown under aerobic conditions and 36 under anaerobic conditions) arbitrarily chosen from the agar plate cultures of a suspended sludge, 34 colonies (15 under aerobic conditions and 19 under anaerobic conditions) produced H₂ under anaerobic conditions. Based on various biochemical tests and microscopic observations, they were classified into 13 groups and tentatively identified as follows: From aerobic isolates,Aeromonas spp. (7 strains),Pseudomonas spp. (3 strains), andVibrio spp. (5 strains); from anaerobic isolates,Actinomyces spp. (11 strains),Clostridium spp. (7 strains), andPorphyromonas sp. When glucose was used as the carbon substrate, all isolates showed a similar cell density and a H₂ production yield in the batch cultivations after 12h (2.24–2.74 OD at 600 nm and 1.02–1.22 mol H₂/mol glucose, respectively). The major fermentation by-products were ethanol and acetate for the aerobic isolates, and ethanol, acetate and propionate for the anaerobic isolates. This study demonstrated that several H₂ producers in an anaerobic granular sludge exist in large proportions and their performance in terms of H₂ production is quite similar.     

Enhancement of sulfate reduction activity using granular sludge in anaerobic treatment of acid mine drainage

Three laboratory-scale, upflow anaerobic reactors were operated for about 250 d to determine the effect of activated granular sludge with high density of sulfate reducing bacteria in the treatment of artificial acid mine drainage. Sulfate reducing bacteria in the granular sludge taken from the upflow anaerobic sludge blanket reactor were 1–2×10⁶ c.f.u. g^–1, which is at least 10 times higher than that of organic substrates such as cow manure and oak compost. The reactors with granular sludge effectively removed over 99% of heavy metals, such as Fe, Al, Cu, and Cd during the experiment. This result suggests a feasibility of the application of granular sludge as a source of sulfate reducing bacteria for the treatment of acid mine drainage.     

Start-up and inhibition analysis of the Anammox process seeded with anaerobic granular sludge

The longer start-up period of the Anammox process is due to the very low cellular yield and growth rates of Anammox bacteria. Nitrite inhibition is considered to be the key factor in the instability of the Anammox process during the operation. However, little attention was paid to the inhibitory effect of pH and free ammonia. This paper presents start-up and inhibition analysis of an Anammox biofilm reactor seeded with anaerobic granular sludge. Results showed that the start-up period could be divided into the sludge lysis phase, lag phase, propagation phase, stationary phase and inhibition phase. Optimization control could be implemented correspondingly to accelerate the start-up of Anammox bioreactors. Effluent pH increased to 8.7–9.1 when the nitrogen removal rate was higher than 1,200 mg l⁻¹ day⁻¹. The free ammonia concentration was accompanied with a higher level of 64–73 mg l⁻¹. Inhibitory effects of high pH and free ammonia on Anammox bacteria contributed to the destabilization of the Anammox bioreactor during the first 125 days with influent KHCO₃ of 0.5 g l⁻¹. Increasing the suffering capacity in the inlet by dosing 1.25 g KHCO₃ l⁻¹ effectively reduced the pH variation, and the nitrogen removal performance of the reactor was further developed.     

Feasibility of expanded granular sludge bed reactors for the anaerobic treatment of low-strength soluble wastewaters

The application of the expanded granular sludge bed (EGSB) reactor for the anaerobic treatment of low-strength soluble wastewaters using ethanol as a model substrate was investigated in laboratory-scale reactors at 30oC. Chemical oxygen demand (COD) removal efficiency was above 80% at organic loading rates up to12 g COD/L . d with influent concentrations as low as 100 to 200 mg COD/L. These results demonstrate the suitability of the EGBS reactor for the anaerobic treatment of low-strength wastewaters. The high treatment performance can be attributed to the intense mixing regime obtained by high hydraulic and organic loads. Good mixing of the bulk liquid phase for the substrate-biomass contact and adequate expansion of the substrate-biomass contact and adequate expansion of the sludge bed for the degassing were obtained when the liquid upflow velocity (V(up)) was greater than 2.5 m/h. Under such conditions, an extremely low apparent K(s) value for acetoclastic methanogenesis of 9.8 mg COD/L was observed. The presence of dissolved oxygen in the wastewater had no detrimental effect on the treatment performance. Sludge piston flotation from pockets of biogas accumulating under the sludge bed occurred at V(up) lower than 2.5 m/h due to poor bed expansion. This problem is expected only in small diameter laboratory-scale reactors. A. more important restriction of the EGSB reactor was the sludge washout occurring at V(up) higher than 5.5 m/h and which was intensified at organic loads higher than 7 g COD/L. d due to buoyancy forces from the gas production. To achieve an equilibrium between the mixing intensity and the sludge hold-up, the operation should be limited to an organic loading rate of 7 g COD/L d. and to a liquid up-flow velocity between 2.5 and 5.5 m/h (c) 1994 John Wiley & Sons, Inc.     

荧光定量PCR监测五氯酚对好氧颗粒污泥和活性污泥中氨氧化细菌数量的影响

通过特异引物扩增环境中氨氧化细菌16S rDNAV2保守区域,将该片段克隆到T-easy载体上,PCR产物经测序和定量PCR扩增体系鉴定,证实PCR扩增产物为氨氧化细菌16S rDNA保守序列,以含该序列的重组质粒作为定量PCR监测氨氧化细菌数量的DNA标准品。用荧光定量PCR技术比较了五氯酚(PCP)对好氧颗粒污泥和活性污泥中氨氧化细菌数量的影响。结果表明,不加PCP的反应器中,好氧颗粒污泥和活性污泥中氨氧化细菌的数量分别为4.28×107±5.44×106cells/(g干污泥)和2.51×109±8.61×108cells/(g干污泥)。随着PCP浓度的增加(0~50mg/L),PCP对氨氧化细菌数量的影响不大(P>0.05),而且,污泥中氨氧化细菌的数量与氨氮的去除率无直接的正相关关系(P>0.05),PCP主要是抑制氨氧化细菌的代谢活性导致污泥氨氮去除效率降低。     

Advanced monitoring of high-rate anaerobic reactors through quantitative image analysis of granular sludge and multivariate statistical analysis

Four organic loading disturbances were performed in lab-scale EGSB reactors fed with ethanol. In load disturbance 1 (LD1) and 2 (LD2), the organic loading rate (OLR) was increased between 5 and 18.5 kg COD m(-3) day(-1), through the influent ethanol concentration increase, and the hydraulic retention time decrease from 7.8 to 2.5 h, respectively. Load disturbances 3 (LD3) and 4 (LD4) were applied by increasing the OLR to 50 kg COD m(-3) day(-1) during 3 days and 16 days, respectively. The granular sludge morphology was quantified by image analysis and was related to the reactor performance, including effluent volatile suspended solids, indicator of washout events. In general, it was observed the selective washout of filamentous forms associated to granules erosion/fragmentation and to a decrease in the specific acetoclastic activity. These phenomena induced the transitory deterioration of reactor performance in LD2, LD3, and LD4, but not in LD1. Extending the exposure time in LD4 promoted acetogenesis inhibition after 144 h. The application of Principal Components Analysis determined a latent variable that encompasses a weighted sum of performance, physiological and morphological information. This new variable was highly sensitive to reactor efficiency deterioration, enclosing variations between 27% and 268% in the first hours of disturbances. The high loadings raised by image analysis parameters, especially filaments length per aggregates area (LfA), revealed that morphological changes of granular sludge, should be considered to monitor and control load disturbances in high rate anaerobic (granular) sludge bed digesters.     

Quantitative image analysis as a diagnostic tool for monitoring structural changes of anaerobic granular sludge during detergent shock loads

Two shock loads of a commercial detergent (I-150 mg chemical oxygen demand (COD)/L, fed for 56 h; II-300 mg COD/L fed for 222 h) were applied in a lab-scale Expanded Granular Sludge Blanket (EGSB) reactor, fed with 1,500 mg COD/L of ethanol. The impact of the surfactant was assessed in terms of granular sludge morphology, specific methanogenic activity (SMA) in the presence of individual substrates, and reactor performance. COD removal efficiency remained unaffected in the shock I, but 80 h after starting exposure to the shock II, the COD removal efficiency decreased drastically from 75 to 17%. In the first 8 h of operation of shock I, the SMA was stimulated and decreased afterwards, being recovered 5 days after the end of exposure time. Concerning to shock II, the SMA was immediately and persistently reduced during the exposure time, although, the inhibition of SMA in presence of H(2)/CO(2) showed a trend to increase after the exposure time. Acetoclastic bacteria were observed as the most sensitive to the toxic effects of surfactant whereas the hydrogenotrophic bacteria were less affected. The inhibitory effects were dependent on surfactant concentration and exposure time. The ratio filaments length per total aggregates area (LfA) was an early-warning indicator of biomass washout, since it increased 3 and 5 days before effluent volatile suspended solids (VSS) rise, respectively, in shocks I and II.     

Cobalt toxicity in anaerobic granular sludge: influence of chemical speciation

The influence of cobalt speciation on the toxicity of cobalt to methylotrophic methanogenesis in anaerobic granular sludge was investigated. The cobalt speciation was studied with three different media that contained varying concentrations of complexing ligands [carbonates, phosphates and ethylenediaminetetraacetic acid (EDTA)]. Three fractions (nominal added, dissolved and free) of cobalt were determined in the liquid media and were correlated with data from batch toxicity experiments. The average concentration of cobalt that was required for 50% inhibition of methanogenic activity (IC₅₀) for free Co²⁺ in the three sets of measurements was 13 μmol/L with a standard deviation of 22% and a similarity of 72% between the data obtained in the three different media for the range of cobalt concentrations investigated. The standard deviation of the IC₅₀ for the other two fractions was much higher, i.e. 85 and 144% for the added cobalt and dissolved cobalt, respectively, and the similarity was almost 0% for both fractions. Complexation (and precipitation) with EDTA, phosphates and carbonates was shown to decrease the toxicity of cobalt on methylotrophic methanogenesis. The free cobalt concentration is proposed to be the key parameter to correlate with cobalt toxicity. Thus, the toxicity of cobalt to granular sludge can be estimated based on the equilibrium-free cobalt concentration.     

Quantitative analysis of a high-rate hydrogen-producing microbial community in anaerobic agitated granular sludge bed bioreactors using glucose as substrate

Fermentative H₂ production microbial structure in an agitated granular sludge bed bioreactor was analyzed using fluorescence in situ hybridization (FISH) and polymerase chain reaction-denatured gradient gel electrophoresis (PCR-DGGE). This hydrogen-producing system was operated at four different hydraulic retention times (HRTs) of 4, 2, 1, and 0.5 h and with an influent glucose concentration of 20 g chemical oxygen demand/l. According to the PCR-DGGE analysis, bacterial community structures were mainly composed of Clostridium sp. (possibly Clostridium pasteurianum), Klebsiella oxytoca, and Streptococcus sp. Significant increase of Clostridium/total cell ratio (68%) was observed when the reactor was operated under higher influent flow rate. The existence of Streptococcus sp. in the reactor became more important when operated under a short HRT as indicated by the ratio of Streptococcus probe-positive cells to Clostridium probe-positive cells changing from 21% (HRT 4 h) to 38% (HRT 0.5 h). FISH images suggested that Streptococcus cells probably acted as seeds for self-flocculated granule formation. Furthermore, combining the inspections with hydrogen production under different HRTs and their corresponding FISH analysis indicated that K. oxytoca did not directly contribute to H₂ production but possibly played a role in consuming O₂ to create an anaerobic environment for the hydrogen-producing Clostridium.     

厌氧颗粒污泥微生物群落结构与功能的研究进展

厌氧颗粒污泥(anaerobicgranularsludge,AnGS)是由多种功能微生物组成的自固定化聚集体,具有容积负荷高、工艺简单、剩余污泥产量低等优点,在废水处理领域中显示出巨大的技术和经济潜力,被认为是一种很有前景的低碳废水处理工艺。本文系统总结了近年来厌氧颗粒污泥微生物结构和功能的研究成果,从微生物学角度讨论了厌氧颗粒污泥形成及稳定的影响因素,并对今后厌氧颗粒污泥的研究进行了展望,以期为后续厌氧颗粒污泥技术的深入研究和实际工程应用提供参考。