Continuous production of thienamycin in immobilized cell systems

A novel 2-L bubble column was used to study the continuous, immobilized cell production of thienamycin. Cells of Streptomyces cattleya were immobilized by culturing them in an appropriate growth medium containing 60/80 mesh celite particles. The dilution rate used during the continuous growth phase was 0.2 h(-1). This growth phase was terminated upon the development of heavy cell films (100-500 mum thickness), and the medium was replaced with an appropriate thienamycin production medium. The system was then operated in a batch mode until thienamycin production began. At that time, continuous feeding of the production medium was initiated and the influence of medium composition and dilution rate on CO(2), NH(4), biomass, and thienamycin production investigated. With synthetic production medium, a doubling of the dilution rate from 0.05 to 0.10 h(-1) resulted in a doubling of the thienamycin volumetric productivity. Rates of CO(2) and NH(4) production increased by ca. factors of three and two, respectively. The rate of PO(4) utilization also doubled. When the dilution rate was decreased to 0.05 h(-1), the rates of CO(2) production and PO(4) utilization quickly decreased (i.e., within 3 h). The rates of NH(4) and thienamycin production also decreased but more slowly (i.e., ca. 100 h after the decrease in dilution rate). With complex production medium, the rates of CO(2) production and PO(4) utilization appeared to be a direct function of dilution rate at the dilution rates tested. Thienamycin production in this case was not a function of dilution rate. Comparing the synthetic medium with the complex medium at either dilution rate, the volumetric rate of thienamycin production was higher in the system being fed complex medium. However, the specific activity (units thienamycin/g cell/h) observed with complex medium was lower than that observed with synthetic medium. The higher volumetric productivity observed with complex medium was the result of a high cell loading. The above observations will be discussed in terms of control of thienamycin synthesis and film thickness effects.     

Biosynthesis of the beta-lactam antibiotic, thienamycin, by Streptomyces cattleya

Radioactive- and stable isotope-containing substrates were used to identify the biosynthetic precursors of the beta-lactam antibiotic, thienamycin, in Streptomyces cattleya. Acetate is utilized by the organism to form C(6) and C(7) of the beta-lactam ring. The two carbons of the hydroxyethyl group attached to C(6) are both derived from the methyl of methionine. The cysteaminyl side chain attached to C(2) is derived from cysteine. Selective inhibition of thienamycin and cephamycin C biosynthesis has been achieved either through the addition of metabolic inhibitors or through manipulation of the growth medium. These results suggest that the two beta-lactam antibiotics, thienamycin and cephamycin C, are formed by different biosynthetic pathways.     

硫霉素环化酶基因在变铅青链霉菌TK24中的表达及基因定位

将含有硫霉素环化酶基因的重组质粒p6BCl2转化变铅青链霉菌(Streptomyceslividans)TK24,含有p6BCl2的转化子细胞抽提液分别与琉霉素生物合成阻断变株Y,发酵液以及纯化的Y。中间产物经过体外共培养可产生活性物质．化学分析表明与Y,发酵液混合后产生的是硫霉素,与纯化的Y。中间产物混合产生的是一种不稳定的活性物质。说明硫霉素环化酶基因在S.lividans TK24中得到了表达,其产物以Y。中间产物为底物并弥补了Y,中的缺陷。对p6Bcl2中4．5kb外源片段进行了限制酶酶切分析,建立了酶切图谱．利用含硫霉素环化酶基因的S．Lividans TK24转化子体外转化Y,的应用体系,将硫霉素环化酶基因定位在0．9kb Hinc I—Pst I片段上,并证明了硫霉紊环化酶的活性与IPNS同源片段无关。以上实验为进一步研究琉霉素环化酶基因的结构打下了基础。     

Thienamycin production by immobilized cells of Streptomyces cattleya in a bubble column

A novel 2.0-L columnar reactor has been developed for the production of thienamycin by cells of Streptomyces cattleya attached to celite particles. Successful immobilization of cells was achieved by operating the column continuously at a high dilution rate during the growth phase. Scanning electron micrographs of the celite particles indicate the involvement of subcellular fibrils in the attachment of cells to the solid surfaces. Reactor operation was divided into two distinct phases-a growth phase and a production phase. The kinetics of attached growth and thienamycin production were found to be strongly influenced by nutrient concentrations. The influences of nutrient concentration on CO(2) production and thienamycin production during both the growth phase and the production phase are discussed.     

On principles of organization of polyreplicon systems

Summary Principles for the acceptability of replicons and polyreplicon systems are formulated, based on the postulated single reproduction of all the components of these systems in each reduplication cycle. On this basis the diverse variants of properties inherent to these systems and their punctuation marks (replicators and terminators) are discussed. The problem of the existence of terminators of reduplication is also considered.Variants of linear polyreplicon systems with identical punctuation are examined. Rules determining the acceptability of different aberrations are put forward. The following variants are unacceptable: inversions the ends of which lie in replicons with the same orientation; non-reciprocal translocations where the ends lie in replicons with opposite orientation; reciprocal translocations of two fragments differing in the orientation of the end replicons; all deletions. It is shown that polyreplicon systems in which all the replicons have the same orientation are subject to maximal losses due to aberrations, whereas systems consisting of two replicon groups equal in total length and having opposite orientation bear minimal losses.The following conclusions are drawn from the comparison of these rules and the analysis of the experimental data: 1)-If terminators exist, replicons of eukaryote chromosomes, in which acceptable aberrations are found, do not overlap and have the same punctuation. 2)- In this case, the alternating orientation of replicons in mammalian chromosomes corresponds to minimal aberrational losses. A hypothesis is proposed for the evolutionary pathway along which linear polyreplicon systems of eukaryotes may have appeared. According to this hypothesis, circular replicons of prokaryotes have united by means of recombination into systems with subsequent selection of variants based on minimal aberrational losses.     

Inhibition of beta-lactam antibiotics at two different times in the cell cycle of Streptococcus faecium ATCC 9790.

Treatment of Streptococcus faecium ATCC 9790 with sublytic concentrations of beta-lactam antibiotics revealed two different division blocks in the cell division cycle. One block, induced by N-formimidoyl thienamycin and methicillin, occurred before the completion of chromosome replication, whereas the other, induced by cefoxitin and cephalothin, took place later in the cycle. In addition, these antibiotics gave rise to distinct morphological forms; the antibiotics acting at the earlier block point produced mainly "dumbbells," whereas those affecting the later time formed "lemons." When used in combination N-formimidoyl thienamycin and cefoxitin exerted synergistic killing on this strain. These data suggest that beta-lactam antibiotics have at least two sites of action in S. faecium.     

Comparative characterization of repABC-type replicons of Paracoccus pantotrophus composite plasmids

The repABC replicons have an unusual structure, since they carry genes coding for partitioning (repA, repB) and replication (repC) proteins, which are organized in an operon. So far, the presence of these compact bi-functional modules has been reported only in the megaplasmids of the Rhizobiaceae and within the plasmid pTAV1 (107kb) of Paracoccus versutus. We studied the distribution of repABC-type replicons within bacteria belonging to the genus Paracoccus. We found that repABC replicons occur only in the group of pTAV1-like plasmids: pKLW1, pHG16-a, pWKS2, and pPAN1, harbored by different strains of Paracoccus pantotrophus. A partial sequencing approach followed by phylogenetic analysis revealed that these replicons constitute a distinct evolutionary branch of repABC replicons. Incompatibility studies showed that they represent two incompatibility groups designated IncABC1 (pTAV1, pKLW1, and pHG16-a) and IncABC2 (pPAN1). Sequence comparison using available databases allowed the identification, within plasmid pRS241d of Rhodobacter sphaeroides 2.4.1, of an additional sequence highly homologous to the paracoccal repABC replicons, which has been included in comparative analyses.     

Hairpin telomeres and genome plasticity in Borrelia: all mixed up in the end

Spirochetes of the genus Borrelia have a highly unusual genome structure composed of over 20 replicons. Most of these replicons are linear and terminated by covalently closed hairpin ends or telomeres. Moreover, the linear replicons are affected by extensive DNA rearrangements, including telomere exchanges, DNA duplications, and harbour a large number of pseudogenes. The mechanism for the unusual genome plasticity in the linear replicons has remained elusive. The enzymatic machinery (the telomere resolvase ResT) responsible for generating the hairpin ends from replicative intermediates has recently been shown to also perform a reverse reaction that fuses telomeres on unrelated replicons. Infrequent stabilization of such fusion events over evolutionary time provides the first proposed biochemical mechanism for the DNA rearrangements that are so prominent in the linear replicons of B. burgdorferi.     

Application of affinity adsorption in thienamycin fermentation

Summary Many antibiotic fermentations are sensitive to high concentrations of their own product possibly due to product regulation and toxicity mechanisms. In this paper we discuss the feasibility of using affinity adsorption with biospecific ligands for in situ product removal to alleviate this problem. The concept of using whole cells containing the biospecific ligands is demonstrated in the case of thienamycin fermentation using whole cells of Bacillus stearothermophilus and immobilized -lactamase. It is observed that thienamycin production continues for an extended period of time.     

Multiple replicons constituting the genome of Pseudomonas cepacia 17616.

Macrorestriction fragment analysis of DNA from Pseudomonas cepacia 17616, in conjunction with Southern hybridization experiments using junction fragments containing rare restriction enzyme sites as probes, indicated that this bacterium contains three large circular replicons of 3.4, 2.5, and 0.9 megabases (Mb). Inclusion of the 170-kb cryptic plasmid present in this strain gave an overall estimate of genome size of 7 Mb. Other Southern hybridization experiments indicated that the three large replicons contained rRNA genes as well as insertion sequence elements identified previously in this strain. The distribution of SwaI, PacI, and PmeI sites on the three replicons was determined. A derivative of Tn5-751 carrying a SwaI site was used to inactivate and map genes on the 2.5- and 3.4-Mb replicons. Mutants were isolated in which the 2.5- and 0.9-Mb replicons had been reduced in size to 1.8 and 0.65 Mb, respectively. The loss of DNA from the 2.5-Mb replicon was associated with lysine auxotrophy, beta-lactamase deficiency, and failure to utilize ribitol and trehalose as carbon and energy sources. DNA fragments corresponding in size to randomly linearized forms of the different replicons were detected in unrestricted DNA by pulsed-field gel electrophoresis. The results provide a framework for further genetic analysis of strain 17616 and for evaluation of the genomic complexities of other P. cepacia isolates.     

The nucleoprotein is required for efficient coronavirus genome replication

The construction of a set of transmissible gastroenteritis coronavirus (TGEV)-derived replicons as bacterial artificial chromosomes is reported. These replicons were generated by sequential deletion of nonessential genes for virus replication, using a modified TGEV full-length cDNA clone containing unique restriction sites between each pair of consecutive genes. Efficient activity of TGEV replicons was associated with the presence of the nucleoprotein provided either in cis or in trans. TGEV replicons were functional in several cell lines, including the human cell line 293T, in which no or very low cytopathic effect was observed, and expressed high amounts of heterologous protein.     

Methionine inhibition of thienamycin formation

Summary Methionine interference in the formation of thienamycin byStreptomyces cattleya is due, to a major extent, to inhibition of enzyme activity.     

Alphavirus vectors for gene expression and vaccines.

Alphavirus expression vectors are finding novel uses in research. They are showing increasing promise as vaccines and are being developed for diagnostic assays of other viruses. Some highlights over the past couple of years include improvements in packaging of replicons, targeting of Sindbis virus replicons, stable cell lines that can be induced to produce replicons, and the isolation of noncytopathic variants of Sindbis virus replicons. Reports that alphavirus vectors can efficiently infect neurons in rat hippocampal slices should increase their use in neurobiological studies.     

Distribution of Bacillus megaterium QM B1551 plasmids among other B. megaterium strains and Bacillus species

Bacillus megaterium QM B1551 contains seven plasmids. Two are small rolling circle plasmids and five are theta-replicating plasmids with cross-hybridizing replicons that define a new family of very homologous yet compatible theta replicons. Previous sequencing of several of the plasmids has shown genes with high similarity to those on the genomes and plasmids of other Gram-positive bacteria. To test the possible distribution of these plasmids, nine other B. megaterium strains and 20 other Bacillus or related species were tested for the presence of similar replicons, and specific flanking DNA by both hybridization and PCR. The theta replicons were widespread among the B. megaterium strains, and two had one or more of the rolling circle plasmids, but none of the plasmid replicon regions were observed in the other Bacillus or related species. It appears from the data that even though some plasmids carry genes suggesting horizontal transfer, their replicons seem to be unique to B. megaterium, or rarely present in related species.     

Heterogeneity of eukaryotic replicons, replicon clusters, and replication foci

According to the current paradigm, replication foci are discrete sites in the interphase nucleus where assemblies of DNA replication enzymes simultaneously elongate the replication forks of 10–100 adjacent replicons (each ∼100 kbp). Here we review new results and provide alternative interpretations for old results to show that the current paradigm is in need of further development. In particular, many replicons are larger than previously thought – so large that their complete replication takes much longer (several hours) than the measured average time to complete replication at individual foci (45–60 min). In addition to this large heterogeneity in replicon size, it is now apparent that there is also a corresponding heterogeneity in the size and intensity of individual replication foci. An important property of all replication foci is that they are stable structures that persist, with constant dimensions, during all cell cycle stages including mitosis, and therefore likely represent a fundamental unit of chromatin organization. With this in mind, we present a modified model of replication foci in which many of the foci are composed of clusters of small replicons as previously proposed, but the size and number of replicons per focus is extremely heterogeneous, and a significant proportion of foci are composed of single large replicons. We further speculate that very large replicons may extend over two or more individual foci and that this organization may be important in regulating the replication of such large replicons as the cell proceeds through S-phase. Received: 16 August 1999 / Accepted: 17 August 1999     

Stochastic association of neighboring replicons creates replication factories in budding yeast

Inside the nucleus, DNA replication is organized at discrete sites called replication factories, consisting of DNA polymerases and other replication proteins. Replication factories play important roles in coordinating replication and in responding to replication stress. However, it remains unknown how replicons are organized for processing at each replication factory. Here we address this question using budding yeast. We analyze how individual replicons dynamically organized a replication factory using live-cell imaging and investigate how replication factories were structured using super-resolution microscopy. Surprisingly, we show that the grouping of replicons within factories is highly variable from cell to cell. Once associated, however, replicons stay together relatively stably to maintain replication factories. We derive a coherent genome-wide mathematical model showing how neighboring replicons became associated stochastically to form replication factories, which was validated by independent microscopy-based analyses. This study not only reveals the fundamental principles promoting replication factory organization in budding yeast, but also provides insight into general mechanisms by which chromosomes organize sub-nuclear structures.     

Characterization of a cryptic plasmid from Lactobacillus fermentum KC5b and its use for constructing a stable Lactobacillus cloning vector

Lactobacillus fermentum KC5b, a strain originally isolated from the human vagina, contains a cryptic plasmid pKC5b. The sequence and genetic organization of the 4392-bp plasmid were determined. It contains two convergently oriented replicons, which are homologous to each other and to the stable replicon of the Enterococcus faecium plasmid pMBB1. The two replicons of pKC5b were used either individually or together to construct Lactobacillus-Escherichia coli shuttle plasmids. Only the plasmid pSP1 that carried both replicons transformed lactobacilli, suggesting a complementary function between the two replicons. Since the replicons had a high homology to those of other plasmids that replicate via a theta-like mechanism and no detectable single-stranded intermediates were found for the plasmid, it is possible that pKC5b may replicate via a theta-like mechanism. The new shuttle plasmid pSP1 has been transformed and stably maintained in several Lactobacillus strains. As an initial application, pSP1 was used to clone the S-layer protein gene (slpA) of Lactobacillus acidophilus ATCC 4356 into a heterologous vaginal Lactobacillus strain and achieved surface-bound expression of the protein.     

The genome organization of Ralstonia eutropha strain H16 and related species of the Burkholderiaceae

Ralstonia eutropha strain H16 is a facultatively chemolithoautotrophic, hydrogen-oxidizing bacterium belonging to the family Burkholderiaceae of the Betaproteobacteria. The genome of R. eutropha H16 consists of two chromosomes (Chr1, Chr2) and one megaplasmid (pHG1), and thus shows a multi-replicon architecture, which is characteristic for all members of the Burkholderiaceae sequenced so far. The genes for housekeeping cell functions are located on Chr1. In contrast, many characteristic traits of R. eutropha H16 such as the ability to switch between alternative lifestyles and to utilize a broad variety of growth substrates are primarily encoded on the smaller replicons Chr2 and pHG1. The latter replicons also differ from Chr1 by carrying a repA-associated origin of replication typically found on plasmids. Relationships between the individual replicons from various Burkholderiaceae genomes were studied by multiple sequence alignments and whole-replicon protein comparisons. While strong conservation of gene content and order among the largest replicons indicate a common ancestor, the resemblance between the smaller replicons is considerably lower, suggesting a species-specific origin of Chr2. The megaplasmids, however, in most cases do not show any taxonomically related similarities. Based on the results of the comparative studies, a hypothesis for the evolution of the multi-replicon genomes of the Burkholderiaceae is proposed.     

Comparative analysis of a cryptic thienamycin-like gene cluster identified in Streptomyces flavogriseus by genome mining

In silico database searches allowed the identification in the S. flavogriseus ATCC 33331 genome of a carbapenem gene cluster highly related to the S. cattleya thienamycin one. This is the second cluster found for a complex highly substituted carbapenem. Comparative analysis revealed that both gene clusters display a high degree of synteny in gene organization and in protein conservation. Although the cluster appears to be silent under our laboratory conditions, the putative metabolic product was predicted from bioinformatics analyses using sequence comparison tools. These data, together with previous reports concerning epithienamycins production by S. flavogriseus strains, suggest that the cluster metabolic product might be a thienamycin-like carbapenem, possibly the epimeric epithienamycin. This finding might help in understanding the biosynthetic pathway to thienamycin and other highly substituted carbapenems. It also provides another example of genome mining in Streptomyces sequenced genomes as a powerful approach for novel antibiotic discovery.     

Comparative genome architecture and dynamics in bacteria

This article reviews current knowledge about the organization of bacterial genomes, of which a number of components (replicons), namely chromosomes, plasmids and prophages, have been well characterized. The historical position of the acceptance of the idea of circularity and unit copy number of replicons in bacterial cells has been readdressed by new methods of genome analysis, particularly pulsed-field gcl electrophoresis, which have facilitated identification of variation in replicon number and distinction whether the replicons are circular or linear DNA structures. Much has also been learnt about the origins of DNA replication in replicons and how they function via the controlling role of specific proteins or RNA. A related aspect is thc problem of how the replication products are stabilized, segregated and partitioned into daughter cells at cell division. Our understanding of replicons has also been improved by application of state-of-the-art computer software methods of comparative DNA and protein sequence analysis. This knowledge has provided insights into the fundamental nature of these processes and their origin and evolution in single-cell and multicellular organisms.