Zonal-Centrifuged Purified Duck Embryo Cell Culture Rabies Vaccine for Human Vaccination

Rabies virus produced in duck embryo cell culture was concentrated from volumes of 14 to 30 liters to 400 to 800 ml by zonal centrifugation. Virus titers of peak fractions were from 100- to 1,000-fold greater than those of the starting material. Vaccines were prepared by combining fractions with peak virus titers and diluting back to 10 times concentration. The resulting beta-propiolactone-inactivated vaccines, when prepared as lyophilized vaccines with AlPO(4) adjuvant diluents, were low in protein nitrogen (0.01 mg/ml), and three of four lots passed the National Institutes of Health potency test when tested as equivalent to a standard 10% suspension of duck embryo or mouse brain tissue vaccine. These vaccines also induced good sero-conversion in adult rabbits after a single 1-ml dose of vaccine. Guinea pigs sensitized with zonal-centrifuged purified duck embryo vaccine (with AlPO(4) adjuvant) did not exhibit anaphylactic shock reactions when challenged with homologous vaccine. Also, no anaphylactic shock reactions were observed when guinea pigs were sensitized with either a 10% experimental duck embryo vaccine or cell culture vaccine and then challenged with the zonal-purified vaccine. However, guinea pigs sensitized with cell culture or zonal-purified vaccine and then challenged with the 10% experimental vaccine did show slight transitory congestion. The 10% experimental whole duck embryo vaccine was responsible for all observed anaphylactic shock reactions whether homologous or heterologous.     

Standardization of an enzyme immunoassay for the in vitro potency assay of inactivated tissue culture rabies vaccines: determination of the rabies virus glycoprotein with polyclonal antisera

A non-competitive enzyme-linked immunoassay (ELISA) has been standardized to supplement the in vivo potency test used for the quality control of inactivated tissue culture vaccines against rabies. The essentials of the ELISA were: fixation of the virus in different dilutions of vaccine on the surface of microtitre plates; testing of the reference and up to six test vaccines on one plate; incubation with polyclonal antisera to rabies virus glycoprotein containing an excess of antibody; further incubation with a species-specific anti-IgG coupled to peroxidase; a final incubation with a substrate. The incubation periods were 1 h, 1 h and 30 min both at +37 degrees C. The relative potency determinations were made graphically or by a computer using a parallel line bioassay in which the potencies of the vaccines of unknown potency were tested against the reference preparation on a single microtitre plate. Under these conditions inactivated rabies vaccines of different types (virus strains, cell substrates, inactivation and concentration procedures) were tested for potency. Furthermore, it was possible with this in vitro method to assay adjuvanted vaccines, in process samples such as tissue culture supernatants with live or inactivated rabies virus, concentrates, and vaccines undergoing thermal stability tests. The rabies glycoprotein antigen-antibody reaction was highly specific according to the results and the glycoprotein content was measured quantitatively. The potency determined by the in vitro ELISA correlated with the in vivo NIH protection potency test. The lower limit of detection of the ELISA was 0.015 IU/ml. Quantitative antigen determination was possible with both homologous and heterologous antisera to rabies virus glycoprotein when vaccines of the same virus strain were tested. When the potencies of vaccines of different virus strain specificity were calculated, it was necessary to take into account the strain-specific antigenicity. Even so vaccines of high potency were found to give a stronger reaction with a heterologous serum than did weak vaccines with a homologous antiserum. Stability tests made on inactivated tissue culture vaccines such as vaccine from the human diploid cell strain (HDCS), from purified chicken embryo cell (PCEC) or from purified Vero cell rabies vaccine (PVRV), showed high stability of the glycoprotein antigen even after four months of storage at +37 degrees C or 24 h at +56 degrees C, provided that the vaccines were stored in a lyophilized state. The antigenicity of liquid vaccines was inactivated after a few hours at +56 degrees C. For tropical areas, therefore, only lyophilized vaccines should be considered.     

Use of a monoclonal antibody for quantitation of rabies vaccine glycoprotein by enzyme immunoassay

The use of a monoclonal antibody specific for the envelope glycoprotein of rabies virus has been used in a direct enzyme immunoassay to quantify the glycoprotein content of rabies vaccines produced in two kinds of cell culture. The results of this direct enzyme immunoassay are well correlated with the in vivo NIH potency test. This test may be a useful tool to rapidly and accurately control the antigenic value of a vaccine. It could also be used for the "in process' control of vaccine production before deciding whether a vaccine batch may reasonably be subjected to the NIH potency test.     

A semi-quantitative serological method to assess the potency of inactivated rabies vaccine for veterinary use

Potency is one of the most important indexes of inactivated vaccines. A number of methods have been established to assay the potency, of which the NIH test and single-dose mouse protection test are the “prescribed methods”. Here, we report a method to semi-quantitatively assay the potency of an inactivated rabies vaccine, which uses fewer animals and takes less time to complete. Depending on the quality requirements of a vaccine (e.g. minimum potency), a rabies reference vaccine is, for example, diluted to the minimum potency, and 50 μL of the dilution is taken to inoculate 10 mice. The same amount of the test rabies vaccine is inoculated into another 10 mice. After two weeks, all mice are bled and serum samples are assayed for viral neutralizing antibody by the fluorescent antibody virus neutralization (FAVN) test. By comparing the median and interquartile range of antibody titers of the reference vaccine with those of the test vaccine, the test vaccine potency can be semi-quantitatively judged as to whether it is in accord with the required quality. The reliability of this method was also confirmed in dogs. The procedure can be recommended for batch potency testing during inactivated rabies vaccine production.     

A mouse model of the pathogenesis and postexposure prophylaxis of rabies

A mouse model for the study of postexposure prophylaxis of rabies was established. Mice injected intramuscularly with a street strain of rabies virus were significantly protected from death by five daily 0.2-ml doses of inactivated rabies vaccine of chick embryo cell culture origin initiated immediately or 3 hr after infection. In these mice, a large amount of circulating interferon was induced as early as 1 hr after the first dose of vaccine and lasted until at least 12 hr but no such amount of interferon was induced by additional doses of vaccine. Serum antibody was first detected in the mice on day 6. It was noted that some of the surviving mice manifested an ataxia or paralysis of the legs. Increasing mortality rates were shown in mice treated with decreasing doses of the vaccine. Passive protection tests using concentrated IgG and IgM antibodies with equivalent neutralization titers showed that IgG antibody gave total protection when given 24 hr before the infection, while it was almost totally ineffective in reducing the mortality when given 2 days or more after infection. IgM antibody did not protect the mice even when given 24 hr before infection. These results suggest that interferon production is more important than antibody production in the initial stages of protection by postexposure vaccination. However, the mechanisms of postexposure prophylaxis in this model could not be explained only by the interferon produced by the vaccine and the possible contributions of additional mechanisms were suggested.     

Immunization Against Rabies

The methods used for both pre-exposure and post-exposure immunization against rabies were studied. In pre-exposure immunization duck embryo vaccine should be used. In post-exposure immunization either duck embryo or Semple-type vaccine appears to be effective in stimulating antibody production. Both vaccines may cause neurological sequelae. A dose of vaccine should be given 20-50 days after completion of the primary course of vaccination. Immune serum should be used in all severe exposures especially of the head and neck, and in individuals in whom the commencement of vaccination has been unduly delayed. In individuals who have been previously vaccinated reinforcing doses have been found to be effective even as long as 20 years after the primary vaccination. A tissue culture vaccine has been developed and is about to undergo field trials.     

Management of 41 persons exposed to a rabid dog: unplanned experience with human diploid vaccine.

Thirty-six persons -- veterinarians, technicians and students at a veterinary clinic -- were unwittingly exposed to a rabid dog over a period of 21/2 days. One veterinarian received a penetrating bite, two other individuals were grabbed by the dog but the skin was not penetrated, and many were exposed to saliva or urine or both. In addition, the owner of the dog and his wife and three children, while not bitten, were exposed to saliva. The diagnosis was made post mortem when specimens of the dog''s brain were examined by indirect fluorescent antibody testing. All but one of the students had been vaccinated against rabies with hamster kidney vaccine, but eight members of the veterinary college''s staff had not been so vaccinated. Treatment started with duck embryo vaccine; if necessary, rabies (human) immune globulin was also given. When one student reacted severely to the first dose of duck embryo vaccine permission was sought to bring a human diploid vaccine into Canada. In five patients the human diploid vaccine was substituted for the duck embryo vaccine because of severe reactions to the latter. Twenty-five staff members and the family of five received both vaccines. Reactions to the human diploid vaccine were minor and transient. Recommendations include the early licensing of the human diploid vaccine in Canada.     

炭疽活疫苗家兔免疫力与血清抗芽胞IgG关系的研究

炭疽疫苗是预防炭疽流行和炭疽生物恐怖的重要手段。已有动物实验表明,炭疽活疫苗的保护力优于以保护性抗原为主要成份的无细胞疫苗,但两类现行疫苗都有待重新评价和改进。炭疽疫苗的效力必须用适当的实验室方法进行检测与分析才能了解其性质和细节。试验中力图探寻炭疽活疫苗家兔免疫力与血清抗芽胞抗体水平的关系。用“皮上划痕人用炭疽活疫苗”免疫家兔,以特定制备的炭疽芽胞抗原用ELISA法检测血清抗炭疽芽胞IgG抗体水平,并用强毒炭疽杆菌攻击进行效力试验。免疫家兔血清几何平均抗芽胞IgG滴度在免疫后一个月内持续升高,14d达到206,28d时达到776,这时其抵抗20MLD毒菌攻击的保护率为80％,符合中国生物制品规程要求的保护力。一个月后抗体水平开始下降,42d时滴度降至223。实验所揭示的炭疽减毒活疫苗诱导的家兔抗芽胞IgG抗体与抗炭疽保护力之间的关系,既为评价现行疫苗提供了资料,也为研制新型疫苗建立了参考性指标。     

Heterologous Prime-Boost Vaccination with MF59-Adjuvanted H5 Vaccines Promotes Antibody Affinity Maturation towards the Hemagglutinin HA1 Domain and Broad H5N1 Cross-Clade Neutralization

In an open label clinical study (2007), MF59-adjuvanted hemagglutinin (HA) vaccine from H5N1-A/Vietnam/1194/2004 (clade 1) was administered to subjects previously vaccinated (primed) with clade 0 H5N3 (A/duck/Singapore/97) vaccine at least 6 years earlier (in 1999 or 2001). The primed individuals responded rapidly and generated high neutralizing antibody titers against the H5N1-Vietnam strain within 7 days of a single booster vaccination. Furthermore, significant cross-neutralization titers were measured against H5N1 clade 0, 1, and 2 viruses. In the current study, the impact of MF59 adjuvant during heterologous priming on the quality of humoral polyclonal immune response in different vaccine arms were further evaluated using real time kinetics assay by surface plasmon resonance (SPR). Total anti-H5N1 HA1 polyclonal sera antibody binding from the heterologous prime-boost groups after a single MF59-H5N1 boost was significantly higher compared with sera from unprimed individuals that received two MF59-H5N1 vaccinations. The antigen-antibody complex dissociation rates (surrogate for antibody affinity) of the polyclonal sera against HA1 of H5N1-A/Vietnam/1194/2004 from the MF59-H5N3 primed groups were significantly higher compared to sera from unadjuvanted primed groups or unprimed individuals that received two MF59-H5N1 vaccines. Furthermore, strong inverse correlations were observed between the antibody dissociation off-rates of the immune sera against HA1 (but not HA2) and the virus neutralization titers against H5 vaccine strains and heterologous H5N1 strains. These findings supports the use of oil-in-water-adjuvanted pandemic influenza vaccines to elicit long term memory B cells with high affinity BCR capable of responding to potential variant pandemic viruses likely to emerge and adapt to human transmissions.     

An immune response profile model for immunogenicity quantitation

We propose an analytical model, which can simultaneously depict many fundamental characteristics of the immunogenicity of various vaccines. This model, the Immune Response (IR) profile, conveniently expresses the mathematical relation between pre- and post-vaccination titers. A vaccine's IR profile is antigen-specific, dose-dependent and post-vaccination interval-dependent. The maximal capability for serological response to a vaccine can be determined using this model irrespective of the dose administered, the post-vaccination assay interval, or the live or killed state of the vaccine. The IR profile obtained from analysis of booster vaccine responses in a limited number of seropositive study subjects can be used to predict maximal antibody titers which are expected after vaccination and can predict the geometric mean post-vaccination antibody titer of a cohort of subjects undergoing primary immunization. Using this model, it is anticipated that the immunoregulation implied by the IR profile may also prove to be correlated with cellular subpopulations and idiotypic antibody functions. Although derived from influenza vaccines analyses, the model successfully describes immune response characteristics following natural infection with malaria and following diphtheria and rubella vaccine administration.     

Yellow Fever Vaccine: Direct Challenge of Monkeys Given Graded Doses of 17D Vaccine

In rhesus monkeys a wide dosage range of 17D yellow fever (YF) vaccine extending to a level even below that recommended for vaccination of man elicited an immune response providing solid protection to challenge with virulent YF virus. Forty-three of 45 monkeys vaccinated with 10(2.3) or greater weanling mouse mean lethal doses of 17D vaccine were resistant to challenge 20 weeks later with virulent Asibi strain YF virus. Monkeys given graded doses of lesser amounts of vaccine were progressively more susceptible to challenge. With a vaccine dose >/= 10(2.3) weanling mouse mean lethal doses, plaque neutralization (PN) seroconversion rates were 90% or greater, whereas hemagglutination-inhibiting (HI) and complement-fixing (CF) seroconversion rates were unrelated to vaccine dosage and were generally in the range of 20 to 80%. Ninety-six percent (51 of 54) of immune monkeys had PN titers >/=0.7 log(10) (fivefold) neutralization index as compared to approximately 55 to 65% who showed HI or CF titers >/=2 log(2) (fourfold) neutralization index. After challenge with Asibi strain YF virus, antibody titers of all three tests increaed equally. In rhesus monkeys PN antibody titers were well correlated with YF immunity, whereas HI and CF antibody titers were not.     

The rapid fluorescent focus inhibition test is a suitable method for batch potency testing of inactivated rabies vaccines

The European Pharmacopoeia proposes two methods for potency determination of inactivated rabies vaccines for veterinary use: The first one is a classical mouse challenge test, which is imprecise, time-consuming, and causes severe distress to the test animals. Alternatively, the potency may be determined serologically by measuring the neutralizing antibody titers induced after vaccination of mice by using a rapid fluorescent focus inhibition test (RFFIT). Although this method is faster and less painful for the animals, it is not widely used yet, and only little data exist concerning the comparability of both methods.We have therefore performed a comparative study, in which we demonstrated a good correlation between the challenge test results and the mean titers determined by RFFIT. Furthermore, all vaccine batches failing the challenge test were also recognized as insufficient in the serological assay. This publication further describes the influence of different vaccine administration routes on the resulting antibody titers, and it proposes various modifications to the serological assay protocol which could improve its overall practicability. Finally, we recommend that the serological assay be used for the potency testing of inactivated rabies vaccines.     

Evaluation of the single radial-immunodiffusion assay for measuring the glycoprotein content of rabies vaccines

The glycoprotein content of rabies vaccines containing the Pitman-Moore strain of rabies virus was measured by the single radial immunodiffusion assay and correlated with vaccine potency. The variability of this assay was 6.3% for a single vaccine lot tested over a one-year period. Using sera prepared against rabies virus glycoprotein from different strains of virus, the assay gave different values. These differences could be eliminated by using a homologous vaccine strain as an internal reference. Single radial-immunodiffusion values for Pitman-Moore vaccines correlated with the manufacturers' NIH potency assay, but required a mathematical transformation to convert values from one assay to the other. Single radial-immunodiffusion values for Street Alabama Dufferin and Flury-LEP vaccines did not correlate with NIH values. Modification of the single radial immunodiffusion technique and the feasibility of using this assay for the determination of rabies vaccine potency are discussed.     

两个NIH小鼠种群对不同种类的乙肝疫苗免疫应答效应的比较

目的比较两种不同的NIH小鼠种群基因组DNA中H-2q单倍型的百分比,对重组基因乙型肝炎疫苗（酿酒酵母）、重组基因乙型肝炎疫苗（CHO）、重组基因乙型肝炎疫苗（汉逊酵母）和治疗性乙型肝炎疫苗（乙克）免疫应答的影响。方法检测乙肝疫苗免疫效力用酶标法,测定乙肝疫苗的ED50值,再通过微量细胞毒法和PCR方法检测小鼠的H-2单倍型,计算不同品系小鼠H-2q的百分数,得出乙肝疫苗与不同动物种群的相关性。结果经验证,经1号NIH小鼠检测结果证实,重组基因乙型肝炎免疫效力依次为CHO〉汉逊〉酿酒,疗性乙型肝炎疫苗（乙克）效力检测合格,但经2号NIH小鼠检测结果显示除CHO疫苗合格外,其他三种疫苗检测结果均为不合格。基因检测结果为,1号种群NIH鼠含有H-2q型基因的百分比是96%,而2号种群NIH小鼠含有H-2q型基因基因百分比为30%,因此不同的q型基因百分比导致了不同的检测结果。结论根据本研究结果表明虽然NIH鼠的H-2单倍型中有q型基因,但不同来源的小鼠种群之间会存在差异,经不同的环境饲养后,小鼠的基因会发生不同的变化,因此在进行生物制品检定时,要注意不同品系小鼠及同一品系小鼠不同种群之间的差异对试验本身的影响。建立一种＂动物免疫＂的概念。     

Immunization of primates with a Newcastle disease virus-vectored vaccine via the respiratory tract induces a high titer of serum neutralizing antibodies against highly pathogenic avian influenza virus

The ongoing outbreak of highly pathogenic avian influenza virus (HPAIV) in birds, the incidence of transmission to humans with a resulting high mortality rate, and the possibility of a human pandemic warrant the development of effective human vaccines against HPAIV. We developed an experimental live-attenuated vaccine for direct inoculation of the respiratory tract based on recombinant avian Newcastle disease virus (NDV) expressing the hemagglutinin (HA) glycoprotein of H5N1 HPAIV (NDV-HA). Expression of the HPAIV HA gene slightly reduced NDV virulence, as evidenced by the increased mean embryo death time and reduced replication in chickens. NDV-HA was administered to African green monkeys in two doses of 2 x 10(7) infectious units each with a 28-day interval to evaluate the systemic and local antibody responses specific to H5N1 HPAIV. The virus was shed only at low titers from the monkeys, indicative of safety. Two doses of NDV-HA induced a high titer of H5N1 HPAIV-neutralizing serum antibodies in all of the immunized monkeys. Moreover, a substantial mucosal immunoglobulin A response was induced in the respiratory tract after one and two doses. The titers of neutralizing antibodies achieved in this study suggest that the vaccine would be likely to prevent mortality and reduce morbidity caused by the H5N1 HPAIV. In addition, induction of a local immune response in the respiratory tract is an important advantage that is likely to reduce or prevent transmission of the virus during an outbreak or a pandemic. This vaccine is a candidate for clinical evaluation in humans.     

新城疫壳聚糖微球疫苗免疫效果的研究

鸡新城疫是由新城疫病毒引起的鸡的一种急性、烈性、高度接触性传染病,是危害养禽业的最严重疫病之一。控制新城疫最根本的措施是进行有效的疫苗接种,目前常用的疫苗是弱毒活疫苗和灭活疫苗,但二者在实际应用中均存在一定的局限性。口服微球疫苗可以诱导较强的粘膜免疫;同时还能够诱导产生系统的体液免疫和细胞免疫,已成为ND疫苗研究的热点。以壳聚糖为囊材,新城疫La Sota抗原液为芯材,戊二醛为交联剂,制备出新城疫壳聚糖微球疫苗,通过了实验室安全检验和效力检验。将新城疫壳聚糖微球疫苗与LaSota活疫苗和新城疫油乳剂灭活苗分别免疫SPF鸡,利用MTT、血凝抑制法(HI)和ELISA等分别检测不同疫苗免疫后的细胞免疫、体液免疫和粘膜免疫抗体IgA,并在当免疫鸡HI抗体降到23的情况下进行了攻毒试验。结果表明,新城疫壳聚糖微球疫苗安全性好,免疫后可刺激机体产生较强的细胞免疫、体液免疫和局粘膜免疫,具有较好的保护作用。     

Induction of genital immunity by DNA priming and intranasal booster immunization with a replication-defective adenoviral recombinant.

Mice immunized through different routes such as i.m., intradermally, or intratracheally with a DNA vaccine to rabies virus developed high titers of serum Ab but only borderline levels of mucosal Abs determined from vaginal secretions. DNA vaccines given by either route enhanced vaginal IgA and IgG2a secretion upon a subsequent intranasal booster immunization with an E1-deleted adenoviral recombinant expressing the same Ag of rabies virus. DNA vaccine priming reduced the Ab response to the adenoviral Ags and counterbalanced the impaired B cell response to the rabies virus Ag expressed by the adenoviral recombinant in mice preimmune to adenovirus. The vaginal B cell response could further be enhanced by using the Th2-type cytokines IL-4 or IL-5 as genetic adjuvants concomitantly with the DNA vaccine before intranasal booster immunization with the recombinant vaccine.     

Possible influence of measles virus infection of cynomolgus monkeys on the outcome of the neurovirulence test for oral poliovirus vaccine.

Macaque monkeys are susceptible to measles infection which triggers temporary immuno-depression similar to the well known phenomenon in humans. It is known that feral monkeys become infected with measles virus when they are exposed to humans. Since Macaca mulatta and M. fascicularis are species used to assay the neurovirulence of oral poliovirus vaccine, the immunodepression caused by measles infection of the test monkeys could significantly alter the results of the neurovirulence test. The serum titers of measles-neutralizing antibodies were studied in over 1500 monkeys used for neurovirulence tests. A high proportion of the feral monkeys had measles antibodies (51-100%); in contrast, none of 493 M. fascicularis monkeys which had been bred in a primate colony under strict isolation measures was found positive for measles antibodies. An increase in the prevalence of measles in the population of Ontario and Quebec provinces was accompanied with an increase in the proportion of measles-positive monkey and their serum antibody titers were found higher. It was observed that monkeys used in tests that had been performed during high measles prevalence presented with a poliomyelitis of more pronounced severity clinically and histologically. The analysis of 29 tests conducted on type 1 vaccines over several years showed a positive correlation (correlation coefficient = 0.5141, P less than 0.0022) between severity of poliomyelitis and the presence of measles serum antibodies in test monkeys (some animals seroconverted during the test). A similar observation, when type 3 Sabin vaccines were tested in M. fascicularis, was recently reported from another laboratory in Ontario.     

Western equine encephalomyelitis vaccine produced in chick embryo cell cultures

A method was developed for production of a freeze-dried Western equine encephalomyelitis vaccine from virus propagated in chick embryo cell culture monolayers maintained with a serum-free medium. A sufficient concentration of virus accumulated in the cell culture fluids prior to the occurrence of viral cytopathology to permit the production of a vaccine relatively free from serum and cellular proteins. Inoculation with two mouse ld₅₀ doses of virus per 100 tissue culture cells was found to yield reproducible high virus titers at a convenient harvest time. These harvests were inactivated at 22 C by 0.05% formalin within 48 hr. Potency test results, as measured by the protection of immunized guinea pigs against an intracerebral virus challenge, indicated that the vaccine produced from the virus propagated in cell culture was equal in potency to a lot of whole chick embryo vaccine used to immunize laboratory and field workers subject to a high risk of infection.     

The influence of the type of immunosorbent on rabies antibody EIA; advantages of purified glycoprotein over whole virus

Two types of in vitro assay (enzyme immunoassay and sero-neutralization test) for the titration of rabies antibodies were used to assay sera from mice and humans immunized with cell culture vaccines or neural tissue vaccines. Enzyme immunoassays (EIA) were performed in plates sensitized with whole virus, purified glycoprotein or purified nucleocapsid. Neutralizing antibody titres were determined by the rapid fluorescent focus inhibition test (REFIT) and by an in vitro seroneutralization test including a rapid enzyme immunotitration of intracellular antigens (REITICA). The results obtained with sera of immunized mice and humans showed that (1) cell culture vaccines mainly induced the synthesis of antiglycoprotein neutralizing antibodies; and (2) neural tissue vaccines induced a high synthesis of antinucleocapsid non-neutralizing antibodies and a more or less important synthesis of antiglycoprotein antibodies depending on the origin of the tissue used for their preparation. Consequently, it was emphasized that when using EIA, the antibody titration must be run in glycoprotein-coated plates rather than in whole virus-coated plates to appreciate correctly the immunizing potency of a rabies vaccine, especially neural tissue vaccine.