Metabolism of acetonitrile and propionitrile by Nocardia rhodochrous LL100-21.

Six nitrile compounds and two amide derivatives were degraded by Nocardia rhodochrous LL100-21. Acetonitrile, hydroacrylonitrile, and propionitrile were the best sources of carbon and nitrogen for growth, whereas butenenitrile, succinonitrile, and acetamide supported less growth. Acrylonitrile and acrylamide supported growth but only as a source of nitrogen. Gas chromatography of the culture medium revealed a decrease in acetonitrile with the sequential formation of acetamide and acetic acid. Ammonia was also detected by colorimetric procedures. The enzyme system responsible for the hydrolysis of acetonitrile was shown to be intracellular and inducible. The breakdown of acetonitrile by a crude bacterial extract was a two-step enzymatic hydrolysis with acetamide as the intermediate product and acetic acid and ammonia as the final products. Product formation was stoichiometric with substrate disappearance. When propionitrile was the growth substrate, there was complete conversion of the nitrile to propionic acid and ammonia as the major products. The enzymatic breakdown of the propionitrile, although slower than acetonitrile, yielded the corresponding carboxylic acid and ammonia. Propionamide was produced in very small amounts as an intermediate product.     

Degradation of Acetonitrile by Pseudomonas putida

A bacterium capable of utilizing high concentrations of acetonitrile as the sole source of carbon and nitrogen was isolated from soil and identified as Pseudomonas putida. This bacterium could also utilize butyronitrile, glutaronitrile, isobutyronitrile, methacrylonitrile, propionitrile, succinonitrile, valeronitrile, and some of their corresponding amides, such as acetamide, butyramide, isobutyramide, methacrylamide, propionamide, and succinamide as growth substrates. Acetonitrile-grown cells oxidized acetonitrile with a K_m of 40.61 mM. Mass balance studies with [¹⁴C]acetonitrile indicated that nearly 66% of carbon of acetonitrile was released as ¹⁴CO₂ and 14% was associated with the biomass. Metabolites of acetonitrile in the culture medium were acetic acid and ammonia. The acetate formed in the early stages of growth completely disappeared in the later stages. Cell extracts of acetonitrile-grown cells contained activities corresponding to nitrile hydratase and amidase, which mediate the breakdown of actonitrile into acetic acid and ammonia. Both enzymes were intracellular and inducible and hydrolyzed a wide range of substrates. The specific activity of amidase was at least 150-fold higher than the activity of the enzyme nitrile hydratase.     

Induction and Repression of Amidase Enzymes in Aspergillus nidulans

Aspergillus nidulans can grow on acetamide as both a carbon and nitrogen source and can also grow on formamide as a nitrogen source. Two distinct enzymes, an acetamidase and a formamidase, are produced. The control of the synthesis of these two enzymes in a wild-type strain was investigated. The formamidase is induced by acetamide and formamide and repressed by ammonia. The acetamidase is induced by formamide and acetamide, repressed by carbon metabolites derived from glucose and acetate, and repressed by ammonia. Repression of the acetamidase by ammonia depends on the carbon source; growth on glucose but not on acetate or acetamide allows repression to occur. The pattern of acetamidase repression is compared with that of histidine catabolic enzymes in various bacteria.     

Synergistic degradation of acetamide by methanogens and an aerobic Gram-positive rod

Methanogenesis from acetamide occurs through a two-step reaction in methanogenic sludges. First, acetamide is transformed to acetate and ammonia, then, acetate is converted to methane. There is evidence that the first step is performed by an aerobic sporulating rod that co-exists in the same sludge with methanogens. This finding provides new perspectives for further technological developments in the field of waste-water treatment, on the basis of the establishment of controlled relationships between aerobes and strict anaerobes.     

Remaining acetamide in acetonitrile degradation using nitrile hydratase- and amidase-producing microorganisms

The tandem conversion process involving nitrile hydratase- and amidase-producing microorganisms has potential for use in the treatment of acetonitrile-containing wastes. In that process, the acetamide hydrolysis step catalyzed by amidase is very slow compared with the acetonitrile hydration step catalyzed by nitrile hydratase, and a small amount of acetamide remains in the resulting solution. This study aimed to improve the efficiency of the acetamide hydrolysis step. An amidase-producing microorganism, Rhodococcus sp. S13-4, was newly obtained, whose use enabled rapid acetamide degradation. Though residual acetamide was still detected, it was successfully reduced by the addition of cation/anion mixed ion exchange resin or calcium hydroxide after the acetamide hydrolysis reaction using Rhodococcus sp. S13-4 cells. This result implies that acetamide hydrolysis and acetamide formation are in equilibrium. The incubation of Rhodococcus sp. S13-4 cells with high concentrations of ammonium acetate produced acetamide. The purified amidase from Rhodococcus sp. S13-4 revealed the acetamide formation activity (specific activity of 30.6 U/mg protein). This suggests that the amidase-catalyzed amide formation may cause the remaining of acetamide in the acetonitrile conversion process.     

Amide metabolism of Chlamydomonas reinhardi

Chlamydomonas reinhardi can utilise the lower aliphatic amides (C₁–C₄) as nitrogen sources. Of these only acetamide can serve as a sole carbon source. The acetamide analogue F-acetamide kills cells after conversion to F-acetate and F-citrate. This conversion is controlled by exogenous ammonia and, in part, acetate levels. Only one enzyme and one active site are involved in acetamidase function. Enzymatic analysis indicates an increased substrate range as compared to the growth — supported range, indicating uptake, toxicity or metabolic control restrictions.Abbreviations TCA trichloroacetic acid - TAP tris-acetate-phosphate medium - MIC mimmum inhibitory concentration - BSA bovine serum albumin     

Enzymatic degradation of nitriles by Klebsiella oxytoca

Klebsiella oxytoca, isolated from cyanide-containing wastewater, was able to utilize many nitriles as sole source of nitrogen. The major objective of this study was to explore the ability of K. oxytoca to utilize some nitriles and then further evaluate the pathways of transformation of cyanide compounds by K. oxytoca. Results from this study indicate that succinonitrile and valeronitrile were the most optimal sources of nitrogen for the growth of K. oxytoca. The biodegradation of acetonitrile proceeded with the formation of acetamide followed by acetic acid. The production of ammonia was also detected in this biodegradation experiment. Similar results were observed in the propionitrile biodegradation experiments. Collectively, this study suggests that the breakdown of acetonitrile or propionitrile by this bacterium was via a two-step enzymatic hydrolysis with amides as the intermediates and organic acids plus with ammonia as the end products.     

A sex difference in hepatic glutathione S-transferase B and the effect of hypophysectomy.

[2-14C]Methyl cyanide (acetonitrile) is metabolized to citrate, succinate, fumarate, malate, glutamate, pyrrolidonecarboxylic acid and aspartate. Non-radioactive acetamide and acetate compete with 14C from methyl cyanide, and [2-14C]acetate and [2-14C]methyl cyanide are metabolized at similar rates, giving identical products. This evidence, combined with the inhibitory effect of fluoroacetate and arsenite on methyl cyanide metabolism, indicates that the pathway is: methyl cyanide leads to acetamide leads to acetate leads to tricarboxylic acid-cycle intermediates. The pathway was investigated in a species of Pseudomonas (group III; N.C.I.B. 10477), but comparison of labelling patterns suggests that it also exists in several higher plants.     

Induction of the acetamidase of Aspergillus nidulans by acetate metabolism.

Growth tests and enzyme determinations strongly suggest that the acetamidase of Aspergillus nidulans is induced by a product of acetate metabolism rather than the substrate, acetamide. The cis-dominant mutation, amdI9, which is closely linked to amdS, the structural gene for the acetamidase, results in greatly increased sensitivity to induction by acetate metabolism. Propionate, L-threonine, and ethanol also result in acetamidase induction. Mutations in the facA, facB, and facC genes, which lead to low levels of acetyl-coenzyme A synthase, are epistatic to the amdI9 mutation for strong growth on acetamide medium and abolish acetamide and propionamide induction of the acetamidase and isocitrate lyase enzymes. Acetate, L-threonine, and ethanol, however, can induce these enzymes in strains containing facA and facC lesions but not in strains containing a facB lesion. The evidence suggests that acetamidase and isocitrate lyase may be induced by a similar mechanism.     

Studies on utilization of acetonitrile by Rhodococcus erythropolis A10

A petrochemical wastewater isolate, capable of utilizing high concentrations of acetonitrile and acetamide as the sole source of carbon and nitrogen was identified as Rhodococcus erythropolis A10. Cell-free extracts of acetonitrile-grown cells exhibited activities corresponding to nitrile hydratase (EC 4.2.1.84) and amidase (EC 3.5.1.4), which mediate the two-step breakdown of acetonitrile into acetic acid and ammonia. Studies indicated that both these enzymes in R. erythropolis A10 are intracellular, inducible and capable of hydrolysing a wide range of nitriles, including simple (acetonitrile, propionitrile), branched-chain (isobutyronitrile) and dinitrile (succinonitrile). The specific activity of the amidase was found to be several-fold higher than nitrile hydratase.     

Utilization of acetonitrile and other aliphatic nitriles by a Candida famata strain

Abstract A variant of a yeast strain identified as Candida famata isolated from gold mine effluent was able to grow on acetonitrile, acrylonitrile, butyronitrile, isobutyronitrile, methacrylnitrile, propionitrile, succinonitrile, valeronitrile, acetamide, isobutyamide, and succinamide as sole nitrogen source, after acclimatization. The yeast grew on acetonitrile and acetamide at concentrations up to 4%. The utilisation of acetonitrile and acetamide by the C. famata strain probably involves hydrolysis in a two-step reaction mediated by both inducible and intracellular nitrile hydratase and amidase.     

Regulation by ammonium of glutamate dehydrogenase (NADP+) from Saccharomyces cerevisiae

The activity of glutamate dehydrogenase (NADP+) (EC 1.4.1.4; NADP-GDH) of Saccharomyces cerevisiae is decreased under conditions in which intracellular ammonia concentrations increases. A high internal ammonia concentration can be obtained (a) by increasing the ammonium sulphate concentration in the culture medium, and (b) by growing the yeast either in acetate + ammonia media, where the pH of the medium rises during growth, or in heavily buffered glucose + ammonia media at pH 7.5. Under these conditions cellular oxoglutarate concentrations do not vary and changes in NADP-GDH activity appear to provide a constant rate of oxoglutarate utilization. The following results suggest that the decrease in NADP-GDH activity in ammonia-accumulating yeast cells is brought about by repression of synthesis: (i) after a shift to high ammonium sulphate concentrations, the number of units of activity per cell decreased as the inverse of cell doubling; and (ii) the rate of degradation of labelled NADP-GDH was essentially the same in ammonia-accumulating yeast cells and in controls, whereas the synthesis constant was much lower in the ammonia-accumulating cells than in the controls.     

Utilization of acrylonitrile by bacteria isolated from petrochemical waste waters

A bacterium, utilising acrylonitrile as a sole source of carbon and nitrogen, was isolated from Indian Petrochemical Corporation Limited (IPCL) waste waters and identified as Arthrobacter sp. This strain could also utilize acetonitrile, acetamide and acrylamide individually as a source of carbon and nitrogen. The metabolic studies with the whole cells indicated the sequential conversion of the nitrile to the respective amide and then to the respective acid and ammonia. The rate of nitrile hydrolysis was slower than the corresponding amide hydrolysis. Acrylic acid, the end product of acrylonitrile breakdown, did not support the growth when provided as a carbon source.     

Acetamide selection of Kluyveromyces lactis cells transformed with an integrative vector leads to high-frequency formation of multicopy strains

The yeast Kluyveromyces lactis has been extensively used as a host for heterologous protein expression. A necessary step in the construction of a stable expression strain is the introduction of an integrative expression vector into K. lactis cells, followed by selection of transformed strains using either medium containing antibiotic (e.g., G418) or nitrogen-free medium containing acetamide. In this study, we show that selection using acetamide yields K. lactis transformant populations nearly completely comprised of strains bearing multiple tandem insertions of the expression vector pKLAC1 at the LAC4 chromosomal locus, whereas an average of 16% of G418-selected transformants are multiply integrated. Additionally, the average copy number within transformant populations doubled when acetamide was used for selection compared to G418. Finally, we demonstrate that the high frequency of multicopy integration associated with using acetamide selection can be exploited to rapidly construct expression strains that simultaneously produce multiple heterologous proteins or multisubunit proteins, such as Fab antibodies.     

In vitro and in vivo study of glutamate dehydrogenase encapsulated into mouse erythrocytes by a hypotonic dialysis procedure

Glutamate dehydrogenase (GDH) has been encapsulated into mouse erythrocytes by a hypotonic dialysis/isotonic resealing method. Although a low GDH entrapment yield was achieved (3.8%), this percentage appeared sufficient enough to metabolize high quantities of ammonia. Carrier cell recovery yield was 56%. Due to the decrease in cell volume and haemoglobin content, constant mean cell haemoglobin concentration (MCHC) values were obtained. The osmotic fragility curves (OFC) indicated that dialyzed/resealed-RBCs are more resistant to hypotonic haemolysis than native-RBCs. The successful in vitro ammonia degradation by GDH-RBCs was reflected in its total disappearance from the incubation medium at around 48 h. In contrast, initial ammonia levels were not affected during the incubation in the presence of native-RBCs and remained constant. Two different methods were used for the preparation of hyperammonaemic mice model. Since the intraperitoneal (i.p.) administration of ammonium acetate produced high ammonia levels that lasted only a few minutes, the i.p. administration of urease was chosen, given that it generated elevated ammonia levels for longer periods of time. Hyperammonaemic mice quickly removed high levels of circulating ammonia in the presence of GDH-RBCs, whereas in the presence of native-RBCs ammonia was slowly metabolized. These results suggest that loaded GDH-erythrocytes can be used as a potential carrier systems for the in vivo removal of high levels of ammonia from blood.     

Rapid quantification of major reaction products formed during thermochemical pretreatment of lignocellulosic biomass using GC-MS

Accurate quantification of reaction products formed during thermochemical pretreatment of lignocellulosic biomass would lead to a better understanding of plant cell wall deconstruction for production of cellulosic biofuels and biochemicals. However, quantification of some process byproducts, most notably acetamide, acetic acid and furfural, present several analytical challenges using conventional liquid chromatography methods. Therefore, we have developed a high-throughput gas chromatography based mass spectrometric (GC-MS) method in order to quantify relevant compounds without requiring time-consuming sample derivatization prior to analysis. Solvent extracts of untreated, ammonia fiber expansion (AFEX) treated and dilute-acid treated corn stover were analyzed by this method. Biomass samples were extracted with acetone using an automated solvent extractor, serially diluted and directly analyzed using the proposed GC-MS method. Acetone was the only solvent amongst water, methanol and acetonitrile that did not contain detectable background levels of the target compounds or facilitate a buildup of plant-derived residues in the GC injector, which decreased analytical reproducibility. Quantitative results were based on the method of standard addition and external standard calibration curves.     

Utilization of aliphatic nitrile by Paracoccus sp. SKG isolated from chemical waste samples

A bacterial strain Paracoccus sp. SKG capable of utilizing acetonitrile as a sole source of carbon and nitrogen was isolated from the chemical waste samples. The molecular phylogram generated using the complete sequence of 16S rDNA of the strain SKG showed close links to the bacteria grouped under Brucellaceae family, that belongs to the class alphaproteobacteria. Specifically, the 16S rDNA sequence of strain SKG has shown 99% similarity to Paracoccus sp. This bacterium has also shown impressive growth on aliphatic nitriles like acetonitrile, propionitrile, acrylonitrile, valeronitrile and their corresponding amides. The nitriles degradation has led to the accumulation of ammonia and respective carboxylic acids. The acetonitrile grown cells showed the release of ammonia that contributes to the increase in pH of the medium. However, glucose grown cells failed to produce ammonia, thus indicating the inducible nature of acetonitrile degrading enzymes in Paracoccus sp. SKG. Nitrile hydratase and amidase are the two key enzymes involved in the degradation of acetonitrile. Degradation of acetonitrile in Paracoccus sp. SKG follows the bi-enzymatic pathway. Further, this strain is capable of degrading acetonitrile in the presence of other organic solvents such as methanol, ethanol and dimethylformamide. Therefore, this strain is efficiently used for the treatment of HPLC waste stream containing acetonitrile in the presence of other organic solvents.     

Acetamide Selection of Kluyveromyces lactis Cells Transformed with an Integrative Vector Leads to High-Frequency Formation of Multicopy Strains

The yeast Kluyveromyces lactis has been extensively used as a host for heterologous protein expression. A necessary step in the construction of a stable expression strain is the introduction of an integrative expression vector into K. lactis cells, followed by selection of transformed strains using either medium containing antibiotic (e.g., G418) or nitrogen-free medium containing acetamide. In this study, we show that selection using acetamide yields K. lactis transformant populations nearly completely comprised of strains bearing multiple tandem insertions of the expression vector pKLAC1 at the LAC4 chromosomal locus, whereas an average of 16% of G418-selected transformants are multiply integrated. Additionally, the average copy number within transformant populations doubled when acetamide was used for selection compared to G418. Finally, we demonstrate that the high frequency of multicopy integration associated with using acetamide selection can be exploited to rapidly construct expression strains that simultaneously produce multiple heterologous proteins or multisubunit proteins, such as Fab antibodies.     

Methane production from acetamide in an upflow anaerobic sludge-blanket reactor based on a synergistic association between an aerobic rod and methanogens

Acetamide degradation was investigated in a bench-scale upflow anaerobic sludge-blanket (UASB) reactor, successively fed with acetamide, acetate and acetamide, over a period of 343 days, at different hydraulic retention times (t _HR). The reactor was seeded with the sludge previously described [Guyot et al. (1994) Appl Microbiol Biotechnol, 42:452-456], in which methanogenesis from acetamide was performed through a synergistic relationship between an acetamide-degrading, aerobic rod and methanogens. When the reactor was fed acetamide, the chemical oxygen demand (COD) removal efficiency was 86% at volumetric loads less than 1.18 kg COD m^–3 day ^–1. At higher volumetric loads, the efficiency decreased markedly, e.g. 50.9% at a volumetric organic load of 3.39 kg COD m^–3 day^–1 (1 day t _HR) with an accumulation of both acetamide and acetate. The same reactor, when fed with acetate at t _HR 1 day, reached a high COD removal (99%). Evidence of the inhibition of acetate degradation by acetamide is presented. After a long period (135 days) without feeding the reactor with acetamide, the sludge reactor was still capable of degrading acetamide when this substrate was supplied again. It seems that the synergistic degradation of acetamide by aerobes and methanogens present in the UASB reactor sludge is stable over a long period (343 days), in spite of limiting concentrations of dissolved oxygen in the feed.     

Fungal ammonia fermentation, a novel metabolic mechanism that couples the dissimilatory and assimilatory pathways of both nitrate and ethanol. Role of acetyl CoA synthetase in anaerobic ATP synthesis

Fungal ammonia fermentation is a novel dissimilatory metabolic mechanism that supplies energy under anoxic conditions. The fungus Fusarium oxysporum reduces nitrate to ammonium and simultaneously oxidizes ethanol to acetate to generate ATP (Zhou, Z., Takaya, N., Nakamura, A., Yamaguchi, M., Takeo, K., and Shoun, H. (2002) J. Biol. Chem. 277, 1892-1896). We identified the Aspergillus nidulans genes involved in ammonia fermentation by analyzing fungal mutants. The results showed that assimilatory nitrate and nitrite reductases (the gene products of niaD and niiA) were essential for reducing nitrate and for anaerobic cell growth during ammonia fermentation. We also found that ethanol oxidation is coupled with nitrate reduction and catalyzed by alcohol dehydrogenase, coenzyme A (CoA)-acylating aldehyde dehydrogenase, and acetyl-CoA synthetase (Acs). This is similar to the mechanism suggested in F. oxysporum except A. nidulans uses Acs to produce ATP instead of the ADP-dependent acetate kinase of F. oxysporum. The production of Acs requires a functional facA gene that encodes Acs and that is involved in ethanol assimilation and other metabolic processes. We purified the gene product of facA (FacA) from the fungus to show that the fungus acetylates FacA on its lysine residue(s) specifically under conditions of ammonia fermentation to regulate its substrate affinity. Acetylated FacA had higher affinity for acetyl-CoA than for acetate, whereas non-acetylated FacA had more affinity for acetate. Thus, the acetylated variant of the FacA protein is responsible for ATP synthesis during fungal ammonia fermentation. These results showed that the fungus ferments ammonium via coupled dissimilatory and assimilatory mechanisms.