甲醇毕赤酵母表达木质素过氧化物酶的研究

将含有黄孢原毛平革菌(Phanerochaetechrysosprium)木质素过氧化物酶基因的甲醇毕赤酵母工程菌进行了鉴定和筛选,筛选得到木质素过氧化物酶活力高的菌株PMLIP08。确定了一步法发酵的最优葡萄糖浓度,优化其发酵培养条件,结果表明葡萄糖的添加量为10g/L时,发酵条件为pH3.0,诱导温度24℃,培养时间12h,甲醇添加量1.1%,诱导时间72h后发酵液中酶活可达4888U/L。     

木质素过氧化物酶基因（LipH8）的克隆及在甲醇毕赤酵母中的表达

以黄孢原毛平革菌 (Phanerochaetechrysosporium)RNA为模板 ,克隆LipH8基因片段 ,研究LipH8基因在甲醇毕赤酵母中的表达。构建了甲醇酵母表达质粒pMETA_LipH8载体 ,并将其线性化后用电穿孔法导入PichiamethabolicaPMAD16 ,部分阳性克隆的PCR结果表明LipH8基因已经整合到甲醇毕赤酵母染色体上 ,经摇瓶培养筛选出表达水平较高的酵母工程菌株。胞外木质素过氧化物酶活力达 932U L。     

黄孢原毛平革菌降解土霉素的影响因素及酶活分析

目的:黄孢原毛平革菌降解土霉素的影响因素及酶活分析。方法:文章使用的方法有制备实验菌种和孢子悬浮液、测定校准曲线及样品与测定酶活性等。结果:培养基中的营养物质真菌降解抗生素和吸附重金属特性减少然后,产生了酶的次生阶段,不利于营养的获得,分泌了锰过氧化物酶,酶活不断增加,达到了最大值。活跃期过后,酶活逐渐降低,在培养后期,产生的代谢物越来越多,堆集了大量的有毒代谢物,降低了锰过氧化物酶活性。讨论:当土壤浓度维持在200mg/L时,采用固化或者是非固化的方式后,黄孢原毛平革菌对土壤的降解度分别为92.44%与67.63%。在实验过程中,使用了两种方式处理,但菌产锰过氧化物酶酶培养96h之后,土霉素达到了最大浓度,为70 mg/L,相应为527.40 U/L与73.90 U/L;使用两种处理方式,菌产木质素过氧化物酶都要先培养96h之后,土霉素浓度变成了70 mg/L,这个时候是最大值,相应为0.384 U/L与O.204 U/L,因此,黄孢原毛平革菌降解土霉素时,起到关键作用的是锰过氧化物酶。文章可行性研究了黄孢原毛平革菌降解土霉素。实验相应地考察了p H值、土霉素初始浓度是如何影响影响黄孢原毛平革菌降解土霉素。实验结果显示,相应地增加土霉素的浓度,能提升酶活,当超过一定限度时,酶的活性会随着增加而降低。     

三种白腐菌及其组合菌种木质素降解酶比较研究

朱红栓菌Trametes cinnabarina、糙皮侧耳Pleurotus ostreatus、黄孢原毛平革菌Phanerochaete chrysosporium是产生木质素降解酶能力强的菌株。对三种白腐菌及其组合菌种产生木质素降解酶能力和行为进行了比较分析和研究。结果表明,最佳培养方式为液体振荡培养;最佳培养基为酵母膏液体培养基。在产漆酶(laccases,lacs)方面,Pleurotus ostreatus和Phanerochaete chrysosporium的组合菌种的酶活最强,在第6天出现峰值,酶活达到450U/L;在产锰过氧化物酶(manganese peroxidases,mnps)方面,Trametes cinnabarina和Pleurotus ostreatus的组合菌种的酶活最强,在第10天出现峰值,酶活达到1050U/L;在产木质素过氧化物酶(lignin peroxidases,lips)方面,Trametes cinnabarina和Phanerochaete chrysosporium的组合菌种的酶活最强,在第8天出现产酶峰值,酶活达到2990U/L。筛选结果表明,组合菌种比单菌种产生的三种主要木质素降解酶的活性强,这为白腐菌高效产酶提供了一条新的途径,并为白腐菌研究领域的后续工作奠定基础。     

白腐菌产锰过氧化物酶培养基的优化

黄孢原毛平革菌(Phanerochaete Chrysosporium)5．776在初始发酵培养基中产胞外锰过氧化物酶活力极低。为了显著提高锰过氧化物酶活力,对初始发酵培养基进行优化。通过调整培养基中碳源、氮源种类和含量,吐温80添加量,Mn^2 终浓度,静置培养温度、时间,采用分光光度计法测定酶活力,发现黄孢原毛平革菌在限氮高锰培养基中产生较高的锰过氧化物酶。静置液体培养的优化条件是：葡萄糖10g／L;酒石酸铵2mmol／L;吐温80 lg／L;Mn^2 9．9μg／L;于34℃静置培养5d;产MnP活力达1200U／L,比优化前提高了近17倍。     

培养于天然冷杉木片的黄孢原毛平革菌木质素过氧化物酶基因表达的RTPCR分析

利用RTPCR方法分析了生长于冷杉木片上的黄孢原毛平革菌木质素过氧化物酶基因lipＡ２（GLG3）、lipＣ1(GLG2)、lipＣ2(GLG5)、lipＤ２(GLG1)、lipE（LP0811）的表达。结果发现在不同的培养时间里仅有特定的基因表达,在第２周时仅有lipＡ2(GLG3)基因表达,在第４周时未检测到任何基因的表达,在第６周时lipＤ2(GLG1)和lipＣ1(GLG2)基因表达,在第８周时仅有lipＡ2(GLG3)基因表达。这些结果说明,在冷杉木片上培养的黄孢原毛平革菌的lip基因表达具有明显的时间特异性,并且与限定培养基中得到的结果明显不同。     

黄孢原毛平革菌抗营养阻遏产漆酶诱变育种及其产酶特性

【目的】筛选能抗营养阻遏产漆酶的黄孢原毛平革菌,论证其产漆酶的确定性及抗营养阻遏产木质素酶的可行性,为白腐菌产酶代谢调控、木质素降解机理的研究奠定基础。【方法】利用重复紫外诱变法,以愈创木酚富氮鉴别培养基筛选目标菌株;比较不同营养条件下菌体生长与产酶动力学差异研究产酶营养调控机理;通过热处理、排除锰离子和加入过氧化氢酶等不同措施论证黄孢原平毛平革菌能否产生漆酶。【结果】3种不同方法均证实选育到的pcR5305和pcR5324菌株在限氮与富氮条件下均能产生漆酶,pcR5305和pcR5324在限氮条件下产漆酶分别达到203.5、187.6 U/L;在富氮条件下为220.6、183.9 U/L,而原菌株pc530在两种条件下都基本不产生漆酶。二菌株产漆酶调控方式不同,pcR5305漆酶产生与菌体生长同步,而pcR5324漆酶产生却受营养氮阻遏。二菌株同时具有抗营养阻遏高产木质素过氧化物酶(LiP)和锰过氧化物酶(MnP)(分别为LiP 1343.2、MnP 252.2 U/L;LiP 1169.5、MnP 172.4 U/L)的能力。【结论】筛选到的黄孢原毛平革菌变异菌株能产漆酶,同时表现了抗营养阻遏产漆酶、木质素过氧化物酶和锰过氧化物酶的能力,具有重要的生产应用与理论研究价值,为白腐菌产酶代谢调控机理研究提供了原始菌株并奠定了良好的基础。     

高效木质素降解菌的筛选及其对玉米秸秆的降解效果

本研究利用愈创木酚和苯胺蓝固体培养基对菌株进行初筛,利用形态学和分子生物学对筛选出的菌株进行鉴定,以黄孢原毛平革菌Phanerochaete chrysosporium CGMCC 5.0776为对照,利用其对玉米秸秆进行预处理并测定木质素和纤维素的降解率,测定筛选菌株在预处理玉米秸秆过程中漆酶、锰过氧化物酶(mang...     

黄孢原毛平革菌基因启动子的分离与鉴定

利用启动子探针型载体pSUPV8直接在大肠杆菌(Escherichia coli)中分离黄孢原毛平革菌(Phanerochaete chrysosporium)基因启动子片段,获得6个潮霉素抗性(Hyg-r)重组子。对重组子CH2、CH6进行序列分析,结果发现它们都存在真核生物基因启动子的保守序列;用原生质体转化法将其转化黄孢原毛平革菌,仅pCH6获得了潮霉素抗性转化子;PCR和斑点杂交分析表明,pCH6已成功导入黄孢原毛平革菌,并启动潮霉素抗性基因的表达。     

培养于天然冷杉木片的黄孢原毛平革菌木质素过氧化物酶基因表达的RT-PCR分析

利用RT-PCR方法分析了生长于冷杉木片上的黄孢原毛平革菌木质素过氧化物酶基因lipA2(GLG3)、lipC1(GLG2)、lipC2(GLG5)、lipD2(GLG1)、lipE(LPO811)的表达。结果发现在不同的培养时间里仅有特定的基因表达,在第2周时仅有lipA2(GLG3)基因表达,在第4周时未检测到任何基因的表达,在第6周时lipD2(GLG1)和lipC1(GLG2)基因表达,在第8周时仅有lipA2(GLG3)基因表达。这些结果说明,在冷杉木片上培养的黄孢原毛平革菌的lip基因表达具有明显的时间特异性,并且与限定培养基中得到的结果明显不同。     

Heterologous expression of lignin peroxidase of Phanerochaete chrysosporium in Pichia methanolica

The cDNA encoding for lignin peroxidase of Phanerochaete chrysosporium was expressed in the Pichia methanolica under the control of the alcohol oxidase (AUG1) promoter which was followed by either the lignin peroxidase leader peptide of Phanerochaete chrysosporium or the Saccharomyces cerevisiae alpha-factor signal peptide. Both peptides efficiently directed the secretion of lignin peroxidase from the recombinant yeast cell. The extracellular lignin peroxidase activity in two recombinants was 932 U l(-1) and 1933 U l(-1). The purity of the recombinant product was confirmed by SDS-PAGE.     

Lignin peroxidase-negative mutant of the white-rot basidiomycete Phanerochaete chrysosporium

Phanerochaete chrysosporium produces two classes of extracellular heme proteins, designated lignin peroxidases and manganese peroxidases, that play a key role in lignin degradation. In this study we isolated and characterized a lignin peroxidase-negative mutant (lip mutant) that showed 16% of the ligninolytic activity (14C-labeled synthetic lignin----14CO2) exhibited by the wild type. The lip mutant did not produce detectable levels of lignin peroxidase, whereas the wild type, under identical conditions, produced 96 U of lignin peroxidase per liter. Both the wild type and the mutant produced comparable levels of manganese peroxidase and glucose oxidase, a key H2O2-generating secondary metabolic enzyme in P. chrysosporium. Fast protein liquid chromatographic analysis of the concentrated extracellular fluid of the lip mutant confirmed that it produced only heme proteins with manganese peroxidase activity but no detectable lignin peroxidase activity, whereas both lignin peroxidase and manganese peroxidase activities were produced by the wild type. The lip mutant appears to be a regulatory mutant that is defective in the production of all the lignin peroxidases.     

Homologous expression of recombinant lignin peroxidase in Phanerochaete chrysosporium

The glyceraldehyde-3-phosphate dehydrogenase (gpd) promoter was used to drive expression of lip2, the gene encoding lignin peroxidase (LiP) isozyme H8, in primary metabolic cultures of Phanerochaete chrysosporium. The expression vector, pUGL, also contained the Schizophyllum commune ura1 gene as a selectable marker. pUGL was used to transform a P. chrysosporium Ura11 auxotroph to prototrophy. Ura+ transformants were screened for peroxidase activity in liquid cultures containing high-carbon and high-nitrogen medium. Recombinant LiP (rLiP) was secreted in active form by the transformants after 4 days of growth, whereas endogenous lip genes were not expressed under these conditions. Approximately 2 mg of homogeneous rLiP/liter was obtained after purification. The molecular mass, pI, and optical absorption spectrum of rLiPH8 were essentially identical to those of the wild-type LiPh8 (wt LiPH8), indicating that heme insertion, folding, and secretion functioned normally in the transformant. Steady-state and transient-state kinetic properties for the oxidation of veratryl alcohol between wtLiPH8 and rLiPH8 were also identical.     

Enhanced lignin peroxidase synthesis by Phanerochaete Chrysosporium in solid state bioprocessing of a lignocellulosic substrate

Summary A solid state fermentation (SSF) process for the production of lignin peroxidase was optimized to enhance enzyme production by Phanerochaete chrysosporium. Optimization of the corncob SSF medium caused a significant reduction in fermentation time to give maximum lignin peroxidase yield. Supplementation of the SSF medium by low concentrations of peptone, yeast extract and Tween-80 enhanced lignin peroxidase production. Maximum yield of lignin peroxidase was 13.7 U/gds (units per gram dry substrate) noted after 5 days of SSF with 70% moisture and 20% (v/w) inoculum.     

杂色云芝漆酶基因(Lcc1)的克隆及在甲醇毕赤酵母中的表达

以白腐菌杂色云芝Coriolus versicolor RNA为模板,通过RT-PCR获得漆酶Leel基因的cDNA片段。构建了甲醇酵母表达质粒pMETA-Lccl载体,并将其线性化后用电穿孔法导入Pichia methabolica PMAD16,部分阳性克隆的PCR结果表明Lccl基因已经整合到甲醇毕赤酵母染色体上,经摇瓶培养筛选出表达水平较高的酵母工程菌株。漆酶酶活力达53U/L     

Production and separation of manganese peroxidase from heme amended yeast cultures

A method for the production and concentration of the lignin-degrading enzyme, manganese peroxidase (rMnP), was developed using the yeast Pichia pastoris in high cell density, fed-batch cultivations. A gene encoding manganese peroxidase (mnp1) from the white-rot fungus Phanerochaete chrysosporium was cloned into a protease deficient (pep4-) strain of the methylotrophic yeast P. pastoris. Heme is an important cofactor for active rMnP production, and amendment of yeast cultures with heme increased active rMnP concentrations. In both shake-flasks and fed-batch bioreactors, the relationship between heme concentration and rMnP activity was logarithmic, with increasing heme concentrations resulting in progressively lesser increases in enzyme activity. Scale-up from shake-flasks to 2 L fed-batch cultivations increased rMnP activities from 200 U/L to 2,500 U/L, with addition of 0.1 g/L heme (added heme per liquid volume) at the beginning of the fed-batch phase resulting in higher enzyme activities than addition at the beginning of the batch phase. A combination of centrifugation, acetone precipitation, dialysis, and freeze drying was found to be effective for concentrating the rMnP from 2,500 U/L in the P. pastoris bioreactor culture to 30,000 U/L in 0.1 M potassium phosphate buffer pH 6. The rMnP recovery yield was 60% and the purity was 1-4%. By using 0.1 g/L heme during the fed-batch cultivation, the heme content of the final enzyme preparation could be reduced by 97%, and had sufficiently high rMnP activity and low enough color to be suitable for pulp bleaching experiments.     

Solid state fermentation of Achras zapota lignocellulose by Phanerochaete chrysosporium

The biological transformation of lignocellulose of Achras zapota by white rot fungi, Phanerochaete chrysosporium, in solid state fermentation (SSF) was studied for 28 days. The kinetic transformation of lignocellulose was monitored through the determination of acid soluble and acid insoluble lignin content, total organic carbon (TOC) and chemical oxygen demand (COD). The lignolytic enzymes, lignin peroxidase (LiP) and manganese peroxidase (MnP) were quantified on weekly intervals. The degradation of lignin and other structural moieties of A. zapota lignocellulose were confirmed by high performance liquid chromatography (HPLC), Fourier transform infrared spectroscopy (FTIR) and scanning electron microscopy (SEM). The degradation of lignin was increased after 7 days of fermentation with the release of water soluble and fermentable products. The LiP and MnP activities were increased in the first week of SSF and lignin degradation was also set to increase. This was accompanied with increase in COD by 94.6% and TOC by 80% and lignin content was decreased by 76%. The maximum activities of the enzymes LiP and MnP in extracellular fluid of SSF under nitrogen limitation, at pH 5.0, at temperature 37 degrees C and at 60% humidity were 2100 U/L and 1200 U/L.     

Production of Phanerochaete chrysosporium lignin peroxidase

Liginin peroxidase (ligninase) of the white rot fungus Phanerochaete chrysosporium Burdsall was discovered in 1982 as a secondary metabolite. Today multiple isoenzymes are known, which are often collectively called as lignin peroxidase. Lignin peroxidase has been characterized as a veratryl alcohol oxidizing enzyme, but it is a relatively unspecific enzyme catalyzing a variety of reactions with hydrogen peroxide as the electron acceptor. P. chrysosporium ligninases are heme glycoproteins. At least a number of isoenzymes are also phosphorylated. Two of the major isoenzymes have been crystallized. Until recently lignin peroxidase could only be produced in low yields in very small scale stationary cultures owing to shear sensitivity. Most strains produce the enzyme only after grown under nitrogen or carbon limitation, although strains producing lignin peroxidase under nutrient sufficiency have also been isolated. Activities over 2000 U dm(-3) (as determined at 30 degrees to 37 degrees C) have been reported in small scale Erlenmeyer cultures with the strain INA-12 grown on glycerol in the presence of soybean phospholipids under nitrogen sufficiency. In about 8 dm(3) liquid volume pilot scale higher than 100 U dm(-3) (as determined at 23 degrees C) have been obtained under agitation with immobilized P. chrysosporium strains ATCC 24725 or TKK 20512. Good results have been obtained for example with nylon web, polyurethane foam, sintered glass or silicon tubing as the carrier. The immobilized biocatalyst systems have also made large scale repeated batch and semicontinuous production possible. With nylon web as the carrier, lignin peroxidase production has recently been scaled up to 800 dm(3) liquid volume semicontinuous industrial production process.