Characterization of cross‐linked immobilized arylesterase from Gluconobacter oxydans 621H with activity toward cephalosporin C and 7‐aminocephalosporanic acid

Cross‐linked enzyme aggregates (CLEAs) were prepared from several precipitant agents using glutaraldehyde as a cross‐linking agent with and without BSA, finally choosing a 40% saturation of ammonium sulfate and 25 mM of glutaraldehyde. The CLEAs obtained under optimum conditions were biochemically characterized. The immobilized enzyme showed higher thermal activity and a broader range of pH and organic solvent tolerance than the free enzyme. Arylesterase from Gluconobacter oxydans showed activity toward cephalosporin C and 7‐aminocephalosporanic acid. The CLEAs had a Kcat/K_M of 0.9 M^?1/S^?1 for 7‐ACA (7‐aminocephalosporanic acid) and 0.1 M^?1/S^?1 for CPC (cephalosporin c), whereas free enzyme did not show a typical Michaelis–Menten kinetics. © 2015 American Institute of Chemical Engineers Biotechnol. Prog., 32:36–42, 2016     

Penicillin acylase-catalyzed synthesis of beta-lactam antibiotics in highly condensed aqueous systems: beneficial impact of kinetic substrate supersaturation

Advantages of performing penicillin acylase-catalyzed synthesis of new penicillins and cephalosporins by enzymatic acyl transfer to the beta-lactam antibiotic nuclei in the supersaturated solutions of substrates have been demonstrated. It has been shown that the effective nucleophile reactivity of 6-aminopenicillanic (6-APA) and 7-aminodesacetoxycephalosporanic (7-ADCA) acids in their supersaturated solutions continue to grow proportionally to the nucleophile concentration. As a result, synthesis/hydrolysis ratio in the enzymatic synthesis can be significantly (up to three times) increased due to the nucleophile supersaturation. In the antibiotic nuclei conversion to the target antibiotic the remarkable improvement (up to 14%) has been gained. Methods of obtaining relatively stable supersaturated solutions of 6-APA, 7-ADCA, and D-p-hydroxyphenylglycine amide (D-HPGA) have been developed and syntheses of ampicillin, amoxicillin, and cephalexin starting from the supersaturated homogeneous solutions of substrates were performed. Higher synthetic efficiency and increased productivity of these reactions compared to the heterogeneous "aqueous solution-precipitate" systems were observed. The suggested approach seems to be an effective solution for the aqueous synthesis of the most widely requested beta-lactam antibiotics (i.e., amoxicillin, cephalexin, cephadroxil, cephaclor, etc.).     

Characterization of <Emphasis Type="Italic">Mucor miehei</Emphasis> lipase immobilized on polysiloxane-polyvinyl alcohol magnetic particles

Mucor miehei lipase was immobilized on magnetic polysiloxane-polyvinyl alcohol particles by covalent binding. The resulting immobilized biocatalyst was recycled by seven assays, with a retained activity around 10% of its initial activity. K_m and V_max were respectively 228.3 M and 36.1 U mg of protein^–1 for immobilized enzyme. Whereas the optimum temperature remained the same for both soluble and immobilized lipase (45 °C), there was a shift in pH profiles after immobilization. Optimum pH for the immobilized lipase was 8.0. Immobilized enzyme showed to be more resistant than soluble lipase when assays were performed out of the optimum temperature or pH.     

One ring to rule them all: Current trends in combating bacterial resistance to the β‐lactams

From humble beginnings of a contaminated petri dish, β‐lactam antibiotics have distinguished themselves among some of the most powerful drugs in human history. The devastating effects of antibiotic resistance have nevertheless led to an “arms race” with disquieting prospects. The emergence of multidrug resistant bacteria threatens an ever‐dwindling antibiotic arsenal, calling for new discovery, rediscovery, and innovation in β‐lactam research. Here the current state of β‐lactam antibiotics from a structural perspective was reviewed.     

Effects of rare earth ions (Tb,Ce, Eu,Dy) on the thermoluminescence characteristics of sol–gel derived and γ‐irradiated SiO2 nanoparticles

Highly pure SiO₂ and SiO₂:RE nanoparticles were synthesized by the sol–gel method. The morphological, structural and optical properties of the nanoparticles were characterized by X‐ray diffraction (XRD), scanning electron microscopy (SEM) and transmission electron microscopy (TEM). XRD results indicate that all the samples studied were free from impurities. SEM/TEM results indicate that the samples were well dispersed. Surface characterization of the nanocrystals by Fourier transform infrared spectroscopy has been carried out and the structure of surface‐bound SiO₂ based on spectral analysis is proposed. Thermoluminescence (TL) characteristics were investigated to study the influence of rare earth dopants (Tb, Ce, Eu, Dy) on SiO₂ matrix subjected to 0.5 kG (1 h) γ‐irradiation. Among these rare earth elements, Eu³⁺ was found to be the most efficient dopant for SiO₂ showing maximum thermoluminescence intensity. SiO₂:Eu_0.5 seems to be a promising candidate for use as a TL dosimeter. Copyright © 2013 John Wiley & Sons, Ltd.     

Examination of the active secondary structure of the peptide 101.10, an allosteric modulator of the interleukin‐1 receptor,by positional scanning using β‐amino γ‐lactams

The relationship between the conformation and biological activity of the peptide allosteric modulator of the interleukin‐1 receptor 101.10 (D ‐Arg‐D ‐Tyr‐D ‐Thr‐D ‐Val‐D ‐Glu‐D ‐Leu‐D ‐Ala‐NH₂) has been studied using (R)‐ and (S)‐Bgl residues. Twelve Bgl peptides were synthesized using (R)‐ and (S)‐cyclic sulfamidate reagents derived from L ‐ and D ‐aspartic acid in an optimized Fmoc‐compatible protocol for efficient lactam installment onto the supported peptide resin. Examination of these (R)‐ and (S)‐Bgl 101.10 analogs for their potential to inhibit IL‐1β‐induced thymocyte cell proliferation using a novel fluorescence assay revealed that certain analogs exhibited retained and improved potency relative to the parent peptide 101.10. In light of previous reports that Bgl residues may stabilize type II′β‐turn‐like conformations in peptides, CD spectroscopy was performed on selected compounds to identify secondary structure necessary for peptide biological activity. Results indicate that the presence of a fold about the central residues of the parent peptide may be important for activity. Copyright © 2011 European Peptide Society and John Wiley & Sons, Ltd.     

Theaflavin‐3,3´‐digallate increases the antibacterial activity of β‐lactam antibiotics by inhibiting metallo‐β‐lactamase activity

Metallo‐β‐lactamases (MBLs) are some of the best known β‐lactamases produced by common Gram‐positive and Gram‐negative pathogens and are crucial factors in the rise of bacterial resistance against β‐lactam antibiotics. Although many types of β‐lactamase inhibitors have been successfully developed and used in clinical settings, no MBL inhibitors have been identified to date. Nitrocefin, checkerboard and time‐kill assays were used to examine the enzyme behaviour in vitro. Molecular docking calculation, molecular dynamics simulation, calculation of the binding free energy and ligand‐residue interaction decomposition were used for mechanistic research. The behaviour of the enzymes in vivo was investigated by a mouse infection experiment. We showed that theaflavin‐3,3´‐digallate (TFDG), a natural compound lacking antibacterial activities, can inhibit the hydrolysis of MBLs. In the checkerboard and time‐kill assays, we observed a synergistic effect of TFDG with β‐lactam antibiotics against methicillin‐resistant Staphylococcus aureus BAA1717. Molecular dynamics simulations were used to identify the mechanism of the inhibition of MBLs by TFDG, and we observed that the hydrolysis activity of the MBLs was restricted by the binding of TFDG to Gln242 and Ser369. Furthermore, the combination of TFDG with β‐lactam antibiotics showed effective protection in a mouse Staphylococcus aureus pneumonia model. These findings suggest that TFDG can effectively inhibit the hydrolysis activity of MBLs and enhance the antibacterial activity of β‐lactam antibiotics against pathogens in vitro and in vivo.     

Kinetically controlled synthesis of ampicillin with immobilized penicillin acylase in the presence of organic cosolvents

Penicillin acylase (PA) is used in the industrial production of 6-amino penicillanic acid (6-APA). However, by proper control of reaction medium, the enzyme can be used in the reverse synthesis of β-lactam antibiotics from the corresponding β-lactam nuclei and suitable acyl donors. Under thermodynamically controlled strategy, the use of organic cosolvents can favor synthesis over hydrolysis by lowering water activity and favoring the non-ionic reactive species. Under kinetically controlled strategy using activated acyl donors, organic solvents can favor synthesis by depressing hydrolytic reactions. Results are presented on the synthesis of ampicillin from phenylglycine methyl ester and 6-APA with immobilized Escherichia coli PA in the presence of organic cosolvents. Several solvents were tested in terms of enzyme stability and solubility of substrates. Ethylene glycol, glycerol, 1–2 propanediol and 1–3 butanediol were selected accordingly and ampicillin synthesis was performed in all of them. Best results in terms of yield and productivity were obtained with ethylene glycol, with which further studies were conducted. Variables studied were enzyme to limiting substrate ratio, acyl acceptor to acyl donor ratio, organic solvent concentration, pH and temperature. Experimental design based on a two-level fractional factorial design was conducted. pH was determined as the most sensitive variable and was further optimized. The best conditions for ampicillin synthesis in terms of productivity, within the range of values studied for those variables, were pH 7.4, 28°C, 36 U_S PA/mmol 6-APA, 3 mol PGME/mol 6-APA and 45 % (v/v) ethylene glycol concentration. Productivity was 7.66 mM ampicillin/h, which corresponds to a specific productivity of 7.02 μmol ampicillin/h U_S at 55 % yield. Productivity was lower than in buffer but product yield was higher because of the much lower relative hydrolysis rates.     

Modification of Immobead 150 support for protein immobilization: Effects on the properties of immobilized Aspergillus oryzae β‐galactosidase

We studied the modification of Immobead 150 support by either introducing aldehyde groups using glutaraldehyde (Immobead‐Glu) or carboxyl groups through acid solution (Immobead‐Ac) for enzyme immobilization by covalent attachment or ion exchange, respectively. These two types of immobilization were compared with the use of epoxy groups that are now provided on a commercial support. We used Aspergillus oryzae β‐galactosidase (Gal) as a model protein, immobilizing it on unmodified (epoxy groups, Immobead‐Epx) and modified supports. Immobilization yield and efficiency were tested as a function of protein loading (10–500 mg g^?1 support). Gal was efficiently immobilized on the Immobeads with an immobilization efficiency higher than 75% for almost all supports and protein loads. Immobilization yields significantly decreased when protein loadings were higher than 100 mg g^?1 support. Gal immobilized on Immobead‐Glu and Immobead‐Ac retained approximately 60% of its initial activity after 90 days of storage at 4°C. The three immobilized Gal derivatives presented higher half‐lifes than the soluble enzyme, where the half‐lifes were twice higher than the free Gal at 73°C. All the preparations were moderately operationally stable when tested in lactose solution, whey permeate, cheese whey, and skim milk, and retained approximately 50% of their initial activity after 20 cycles of hydrolyzing lactose solution. The modification of the support with glutaraldehyde provided the most stable derivative during cycling in cheese whey hydrolysis. Our results suggest that the Immobead 150 is a promising support for Gal immobilization. © 2018 American Institute of Chemical Engineers Biotechnol. Prog., 34:934–943, 2018     

A pseudo steady‐state model for galacto‐oligosaccharides synthesis with β‐galactosidase from Aspergillus oryzae

A pseudo steady‐state model for the kinetically controlled synthesis of galacto‐oligosaccharides (GOS) with Aspergillus oryzae β‐galactosidase is presented. The model accounts for the dynamics of lactose consumption and production of galactose, glucose, di, tri, tetra, and penta‐oligosaccharides during the synthesis, being able to describe the total GOS content in the reaction medium at the experimental conditions evaluated. Experimental results show that the formation of GOS containing only galactose residues is significant at high conversions of substrate, which was taken into account in the model. The formation of enzyme transition complexes was considered and reasonable assumptions were made to reduce the number of parameters to be determined. The model developed has 8 parameters; 2 of them were experimentally determined and the other 6 were estimated by fitting to the experimental data using multiresponse regression. Temperature effect on kinetic and affinity constants was determined in the range from 40 to 55°C, and the data were fitted to Arrhenius type equation. Parameters of the proposed model are independent from the enzyme load in the reaction medium and, differently from previously reported models, they have a clear biochemical meaning. The magnitude of the kinetic and affinity constants of the enzyme suggests that the liberation of galactose from the galactosyl–enzyme complex is a very slow reaction and such complex is driven into GOS formation. It also suggests that the affinity for sugars of the galactosyl–enzyme complex is higher than that of the free enzyme. Biotechnol. Bioeng. 2011;108: 2270–2279. © 2011 Wiley Periodicals, Inc.     

Enzymatic synthesis of amoxicillin: avoiding limitations of the mechanistic approach for reaction kinetics

A recurrent doubt that occurs to the enzyme‐kinetics modeler is, When should I stop adding parameters to my mechanistic model in order to fit a non‐conventional behavior? This problem becomes more and more involving when the complexity of the reaction network increases. This work intends to show how the use of artificial neural networks may circumvent the need of including an overwhelming number of parameters in the rate equations obtained through the classical, mechanistic approach. We focus on the synthesis of amoxicillin by the reaction of p‐OH‐phenylglycine methyl ester and 6‐aminopenicillanic acid, catalyzed by penicillin G acylase immobilized on glyoxyl‐agarose, at 25°C and pH 6.5. The reaction was carried on a batch reactor. Three kinetic models of this system were compared: a mechanistic, a semi‐empiric, and a hybrid–neural network (NN). A semi‐empiric, simplified model with a reasonable number of parameters was initially built‐up. It was able to portray many typical process conditions. However, it either underestimated or overestimated the rate of synthesis of amoxicillin when substrates' concentrations were low. A more complex, full‐scale mechanistic model that could span all operational conditions was intractable for all practical purposes. Finally, a hybrid model, that coupled artificial neural networks (NN) to mass‐balance equations was established, that succeeded in representing all situations of interest. Particularly, the NN could predict with accuracy reaction rates for conditions where the semi‐empiric model failed, namely, at low substrate concentrations, a situation that would occur, for instance, at the end of a fed‐batch industrial process. © 2002 Wiley Periodicals, Inc. Biotechnol Bioeng 80: 622–631, 2002.     

Kinetic characterization of galacto‐oligosaccharide (GOS) synthesis by three commercially important β‐galactosidases

Many β‐galactosidases show large differences in galacto‐oligosaccharide (GOS) production and lactose hydrolysis. In this study, a kinetic model is developed in which the effect of lactose, glucose, galactose, and oligosaccharides on the oNPG converting activity of various β‐galactosidases is quantified. The use of oNPG as a competing substrate to lactose yields more information than can be obtained by examining only the conversion of lactose itself. The reaction rate with lactose or oligosaccharides as substrate relative to that with water as acceptor is much higher for the β‐galactosidase of Bacillus circulans than the β‐galactosidases of Aspergillus oryzae and Kluyveromyces lactis. In addition, the β‐galactosidase of B.circulans has a high reaction rate with galactose as acceptor, in contrast to those of A. oryzae and K. lactis. The latter two are strongly inhibited by galactose. These differences explain why β‐galactosidase of B. circulans gives higher yields in GOS production than other β‐galactosidases. Many of the reaction rate constants for the β‐galactosidase isoforms of B. circulans increase with increasing molecular weight of the isoform. This indicates that the largest isoform β‐gal‐A is most active in GOS production. However, its hydrolysis rate is also much higher than that of the other isoforms, which results in a faster hydrolysis of oligosaccharides as well. © 2013 American Institute of Chemical Engineers Biotechnol. Prog., 30:38–47, 2014     

Knockout of pgdS and ggt genes improves γ‐PGA yield in B. subtilis

One of the emerging biopolymers that are currently under active investigation is bacterial poly(γ‐glutamic acid) (γ‐PGA). However, before its full industrial exploitation, a substantial increase in microbial productivity is required. γ‐PGA obtained from the Bacillus subtilis laboratory strain 168 offers the advantage of a producer characterized by a well defined genetic framework and simple manipulation techniques. In this strain, the knockout of genes for the major γ‐PGA degrading enzymes, pgdS and ggt, leads to a considerable improvement in polymer yield, which attains levels analogous to the top wild γ‐PGA producer strains. This study highlights the convenience of using the laboratory strain of B. subtilis over wild isolates in designing strain improvement strategies aimed at increasing γ‐PGA productivity. Biotechnol. Bioeng. 2013; 110: 2006–2012. © 2013 Wiley Periodicals, Inc.     

TAPP analogs containing β3‐homo‐amino acids: synthesis and receptor binding

β‐Amino acids containing α,β‐hybrid peptides show great potential as peptidomimetics. In this paper, we describe the synthesis and affinity to μ‐opioid and δ‐opioid receptors of α,β‐hybrids, analogs of the tetrapeptide Tyr‐ d ‐Ala‐Phe‐Phe‐NH₂ (TAPP). Each amino acid was replaced with an l ‐ or d ‐β³‐h‐amino acid. All α,β‐hybrids of TAPP analogs were synthesized in solution and tested for affinity to μ‐opioid and δ‐opioid receptors. The analog Tyr‐β³h‐ d ‐Ala‐Phe‐PheNH₂ was found to be as active as the native tetrapeptide. Copyright © 2012 European Peptide Society and John Wiley & Sons, Ltd.     

Regulation of interleukin‐1β by interferon‐γ is species specific,limited by suppressor of cytokine signalling 1 and influences interleukin‐17 production

Reports describing the effect of interferon‐γ (IFNγ) on interleukin‐1β (IL‐1β) production are conflicting. We resolve this controversy by showing that IFNγ potentiates IL‐1β release from human cells, but transiently inhibits the production of IL‐1β from mouse cells. Release from this inhibition is dependent on suppressor of cytokine signalling 1. IL‐1β and Th17 cells are pathogenic in mouse models for autoimmune disease, which use Mycobacterium tuberculosis (MTB), in which IFNγ and IFNβ are anti‐inflammatory. We observed that these cytokines suppress IL‐1β production in response to MTB, resulting in a reduced number of IL‐17‐producing cells. In human cells, IFNγ increased IL‐1β production, and this might explain why IFNγ is detrimental for multiple sclerosis. In mice, IFNγ decreased IL‐1β and subsequently IL‐17, indicating that the adaptive immune response can provide a systemic, but transient, signal to limit inflammation.     

The stress response neuropeptide CRF increases amyloid‐β production by regulating γ‐secretase activity

The biological underpinnings linking stress to Alzheimer's disease (AD) risk are poorly understood. We investigated how corticotrophin releasing factor (CRF), a critical stress response mediator, influences amyloid‐β (Aβ) production. In cells, CRF treatment increases Aβ production and triggers CRF receptor 1 (CRFR1) and γ‐secretase internalization. Co‐immunoprecipitation studies establish that γ‐secretase associates with CRFR1; this is mediated by β‐arrestin binding motifs. Additionally, CRFR1 and γ‐secretase co‐localize in lipid raft fractions, with increased γ‐secretase accumulation upon CRF treatment. CRF treatment also increases γ‐secretase activity in vitro, revealing a second, receptor‐independent mechanism of action. CRF is the first endogenous neuropeptide that can be shown to directly modulate γ‐secretase activity. Unexpectedly, CRFR1 antagonists also increased Aβ. These data collectively link CRF to increased Aβ through γ‐secretase and provide mechanistic insight into how stress may increase AD risk. They also suggest that direct targeting of CRF might be necessary to effectively modulate this pathway for therapeutic benefit in AD, as CRFR1 antagonists increase Aβ and in some cases preferentially increase Aβ42 via complex effects on γ‐secretase.     

Cross-linked aggregates of penicillin acylase: robust catalysts for the synthesis of β-lactam antibiotics

A novel method for the immobilization of penicillin G acylase (penicillin amidohydrolase, E.C. 3.5.1.11) is reported. It involves the physical aggregation of the enzyme, followed by chemical cross-linking to form insoluble cross-linked enzyme aggregates (CLEAs). Compared with conventionally immobilized penicillin G acylases, these CLEAs possess a high specific activity as well as a high productivity and synthesis/hydrolysis (S/H) ratio in the synthesis of semi-synthetic antibiotics in aqueous media. Moreover, they are active in a broad range of polar and apolar organic solvents.