Characterization of chitinases of polycentric anaerobic rumen fungi

Chitinolytic systems of anaerobic polycentric rumen fungi of genera Orpinomyces and Anaeromyces were investigated in three crude enzyme fractions - extracellular, cytosolic and cell-wall. Endochitinase was found as a dominant enzyme with highest activity in the cytosolic fraction. Endochitinases of both genera were stable at pH 4.5-7.0 with optimum at 6.5. The Orpinomyces endochitinase was stable up to 50 degrees C with an optimum for enzyme activity at 50 degrees C; similarly, Anaeromyces endochitinase was stable up to 40 degrees C with optimum at 40 degrees C. The most suitable substrate for both endochitinases was fungal cell-wall chitin. Enzyme activities were inhibited by Hg(2+) and Mn(2+), and activated by Mg(2+) and Fe(3+). Both endochitinases were inhibited by 10 mmol/L SDS and activated by iodoacetamide.     

Expression and characterization of <Emphasis Type="Italic">Trichoderma virens</Emphasis> UKM-1 endochitinase in <Emphasis Type="Italic">Escherichia</Emphasis> <Emphasis Type="Italic">coli</Emphasis>

A gene encoding endochitinase from Trichoderma virens UKM-1 was cloned and expressed in E. coli BL21 (DE3). Both the endochitinase gene and its cDNA sequences were obtained. The endochitinase gene encodes 430 amino acids from an open reading frame comprising of 1,690 bp nucleotide sequence with three introns. The endochitinase was expressed as soluble and active enzyme at 20°C when induced with 1 mM IPTG. Maximum activity was observed at 4 h of post-induction time. SDS-PAGE showed that the purified endochitinase exhibited a single band with molecular weight of 42 kDa. Biochemical characterization of the enzyme displayed a near neutral pH characteristic with an optimum pH at 6.0 and optimum temperature at 50°C. The enzyme is stable between pH 3.0–7.0 and is able to retain its activity from 30 to 60°C. The presence of Mg²⁺ and Ca²⁺ ions increased the enzyme activity up to 20%. The purified enzyme has a strong affinity towards colloidal chitin and low effect on ethyl cellulose and D-cellubiose which are non-chitin related substrates. HPLC analysis from the chitin hydrolysis showed the release of (GlcNAc)₃, (GlcNAc)₂ and GlcNAc, in which (GlcNAc)₂ was the main product.     

温和气单孢菌YH311硫酸软骨素裂解酶的分离纯化与固定化

通过硫酸铵沉淀、QAESephadex-A50柱层析及Sephadex-G150凝胶过滤等纯化步骤,对源自温和气单孢菌YH311的ChSase进行了分离纯化。结果表明,ChSase经上述纯化步骤后被纯化了55倍,其最终纯度可达95%以上,比活为31.86u/mg。经SDSPAGE及IFE测定可知该酶的分子量约为80kD,等电点为4.3～4.8。将纯化后的ChSase用海藻酸钠或纤维素固定化后,ChSase的热稳定性及贮存稳定性均可得到大幅度的提高：固定化酶用80℃水浴处理120min或于4℃冰箱放置30d后仍可保留50%以上的相对活力;但固定化酶的收率较低,仅为18.56%和18.86%。     

Optimization of extracellular thermotolerant alkaline protease produced by marine <Emphasis Type="Italic">Roseobacter</Emphasis> sp. (MMD040)

Marine endosymbiontic Roseobacter sp. (MMD040), which produced high yields of protease, was isolated from marine sponge Fasciospongia cavernosa, collected from the peninsular coast of India. Maximum production of enzyme was obtained in Luria-Bertani broth. Catabolite repression was observed when the medium was supplemented with readily available carbon sources. The optimum temperature and pH for the enzyme production was 37 degrees C and 7.0, respectively. The enzyme exhibited maximum activity in pH range of 6-9 with an optimum pH of 8.0 and retained nearly 92.5% activity at pH 9.0. The enzyme was stable at 40 degrees C and showed 89% activity at 50 degrees C. Based on the present findings, the enzyme was characterized as thermotolerant alkaline protease, which can be developed for industrial applications.     

An acidic protease from the grass carp intestine (Ctenopharyngodon idellus)

The acidic Protease was extracted from the intestine of the grass carp (Ctenopharyngodon idellus) by 0.1 M sodium phosphate buffer, pH 7.0 at 4 degrees C after neat intestine was defatted with acetone, and partially purified by ammonium sulfate precipitation, gel filtration chromatography and ionic exchange chromatography. SDS-PAGE electrophoresis showed that the enzyme was homogeneous with a relative molecular mass of 28,500. Substrate-PAGE at pH7.0 showed that the purified acidic protease has only an active component. Specificity and inhibiting assays showed that it should be a cathepsin D. The optimal pH and optimal temperature of the enzyme were pH2.5 and 37 degrees C, respectively. It retained only 20% of its initial activity after incubating at 50 degrees C for 30 min. The enzyme lost 81% of its activity after incubation with pepstatin A at room temperature, but was not inhibited by soybean trypsin inhibitor or phenylmethylsulfonyl fluoride (PMSF). Its V(max) and K(m) values were determined to be 3.57 mg/mL and 0.75 min(-1), respectively.     

Purification and characterization of a thermostable α-amylase fromBacillus stearothermophilus

A soil isolate of Bacillus stearothermophilus was found to synthesize thermostable alpha-amylase. The enzyme was purified to homogeneity by ammonium sulfate fractionation and IECC on DEAE-cellulose column. The purified enzyme was considered to be a monomeric protein with a molar mass of 64 kDa, as determined by SDS-PAGE. The enzyme showed a wide range of pH tolerance and maximum activity at pH 7.0. The temperature tolerance was up to 100 degrees C with more than 90% catalytic activity; the maximum activity was observed at 50 degrees C. Divalent metal ions exhibited inhibitory effect on the enzyme activity. However, proteinase inhibitor did not react positively.     

Purification and characterization of an oxygen-sensitive, reversible 3,4-dihydroxybenzoate decarboxylase from Clostridium hydroxybenzoicum.

A 3,4-dihydroxybenzoate decarboxylase (EC 4.1.1.63) from Clostridium hydroxybenzoicum JW/Z-1T was purified and partially characterized. The estimated molecular mass of the enzyme was 270 kDa. Sodium dodecyl sulfate-polyacrylamide gel electrophoresis gave a single band of 57 kDa, suggesting that the enzyme consists of five identical subunits. The temperature and pH optima were 50 degrees C and pH 7.0, respectively. The Arrhenius energy for decarboxylation of 3,4-dihydroxybenzoate was 32.5 kJ . mol(-1) for the temperature range from 22 to 50 degrees C. The Km and kcat for 3,4-dihydroxybenzoate were 0.6 mM and 5.4 x 10(3) min(-1), respectively, at pH 7.0 and 25 degrees C. The enzyme optimally catalyzed the reverse reaction, that is, the carboxylation of catechol to 3,4-dihydroxybenzoate, at pH 7.0. The enzyme did not decarboxylate 2-hydroxybenzoate, 3-hydroxybenzoate, 4-hydroxybenzoate, 2,3-dihydroxybenzoate, 2,4-dihydroxybenzoate, 2,5-dihydroxybenzoate, 2,3,4-trihydroxybenzoate, 3,4,5-trihydroxybenzoate, 3-F-4-hydroxybenzoate, or vanillate. The decarboxylase activity was inhibited by 25 and 20%, respectively, by 2,3,4- and 3,4,5-trihydroxybenzoate. Thiamine PPi and pyridoxal 5'-phosphate did not stimulate and hydroxylamine and sodium borohydride did not inhibit the enzyme activity, indicating that the 3,4-dihydroxybenzoate decarboxylase is not a thiamine PPi-, pyridoxal 5'-phosphate-, or pyruvoyl-dependent enzyme.     

Purification and characterization of a novel mannitol dehydrogenase from Lactobacillus intermedius

Mannitol 2-dehydrogenase (MDH) catalyzes the pyridine nucleotide dependent reduction of fructose to mannitol. Lactobacillus intermedius (NRRL B-3693), a heterofermentative lactic acid bacterium (LAB), was found to be an excellent producer of mannitol. The MDH from this bacterium was purified from the cell extract to homogeneity by DEAE Bio-Gel column chromatography, gel filtration on Bio-Gel A-0.5m gel, octyl-Sepharose hydrophobic interaction chromatography, and Bio-Gel Hydroxyapatite HTP column chromatography. The purified enzyme (specific activity, 331 U/mg protein) was a heterotetrameric protein with a native molecular weight (MW) of about 170 000 and subunit MWs of 43 000 and 34 500. The isoelectric point of the enzyme was at pH 4.7. Both subunits had the same N-terminal amino acid sequence. The optimum temperature for the reductive action of the purified MDH was at 35 degrees C with 44% activity at 50 degrees C and only 15% activity at 60 degrees C. The enzyme was optimally active at pH 5.5 with 50% activity at pH 6.5 and only 35% activity at pH 5.0 for reduction of fructose. The optimum pH for the oxidation of mannitol to fructose was 7.0. The purified enzyme was quite stable at pH 4.5-8.0 and temperature up to 35 degrees C. The K(m) and V(max) values of the enzyme for the reduction of fructose to mannitol were 20 mM and 396 micromol/min/mg protein, respectively. It did not have any reductive activity on glucose, xylose, and arabinose. The activity of the enzyme on fructose was 4.27 times greater with NADPH than NADH as cofactor. This is the first highly NADPH-dependent MDH (EC 1.1.1.138) from a LAB. Comparative properties of the enzyme with other microbial MDHs are presented.     

Production physiology and properties of a novel fungal fibrinolytic enzyme.

A potent extracellular fibrinolytic enzyme was obtained from cultures of the imperfect fungus Fusarium semitectum under certain growth conditions. Nitrate addition to cultures increased enzyme production. The enzyme showed a versatile proteolytic activity against several protein substrates including casein, gelatin, haemoglobin, bovine serum albumin, and fibrin from both buffalo and human sources. Optimal fibrinolysis occurred at pH values around 7.0. The fibrinolytic activity exhibited marked heat stability in enzyme samples heated at 60 degrees C, and retained more than 40% of its activity in samples heated to 100 degrees C for 10 min. Fibrinolysis proceeded optimally in the temperature range between 50--60 degrees C. Copper ions significantly activated the enzyme. Other biochemical properties are also reported.     

Purification and characterization of a recombinant β-galactosidase with transgalactosylation activity from Bifidobacterium infantis HL96

A beta-galactosidase isoenzyme, beta-Gall, from Bifidobacterium infantis HL96, was expressed in Escherichia coli and purified to homogeneity. The molecular mass of the beta-Gall subunit was estimated to be 115 kDa by SDS-PAGE. The enzyme appeared to be a tetramer, with a molecular weight of about 470 kDa by native PAGE. The optimum temperature and pH for o-nitrophenyl-beta-D-galactopyranoside (ONPG) and lactose were 60 degrees C, pH 7.5, and 50 degrees C, pH 7.5, respectively. The enzyme was stable over a pH range of 5.0-8.5, and remained active for more than 80 min at pH 7.0, 50 degrees C. The enzyme activity was significantly increased by reducing agents. Maximum activity required the presence of both Na+ and K+, at a concentration of 10 mM. The enzyme was strongly inhibited by p-chloromercuribenzoic acid, divalent metal cations, and Cr3+, and to a lesser extent by EDTA and urea. The hydrolytic activity using lactose as a substrate was significantly inhibited by galactose. The Km, and Vmax values for ONPG and lactose were 2.6 mM, 262 U/mg, and 73.8 mM, 1.28 U/mg, respectively. beta-Gall possesses strong transgalactosylation activity. The production rate of galactooligosaccharides from 20% lactose at 30 and 60 degrees C was 120 mg/ml, and this rate increased to 190 mg/ml when 30% lactose was used.     

Lipase activity and gene cloning of Acinetobacter calcoaceticus LP009

The production of lipase from Acinetobacter calcoaceticus LP009, a bacterium isolated from raw milk, was found to be best induced by Tween-80 at 1.0% concentration. It was efficiently secreted, and only a minute amount of activity was detected at the cell surface and intracellularly. A. calcoaceticus LP009 lipase exhibited maximum activity at pH 7.0 and 50 degrees C, and was relatively stable upon storage at pH 5.0 to 7.0 and at 4, 30, or 37 degrees C. The enzyme was found to be inactivated by EDTA suggesting that it was a metalloenzyme. Its activity was reduced by less than 20% with the addition of various ions to reaction mixtures, but long storage with them caused approximately 50% reduction in subsequent reactions under standard conditions. By contrast, the addition of Fe(3+) enhanced activity. The enzyme was highly stable upon storage with 0.1% of Triton X-100, Tween-80 or Tween-20, but highly unstable with various organic solvents tested. PMSF, a serine enzyme inhibitor, and 2-mercaptoethanol, a reducing agent, did not affect enzyme activity. After extraction and transfer, the lipase gene was efficiently expressed in recombinant Aeromonas sobria. This recombinant strain was shown to have increased hydrolyzing efficiency and have high potential for lipid-rich wastewater treatment.     

芽孢杆菌M50产生β—甘露聚糖酶的条件研究

从土壤中分离到９株产生β－甘露聚糖酶的芽孢杆菌（Ｂａｃｉｌｌｕｓ ｓｐ．）。Ｂａｃｉｌｌｕｓ ｓｐ．Ｍ５０２５０ｍＬ三角瓶摇瓶培养试验,以４％的魔芋粉为碳源,１．０％（ＮＨ４）２ＳＯ４为氮源,０．３５％Ｎａ２ＣＯ３,３０～３４℃培养６０ｈ产酶达到高峰。酶活力为１８０～２２０ｕ／ｍＬ。１００Ｌ罐发酵,在３０～３２℃,１：０．７５ｖｖｍ通气量,２００ｒ／ｍｉｎ条件下,发酵液酶活力高达３３０ｕ／ｍＬ。     

The production of hemicellulases by aerobic fungi on medium containing residues of banana plant as substrate

Trichoderma harzianum strains T4 and T6, Acrophialophora nainiana, and Humicola grisea var. thermoidea were screened for their ability to produce carbohydrate-degrading enzyme activities in a medium containing banana plant residue as the carbon source. The best balance of enzyme activities was obtained from cultures of H. grisea var. thermoidea. Xylanase activity from crude extract of A. nainiana had a maximum activity at pH 5.5-7.0 and a temperature range of 50-55 degrees C. It was stable up to 55 degrees C at pH 7.0 for at least 2 h. The fungi were also able to produce xylanase and pectinase activities when grown on extractives as substrate.     

One-step purification and properties of catalase from leaves of Zantedeschia aethiopica

Catalase (E.C 1.11.1.6) was purified from leaves of Zandedeschia aethiopica to apparent homogeneity by a one-step hydrophobic interaction chromatography on a phenyl Sepharose CL-4B column. The purified enzyme preparation was obtained with a final recovery of enzyme activity of about 61% and a specific activity of 146 U/mg protein. The purified enzyme ran as a single protein band when analyzed both by native PAGE and SDS-PAGE corresponding to an Mr of 220,000 Da, which consists of 4 subunits with identical Mr of 54,000 Da. The pI of purified enzyme was found to be 5.2 by isoelectric focusing on ultrathin polyacrylamide gels. The purified catalase has an optimum temperature of activity at 40 degrees C, whereas it is stable between 0 degrees and 50 degrees C. As regards pH, the enzyme has an optimum activity at pH 7.0 and it is stable in the range pH 6-8. The absorption spectrum of the purified enzyme exhibited 2 peaks at 280 nm and 405 nm.     

Purification and characterization of carboxymethyl cellulase from Bacillus sp. isolated from a paddy field

A microorganism hydrolyzing carboxymethyl cellulose was isolated from a paddy field and identified as Bacillus sp. Production of cellulase by this bacterium was found to be optimal at pH 6.5, 37 degrees C and 150 rpm of shaking. This cellulase was purified to homogeneity by the combination of ammonium sulphate precipitation, DEAE cellulose, and sephadex G-75 gel filtration chromatography. The cellulase was purified up to 14.5 fold and had a specific activity of 246 U/mg protein. The enzyme was a monomeric cellulase with a relative molecular mass of 58 kDa, as determined by SDS-PAGE. The enzyme exhibited its optimal activity at 50 degrees C and pH 6.0. The enzyme was stable in the pH range of 5.0 to 7.0 and its stability was maintained for 30 min at 50 degrees C and its activity got inhibited by Hg2+, Cu2+, Zn2+, Mg2+, Na2+, and Ca2+.     

漆酶在磁性壳聚糖微球上的固定及其酶学性质研究

以磁性壳聚糖微球为载体,戊二醛为交联剂,共价结合制备固定化漆酶。探讨了漆酶固定化的影响因素,并对固定化漆酶的性质进行了研究。确定漆酶固定化适宜条件为：50 mg磁性壳聚糖微球,加入10mL 0.8mg/mL 漆酶磷酸盐缓冲液（0.1mol/L,pH 7.0）,在4℃固定2h。固定化酶最适pH为3.0, 最适温度分别为10℃和55℃,均比游离酶降低5℃。在pH 3.0,温度37℃时,固定化酶对ABTS的表观米氏常数为171.1μmol/L。与游离酶相比,该固定化漆酶热稳定性明显提高,并具有良好的操作和存储稳定性。     

Purification and Properties of beta-1, 4-Xylanase from Aeromonas caviae W-61

Aeromonas caviae W-61, which was isolated from water samples at the Faculty of Agriculture, Tohoku University, produced beta-1, 4-xylanase (1,4-beta-d-xylan xylanohydrolase; EC 3.2.1.8) extracellularly. The xylanase was purified to homogeneity by using DEAE-Sephadex A-50, CM-Sephadex C-50, and Sephadex G-100 column chromatographies. The molecular weight of the purified enzyme was estimated to be 22,000 by sodium dodecyl sulfate-polyacrylamide gel electrophoresis. The isoelectric point of the enzyme was 9.2. The optimal pH and temperature for the activity of the enzyme were 7.0 and 55 degrees C, respectively. The enzyme was stable at pH 7.0 at temperatures of up to 50 degrees C. As enzymatic products, various xylo-oligosaccharides such as xylobiose, xylotriose, xylotetraose, and xylopentaose were formed, and only a small amount of xylose was detected. The purified enzyme did not hydrolyze starch, cellulose, carboxymethylcellulose, or beta-1, 3-xylan.     

Effect of temperature and pH on the ribulose-1,5-diphosphate carboxylase activity of the thermophilic hydrogen bacterium, Pseudomonas thermophila

The activity of ribulose 1,5-diphosphate (RDP) carboxylase was found in the soluble fraction of the cytoplasm from sonicated Pseudomonas thermophila K-2 cells. The enzyme is relatively thermolabile and completely loses its activity at 80 degrees C. The activity of RDP carboxylase at 60 degrees C increases by 40% during the first 10 min of heating in the presence of Mg2+ ions, bicarbonate and dithiothreitol, and again decreases if the enzyme is heated over 20 min. The optimum temperature of the enzyme is 50--55 degrees C. The specific activity of the enzyme in fresh preparations under these conditions reaches 0.22 unit per 1 mg of protein in the extract. The calculated value of the activation energy for RDP carboxylase is 6.4 kcal-mole-1, but 11.6 kcal-mole-1 in frozen preparations. The optimal pH is 7.0--7.3 depending on the buffer. The temperature optimum for the enzyme action does not depend on pH within the range of 7.3 to 8.8. Therefore, RDP carboxylase of Ps. thermophila K-2 differs from RDP carboxylases of mesophilic cultures studied earlier by a higher susceptibility to a decrease in temperature (the enzyme activity is negligible at 30 degrees C), by a lower value of the activation energy at suboptimal temperatures, and by a lower pH optimum of the enzyme action.     

Isolation of Thermoanaerobacter keratinophilus sp. nov., a novel thermophilic, anaerobic bacterium with keratinolytic activity

Several thermophilic anaerobic bacteria with keratinolytic activity growing at temperatures between 50 degrees C and 90 degrees C were isolated from samples collected on the island of S?o Miguel in the Azores (Portugal). On the basis of morphological, physiological, and 16S rDNA studies, the isolate 2KXI was identified as a new species of the genus Thermoanaerobacter, designated Thermoanaerobacter keratinophilus. This strain, which grows optimally at 70 degrees C, pH 7.0, and 0.5% NaCl, is the first member of the genus Thermoanaerobacter that has been described for its ability to degrade native keratin. Around 70% of native wool was solubilized after 10 days of incubation under anaerobic conditions. The strain was shown to possess intracellular and extracellular proteases optimally active at 60 degrees C, pH 7.0, and 85 degrees C, pH 8.0, respectively. Keratin hydrolysis was demonstrated in vitro using a sodium dodecyl sulfate gel containing feather meal. The extracellular protease responsible for breaking down keratin fibers was purified to homogeneity in only one step by applying hydroxyapatite column chromatography. The enzyme belongs to the serine-type proteases and has a molecular mass of 135 kDa.     

Hydrolysis of rice hull by crosslinked Aspergillus niger cellulase

A. niger cellulase was crosslinked by glutaraldehyde to obtain a heat-stable enzyme preparation for rice hull cellulose hydrolysis. Under optimized crosslinking conditions of 0.12 M glutaraldehyde, pH 7.0, temperature 40 degrees C and at 45 min of crosslinking, a preparation having 15% more activity than free enzyme was obtained which also had considerable improvement in heat stability at 65 degrees C and 70 degrees C. Whereas the free enzyme lost 80% of its activity in 4 h at 65 degrees C, the crosslinked preparation lost only 30% activity. The crosslinked preparation hydrolyzed cellulosic biomass more effectively giving 2.2 mg/ml glucose and 52% corresponding saccharification in 4 h at 65 degrees C as compared to 14% saccharification by free enzyme under similar conditions.