彩绒革盖菌固体发酵生产木质素酶工艺优化研究*

采用均匀设计U15(5^8)和双温度培养法进行彩绒革盖菌固体发酵生产木质素酶,对漆酶、愈创木酚酶、多酚氧化酶的活力进行回归分析。结果表明：应用双温度培养法进行彩绒革盖菌固体发酵生产木质素酶时,在自然补给氧气,培养基pH自然(约6．5),并保持环境湿度约60％的条件下,20d是适宜的发酵周期;玉米浆、麸皮、(NH4)2SO4、水分适宜作为固体培养基的成分;少量的Tween-80有利于木质素酶的生产。     

彩绒革盖菌CV—8漆酶和多酚氧化酶活性

彩绒革盖菌（Ｃｏｒｉｌｕｓｖｅｒｓｉｃｏｌｏｒ）是一种具有木质素降解能力的白腐菌,其降解木素的能力主要取决于木质素过氧化物酶、漆酶、多酚氧化酶和愈创木酚氧化酶的活力高低,所以研究其活力和分泌情况对木质素的生物降解、生物制浆和环境保护具有十分重要的意义。国外已有彩绒革盖菌漆酶的报道［１,２］,但主要集中在漆酶对木质素作用后所造成的木质素结构上的变化,有关漆酶和多酚氧化酶的活性分析报道较少［３］;国内有关的研究报道更少［４,５］,至今未见彩绒革盖菌漆酶和多酚氧化酶的研究报道。本文主要测定了彩绒革盖菌…     

碳源和氮源对彩绒革盖菌液体发酵合成漆酶的影响

研究了碳源、氮源对彩绒革盖菌液体发酵合成漆酶的影响。结果表明,在所选的几种碳、氮源中,麸皮为试验菌株合成漆酶的较好碳源;酵母浸膏、酒石酸铵、蛋白胨均是比较理想的氮源。不同的碳氮比对彩绒革盖菌漆酶的产量有着显著的影响,高碳高氮是其生产漆酶的最佳条件。在适宜的培养条件下该菌株能合成高活力的漆酶,其酶活力可达298 U/mL以上,产酶周期为6~7 d。     

不同真菌漆酶的性质研究

为了更好开发利用漆酶,用邻联甲苯胺法比较分析了彩绒革盖菌、毛栓菌和多孔菌在液体培养时的产酶曲线、酶作用的最适pH值、最适酶解温度及无机离子对酶活的影响。结果表明,不同漆酶产酶曲线不同,彩绒革盖菌和多孔菌,第9d达产酶高峰,峰值活力分别达395.6u/ml和412.2u/ml;毛栓菌,第11d达到产酶高峰,峰值本科活较不同真菌漆酶的性质研究高达554.6u/ml。漆酶性质有明显差别,最适酶解温度不同,彩绀革盖菌和多孔菌漆酶最适酶解温度为25℃;毛栓菌为30℃;最适酶解pH值有差异,彩绒革盖菌漆酶最适酶解,pH值为4.5,毛栓菌为4.0,多孔菌为4.2;不同离子对酶活的影响不同;K^、Zn^2 、对彩绒革盖菌所产漆酶有激活作用;K^ 、Zn^2 、Cu^2 对毛栓菌所产漆酶有激活作用;Mn^2 、Mg^2 对多孔菌所产漆酶有激活作用;Ag^ 、Fe^3 对三种菌所产漆本科均有明显抑制作用。     

从白腐菌中筛选漆酶高产菌株的初步研究

从中国分离的149株木腐菌中,有30株具有漆酶活性。在添加了阿魏酸的液体培养基中,漆酶产量高(每升培养液中漆酶含量在10000单位以上)的菌株有9个:游离细胞培养的彩绒革盖菌Coriolus versicolor G30,相邻小孔菌Microporus affinis G07,血红密孔菌Pycnoporus sanguineus W006,W006-2,W3008,G05和香菇Lentinus edodes G18,以及固定细胞培养的鲑贝革盖菌Coriolus consors 98563和干酪菌Tyromyces sp. 98420。彩绒革盖菌、相邻小孔菌和血红密孔菌具有重要的生物工程研究价值。     

从白腐菌中筛选漆酶高产菌株的初步研究

从中国分离的149株木腐菌中,有30株具有漆酶活性,在添加了阿魏酸的液体培养基中,漆酶产量高（每升培养液中漆酶含量在10000单位以上）的菌株有9个,游离细胞培养的彩绒革盖菌Coriolus versicolor G30,相邻小孔菌Microporus affinis G07,血红密孔菌Pycnoporus sanguineus W006,W006-2,W3008,G05和香菇Lentinus edodes G18,以及固定细胞培养的鲑贝革盖菌Coriolus consors 98563和干酪菌Tyromyces sp.98420。彩绒革盖菌,相邻小孔菌和血红密孔菌具有重要的生物工程研究价值。     

碳素和氮素对Coriolus versicolor胞外酶分泌的影响

采用单因子相互比较法研究了不同碳素和氮素对彩绒革盖菌胞外漆酶,愈创木酚氧化酶,多酚氧化酶,锰过氧化物酶等木素降解酶分泌的影响,结果淀粉作碳源,干酪素作氮源有利于漆酶的分泌,麦芽粉作碳源,酵母膏作氮源有利于愈创木酚氧化酶和多酚氧化酶的分泌,淀粉作碳源,玉米粉作氮源有利于锰过氧化物酶的分泌。     

碳源和氮源对彩绒革盖菌Coriolus versicolor木质纤维素酶和木质素酥分泌

研究了彩绒革盖菌在不同硬源和氮源培养基中生长时,对纤维素酶、革纤雄素酶、本质素酶（漆酶、多酚氧化酶、愈创木酚氧化酶）分泌的影响。表明不同碳源和氮源对酶类失发泌影响很大,富含淀粉的物质能明显促进本质素酶的分泌,而专一性底物（纤维素和半纤维素）对纤维素酶和半纤维素酶有诱导作用,麸皮也能话导半纤维素酶的产生。     

高酶活菌株的筛选及漆酶特性

通过Bavendamn氏反应和液体发酵实验筛选出漆酶高产菌株 ,并对其产酶条件和酶活性进行了研究。结果表明 71株实验真菌中有 64株Bavendamn氏反应呈阳性 ,且阳性菌株都具有漆酶活性 ;不同菌株产酶培养基最适碳源、氮源不同 ,采绒革盖菌以淀粉为碳源、干酪素为氮源 ,毛栓菌以麦草粉为碳源、硫酸铵为氮源 ,有利于酶的分泌 ;不同来源漆酶性质不尽相同 ,采绒革盖菌漆酶最适酶解温度为 2 5℃ ,最适酶解pH值为4.6,毛栓菌则分别为 3 0℃和 pH 4.0 ;K+ ,Zn2 + 等对 2种漆酶均有激活作用 ,Ag+ 则能明显抑制漆酶活性。     

普洱茶渥堆发酵与堆肥渥堆发酵的比较研究

普洱茶的自然渥堆发酵工艺与农业及环保中的堆肥发酵工艺在堆垛方法、堆垛形状和大小、自然升温过程、高温发酵、翻堆工艺等方面有许多相似之处,主要差别是原料和含水量的不同。对不同原料堆肥已有详细的研究及其动态菌群和多种发酵剂的研究和应用报道,明确了高温菌在渥堆发酵过程中起重要作用,对其翻堆工艺也有较详细的参数及其机械化的应用,但普洱茶渥堆发酵基本上还停留在自然发酵、人工翻堆、常温菌的研究及老茶头作发酵剂的应用等水平上。堆肥的许多研究手段和方法甚至物质转化、脱毒、高温菌的研究等都值得普洱茶渥堆发酵研究加以借鉴。     

Anaerobic digestion of alcohol sulfate (anionic surfactant) rich wastewater--batch experiments. Part II: influence of the hydrophobic chain length

The mineralisation and the humification of organic matter (OM) in sterile horticultural plant wastes inoculated with Coriolus versicolor or Phanerochaete flavido-alba was investigated under different aeration rates in order to determine their efficacy as potential inoculants for composting. The change in elemental composition, lignin content and OM fractions was analysed during a 90-day incubation. Both fungi degraded 30% of lignin at low aeration rates. Different aeration rates led to significant changes in OM mineralisation induced by C. versicolor, but did not have noticeable effect on P. flavido-alba activity. The mineralisation was more effectively carried out by P. flavido-alba than by C. versicolor. Lignin degradation and the linked humification process were equally achieved by the two fungi and were enhanced in aerated conditions. The fungi analysed may facilitate the composting of lignocellulosic wastes by means of an increase in substrate bioavailability and OM humification.     

云芝的化学成分及药理活性研究概况

通过文献检索对云芝的化学成分及药理活性方面进行了综述。研究发现云芝含甾体类、三萜类、有机酸类、生物碱类、葡糖醇类、蛋白质类、糖类、糖肽类等29个化合物,还含胞外黏性物质（ECMM）、胃蛋白酶抑制剂、真菌激发子、铁黏合螯合剂、环肽、18种人体所需的氨基酸和维生素B1、B2、B6及铜、铁、钾、锌等10多种人体所需的活性微量...     

枸杞子对云芝菌丝体生长和多糖含量的影响

本文主要研究了枸杞子水煎液的不同浓度对云芝菌丝体生长和云芝多糖积累的影响,试验结果表明,低浓度的枸杞子水煎液有明显的促进作用,高浓度的枸杞子水煎液不表现过强的抑制作用.     

Enzyme production-based approach for determining the functions of microorganisms within a community

The functions of specific microorganisms in a microbial community were investigated during the composting process. Cerasibacillus quisquiliarum strain BLx(T) and Bacillus thermoamylovorans strain BTa were isolated and characterized in our previous studies based on their dominance in the composting system. Strain BLx(T) degrades gelatin, while strain BTa degrades starch. We hypothesized that these strains play roles in gelatinase and amylase production, respectively. The relationship between changes in the abundance ratios of each strain and those of each enzyme activity during the composting process was examined to address this hypothesis. The increase in gelatinase activity in the compost followed a dramatic increase in the abundance ratio of strain BLx(T). Zymograph analysis demonstrated that the pattern of active gelatinase bands from strain BLx(T) was similar to that from the compost. Gelatinases from both BLx(T) and compost were partially purified and compared. Homologous N-terminal amino acid sequences were found in one of the gelatinases from strain BLx(T) and that of compost. These results indicate strain BLx(T) produces gelatinases during the composting process. Meanwhile, the increase in the abundance ratio of strain BTa was not concurrent with that of amylase activity in the compost. Moreover, the amylase activity pattern of strain BTa on the zymogram was different from that of the compost sample. These results imply that strain BTa may not produce amylases during the composting process. To our knowledge, this is the first report demonstrating that the function of a specific microorganism is directly linked to a function in the community, as determined by culture-independent and enzyme-level approaches.     

Comparison of characterization and microbial communities in rice straw- and wheat straw-based compost for <Emphasis Type="Italic">Agaricus bisporus</Emphasis> production

Rice straw (RS) is an important raw material for the preparation of Agaricus bisporus compost in China. In this study, the characterization of composting process from RS and wheat straw (WS) was compared for mushroom production. The results showed that the temperature in RS compost increased rapidly compared with WS compost, and the carbon (C)/nitrogen (N) ratio decreased quickly. The microbial changes during the Phase I and Phase II composting process were monitored using denaturing gradient gel electrophoresis (DGGE) and phospholipid fatty acid (PLFA) analysis. Bacteria were the dominant species during the process of composting and the bacterial community structure dramatically changed during heap composting according to the DGGE results. The bacterial community diversity of RS compost was abundant compared with WS compost at stages 4–5, but no distinct difference was observed after the controlled tunnel Phase II process. The total amount of PLFAs of RS compost, as an indicator of microbial biomass, was higher than that of WS. Clustering by DGGE and principal component analysis of the PLFA compositions revealed that there were differences in both the microbial population and community structure between RS- and WS-based composts. Our data indicated that composting of RS resulted in improved degradation and assimilation of breakdown products by A. bisporus, and suggested that the RS compost was effective for sustaining A. bisporus mushroom growth as well as conventional WS compost.     

Enzyme Production-Based Approach for Determining the Functions of Microorganisms within a Community

The functions of specific microorganisms in a microbial community were investigated during the composting process. Cerasibacillus quisquiliarum strain BLx^T and Bacillus thermoamylovorans strain BTa were isolated and characterized in our previous studies based on their dominance in the composting system. Strain BLx^T degrades gelatin, while strain BTa degrades starch. We hypothesized that these strains play roles in gelatinase and amylase production, respectively. The relationship between changes in the abundance ratios of each strain and those of each enzyme activity during the composting process was examined to address this hypothesis. The increase in gelatinase activity in the compost followed a dramatic increase in the abundance ratio of strain BLx^T. Zymograph analysis demonstrated that the pattern of active gelatinase bands from strain BLx^T was similar to that from the compost. Gelatinases from both BLx^T and compost were partially purified and compared. Homologous N-terminal amino acid sequences were found in one of the gelatinases from strain BLx^T and that of compost. These results indicate strain BLx^T produces gelatinases during the composting process. Meanwhile, the increase in the abundance ratio of strain BTa was not concurrent with that of amylase activity in the compost. Moreover, the amylase activity pattern of strain BTa on the zymogram was different from that of the compost sample. These results imply that strain BTa may not produce amylases during the composting process. To our knowledge, this is the first report demonstrating that the function of a specific microorganism is directly linked to a function in the community, as determined by culture-independent and enzyme-level approaches.     

Humic substances change during the co-composting process of municipal solid wastes and sewage sludge

The change of the degree of stability of compost during the composting process was a kind of guideline for our study. This stability was estimated by monitoring the chemical fractionation (extraction of humic and fulvic acids, and humin) during two cycles of composting. Change of humin (H), humic-like acid carbon (CHA) and fulvic-like acid carbon (CFA) fractions during the composting process of municipal solid wastes were investigated using two windrows W1 (100% of municipal solid wastes) and W2 (60% of municipal solid wastes and 40% of dried sewage sludge). Humin and fulvic acid fractions in the two windrows decreased since the start of composting process and tend to stabilize. At the end of composting process, humic acid fraction is more important in the windrow without sludge (W1) than the one with sludge (W2). The humification indexes used in this study showed that the humic-like acid carbon fraction production takes place largely during the phase of temperature increase (thermophilic phase), and it appeared very active in the windrow W2. At the end of composting process, the E₄/E₆ ratio value indicated that the compost of W1 is more mature than the compost of W2. The humification ratio (HR) allowed a correct estimation of compost organic matter stabilization level.     

Heat inactivation of Salmonella spp. in fresh poultry compost by simulating early phase of composting process

Aims: The purpose of this study was to determine the effect of moisture on thermal inactivation of Salmonella spp. in poultry litter under optimal composting conditions. Methods and Results: Thermal inactivation of Salmonella was studied in fresh poultry compost by simulating early phase of composting process. A mixture of three Salmonella serotypes grown in Tryptic soy broth with rifampin (TSB‐R) was inoculated in fresh compost with 40 or 50% moisture at a final concentration of c. 7 log CFU g^?1. The inoculated compost was kept in an environmental chamber which was programmed to rise from room temperature to target composting temperatures in 2 days. In poultry compost with optimal moisture content (50%), Salmonella spp. survived for 96, 72 and 24 h at 50, 55 and 60°C, respectively, as compared with 264, 144 and 72 h at 50, 55 and 60°C, respectively, in compost with suboptimal moisture (40%). Pathogen decline was faster during the come‐up time owing to higher ammonia volatilization. Conclusions: Our results demonstrated that Salmonella spp. survived longer in fresh poultry compost with suboptimal moisture of 40% than in compost with optimal moisture of 50% during thermophilic composting. High nitrogen content of the poultry compost is an additional factor contributing to Salmonella inactivation through ammonia volatilization during thermal exposure. Significance and Impact of the Study: This research validated the effectiveness of the current composting guidelines on Salmonella inactivation in fresh poultry compost. Both initial moisture level and ammonia volatilization are important factors affecting microbiological safety and quality of compost product.     

杂色云芝漆酶基因(Lcc1)的克隆及在甲醇毕赤酵母中的表达

以白腐菌杂色云芝Coriolus versicolor RNA为模板,通过RT-PCR获得漆酶Leel基因的cDNA片段。构建了甲醇酵母表达质粒pMETA-Lccl载体,并将其线性化后用电穿孔法导入Pichia methabolica PMAD16,部分阳性克隆的PCR结果表明Lccl基因已经整合到甲醇毕赤酵母染色体上,经摇瓶培养筛选出表达水平较高的酵母工程菌株。漆酶酶活力达53U/L