Enhanced methane and hydrogen production from municipal solid waste and agro-industrial by-products co-digested with crude glycerol

The effects of crude glycerol on the performance of single-stage anaerobic reactors treating different types of organic waste were examined. A reactor treating the organic fraction of municipal solid waste produced 1400 mL CH₄/d before the addition of glycerol and 2094 mL CH₄/d after the addition of glycerol. An enhanced methane production rate was also observed when a 1:4 mixture of olive mill wastewater and slaughterhouse wastewater was supplemented with crude glycerol. Specifically, by adding 1% v/v crude glycerol to the feed, the methane production rate increased from 479 mL/d to 1210 mL/d. The extra glycerol-COD added to the feed did not have a negative effect on the reactor performance in either case. Supplementation of the feed with crude glycerol also had a significant positive effect on anaerobic fermentation reactors. Hydrogen yield was 26 mmole H₂/g VS added and 15 mmole H₂/g VS added in a reactor treating the organic fraction of municipal solid waste and a 1:4 mixture of olive mill and slaughterhouse wastewater. The addition of crude glycerol to the feed enhanced hydrogen yield at 2.9 mmole H₂/g glycerol added and 0.7 mmole H₂/g glycerol added.     

Comparative study of the effect of ultrasonication on the anaerobic biodegradability of food waste in single and two-stage systems

Five different mesophilic systems were evaluated in this study for the anaerobic treatment of food waste. Systems A and B were one stage methane with unsonicated and sonicated feeds, respectively, while, systems C and D were two-stage hydrogen and methane with unsonicated and sonicated feeds, respectively. System E comprised a novel sonicated biological hydrogen reactor (SBHR) followed by methane reactor. The results showed that sonication inside the reactor in the first stage (system E) showed superior results compared to all other systems. Overall VSS removal efficiencies of 67%, 59%, 51%, 44%, and 36% were achieved in systems E, D, C, B, and A, respectively. Volumetric hydrogen production rates of 4.8, 3.3, and 2.6 L H₂/L_reactor d were achieved in the SBHR, CSTR with and without sonicated feed, respectively, while, methane production rates of 1.6, 2.1, 2.3, 2.6, and 3.2 L CH₄/L_reactor d were achieved in systems A-E, respectively.     

A comparison study on the high-rate co-digestion of sewage sludge and food waste using a temperature-phased anaerobic sequencing batch reactor system

Assessing contemporary anaerobic biotechnologies requires proofs on reliable performance in terms of renewable bioenergy recovery such as methane (CH₄) production rate, CH₄ yield while removing volatile solid (VS) effectively. This study, therefore, aims to evaluate temperature-phased anaerobic sequencing batch reactor (TPASBR) system that is a promising approach for the sustainable treatment of organic fraction of municipal solid wastes (OFMSW). TPASBR system is compared with a conventional system, mesophilic two-stage anaerobic sequencing batch reactor system, which differs in operating temperature of 1st-stage. Results demonstrate that TPASBR system can obtain 44% VS removal from co-substrate of sewage sludge and food waste while producing 1.2 m³CH₄/m³_system/d (0.2 m³CH₄/kgVS_added) at organic loading rate of 6.1 gVS/L/d through the synergy of sequencing-batch operation, co-digestion, and temperature-phasing. Consequently, the rapid and balanced anaerobic metabolism at thermophilic stage makes TPASBR system to afford high organic loading rate showing superior performance on OFMSW stabilization.     

Hydrogen and methane production from desugared molasses using a two‐stage thermophilic anaerobic process

Hydrogen and methane production from desugared molasses by a two‐stage thermophilic anaerobic process was investigated in a series of two up‐flow anaerobic sludge blanket (UASB) reactors. The first reactor that was dominated with hydrogen‐producing bacteria of Thermoanaerobacterium thermosaccharolyticum and Thermoanaerobacterium aciditolerans could generate a high hydrogen production rate of 5600 mL H₂/day/L, corresponding to a yield of 132 mL H₂/g volatile solid (VS). The effluent from the hydrogen reactor was further converted to methane in the second reactor with the optimal production rate of 3380 mL CH₄/day/L, corresponding to a yield of 239 mL CH₄/g VS. Aceticlastic Methanosarcina mazei was the dominant methanogen in the methanogenesis stage. This work demonstrates that biohydrogen production can be very efficiently coupled with a subsequent step of methane production using desugared molasses. Furthermore, the mixed gas with a volumetric content of 16.5% H_2, 38.7% CO₂, and 44.8% CH₄, containing approximately 15% energy by hydrogen is viable to be bio‐hythane.     

Integrated biogas upgrading and hydrogen utilization in an anaerobic reactor containing enriched hydrogenotrophic methanogenic culture

Biogas produced by anaerobic digestion, is mainly used in a gas motor for heat and electricity production. However, after removal of CO₂, biogas can be upgraded to natural gas quality, giving more utilization possibilities, such as utilization as autogas, or distant utilization by using the existing natural gas grid. The current study presents a new biological method for biogas upgrading in a separate biogas reactor, containing enriched hydrogenotrophic methanogens and fed with biogas and hydrogen. Both mesophilic‐ and thermophilic anaerobic cultures were enriched to convert CO₂ to CH₄ by addition of H₂. Enrichment at thermophilic temperature (55°C) resulted in CO₂ and H₂ bioconversion rate of 320 mL CH₄/(gVSS h), which was more than 60% higher than that under mesophilic temperature (37°C). Different dominant species were found at mesophilic‐ and thermophilic‐enriched cultures, as revealed by PCR–DGGE. Nonetheless, they all belonged to the order Methanobacteriales, which can mediate hydrogenotrophic methanogenesis. Biogas upgrading was then tested in a thermophilic anaerobic reactor under various operation conditions. By continuous addition of hydrogen in the biogas reactor, high degree of biogas upgrading was achieved. The produced biogas had a CH₄ content, around 95% at steady‐state, at gas (mixture of biogas and hydrogen) injection rate of 6 L/(L day). The increase of gas injection rate to 12 L/(L day) resulted in the decrease of CH₄ content to around 90%. Further study showed that by decreasing the gas–liquid mass transfer by increasing the stirring speed of the mixture the CH₄ content was increased to around 95%. Finally, the CH₄ content around 90% was achieved in this study with the gas injection rate as high as 24 L/(L day). Biotechnol. Bioeng. 2012; 109: 2729–2736. © 2012 Wiley Periodicals, Inc.     

Using cheese whey for hydrogen and methane generation in a two-stage continuous process with alternative pH controlling approaches

This study focuses on the exploitation of cheese whey as a source for hydrogen and methane, in a two-stage continuous process. Mesophilic fermentative hydrogen production from undiluted cheese whey was investigated at a hydraulic retention time (HRT) of 24 h. Alkalinity addition (NaHCO₃) or an automatic pH controller were used, to maintain the pH culture at a constant value of 5.2. The hydrogen production rate was 2.9 ± 0.2 L/Lreactor/d, while the yield of hydrogen produced was approximately 0.78 ± 0.05 mol H₂/mol glucose consumed, with alkalinity addition, while the respective values when using pH control were 1.9 ± 0.1 L/Lreactor/d and 0.61 ± 0.04 mol H₂/mol glucose consumed. The corresponding yields of hydrogen produced were 2.9 L of H₂/L cheese whey and 1.9 L of H₂/L cheese whey, respectively. The effluent from the hydrogenogenic reactor was further digested to biogas in a continuous mesophilic anaerobic bioreactor. The anaerobic digester was operated at an HRT of 20d and produced approximately 1 L CH₄/d, corresponding to a yield of 6.7 L CH₄/L of influent. The chemical oxygen demand (COD) elimination reached 95.3% demonstrating that cheese whey could be efficiently used for hydrogen and methane production, in a two-stage process.     

Performance and microbial community analysis of two-stage process with extreme thermophilic hydrogen and thermophilic methane production from hydrolysate in UASB reactors

The two-stage process for extreme thermophilic hydrogen and thermophilic methane production from wheat straw hydrolysate was investigated in up-flow anaerobic sludge bed (UASB) reactors. Specific hydrogen and methane yields of 89 ml-H₂/g-VS (190 ml-H₂/g-sugars) and 307 ml-CH₄/g-VS, respectively were achieved simultaneously with the overall VS removal efficiency of 81% by operating with total hydraulic retention time (HRT) of 4 days . The energy conversion efficiency was dramatically increased from only 7.5% in the hydrogen stage to 87.5% of the potential energy from hydrolysate, corresponding to total energy of 13.4 kJ/g-VS. Dominant hydrogen-producing bacteria in the H₂-UASB reactor were Thermoanaerobacter wiegelii, Caldanaerobacter subteraneus, and Caloramator fervidus. Meanwhile, the CH₄-UASB reactor was dominated with methanogens of Methanosarcina mazei and Methanothermobacter defluvii. The results from this study suggest the two stage anaerobic process can be effectively used for energy recovery and for stabilization of hydrolysate at anaerobic conditions.     

Performance and spatial community succession of an anaerobic baffled reactor treating acetone-butanol-ethanol fermentation wastewater

An anaerobic baffled reactor with four compartments (C1-C4) was successfully used for treatment of acetone-butanol-ethanol fermentation wastewater and methane production. The chemical oxygen demand (COD) removal efficiency was 88.2% with a CH₄ yield of 0.25 L/(g COD_removed) when organic loading rate (OLR) was 5.4 kg COD m⁻³ d⁻¹. C1 played the most important role in solvents (acetone, butanol and ethanol) and COD removal. Community structure of C2 was similar to that in C1 at stage 3 with higher OLR, but was similar to those in C3 and C4 at stages 1-2 with lower OLR. This community variation in C2 was consistent with its increased role in COD and solvent removal at stage 3. During community succession from C1 to C4 at stage 3, abundance of Firmicutes (especially OTUs ABRB07 and ABRB10) and Methanoculleus decreased, while Bacteroidetes and Methanocorpusculum became dominant. Thus, ABRB07 coupled with Methanoculleus and/or acetogen (ABRB10) may be key species for solvents degradation.     

Influence of carbohydrates and proteins concentration on fermentative hydrogen production using canteen based waste under acidophilic microenvironment

Functional role of biomolecules viz., carbohydrates and proteins on acidogenic biohydrogen (H₂) production was studied through the treatment of canteen based composite food waste. The performance was evaluated in an anaerobic sequencing batch reactor (AnSBR) at pH 6 with five variable organic loading conditions (OLR1, 0.854; OLR2, 1.69; OLR3, 3.38; OLR4, 6.54 and OLR5, 9.85 kg COD/m³-day). Experimental data depicted the feasibility of H₂ production from the stabilization of food waste and was found to depend on the substrate load. Among the five loading conditions studied, OLR4 documented maximum H₂ production (69.95 mmol), while higher substrate degradation (3.99 kg COD/m³-day) was observed with OLR5. Specific hydrogen yield (SHY) vary with the removal of different biomolecules and was found to decrease with increase in the OLR. Maximum SHY was observed with hexose removal at OLR1 (139.24 mol/kg Hexose_R at 24 h), followed by pentoses (OLR1, 108.26 mol/kg Pentose_R at 48 h), proteins (OLR1, 109.71 mol/kg Protein_R at 48 h) and total carbohydrates (OLR1, 58.31 mol/kg CHO_R at 24 h). Proteins present in wastewater helped to maintain the buffering capacity but also enhanced the H₂ production by supplying readily available organic nitrogen to the consortia. Along with carbohydrates and proteins, total solids also registered good removal.     

Optimization of two-phase thermophilic anaerobic digestion of biowaste for hydrogen and methane production through reject water recirculation

The optimization of a two-phase thermophilic anaerobic process treating biowaste for hydrogen and methane production was carried out at pilot scale using two stirred reactors (CSTRs) and without any physical/chemical pre-treatment of inoculum. During the experiment the hydrogen production at low hydraulic retention time (3d) was tested, both with and without reject water recirculation and at two organic loading rate (16 and 21 kgTVS/m³d). The better yields were obtained with recirculation where the pH reached an optimal value (5.5) thanks to the buffering capacity of the recycle stream. The specific gas production of the first reactor was 51 l/kgVS_fed and H₂ content in biogas 37%. The mixture of gas obtained from the two reactors met the standards for the biohythane mix only when lower loading rate were applied to the first reactor, with a composition of 6.7% H₂, 40.1% CO₂ and 52.3% CH₄ the overall SGP being 0.78 m³/kgVS_fed.     

Effect of enzyme additions on methane production and lignin degradation of landfilled sample of municipal solid waste

Operation of waste cells as landfill bioreactors with leachate recirculation is known to accelerate waste degradation and landfill gas generation. However, waste degradation rates in landfill bioreactors decrease with time, with the accumulation of difficult to degrade materials, such as lignin-rich waste. Although, potential exists to modify the leachate quality to promote further degradation of such waste, very little information is available in literature. The objective of this study was to determine the viability of augmenting leachate with enzymes to increase the rate of degradation of lignin-rich waste materials. Among the enzymes evaluated MnP enzyme showed the best performance in terms of methane yield and substrate (lignin) utilization. Methane production of 200 mL CH₄/g VS was observed for the MnP amended reactor as compared to 5.7 mL CH₄/g VS for the control reactor. The lignin reduction in the MnP amended reactor and control reactor was 68.4% and 6.2%, respectively.     

Feeding approaches for biogas production from animal wastes and industrial effluents

Different feeding approaches were applied to a 5 l anaerobic digester in order to improve the biogas production. During operation, the reactor was fed with a mixture (9.7% w/v total solids (TS) and 7.6% w/v volatile solids (VS) in average) of pig manure with fish oil waste and waste from bentonite of edible oil filtration process, at different intervals of 24, 12 and 4 h at 15 days of hydraulic retention time. Production and quality of the biogas were practically constant at 183.7 ml (average) of biogas per gram of volatile solids available in the reactor per day, and the best biogas composition was 73.6% v/v CH₄ and 26.4% v/v CO₂.     

Impact of chlortetracycline on sequencing batch reactor performance for swine manure treatment

Treatment of aged (500 day, 4 °C stored) chlortetracycline (CTC; 0, 20, 40, 80 mg/L CTC)-amended swine manure using two cycle, 22 day stage anaerobic sequencing batch reactors (SBR) was assessed. Eighty milligrams per liter CTC treatment inhibited SBR treatment efficiencies, although total gas production was enhanced compared to the no-CTC treatment. The 20 and 40 mg/L CTC treatments resulted in either slight or no differences to SBR treatment efficiencies and microbial diversities compared to the no-CTC treatment, and were generally similar to no-CTC treatments upon completion of the first 22 day SBR cycle. All CTC treatments enhanced SBR gas generation, however CH₄ yields were lowest for the 80 mg/L CTC treatment (0.111 L CH₄/g tCOD) upon completion of the second SBR react cycle. After a 22 day acclimation period, the 80 mg/L CTC treatment inhibited methanogenesis due to acetate accumulation, and decreased microbial diversity and CH₄ yield compared to the no-CTC treatment.     

A pan‐Arctic synthesis of CH4 and CO2 production from anoxic soil incubations

Permafrost thaw can alter the soil environment through changes in soil moisture, frequently resulting in soil saturation, a shift to anaerobic decomposition, and changes in the plant community. These changes, along with thawing of previously frozen organic material, can alter the form and magnitude of greenhouse gas production from permafrost ecosystems. We synthesized existing methane (CH₄) and carbon dioxide (CO₂) production measurements from anaerobic incubations of boreal and tundra soils from the geographic permafrost region to evaluate large‐scale controls of anaerobic CO₂ and CH₄ production and compare the relative importance of landscape‐level factors (e.g., vegetation type and landscape position), soil properties (e.g., pH, depth, and soil type), and soil environmental conditions (e.g., temperature and relative water table position). We found fivefold higher maximum CH₄ production per gram soil carbon from organic soils than mineral soils. Maximum CH₄ production from soils in the active layer (ground that thaws and refreezes annually) was nearly four times that of permafrost per gram soil carbon, and CH₄ production per gram soil carbon was two times greater from sites without permafrost than sites with permafrost. Maximum CH₄ and median anaerobic CO₂ production decreased with depth, while CO₂:CH₄ production increased with depth. Maximum CH₄ production was highest in soils with herbaceous vegetation and soils that were either consistently or periodically inundated. This synthesis identifies the need to consider biome, landscape position, and vascular/moss vegetation types when modeling CH₄ production in permafrost ecosystems and suggests the need for longer‐term anaerobic incubations to fully capture CH₄ dynamics. Our results demonstrate that as climate warms in arctic and boreal regions, rates of anaerobic CO₂ and CH₄ production will increase, not only as a result of increased temperature, but also from shifts in vegetation and increased ground saturation that will accompany permafrost thaw.     

Enhanced methane production in a two-phase anaerobic digestion plant, after CO2 capture and addition to organic wastes

Cost-effective technologies are needed to reach the international greenhouse gas (GHG) reduction targets in many fields, including waste and biomass treatment. This work reports the effects of CO₂ capture from a combustion flue gas and its use in a newly-patented, two-phase anaerobic digestion (TPAD) process, to improve energy recovery and to reduce CO₂ emissions. A TPAD process, fed with urban wastewater sludge, was successfully established and maintained for several months at pilot scale. The TPAD process with injection of CO₂ exhibits efficient biomass degradation (58% VSS reduction), increased VFA production during the acidogenic phase (leading to VFA concentration of 8.4 g/L) and high biomethane production (0.350 Sm³/kg_SSV; 0.363 Sm³/m³_react·d). Moreover, CO₂ intake in the acid phase has a positive impact on the overall GHG balance associated to biomethane production, and suggests an improved solution for both emission reduction and biomass conversion into biomethane.     

Profiles of fatty acids and triacylglycerols and their influence on the anaerobic biodegradability of effluents from poultry slaughterhouse

The hydrolysis of effluent from a poultry slaughterhouse containing 800 mg oil and grease (O&G)/L was conducted with 1% (w/v) of an enzymatic pool obtained by solid-state fermentation with the fungus Penicillium restrictum. The chromatographic evaluation of the lipid profile during hydrolysis indicated a higher concentration of acids after 4 h of reaction (2954 mg/L), with a predominance of oleic, palmitic, and linoleic acids. Effluent aliquots were collected after 4, 8, and 24 h of hydrolysis and tested for anaerobic biodegradation in sequential batches. An adaptation of the biomass was observed, both in the control experiment (with non-hydrolyzed raw effluent) and in the experiments with enzymatically pre-treated effluent. The specific methane production in the control experiment was 0.248 L CH₄/g COD_consumed, and in the experiment with effluent pre-treated for 4 h, this production was 0.393 L CH₄/g COD_consumed, indicating a higher methane production after enzymatic hydrolysis.     

Experimental studies and mathematical modeling of an up-flow biofilm reactor treating mustard oil rich wastewater

Bioremediation of lipid-rich model wastewater was investigated in a packed bed biofilm reactor (anaerobic filter). A detailed study was conducted about the influence of fatty acid concentration on biomethanation of the high-fat liquid effluent of edible oil refineries. The biochemical methane potential (BMP) of the liquid waste was reported and maximum cumulative methane production at the exit of the reactor is estimated to be 785 ml CH₄ (STP)/(g VSS added). The effects of hydraulic retention time (HRT), organic loading rate (OLR) and bed porosity on the cold gas efficiency or energy efficiency of the bioconversion process were also investigated. Results revealed that the maximum cold gas efficiency of the process is 42% when the total organic load is 2.1 g COD/l at HRT of 3.33 days. Classical substrate uninhibited Monod model is used to generate the differential system equations which can predict the reactor behavior satisfactorily.     

Radiative forcing of methane fluxes offsets net carbon dioxide uptake for a tropical flooded forest

Wetlands are important sources of methane (CH₄) and sinks of carbon dioxide (CO₂). However, little is known about CH₄ and CO₂ fluxes and dynamics of seasonally flooded tropical forests of South America in relation to local carbon (C) balances and atmospheric exchange. We measured net ecosystem fluxes of CH₄ and CO₂ in the Pantanal over 2014–2017 using tower‐based eddy covariance along with C measurements in soil, biomass and water. Our data indicate that seasonally flooded tropical forests are potentially large sinks for CO₂ but strong sources of CH₄, particularly during inundation when reducing conditions in soils increase CH₄ production and limit CO₂ release. During inundation when soils were anaerobic, the flooded forest emitted 0.11 ± 0.002 g CH₄‐C m^?2 d^?1 and absorbed 1.6 ± 0.2 g CO₂‐C m^?2 d^?1 (mean ± 95% confidence interval for the entire study period). Following the recession of floodwaters, soils rapidly became aerobic and CH₄ emissions decreased significantly (0.002 ± 0.001 g CH₄‐C m^?2 d^?1) but remained a net source, while the net CO₂ flux flipped from being a net sink during anaerobic periods to acting as a source during aerobic periods. CH₄ fluxes were 50 times higher in the wet season; DOC was a minor component in the net ecosystem carbon balance. Daily fluxes of CO₂ and CH₄ were similar in all years for each season, but annual net fluxes varied primarily in relation to flood duration. While the ecosystem was a net C sink on an annual basis (absorbing 218 g C m^?2 (as CH₄‐C + CO₂‐C) in anaerobic phases and emitting 76 g C m^?2in aerobic phases), high CH₄ effluxes during the anaerobic flooded phase and modest CH₄ effluxes during the aerobic phase indicate that seasonally flooded tropical forests can be a net source of radiative forcings on an annual basis, thus acting as an amplifying feedback on global warming.     

Kinetics of CH4 production from H2 and CO2 in a hollow fiber reactor by plug flow reaction model

For microbial production of CH₄ from H₂ and CO₂, a hollow fiber reactor had been developed to increase an interfacial area between liquid and gas phases. The CH₄ production with the hollow fiber reactor was analyzed by applying a plug flow reaction model of a tubular reactor. It was possible to apply the model to the reaction of CH₄ production. The relationships between influent gas velocity, length of reactor and reaction yield were simulated by the reaction model. The plug flow reaction model was useful to design a hollow fiber bioreactor for the biomethanation of H₂ and CO₂.