Carvacrol and Thymol Reduce Swine Waste Odor and Pathogens: Stability of Oils

An incomplete anoxic fermentation of livestock waste results in offensive odor emissions. Antimicrobial additives may be useful in controlling odor emissions and pathogens. Natural antimicrobial compounds, carvacrol or thymol at 16.75 mM (2.5 g/l) completely inhibited the production of the offensive odor compounds, isobutyrate, valerate, isovalerate, and cresol, and significantly reduced other short-chain volatile fatty acids and gas emissions from swine waste. Fecal coliforms were reduced from 6.3 × 10⁶ to 1.0 × 10³ cells per ml 2 days after treatment with carvacrol (13.3 mM) and were not detectable within 14 days. Total culturable anaerobic bacteria were reduced from 12.4 × 10¹⁰ to 7.2 × 10⁸ cells per ml after 2 days and were suppressed below this level for 28 days. Lactate production was not prevalent in untreated swine waste indicating that the microbial populations differ from those in cattle waste. Carvacrol and thymol were stable in swine waste under anoxic conditions for 62 days with 90 to 95% of the additive being recovered in the waste solids. In conclusion, carvacrol and thymol are not metabolized in anoxic swine waste and they are potentially useful in controlling odor emissions and pathogens in swine waste. Received: 22 March 2001 / Accepted: 14 May 2001     

Plant-derived oils reduce pathogens and gaseous emissions from stored cattle waste

Carvacrol and thymol in combination at 6.7 mM each completely inhibited the production of short-chain volatile fatty acids and lactate from cattle waste in anoxic flasks over 23 days. Fecal coliforms were reduced from 4.6 x 10(6) to 2.0 x 10(3) cells per ml 2 days after treatment and were nondetectable within 4 days. Total anaerobic bacteria were reduced from 8.4 x 10(10) to 1.5 x 10(7) cells per ml after 2 days and continued to be suppressed to that level after 14 days. If the concentration of carvacrol or thymol were doubled (13.3 mM), either could be used to obtain the same inhibitory fermentation effect. We conclude that carvacrol or thymol may be useful as an antimicrobial chemical to control pathogens and odor in stored livestock waste.     

Plant-Derived Oils Reduce Pathogens and Gaseous Emissions from Stored Cattle Waste

Carvacrol and thymol in combination at 6.7 mM each completely inhibited the production of short-chain volatile fatty acids and lactate from cattle waste in anoxic flasks over 23 days. Fecal coliforms were reduced from 4.6 × 10⁶ to 2.0 × 10³ cells per ml 2 days after treatment and were nondetectable within 4 days. Total anaerobic bacteria were reduced from 8.4 × 10¹⁰ to 1.5 × 10⁷ cells per ml after 2 days and continued to be suppressed to that level after 14 days. If the concentration of carvacrol or thymol were doubled (13.3 mM), either could be used to obtain the same inhibitory fermentation effect. We conclude that carvacrol or thymol may be useful as an antimicrobial chemical to control pathogens and odor in stored livestock waste.     

Effects of Chlorhexidine Diacetate on Ruminal Microorganisms

The objectives of this study were to examine the effects of chlorhexidine diacetate on growth and L-lactate production by Streptococcus bovis JB1 as well as the effects of this antimicrobial compound on the mixed ruminal microorganism fermentation. Addition of 1.8 μM chlorhexidine diacetate to glucose medium resulted in a lag in growth by S. bovis JB1, and growth was completely inhibited in the presence of 3.6, 9.0, and 18 μM chlorhexidine. When 6.2 μM chlorhexidine diacetate was added to glucose medium after 2 h of incubation, glucose utilization and L-lactate production by S. bovis JB1 were reduced. Phosphoenolpyruvate-dependent phosphorylation of ¹⁴C-glucose by toluene-treated cells of S. bovis JB1 was inhibited by increasing concentrations (1.8 to 18 μM) of chlorhexidine, whereas only the 18 μM concentration reduced the membrane potential (ΔΨ). Chlorhexidine diacetate was a potent inhibitor of L-lactate and methane production from glucose fermentation by mixed ruminal microorganisms. However, because chlorhexidine also decreased acetate and propionate concentrations and increased ammonia concentrations in mixed-culture incubations, this antimicrobial compound may have limited application as a ruminant feed additive. Received: 4 November 1997 / Accepted: 22 December 1997     

Microbial profiles, in vitro gas production and dry matter digestibility based on various ratios of roughage to concentrate

The study assessed the effects of different roughage to concentrate ratios on enteric methane production, rumen fermentation and microbial counts. These ratios were 80:20, 50:50, and 20:80 for diets 1, 2, and 3, respectively. No significant differences were observed in total gas production among diets; however, methane emissions increased (P?<?0.05) with increased roughage in diet. The pH was greater (P?<?0.05) in diet 1 compared to diets 2 and 3 (6.38 vs 6.17 and 6.07). In vitro dry matter digestibility increased with decreased roughage ratios (47.67, 61.67, 67.33 % for diets 1, 2 and 3, respectively). Similarly, total volatile fatty acids (mM/100 mL) also increased with decreased roughage ratios [diet 1 (5.38); diet 2 (6.30); diet 3 (7.37)]. Methanogen counts, total bacterial counts and protozoal counts were lower (P?<?0.05) in diet 3 compared to diet 1 and 2. However, total fungal counts were higher in diet 1 compared to diet 2 and 3. The results indicate that methane emission, enteric fermentation patterns, and change in methanogens population appear only with higher level of roughage. These findings are important for reducing methane without any impact on rumen performance.     

Quantitative Method for the Gas Chromatographic Analysis of Short-Chain Monocarboxylic and Dicarboxylic Acids in Fermentation Media

A method for the preparation and gas chromatographic analysis of the butyl esters of volatile (C-1-C-7) and nonvolatile (lactic, succinic, and fumaric) acids in microbial fermentation media is presented. Butyl esters were prepared from the dry salts of the acids. The esters were separated by temperature programming on a column of Chromosorb W coated with Dexsil 300 GC liquid phase and analyzed with a flame ionization detector. Apparent recoveries with butanol-HCl or butanol-H2SO4 as butylating agents were 80 to 90% for most acids. Chromatographic profiles of the butyl esters demonstrated that both volatile and nonvolatile acids can be detected and separated in 24 min on a single column. Standard calibration curves (peak area versus concentration) of the butyl esters were linear in the range of 5 to 40 mumol of acid per ml. The advantages of using an internal standard (heptanoic acid) for quantitating fatty acids in a mixture are given. Chromatograms of butylated fermentation media in which rumen anaerobic bacteria were grown illustrated that this method is useful for determining short-chain volatile and nonvolatile acids of toxonomic significance.     

Influence of supplemental endoglucanase or xylanase on volatile fatty acid production from ruminant feed by ruminal in vitro cultures

This study employed two commercial enzyme preparations to examine the effects of endoglucanase, xylanase or their combination on in vitro volatile fatty acid (VFA) production by ruminal microbial populations. Batch ruminal cultures were established with one of various feedstuffs or with a fescue hay-based diet and ruminal fluid from a heifer fed a 40% forage:60% concentrate diet. Addition of xylanase at 135 xylanase units (XU) per ml increased total VFA production from the fescue hay-based diet (44.3 vs. 57.2 mM, p < 0.05) without changing the acetate to propionate (A:P) ratio. Addition of endoglucanase at 2, 3, 4, and 5 carboxymethyl cellulase units (CMCU) per ml increased total VFA production from the fescue hay-based diet on average by 36% (p < 0.05). Addition of 3, 4 and 5 CMCU/ml also decreased (p < 0.05) the A:P ratio. The combined addition of xylanase (135 XU/ml) and endoglucanase (5 CMCU/ml) increased total VFA production from the fescue hay-based diet (40.9 vs. 61.5 mM, p < 0.05) and reduced the A:P ratio (3.4 vs. 1.5, p < 0.05). The effects of endoglucanase and xylanase supplementation on in vitro VFA production varied across the various substrates used. However, endoglucanase supplementation consistently reduced the A:P ratio with all substrates tested. The effects of the enzyme combination were generally greater than either enzyme alone. We conclude that endoglucanase and xylanase activities differ in their ability to affect ruminal VFA production, and endoglucanase but not xylanase, may improve fermentation efficiency by reducing the A:P ratio.     

餐厨垃圾协同剩余污泥发酵产酸的生物过程与影响因素研究进展

资源化利用是应对餐厨垃圾(Kitchen waste,KW)和剩余污泥(Excess sludge,ES)快速增加的有效方法,而厌氧发酵获得挥发性脂肪酸(Volatile fatty acids,VFAs)是其中的重要方式之一,但单一底物限制了VFAs的高效生产.近年来,不同底物厌氧共发酵产生VFAs被广泛研究与应用,...     

Biomass-derived volatile fatty acid platform for fuels and chemicals

The typical biorefinery platforms are sugar, thermochemical (syngas), carbon-rich chains, and biogas platforms, each offering unique advantages and disadvantages. The sugar platform uses hexose and pentose sugars extracted or converted from plant body mass. The thermochemical (syngas) platform entails a chemical or biological conversion process using pyrolysis or gasification of plants to produce biofuels. The carbon-rich chains platform is used to produce biodiesel from long-chain fatty acids or glycerides. In the present work, we suggest a new platform using volatile fatty acids (VFAs) for the production of biofuels and biochemicals production. The VFAs are short-chain fatty acids composed mainly of acetate and butyrate in the anaerobic digestion (AD) process, which does not need sterilization, additional hydrolysis enzymes (cellulose or xylanase), or a high cost pretreatment step. VFAs are easily produced from almost all kinds of biomass with low lignin content (terrestrial, aquatic, and marine biomass) by the AD process. Considering that raw material alone constitutes 40∼80% of biofuel production costs, biofuels made from VFAs derived from waste organic biomass potentially offer significant economical advantage.     

The effect of cocoa and polydextrose on bacterial fermentation in gastrointestinal tract simulations

Effects of cocoa mass and supplemented dietary fiber (polydextrose) on microbial fermentation were studied by combining digestion simulations of stomach and small intestine with multi-staged colon simulations. During the four phases of digestion, concentrations of available soluble proteins and reducing sugars reflected in vivo absorption of nutrients in small intestine. In colon simulation vessels, addition of polydextrose to digested cocoa mass significantly increased concentrations of total short-chain fatty acids and butyric acid, from 103 to 468 mM (P<0.01) and from 12 to 22 mM (P<0.01), respectively. Long-chain fatty acid concentrations (decreasing from 1,222 to 240 mM) were mainly affected by the presence of digested cocoa mass. Cocoa mass with or without polydextrose addition significantly decreased production of cadaverine (P<0.02) and branched-chain fatty acids compared to control during colon simulations. Results indicate beneficial effects on metabolism of colonic microbiota after digestion of cocoa mass, and even more so with polydextrose addition.     

In vitro fermentation of linear and alpha-1,2-branched dextrans by the human fecal microbiota

The role of structure and molecular weight in fermentation selectivity in linear α-1,6 dextrans and dextrans with α-1,2 branching was investigated. Fermentation by gut bacteria was determined in anaerobic, pH-controlled fecal batch cultures after 36 h. Inulin (1%, wt/vol), which is a known prebiotic, was used as a control. Samples were obtained at 0, 10, 24, and 36 h of fermentation for bacterial enumeration by fluorescent in situ hybridization and short-chain fatty acid analyses. The gas production of the substrate fermentation was investigated in non-pH-controlled, fecal batch culture tubes after 36 h. Linear and branched 1-kDa dextrans produced significant increases in Bifidobacterium populations. The degree of α-1,2 branching did not influence the Bifidobacterium populations; however, α-1,2 branching increased the dietary fiber content, implying a decrease in digestibility. Other measured bacteria were unaffected by the test substrates except for the Bacteroides-Prevotella group, the growth levels of which were increased on inulin and 6- and 70-kDa dextrans, and the Faecalibacterium prausnitzii group, the growth levels of which were decreased on inulin and 1-kDa dextrans. A considerable increase in short-chain fatty acid concentration was measured following the fermentation of all dextrans and inulin. Gas production rates were similar among all dextrans tested but were significantly slower than that for inulin. The linear 1-kDa dextran produced lower total gas and shorter time to attain maximal gas production compared to those of the 70-kDa dextran (branched) and inulin. These findings indicate that dextrans induce a selective effect on the gut flora, short-chain fatty acids, and gas production depending on their length.     

Chlorhexidine Salt-Loaded Polyurethane Orthodontic Chains: In Vitro Release and Antibacterial Activity Studies

The widespread use of indwelling medical devices has enormously increased the interest in materials incorporating antibiotics and antimicrobial agents as a means to prevent dangerous device-related infections. Recently, chlorhexidine-loaded polyurethane has been proposed as a material suitable for the production of devices which are able to resist microbial contamination. The aim of the present study was to characterize the in vitro release of chlorhexidine from new polymeric orthodontic chains realized with polyurethane loaded with two different chlorhexidine salts: chlorhexidine diacetate or chlorhexidine digluconate. The orthodontic chains constituted of three layers: a middle polyurethane layer loaded with chlorhexidine salt inserted between two layers of unloaded polymer. In vitro release of chlorhexidine diacetate and digluconate from orthodontic chains loaded with 10% or 20% (w/w) chlorhexidine salt was sustained for 42 days and followed Fickian diffusion. The drug diffusion through the polyurethane was found to be dependent not only on chlorhexidine loading, but also on the type of chlorhexidine salt. The antibacterial activity of 0.2% (w/w) chlorhexidine diacetate-loaded orthodontic chain was successfully tested towards clinically isolated biofilm forming ica-positive Staphylococcus epidermidis via agar diffusion test. In conclusion, the chlorhexidine salt-loaded chains could provide an innovative approach in the prevention of oral infections related to the use of orthodontic devices.KEY WORDS: antibacterial activity, cariogenic treatment, chlorhexidine, in vitro release, orthodontic chains     

Olfactory discrimination of anal sac secretions in the domestic cat and the chemical profiles of the volatile compounds

Scent emitted from anal sac secretions provides important signals for most Carnivora. Their secretions emit a variety of volatile compounds, some of which function as chemical signals with information about the scent owners. The domestic cat has a pair of anal sac glands to secrete a pungent liquid. Their anal sac secretions may give information about sex, reproductive state, and recognition of individuals. However, little is known about the volatile compounds emitted from anal sac secretions and their biological functions in cats. In this study, we examined the volatile chemical profiles of anal sac secretions in cats and their olfactory ability to discriminate intraspecific anal sac secretions. Analysis with gas chromatography–mass spectrometry showed that the major volatile compounds were short-chain free fatty acids, whose contents varied among individuals, as well as other carnivores. There was no sex difference in the volatile profiles. In temporal analyses of individual anal sac secretions performed 2 months apart, the profiles were highly conserved within individuals. Habituation–dishabituation tests showed that cats can distinguish individual differences in the odor of anal sac secretions. These results suggest that cats utilize short-chain free fatty acids emitted from anal sac secretions to obtain scent information for individual recognition rather than species or sex recognition.     

Evaluation of native potential probiotic bacteria using an in vitro ruminal fermentation system

Rumen microbiota provides an important source of protein to grazing animals and produces volatile fatty acids (VFA), the main energy source for ruminants generated by fibre fermentation. Probiotics can be used to modulate rumen fermentation, and native microbiota is a source of potentially useful microorganisms. In this work, ruminal bacterial strains were isolated and subsequently identified, and their potential to modify fermentation patterns with wheat straw, microcrystalline cellulose and oat xylan as substrates was assessed by in vitro gas production and VFA fermentation patterns. Four of the isolates were identified as Pseudobutyrivibrio ruminis and two corresponded to new members of the Lachnospiraceae family. The addition of one P. ruminis (strain 50C) and one Lachnospiraceae (strain 21C) to the fermentation system which used wheat straw as the substrate significantly increased total VFA concentration without altering the total gas produced in one case and showed a decrease in total gas production in the other. All bacterial strains induced higher butyric acid concentrations with the three substrates (up to 31 mM in the case of Lachnospiraceae 21C incubated with oat xylan and 25 mM in microcrystalline cellulose fermenters to which P. ruminis 50C had been added) compared to the control, which had concentrations of <1 mM. Analysis of the fermentation products suggested that the addition of probiotics to the fermentation system had the potential to induce metabolic shifts that would result in better energy yields. These results show that native bacteria have promising features as fermentation modulators, thereby justifying further research to assess their use as probiotics for ruminants.     

Influence of supplemental endoglucanase or xylanase on volatile fatty acid production from ruminant feed by ruminal in vitro cultures

Abstract

This study employed two commercial enzyme preparations to examine the effects of endoglucanase, xylanase or their combination on in vitro volatile fatty acid (VFA) production by ruminal microbial populations. Batch ruminal cultures were established with one of various feedstuffs or with a fescue hay-based diet and ruminal fluid from a heifer fed a 40% forage:60% concentrate diet. Addition of xylanase at 135 xylanase units (XU) per ml increased total VFA production from the fescue hay-based diet (44.3 vs. 57.2 mM, p < 0.05) without changing the acetate to propionate (A:P) ratio. Addition of endoglucanase at 2, 3, 4, and 5 carboxymethyl cellulase units (CMCU) per ml increased total VFA production from the fescue hay-based diet on average by 36% (p < 0.05). Addition of 3, 4 and 5 CMCU/ml also decreased (p < 0.05) the A:P ratio. The combined addition of xylanase (135 XU/ml) and endoglucanase (5 CMCU/ml) increased total VFA production from the fescue hay-based diet (40.9 vs. 61.5 mM, p < 0.05) and reduced the A:P ratio (3.4 vs. 1.5, p < 0.05). The effects of endoglucanase and xylanase supplementation on in vitro VFA production varied across the various substrates used. However, endoglucanase supplementation consistently reduced the A:P ratio with all substrates tested. The effects of the enzyme combination were generally greater than either enzyme alone. We conclude that endoglucanase and xylanase activities differ in their ability to affect ruminal VFA production, and endoglucanase but not xylanase, may improve fermentation efficiency by reducing the A:P ratio.     

Interactions between substrate,fermentation end-products,buffering systems and gas production upon fermentation of different carbohydrates by mixed rumen microorganisms in vitro

Summary In animal nutrition, incubation of feed samples with CO₂/HCO₃-buffered rumen fluid is used to predict the nutritional values of the feed. During fermentation, volatile fatty acids (VFAs) are produced, which release CO₂ from the buffer through their H⁺ ions. This indirect gas production amounted to 20.8 ml gas per mmol VFA. By incubating glucose, rice starch and cellulose, the relationship between direct and indirect gas production in relation to fermentation kinetics was studied. The total amount of gas formed was found to be dependent on the composition of the fermentation end-products formed. This could be described by: ml gas = M_v·mmol HAc + 2M_v·mmol HB + 0.87M_v·mmol Tot. VFA where HAc = acetic acid; HB = butyric acid; and M_v = molar gas volume. No clear relationship was found between the rate of fermentation and total gas production. From rice starch more total gas was produced than from glucose and cellulose, which were fermented faster and slower, respectively. Correspondence to: S. F. Spoelstra     

芳香植物精油的抗菌性及在动物生产中的应用

芳香植物精油为具特征性气味的挥发性油状液体, 是从芳香植物中提取的一种重要次生代谢物质。芳香植物精油的抗菌活性由其化学成分和浓度决定, 其中酚类、含氧萜类和萜烯类在抗菌方面表现出较强的活性。芳香植物精油的抗菌机制主要涉及脂肪酸外膜的改变、细胞质膜的损坏、质子动力的消耗、代谢物及离子泄露。在畜牧业生产体系中, 抗生素的无序使用不仅可能引发“超级细菌”的产生, 其残留亦会造成畜产品不安全和环境污染。芳香植物精油作为一种天然植物抗菌剂, 毒性较低且无残留, 作为饲料添加剂可用于维持动物机体的健康, 有望成为重要的抗生素替代品。该文阐述了芳香植物精油的活性成分、抗菌作用机制及其在动物生产中的应用, 为抗菌机理研究和新技术开发利用提供了理论依据。     

Optimization of fermentation parameters for production of ethanol from kinnow waste and banana peels by simultaneous saccharification and fermentation

A study was taken up to evaluate the role of some fermentation parameters like inoculum concentration, temperature, incubation period and agitation time on ethanol production from kinnow waste and banana peels by simultaneous saccharification and fermentation using cellulase and co-culture of Saccharomyces cerevisiae G and Pachysolen tannophilus MTCC 1077. Steam pretreated kinnow waste and banana peels were used as substrate for ethanol production in the ratio 4:6 (kinnow waste: banana peels). Temperature of 30°C, inoculum size of S. cerevisiae G 6% and (v/v) Pachysolen tannophilus MTCC 1077 4% (v/v), incubation period of 48 h and agitation for the first 24 h were found to be best for ethanol production using the combination of two wastes. The pretreated steam exploded biomass after enzymatic saccharification containing 63 gL⁻¹ reducing sugars was fermented with both hexose and pentose fermenting yeast strains under optimized conditions resulting in ethanol production, yield and fermentation efficiency of 26.84 gL⁻¹, 0.426 gg ⁻¹ and 83.52 % respectively. This study could establish the effective utilization of kinnow waste and banana peels for bioethanol production using optimized fermentation parameters.     

Continuous cultivation of rumen microorganisms,a system with possible application to the anaerobic degradation of lignocellulosic waste materials

Summary An in vitro continuous fermentation device is described which allows the maintenance of a mixed rumen microbial population under conditions similar to those in the rumen. The differences in flow rates of solids and liquids found in the rumen were established in vitro by means of a simple filter construction. A grass-grain mixture was used as a solid growth substrate. During a test period of 65 days the artificial rumen fermenter showed stable operation with respect to ciliate numbers, fibre degradation and volatile fatty acids production. Values obtained were comparable to those found in vivo. Optimal fibre degradation and volatile fatty acids production were maintained when hydraulic retention times (HRT) ranged from 11 to 14 h. At these HRT-values ciliate numbers were maintained at about 8.5×10⁴ cells per ml. Ciliate numbers declined drastically at HRT-values above 14h. A fermenter inoculated with a small volume of rumen fluid (1:100, v/v) reached normal protozoal numbers, fibre degradation and volatile fatty acids productions after a start up period of only 8 to 10 days. The possible application of rumen microorganisms for an efficient degradation of lignocellulosic waste material in an artificial rumen digester is discussed.