一株甲烷利用菌的分离及其在甲烷气体测定中的应用

从山西太原晋阳湖水样中分离得到一株能以甲烷为唯一碳源生长的菌株ME16.气相色谱分析表明ME16菌株能利用甲烷.ME16菌株的16S rDNA 序列与铜绿假单胞菌(Pseudomonasaeruginosa,ATCC 10145,AF094713)相似性为99%.该菌株最适培养条件为30℃、2%接种量、25%甲烷含量和培养基pH为6.0.用电化学法研究了ME16固定化细胞体系中不同含量甲烷对溶氧的响应时间以及溶氧变化与甲烷含量的关系.结果表明,加入固定化细胞后.溶氧变化在100s内达到平衡,溶氧消耗量与通入甲烷气体含量在0～16%呈线性关系,相关系数为0.9954.对样品气体8次测量,RSD为3.34%,表明该反应体系重现性良好,为该菌株进一步研究甲烷传感器奠定基础.     

一株可利用甲烷的克雷伯氏菌的分离及其在甲烷检测中的应用

从山西太原水稻田土壤中,分离得到一株能以甲烷为唯一碳源和能源生长的菌株C611。通过生理生化特征及16SrDNA序列分析,该菌株初步鉴定为克雷伯氏菌(Klebsiella sp.)。采用响应面法优化了该菌株利用甲烷的培养条件,得到最佳培养条件为:温度24.4oC、接种量为6.7%、甲烷含量25%。以C611固定化细菌和溶氧响应仪为体系,采用电化学法研究了不同含量甲烷的响应时间以及溶氧变化与甲烷含量的关系。结果表明,菌株C611能利用甲烷,该反应体系对0～10%甲烷气体测定的响应时间小于100s;溶氧消耗量与通入甲烷气体含量呈线性关系,拟合系数(R2)为0.9994。以3%甲烷气体样品进行8次测量,测定平均值为3.09%,RSD为3.48%,相对误差为3%。表明该反应体系重现性良好,为该菌株进一步研究甲烷传感器奠定基础。     

一株高效铁锰氧化细菌P1的分离鉴定及氧化条件优化

利用富集培养技术从富含铁锰的地下水井淤泥中分离得到1株能够氧化铁锰的细菌,命名为P1。经形态特征、生理生化特征和16SrDNA序列分析,将菌株P1鉴定为蜡状芽孢杆菌(Bacilluscereus)。利用单因素实验探讨菌株P1的生长及氧化特性;采用响应面分析方法考察接种量、温度、pH值3个因素对菌株P1氧化特性的影响,进一步优化菌株的氧化条件。结果表明,菌株P1的最佳氧化条件:温度28.54℃,pH7.23,接种量4.35%。在此条件下,菌株P1在锰含量为200mg/L、铁含量为800mg/L的选择性培养液中培养3d后,锰氧化率达93%以上,铁氧化率达100%。     

氧化亚铁硫杆菌的分离及其培养条件优化

目的:获得可应用于烟气脱硫的菌株,并对其培养条件进行优化.方法:从化工厂取土样分离氧化亚铁硫杆菌,分析分离菌株的形态学特征、培养特征及16S rDNA序列,确定菌株的分类地位.通过单因子实验,对培养基中主要成分硫酸亚铁和硫酸铵的浓度进行优化.利用SAS软件中的Box-Behnken法设计实验,通过响应面分析对初始pH、温度、接种量、装液量4个因素进行优化.结果:获得菌株N16,经鉴定为嗜酸性氧化亚铁硫杆菌(Acidithiobacillus ferrooxidans).确定FeSO_4·7H_2O和(NH_4)_2SO_4的最适添加量分别为60/L和1g/L.确定菌株最适培养条件为:初始pH 1.8,温度28℃,转速150r/min,接种量15%,装液量30mL.在最适培养墓及培养条件下,菌株N16的亚铁氧化率可达99.78%.结论:分离得到的菌株适合于微生物法烟气脱硫的应用.     

一株异养型细菌对无机硫化物的降解特性和培养条件优化

畜禽屠宰加工、鱼粉饲料加工等一些食品工业生产过程中会释放出大量的硫化氢恶臭气体,导致周边环境的严重污染。为实现以培养异养型细菌脱除硫化氢气体的目的,取分离到的异养脱硫细菌XJ-2,通过诱变筛选得到一株高效脱硫菌株ZJNB-B3,其脱硫率达97%。基于形态学研究、API 50 CHB生理生化鉴定及16S r RNA基因测序,鉴定该菌为蜡状芽胞杆菌Bacillus cereus ZJNB-B3。该菌Gen Bank登录号为MF679650。降解特性研究表明,ZJNB-B3菌株对有毒的硫化物有较高耐受性,耐受上限高达300 mg/L。采用响应面法优化环境因素对菌株降解硫化物效率的影响,得到在最适培养温度30℃下,初始S~2–浓度为211.8 mg/L、初始p H值6.72、接种量为5.04%时,菌株氧化脱硫效果最显著,经过实测在48 h产生的硫酸盐浓度为63.8 mg/L,脱硫率达97.3%。菌株在氧化硫化物时不会产生硫酸抑制菌株的生长,可以在p H值温和的环境条件下脱硫,因此,该菌有较高的工业应用价值。本研究为异养型细菌应用于工业反应器脱除硫化氢恶臭气体提供了小试研究基础。     

一株脂肪酶产生菌的筛选及产酶条件优化研究

通过利用溴甲酚紫显色培养基初筛和酶活测定法复筛得到产脂肪酶的一株细菌HP2,经形态学观察和生理生化测定初步鉴定该菌株为不动杆菌属。并对该菌株的摇床培养产酶条件进行了初步研究,采用正交试验对HP2菌株发酵产脂肪酶的条件进行了优化,得到最佳发酵条件为初始pH为7.7,培养温度为35℃,接种量(V/V)为1.5%,发酵周期为48 h,酶活力达到129.7 U/mL。     

抑氨菌筛选鉴定、培养条件优化及在鸡粪除臭中的应用

目的筛选能抑制鸡粪中恶臭气体NH3释放的亚硝化、硝化细菌菌株。方法以亚硝化、硝化细菌培养基为筛选培养基筛选菌株,然后将菌株分别以10%(v/m,下同)的接种量接种到鸡粪中,测定其对鸡粪中NH3释放量的影响,从中筛选出可减少NH3释放的菌株。根据菌株的形态特征和16S rDNA序列分析对其进行鉴定。通过自动发酵系统对菌株培养温度、pH、通气量及转速四个因素进行正交优化。结果通过筛选得到两株细菌YF1和YS2,经鉴定分别为假单胞菌属(Pseudomonas sp.)和中华根瘤菌属(Sinorhizobium sp.)。菌株YF1最适培养条件为温度28℃,pH 7.0,通气量5 L/min,转速200 r/min;菌株YS2最适培养条件为温度30℃,pH6.5,通气量5 L/min,转速300 r/min。温度、pH、接种量和通气量对YF1、YS2影响均极显著(P0.01)。YF1和YS2单独按10%剂量接种分别使鸡粪中NH3的释放量降低26.0%和28.4%,而两菌1∶1混合接种可使NH3释放量降低75.6%。结论 YF1和YS2是抑制鸡粪中NH3释放的优良菌株。     

氧化亚铁硫杆菌的分离鉴定及培养条件优化

[目的]获得可用于浸矿的菌株,对其培养条件进行优化.[方法]从成都热电厂采集土样中分离得到一株菌株,分析该菌株的形态学特征、培养特征及16S rDNA序列,确定菌株的分类地位.利用Design-Expert软件中的Box-Behnken法设计实验,通过响应面分析对初始pH值、温度、接种量和装液量4个因素进行优化,确定其最适培养条件.[结果]获得菌株Z1,该菌为革兰氏阴性菌,短杆状,经16S rDNA鉴定为嗜酸性氧化亚铁硫杆菌(Acidithiobacillus ferrooxidans,简称At.f).确定菌株最适培养条件为:pH 1.8、温度30℃、接种量14％、装液量250 mL摇瓶装60 mL培养液.在此条件下,Z1的亚铁氧化率可达99.7％.[结论]Z1菌株适合于生物浸矿的应用.     

降解豆粕菌株的筛选及其发酵工艺研究

以脱脂豆粕粉为原料,接入产蛋白酶能力较强的菌株进行发酵,通过菌株所产蛋白酶作用于豆粕粉中的大豆蛋白将其水解为大豆多肽。以蛋白酶活力及水解度为指标逐步筛选降解豆粕的菌株,获得菌株CHD16;以水解度作为指标,对菌株CHD16发酵降解豆粕的条件进行了优化。通过液体发酵探讨菌株CHD16适宜的培养基组成、接种时间、接种量与发酵时间。结果表明：在豆粕含量11%,蔗糖含量2%的液体发酵培养基中接种3%的菌龄为21h的液体种子,于温度40℃、转速120r/min条件下发酵48h,豆粕蛋白的水解度可达58%,比条件优化前的水解度提高了88%。     

褐藻胶降解菌株S10鉴定及产酶条件优化

探讨了褐藻胶降解菌株S10的生长条件及其对产褐藻胶降解酶活力的影响。以分离自海参肠道的褐藻胶降解菌株S10为研究对象，采用形态学观察结合16S rDNA序列分析，对菌株S10进行菌种鉴定并对其生理生化特性进行测定。以降解酶活力为指标，利用单因素、Plackett-Burman(PB)和响应面法对培养基成分和培养条件进行优化；最后对优化前后的菌株生长量、产酶活力和粗酶液稳定性进行分析。结果表明，菌株S10属于溶藻孤菌(Vibrio algindyticus);当pH 7、接种量2%(体积分数)、装液量150 mL、温度26℃、转速150 r/min、NaCl 3%(质量分数，下同)、海藻酸钠含量1.12%、硫酸铵含量0.44%、培养时间35.95 h条件下，褐藻胶降解酶活力最大(188.18 U/min)。优化后产酶活力提高30%;4℃低温更有利于该酶保存。综上，优化后的菌株S10产褐藻胶降解酶活力较高，能更好地用于降解褐藻胶，可为提高褐藻胶的利用率和进一步发掘褐藻胶寡糖的利用价值提供参考。     

Characterization of a methane‐utilizing strain and its application for monitoring methane

Aims: To explore new resources of methane‐utilizing micro‐organism and develop a microbial biosensing system for monitoring methane released from natural and semi‐natural ecosystems. Methods and Results: A methane (CH₄)‐utilizing bacterial strain was isolated from paddy soil using CH₄ as the sole carbon source and identified as Klebsiella sp. ME17 by phenotyping and 16S rDNA sequence analysis. The efficiency of CH₄ utilization of strain ME17 was 83·2% by gas chromatography analysis. A microbial biosensing system for CH₄ detection was developed by combining immobilized cells of strain ME17 with a dissolved oxygen sensor. It was found that response time of the system to CH₄ was <90s. The dissolved O₂ consumption increased with increasing CH₄ from 0% to 16·0% (v/v) demonstrating a positive linear relationship with a low detection limit of 0·2% (v/v). The relative standard deviation is 3·48%. Conclusions: Klebsiella sp. ME17 isolate is capable of utilizing CH₄. The microbial biosensing system of strain ME17 has been successfully applied to measure standard CH₄ sample with satisfactory results. Significance and Impact of the Study: This study suggests that certain strains of Klebsiella genus are capable of utilizing CH₄. Our proposed method appears very attractive for CH₄ measurement in coal mine.     

一株红景天内生细菌的筛选及初步研究

【目的】从红景天根部筛选并鉴定一株产酪醇的细菌,初步研究其产酪醇特性,为寻找红景天替代资源提供新途径。【方法】用NA培养基从大花红景天根部中分离内生细菌,通过薄层层析(TLC)、高效液相色谱(HPLC)、气相色谱-质谱联用(GC-MS)筛选出产量最大的菌株,经菌落形态分析、革兰氏染色分析及16S rRNA基因序列分析其分类学地位。单因素实验确定初始pH、培养温度、发酵时间及接种量对菌株产酪醇活力的影响。【结果】从大花红景天根部分离出14株内生细菌,其中8株能产酪醇,筛选出酪醇产量最大的菌株B3,经菌落形态分析、革兰氏染色分析及16S rRNA基因序列分析初步鉴定为水生拉恩氏菌(Rahnella aquatilis)。研究其发酵条件,其最适pH为6.0,最适温度为32 °C,最佳发酵时间为42 h,最佳接种量为15%。在最适发酵条件下,用改良NA培养基发酵,B3菌株酪醇的产量为15.68 mg/L。【结论】B3菌株是一株具有产酪醇能力的细菌,在最适发酵条件下酪醇产量达到15.68 mg/L,具有潜在的开发价值。     

利用甘蔗糖蜜酒精发酵液生产腐植酸的菌种鉴定及发酵条件研究

从土壤中筛选出一株适合用甘蔗糖蜜酒精发酵液生产腐植酸的菌株H812。单因素实验和正交实验结果表明,该菌株培养的最适酒精发酵液浓度为16°Bx,最适培养条件为:时间8d、温度34℃、摇床转速200r/min、初始pH7.0、接种量12%和装液量50ml/250ml,其中温度对发酵产品影响显著。在优化的条件下,腐植酸产量为38.12 g/L,较优化前提高了148.34%。对H812菌株进行形态特征分析以及ITS序列分析,推测该菌株为曲霉属真菌。     

Screening for an oil‐removing microorganism and oil removal from waste silk by pure culture fermentation

The presence of oil is the major limitation to the regeneration of spun silk from waste silk. A pure culture fermentation process was developed to remove oil from waste silk. Fourteen strains were isolated from natural fermentation liquor of waste silk. The strain D3 showed highest lipase activity and oil‐removing ability. This strain was identified as Rhodococcus sp. on the basis of morphological and biochemical characteristics and 16S rRNA sequence analysis. The strain D3 was used to remove oil from waste silk by pure culture fermentation. The effects of various parameters on oil removal were investigated. A pH of 7.0, a temperature of 35–40°C, an incubation time of three days and an inoculum of 10% were optimum conditions for removing oil from waste silk by stain D3. This study shows that pure culture fermentation is a promising process to improve the oil removal of waste silk.     

Culture condition improvement for whole-cell lipase production in submerged fermentation by Rhizopus chinensis using statistical method

Rhizopus chinensis CCTCC M201021 was a versatile strain capable of producing whole-cell lipase with synthetic activity in submerged fermentation. In order to improve the production of whole-cell lipase and study the culture conditions systematically, the combination of taguchi method and response surface methodology was performed. Taguchi method was used for the initial optimization, and eight factors viz., maltose, olive oil, peptone, K2HPO4, agitation, inoculum size, fermentation volume and pH were selected for this study. The whole-cell lipase activity yield was two times higher than the control experiment under initial optimal conditions, and four significant factors (inoculum, olive oil, fermentation volume and peptone) were selected to test the effect on the lipase production using response surface methodology. The optimal fermentation parameters for enhanced whole-cell lipase yield were found to be: inoculum 4.25 x 10(8) spores/L, olive oil 2.367% (w/v), fermentation volume 18 mL/250 mL flask, peptone 4.06% (w/v). Subsequent experimental trails confirmed the validity of the model. These optimal culture conditions in the shake flask led to a lipase yield of 13875 U/L, which 120% increased compare with the non-optimized conditions.     

蛋白酶产生菌LN01水解玉米黄粉蛋白的研究

玉米黄粉中含有约质量分数60%的蛋白质,但很难直接应用,必须进行预处理.本文以玉米黄粉为原料,利用蛋白酶产生菌LN01进行液体发酵,分别研究了液体接种量、初始pH、培养温度和培养时间等因素对LN01菌株水解玉米黄粉蛋白的影响.实验结果表明,LN01菌株水解玉米黄粉蛋白的最佳发酵条件为:初始pH值为6.0,液体种子接种量...     

Anaerobic degradation of cellulose by mixed culture

A mixed culture in which cellulose is capable of being converted to methane and carbon dioxide was obtained from an inoculum procured from a sewage-treatment plant and maintained in a synthetic medium containing tissue paper and an inorganic salt and vitamin mixture. The culture was tested for its ability to degrade 12 different paper and cotton products under batch conditions in 3-l anaerobic fermenters. This culture degraded 6-8 mmol/l per week of cellulose, expressed as glucose equivalents, with total gas yields of 0.3 m3/kg of cellulose degraded. The gas produced contained between 56 and 59% of methane. Maximum cellulose degradation occurred at chemical oxygen demand:nitrogen:phosphorus level of 80:5:1 and was adversely affected by high stirring rate. Also the presence of higher proportions of lignin in cellulose products adversely affected the ability of this culture to degrade cellulose.