Ethanol fermentation in a yeast immobilized tubular fermentor

In this article, a mathematical model describing the kinetics of ethanol fermentation in a whole cell immobilized tubular fermentor is proposed. Experimental results show reasonable agreement with the proposed model. A procedure for treating the fermentation data for determining the ethanol inhibition constants k(1) and k(2) is described. The ethanol productivity of the immobilized cell fermentor is compared with those of traditional fermentors. Experimental studies indicate that with Saccharomyces cerevisiae (NRRL Y132) culture, ethanol productivity in the range 21.2-83.7 g ethanol L(-1) h(-1) at ethanol concentration of 76-60 g/L can be achieved. This is comparable to or higher than those reported in the literature for yeast. The product yield factor of 0.5 g ethanol/g glucose was obtained. The immobilized cell fermentor does not show washout at dilution rates of 7 h(-1) and shows good stability over a 650-h operating period.     

Continuous production of ethanol from a glucose,xylose and arabinose mixture by a flocculent strain ofPichia stipitis

Summary Enhanced rates of continuous ethanol production by a flocculent strain ofPichia stipitis from a sugar mixture (xylose 75%, glucose 20%, arabinose 5%) were attained using a single-stage gas lift tower fermentor. With a substrate feed of 50g/l, the biomass accumulated at a level near 50g/l, showed a maximum and stable ethanol productivity of 10.7 g/l.h, with a substrate conversion of 80%; the ethanol yield reached 0.41g/g. In these operating conditions, similar performances were obtained when D.xylose alone was supplied.     

Influence of linearly decreasing feeding rates on fed-batch ethanol fermentation of sugar-cane blackstrap molasses

Summary The ethanol yield was not affected and the ethanol productivity increased (10%) when linearly decreasing feeding rates were used instead of constant feeding rates in fed-batch ethanol fermentations.Nomenclature F reactor feeding rate (L.h^–1) - M_E mass of ethanol in the fermentor (g) - M_s mass of TRS in the fermentor (g) - M_x mass of yeast cells (dry matter) in the fermentor (g) - P ethanol productivity (g.L^–1.h^–1) - s standard deviation - S_o TRS concentration in the feeding mash (g.L^–1) - t time (h) - T fermentor filling-up time (h) - TRS total reducing sugars calculated as glucose (g.L^–1) - X_o yeast cells concentration (dry matter) in the inoculum (g.L^–1) - average ethanol yield (% of the theoretical value)     

Ethanol fermentation of raw cassava starch with Rhizopus koji in a gas circulation type fermentor

Studies have been conducted in a gas circulation type fermentor in order to characterize the ethanol fermentation of uncooked cassava starch with Rhizopus koji. Results showed that ethanol concentration reached 13-14% (v/v) in 4-day broth, and the maximum productivity of ethanol was 2.3 g ethanol/L broth h. This productivity was about 50% compared to the productivity of a glucose-yeast system. Ethanol yield reached 83.5-72.3% of the theoretical yield for the cassava starch used. The fermentor used in the present work has been proven by experiment to be suitable for ethanol fermentation of the broth with solid substrate.     

Effect of air supplement on the performance of continuous ethanol fermentation system

For the purpose of improving ethanol productivity, the effect of air supplement on the performance of continuous ethanol fermentation system was studied. The effect of oxygen supplement on yeast concentration, cell yield, cell viability, extracellular ethanol concentration, ethanol yield, maintenance coefficient, specific rates of glucose assimilation, ethanol production, and ethanol productivity have been evaluated, using a high alcohol tolerant Saccharomyces cerevisiae STV89 strain and employing a continuous fermentor equipped with an accurate air metering system in the flow rate range 0-11 mL air/L/h. It was found that, when a small amount of oxygen up to about 80mu mol oxygen/L/h was supplied, the ethanol productivity was significantly enhanced as compared to the productivity of the culture without any air supplement. It was also found that the oxygen supplement improved cell viability considerably as well as the ethanol tolerance level of yeast. As the air supply rate was increased, from 0 to 11 mL air/L/h while maintaining a constant dilution rate at about 0.06 h(-1), the cell concentration increased from 2.3 to 8.2 g/L and the ethanol productivity increased from 1.7 to 4.1 g ethanol/L/h, although the specific ethanol production rate decreased slightly from 0.75 to 0.5 g ethanol/g cell/h. The ethanol yield was slightly improved also with an increase in air supply rate, from about 0.37 to 0.45 ethanol/g glucose. The maintenance coefficient increased by only a small amount with the air supplement. This kind of air supplement technique may very well prove to be of practical importance to a development of a highly productive ethanol fermentation process system especially as a combined system with a high density cell culture technique.     

Influence of exponentially decreasing feeding rates on fed-batch ethanol fermentation of sugar cane blackstrap molasses

Summary The ethanol yield was not affected and the ethanol productivity was increased when exponentially decreasing feeding rates were used instead of constant feeding rates in fed batch ethanol fermentations. The influences of the initial sugar feeding rate on the ethanol productivity, on the constant ethanol production rate during the feeding phase and on the initial ethanol production specific rate are represented by Monod-like equations.Nomenclature F reactor feeding rate (L.h^–1) - F_o initial reactor feeding rate (L.h^–1) - K time constant; see equation (l) (h^–1) - M_E mass of ethanol in the fermentor (g) - M_s mass of TRS in the fermentor (g) - M_x mass of yeast cells (dry matter) in the fermentor (g) - P ethanol productivity (g.L^–1.h^–1) - R ethanol constant production rate during the feeding phase (g.h^–1) - s standard deviation - S_o TRS concentration in the feeding mash (g.L^–1) - t time (h) - T fermentor filling-up-time (h) - T time necessary to complete the fermentation (h) - TRS total reducing sugars calculated as glucose (g.L^–1) - V_o volume of the inoculum (L) - V_f final volume of medium in the fermentor (L) - X_o yeast concentration of the inoculum (dry matter) (g.L^–1) - ethanol yield (% of the theoretical value) - initial specific rate of ethanol production (h^–1)     

自絮凝酵母SPSC01在组合反应器系统中酒精连续发酵的研究

建立了一套由四级磁力搅拌发酵罐串联组成、总有效容积4000mL的小型组合生物反应器系统 ,其中一级罐作为种子培养罐。以脱胚脱皮玉米粉双酶法制备的糖化液为种子培养基和发酵底物 ,进行了自絮凝颗粒酵母酒精连续发酵的研究。种子罐培养基还原糖浓度为100g L ,添加 (NH₄)₂HPO₄ 和KH₂PO₄ 各 20g L ,以0.017h^-1 的恒定稀释速率流加 ,并溢流至后续酒精发酵系统。发酵底物初始还原糖浓度 220g/L ,添加 (NH₄)₂HPO₄ 15g/L和KH₂PO₄2 5g/L ,流加至第一级发酵罐 ,稀释速率分别为 0.017、0.025、0.033、0.040和0.05 0h^-1。实验数据表明 ,自絮凝颗粒酵母在各发酵罐中呈部分固定化状态 ,在稀释速率0.040h^-1 条件下 ,发酵系统呈一定的振荡行为 ,其他四个稀释速率实验组均能够达拟稳态。当稀释速率不超过 0 0 33h^-1 ,流出末级发酵罐的发酵液中酒精浓度可以达到 12 % (V/V)以上 ,残还原糖和残总糖分别在 0 11%和 0 35 % h^-1,流出末级发酵罐的发酵液中酒精浓度可以达到12%（V/V）以上,残还原糖和残总糖分别在0.11%和0.35%（W/V）以下。在稀释速率为0.033h^-1时,计算发酵系统酒精的设备生产强度指标为3.32（g·L^-1·h^-1）,与游离酵母细胞传统酒精发酵工艺相比,增加约1倍。     

Ethanol production in a hollow fiber bioreactor using Saccharomyces cerevisiae

Summary A new approach for continuous production of ethanol was developed using a Hollow fiber fermentor (HFF). Saccharomyces cerevisiae cells were packed into the shell-side of a hollow fiber module. Using 100 g/l glucose in the feed gave an optimum ethanol productivity, based on total HFF volume, of 40 g ethanol/l/h at a dilution rate of 3.0 h^-1. Under these conditions, glucose utilization was 30%. However, at 85% glucose utilization the productivity was 10 g ethanol/l/h. This compares to batch fermentor productivity of 2.1 g ethanol/l/h at 100% glucose utilization.     

Ethanol and sugar tolerance of Candida shehatae

Summary Candida shehatae ATCC 22984 fermented solutions of up to 260 g/L sugars derived by hydrolysis of whole barley. These solutions contained hexose: pentose 7030, the hexose being mainly glucose from the barley starch and the pentose being mainly xylose. At sugar concentrations of 180 g/L, fermentation was complete in 72 h, yielding 84 g/L ethanol, 0.47 g ethanol/g sugar. At 260 g/L, fermentation ceased when ethanol concentration reached 100 g/L, but resumed when the ethanol was removed by vacuum distillation, to yield finally 0.50 g ethanol/g sugar.     

Alteration of xylose reductase coenzyme preference to improve ethanol production by Saccharomyces cerevisiae from high xylose concentrations

A K270R mutation of xylose reductase (XR) was constructed by site-direct mutagenesis. Fermentation results of the F106X and F106KR strains, which carried wild type XR and K270R respectively, were compared using different substrate concentrations (from 55 to 220 g/L). After 72 h, F106X produced less ethanol than xylitol, while F106KR produced ethanol at a constant yield of 0.36 g/g for all xylose concentrations. The xylose consumption rate and ethanol productivity increased with increasing xylose concentrations in F106KR strain. In particular, F106KR produced 77.6g/L ethanol from 220 g/L xylose and converted 100 g/L glucose and 100g/L xylose into 89.0 g/L ethanol in 72h, but the corresponding values of F106X strain are 7.5 and 65.8 g/L. The ethanol yield of F106KR from glucose and xylose was 0.42 g/g, which was 82.3% of the theoretical yield. These results suggest that the F106KR strain is an excellent producer of ethanol from xylose.     

代谢工程改造大肠杆菌合成丁二酸及发酵罐放大工艺

【背景】Escherichia coli AFP111发酵生产丁二酸时大量副产乙酸,丁二酸得率低。【目的】代谢工程改造EscherichiacoliAFP111,提高丁二酸得率,降低副产物乙酸的生成,建立100 L规模的丁二酸发酵工艺。【方法】一步同源重组敲除乙酸合成途径关键酶基因,改造丁二酸合成途径关键酶启动子实现过表达;单因素优化5L发酵罐培养条件。【结果】敲除乙酸产生途径编码乙酸激酶和磷酸转乙酰酶的基因ackA-pta、苏氨酸脱羧酶和2-酮丁酸甲酸裂解酶的基因tdcDE获得SX02菌株,摇瓶发酵条件下其乙酸产量下降了53.42%,丁二酸得率提高9.85%。在SX02菌株基础上,经启动子改造过表达编码葡萄糖激酶的基因glk后获得菌株SX03,其Glk酶活性提高3.66倍,乙酸产量下降了31.62%,丁二酸得率提高8.28%。SX03菌株发酵生产丁二酸在5 L发酵罐进行放大,其乙酸产量为3.97 g/L,丁二酸得率为1.62 mol/mol葡萄糖,相比出发菌株的乙酸产量下降了75.76%,丁二酸得率提高19.12%。在5L发酵罐上对比研究了中和剂Na2CO3和NaOH混合液替换碱式MgCO3的发酵效果,并优化了发酵pH、搅拌转速和葡萄糖浓度,获得如下最适发酵条件:pH6.8,搅拌转速250r/min,葡萄糖100g/L,发酵结束时乙酸产量为2.24 g/L,丁二酸得率为1.66 mol/mol葡萄糖。中和剂替换优化后乙酸产量下降了20.65%,丁二酸得率提高2.47%。菌株SX03发酵工艺进一步在100 L发酵罐上实现放大,其乙酸产量为1.91 g/L,丁二酸得率为1.30 mol/mol葡萄糖。【结论】通过代谢工程改造的大肠杆菌,其副产物乙酸含量显著下降,丁二酸得率提高,并在5 L和100 L发酵罐上实现了工艺放大,展现出较大的工业化利用潜力。     

Effect of interstage mixing in multistage culture systems on continuous biomass production

The significance of the interstage mixing on important process parameters of biomass production was studied. The experiments were performed in a multistage tower fermentor and in fermentors in series. The interstage mixing effect can be evaluated under conditions of geometrical similarity, identity of oxygen transfer rate, and identity of dilution rate per stage in the individual stages of both culture systems. Candida utilis was cultivated on a synthetic medium with ethanol as the sole carbon and energy source in the concentration range 10–100 g/liter. Dilution rate, temperature, and pH in each stage of both culture systems were kept constant. It was demonstrated that in the multistage tower fermentor the definite backflow which ensures the permanent reinoculation by adapted cells significantly decreases the inhibitory effect of higher ethanol concentrations on the cell growth and on the rate of ethanol utilization.     

Continuous fermentation of feed streams containing D-glucose and D-xylose in a two-stage process utilizing immobilized Saccharomyces cerevisiae and Pachysolen tannophilus

In the U.S., forest and crop residues contain enough glucose and xylose to supply 10 times the country's usage of ethanol and ethylene, but an efficient fermentation scheme is lacking,(1,2,3) To develop a strategy for process design, specific ethanol productivities and yields of Pachysolen tannophilus NRRL Y-2460 and Saccharomyces cerevisiae NRRL Y-2235 were compared. Batch cultures and continuous stirred reactors (CSTR) loaded with immobilized cells were fed glucose and xylose. As expected from previous reports, Y-2235 fermented glucose but not xylose. Y-2460 consumed both sugars but fermented glucose inefficiently relative to Y-2235, and it suffered a diauxic lag lasting 10-20 h when given a sugar mixture. Immobilized Y-2235 exhibited increasing productivity but constant yield with in creasing glucose concentration. In contrast, Y-2460 exhibited an optimum productivity at 30-40 g/L xylose and a declining yield with increasing xylose concentration. Immobilized Y-2235 tolerated more than 100 g/L ethanol while the productivity and yield of Y-2460 fell by 80 and 58%, respectively, as ethanol reached 50 g/L. A 38.8-g/L ethanol stream could be produced as 103 g/L xylose was continuously fed to Y-2460. If it was blended with a 274 g/L glucose stream to give a composite of 23.7 g/L ethanol and 107 g/L glucose, Y-2235 could en rich the ethanol to 75 g/L. Taken together these results suggest use of a two-stage continuous reactor for pro cessing xylose and glucose from lignocellulose. An immobilized Y-2460 CSTR (or cascade) would convert the hemicellulose hydrolyzate. Then downstream, an immobilized Y-2235 plug flow reactor would enrich the hemicellulose-derived ethanol to more than 70 g/L upon addition of cellulose hydrolyzate.     

pH及流加葡萄糖对酵母分批发酵生产谷胱甘肽的影响

在5 L的发酵罐中研究了pH及流加葡萄糖对酵母分批发酵生产谷胱甘肽(GSH)的影响。实验考察了不同浓度的流加葡萄糖和不同的恒pH值的分批发酵对于酵母生产GSH产量的变化。实验结果表明,当pH值控制为5.0,流加葡萄糖流速为5g.L-1.h-1,连续流加30 h,可使GSH产量最高,与之前未流加葡萄糖和控制pH相比,其产量提高了6倍。     

Control of packed column fouling in the continuous fermentation and stripping of ethanol

By recycling the contents of a 14 L fermentor through a stripping column to continuously remove ethanol and reduce product inhibition, continuous complete conversion of nutrient feed containing 600 g/L glucose was achieved in a small pilot plant. Ethanol was recovered from the carbon dioxide stripping gas in a refrigerated condenser, and the gas was reheated with steam and recycled by a blower. Productivity of ethanol in the fermentor as high as 15.8 g/L/h and condensate production of up to 10 L/day of almost 50% by volume ethanol were maintained for up to 60 days of continuous operation. Weekly washing of the column packing in situ was required to prevent loss of performance caused by attached growth of yeast cells, which restricts the gas flow rate through the stripping column. (c) 1996 John Wiley & Sons, Inc.     

The effect of pH,temperature and sucrose concentration on high productivity continuous ethanol fermentation using Zymomonas mobilis

Summary A flocculent strain of Zymomonas mobilis was used for ethanol production from sucrose. Using a fermentor with cell recycle (internal and external settler) high sugar conversion and ethanol productivity were obtained. At a dilution rate of 0.5 h^-1 (giving 96% sugar conversion) the ethanol productivity, yield and concentrations respectively were 20 g/l/h, 0.45 g/g and 40 g/l using a medium containing 100 g/l sucrose. At a sucrose concentration of 150 g/l, the ethanol concentration reached 60 g/l. The ethanol yield was 80% theoretical due to levan and fructo-oligomer formation. No sorbitol was detected. This fermentation was conducted at a range of conditions from 30 to 36°C and from pH 4.0 to 5.5.     

Continuous ethanol production in the gas-lift tower fermenter

Summary A highly flocculent strain of Saccharomyces uvarum was used to convert glucose to ethanol and CO₂ in a single stage, continuous, gas-lift tower fermenter. Satisfactory operation was maintained in prolonged runs with yeast concentrations in excess of 100 g/L (d.w.) and hydraulic retention times less than 0.4 h. Maximum ethanol concentration and productivity were 88 g/L and 44.5 g/Lh respectively. Conversion efficiency was between 80 and 95% of theoretical.     

产酸丙酸杆菌生长特性及5L罐发酵动力学研究

论文在摇瓶水平对产酸丙酸杆菌基本生长特性（温度、pH、摇床转速、接种量、种龄等）、碳源、氮源利用情况、产物抑制及5 L罐发酵动力学进行了研究。结果表明,该菌在32℃,初始pH 6．5,摇床转速150 r/min,接种24 h的种子液,接种量为5％条件下,产酸丙酸杆菌生长及产酸水平达最高值;该菌可利用碳源十分广泛,但对氮源要求比较高,只可利用有机氮源;在不同初始葡萄糖浓度下,产酸丙酸杆菌生长及产酸水平差异不大,无明显底物抑制现象;在2g/L的初始丙酸盐浓度下,该菌生长受到明显抑制;在5L发酵罐中,初始葡萄糖浓度为58．8 g/L,发酵72 h,葡萄糖消耗完全,丙酸终浓度达22．4 g/L,丙酸得率和产率分别达0．381 g/g和0．295 g/（L·h）,丙酸占总酸比例达72．10％。     

Ethanol production from xylose with the yeast Pichia stipitis and simultaneous product recovery by gas stripping using a gas-lift loop fermentor with attached side-arm (GLSA)

The bioconversion of xylose into ethanol with the yeast Pichia stipitis CBS 5773 is inhibited when 20 g/L of ethanol are present in the fermentation broth. In order to avoid this limitation, the fermentation was carried out with simultaneous recovery of product by CO(2) stripping. The fermentation was also improved by attaching a side-arm to the main body of a classical gas-lift loop fermentor. This side-arm increases the liquid circulation, mass transfer, and gas distribution, reducing the amount of oxygen in the inlet gas necessary to perform the fermentation of xylose under microaerobic conditions (K(L)a approximately 16 h(-1)). The continuous stripping of ethanol from the fermentation broth in this new bioreactor system allowed the consumption of higher xylose concentrations than using Erlenmeyer shaker flasks, improved significantly the process productivity and provided a clean ethanol solution by using an ice-cooled condenser system. Finally, a fed-batch fermentation was carried out with a K(L)a = 15.8 h(-1). Starting with 248.2 g of xylose, 237.6 g of xylose was consumed to produce 88.1 g of ethanol which represents 72.6% of the theoretical yield (47.2 g/L of ethanol was recovered in the condenser, while 9.6 g/L remained in the fermentation broth).     

Ethanol production by immobilized Saccharomyces cerevisiae, Saccharomyces uvarum, and Zymomonas mobilis

Saccharomyces cerevisiae NRRL Y-2034, S, uvarum NRRL Y-1347, and Zymomonas mobilis NRRL B-806 each were separately immobilized in a Ca-alginate matrix and incubated in the presence of a free-flowing and continuous 1, 3, 5, 10, or 20% (w/w) glucose solution. In general, the yeast cells, converted 100percnt; of the 1, 3, and 5% glucose to alcohol within 48 h and maintained such a conversion rate for at least two weeks. The bacterium converted ca. 90% (w/w) of the 1, 3, and 5% glucose to alcohol continuously for one week. However, both the yeast and bacterium were inhibited in the highest glucose (20% w/w) solution. All of the immobilized cultures produced some alcohol for at least 14 days. Immobilized S. cerevisiae was the best alcohol producer of all of the glucose concentrations; the yeast yielded 4.7 g ethanol/100 g solution within 72 h in the 10% glucose solution. After 7-8 days in the 10% solution, S. cerevisiae produced ethanol at 100% of theoretical yield (5.0 g ethanol/100 g solution), with a gradual decrease in alcohol production by 14 days. Immobillized S. uvarum produced a maximum of 4.0 g ethanol/100 g solution within 2 days and then declined to ca. 1.0 g ethanol/100 g solution after 7 days continuous fermentation in the 10% glucose solution. Zymomonas mobilis reached its maximum ethanol production at 4 days (4.7 g/100 g solution), and then diminished similarly to S. uvarum. The development of a multiple disk shaft eliminated the problem both of uneven distribution of alginate-encapsulated cells and of glucose channeling within the continuous-flow fermentor column. This invention improved alcohol production about threefold for the yeast cells.