Effects of balancing crystalline amino acids in diets containing heat-damaged soybean meal or distillers dried grains with solubles fed to weanling pigs

Two experiments were conducted to investigate if adjustments in diet formulations either based on total analysed amino acids or standardized ileal digestible (SID) amino acids may be used to eliminate negative effects of including heat-damaged soybean meal (SBM) or heat-damaged corn distillers dried grains with solubles (DDGS) in diets fed to weanling pigs. In Experiment 1, four corn–SBM diets were formulated. Diet 1 contained non-autoclaved SBM (315 g/kg), and this diet was formulated on the basis of analysed amino acid concentrations and using SID values from the AminoDat® 4.0 database. Diet 2 was similar to Diet 1 in terms of ingredient composition, except that the non-autoclaved SBM was replaced by autoclaved SBM at 1 : 1 (weight basis). Diet 3 was formulated using autoclaved SBM and amino acid inclusions in the diet were adjusted on the basis of analysed total amino acid concentrations in the autoclaved SBM and published SID values for non-autoclaved SBM (AminoDat® 4.0). Diet 4 also contained autoclaved SBM, but the formulation of this diet was adjusted on the basis of analysed amino acids in the autoclaved SBM and SID values that were adjusted according to the degree of heat damage in this source of SBM. Pigs (160; initial BW: 10.4 kg) were allotted to the four treatments with eight replicate pens per treatment in a randomized complete block design. Diets were fed to pigs for 21 days. The gain to feed ratio (G : F) was greater (P<0.05) for pigs fed Diet 1 compared with pigs fed the other diets and pigs fed Diet 4 had greater (P<0.05) G : F than pigs fed Diet 2. In Experiment 2, 144 pigs (initial BW: 9.9 kg) were allotted to four diets with eight replicate pens per diet. The four diets contained corn, SBM (85 g/kg) and DDGS (220 g/kg), and were formulated using the concepts described for Experiment 1, except that heat-damaged DDGS, but not heat-damaged SBM, was used in the diets. Pigs fed Diet 1 had greater (P<0.05) G : F than pigs fed Diet 2, but no differences were observed for G : F among pigs fed diets containing autoclaved DDGS. Results demonstrate that the negative effects of heat damage of SBM or DDGS may be ameliorated if the reduced concentration and digestibility of amino acids in heat-damaged SBM or DDGS is taken into account in diet formulation. Further research is needed to improve the prediction of the ileal digestibility of amino acids in heat-processed ingredients used in practical diet formulations.     

The nutritive value of Tower rapeseed meal for swine

Two experiments involving 144 Yorkshire × Lacombe gilts, with an average initial weight of 20 kg, were conducted. In Experiment 1 the gilts were allotted to a control diet containing soya bean meal (SBM) or to diets in which either 50% or all of the supplementary protein was provided by Tower rapeseed meal (RSM). In the second experiment the two diets had either SBM or Tower RSM as the supplementary protein source. In a third diet Tower RSM was supplemented with sufficient lysine to equal the calculated available lysine level of the SBM control diet. In Experiment 1, gilts given the SBM diet grew from 20 to 60 kg significantly faster (P<0.01), and had better feed conversion efficiency (P<0.01), than those given the RSM diets. A 50% replacement of SBM by Tower RSM gave intermediate results. Partial or total replacement of SBM by Tower did not significantly affect the growth rate or feed conversion efficiency of the gilts when growing from 60 to 100 kg liveweight. Serum triiodothyronine (T3) and thyroxine (T4) concentrations of the gilts at 100 kg were lower in pigs fed on the RSM diets but the differences were not significant. In the second experiment, total replacement of SBM by Tower RSM, with or without the addition of lysine, significantly (P<0.001) reduced growth rate and feed conversion efficiency during the growing period (20–60 kg) but did not significantly affect performance during the finishing period (60–90 kg). Serum T3 concentration was not significantly affected by the addition of Tower RSM to the diet but T4 concentrations were significantly reduced (P<0.01). None of the carcass parameters studied were significantly affected by the addition of Tower RSM to the diets.     

Effects of reduced in utero and post-weaning nutrition on milk yield and composition in primiparous beef cows

Development and long-term retention of replacement beef females in a semi-arid environment are of a major concern for extensive livestock producers. Furthermore, the demand of not only producing a thriving, healthy calf, but having sufficient milk to support that first calf is essential. To address this issue, we conducted a 3-year study measuring milk production and milk constituent yields in primiparous beef heifers (n=48; 16/year reared under two different feeding regimens) raising steer calves. Cows received 1.8 or 1.2 kg/day winter supplementation for ~80 day before parturition and their heifer calves were then randomly assigned to heifer development treatments that provided ad libitum (AL) or 80% (less than ad libitum (LAL)) of ad libitum feed post weaning. Heifers developed on the AL treatment also received 1.8 kg/day winter supplementation for life, whereas heifers developed on the LAL treatment received 1.2 kg/day winter supplementation for life. Milk production of primiparous cows was measured with a portable milking machine every other week from days 27 to 125 postpartum. Milk yield for the 125-day lactation period was calculated from area under the lactation curve approximated by trapezoidal summation. The ANOVA model included in utero winter nutrition, post-weaning heifer development treatment, year and their interaction. Heifers subjected to the AL treatment reached peak milk yield ~12.3 day later (P=0.02) than heifers receiving LAL treatment. In addition, an in utero nutrition×post-weaning heifer treatment×year interaction existed (P⩽0.04) for milk peak yield, average daily milk yield (kg/day) and nutrient composition (protein, lactose, fat, solids non-fat, g/day). These interactions manifest as changes in magnitude and rank across the 3 years of the study. Livestock production in extensive environments is subject to variations in seasonal precipitation patterns and quality and quantity of grazeable forage and these fluctuations have a large impact on milk yield. In summary, the gestational nutritional environment of a heifer’s mother may interact with the heifer’s nutrient consumption during post-weaning growth and the current year to trigger variation in year-to-year milk production.     

A 3-week feed restriction after weaning as an alternative to a medicated diet: effects on growth,health, carcass and meat traits of rabbits of two genotypes

Feed restriction after weaning is widely used in meat rabbit farms to promote health and reduce mortality, but this practice impacts negatively on rabbit growth and slaughter performance. This study compared a 3-week post-weaning feed restriction with ad libitum medicated feeding, evaluating effects on feed intake, growth, health, carcass and meat quality of rabbits of two genotypes: Italian White pure breed and Hycole hybrid×Italian White crossbred. A total of 512 rabbits at 36 days of age, of both sexes and two genotypes, were divided into four homogeneous groups assigned, from 36 to 57 days of age, to different feeding programmes (FP): restricted non-medicated (R-N), ad libitum non-medicated (L-N), restricted medicated (R-M) and ad libitum medicated (L-M). The diets were medicated with oxytetracycline (1540 mg/kg) and colistin sulphate (240 mg/kg). The restriction, performed by giving 70, 80 and 90 g/day of feed for the 1st, 2nd and 3rd week, was followed by ad libitum feeding in the successive 5 weeks, up to slaughter at 92 days of age. Restricted feeds were ingested at a level of 64% of the feed intake recorded in the ad libitum fed rabbits; it was significantly associated, regardless of medication and rabbit genotype, with a lower feed intake (−22 to −24 g dry matter/day) during the entire experiment, compensatory growth and a lower feed conversion ratio in the ad libitum period, and a lower final live weight (−150 g) than ad libitum feeding (P<0.001). During restriction, mortality was lower in the restricted rabbits (6.25%, 5.47% v. 12.5%, 14.8% for R-N, R-M, L-N and L-M; P<0.05), whereas in the ad libitum period mortality did not differ among the groups (9.23%, 9.90%, 11.0% and 4.59% for R-N, R-M, L-N and L-M). Dressing out percentage was not affected by FP or genotype; heavier carcasses were produced by rabbits fed ad libitum (+100 g; P<0.001) and crossbred rabbits (+122 g; P<0.001). Restriction did not alter meat quality, except for a tendency towards a higher cooking loss and less fat; crossbred meat was higher in L* (+1.3; P<0.01) and b* (+0.51; P<0.05) colour indexes and tenderness (−0.14 kg/cm²; P<0.05) than pure breed meat. Under the conditions of this study, a 3-week restricted feeding after weaning resulted to be a suitable alternative, also for high growth potential genotypes, to the antibiotics to preserve rabbit health. The production of lighter carcasses could be compensated partly by the lower feed conversion ratio showed by restricted rabbits.     

Effect of different levels of rapeseed meal and sunflower meal and enzyme combination on the performance,digesta viscosity and carcass traits of broiler chickens fed wheat-based diets

The aim of the present experiment was to examine the effect of different levels of rapeseed meal (RSM) and sunflower meal (SFM) and enzyme combination (endoxylanase and β-glucanase) on the production performance, carcass quality, gizzard development and digesta viscosity of broiler chickens. The experimental design was a 3×2 factorial arrangement of treatments evaluating three diet types containing different levels of RSM and SFM (low (L), medium (M) and high (H)) and two levels of enzyme inclusion (0 or 100 g/tonne diet to provide 1220 U xylanase and 152 U β-glucanase per kg diet). Broiler starter and grower/finisher diets were formulated, based on wheat and soya bean meal and containing 50, 50 and 80 g/kg RSM and 0, 50 and 60 g/kg SFM for L, M and H treatments, respectively, during starter period and 80, 80 and 120 g/kg RSM and 0, 80 and 100 g/kg SFM for L, M and H, respectively, during grower/finisher period, and each diet was fed ad libitum to eight pens of 20 male broilers each. During the starter period (1 to 21 days), birds fed the H treatment had lower (P<0.05) BW gain (BWG) compared with those fed the L and M treatments. Diet type also influenced (P<0.05) feed intake (FI). Feeding the H treatment reduced (P<0.05) FI compared with the M treatment. Diet type and enzyme supplementation had no effect (P>0.05) on feed conversion ratio (FCR). During the grower/finisher phase (22 to 42 day) and over the entire period (1 to 42 day) birds fed the H treatment had lower (P<0.05) BWG and higher (P<0.05) FCR compared with those fed the L and M diets. Enzyme supplementation improved (P<0.05) FCR compared with the unsupplemented diets. No interactions (P>0.05) between RSM and SFM inclusion level and enzyme supplementation were observed for any of the measured parameters at any period. Diet type and enzyme supplementation had no effect (P>0.05) on carcass traits, abdominal fat pad, breast meat yield and jejunal digesta viscosity. Diet type influenced (P=0.05) relative empty gizzard weight, where the H treatment had higher relative empty gizzard weight compared with the L treatment. Enzyme supplementation tended (P=0.10) to increase relative empty gizzard weight. The present data suggest that high inclusion of SFM and RSM negatively influenced broiler performance. Enzyme supplementation improved FCR at all levels of RSM and SFM included in this study, but did not recover the reduction in weight gain caused by high inclusion of RSM and SFM.     

Effect of the inclusion of food waste in pig diets on growth performance, carcass and meat quality

Food waste from fish and fruit shops was used as an alternative to the grain in grower-finisher pig diets. Two diets were formulated on an iso-nutrient basis (14 MJ digestible energy per kg, 160 g crude protein per kg on a dry-matter basis) to contain 0 g of food waste per kg in the control diet and 50 g of fish-shop waste per kg and 120 g of fruit-shop waste per kg in the experimental diet. In the study, 28 pigs per diet (seven pigs per pen) were fed ad libitum from 20 kg to 100 kg, then, they were slaughtered and the carcass characteristics determined. The inclusion of food waste in the diet had no significant effect (P>0.05) on average daily feed intake (2.12 v. 2.20 kg/day), average daily gain (0.74 v. 0.78 kg/day), or gain/feed (0.35 v. 0.35 kg per kg). In the case of the experimental diet, backfat thickness was significantly lower (18.0 v. 21.3 mm, P < 0.01). The results of the taste test indicated that the meat from food waste-fed pigs had acceptable organoleptic quality although a very light aroma to fish was observed in the bacon (P < 0.01).It was concluded that food waste from the fish and fruit shops could be included in grower-finisher pig diets without any detrimental effect on growth performance and only minor effects on carcass characteristics and meat quality.     

Improved performance and immunological responses as the result of dietary genistein supplementation of broiler chicks

The present study aimed to investigate the effect of supplemental genistein (an isoflavonoid) on performance, lymphoid organs’ development, and cellular and humoral immune responses in broiler chicks. A total of 675-day-old male broiler chicks (Ross 308) were randomly assigned to the five replicate pens (15 chicks each) of nine experimental diets. Dietary treatments included a negative (not-supplemented) control diet, two positive control groups (virginiamycin or zinc-bacitracin, 20 mg/kg), and diets containing 10, 20, 40, 80, 160 and 320 mg/kg of genistein. The cutaneous basophil hypersensivity (CBH) test was measured at day 10 of age after toe web injection with phytohemagglutinin-P. In addition, sera samples were collected after different antigen inoculations to investigate antibody responses. At day 28 of age, three randomly selected birds from each pen were euthanized to evaluate the relative weights of lymphoid organs. Results showed that dietary supplementation of both antibiotics increased (P<0.01) feed intake during 1 to 42 days of age. Furthermore, daily weight gain was influenced (P<0.01) by dietary treatments throughout the trial, so that the birds fed on antibiotics and 20 to 80 mg/kg genistein diets revealed the greater weight gains compared with other experimental groups. The best (P<0.05) feed conversion ratio assigned to the birds fed on diets containing antibiotics and moderate levels (40 to 80 mg/kg) of genistein. Although the relative weights of thymus (P<0.05) and bursa of Fabricius (P<0.01) were greater in birds fed on genistein-supplemented diets compared with antibiotics-supplemented birds, the spleen weight was not affected by experimental diets. Similarly, CBH response and antibody titers against Newcastle and infectious bronchitis disease viruses were markedly (P<0.05) greater in chicks fed on diets supplemented with 20 to 80 mg/kg of genistein. Interestingly, the higher dosages of genistein suppressed CBH and antibody responses to the levels seen by control and antibiotics chicks. Dietary inclusion of genistein increased (P<0.05) lymphocytes and subsequently reduced (P<0.01) heterophil to lymphocyte ratio. The present findings indicate that dietary genistein supplementation at the levels of 20 to 80 mg/kg not only improves growth performance, but also could beneficially affect immunological responses in broiler chicks.     

Effect of wheat dried distillers grains and enzyme supplementation on growth rates,feed conversion ratio and beef fatty acid profile in feedlot steers

The objectives of this study were to determine: (1) the effect of wheat dried distillers grain with solubles (DDGS) inclusion, and (2) dietary feed enzyme (FE; Econase XT) supplementation in a finishing diet containing wheat DDGS on fatty acid profile of the pars costalis diaphragmatis muscle of beef cattle. A total of 160 crossbred yearling steers with initial BW of 495±38 kg were blocked by BW and randomized into 16 pens (10 head/pen). The pens were randomly assigned to one of the four treatments: (1) control (CON; 10% barley silage and 90% barley grain-based concentrate, dry matter (DM) basis); (2) diet containing 30% wheat DDGS in place of barley grain without FE (WDG); (3) WDG diet supplemented with low FE (WDGL; 1 ml FE/kg DM); and (4) WDG diet supplemented with high FE (2 ml FE/kg DM). The pars costalis diaphragmatis muscle samples were collected from cattle at slaughter at the end of the finishing period (120 days) with a targeted live weight of 650 kg. No differences in organic matter intake, final BW and average daily gain were observed among treatments. However, steers fed WDG had greater (P<0.01) feed conversion ratio than those fed CON, and increasing FE application in wheat DDGS-based diets tended (P<0.10) to linearly decrease feed conversion ratio. In assessing the effects of including WDG diets without FE, concentration of total polyunsaturated fatty acids (PUFA) in muscle tended to be greater (P<0.10) for steers fed WDG than steers fed CON. In addition, inclusion of wheat DDGS into the diet increased (P<0.05) concentration of CLA and vaccenic acid (VA) in muscle and also resulted in a higher (P<0.05) ratio of n-6/n-3 PUFA compared with that from steers fed CON diet. Increasing FE application in wheat DDGS-based diets did not modify the concentrations of individual or total fatty acids. These results suggest that inclusion of wheat DDGS in finishing diets may improve fatty acid profile of beef muscle which could benefit human health.     

Feeding dried distillers grains with solubles to lactating beef cows: impact of excess protein and fat on post-weaning progeny growth,glucose tolerance and carcass traits

Feeding dried distillers grains with solubles (DDGS), a feed high in fat and protein, to lactating beef cows can alter milk production and composition, resulting in improved pre-weaning growth of progeny. This alteration in milk profile may consequently alter the growth and carcass composition of the offspring after weaning. Therefore, Angus×Simmental steers (n=48) whose dams were fed one of two diets supplemented with either DDGS or soybean meal (CON) from calving to mid-lactation were placed in a feedlot to determine the effects of maternal nutrition during lactation on progeny development and carcass composition. Cow–calf pairs were allotted to two treatments at birth based on cow and calf BW, breed and age. Maternal diets were isocaloric (3.97 MJ/kg NE_g) and consisted of rye hay supplemented with DDGS at 1% of BW (19.4% CP; 8.76% fat) or rye hay and corn silage supplemented with CON (11.7% CP; 2.06% fat). After conclusion of the treatments at 129 days postpartum, cow–calf pairs were comingled and managed as one group until weaning at 219 days postpartum. Steers were then transitioned to a common diet composed of 60% DDGS, 34% corn silage and 6% vitamin/mineral supplement and were placed indoors in individual pens with slatted floors. An intravenous glucose tolerance test (IVGTT) was performed 134 days after feedlot entry on 16 steers (CON, n=7; DDGS, n=9) to determine the effect of maternal diet on glucose and insulin sensitivity. Steers were slaughtered at a target BW of 645 kg. Categorical and continuous data were analyzed using the GLIMMIX and MIXED procedures of SAS, respectively. Steers from DDGS dams tended to be heavier on day 85 of feedlot finishing (P=0.09) compared with steers from CON dams. However, there were no differences in final weight, average daily gain, dry matter intake or efficiency (gain:feed, P⩾0.18). Maternal treatments did not affect progeny days on feed (P=0.15), despite a mean difference of 9 days in favor of DDGS. Glucose and insulin concentrations and area under the curve of progeny as measured by IVGTT were not affected by maternal diet (P⩾0.16). Maternal DDGS supplementation decreased marbling score (P=0.04), but did not influence carcass grading percentage or any other carcass characteristic (P⩾0.17).     

Evaluation of the effects of pharmacological zinc oxide and phosphorus source on weaned piglet growth performance,plasma minerals and mineral digestibility

Crossbred pigs (n=720; average age=28±3 days and weight=9.5±0.3 kg) were used in a 20-day trial in order to determine the influence of phosphorus (P) source and various doses of pharmacological zinc (Zn) on growth performance, plasma minerals and mineral digestibility. Pigs (five intact males and five females per pen) were randomly allotted to treatments in a 3×3 factorial arrangement with three sources of dietary P (4.5 g/kg digestible P, 4.5 g/kg digestible P plus 2500 phytase units (FTU)/kg, or 5.5 g/kg digestible P) and three dietary levels of supplemental Zn (0, 1750 or 3500 mg/kg) from ZnO (82% Zn) with eight pens per treatment. Diets were formulated to exceed all nutrient requirements, including calcium (Ca), P and Zn from day 0 to 20. Zn supplementation increased (quadratic P<0.05) average daily feed intake. There was a significant Zn level×P source interaction on average daily gain and feed conversion ratio (FCR). Pigs fed 4.5 g/kg digestible P without or with 2500 FTU/kg phytase gained more per day (quadratic P<0.05) and had better FCR (quadratic P<0.05) when they were fed 1750 mg/kg supplemental Zn. However, pigs fed 5.5 g/kg digestible P gained more per day (linear P<0.05) and were more efficient (linear P<0.05) when they were fed 3500 mg/kg supplemental Zn. Plasma Zn and Zn digestibility increased (linear P<0.05) as pharmacological Zn supplementation increased from 0 to 3500 mg/kg, irrespective of P source. However, Ca, P, sodium (Na), potassium (K) and copper (Cu) digestibility were reduced (P<0.05) as pharmacological Zn supplementation increased, and this was mitigated or exacerbated by the supplementation of 5.5 g/kg digestible P or phytase. In conclusion, increasing the dietary inclusion of pharmacological Zn may impact growth performance in young pigs through the interaction with minerals such as Ca, P, Na and K. Pharmacological Zn may reduce Na or K digestibility and indirectly reduce water secretion into the lumen, resulting in an increase in faecal dry matter as pharmacological Zn supplementation in the diet increased.     

Effects of l-carnitine in the distillers dried grains with solubles diet of sows on reproductive performance and antioxidant status of sows and their offspring

Distillers dried grains with solubles (DDGS) are highly susceptible to lipid oxidation because DDGS contain about 10% crude fat, which is largely composed of polyunsaturated fatty acids. l-carnitine serves an important function in fatty acids β-oxidation, and also has antioxidant properties. The objective of this study was to examine the effects of l-carnitine in the DDGS diet of gestating and lactating sows on reproductive performance, milk composition and antioxidant status of sows and their offspring. One hundred and twenty sows (Landrace×Large white, mean parity 4.2, initial BW 230 kg) were randomly allotted to 1 of 4 dietary treatments (n=30 sows/treatment). Treatments were arranged as a 2×2 factorial with two levels of dietary DDGS (0 v. 250 g/kg in gestating diets and 400 g/kg in lactating diets) and two levels of dietary l-carnitine (0 v. 100 mg/kg in gestating diets and 0 v. 200 mg/kg in lactating diets). Distillers dried grains with solubles had no significant effect on litter size but significantly reduced the birth weights and weaning weights of piglets (P<0.05). Distillers dried grains with solubles reduced the antioxidant enzyme activities (P<0.05) and increased the malondialdehyde level in the plasma of sows on day 60 of gestation (P=0.004) and day 14 of lactation (P=0.008). The compositions of colostrum and milk were not affected by inclusion of DDGS and dietary l-carnitine (P>0.05). Supplementing the diets with l-carnitine had no significant effect of total litter size (P>0.05) but increased the number of piglets born alive and piglets weaned, birth weight and weaning weight of piglets and litter weight at birth and weaning (P<0.05). l-carnitine supplementation also increased the concentration of l-carnitine in milk and l-carnitine status of piglets (P<0.05). The antioxidant enzyme activities of new born and weaning piglets were increased (P<0.05) by maternal dietary l-carnitine but this did not extend to finishing pigs. In conclusion, including DDGS in the sows diet could induce oxidative stress, which may be associated with the reduced individual birth and weaning weight of piglets. Dietary l-carnitine supplementation improved the antioxidant and l-carnitine status of sows, which may be associated with the improved reproduction and piglet performance and the antioxidant status of piglets at birth and weaning. There were no interactions between DDGS and l-carnitine.     

The effects of a novel synthetic emulsifier product on growth performance of chickens for fattening and weaned piglets

Two experiments were conducted to evaluate the effects of a novel synthetic emulsifier product (AVI-MUL TOP) on the growth performance of chickens for fattening and weaned piglets. The emulsifier product consists of 50% vegetal bi-distillated oleic acid emulsified with 50% glyceryl polyethyleneglycol ricinoleate. In experiment 1, 480 1-day-old female Cobb500 chickens for fattening were assigned to two treatments: (1) a control diet (CTR); and (2) the control diet+the emulsifier (AMT, 1 g/kg from day 0 to day 10, 0.75 g/kg from day 10 to day 20 and 0.5 g/kg from day 20 to day 34 of the trial). AMT supplementation increased BW on days 20 and 34 (P<0.01). Dietary AMT increased the average daily gain and average daily feed intake (ADFI) from day 10 to day 20, from day 20 to day 34 and from day 0 to day 34 (P<0.01). A reduced feed conversion ratio was observed in the AMT group from day 10 to day 20 (P<0.01). In experiment 2, 96 Stambo HBI×Dalland piglets were weaned at 24 days and assigned to two treatments (the basal diet without the product (CTR) or with 2 g/kg emulsifier from day 0 to day 14 and 1.5 g/kg from day 14 to day 42 (AMT)). There was an increase in the ADFI associated with AMT supplementation from day 14 to day 42 (P=0.04). These results indicated that supplementation with the synthetic emulsifier may significantly improve the growth performance of chickens for fattening and numerically improve that of weaned piglets.     

Ileal digestibility of nutrients and amino acids in low quality soybean meal sources treated with β-mannanase for growing pigs

Apparent ileal digestibility (AID) of energy, dry matter (DM), nitrogen (N) and amino acids and standardized ileal digestibility (SID) of amino acids in low quality soybean meals with different CP concentration (SBM 44% CP and SBM 48% CP) with or without 400 U β-mannanase/kg supplementation were evaluated in 20 cannulated barrows ((Landrace×Yorkshire)×Duroc) with an average BW of 25.08±3.42 kg. A N-free diet was used to determine basal endogenous losses of amino acids. The supplementation of β-mannanase improved (P<0.05) AID of DM compared with non-supplemented diet. However, enzyme supplementation did not improve (P>0.05) AID of N and energy. The type of SBM (SBM 44% CP v. SBM 48% CP) had no effect on AID of DM, N and energy. β-mannanase improved (P<0.05) AID of sum of essential amino acids, arginine, histidine, lysine, valine and glycine. The SID of lysine was higher (P<0.05) in enzyme supplemented than in non-supplemented diets. Larger AID and SID of threonine and proline (P<0.05) were observed in SBM 48% CP than in SBM 44% CP. In conclusion, the supplementation of enzyme improved AID of arginine, histidine, lysine, valine and glycine, but it did not cause marked difference in SID of these amino acids except for lysine. The low nutrient digestibility of the SBM sources used in the present experiment might have favoured the positive effect of β-mannanase supplementation.     

Impact of feed restriction and housing hygiene conditions on specific and inflammatory immune response,the cecal bacterial community and the survival of young rabbits

Limiting the post-weaning intake of the young rabbit is known to improve its resistance to digestive disorders, whereas a degradation of its housing hygiene is assumed to have a negative impact on its health. This study aims at providing insights into the mechanism of digestive health preservation regarding both host (growth and immune response) and its symbiotic digestive microbiota. A 2×2 factorial design from weaning (day 28) to day 64 was set up: ad libitum intake or restricted intake at 70% of ad libitum, and high v. low hygiene of housing (n=105 per group). At day 36 and day 45, 15 animals/group were subcutaneously immunized with ovalbumin (OVA) to assess their specific immune response. Blood was sampled at 36, 45, 57 and 64 days of age to determine total and anti-OVA immunoglobulin type G (IgG) and haptoglobin levels. The cecal bacterial community was explored (18 per group) by 454 pyrosequencing of genes coding for the 16S ribosomal RNA, whereas cecal pH, NH₃ and volatile fatty acid (VFA) concentrations were measured to characterize fermentative activity. A 30% reduction in feed intake reduced the growth by only 17% (P<0.001), and improved the feed conversion ratio by 15% (P<0.001), whereas the degradation of hygiene conditions slightly decreased the feed intake in ad libitum fed rabbits (−3.5%, P<0.02). As poor hygiene conditions did not affect weight gain, feed conversion was improved from day 42 (P<0.05). Restricted feeding led to a lower mortality between day 28 and day 40 (P=0.047), whereas degraded hygiene conditions decreased overall morbidity (7.8% v. 16.6%; P<0.01). Both a reduced intake and low hygiene conditions of housing affected microbiota composition and especially dominant genera belonging to the Ruminococcaceae family (P<0.01). Moreover, low hygiene was associated with a higher Ruminococcaceae/Lachnospiraceae ratio (3.7 v. 2.4; P<0.05). Cecal total VFA and pH were increased (+19%; P<0.001) and decreased (−0.1 pH unit; P<0.05), respectively, in feed-restricted rabbits. Neither specific anti-OVA IgG nor haptoglobin was affected by treatments. Total IgG concentrations were the highest in animals raised in poor hygiene conditions after 8 days of restriction, but decreased after 19 days of restriction in high hygiene conditions (−2.15%; P<0.05). In conclusion, the degradation of hygiene conditions failed to induce a systematic specific and inflammatory response in rabbit, but reduced morbidity instead. Our results suggest that the microbiota composition would be a helpful source of biomarkers of digestive health.     

Meat quality traits and fatty acid composition of breast muscles from ducks fed with yellow lupin

The protein sources in feed have a huge impact on good-quality and -quantity meat traits. Yellow lupin (YL) seeds have a similar level of protein as soybean meal (SBM). The most popular is SBM that is genetically modified (GMO). During this age, the consumer market requires non-GMO products. Yellow lupin used as a high-protein substitute for SBM in feed has an effect on the quality of meat from broiler ducks. The aim of the study was to analyse and compare meat quality traits in breast and leg muscles as well as fatty acid (FA) composition in breast muscles from ducks fed mixtures containing YL as an alternative to SBM. Two hundred 1-day-old Cherry Valley ducks were kept in pens on litter in two equal dietary groups, four replications with 25 birds per group. The control group (1) received balanced feed containing SBM. The treatment group (2) received balanced feed containing YL. The feed provided to both groups contained 55% of concentrate and 45% of wheat. Birds received feed and water ad libitum and were reared for 8 weeks. After that, 16 ducks (eight from each group) of BW close to the mean for the whole group were slaughtered. Plucked and gutted carcasses were analysed in a laboratory for quality parameters. Meat was analysed for pH, colour, water-holding capacity and drip loss. Samples of breast muscles were analysed for the content of cholesterol, collagen, intramuscular fat and FA composition. The proposed feed mixture containing YL had no impact on meat traits, content of muscles or fat in duck carcasses (P > 0.05). The values of lightness (L*) and yellowness (b*) and collagen content in breast muscles were significantly higher (P < 0.05) in group 2 (YL). A lower ability to retain water, that is, higher water-holding capacity (percentage of water lost from meat) (P < 0.05), was found for leg muscles from group 2 (YL). The content of C16:0, C18:0, C20:4 n-6, C22:4 n-6, C22:5 n-3, total content of saturated fatty acids (SFA), values of atherogenic index and thrombogenic index were significantly lower (P < 0.05) in group 2 (YL) than in group 1 (SBM). The content of C18:2 n-6 and the polyunsaturated fatty acids-to-SFA ratio (P/S) were significantly higher (P < 0.05) in ducks fed the diet with the inclusion of YL. Diets with YL could be proposed as a partial substitute for SBM in duck-rearing.     

Dietary inclusion of raw faba bean instead of soybean meal and enzyme supplementation in laying hens: Effect on performance and egg quality

An experiment was conducted with 160 Hisex Brown laying hens to evaluate the effect of different inclusion levels of faba bean (FB) and enzyme supplementation on productive performance and egg quality parameters. The experimental diets consisted of five levels of FB: 0% (control), 25%, 50%, 75% and 100%, substituting soybean meal (SBM), and two levels of enzyme supplementation (0 or 250 mg/kg). Each dietary treatment was assigned to four replicate groups and the experiment lasted 22 weeks. A positive relationship (P < 0.05) was found between FB inclusion and body weight (BW) change of hens when compared to those of the control treatment. Enzyme supplementation significantly affected the final hens’ BW. Feed consumption (FC) of hens was statistically increased with increasing FB level up to 50%. Supplementing dietary enzyme mixture at 250 mg/kg led to improvement in FC at all studied ages (P < 0.05). Inclusion of 25% or 50% FB in diets had no adverse effects on feed conversion ratio (FCR) compared to the higher FB inclusion levels (75% or 100%). Egg weight (EW), egg number (EN) and egg mass (EM) were significantly (P < 0.05) influenced by FB inclusion in diet during the entire experimental periods, except for EN and EM at 20–24 weeks of age. Egg productive parameters were not influenced by enzyme mixture supplementation (P > 0.05). The main effect of FB levels replacing for SBM affected (P < 0.05) yolk and shell percentages, yolk index, yolk to albumen ratio, shell thickness and egg shape index. It can be concluded that FB and enzyme supplementation could be included in hens diet at less than 50% instead of SBM to support egg productive performance, however higher raw FB levels negatively affected egg production indices and quality.     

Opportunities for avoidance of land‐use change through substitution of soya bean meal and cereals in European livestock diets with bioethanol coproducts

An analysis is presented which quantifies the potential for distillers dried grains with solubles (DDGS, a coproduct of wheat bioethanol production) to replace soya bean meal (SBM) and cereals in livestock rations. A major proportion of the SBM imported into Europe as a protein‐rich feedstuff for livestock comes from South America, where land‐use change (LUC) is associated with high carbon emissions. Production of DDGS can therefore reduce LUC in South America by substitution of SBM in animal feed. The analysis indicates that a single bioethanol distillery processing 1 million tonnes of wheat, and producing ca. 330 000 tonnes of DDGS per annum, would substitute at least 136 493 tonnes of whole soya beans grown on 47 725 ha of land, and save greenhouse gas emissions equivalent to 0.63 million tonnes CO₂ per annum. By growing sugar beet and wheat in an average ratio of 0.06 : 0.94 on 1 ha of land in Europe, the net area of agricultural land required to produce feed ingredients equivalent to 6.08 t of sugar beet pulp (SBP) and 1.72 t of DDGS associated with 2363 L of bioethanol, is reduced to 0.40 ha. This accounts for 0.42 ha of soya that is not required when DDGS displaces SBM, and 0.18 ha of wheat that is not required when DDGS and SBP displace wheat in livestock rations.     

Amino acid digestibility in corn distillers’ dried grains with solubles in pigs at different dietary levels of casein and test ingredient

Digestibility of amino acids (AA) in feed ingredients for pigs has been generally determined by feeding experimental diets containing test feedstuffs as a sole source of N, which may lead to the deficiency or imbalance of AA and hinder an accurate determination of digestibility values. Therefore, the addition of casein in experimental diets may ameliorate the potential negative effects of deficiency or imbalance of AA. In addition, the concentration of test feedstuffs in experimental diets may affect the digestibility of AA in test feedstuffs. Two experiments were conducted with corn distillers’ dried grains with solubles (DDGS) as the test feedstuff to determine the effects of increasing concentrations of casein in experimental diets on standardized ileal digestibility (SID) of AA in DDGS (experiment 1) and to investigate the effects of two concentrations of DDGS in experimental diets with or without the addition of casein on SID of AA in DDGS (experiment 2). In experiment 1, 20 barrows (initial BW = 45.3 ± 1.80 kg) surgically fitted with T-cannulas at the distal ileum were allocated to a quadruplicate 5 × 2 incomplete Latin square design with five diets and two periods. Four isonitrogenous diets containing increasing concentrations of casein from 0 to 165 g/kg with decreasing concentrations of DDGS from 466.8 to 0 g/kg and a N-free diet were prepared. The SID of AA, except for arginine, cysteine, and glycine, in DDGS linearly decreased (P < 0.05) with increasing concentrations of casein in experimental diets. Quadratic response (P = 0.023) was observed in the SID of lysine in DDGS when the concentration of casein in experimental diets increased. In experiment 2, the same 20 barrows (initial BW = 52.8 ± 2.99 kg) and experimental design as experiment 1 were used with different diets, which were prepared as a 2 × 2 factorial arrangement with the concentration of DDGS at 466.8 or 155.6 g/kg and that of casein at 0 or 110 g/kg. Regardless of the addition of casein, pigs fed experimental diets containing 466.8 g/kg DDGS had greater (P < 0.01) SID of indispensable AA, except for tryptophan, in DDGS than those fed diets containing 155.6 g/kg DDGS. In conclusion, the addition of casein in experimental diets did not affect the SID of AA in DDGS, whereas the SID of AA in DDGS decreased as the concentration of DDGS in diets decreased.     

Effect of feed restriction on the performance and behaviour of pigs immunologically castrated with Improvac®

For centuries, entire male pigs have been castrated to reduce the risk of boar taint. However, physical castration of pig is increasingly being questioned with regard to animal welfare considerations. Immunization against gonadotrophin releasing hormone (GnRH) provides an alternative to physical castration. Using the currently available commercial product (Improvac®; Pfizer Animal Health), a two-dose regimen of a GnRH vaccine is administered. After the second vaccination, a substantial increase in feed consumption has been reported, which may be associated with increased body fatness and decreased feed efficiency when compared with unvaccinated entire male pigs. The aim of the present study was to investigate the effect of a feed restriction on these traits and on the behaviour of 120 group-housed entire males (five pigs/pen) vaccinated against GnRH. The first vaccination was performed at 62 days of age and the second (V2) at 130 days of age. Pigs were slaughtered in two batches 4 to 5 weeks after V2. They were either offered feed ad libitum over the 22 to 114 kg BW range (AL treatment) or ad libitum up to a maximum of 2.50 (R2.50 treatment) or 2.75 kg/day per pig (R2.75 treatment). Behavioural observations and skin lesion scoring were conducted 1 week before V2, and 1 and 3 weeks after V2. At slaughter, the volumetric lean meat content was measured using an X-ray computed tomography scanner. Between V2 and slaughter, the average feed intakes for the R2.75 and R2.50 treatments were 15% and 22% lower than the average AL feed intake (3.20 kg/day), respectively. Feed restriction was associated with a reduced average daily gain after V2 (846, 932 and 1061 g/day in the R2.50, R2.75 and AL groups, P < 0.01) but had no effect on the feed conversion ratio (3.00 kg feed/kg BW gain on average, P = 0.62). No difference was observed in the lean meat content (71.8%, 70.7% and 70.4% in the R2.50, R2.75 and AL groups, P = 0.14), despite a reduced backfat thickness measured in restrictively fed pigs (12.0, 13.0 and 13.6 mm in the R2.50, R2.75 and AL groups, P < 0.01). Higher skin lesion scores were observed 3 weeks after V2 in R2.50 and R2.75 pigs than in the AL ones (scores 33.4, 27.7 and 25.5, respectively, P = 0.04). These results, combined with an unimproved feed efficiency and no marked change in carcass characteristics, suggest that immunologically castrated pigs should not be restrictively fed during the late finishing period.     

Identifying the limitations for growth in low performing piglets from birth until 10 weeks of age

The evolution of hyper-prolific pig breeds has led to a higher within-litter variation in birth weight and in BW gain during the nursery phase. Based on an algorithm developed in previous research, two populations from a pool of 368 clinically healthy piglets at 6 weeks of age were selected: a low (LP) and a high (HP) performing population and their development was monitored until the end of the nursery phase (10 weeks of age). To understand the cause of the variation in growth between these populations we characterized the LP and HP piglets in terms of body morphology, behaviour, voluntary feed intake, BW gain, and apparent total tract and ileal nutrient digestibility. Piglets were housed individually and were fed a highly digestible diet. At selection, 6 weeks of age, the BW of LP and HP piglets were 6.8±0.1 and 12.2±0.1 kg, respectively. Compared with the LP piglets the HP piglets grew faster (203 g/day), ate more (275 g/day) from 6 to 10 weeks of age and were heavier at 10 weeks (30.0 v. 18.8 kg, all P<0.01). Yet, the differences in average daily gain and average daily feed intake disappeared when compared per kg BW^0.75. Assuming similar maintenance requirements per kg BW^0.75 the efficiency of feed utilization above maintenance was 0.1 g/g lower for the LP piglets (P=0.09).The gain : feed ratio was similar for both groups. LP piglets tended to take more time to touch a novel object (P=0.10), and spent more time eating (P<0.05). At 10 weeks, LP piglets had a higher body length and head circumference relative to BW (P<0.01). Relative to BW, LP had a 21% higher small intestine weight; 36% longer length, and relative to average FI, the small intestinal weight was 4 g/kg higher (both P=<0.01). Apparent total tract and ileal dry matter, N and gross energy digestibility were similar between groups (P>0.10). We concluded that the low performance of the LP piglets was due to their inability to engage compensatory gain or compensatory feed intake as efficiency of nutrient utilization and feed intake per kg BW^0.75 was unaffected. LP piglets tend to be more fearful towards novel objects. The morphological comparisons, increased body length and head circumference relative to BW imply that LP piglets have an increased priority for skeletal growth.