黑曲霉纤维素酶高产固态培养基的快速优选研究

研究采用正交设计,对影响黑曲霉 Ｆ_２７产纤维素酶的 １０个营养因素在较少水平下进行初选,从中选出对产酶影响显著的４个因素．在此基础上采用均匀设计,在较多水平下进行较少次数的试验,将试验结果用微机逐步回归处理,得到最优回归方程,由回归方程计算出预测极值点和预测极值、优化出高产纤维素酶固态培养基配方．经试验验证,试验实测值和预测值基本相符, ＣＭＣａｓｅ活力平均达 ３７０５Ｕ／ｇ, ＦＰＡ活力平均达 ７．４Ｕ／ｇ．表明对于多因子试验,应用正交设计结合均匀设计的试验方法是快速、简便、可行的．     

爱尔兰帚霉产低温纤维素酶的酶学性质和发酵工艺

本文旨在对爱尔兰帚霉E71702M菌株产低温纤维素酶的酶学性质进行初步研究,并获得其最优发酵条件,为低温纤维素酶开发利用提供参考。通过单因素试验确定温度、pH及金属离子对纤维素酶活力的影响;以Plackett-Burman试验设计从8个培养条件中筛选出影响产酶的3个主要因素,即麸皮含量、装瓶量和起始pH;运用Box-Behnken试验设计及响应面分析法确定这3个主要因素的最优发酵条件。对酶学性质的初步研究表明,该酶最适pH为3.0,最适反应温度为30℃,在0℃时残余酶活力为最适反应温度时的56.3%。响应面分析得到最优发酵条件为:麸皮含量8.79g/L、装瓶量40.93m L、初始pH 4.01。通过优化,纤维素酶活力由0.6338IU/m L提高到1.7386IU/m L,提高了174%。     

家蚕肠道纤维素酶菌株的筛选及产酶条件的优化研究

从5龄家蚕肠道分离筛选得到一株产纤维素酶菌株BMC-2,以羧甲基纤维素酶(CMCase)比活力为响应值,通过Plackett-Burman试验设计、最陡爬坡试验和Box-Behnken试验设计对菌株BMC-2产纤维素酶发酵条件进行优化,结果表明,发酵时间、发酵温度、培养基初始pH和转速对CMCase比活力具有显著影响,其影响程度由大到小依次为发酵时间、培养基初始pH、发酵温度、转速.确定菌株BMC-2产纤维素酶最优发酵条件为:发酵时间94.35 h,发酵温度30.3℃,培养基初始pH 7.01,转速179 r/min.在此条件下, CMCase比活力理论值为25.801 U/mg,验证值为25.526 U/mg,较产酶条件优化前提高了1倍,预测模型可靠性高,可应用于菌株BMC-2产纤维素酶条件的优化.     

固态混合发酵提高木聚糖酶和纤维素酶活力的研究

研究了接种比例、接种时间、碳源、氮源等因素对木霉和黑曲霉混合发酵产木聚糖酶和纤维素酶的影响。试验结果表明,当木霉和黑曲霉按4:6同时接种,以玉米芯3．75g、麸皮3．75g、葡萄糖37．5mg为混合碳源,Mandels营养盐11．5mL、添加NH_4NO_37．5mg为氮源,在84h产纤维素酶活力达到230IU/g干物质,木聚糖酶活力达到1308IU/g干物质,与两菌纯培养相比,纤维素酶活力提高163％,木聚糖酶活力提高79．5％。     

家蚕肠道环境对外源纤维素酶活力稳定性影响的研究

纤维素酶对家蚕消化桑叶纤维素起重要生理作用,本试验研究了不同温度、pH对外源纤维素酶活力的影响及纤维素酶的热稳定性与pH稳定性,同时在模拟家蚕肠道环境条件下,研究了纤维素酶活力的稳定性。结果表明：所选的外源纤维素酶在家蚕肠液中的最适催化温度为30℃左右,最适pH为8．0左右;酶在家蚕体温范围内具有较好的稳定性,在pH8．0-10．0范围内酶活力较稳定;模拟家蚕肠道环境条件下酶活力稳定性实验表明,在80min时间内,纤维素酶能够保持较高的活力而发挥生物活性。     

Identification and optimal degradation conditions for cellulase-degrading enzyme of a methanol-utilizing and cellulase-producing bacterium

采用刚果红染色法,从废弃矿山周边土壤中筛选出一株产纤维素酶的甲醇利用细菌,命名为xt - 04.形态特征、生理试验及16S rDNA序列和gyrB序列分析表明,该菌株属于Bacillus methylotrophicus.为提高该菌所产纤维素酶的降解能力,首先通过单因子实验考察了底物CMC -Na浓度、反应温度及缓冲液pH值对纤维素酶活力的影响;然后采用响应面分析法对影响纤维素酶活力的3个单因子进行了优化.结果表明,单因素实验得出的适宜反应温度、缓冲液pH和底物浓度分别为70℃、5.0和2％ (20 mg/mL);响应面法得出的最高酶活力条件:反应温度、pH和底物浓度分别为66.1℃、4.81和19.01mg/mL.在最优条件下,酶活力达到17.85 U/mL,比优化前的酶活力12.84 U/mL提高了39.01％.因此,鉴于这种纤维素酶能耐受较高温度和酸性条件,该菌株所产纤维素酶可能在工业中具有良好的应用前景.     

一株产纤维素酶的甲醇利用细菌的鉴定及其纤维素降解条件优化

采用刚果红染色法,从废弃矿山周边土壤中筛选出一株产纤维素酶的甲醇利用细菌,命名为xt-04。形态特征、生理试验及16SrDNA序列和gyrB序列分析表明,该菌株属于Bacillusmethylotrophicus。为提高该菌所产纤维素酶的降解能力,首先通过单因子实验考察了底物CMC—Na浓度、反应温度及缓冲液pH值对纤维素酶活力的影响;然后采用响应面分析法对影响纤维素酶活力的3个单因子进行了优化。结果表明,单因素实验得出的适宜反应温度、缓冲液pH和底物浓度分别为70℃、5．0和2％（20mg／mL）;响应面法得出的最高酶活力条件：反应温度、pH和底物浓度分别为66．1℃、4．81和19．01mg／mL。在最优条件下,酶活力达到17．85U／mL,比优化前的酶活力12．84U／mL提高了39．01％。因此,鉴于这种纤维素酶能耐受较高温度和酸性条件,该菌株所产纤维素酶可能在工业中具有良好的应用前景。     

烟草叶肉细胞原生质体培养成植株的研究

应用自制的纤维素酶从三个烟草品种的叶肉组织获得大量完整的有活力的原生质体,阐述了影响原生质体活力的某些因素。详细叙述了烟草原生质体的培养过程和方法,由于培养技术的改进,试验所用三个烟草品种的叶肉原生质体已经生长分裂形成愈伤组织,并分化成再生植株。此外,观察到“金星”的双倍体与单倍体叶肉原生质体在同一培养基上生长的差异。并对自制纤维素酶与日本纤维素酶(Onozuka)进行了比较。讨论了烟草原生质体从体积增大到细胞分裂形成愈伤组织过程中必须移贴的原因。     

不同年龄泥蚶几种消化酶活性的季节变化

对不同年龄乐清养殖的泥蚶蛋白酶、淀粉酶和纤维素酶活性的季节变化进行了研究,经双因子方差(two—way ANOVA)分析,结果表明,季节显著影响蛋白酶、淀粉酶和纤维素酶活力;年龄显著影响蛋白酶、淀粉酶活力,对纤维素酶无显著影响;季节和年龄相互作用显著影响蛋白酶、淀粉酶和纤维素酶活力。     

秸秆质外体蛋白对纤维素酶活力的影响

研究了玉米秸秆在储存过程中质外体蛋白含量的变化情况,及其对Penicilllumexpansum纤维素酶活力的影响。结果表明随着储存时间的延长,可抽提的玉米秸秆质外体蛋白的数量逐渐减少,与P.expansum纤维素酶的协同作用也随之减弱。储存玉米秸秆质外体蛋白没有内源性纤维素酶活力,而新鲜玉米秸秆有内源性EG活性,但它的稳定性较差,储存半年后基本降解或失活。储存秸秆质外体蛋白对FPA酶活力、棉花酶活力、β-葡萄糖苷酶活力有明显的增效作用,最大增效分别达到95.32%、102.06%和96.6%。而对CMCase却表现出抑制作用,最大抑制率为49.52%,质外体蛋白-EG-βG表现出明显的协同关系,而它对CBH酶活力没有影响。消除内源性EG的影响后,新鲜玉米秸质外体蛋白对FPA活力、棉花酶活力、β-葡萄糖苷酶活力的促进率,以及CMCase的抑制率均高于储存秸秆的质外体蛋白。可见质外体蛋白是天然纤维素酶解研究不可忽视的影响因素。     

纤维素酶-超声波协同提取黑木耳黑色素工艺及其抗氧化活性分析

黑色素是黑木耳的主要活性成分之一,在黑木耳的药理活性上发挥着重要作用。为了提高黑木耳黑色素的提取得率,实验采用正交法和响应面法对纤维素酶-超声波协同提取黑木耳黑色素的提取工艺进行了优化,并对最优条件下提取的黑木耳黑色素体外抗氧化活性进行了分析。实验结果表明,纤维素酶-超声波协同提取黑木耳黑色素的最优条件为:酶添加量12mg,酶解温度40℃,酶解pH 5.0,酶解时间120min,NaOH浓度1.27mol/L,料液比1:40,超声功率300W,超声时间52min,超声温度60℃。在最优条件下,黑木耳黑色素提取得率可达到10.48%,相比于实验设置的未添加纤维素酶的超声波组黑色素提取得率提高了12.93%。抗氧化结果表明,采用纤维素酶-超声波协同提取的黑色素相比于未加纤维素酶提取的黑色素清除ABTS、DPPH和羟基自由基的能力更强。研究结果为黑木耳黑色素的高效提取及其产品的应用开发奠定了基础。     

Extremely low frequency magnetic field effects on metabolite of Aspergillus niger

The effect of the extremely low frequency (ELF) magnetic field on citric acid and cellulase production by Aspergillus niger using liquid Charles culture medium was studied during shake flask culture. The cellular suspension was exposed to a magnetic field (t = 4 h, B = 1 mT, and f = 50 Hz). The dependence of yield of citric acid and activity of cellulase on time of exposure and on the value of the magnetic field induction B was measured. Both yield of citric acid and activity of cellulase increased with increasing exposure time and/or induction B, but the quantity of the effect was dependent on the chemical structure of metabolites. The metabolism of citric acid was more sensitive to the magnetic field than that of cellulase. From the measurement of the metabolism dynamics we concluded that the increase in the citric acid and activity of cellulase started immediately after the magnetic field was switched on.     

Optimization of the Cellulase−Ultrasonic Synergistic Extraction Conditions of Polysaccharides from Lenzites betulina

Lenzites betulina has been recognized as a rich source of chemical components, including polysaccharides, sterides and sugar alcohols. In this study, cellulase?ultrasonic synergistic extraction method was applied to extract polysaccharides from L. betulina, and the response surface methodology was used to optimize the extraction conditions. The eight basic factors affecting extraction yield were evaluated by Plackett?Burman design (PBD). Then, the four important factors significantly affecting the yield of polysaccharides from L. betulina, including enzymolysis temperature, enzymolysis time, ultrasound time and ultrasound temperature, were optimized by Box?Behnken design (BBD). Maximum extraction yield of L. betulina polysaccharides was 13.64±0.09 % at a cellulase dosage of 0.8 %, enzymolysis temperature of 60 °C, enzymolysis time of 180 min, pH of 4.5, liquid‐solid ratio of 45 ml/g, ultrasound power of 300 W, ultrasound time of 20 min and ultrasound temperature of 45 °C. Subsequently, the characteristic structure of crude polysaccharides was determined by FT‐IR. Results indicated that cellulase?ultrasonic synergistic treatment is suitable for L. betulina polysaccharides extraction, and it has good prospect for development and utilization.     

酶法辅助超声波微波仪从胡桃青皮中提取胡桃醌的工艺研究

以胡桃青皮为原料,在优化酶解与超声波微波萃取仪提取条件下,用硅胶层析法制取胡桃醌,并检测其纯度和含量。经过对多种提取条件的优化,确定其最佳酶解条件为:1%纤维素酶和1%果胶酶各400μL等量混合,固液比1∶20,温度55℃,pH 6.2,时间15 h。最佳提取条件是以氯仿作提取剂,固液比1∶20;在超声波恒定条件下,超声波微波萃取仪处理15 min;设置温度分别为55、60、65℃,超声波功率800、900、1 000 W,微波功率200、250、300 W,超声波频率25 kHz,模式15∶10,电机转速900 r·min-1。硅胶柱干法上样,用氯仿和石油醚分阶段洗脱得到较纯的胡桃醌制品。光度计测得胡桃醌平均含量为0.49%,纯度为81.7%。     

响应面法优化红景天总黄酮提取工艺的研究

研究了红景天中总黄酮提取率的影响因素,先经单因素实验初步确定影响因素,再用Box-Behnken响应面法建立影响因素的二次回归模型,通过对二次回归模型求解编码转换得知,液料比40:1(ml/g),酶添加量1.2%,酶解时间4.5 h,酶解温度45℃,pH5,超声时间为12 min,超声功率为250w中的高档,超声次数为3次,在这最优条件下总黄酮提取率为3.99%。     

Enhanced co-production of pectinase,cellulase and xylanase enzymes from Bacillus subtilis ABDR01 upon ultrasonic irradiation

The effect of low-intensity ultrasound irradiation was studied to improve the co-production for pectinase, cellulase, and xylanase enzymes using Bacillus subtilis ABDR01. Different parameters such as ultrasonic irradiation at the different growth phases of the bacterial strain, ultrasound power, irradiation duration, and irradiation duty cycle were assessed. Sonication with 90 W ultrasound power, 25 kHz frequency with 70 % duty cycle for 5 min at 6 h of bacterial growth phase gave the maximum productions of 87.82 U/ mL pectinase 22.17 U/ mL cellulase and 137.95 U/ mL xylanase respectively. The enzyme activity of pectinase, cellulase, and xylanase was enhanced by about 38.15 %, 53.77 %, and 24.59 %, respectively, compared to non-sonicated control cultivation. This optimized low-frequency ultrasound irradiation to bacterial cells enhanced the nutrient uptake rate and increased the cell wall permeability, which results in higher enzyme productivity. Our results signify the effectiveness of low-frequency ultrasound irradiation for improved enzyme yields and hyperactivation during microbial fermentation.     

里氏木霉产纤维素酶研究进展

木质纤维素类生物质被认为是重要且可持续的可再生能源,其主要组成部分是纤维素.纤维素酶是一种能将纤维素分解为葡萄糖的复合酶,能有效地降解木质纤维素生物质.真菌、细菌、放线菌、酵母等多种微生物均可以产生纤维素酶,其中里氏木霉具有完整的纤维素酶系结构,常作为生物技术领域中一个重要菌株,广泛应用于纤维素酶的商业生产.介绍了纤维...     

Cellulose in algal cell wall: an "in situ" localization.

In order to ascertain the presence and the in muro localization of cellulose, the enzyme-gold affinity test was applied to algal cell walls. The high specificity of affinity cytochemistry allowed us, by using the enzyme cellulase, to confirm the available biochemical data and to give a map of the cellulose localization in different algal groups. Taking into account the complex skeletal polysaccharide structure and composition of the algal cell walls, this method proved to be a reliable tool in this field.     

一株毛栓菌静置液体发酵产纤维素酶条件研究

考察一株新分离的毛栓菌静置产纤维素酶的条件,通过单因素试验和正交设计试验分别对培养基初始pH、培养基中的碳源、氮源及诱导物进行研究。利用DNS（3,5-二硝基水杨酸）法测定CMC-Na（羧甲基纤维素钠）纤维素酶活。结果表明：该毛栓菌静置发酵产纤维素酶的最适pH为5.0,最适碳源、氮源和诱导物分别是淀粉、酵母粉和干麸皮,且质量浓度分别为淀粉1%、酵母粉0.4%、干麸皮1.5%,在此条件下,进行静置发酵3d,可获得CMC-Na（羧甲基纤维素钠）纤维素酶活力最高为56.62U/mL。此研究开创了纤维素酶生产菌的新发现,与以往所报道的好氧产纤维素酶菌种黑曲霉、木霉等相比,具有发酵时间短、耗能小等优点,具有一定的潜在应用价值。     

Hydrolytic enzyme activity in landfilled refuse

Extracellular hydrolytic enzyme activity was assayed in 28 refuse samples excavated from 14 bore holes in Fresh Kills Landfill, Staten Island, N. Y. Esterases, proteases and amylases were present in all of the samples. Enzyme screening assays utilizing the API-ZYM test system showed the incidence of enzymes in the order: specific phosphatases > esterases > glycosyl hydrolases. Measurement of cellulase by the cellulose-azure test detected activity in two out of 28 samples. Analysis for cellulase activity using the cellulose-azure test on refuse samples from landfills in Naples, Florida, and Tucson, Arizona, also showed a limited distribution of cellulases. Mineralization of [¹⁴C]cellulose, an independent measure of cellulase activity, ranged from < 5 to 23% in a 4-week incubation, which supports a highly variable cellulolytic activity in landfilled refuse. Correspondence to: A. C. Palmisano