谷氨酸棒杆菌高丝氨酸脱氢酶编码基因hom的敲除

本研究以谷氨酸棒杆菌（Corynebacterium glutamicum）标准菌株ATCC 13032染色体为模板,设计引物PCR扩增高丝氨酸脱氢酶编码基因（hom）,在hom基因内部插入一段来源于质粒pET28a的卡那霉素抗性基因（Km）,得到基因元件hom::Km;通过电击转化法将hom::Km转入出发菌株替换原菌株的hom,在含卡那霉素的平板上挑取阳性转化子,通过PCR验证得到高丝氨酸脱氢酶缺陷的重组菌。发酵结果表明重组菌C.g- hom::Km -8发酵60小时赖氨酸产量达到4.7 g／L,是出发菌株谷氨酸棒杆菌ATCC 13032（0.7 g／L）的6.7倍。     

谷氨酸棒杆菌1dh基因的敲除

谷氨酸棒杆菌中ldh基因编码乳酸脱氢酶,可催化丙酮酸转化生成乳酸.利用重叠延伸PCR的方法,获得中间缺失部分序列的dldh基因片段,将其与载体pk 18mobsacB连接,转化大肠杆菌感受态,筛选出阳性转化子后,转化谷氨酸棒杆菌ATCC 13032感受态细胞.分别在卡那霉素抗性平板及10％蔗糖平板上进行两次筛选,利用PCR方法鉴定,成功获得ldh基因缺失的谷氨酸棒杆菌突变株ATCC 13032-(4)ldh.应用荧光定量PCR检测,ATCC 13032-(z)ldh中的ldh基因在转录水平与野生型菌株ATCC 13032相比,相对表达量为O.ldh基因的敲除对菌株的生长造成了一定的影响.     

Pyruvate carboxylase is a major bottleneck for glutamate and lysine production by Corynebacterium glutamicum

Corynebacterium glutamicum possesses both phosphoenolpyruvate carboxylase (PEPCx) and pyruvate carboxylase (PCx) as anaplerotic enzymes for growth on carbohydrates. To analyze the significance of PCx for the amino acid production by this organism, the wild-type pyc gene, encoding PCx, was used for the construction of defined pyc-inactive and pyc-overexpressing strains and the glutamate, lysine and threonine production capabilities of these recombinant strains of C. glutamicum were tested in comparison to the respective host strains. No PCx activity was observed in the pyc-inactive mutants whereas the pyc-overexpressing strains showed eight-to elevenfold higher specific PCx activity when compared to the host strains. In a detergent-dependent glutamate production assay, the pyc-overexpressing strain showed more than sevenfold higher, the PCx-deficient strain about twofold lower glutamate production than the wild-type. Overexpression of the pyc gene and thus increasing the PCx activity in a lysine-producing strain of C. glutamicum resulted in approximately 50% higher lysine accumulation in the culture supernatant whereas inactivation of the pyc gene led to a decrease by 60%. In a threonine-producing strain of C. glutamicum, the overexpression of the pyc gene led to an only 10 to 20% increase in threonine production, however, to a more than 150% increase in the production of the threonine precursor homoserine. These results identify the anaplerotic PCx reaction as a major bottleneck for amino acid production by C. glutamicum and show that the enzyme is an important target for the molecular breeding of hyperproducing strains.     

Lysine uptake and exchange in Corynebacterium glutamicum.

Resting cells of Corynebacterium glutamicum (ATCC 13032) accumulate [14C]lysine by a transport system with a relatively high affinity (10 microMs) and a low maximum velocity (0.15 nmol/min per mg [dry weight]). Uptake of lysine was not inhibited by uncouplers or by ionophores affecting the ion gradients and the energetic state of the cell. Analysis of intracellular amino acid concentrations during the transport reaction as well as kinetic studies revealed that the observed uptake of lysine in fact represents a homologous antiport between extracellular [14C]lysine and intracellular unlabeled lysine. Intracellular [14C]lysine could only be released by the addition of unlabeled lysine to the bacterial suspension. In contrast to this homologous antiport reaction, we observed net uptake of lysine in lysine-depleted cells of a lysine auxotrophic strain. This net uptake was found to be electrogenic and could also be observed as a heterologous antiport reaction in wild-type cells under particular conditions. In this case exchange was mediated between internal lysine and external alanine, isoleucine, or valine. This antiport was electrogenic, since the substrates differ in charge. The cells can switch between electroneutral homologous exchange and electrogenic heterologous antiport mode during fermentation because of changing metabolic conditions.     

Role of cytochrome bd oxidase from Corynebacterium glutamicum in growth and lysine production

Corynebacterium glutamicum possesses two terminal oxidases, cytochrome aa3 and cytochrome bd. Cytochrome aa3 forms a supercomplex with the cytochrome bc1 complex, which contains an unusual diheme cytochrome c1. Both the bc1 -aa3 supercomplex and cytochrome bd transfer reducing equivalents from menaquinol to oxygen; however, they differ in their proton translocation efficiency by a factor of three. Here, we analyzed the role of cytochrome bd for growth and lysine production. When cultivated in glucose minimal medium, a cydAB deletion mutant of C. glutamicum ATCC 13032 grew like the wild type in the exponential phase, but growth thereafter was inhibited, leading to a biomass formation 40% less than that of the wild type. Constitutive overproduction of functional cytochrome bd oxidase in ATCC 13032 led to a reduction of the growth rate by approximately 45% and of the maximal biomass by approximately 35%, presumably as a consequence of increased electron flow through the inefficient cytochrome bd oxidase. In the L-lysine-producing C. glutamicum strain MH20-22B, deletion of the cydAB genes had only minor effects on growth rate and biomass formation, but lysine production was increased by approximately 12%. Thus, the respiratory chain was shown to be a target for improving amino acid production by C. glutamicum.     

Improved electrotransformation frequencies of Corynebacterium glutamicum using cell-surface mutants

The electrotransformation efficiency for homologously- and heterologously-derived plasmid DNA was determined for two families of Corynebacterium glutamicum strains derived from ATCC13059 (AS019 and auxotrophic, cell surface mutants MLB133 and MLB194) and ATCC13032 (parent strain and restriction-minus mutants RM3 and RM4), following their growth in LBG supplemented with glycine plus isonicotinic acid hydrazide (INH). Electrotransformation efficiencies of MLB133 were up to 100-fold higher than for strain ASO19 and, when using heterologously-derived plasmid DNA, MLB133 showed efficiencies comparable to or better than strains RM3 and RM4, demonstrating the relative importance of cell surface structures in impeding DNA uptake in C. glutamicum. Transmission electron microscopy analysis of cell surface structures showed that strain MLB133 has a thin cell wall relative to AS019 and growth in either glycine or INH further diminished its thickness. Both RM3 and RM4 were more sensitive to INH than ATCC13032 and growth in glycine plus INH further improved transformation efficiency. The mycolic acid composition of these strains is described and the impact of glycine and INH on this is reported.     

New insights into the biogenesis of the cell envelope of corynebacteria: identification and functional characterization of five new mycoloyltransferase genes in Corynebacterium glutamicum

Mycolic acids, the major lipid constituents of Corynebacterineae, play an essential role in maintaining the integrity of the bacterial cell envelope. We have previously characterized a corynebacterial mycoloyltransferase (PS1) homologous in its N-terminal part to the three known mycobacterial mycoloyltransferases, the so-called fibronectin-binding proteins A, B and C. The genomes of Corynebacterium glutamicum (ATCC13032 and CGL2005) and Corynebacterium diphtheriae were explored for the occurrence of other putative corynebacterial mycoloyltransferase-encoding genes (cmyt). In addition to csp1 (renamed cmytA), five new cmyt genes (cmytB-F) were identified in the two strains of C. glutamicum and three cmyt genes in C. diphtheriae. In silico analysis showed that each of the putative cMyts contains the esterase domain, including the three key amino acids necessary for the catalysis. In C. glutamicum CGL2005 cmytE is a pseudogene. The four new cmyt genes were disrupted in this strain and overexpressed in the inactivated strains. Quantitative analyses of the mycolate content of all these mutants demonstrated that each of the new cMyt-defective strains, except cMytC, accumulated trehalose monocorynomycolate and exhibited a lower content of covalently bound corynomycolate than did the parent strain. For each mutant, the mycolate content was fully restored by complementation with the corresponding wild-type gene. Finally, complementation of the cmytA-inactivated mutant by the individual new cmyt genes established the existence of two classes of mycoloyltransferases in corynebacteria.     

Cloning and nucleotide sequence of the phosphoenolpyruvate carboxylase-coding gene of Corynebacterium glutamicum ATCC13032

As a first step in determining the importance of the anaplerotic function of phosphoenolpyruvate carboxylase (PEPC) in amino acid biosynthesis, the ppc gene coding for PEPC of Corynebacterium glutamicum ATCC13032 has been cloned by complementation of an Escherichia coli ppc mutant strain. PEPC activity encoded by the cloned gene is not affected by acetyl-CoA under conditions where the E. coli enzyme is strongly activated, whereas acetyl-CoA is able to relieve inhibition by L-aspartate used singly or in combination with alpha-ketoglutarate. Amplification of the ppc gene in a C. glutamicum lysine-excreting strain resulted in increased PEPC-specific activity and lysine productivity. The nucleotide sequence of a DNA fragment of 4885 bp encompassing the ppc gene has been determined. At the amino acid level, PEPC from C. glutamicum presents overall a high degree of similarity with corresponding enzymes from three different organisms. The location of some strictly conserved regions may have important implications for PEPC activity and allostery.     

赖氨酸-尸胺反向转运蛋白cadB基因谷氨酸棒杆菌表达载体的构建及转化

旨在提高谷氨酸棒杆菌合成尸胺的能力,将CadB克隆至谷氨酸棒杆菌中,与LDC共表达,在谷氨酸棒杆菌合成尸胺的同时,帮助尸胺转运至细胞外,解除尸胺的反馈抑制作用。谷氨酸棒杆菌能够高产赖氨酸脱羧酶的底物L-赖氨酸,但不含ldc和cadB基因,因而不能够直接合成尸胺。从E.coliK12中克隆出赖氨酸-尸胺反向转运蛋白基因,与绿色荧光蛋白基因gfp融合构建成融合表达载体pXBG,并转化至谷氨酸棒杆菌进行诱导表达,结果表明表达的CadB蛋白可以正确的定位于谷氨酸棒杆菌的细胞膜上。将基因cadB连接到含有赖氨酸脱羧酶基因的pXMJ19-ldc上,构建成能够共表达赖氨酸脱羧酶和赖氨酸-尸胺反向转运蛋白的重组质粒pXLB,并转化到谷氨酸棒杆菌中。     

Detection of D-ornithine extracellularly produced by Corynebacterium glutamicum ATCC 13032::argF

We found that Corynebacterium glutamicum ATCC 13032::argF extracellularly produced a large amount of D-ornithine when cultivated in a CGXII medium containing 1 mM L-arginine. This is the first report that C. glutamicum ATCC 13032 or its mutant produces a D-amino acid extracellularly. C. glutamicum ATCC 13032::argF produced 13 mM D-ornithine in 45 h of cultivation.     

Cloning and characterization of a DNA region encoding a stress-sensitive restriction system from Corynebacterium glutamicum ATCC 13032 and analysis of its role in intergeneric conjugation with Escherichia coli.

RP4-mediated transfer of mobilizable plasmids in intergeneric conjugation of Escherichia coli donors with Corynebacterium glutamicum ATCC 13032 is severely affected by a restriction system in the recipient that can be inactivated by a variety of exogenous stress factors. In this study a rapid test procedure based on intergeneric conjugal plasmid transfer that permitted the distinction between restriction-negative and restriction-positive C. glutamicum clones was developed. By using this procedure, clones of the restriction-deficient mutant strain C. glutamicum RM3 harboring a plasmid library of the wild-type chromosome were checked for their restriction properties. A complemented clone with a restriction-positive phenotype was isolated and found to contain a plasmid with a 7-kb insertion originating from the wild-type chromosome. This plasmid, termed pRES806, is able to complement the restriction-deficient phenotype of different C. glutamicum mutants. Sequence analysis revealed the presence of two open reading frames (orf1 and orf2) on the complementing DNA fragment. The region comprising orf1 and orf2 displayed a strikingly low G+C content and was present exclusively in C. glutamicum strains. Gene disruption experiments with the wild type proved that orf1 is essential for complementation, but inactivation of orf2 also resulted in a small but significant increase in fertility. These results were confirmed by infection assays with the bacteriophage CL31 from Corynebacterium lilium ATCC 15990.     

The effect of AmtR on growth and amino acids production in Corynebacterium glutamicum

AmtR, the master regulator of nitrogen control in Corynebacterium glutamicum, plays important roles in nitrogen metabolism. To investigate the influence of AmtR on amino acids production in C. glutamicum ATCC 13032, the amtR deletion strain C. glutamicum Q1 was constructed and cultured in modified CGXII minimal medium for 60 h. The ammonium consumption rates as well as amino acids production of both strains cultured in modified CGXII minimal medium were determined. The amtR deletion in C. glutamicum caused an obvious growth defect in the exponential growth phase, but both strains had the same biomass in the stationary phases. Maybe the less alpha-oxoglutarate was used for the tricarboxylic acid cycle to influence the growth of strains. During 12 h, the rate of ammonium consumption and the concentration of Glu, Pro, Arg and Ser were higher but Asp, Gly, Ile, Leu, Lys were lower in the mutation strain. During 48 h, the Q1 had higher levels of Asp, Lys, Pro, Ala and Val,and lower levels of Glu, Arg, Leu and Ile, compared to the wild. The more Glu was synthesized by the activated GS/GOGAT pathway in Q1, and then the accumulation of relative amino acids (Pro, Arg and Ser) were up-regulated within 12 h growth. After 48 h growth, the amtR deletion obviously influenced accumulation of Ala, Asp and Pro. The amtR deletion could influence the growth and amino acids production, which could be useful to the production of amino acids.     

Mixed glucose and lactate uptake by Corynebacterium glutamicum through metabolic engineering

The Corynebacterium glutamicum ATCC 13032 lysC(fbr) strain was engineered to grow fast on racemic mixtures of lactate and to secrete lysine during growth on lactate as well as on mixtures of lactate and glucose. The wild-type C. glutamicum only grows well on L-lactate. Overexpression of D-lactate dehydrogenase (dld) achieved by exchanging the native promoter of the dld gene for the stronger promoter of the sod gene encoding superoxide dismutase in C. glutamicum resulted in a duplication of biomass yield and faster growth without any secretion of lysine. Elementary mode analysis was applied to identify potential targets for lysine production from lactate as well as from mixtures of lactate and glucose. Two targets for overexpression were pyruvate carboxylase and malic enzyme. The overexpression of these genes using again the sod promoter resulted in growth-associated production of lysine with lactate as sole carbon source with a carbon yield of 9% and a yield of 15% during growth on a lactate-glucose mixture. Both substrates were taken up simultaneously with a slight preference for lactate. As surmised from the elementary mode analysis, deletion of glucose-6-phosphate isomerase resulted in a decreased production of lysine on the mixed substrate. Elementary mode analysis together with suitable objective functions has been found a very useful tool guiding the design of strains producing lysine on mixed substrates.     

The Corynebacterium glutamicum genome: features and impacts on biotechnological processes

Corynebacterium glutamicum has played a principal role in the progress of the amino acid fermentation industry. The complete genome sequence of the representative wild-type strain of C. glutamicum, ATCC 13032, has been determined and analyzed to improve our understanding of the molecular biology and physiology of this organism, and to advance the development of more efficient production strains. Genome annotation has helped in elucidation of the gene repertoire defining a desired pathway, which is accelerating pathway engineering. Post genome technologies such as DNA arrays and proteomics are currently undergoing rapid development in C. glutamicum. Such progress has already exposed new regulatory networks and functions that had so far been unidentified in this microbe. The next goal of these studies is to integrate the fruits of genomics into strain development technology. A novel methodology that merges genomics with classical strain improvement has been developed and applied for the reconstruction of classically derived production strains. How can traditional fermentation benefit from the C. glutamicum genomic data? The path from genomics to biotechnological processes is presented.     

Identification of an anion-specific channel in the cell wall of the Gram-positive bacterium Corynebacterium glutamicum

A cation-selective channel (porin), designated PorA, facilitates the passage of hydrophilic solutes across the cell wall of the mycolic acid-containing actinomycete Corynebacterium glutamicum. Biochemical and electrophysiological investigations of the cell wall of the mutant strain revealed the presence of an alternative channel-forming protein. This porin was purified to homogeneity and studied in lipid bilayer membranes. It forms small anion-selective channels with a diameter of about 1.4 nm and an average single-channel conductance of about 700 pS in 1 M KCl. The PorBCglut channel could be blocked by citrate in a dose-dependent manner. This result was in agreement with growth experiments in citrate as sole carbon source where growth in citrate was impaired as compared with growth in other carbon sources. The PorBCglut protein was partially sequenced and based on the resulting amino acid sequence of the corresponding gene, which was designated as porB, was identified as an unannotated 381 bp long open reading frame (ORF) in the published genome sequence of C. glutamicum ATCC13032. PorBCglut contains 126 amino acids with an N-terminal extension of 27 amino acids. One hundred and thirty-eight base pairs downstream of porB, we found an ORF that codes for a protein with about 30% identity to PorBCglut, which was named PorCCglut. The arrangement of porB and porC on the chromosome suggested that both genes belong to the same cluster. RT-PCR from overlapping regions between genes from wild-type C. glutamicum ATCC 13032 and its ATCC 13032DeltaporA mutant demonstrated that this is the case and that porB and porC are cotranscribed. The gene products PorBCglut and PorCCglut represent obviously other permeability pathways for the transport of hydrophilic compounds through the cell wall of C. glutamicum.     

Lysine excretion by Corynebacterium glutamicum. 1. Identification of a specific secretion carrier system

Corynebacterium glutamicum effectively excretes lysine when the internal lysine concentration is elevated. Lysine efflux was investigated using selected mutants which are not able to regulate lysine biosynthesis by feedback inhibition. Secretion of lysine is not the consequence of unspecific permeability of the plasma membrane but is mediated by a secretion carrier which is specific for lysine. Lysine export is characterized by high activation energy and follows Michaelis-Menten type kinetics with an internal Km of 20 mM and a Vmax of 12 nmol.min-1.mg dry cells-1. Excretion can proceed against a preexisting chemical gradient and against the electrical potential, which rules out a previously suggested pore model. Lysine excretion can also be observed in the wild-type strain especially under conditions of peptide uptake. Its possible physiological function may be related to regulation of internal amino acid concentrations under special growth conditions.     

Phenotypic characterization of <Emphasis Type="Italic">Corynebacterium glutamicum</Emphasis> using elementary modes towards synthesis of amino acids

Elementary flux mode (EFM) analysis is a powerful tool to represent the metabolic network structure and can be further utilized for flux analysis. The method enables characterization and quantification of feasible phenotypes in microbes. EFM analysis was employed to characterize the phenotype of Corynebacterium glutamicum to yield various amino acids. The metabolic network of C. glutamicum yielded 62 elementary modes by incorporating the accumulation of amino acids namely, lysine, alanine, valine, glutamine and glutamate. The analysis also allowed us to compute the maximum theoretical yield for the synthesis of various amino acids. These 62 elementary modes were further used to obtain optimal phenotypic space towards accumulation of biomass and lysine. The study indicated that the optimal solution space from 62 elementary modes forms a super space which incorporates various mutants including lysine producing strain of C. glutamicum. The analysis was also extended to obtain sensitivity of the network to variation in the stoichiometry of NADP in the definition of biomass.     

Corynebacterium glutamicum contains 3-deoxy-D-arabino-heptulosonate 7-phosphate synthases that display novel biochemical features

3-Deoxy-D-arabino-heptulosonate 7-phosphate (DAHP) synthase (EC 2.5.1.54) catalyzes the first step of the shikimate pathway that finally leads to the biosynthesis of aromatic amino acids phenylalanine (Phe), tryptophan (Trp), and tyrosine (Tyr). In Corynebacterium glutamicum ATCC 13032, two chromosomal genes, NCgl0950 (aroF) and NCgl2098 (aroG), were located that encode two putative DAHP synthases. The deletion of NCgl2098 resulted in the loss of the ability of C. glutamicum RES167 (a restriction-deficient strain derived from C. glutamicum ATCC 13032) to grow in mineral medium; however, the deletion of NCgl0950 did not result in any observable phenotypic alteration. Analysis of DAHP synthase activities in the wild type and mutants of C. glutamicum RES167 indicated that NCgl2098, rather than NCgl0950, was involved in the biosynthesis of aromatic amino acids. Cloning and expression in Escherichia coli showed that both NCgl0950 and NCgl2098 encoded active DAHP synthases. Both the NCgl0950 and NCgl2098 DAHP synthases were purified from recombinant E. coli cells and characterized. The NCgl0950 DAHP synthase was sensitive to feedback inhibition by Tyr and, to a much lesser extent, by Phe and Trp. The NCgl2098 DAHP synthase was slightly sensitive to feedback inhibition by Trp, but not sensitive to Tyr and Phe, findings that were in contrast to the properties of previously known DAHP synthases from C. glutamicum subsp. flavum. Both Co2+ and Mn2+ significantly stimulated the NCgl0950 DAHP synthase's activity, whereas Mn2+ was much more stimulatory than Co2+ to the NCgl2098 DAHP synthase's activity.