Simultaneous nutrient removal and lipid production from pretreated piggery wastewater by Chlorella vulgaris YSW-04

The feasibility of using a microalga Chlorella vulgaris YSW-04 was investigated for removal of nutrients from piggery wastewater effluent. The consequent lipid production by the microalga was also identified and quantitatively determined. The wastewater effluent was diluted to different concentrations ranging from 20 to 80 % of the original using either synthetic media or distilled water. The dilution effect on both lipid production and nutrient removal was evaluated, and growth rate of C. vulgaris was also monitored. Dilution of the wastewater effluent improved microalgal growth, lipid productivity, and nutrient removal. The growth rate of C. vulgaris was increased with decreased concentration of piggery wastewater in the culture media regardless of the diluent type. Lipid production was relatively higher when using synthetic media than using distilled water for dilution of wastewater. The composition of fatty acids accumulated in microalgal biomass was dependent upon both dilution ratio and diluent type. The microalga grown on a 20 % concentration of wastewater effluent diluted with distilled water was more promising for generating high-efficient biodiesel compared to the other culture conditions. The highest removal of inorganic nutrients was also achieved at the same dilution condition. Our results revealed the optimal pretreatment condition for the biodegradation of piggery wastewater with microalgae for subsequent production of high-efficient biodiesel.     

Seasonal variation in light utilisation,biomass production and nutrient removal by wastewater microalgae in a full-scale high-rate algal pond

There has been renewed interest in the combined use of high-rate algal ponds (HRAP) for wastewater treatment and biofuel production. Successful wastewater treatment requires year-round efficient nutrient removal while high microalgal biomass yields are required to make biofuel production cost-effective. This paper investigates the year-round performance of microalgae in a 5-ha demonstration HRAP system treating primary settled wastewater in Christchurch, New Zealand. Microalgal performance was measured in terms of biomass production, nutrient removal efficiency, light absorption and photosynthetic potential on seasonal timescales. Retention time-corrected microalgal biomass (chlorophyll a) varied seasonally, being lowest in autumn and winter (287 and 364 mg m^?3day^?1, respectively) and highest in summer (703 mg m^?3day^?1), while the conversion efficiency of light to biomass was greatest in winter (0.39 mg Chl- a per μmol) and lowest in early summer (0.08 mg Chl- a per μmol). The percentage of ammonium (NH₄–N) removed was highest in spring (79 %) and summer (77 %) and lowest in autumn (47 %) and winter (53 %), while the efficiency of NH₄–N removal per unit biomass was highest in autumn and summer and lowest in winter and spring. Chlorophyll-specific light absorption per unit biomass decreased as total chlorophyll increased, partially due to the package effect, particularly in summer. The proportional increase in the maximum electron transport rate from winter to summer was significantly lower than the proportional increase in the mean light intensity of the water column. We concluded that microalgal growth and nutrient assimilation was constrained in spring and summer and carbon limitation may be the likely cause.     

Cultivation of a new microalga,Micractinium reisseri,in municipal wastewater for nutrient removal,biomass, lipid,and fatty acid production

Coupling of advanced wastewater treatment with microalgae cultivation for low-cost lipid production was demonstrated in this study. The microalgal species Micractinium reisseri and Scenedesmus obliquus were isolated from municipal wastewater mixed with agricultural drainage. M. reisseri was selected based on the growth rate and cultivated in municipal wastewater (influent, secondary and tertiary effluents) which varied in nutrient concentration. M. reisseri showed an optimal specific growth rate (μ_opt) of 1.15, 1.04, and 1.01 1/day for the influent and the secondary and tertiary effluents, respectively. Secondary effluent supported the highest phosphorus removal (94%) and saturated fatty acid content (40%). The highest lipid content (40%), unsaturated fatty acid content, including monounsaturated and polyunsaturated fatty acids (66%), and nitrogen removal (80%) were observed for tertiary effluent. Fatty acids accumulating in the microalgal biomass (M. reisseri) were mainly composed of palmitic acid, oleic acid, linoleic acid, and a-linolenic acid. Cultivation of M. reisseri using municipal wastewater served a dual function of nutrient removal and biofuel feedstock generation.     

Phycoremediation of dairy and winery wastewater using <Emphasis Type="Italic">Diplosphaera</Emphasis> sp. MM1

A new green microalgal species was isolated, identified and investigated for its biomass production and nutrient removal efficiency in dairy and winery wastewater in this study. The 18S rRNA-based phylogenetic analysis revealed that this new strain is a Diplosphaera sp. and was designated strain MM1. The growth of this strain was evaluated in different diluted dairy and winery wastewaters. The highest algal biomass production (up to 2.3 g L^?1) was obtained in dairy wastewater (D3; dairy wastewater 1:2 deionised water) after 14 days of culture. However, for winery wastewater, the highest algal biomass production (up to 1.46 g L^?1) was obtained in wastewater combination W2 (winery wastewater 1:1 deionised water) after 14 days of culture. Turbid dairy wastewater with high concentration of nitrogen and phosphorous slowed down the initial growth of the alga. However, at the end of day 14, biomass production was nearly twofold higher than that of winery wastewater. The findings from both types of wastewater suggest that Diplosphaera sp. MM1 has potential for its application in generating biomass with simultaneous remediation of nutrient-rich wastewater.     

Improved algal oil production from Botryococcus braunii by feeding nitrate and phosphate in an airlift bioreactor

To improve biomass and microalgal oil production of Botryococcus braunii, fed‐batch culture was investigated in an airlift photobioreactor. The optimal feeding time of the fed‐batch culture was after 15 days of cultivation, where 1.82 g/L of the microalgal biomass was obtained in the batch culture. Nitrate nutrient was the restrictive factor for the fed‐batch cultivation while phosphate nutrient with high concentration did not affect the microalgal growth. The optimal mole ratio of nitrate to phosphate was 34.7:1, where nitrate concentration reached the initial level and phosphate concentration was one quarter of its initial level. With one feeding, the biomass of B. braunii reached 2.56 g/L after 18 days. Two feedings in 2‐day interval enhanced the biomass production up to 2.87 g/L after 19 days of cultivation. The hydrocarbon content in dry biomass of B. braunii kept at high level of 64.3% w/w. Compared with the batch culture, biomass production and hydrocarbon productivity of B. braunii were greatly improved by the strategic fed‐batch cultivation.     

Phycoremediation of municipal wastewater by microalgae to produce biofuel

Municipal wastewater (WW), if not properly remediated, poses a threat to the environment and human health by carrying significant loads of nutrients and pathogens. These contaminants pollute rivers, lakes, and natural reservoirs where they cause eutrophication and pathogen-mediated diseases. However, the high nutrient content of WW makes it an ideal environment for remediation with microalgae that require high nutrient concentrations for growth and are not susceptible to toxins and pathogens. Given that an appropriate algal strain is used for remediation, the incurred biomass can be refined for the production of biofuel. Four microalgal species (Chlamydomonas reinhardtii, Chlorella sp., Parachlorella kessleri-I, and Nannochloropsis gaditana) were screened for efficient phycoremediation of municipal WW and potential use for biodiesel production. Among the four strains tested, P. kessleri-I showed the highest growth rate and biomass production in 100% WW. It efficiently removed all major nutrients with a removal rate of up to 98% for phosphate after 10 days of growth in 100% municipal WW collected from Delhi. The growth of P. kessleri-I in WW resulted in a 50% increase of biomass and a 115% increase of lipid yield in comparison to growth in control media. The Fatty acid methyl ester (FAME), and fuel properties of lipids isolated from cells grown in WW complied with international standards. The present study provides evidence that the green alga P. kessleri-I effectively remediates municipal WW and can be used to produce biodiesel.     

Efficacy of Chlorella pyrenoidosa and Scenedesmus abundans for Nutrient Removal in Rice Mill Effluent (Paddy Soaked Water)

Microalgae are product of sustainable development owing to its ability to treat variety of wastewater effluents and thus produced biomass can serve as value added product for various commercial applications. This paper deals with the cultivation of microalgae species namely Chlorella pyrenoidosa and Scenedesmus abundans in rice mill effluent (i.e., paddy soaked water) for nutrient removal. In order to investigate the nutrient removal capability, microalgae are subjected to cultivation in both raw and autoclaved samples. The maximum phosphate removal by Scenedesmus abundans and Chlorella pyrenoidosa in raw sample was 98.3% and 97.6%, respectively, whereas, the removal of ammoniacal nitrogen by Scenedesmus abundans and Chlorella pyrenoidosa in raw sample was 92% and 90.3%, respectively. The growth (measured in terms of chlorophyll content) of Scenedesmus abundans and Chlorella pyrenoidosa in raw sample was 3.88 mg/l and 5.55 mg/l, respectively. The results indicate the suitability of microalgae cultivation in rice mill effluent treatment for nutrient removal.     

Evaluation of microalgal consortia for treatment of primary treated sewage effluent and biomass production

The present investigation was aimed towards analyzing the potential of consortia of native filamentous microalgal strains (MC2), native unicellular microalgal strains (MC3), and selected microalgae from germplasm (MC1) in terms of nutrient removal, water quality improvement, and biomass production using primary treated sewage water. Highest NO₃-N (90 %) and PO₄-P (97.8 %) removal was obtained with MC2-inoculated sewage water. Highest decrease in total dissolved solids to 806 from 1,120 mg L^?1 and highest increase in dissolved oxygen of 9.0 from 0.4 mg L^?1 were obtained using MC2-inoculated sewage water on the sixth day. The biomass production was also highest in MC2 (1.07 g L^?1) followed by MC1 and MC3 (0.90 and 0.94 g L^?1, respectively) on the sixth day. The consortium of filamentous strains from native environment not only proved promising in nutrient removal efficiency but also led to enhanced biomass. The present study highlighted the utility of such a consortium for sewage wastewater treatment and the promise of sewage water as a growth medium for biomass production.     

Co-Cultivation of Fungal and Microalgal Cells as an Efficient System for Harvesting Microalgal Cells,Lipid Production and Wastewater Treatment

The challenges which the large scale microalgal industry is facing are associated with the high cost of key operations such as harvesting, nutrient supply and oil extraction. The high-energy input for harvesting makes current commercial microalgal biodiesel production economically unfeasible and can account for up to 50% of the total cost of biofuel production. Co-cultivation of fungal and microalgal cells is getting increasing attention because of high efficiency of bio-flocculation of microalgal cells with no requirement for added chemicals and low energy inputs. Moreover, some fungal and microalgal strains are well known for their exceptional ability to purify wastewater, generating biomass that represents a renewable and sustainable feedstock for biofuel production. We have screened the flocculation efficiency of the filamentous fungus A. fumigatus against 11 microalgae representing freshwater, marine, small (5 µm), large (over 300 µm), heterotrophic, photoautotrophic, motile and non-motile strains. Some of the strains are commercially used for biofuel production. Lipid production and composition were analysed in fungal-algal pellets grown on media containing alternative carbon, nitrogen and phosphorus sources contained in wheat straw and swine wastewater, respectively. Co-cultivation of algae and A. fumigatus cells showed additive and synergistic effects on biomass production, lipid yield and wastewater bioremediation efficiency. Analysis of fungal-algal pellet''s fatty acids composition suggested that it can be tailored and optimised through co-cultivating different algae and fungi without the need for genetic modification.     

EFFECTS OF NUTRIENT ENRICHMENT ON PRIMARY PRODUCTION AND BIOMASS OF SEDIMENT MICROALGAE IN A SUBTROPICAL SEAGRASS BED1

Eutrophication of coastal waters often leads to excessive growth of microalgal epiphytes attached to seagrass leaves; however, the effect of increased nutrient levels on sediment microalgae has not been studied within seagrass communities. A slow‐release NPK Osmocote fertilizer was added to sediments within and outside beds of the shoal grass Halodule wrightii, in Big Lagoon, Perdido Key, Florida. Gross primary production (GPP) and biomass (HPLC photopigments) of sediment microalgae within and adjacent to fertilized and control H. wrightii beds were measured following two 4‐week enrichment periods during June and July 2004. There was no effect of position on sediment microalgal GPP or biomass in control and enriched plots. However, nutrient enrichment significantly increased GPP in both June and July. These results suggest that sediment microalgae could fill some of the void in primary production where seagrass beds disappear due to excessive nutrient enrichment. Sedimentary chl a (proxy of total microalgal biomass) significantly increased only during the June enrichment period, whereas fucoxanthin (proxy of total diatom biomass) was not increased by nutrient enrichment even though its concentration doubled in the enriched plots in June.     

Bioremediation of wastewater from edible oil refinery factory using oleaginous microalga Desmodesmus sp. S1

Edible oil industry produced massive wastewater, which requires extensive treatment to remove pungent smell, high phosphate, carbon oxygen demand (COD), and metal ions prior to discharge. Traditional anaerobic and aerobic digestion could mainly reduce COD of the wastewater from oil refinery factories (WEORF). In this study, a robust oleaginous microalga Desmodesmus sp. S1 was adapted to grow in WEORF. The biomass and lipid content of Desmodesmus sp. S1 cultivated in the WEORF supplemented with sodium nitrate were 5.62 g·L^?1 and 14.49%, whereas those in the WEORF without adding nitrate were 2.98 g·L^?1 and 21.95%. More than 82% of the COD and 53% of total phosphorous were removed by Desmodesmus sp. S1. In addition, metal ions, including ferric, aluminum, manganese and zinc were also diminished significantly in the WEORF after microalgal growth, and pungent smell vanished as well. In comparison with the cells grown in BG-11 medium, the cilia-like bulges and wrinkles on the cell surface of Desmodesmus sp. S1 grown in WEORF became out of order, and more polyunsaturated fatty acids were detected due to stress derived from the wastewater. The study suggests that growing microalgae in WEORF can be applied for the dual roles of nutrient removal and biofuel feedstock production.     

Integration of algae cultivation as biodiesel production feedstock with municipal wastewater treatment: strains screening and significance evaluation of environmental factors

The objectives of this study are to find the robust strains for the centrate cultivation system and to evaluate the effect of environmental factors including light intensity, light–dark cycle, and exogenous CO₂ concentration on biomass accumulation, wastewater nutrient removal and biodiesel production. The results showed that all 14 algae strains from the genus of Chlorella, Haematococcus, Scenedesmus, Chlamydomonas, and Chloroccum were able to grow on centrate. The highest net biomass accumulation (2.01 g/L) was observed with Chlorella kessleri followed by Chlorella protothecoides (1.31 g/L), and both of them were proved to be capable of mixotrophic growth when cultivated on centrate. Environmental factors had significant effect on algal biomass accumulation, wastewater nutrients removal and biodiesel production. Higher light intensity and exogenous CO₂ concentration with longer lighting period promote biomass accumulation, biodiesel production, as well as the removal of chemical oxygen demand and nitrogen, while, lower exogenous CO₂ concentration promotes phosphorus removal.     

Anaerobic digestion of microalgal biomass with ultrasonic disintegration

The use of photosynthetic microalgae for nutrient removal and biofuel production has been widely discussed. Anaerobic digestion of waste microalgal biomass to produce biogas is a promising technology for bioenergy production. However, the methane yield from this anaerobic process was limited because of the hard cell wall of Chlorella vulgaris. The use of ultrasound has proven to be successful at improving the disintegration and anaerobic biodegradability of Chlorella vulgaris. Ultrasonic pretreatment in the range of 5–200 J ml⁻¹ was applied to waste microalgal biomass, which was then used for batch digestion. Ultrasound techniques were successful and showed higher soluble COD at higher applied energy. During batch digestion, cell disintegration due to ultrasound increased in terms of specific biogas production and the degradation rate. Compared to the untreated sample, the specific biogas production was increased in the ultrasound-treated sample by 90% at an energy dose of 200 J ml⁻¹. For the disintegrated samples, volatile solids reduction was also increased according to the energy input and degradation. These results indicate that the hydrolysis of microalgal cells is the rate-limiting step in the anaerobic digestion of microalgal biomass.     

Utilization of immobilized benthic algal species for N and P removal

Laboratory experiments were performed to study the growth rate and phosphorus (P) and nitrogen (N) uptakes of eight benthic microalgae species isolated from different sources of pig manure. Cells immobilized in calcium alginate beads were cultured with three replicates for each species. P removal rates obtained for the unicellular self-aggregating benthic species (Palmellopsis gelatinosa, Chlorosarcinopsis sp., and Macrochloris sp.) were markedly higher than those obtained in previous published experiments. N removal rates were highest for Macrochloris sp., Chlorosarcinopsis sp., and Euglena sp. 2 and comparable to the maximum rates obtained by other authors. Our results show an excellent efficiency of autochthonous benthic species for nutrient removal, especially for P, and call attention to their use for wastewater treatment.     

Effect of the Nutritional Status of Semi-continuous Microalgal Cultures on the Productivity and Biochemical Composition of <Emphasis Type="Italic">Brachionus plicatilis</Emphasis>

The rotifer Brachionus plicatilis was cultured using the microalga Isochrysis aff. galbana clone T-ISO as feed. T-ISO was cultured semi-continuously with daily renewal rates of 10%, 20%, 30%, 40%, and 50% of the volume of cultures. The increase of renewal rate led to increasing nutrient and light availability in microalgal cultures, which caused differences in the biochemical composition of microalgal biomass. Growth rate, individual dry weight, organic content, and biomass productivity of rotifer cultures increased in response to higher growth rate in T-ISO cultures. Rotifer growth rate showed a strong negative correlation (R ² = 0.90) with the C/N ratio of microalgal biomass. Rotifer dry weight was also affected by nutrient availability of T-ISO cultures, increasing up to 50% from nutrient-limited to nutrient-sufficient conditions. Consequently, biomass productivity of rotifer cultures increased more than twofold with the increase of renewal rate of T-ISO cultures. Rotifer organic content underwent the same trend of total dry weight. Maximum content of polyunsaturated fatty acids was reached in rotifers fed T-ISO from the renewal rate of 40%, with percentages of docosahexaenoic acid (22:6ω-3, DHA) and eicosapentaenoic acid (20:5ω-3, EPA) of 11% and 5% of total fatty acids, respectively. Selecting the most appropriate conditions for microalgal culture can therefore enhance the nutritive quality of microalgal biomass, resulting in a better performance of filter feeders and their nutrient content, and may constitute a useful tool to improve the rearing of fish larvae and other aquaculture organisms that require live feed in some or all the stages of their life cycle.     

Thermophilic,anaerobic co-digestion of microalgal biomass and cellulose for H<Subscript>2</Subscript> production

Microalgal biomass has been a focus in the sustainable energy field, especially biodiesel production. The purpose of this study was to assess the feasibility of treating microalgal biomass and cellulose by anaerobic digestion for H₂ production. A microbial consortium, TC60, known to degrade cellulose and other plant polymers, was enriched on a mixture of cellulose and green microalgal biomass of Dunaliella tertiolecta, a marine species, or Chlorella vulgaris, a freshwater species. After five enrichment steps at 60°C, hydrogen yields increased at least 10% under all conditions. Anaerobic digestion of D. tertiolecta and cellulose by TC60 produced 7.7 mmol H₂/g volatile solids (VS) which were higher than the levels (2.9–4.2 mmol/g VS) obtained with cellulose and C. vulgaris biomass. Both microalgal slurries contained satellite prokaryotes. The C. vulgaris slurry, without TC60 inoculation, generated H₂ levels on par with that of TC60 on cellulose alone. The biomass-fed anaerobic digestion resulted in large shifts in short chain fatty acid concentrations and increased ammonium levels. Growth and H₂ production increased when TC60 was grown on a combination of D. tertiolecta and cellulose due to nutrients released from algal cells via lysis. The results indicated that satellite heterotrophs from C. vulgaris produced H₂ but the Chlorella biomass was not substantially degraded by TC60. To date, this is the first study to examine H₂ production by anaerobic digestion of microalgal biomass. The results indicate that H₂ production is feasible but higher yields could be achieved by optimization of the bioprocess conditions including biomass pretreatment.     

Integration of consumer-targeted microalgal production with marine fish effluent biofiltration – a strategy for mariculture sustainability

EU regulations recommend effluent treatment and nutrient recycling for aquaculture sustainability, so a study was undertaken to provide base-line data for the integration of commercial fish-farm effluents with the production of microalgae. The project relates to a specific bivalve consumer (Tapes decussatus) and biofiltration. Effluent inorganic nutrient composition was assessed and evaluated as culture media for Phaeodactylum tricornutum, Tetraselmis suecica and Tetraselmis sp. Optimization of the microalgal compartment included studies on preparation of a simple medium, nutrient or dilution rate manipulation and nutrient removal. Cell harvest was increased chiefly by N correction (6-fold for Tetraselmis sp.) and semi-continuous or continuous operation (by a factor of 3 to 11). Nutrient removal efficiency was high for ammonium and nitrite-nitrogen (80–100%), depending on species, nutrient ratio (Si correction for P. tricornutum) and culture regime for nitrate (41–100%) or phosphorus (21–99%). Data obtained under cyclostat cultivation (yields of 1.38 and 0.50×10⁶ P. tricornutum or Tetraselmis sp. cells mL⁻¹ d⁻¹ and nutrient uptake rates of 2.32 mg N L⁻¹ d⁻¹ and 0.96 mg P L⁻¹ d⁻¹) were used to show clam production and simultaneous wastewater treatment possibilities through the proposed fish-microalgae-clam integrated aquaculture system.     

Glucose and Nitrogen Amendments Can Mitigate Wastewater‐Borne Bacteria Competition Effect Against Algal Growth in Wastewater‐Based Systems

The reuse of wastewater is important for reducing costs involved with algal lipid production. However, nutrient limitations, wastewater‐borne microbes, and mixotrophic growth can significantly affect biomass yields and lipid/biomass ratios. This research compared the growth performances of both Chlorella vulgaris and Pseudokirchneriella subcapitata on domestic wastewater effluent. The experiments were conducted in the presence and absence of wastewater‐borne bacteria, while additionally assessing the impact of distinct nitrate and glucose supplementations. When compared to the sterilized controls, the presence of wastewater‐borne bacteria in the effluent reduced C. vulgaris and P. subcapitata total biomass production by 37% and 46%, respectively. In the corresponding treatments supplemented with glucose and nitrate, total biomass production increased by 12% and 61%, respectively. The highest biomass production of 1.11 and 0.72 g · L^?1 was, however, observed in the sterilized treatments with both glucose and nitrate supplementations for C. vulgaris and P. subcapitata, respectively. Lipid to biomass ratios were, on average, threefold higher when only nitrate was introduced in the sterilized treatments for both species (0.4 and 0.5, respectively). Therefore, the combination of nitrate and glucose supplementation is shown to be an important strategy for enhancing algal lipid and biomass production when those algae are grown in the presence of wastewater‐borne bacteria. On the other hand, in the absence of wastewater‐borne bacteria, only nitrate supplementation can significantly improve lipid/biomass ratios.     

Suitability of nutrients removal from brewery wastewater using a hydroponic technology with <Emphasis Type="Italic">Typha latifolia</Emphasis>

Background

This study aims to assess suitability of hydroponic technology for treatment of brewery wastewater in a hydroponic bioreactor using Typha latifolia. Triplicated hydroponic bioreactor treatment units were designed, constructed and operated at a hydraulic retention time of 5?days with different surface loadings and mean hydraulic loading rate 0.023?m³ m^?2d^??1. Young T. latifolia shoots were collected in the vicinity of study site. Wastewater characteristics, plant growth and nutrient accumulation during experiment were analyzed as per APHA standard methods and nutrient removal efficiency was evaluated based on inlet and outlet values.

Results

T. latifolia established and grew well in the hydroponics under fluctuations of wastewater loads and showed a good phytoremedial capacity to remove nutrients. Significant removal efficiencies (p?<?0.05) varied between 54 and 80% for Total Kjeldahl Nitrogen, 42 and 65% for NH₄⁺ -N, 47 and 58% for NO₃^? -N, and 51 and 70% for PO₄^3?-P. The system improved the removal up to 29% compared to control and produced biomass of 0.61–0.86?kg dry weight (DW) m^??2. Nutrients retained were up to 21.17?g?N?kg^??1 DW and 2.87?g P kg^??1 DW.

Conclusion

The significant nutrients reduction obtained and production of biomass led us to conclude that hydroponics technology using T. latifolia has suitability potential for treatment of brewery wastewater and similar agro-industrial wastewaters. Thus it could be considered as a promising eco-friendly option for wastewater treatment to mitigate water pollution. Integration of treatment and production of biomass needs further improvement.