The prevention of an anomalous chromatographic behavior and the resulting successful removal of viruses from monoclonal antibody with an asymmetric charge distribution by using a membrane adsorber in highly efficient,anion-exchange chromatography in flow-through mode

Anion exchange (AEX) chromatography in the flow-through mode is a widely employed purification process for removal of process/product-related impurities and exogenous/endogenous viruses from monoclonal antibodies (mAbs). The pH of the mobile phase for AEX chromatography is typically set at half a unit below the isoelectric point (pI) of each mAb (i.e., pI − 0.5) or lower and, in combination with a low ionic strength, these conditions are usually satisfactory for both the recovery of the mAb and removal of impurities. However, we have recently encountered a tight binding of mAb1 to AEX resins under these standard chromatographic conditions. This anomalous adsorption behavior appears to be an effect of the asymmetric charge distribution on the surface of the mAb1. We found that mAb1 did not bind to the AEX resins if the mobile phase has a much lower pH and higher ionic strength, but those conditions would not allow adequate virus removal. We predicted that the use of membrane adsorbers might provide effective mAb1 purification, since the supporting matrix has a network structure that would be less susceptible to interactions with the asymmetric charge distribution on the protein surface. We tested the Natriflo HD-Q AEX membrane adsorber under standard chromatographic conditions and found that mAb1 flowed through the membrane adsorber, resulting in successful separation from murine leukemia virus. This AEX membrane adsorber is expected to be useful for process development because mAbs can be purified under similar standard chromatographic conditions regardless of their charge distributions.     

High-performance countercurrent membrane purification for host cell protein removal from monoclonal antibody products

The transition to continuous biomanufacturing has led to renewed interest in alternative approaches for downstream processing of monoclonal antibody (mAb) products. In this study, we examined the potential of using high-performance countercurrent membrane purification (HPCMP) for the removal of host cell proteins (HCPs) derived from Chinese Hamster Ovary cells in the purification of a mAb. Initial studies used several model proteins to identify appropriate operating conditions for the hollow fiber membrane modules. HPCMP was then used for mAb purification, with mAb yield >95% and more than 100-fold reduction in HCP. Stable operation was maintained for 48 h for feeds that were first prefiltered through the 3M^TM Harvest RC chromatographic clarifier to remove DNA and other foulants. In addition, the Process Mass Intensity for HPCMP can be much less than that for alternative HCP separation processes. These results highlight the potential of using HPCMP as part of a fully continuous mAb production process.     

Innovative modular membrane adsorber system for high-throughput downstream screening for protein purification

To develop the most efficient strategy for the purification of proteins, two types of adsorber membrane devices with different functionalities were designed and tested: 8-strips and single spin columns. The most suitable type of membrane adsorber and the optimal chromatographic loading/elution conditions for several target proteins from different biological matrices could be determined simultaneously in microliter scale. Ion exchange (IEX), metal chelate (MC), and Concanavalin A (Con A) modified membrane types were tested in the devices. Bovine serum albumin (BSA) and lysozyme were used as model proteins for investigations of the binding capacity and protein recovery percentage of the 8-strip anion exchange and the cation exchange membrane. The isolation of His(6)-tagged proteins, Bgl-His and GFP-His from fermentation broth and lysate, respectively, was performed using an 8-strip metal chelate affinity membrane loaded with different metal ions. Separation behavior of a ternary protein mixture (BSA, lysozyme, and Bgl-His) was studied in 8-strips IEX and metal chelate membrane chromatography. The Con A affinity devices were developed on the basis of metal chelate membrane spin columns loaded with Cu(2+) ions and investigated using glucose oxidase (GOD) as model protein. In summary, the advantages of the membrane adsorber technology, such as fast processing and easy scale-up, were utilized. The devices made it possible to load the membrane directly with preclarified fermentation broth or cell lysate and separate the protein of interest often in a single step.     

Two step capture and purification of IgG2 using multicolumn countercurrent solvent gradient purification (MCSGP)

A two‐step chromatography process for monoclonal antibody (mAb) purification from clarified cell culture supernatant (cCCS) was developed using cation exchange Multicolumn Countercurrent Solvent Gradient Purification (MCSGP) as a capture step. After an initial characterization of the cell culture supernatant the capture step was designed from a batch gradient elution chromatogram. A variety of chromatographic materials was screened for polishing of the MCSGP‐captured material in batch mode. Using multi‐modal anion exchange in bind‐elute mode, mAb was produced consistently within the purity specification. The benchmark was a state‐of‐the‐art 3‐step chromatographic process based on protein A, anion and cation exchange stationary phases. The performance of the developed 2‐step process was compared to this process in terms of purity, yield, productivity and buffer consumption. Finally, the potential of the MCSGP process was investigated by comparing its performance to that of a classical batch process that used the same stationary phase. Biotechnol. Bioeng. 2010;107: 974–984. © 2010 Wiley Periodicals, Inc.     

Protein affinity map of chemical space

Affinity fingerprinting is a quantitative method for mapping chemical space based on binding preferences of compounds for a reference panel of proteins. An effective reference panel of <20 proteins can be empirically selected which shows differential interaction with nearly all compounds. By using this map to iteratively sample the chemical space, identification of active ligands from a library of 30 000 candidate compounds has been accomplished for a wide spectrum of specific protein targets. In each case, <200 compounds were directly assayed against the target. Further, analysis of the fingerprint database suggests a strategy for effective selection of affinity chromatography ligands and scaffolds for combinatorial chemistry. With such a system, the large numbers of potential therapeutic targets emerging from genome research can be categorized according to ligand binding properties, complementing sequence based classification.     

New binding specificities derived from Min-23, a small cystine-stabilized peptidic scaffold

The randomization of both internal and surface residues in small protein domains followed by selection from a display library is emerging as a powerful strategy to obtain novel binding specificities. Small and stable scaffold motifs observed in disulfide-rich proteins are attractive because they are small, stable, and accessible to chemical synthesis. The elementary structural motif found in the squash trypsin inhibitor EETI-II (Ecballium elaterium trypsin inhibitor) is the cystine stabilized beta-sheet (CSB) motif, found in nearly 50% of all known small disulfide-rich protein families. We have used Min-23, a short 23-residue peptide containing the CSB motif and shown to be a stable autonomous folding unit and one of the smallest scaffolds described to date, as a scaffold for selection of new binding ligands. We demonstrate that the core CSB motif in Min-23 is permissive to loop insertion, using peptide epitopes from hemagglutinin (HA) and Gla-protein (E). A phage library of more than 10(8) different clones has been constructed by insertion of a randomized sequence on a beta-turn of the Min-23 peptide. The selection of this library on a variety of 7 different targets allowed the isolation of 21 new specific binders, confirming the potential of Min-23 as a scaffold for the development of new ligands. The derived library is able to provide a wide range of novel compounds with possible applications in various biological and pharmaceutical areas.     

Immobilized receptor- and transporter-based liquid chromatographic phases for on-line pharmacological and biochemical studies: a mini-review

This review addresses the synthesis and characterization of two different types of receptor-based liquid chromatographic supports, one based upon a trans-membrane ligand gated ion channel receptor (the nicotinic acetylcholine receptor) and the other a soluble nuclear receptor (the estrogen receptor). In addition, studies with the P-glycoprotein transporter are also reported. The nicotinic receptor was immobilized via hydrophobic insertion into the interstitial spaces of an immobilized artificial membrane (IAM) stationary phase. the estrogen receptor was tethered to a hydrophilic stationary phase and the membranes containing the Pgp transporter were coated on the surface of the IAM stationary phase. The stationary phases were characterized using known ligands and substrates for the respective non-immobilized proteins. The results from zonal and frontal chromatographic experiments demonstrated that the stationary phases could be used to determine binding affinities (expressed as dissociation constants, Kd,'s) and to resolve mixtures of ligands according to their relative affinities. In addition. competitive ligand binding studies on the P-glycoprotein-based stationary phase have established that this phase can be used to identify and characterize competitive displacement and allosteric interactions. These studies demonstrate that immobilized-receptor phases can be used for on-line pharmacological studies and as rapid screens for the isolation and identification of lead drug candidates from complex biological or chemical mixtures.     

Development and characterization of immobilized human organic anion transporter-based liquid chromatographic stationary phase: hOAT1 and hOAT2

This paper reports the development of liquid chromatographic columns containing immobilized organic anion transporters (hOAT1 and hOAT2). Cellular membrane fragments from MDCK cells expressing hOAT1 and S2 cells expressing hOAT2 were immobilized on the surface of the immobilized artificial membrane (IAM) liquid chromatographic stationary phase. The resulting stationary phases were characterized by frontal affinity chromatography, using the marker ligand [3H]-adefovir for the hOAT1 and [14C]-p-aminohippurate for the hOAT2 in the presence of multiple displacers. The determined binding affinities (Kd) for eight OAT1 ligands and eight OAT2 ligands were correlated with literature values and a statistically significant correlation was obtained for both the hOAT1 and hOAT2 columns: r2=0.688 (p<0.05) and r2=0.9967 (p<0.0001), respectively. The results indicate that the OAT1 and OAT2 have been successfully immobilized with retention of their binding activity. The use of these columns to identify ligands to the respective transporters will be presented.     

Fast and efficient protein purification using membrane adsorber systems

The purification of proteins from complex cell culture samples is an essential step in proteomic research. Traditional chromatographic methods often require several steps resulting in time consuming and costly procedures. In contrast, protein purification via membrane adsorbers offers the advantage of fast and gentle but still effective isolation. In this work, we present a new method for purification of proteins from crude cell extracts via membrane adsorber based devices. This isolation procedure utilises the membranes favourable pore structure allowing high flow rates without causing high back pressure. Therefore, shear stress to fragile structures is avoided. In addition, mass transfer takes place through convection rather than diffusion, thus allowing very rapid separation processes. Based on this membrane adsorber technology the separation of two model proteins, human serum albumin (HSA) and immungluboline G (IgG) is shown. The isolation of human growth hormone (hGH) from chinese hamster ovary (CHO) cell culture supernatant was performed using a cation exchange membrane. The isolation of the enzyme penicillin acylase from the crude Escherichia coli supernatant was achieved using an anion exchange spin column within one step at a considerable purity. In summary, the membrane adsorber devices have proven to be suitable tools for the purification of proteins from different complex cell culture samples.     

Recombinase-mediated cassette exchange-based screening of a CRISPR/Cas9 library for enhanced recombinant protein production in human embryonic kidney cells: Improving resistance to hyperosmotic stress

Targeted engineering of mammalian cells has been widely attempted to ensure the efficient production of therapeutic proteins with proper quality during bioprocesses. However, the identification of novel targets for cell engineering is labor-intensive and has not yet been fully substantiated. Here, we established a CRISPR/Cas9 library screening platform in human embryonic kidney (HEK293) cells based on guide RNA integration mediated by recombinase-mediated cassette exchange (RMCE) to interrogate gene function in a high-throughput manner. This platform was further advanced using a nuclear localization signal-tagged recombinase that increased RMCE efficiency by 4.8-fold. Using this platform, we identified putative target genes, such as CDK8, GAS2L1, and GSPT1, and their perturbation confers resistance to hyperosmotic stress that inhibits cell growth and induces apoptosis. Knockout of these genes in monoclonal antibody (mAb)-producing recombinant HEK293 (rHEK293) cells enhanced resistance to hyperosmotic stress-induced apoptosis, resulting in enhanced mAb production. In particular, GSPT1-knockout yielded 2.3-fold increase in maximum mAb concentration in fed-batch culture where hyperosmotic stress naturally occurs due to nutrient feeding. Taken together, this streamlined screening platform allows the identification of novel targets associated with hyperosmotic stress, enabling the development of stress-resistant cells producing recombinant proteins.     

Process intensification by frontal chromatography: Performance comparison of resin and membrane adsorber for monovalent antibody aggregate removal

Aggregates are amongst the most important product-related impurities to be removed during the downstream processing of antibodies due to their potential immunogenicity. Traditional operations use cation-exchange resins in bind-elute mode for their separation. However, frontal analysis is emerging as an alternative. In this study, a three-step process development for a membrane adsorber and a resin material is carried out, allowing the comparison between the stationary phases. Based on a screening study, optimal loading conditions are determined, which show that weak binding is favored on the membrane and strong binding on the resin. Transfer of these findings to breakthrough experiments shows that at 99% pool purity the yield is higher for the membrane, while the resin can be loaded twice as high, exceeding yields of 85%. For the investigated antibody and based on a given regeneration protocol, the productivity of the two phases is similar, ranging around 200 g/(L·h). Due to the higher loading, the resin requires about one-third less buffer than the membrane. Furthermore, the implementation of a wash step after loading allows to further increase yield by about 5%. In comparison to a generic bind-elute process, productivity and buffer consumption are improved by an order of magnitude.     

Mammalian plasma membrane proteomics

Plasma membrane proteins serve essential functions for cells, interacting with both cellular and extracellular components, structures and signaling molecules. Additionally, plasma membrane proteins comprise more than two-thirds of the known protein targets for existing drugs. Consequently, defining membrane proteomes is crucial to understanding the role of plasma membranes in fundamental biological processes and for finding new targets for action in drug development. MS-based identification methods combined with chromatographic and traditional cell-biology techniques are powerful tools for proteomic mapping of proteins from organelles. However, the separation and identification of plasma membrane proteins remains a challenge for proteomic technology because of their hydrophobicity and microheterogeneity. Creative approaches to solve these problems and potential pitfalls will be discussed. Finally, a representative overview of the impressive achievements in this field will also be given.     

Random phage-epitope library based identification of a peptide antagonist of Mac-1 β2 integrin ligand binding

The leukocyte β2 integrin Mac-1 (CD11b/CD18) plays a pivotal role in inflammation and host defense. To develop peptide antagonists selectively inhibiting the function of Mac-1, we used a random constrained 6-mer (cys-6aa-cys) peptide library to map the structural features of CD11b, by determining the epitope of neutralizing monoclonal antibody mAb 44a (anti-CD11b). We have used a stringent phage display strategy, which resulted in the identification of one disulfide C-RLKEKH-C constrained peptide by direct biopanning of library on decreasing amounts of purified mAb 44a. The selected peptide mimics a discontinuous epitope, a peculiar shape on the CD11b-I-domain surface. Competitive ELISA experiments with different Mac-1 ligands showed that C-RLKEKH-C is able to bind to fibrinogen, iC3b, and C1q. Furthermore, the monomeric circular peptide C-RLKEKH-C, was effective in blocking the interaction between (125)I-fibrinogen and Mac-1 (IC(50)=3.35±0.1×10(-6)M), and inhibited the adhesion of human neutrophils to fibrinogen and iC3b. These data provide information about the relative location of amino acids on the I-domain surface using mAb 44a imprint of the CD11b protein. The derived mimotope may help in the design of future anti-inflammatory therapeutic agents that can act as specific therapeutic agents targeting PMNs mediated inflammation.     

Farmer's peptidomimetic approach: A target for synthetic combinatorial libraries

Summary Two combinatorial libraries of 1296 compounds each were synthesized from two sets of carboxylic acid building blocks and two diamino acid scaffolds. The library was designed to produce low-molecular-weight compounds in a soluble form, to be assayed as potential ligands for peptidergic receptors.     

Antibody like peptidomimetics as large scale immunodetection probes.

Antibodies are often used to study the molecular basis of physiologic processes. Despite the widespread applications of monoclonal antibodies (mAb) from basic science to successful therapeutics in clinical settings their use is limited. Production of mAb is often cumbersome and creating diverse and therapeutic amounts of useful mAb is difficult. We have developed a methodology to reduce an antibody into much smaller peptidomimetics and have engineered the mimetics for increased serum half life and affinity. The novel species are termed "antibody like binding peptidomimetics" (ABiP). We developed the Anti-Her2/neu peptidomimetic (AHNP) which is a mimic of Herceptin, a mAb used for advanced breast cancer therapy. The AHNP has been used as a defining tool to develop immunodetection probes that exemplify a general process application. AHNP has been expressed as an oligomeric fusion protein with streptavidin. These Herceptin like ABiPs were used to detect the Her2/neu antigen at extremely low concentrations using the immunodetection amplification technique (IDAT) which our laboratory has also developed. A fully developed highly diverse library of ABiPs represents an alternative for panels of monoclonal antibodies and may also be useful for target validation, antigen detection, therapeutics and as a platform for drug development.     

Implementation of advanced technologies in commercial monoclonal antibody production

Process advancements driven through innovations have been key factors that enabled successful commercialization of several human therapeutic antibodies in recent years. The production costs of these molecules are higher in comparison to traditional medicines. In order to lower the development and later manufacturing costs, recent advances in antibody production technologies target higher throughput processes with increased clinical and commercial economics. In this review, essential considerations and trends for commercial process development and optimization are described, followed by the challenges to obtain a high titer cell culture process and its subsequent impact on the purification process. One of these recent technical advances is the development and implementation of a disposable Q membrane adsorber as an alternative to a Q-packed-bed column in a flow-through mode. The scientific concept and principles underlining Q membrane technology and its application are also reviewed.     

Dynamic behavior of adsorber membranes for protein recovery

In recent years there has been a considerable interest in developing membrane chromatography systems that function as a short, wide chromatographic column in which the adsorptive packing consists of one or more microporous membranes. This study reports the use of new adsorber membranes prepared by the incorporation of various types of ion exchange resins into an EVAL porous membrane for protein recovery. The obtained heterogeneous matrixes composed of solid particles surrounded by the polymeric film possess a good accessibility for the protein to the adsorptive sites. Furthermore, small particles can be embedded into porous polymeric structures without the disadvantages of classical chromatographic columns (high pressure drop, fouling and plugging sensitivity, low flow rate), but with the advantages of membrane technology (easy scale-up, low-pressure drop, high flow rate). The adsorptive membranes feature high static as well as dynamic protein adsorption capacities for operating flow rates ranging from 200 to 400 L h bar per m(2) and ionic strength of 20-200 mM. In a sequential desorption step by changing the pH and/or the ionic strength of the eluent, up to 90% protein recovery was obtained. Next to the separation, the mixed matrix adsorber membrane functions as a concentration medium since the protein can be concentrated up to 20-fold in the eluent. The adsorber membranes can be reused in multiple adsorption/desorption cycles with good adsorption performances.     

A new method for the screening of solid-phase combinatorial libraries for affinity chromatography

A new methodology for the rapid assessment of affinity ligands synthesized by combinatorial solid-phase chemistry is reported. This screening strategy utilizes the target protein conjugated to FITC, and represents an almost universal technique for the preliminary screening of solid-phase combinatorial libraries. The assessment of a triazine-scaffolded solid-phase combinatorial library of ligands, designed to bind to human IgG, was performed with FITC-human IgG, and the results compared with those obtained by conventional affinity chromatographic screening assays. The effect of different molar conjugation ratios of FITC-IgG (F/P) was evaluated. Independently of the F/P ratio, no false negative results were observed, although lower F/P ratios diminished non-specific interactions and the number of false positives. The nature of the substituents on the triazine scaffold was not related to the number of false positive IgG-binding ligands. The reproducibility of the FITC technique, using FITC-human IgG conjugates with low F/P ratio (F/P=2), was also evaluated. The FITC-based technique proved to be efficient and accurate in the identification of strongly binding ligands (binding >50% of loaded protein, by standard affinity chromatographic assays), and is envisaged as a versatile and cost-effective method to screen other systems, and evaluate several binding/elution conditions at small-scale, prior to scale-up to standard affinity chromatography.     

Enantioselective chromatography and absolute configuration of N,N-dimethyl-3-(naphthalen-2-yl)-butan-1-amines: potential sigma1 ligands

We describe the preparation of racemic N,N-dimethyl-3-(naphthalen-2-yl)-butan-1-amines, potential sigma1 ligands, and their resolution via chiral HPLC. In order to obtain enantiopure compounds, direct chromatographic methods of separation using chiral stationary phases were investigated. Different methods suitable for both analytical and semipreparative purposes are proposed. The best resolutions were achieved using cellulose tris (3,5-dimethylphenyl carbamate) (Chiralcel OD and OD-H) and amylose tris (3,5-dimethylphenyl carbamate) (Chiralpak AD). On the basis of the preliminary chromatographic results, the resolution of compound 1 was transferred onto a Chiralcel OD semipreparative column. The enantiomers were obtained in high enantiomeric excess. The configurational assignment was performed by circular dichroism. Computational analysis was used to explore the enantioselective recognition process of compound 1 with the Chiralcel OD stationary phase.     

A structure-based approach to retinoid X receptor-alpha inhibition

In this paper we describe a structure-based approach designed to identify novel ligands for retinoid X receptor-alpha (RXRalpha). By using a virtual approach based on a modified scoring function, we have selected 200 potential candidates on the basis of their predicted ability of docking into the ligand-binding site of the target. Subsequent experimental verification of the compounds in in vitro and cell-based assays led to the identification of a number of novel high affinity ligands for RXRalpha. The compounds are capable of displacing 9-cis-retinoic acid with IC(50) values in the 10 nm and 5 mum range and exhibit marked antagonistic activity in cellular assays. The inhibitory scaffolds discovered with this method form the basis for the development of novel RXRalpha ligands with potential therapeutic properties.