Penicillin G production by immobilized fungal vesicles

Summary The activity of penicillin G production was compared in a well defined medium by native vesicles as well as by calcium alginate gel immobilized vesicles isolated from the protoplasts of Penicillium chrysogenum PQ-96. The activity yield of the immobilized vesicles was 44% in comparison with native vesicles. After 60 h of storage at 4° C the native vesicles showed a rapid decrease in penicillin G production. The storage stability of these vesicles was improved after entrapment inside the calcium alginate gel. After 240 h of storage 1 mg of immobilized vesicular protein catalyzed the production of about 140 nmoles of penicillin G in 1 h.     

疏水吸附固定化天冬氨酸酶及其性质的研究

本文论述了一种N-烷基琼脂珠衍生物的合成方法,研究了pH,离子强度、载体上疏水基团含量等因素对载体吸附天冬氨酸酶的影响以及固定化天冬酸酶的性质。结果表明邻甲苯胺基琼脂珠在pH5.5,0.1mol/L磷酸缓冲液(含有0.25mol/LKCL)中,每克湿载体可吸附15—25mg酶蛋白,酶活力回收达90％以上。固定化酶的性质有所改变,其热稳定性和操作稳定性明显增强。 固定化天冬氨酸酸柱可以用于连续化生产L-天冬氮酸,在pH8.0,1.0mol/L及丁烯二酸铵(含0.02mol/L MgCl_2),30℃条件下,以空间流速SV=3.5操作2个月,固定化酶活力仍保持79.5％。     

Structural investigation of the thermostability and product specificity of amylosucrase from the bacterium Deinococcus geothermalis

Amylosucrases are sucrose-utilizing α-transglucosidases that naturally catalyze the synthesis of α-glucans, linked exclusively through α1,4-linkages. Side products and in particular sucrose isomers such as turanose and trehalulose are also produced by these enzymes. Here, we report the first structural and biophysical characterization of the most thermostable amylosucrase identified so far, the amylosucrase from Deinoccocus geothermalis (DgAS). The three-dimensional structure revealed a homodimeric quaternary organization, never reported before for other amylosucrases. A sequence signature of dimerization was identified from the analysis of the dimer interface and sequence alignments. By rigidifying the DgAS structure, the quaternary organization is likely to participate in the enhanced thermal stability of the protein. Amylosucrase specificity with respect to sucrose isomer formation (turanose or trehalulose) was also investigated. We report the first structures of the amylosucrases from Deinococcus geothermalis and Neisseria polysaccharea in complex with turanose. In the amylosucrase from N. polysaccharea (NpAS), key residues were found to force the fructosyl moiety to bind in an open state with the O3' ideally positioned to explain the preferential formation of turanose by NpAS. Such residues are either not present or not similarly placed in DgAS. As a consequence, DgAS binds the furanoid tautomers of fructose through a weak network of interactions to enable turanose formation. Such topology at subsite +1 is likely favoring other possible fructose binding modes in agreement with the higher amount of trehalulose formed by DgAS. Our findings help to understand the inter-relationships between amylosucrase structure, flexibility, function, and stability and provide new insight for amylosucrase design.     

Starch synthases and starch branching enzymes from Pisum sativum

Concentrations of ADPglucose:α-1,4-glucan-4-glucosyltransferase (starch synthase) and α-1,4 glucan: α-1,4-glucan-6-glycosyltransferase (branching enzyme) from developing seeds of Pisum sativum were measured. Primed starch synthase activity increased from 8 to 14 days after anthesis and decreased by 50 % at 26 days. Citrate-stimulated starch synthase activity was highest at 10 days after anthesis decreasing to low levels by 22 days. Branching enzyme activity increased from 8 to 18 days after anthesis and decreased little by 26 days. Two fractions of starch synthase were recovered by gradient elution from DEAE-cellulose of extracts from 12- and 18-day-old seeds. The two fractions differed in primer specificity, K_m for ADPG and relative amounts of citrate-stimulated activity. A major and minor fraction of branching enzyme were observed in extracts from both 12- and 18-day-old seeds. Marked differences in the relative abilities ofthe two branching enzyme fractions to stimulate phosphorylase and to branch amylose as well as pH optima were found. Although the content of the starch synthase and branching enzyme fractions varied with seed age, little difference was seen in the properties of chromatographically similar fractions. Therefore, the changes in starch synthase and branching enzyme activity during pea seed development resulted from changes in the concentrations of a few enzyme forms, but not the appearance of different enzyme forms.     

Immobilization of the α-amylase of Bacillus amyloliquifaciens TSWK1-1 for the improved biocatalytic properties and solvent tolerance

The α-amylase of Bacillus amyloliquifaciens TSWK1-1 (GenBank Number, GQ121033) was immobilized by various methods, including ionic binding with DEAE cellulose, covalent coupling with gelatin and entrapment in polyacrylamide and agar. The immobilization of the purified enzyme was most effective with the DEAE cellulose followed by gelatin, agar and polyacrylamide. The K _m increased, while V _max decreased upon immobilization on various supports. The temperature and pH profiles broadened, while thermostability and pH stability enhanced after immobilization. The immobilized enzyme exhibited greater activity in various non-ionic surfactants, such as Tween-20, Tween-80 and Triton X-100 and ionic surfactant, SDS. Similarly, the enhanced stability of the immobilized α-amylase in various organic solvents was among the attractive features of the study. The reusability of the immobilized enzyme in terms of operational stability was assessed. The DEAE cellulose immobilized α-amylase retained its initial activity even after 20 consequent cycles. The DEAE cellulose immobilized enzyme hydrolyzed starch with 27 % of efficiency. In summary, the immobilization of B. amyloliquifaciens TSWK1-1 α-amylase with DEAE cellulose appeared most suitable for the improved biocatalytic properties and stability.     

Isolation and properties of prostaglandin H synthetase immobilized in insoluble polyelectrolyte complexes

Immobilization of prostaglandin-H-synthetase (EC 1.14.99.1) of the microsomal fraction of ram vesicular gland in the microparticles of insoluble polyelectrolyte complexes by non-covalent incorporation was studied. It was shown that immobilization occurs with a high efficiency and high activity yield (40-70%). Non-specific reversible inhibition of the enzyme by the polycationic component of the complex was demonstrated. The dependencies of activity of the native and immobilized enzymes on pH, temperature and substrate (adrenaline and arachidonic acid) were studied. The immobilized enzyme had an increased thermal stability as compared to the native one; the thermoinactivation rate constant was decreased 3-7 times. The biexponential type of the curve of the rependence of activity vs. time for the native enzyme and the transformation of the curve into a simple exponential form for the immobilized enzyme were observed.     

Preparation of immobilized alpha-amylase covalently attached to granular polyacrylonitrile

In this report, alpha-Amylase originating from Bacillus subtilis (liquefying type) was immobilized on partially imidoesterized polyacrylonitrile (PAN) by covalent bonding. For the preparation of immobilized alpha-amylase, which has a high activity and high stability to repeated use, the optimum conditions for the preparation reaction were investigated. The optimum conditions for the preparation reaction were quantified on the basis of the enzymatic activity, the preservation of the activity during repeated use in batch process and the protein content on the support. Further-more, enzymatic properties of immobilized alpha-amylase prepared at optimum conditions were compared with the native enzyme. The optimum temperature and reaction time for the imidoes-terification reaction were 30 degrees c and 6 h, respectively, whereas those of the amidinatin reaction were 30-40 degrees C and more than 3 h, respectively; the optimum pH range was 9-10. Immobilized alpha-amylase prepared at the optimum conditions was very stable against the repeated use and had more than 90% of relative to activity of the first use after the tenth procedure. The initial reaction rate of immobilized alpha-amylase was lower than native alpha-amylase, but same amount of reducing sugars were produced after the reaction passed for more than 90 min. The immobilized alpha-amylase was less stabel at the high temperature and the more basic media. However, after long incubation time, immobilized alpha-amylase was more stable than the native enzyme in exposure to heat and a storng base.     

Mixture design of starchy substrates hydrolysis by an immobilized glucoamylase from Aspergillus brasiliensis

Starch has great importance in human diet, since it is a heteropolymer of plants, mainly found in roots, as potato, cassava and arrowroots. This carbohydrate is composed by a highly-branched chain: amylopectin; and a linear chain: amylose. The proportion between the chains varies according to the botanical source. Starch hydrolysis is catalyzed by enzymes of the amilolytic system, named amylases. Among the various enzymes of this system, the glucoamylases (EC 3.2.1.3 glucan 1,4-alpha-glucosidases) are the majority because they hydrolyze the glycosidic linkages at the end of starch chains releasing glucose monomers. In this work, a glucoamylase secreted in the culture medium, by the ascomycete Aspergillus brasiliensis, was immobilized in Dietilaminoetil Sepharose-Polyethylene Glycol (DEAE-PEG), since immobilized biocatalysts are more stable in long periods of hydrolysis, and can be recovered from the final product and reused for several cycles. Glucoamylase immobilization has shown great thermal stability improvement over the soluble enzyme, reaching 66% more activity after 6?h at 60?°C, and 68% of the activity after 10 hydrolysis cycles. A simplex centroid experimental mixture design was applied as a tool to characterize the affinity of the immobilized enzyme for different starchy substrates. In assays containing several proportions of amylose, amylopectin and starch, the glucoamylase from A. brasiliensis mainly hydrolyzed the amylopectin chains, showing to have preference by branched substrates.     

尼龙网固定化果胶酶的制备及其性质研究

用尼龙网作载体,经3-二甲氨基丙胺活化,用戊二醛将果胶酶固定化。所得固定化酶Km值与自然酶接近;对温度的稳定性有较大的提高,100℃保温30min才能使其失活。固定化酶在较宽的pH范围内能保持其正常活力,它对金属离子抑制剂的耐受性有较显著的提高,用0.5％果胶溶液作底物,重复使用10次后酶活力保留44％。固定化果胶酶与自然酶相比较,对不同果汁的澄清效果不同。固定化果胶酶在无保护剂存在的条件下,室温放置四个月活力不减少。     

The structure and function of ribonuclease T1 XXIV. Preparation and properties of a stable water-insoluble polyacrylamide derivative of ribonuclease T1.

Ribonuclease T1 [EC 3.1.4.8] was coupled to a water-insoluble cross-linked polyacrylamide (Enzacryl AH) by the acid azide method. The immobilized enzyme exhibited about 45% and 77% of the original activity toward yeast RNA and 2', 3-cyclic GMP, respectively, as substrates. Although the specific activity was lowered by the coupling, the immobilized enzyme was found to be far more stable to heat and extremes of PH than the native enzyme. The immobilized enzyme was active toward RNA even above pH 9 (at 37 degree C) or above 60 degree C (at pH 7.5), where the native enzyme was inactive. The immobilized enzyme retained much of its activity as assayed at 37 degree C after incubation in the range of pH 1 to 10 at 37 degree C, or after heating at 100 degree C (at pH 7.5) under conditions where the native enzyme was inactivated to a considerable extent. The enzyme derivative could be repeatedly recovered and reused without much loss of activity. The active site glutamic acid-58 in the immobilized enzyme appeared to be nearly as reactive with iodoacetate as that in the native enzyme.     

磁性聚乙二醇载体固定化α淀粉酶的研究

α淀粉酶广泛应用于粮食加工、食品、酿造、发酵、纺织品和医药工业［1］．由于固定化酶的优点,国内外研究人员对固定化糖化酶［2,3］和固定化α淀粉酶[4]的制备及在淀粉酶法生产葡萄糖方面的应用作了大量的研究,显示了工业应用前景．然而,迄今为止,用磁性载体固定化α淀粉酶尚未见报道．我们用磁性聚乙二醇胶体粒子作载体,制备出具有磁响应性强、稳定性强、活力高的固定化α淀粉酶．由于具有磁响应性,可借助外部磁场方便简单地回收酶,为该酶工业化生产葡萄糖提供了一种新的途径．而且,由于磁性的优点,也为该酶在食品、医药、纺织…     

1,4-alpha-Glucan phosphorylase form Klebsiella pneumoniae covalently couple on porous glass.

A simplified procedure for the preparation of 1,4-alpha-glucan phosphorylase from Klebsiella pneumoniae is described. An 80-fold purification is achieved in two steps with an overall yield of about 50%. The specific activity of the homogeneous enzyme protein is 17.7 units/mg. Compared with glycogen phosphorylase from rabbit muscle the enzyme from K. pneumoniae shows a markedly higher stability against deforming and chaotropic agents. The 1,4-alpha-glucan phosphorylase was covalently bound to porous glass particles by three different methods. Coupling with glutaraldehyde gave the highest specific activity, i.e., 5.6 units/mg of bound protein or 133 units/g of glass with maltodextrin as substrate. This corresponds to about 30% of the specific activity of the soluble enzyme. With substrates of higher molecular weight, such as glycogen or amylopectin, lower relative activity was observed. The immobilized enzyme preparations showed pH activity profiles which were slightly displaced to higher values and exhibited an increased temperature stability.     

Catechol modification and covalent immobilization of catalase on titania submicrospheres

In this article, chemical modification with catecholic derivative in solution and subsequent immobilization of catalase (CAT) on titania submicrospheres (450–500 nm) were described. Catalase was first reacted with 3-(3,4-dihydroxyphenyl) propionic acid activated via 1-ethyl-3-[3-dimethylaminopropyl] carbodiimide hydrochloride (EDC) and N-hydroxysuccinimide (NHS) coupling chemistry. The above chemically modified CAT bearing catechol groups was then covalently bound to the surface of titania through the facile chelation reaction between the catechol groups and titania. The immobilized CAT retained 60% catalytic activity with a high loading capacity of 500 mg/g titania. Meanwhile, the immobilized CAT displayed enhanced operational stability, thermal stability and storage stability compared with native, modified CAT counterparts. In repeated batches of decomposition of hydrogen peroxide, after 10 and 19 cycles, the immobilized CAT maintained about 90% and 75% of its initial activity, respectively.     

Immobilization of penicillin acylase on acrylic carriers

Penicillin acylase obtained from E. Coli (E. C. 3.5.1.11) was covalently bound via glutaric aldehyde to acrylic carriers crosslinked with divinylbenzene or ethylene glycol dimethacrylate. The best enzymatic preparation was obtained by using ethyl acrylate/ ethylene glycol dimethacrylate copolymer. 1 cm³ of the carrier bound 6.4 mg of protein, having 72% activity in relation to the native enzyme. The preparation lost only 10% of its initial activity after 100 d of storage at 4°C. A negligible effect of immobilization on the enzyme activity at different temperatures or pH as well as significant increase of the stability of the immobilized enzyme at elevated temperatures were observed.Abbreviations BA butyl acrylate - AE ethyl acrylate - PA penicillin acylase - 6-APA 6-aminopenicillanic acid - EGDMA ethylene glycol dimethacrylate - DVB divinylbenzene     

A chip-based method for studying the effects of exogenous proteins on neuronal axons

It has been reported that the activity of protein improved when it was adsorbed inside the pores of mesoporous silica (MPS). The current study investigated the activity of immobilized avidin to the biotin on MPS with various pore sizes (diameter=2.4-45.0 nm). The binding amount of immobilized avidin to biotin is 123 to 160 ng biotin/10 μg avidin on 2.7- to 5.4-nm pore MPS, but that on 12- to 45-nm pore MPS was markedly decreased (33-42 ng biotin/10 μg). Moreover, the binding amount was approximately 2- and 3-fold higher on the glycidoxypropyl (Gly)-functionalized 5.4- and 45-nm pore MPS in comparison with methyl (Me)-functionalized 5.4- and 45-nm pore MPS, respectively. Furthermore, avidin immobilized in native and Gly-grafted 45-nm pore MPS retained more than 70% and 50% binding activity to biotin, respectively, after incubating at 90°C for 3 h. In contrast, the activity was greatly reduced in the native and Gly-grafted 5.4-nm pore MPS under the same conditions (<36.9%). The immobilization also protected against effects of 0.01 M HCl and 50% MeOH; all of immobilized avidin proteins showed high activity (>50%) with biotin compared with that observed with free avidin (MeOH [<18.2%] and HCl [<32.7%]).     

Stability of immobilized maltotetraose-forming amylase from Pseudomonas stutzeri

The stability of immobilized maltotetraose (G(4))-forming amylase (1,4-alpha-D-glucan maltoteraohydrolase, EC 3.2.1.60) from Pseudomonas stutzeri was investigated in both batch and continous processes. The inactivation process of the immobilized enzyme seemed to obey first-order kinetics, and the immobilized enzyme became more stable when coexisting with 20-30 wt % substrate and calcium ions. From intensive studies on the operational stability in the continuous process, the apparent half-life of G(4) productivity in a constant-flow system was mainly affected by the reaction temperature, substrate concentration, and initial immobilized enzyme activity. A new factor, immobilized enzyme stability factor f(s), was proposed to evaluate the half-life of the immobilized enzyme system.     

Kinetics and stability of immobilized chicken liver xanthine dehydrogenase.

Xanthine dehydrogenase (EC 1.2.1.37) was isolated from chicken livers and immobilized by adsorption to a Sepharose derivative, prepared by reaction of n-octylamine with CNBr-activated Sepharose 4B. Using a crude preparation of enzyme for immobilization it was observed that relatively more activity was adsorbed than protein, but the yield of immobilized activity increased as a purer enzyme preparation was used. As more activity and protein were bound, relatively less immobilized activity was recovered. This effect was probably due to blocking of active xanthine dehydrogenase by protein impurities. The kinetics of free and immobilized xanthine dehydrogenase were studied in the pH range 7.5-9.1. The Km and V values estimated for free xanthine dehydrogenase increase as the pH increase; the K'm and V values for the immobilized enzyme go through a minimum at pH 8.1. By varying the amount of enzyme activity bound per unit volume of gel, it was shown that K'm is larger than Km are result of substrate diffusion limitation in the pores of the support material. Both free and immobilized xanthine dehydrogenase showed substrate activation at low concentrations (up to 2 microM xanthine). Immobilized xanthine dehydrogenase was more stable than the free enzyme during storage in the temperature range of 4-50 degrees C. The operational stability of immobilized xanthine dehydrogenase at 30 degrees C was two orders of magnitude smaller than the storage stability, t 1/2 was 9 and 800 hr, respectively. The operational stability was, however, better than than of immobilized milk xanthine oxidase (t 1/2 = 1 hr). In addition, the amount of product formed per unit initial activity in one half-life, was higher for immobilized xanthine dehydrogenase than for immobilized xanthine oxidase. Unless immobilized milk xanthine oxidase can be considerable stabilized, immobilized chicken liver xanthine dehydrogenase is more promising for application in organic synthesis.     

Immobilization and stabilization of α-galactosidase on Sepabeads EC-EA and EC-HA

α-Galactosidase from tomato has been immobilized on Sepabead EC-EA and Sepabead EC-HA, which were activated with ethylendiamino and hexamethylenediamino groups, respectively. Two strategy was used for the covalent immobilization of α-galactosidase on the aminated Sepabeads: covalent immobilization of enzyme on glutaraldehyde activated support and cross-linking of the adsorbed enzymes on to the support with glutaraldehyde. By using these two methods, all the immobilized enzymes retained very high activity and the stability of the enzyme was also improved. The obtained results showed that, the most stable immobilized α-galactosidase was obtained with the second strategy. The immobilized enzymes were characterized with respect to free counterpart. Some parameters effecting to the enzyme activity and stability were also analyzed. The optimum temperature and pH were found as 60 °C and pH 5.5 for all immobilized enzymes, respectively. All the immobilized α-galactosidases were more thermostable than the free enzyme at 50 °C. The stabilities of the Sepabead EC-EA and EC-HA adsorbed enzymes treated with glutaraldehyde compared to the stability of the free enzyme were a factor of 6 for Sepabead EC-EA and 5.3 for Sepabead EC-HA. Both the free and immobilized enzymes were very stable between pH 3.0 and 6.0 and more than 85% of the initial activities were recovered. Under the identical storage conditions the free enzyme lost its initial activity more quickly than the immobilized enzymes at the same period of time. The immobilized α-galactosidase seems to fulfill the requirements for different industrial applications.     

Immobilization of the exo-maltohexaohydrolase by the irradiation method

Exomaltohexaohydrolase (E.C.3.2.1.98) was immobilized by radiocopolymerization of some synthetic monomers which were mixed in various combinations. Irradiation was carried out while the mixture of monomers and enzymes was frozen in petroleum ether-dry-ice bath. Recovery of the immobilized enzyme was 44-75%.The optimum pH of the enzyme slightly shifted to the acidic side. The pH stability was improved remarkably by immobilization. The enzyme was stable retaining more than 90% of its original activity in the range pH 4-11. The optimum reaction temperature of the enzyme increased about 2 degrees C. Heat stability was also improved by immobilization, and that the enzyme retained about 40% of its original activity after treatment at 75 degrees C for 15 min. The immobilized enzyme was stable to the repeated use of 20 cycles. The K(m) value of the enzyme for short-chain amylose was almost the same as that of native enzyme. When soluble starch was used as the substrate, the K(m), value of the enzyme was three times as large as that of native enzyme. Effects of various metal ions and inhibitors on the immobilized enzyme were also studied compared to the native enzyme.     

Radioactive penicillin G production by immobilized fungal vesicles

Summary Radioactive penicillin G production from l-[1-¹⁴C]-valine (1.75 GBq · mmol^-1) by native and by calcium alginate gel immobilized mycelium of Penicillium chrysogenum PQ-96 in a medium for antibiotic production as well as by vesicles isolated from the protoplasts of the same strain in a well-defined reaction mixture was investigated. Specific radioactivity of the penicillin G produced by the native vesicles was 1.45 GBq · mmol^-1 and that of the antibiotic synthesized by the calcium alginate gel immobilized vesicles was 1.48 GBq · mmol^-1. By comparison, the specific radioactivity of penicillin G produced by native mycelium was 0.42 GBq · mmol^-1 and of that synthesized by the immobilized mycelium was 0.96 GBq · mmol^-1. Production of radioactive penicillin G by native and immobilized vesicles in repeated use was also investigated. At the beginning of the production phase, the radioactive penicillin G synthesized by the immobilized vesicles was 25 nmol · mg protein^-1 · h^-1 and decreased after 8 days to a level of 11 nmol · mg protein^-1 · h^-1. The half-life of the immobilized vesicles was 7 days. The native vesicles showed a rapid decrease in radioactive antibiotic production. In comparison, the penicillin G production in a repeated use of immobilized vesicles decreased during 40 days from 140 nmol · mg protein^-1 · h^-1 to 60 nmol · mg protein^-1 · h^-1. The half-life of the immobilized vesicles was 35 days. The native vesicles showed after 4 days a lack of activity of penicillin G production. The stability of immobilized mycelium or vesicles in the process of radioactive penicillin G production is discussed.