Modified use of a commercial ELISA kit for deoxynivalenol determination in rice and corn silage

The analysis of deoxynivalenol (DON) in silage samples using enzyme-linked immunosorbent assay (ELISA) often leads to an overestimation. To better analyze DON in rice and corn silages using a commercially available ELISA kit, a cleanup method using a MultiSep #226 column was developed. As a result, overestimation of DON by the influence of specific cross-reaction with acetyldeoxynivalenol (AcDON) was confirmed. In samples where AcDON was not detected by liquid chromatography with mass spectrometry (LC-MS), no samples showed a significant difference (P?<?0.05) in DON amounts between ELISA with cleanup and LC-MS analysis. For the recovery study, blank silage was spiked with 0.5 or 1.0 mg/kg DON. The mean recoveries of DON determined by ELISA with cleanup and LC-MS analysis were 112 and 96 %, respectively, and the relative standard deviation for the repeatability (RSD_r) were 8.2 and 9.8 %, respectively. No samples showed a significant difference (P?<?0.05) in DON concentration determined by either ELISA or LC-MS analysis. A collaborative study to validate this rapid method was carried out using four samples, two rice and two corn silage, by 10 participating laboratories. Each sample was analyzed using blind duplicates. The mean values of DON detected were 1.5–2.3 mg/kg, RSD_r and the relative standard deviation for the reproducibility (RSD_R) were 4.1–12.7 and 7.6–23.4 %, respectively, and the HorRat values were 0.5–1.6. Therefore, the overestimation of DON by the influence of nonspecific cross-reaction with sample matrix was reduced by the cleanup method using a MultiSep #226 column, and analysis of DON in silage was improved. This use of this method for estimation of DON contamination in silage allows rapid detection at the place of use that is likely to result in improved animal health.     

T-2 and HT-2 toxin analysis in cereals and cereal products following IAC cleanup and determination via GC-ECD after derivatization

The authors present a new and sensitive method for the determination of T-2- und HT-2 Toxin in cereals and cereal products in the low ppb level. A representative part of the cereal sample is extracted with a mixture of methanol-water (90:10) and the extract is cleaned on the commercially available immunoaffinity column T-2test™ (IAC), eluted with methanol, derivatized by pentafluorpropionic anhydride (PFPA) and measured on a GC-ECD. The method has been successfully validated on wheat, rye and oats. The recovery rates with wheat and rye endowed on a level of 50 ppb and with 85 ppb naturally contaminated oats were 71–115% with a coefficient of variation of 5.7–19.5%. The detection limits of the method with a signal to noise level of 3:1 were 1.5–2.3 μg/kg for HT-2 and 1.1–1.7 μg/kg for T-2 toxin. Financial support: Federal Ministry of Food and Agriculture (part of the project 05HS 001 — Improvement and validation of type A trichothecene (T-2 toxin and HT-2 toxin) analysis and occurrence of these mycotoxins in food marketed in Germany)     

Rapid fluorometric test for the quantitative determination of deoxynivalenol in raw cereals

Fast test systems fulfilling legislative specifications are required to determine mycotoxin contamination in unprocessed cerealse.g. at grain elevators, import and export terminals, or the milling and brewing industry to prevent contamination of food and feed. We describe the first tests of a novel fluorescence-based test for deoxynivalenol (DON), which will be commercially available within the next few months. The analytical procedure of the new test takes less than 15 minutes for extraction, purification, derivatization and measurement. The system’s advantage is its speed and easy procedure providing quantitative DON determination. To ensure an international standard, the validation procedure for wheat, barley and maize will be performed following USDA/GIPSA requirements (03/2006) for DON tests. Presented at the 28^th Mykotoxin-Workshop, Bydgoszcz, Poland, May 29–31, 2006 Financial support: Christian Doppler Society and Government of Lower Austria     

Untersuchungen zu DON-Gehalten in Getreideerzeugnissen aus dem deutschen Einzelhandel im Jahr 2006

Samples of soft wheat flour (n=78), durum wheat semolina (n=6), and pasta (made from durum wheat, n=49) were purchased in January-April 2006 from retail outlets in Hesse, Germany. Samples were analysed for deoxynivalenol (DON) by enzyme immunoassay. The detection limit of the method was 10 μg/kg, with recoveries of 81–85% (RSD_r: 12–17%). DON was detected in 84% of all samples, but the contamination level was low. Median/maximum values for DON in wheat flour, wheat semolina, and pasta were 28μg/kg/217 μg/kg, 38μg/kg/203 μg/kg, and 24μg/kg/119 μg/kg, respectively. Compared with results obtained from previous years, significantly lower DON levels were observed in these commodities.     

Development,validation and application of a multi-mycotoxin method for the analysis of whole wheat plants

Mycotoxins are known to affect the health of humans and husbandry animals. In contrast to wheat grains used for food and feed, whole wheat plants are rarely analysed for mycotoxins, although contaminated straw could additionally expose animals to these toxic compounds. Since the entire wheat plant may also act as source of mycotoxins emitted into the environment, an analytical method was developed, optimised and validated for the analysis of 28 different mycotoxins in above-ground material from whole wheat plants. The method comprises solid-liquid extraction and a clean-up step using a Varian Bond Elut Mycotoxin^® cartridge, followed by liquid chromatography with electrospray ionisation and triple quadrupole mass spectrometry. Total method recoveries for 26 out of 28 compounds were between 69 and 122% and showed limits of detection from 1 to 26 ng/g_{dry weight (dw)}. The overall repeatability for all validated compounds was on average 7%, and their mean ion suppression 65%. Those rather high matrix effects made it necessary to use matrix-matched calibrations to quantify mycotoxins within whole wheat plants. The applicability of this method is illustrated with data from a winter wheat test field to examine the risks of environmental contamination by toxins following artificial inoculation separately with four different Fusarium species. The selected data originate from samples of a part of the field which was inoculated with Fusarium crookwellense. In the wheat samples, various trichothecenes (3-acetyl-deoxynivalenol, deoxynivalenol, diacetoxyscirpenol, fusarenone-X, nivalenol, HT-2 toxin, and T-2 toxin) as well as beauvericin and zearalenone were identified with concentrations ranging from 32 ng/g_dw to 12 × 10³ ng/g_dw.     

Bestimmung von DON-3-Glukosid in künstlich und natürlich kontaminiertem Weizen mittels LC-MS/MS

Naturally contaminated and artificiallyFusarium spp. inoculated wheat was analyzed for deoxynivalenol, deoxynivalenol-3-glucoside, 3-acetyl-deoxynivalenol and 15-acetyl-deoxynivalenol. After extraction and clean-up with MycoSep columns, the trichothecenes were determined using a LC-ESI-MS/MS method. Deoxynivalenol-3-glucoside was detectable in 4 out of 4 artificially inoculated and in 22 out of 25 naturally contaminated wheat samples. For the latter, the average relative deoxynivalenol-3-glucoside concentration was about 6% of the deoxynivalenol concentration. The maximum relative deoxynivalenol-3-glucoside concentration was 12% as compared to the concentration of deoxynivalenol. In all samples, the concentration of deoxynivalenol-3-glucoside was higher than the concentrations of 3-acetyl-deoxynivalenol or 15-acetyl-deoxynivalenol.

Financial support: Christian Doppler Society, Austrian Genome Research Intiative (GEN-AU)     

Influence of water activity on deoxynivalenol accumulation in wheat

The influence of water activity (a_w) on deoxynivalenol accumulation in wheat at 25°C was studied. Gnotobiotic grains were conditioned at different a_w levels, inoculated with a toxigenic Fusarium graminearum strain, and incubated for ten weeks. The highest accumulation of deoxynivalenol (1130 ug/kg) was detected at a_w 0.980. At a_w 0.945 and 0.925 the maximum quantities of toxin accumulated were 113 ug/kg and 93 ug/kg respectively. Deoxynivalenol was not detected in the substrate at a_w 0.900. Results suggest that intermediate a_w levels (0.97 – 0.92) are particularly critical at post harvest time because those are conditions under which deoxynivalenol production is most likely to be initiated naturally.     

Co-occurrence of mycotoxins in swine feed produced in Portugal

A total of 404 samples of commercial swine feed from Portugal feed mills were analysed by HPLC methods for the presence of mycotoxins: 277 samples of feed for fattening pigs were analysed for ochratoxin A (OTA), zearalenone (ZEA), and deoxynivalenol (DON), and 127 samples of feed for sows were analysed for ZEA and fumonisins (FB₁ + FB₂). Concerning feed for fattening pigs, 21 (7.6%) samples were positive for OTA, (2–6.8 μg/kg), 69 (24.9%) were positive for ZEA (5–73 μg/kg), and 47 (16.9%) were positive for DON (100–864 μg/kg). In feed for sows, the results showed 29.9% of positive samples for ZEA (5–57.7 μg/kg) and 8.7% positive samples for FB₁ and FB₂ (50–391.4 μg/kg). Co-occurrence of DON/ZEA was found most frequently, but simultaneous contamination with OTA/ZEA and OTA/DON was also found.     

Development of enzyme-immunoassays based on egg yolk antibodies for the detection of mycotoxins

Enzyme-linked immunosorbent assays (ELISA) proved to be a fast and simple method for the detection of mycotoxins and other undesired contaminants in food and feed. The present study is focused on the optimisation and exploitation of the egg yolk antibody technology in order to develop competitive ELISAs for the detection of mycotoxins in cereals. Due to its importance as one of the most relevant Fusarium mycotoxins, the trichothecene deoxynivalenol (DON) was selected as representative. Chickens were immunised with different protein conjugates performing varying booster intervals. The antibodies were isolated by the poly(ethylene glycol) precipitation method according to Polson. By use of these antibodies an indirect competitive ELISA was developed for the detection of DON. First investigations of naturally contaminated wheat samples showed a good correspondence with results obtained by GC-ECD when calibration in blank wheat extracts was performed.     

Determination of deoxynivalenol in organic and conventional food and feed by sol–gel immunoaffinity chromatography and HPLC–UV detection

The paper describes the determination of deoxynivalenol (DON) in 55 wheat food and feed samples, 26 from conventional and 29 from organic production. Immunoaffinity columns prepared by entrapping anti-DON antibodies by the sol–gel method were used for sample clean-up. DON was quantified by high performance liquid chromatography (HPLC) and ultraviolet (UV) detection. In general, the incidence of DON contamination was rather low. In eight samples (14.5%) the DON concentration was above the LOQ (380 ng/g), in six samples (10.9%) DON was detected but could not be quantified (>LOD (200 ng/g), <LOQ). In seven conventional samples (two pasta, two cookie, two snack and one feed sample) but only in one organic sample (a snack) the DON concentration was >LOQ. The data indicate both a higher incidence of DON contamination and higher DON concentrations in food and feed samples from conventional than in those from organic production.     

Bestimmung von Deoxynivalenol in Brot und Bier

Analytical procedures for the determination of deoxynivalenol (DON) in bread and beer, using enzyme immunoassay (EIA) and HPLC methods, were developed. For determination of DON by EIA, aqueous raw extracts of bread or degassed beer were extracted by liquid-liquid partitioning with ethyl acetate, the organic solvent evaporated, and the residue redissolved in phosphate buffered saline (PBS) for analysis. For determination by HPLC (UV detection at 218 nm), DON in bread extracts or beer was purified on immunoaffinity chromatographic columns. In bread, detection limits for DON of 15 µg/kg (EIA) and 7 µg/kg (HPLC) were achieved, with mean recoveries of 81%. In beer, the detection limit for DON was 2 µg/l both in EIA and HPLC, with recoveries of 91–93%. Both methods showed good agreement of the results for naturally contaminated sample materials, with r²=0.993 for bread and r²=0.823 for beer, respectively.     

The occurrence of culmorin and hydroxy-culmorins in cereals

Forty-five samples from 1988–1995 of naturally contaminated grain, barley, wheat and oats, three samples of mixed feed, and 16 samples of grain artificially inoculated with Fusarium culmorum during the flowering stage were analysed for deoxynivalenol (DON), 3-acetyldeoxynivalenol (3-acetyl-DON), culmorin and hydroxy-culmorins. These compounds are secondary metabolites produced by the fungal species F. culmorum and F. graminearum. Acetonitrile-water extract of the samples was purified on a Mycosep^TM#225 column, derivetized using pentafluoropropionic anhydride (PFPA) and analysed by gas chromatography-mass spectrometry (GC-MS). The amount of each of culmorin, 5-, 12-, 14 and 15-hydroxy-culmorin and one unknown hydroxy-culmorin were determined relative to the amount of DON plus 3-acetyl DON for each sample. The ratio between the total amount of culmorin compounds and the DON compounds ranged from 0.14 to 1.07 in the samples. This study shows that there is a strong correlation between the amount of DON present in the grain and the amount of culmorin and hydroxy-culmorins present. The ratio of each of the culmorin compounds relative to the amount of DON compounds were in the same range in the grain artificially inoculated by F. culmorum as found in an earlier study for F. culmorum strains cultivated on rice, while the hydroxy-culmorin profile in the naturally contaminated grain was more similar to what was found for the F. graminearum cultures in the same study [1]. These results indicate that F. graminearum may be a relatively important source for DON in grain also in relatively cold areas. This revised version was published online in June 2006 with corrections to the Cover Date.     

Deoxynivalenol in pigs: An exclusive effect on the appetite?

A feeding-trial was conducted to determine the effects of a deoxynivalenol (DON)-contaminated diet in growing pigs. DON was added as either the purified toxin or as naturally contaminated wheat. Growth performance, biochemical and hematological parameters and DON-transformation through intestinal bacteria were monitored throughout the study. Epithelial tissues along the gastro-intestinal tract were also examined for pathological changes and selected enzyme activities (oxoglutarat dehydrogenase, alanine-amino-transferase). There were no differences among the dietary treatments in all parameters measured except for feed intake and weight gain in the naturally contaminated diets fed ad libitum. Effectsin vivo could not be explained exclusively by cytotoxicity of DON foundin vitro. These observations may reflect the presence of other unidentified (toxic) compounds in the naturally contaminated grain or the influence of further factors. In future studies synergistic/additive interactions with substances promoting appetite should be taken into consideration.     

Rapid and Specific Detection of Salmonella spp. in Animal Feed Samples by PCR after Culture Enrichment

A PCR procedure has been developed for routine analysis of viable Salmonella spp. in feed samples. The objective was to develop a simple PCR-compatible enrichment procedure to enable DNA amplification without any sample pretreatment such as DNA extraction or cell lysis. PCR inhibition by 14 different feed samples and natural background flora was circumvented by the use of the DNA polymerase Tth. This DNA polymerase was found to exhibit a high level of resistance to PCR inhibitors present in these feed samples compared to DyNAzyme II, FastStart Taq, Platinum Taq, Pwo, rTth, Taq, and Tfl. The specificity of the Tth assay was confirmed by testing 101 Salmonella and 43 non-Salmonella strains isolated from feed and food samples. A sample preparation method based on culture enrichment in buffered peptone water and DNA amplification with Tth DNA polymerase was developed. The probability of detecting small numbers of salmonellae in feed, in the presence of natural background flora, was accurately determined and found to follow a logistic regression model. From this model, the probability of detecting 1 CFU per 25 g of feed in artificially contaminated soy samples was calculated and found to be 0.81. The PCR protocol was evaluated on 155 naturally contaminated feed samples and compared to an established culture-based method, NMKL-71. Eight percent of the samples were positive by PCR, compared with 3% with the conventional method. The reasons for the differences in sensitivity are discussed. Use of this method in the routine analysis of animal feed samples would improve safety in the food chain.     

Determination of ergot alkaloids in rye and rye flour

An effective and timesaving analytical method was developed for the determination of 12 ergot alkaloids (ergometrine, ergotamine, ergocristine, α-ergokryptine, ergosine, ergocornine, and their respective -inine isomers) in rye and rye flour. Samples were extracted with dichloromethane/ethyl acetate/methanol/aqueous ammonia (25%) (50/25/5/1, v/v/v/v), and extracts were purified using a basic alumina column. The eluate was dried in the nitrogen stream and redissolved in acetonitrile/ ammonia carbamate-buffer (0.2 g/1), (1/1, v/v), and injected into an HPLC-FLD system (λ_Ex 330 nm, λ_Em 415 nm), using the same mixture as mobile phase and a Phenyl-Hexyl column. Detection limits for the individual compounds ranged from 0.01 μg/kg to 0.5 μg/kg. In sample material spiked with a mixture of these compounds at two different levels (13 μg/kg and 27 μg/kg per compound), mean (n=5) recoveries were at 101% (s_r 6.4%) and 89% (s_r 3.1%), respectively. Presented at the 28th Mykotoxin-Workshop, Bydgoszcz, Poland, May 29–31, 2006     

Fusarium mycotoxins in forage maize — Detection and evaluation

The deoxynivalenol concentrations found in forage maize ranged between 0.24 and 14.29 mg/kg DM (detected by ELISA). When highly contaminated samples were analysed for deoxynivalenol by HPLC or LC-MS the resulting concentrations were in the mean about 50% lower. Furthermore, using LC-MS other type-A and type-B trichothecenes, zearalenone and α-zearalenol were found in these samples. The differences between ELISA and HPLC/LC-MS data for deoxynivalenol are assumed to result from cross-reactions of other trichothecenes with the antibodies used in ELISA and toxin losses from sample purification procedures needed for HPLC and LC-MS analysis. Presented at the 26^th Mykotoxin-Workshop in Herrsching, Germany, May 17–19, 2004     

Deoxynivalenol and nivalenol in wheat and by-products in Argentina

The deoxynivalenol and nivalenol contamination in wheat and by-products obtained through milling was analized by Trucksess method slightly modified in the proportion of acetonitrile—water (3:1). Only one sample of wheat showed deoxynivalenol contamination, 1,200μg/kg. No samples obtained in different stages of the milling were contaminated with deoxynivalenol or nivalenol. In the commercial wheat flours the levels found ranged between 400 and 800μg/kg, as follows: 400μ/kg, 5 samples; 800jug/kg, 1 sample.     

Modeling the Effect of Glucose Syrup on the Moisture Sorption Isotherm of Figs

Moisture sorption isotherms of figs with and without glucose syrup (at 20% and 40%, w/w) were determined at 5 °C, 25 °C, and 40 °C. A static gravimetric method was used under 0.11–0.84 water activity ranges for the determination of sorption isotherms that were found to be typical type ΙΙΙ for control sample. The inclusion of glucose syrup had significant effects on the sorption isotherms, and the moisture content of samples at each a _w decreased with increasing temperature. The experimental data were fitted well with two-parameter Brunauer–Emmet–Teller, three-parameter Guggenheim–Anderson–de Boer, and four-parameter Peleg models that all had R ² of greater than 0.99. The net isosteric heats of sorption were estimated using the Clausius–Clapeyron equation from the equilibrium data at different temperatures. It was found that the addition of glucose syrup significantly increased the amount of monolayer water and the isosteric heat of sorption. Both water activity and isosteric heat of sorption increased with glucose syrup level and the shape and status of sorption isotherms tend to change toward the typical sigmoid shape of most food systems.     

Fütterungseinfluss von Deoxynivalenol-belastetem Weizen bei Ferkeln

Effects of the mycotoxin deoxnivalenol (DON) on weaned piglets were investigated. Two feeding trials were conducted with naturally contaminated wheat in the ration. In the first trial as preliminary study weaned piglets were fed for one week with 7.7 mg DON per kg ration, intake of DON contaminated diets was not associated with any obvious negative health effects. Also in the main feeding trial with 3 mg DON per kg ration no vomiting and other negative clinical symptoms could be registered. The feed intake and the daily weight gains were significantly lower in the DON fed group when compared with control group, but the feed conversion rates were slightly improved in group fed DON.

Presented at the 25^th Mykotoxin Workshop in Giessen, Germany, May 19–21, 2003     

On the effects ofFusarium-contaminated wheat and the feed intake level on ruminal fermentation and toxin-turnover of cows

The aim of the study was to examine the effects of dry matter intake level and the feeding ofFusarium-contaminated wheat on the toxin-turnover and ruminal fermentation of dairy cows. Fourteen dairy cows equipped with ruminal and duodenal cannulae were used. All animals were fed the same diet, only the daily feed amounts were adjusted to the current performance stage of the cow. On a dry matter basis, the diet consisted of 60% concentrate including 55% wheat (Fusarium-contaminated wheat [Mycotoxin period] or control wheat [Control period]). Each cow was fed with both the contaminated and the control wheat. TheFusarium-contamination of the wheat significantly decreased the flow of undegraded protein at the duodenum with increased intakes of organic matter. The duodenal flow of microbial protein and the activities of aspartate aminotransferase (ASAT), glutamate dehydrogenase (GLDH) and gamma glutamyl transferase (γ-GT) in the serum were not affected by dietary treatment, but increased with feed intake. The duodenal flow of deoxynivalenol (DON) and de-epoxy DON related to DON intake ranged between 12 and 77% when theFusarium-contaminated wheat was fed. DON was almost completely metabolized to de-epoxy DON independent of the feed intake level. The zearalenone (ZON) flow at the duodenum increased moderately with increasing ZON/feed intake.