Effects of various pretreatments on seed germination of<Emphasis Type="Italic">Calystegia soldanella</Emphasis> (Convolvulaceae), a coastal sand dune plant

We tested various pretreatments to enhance the germination of ‘Sea bells’ (Calystegia soldanella Roem. et Schult). One experiment, which improved the germination rate by 70%, involved first scarifying the seed coats, then immersing the seeds in 50 ppm GA₃ for 24 h. A GA₃-alone pretreatment did not increase germination. However, the most effective method, with a 100% success rate, included 3 h of acid pretreatment with 98% H₂SO₄. We also used scanning electron microscopy (SEM) to examine the seed-coat surfaces and cross-sections of dry seeds. SEM showed structural differences between seeds that were not treated and those exposed to 98% H₂SO₄. The latter treatment allowed the seed coats to crack and break, thereby disrupting their physical dormancy.     

Optimization of H2SO4-catalyzed hydrothermal pretreatment of rapeseed straw for bioconversion to ethanol: Focusing on pretreatment at high solids content

A central composite design of response surface method was used to optimize H₂SO₄-catalyzed hydrothermal pretreatment of rapeseed straw, in respect to acid concentration (0.5–2%), treatment time (5–20 min) and solid content (10–20%) at 180 °C. Enzymatic hydrolysis and fermentation were also measured to evaluate the optimal pretreatment conditions for maximizing ethanol production. The results showed that acid concentration and treatment time were more significant than solid content for optimization of xylose release and cellulose recovery. Pretreatment with 1% sulfuric acid and 20% solid content for 10 min at 180 °C was found to be the most optimal condition for pretreatment of rapeseed straw for ethanol production. After pretreatment at the optimal condition and enzymatic hydrolysis, 75.12% total xylan and 63.17% total glucan were converted to xylose and glucose, respectively. Finally, 66.79% of theoretical ethanol yielded after fermentation.     

Isolation and characterization of Desulfovibrio growing on hydrogen plus sulfate as the sole energy source

Two sulfate reducing bacteria (Madison and Marburg strains) that grew on H₂ plus sulfate in a mineral salts medium that contained acetate and CO₂ as sole carbon source were isolated from diverse environments. During growth in this medium 4.2 mol of H₂ were consumed per mol of sulfate reduced to sulfide. Acetate was required for biosynthetic purposes only. Approximately 70% of the cell carbon synthesized was derived from acetate and 30% from CO₂. Acetate was not involved in dissimilatory sulfate reduction.Growth of the bacteria on H₂ plus sulfate was linear rather than exponential, and a doubling time at the beginning of linear growth of approximately 3 h was observed. The optimal growth temperature was found to be near 35° C. Cultures could be grown up to a density of 500 mg cells (dry weight) per liter. Growth yield studies demonstrated that between 4 and 5 g of cells (dry weight) were formed per mol of sulfate reduced to sulfide.The chemolithotrophically growing sulfate reducing isolates were identified as Desulfovibrio species by being obligately anaerobic, gram negative, non spore forming vibrios that contained desulfoviridin and cytochrome c₃ (350–450 nmol/g protein). The organisms were found to be monopolarly and monotrichously flagellated. The abilities of the two strains to grow on electron donors other than H₂ and to use electron acceptors other than sulfate differed considerably. The DNA base composition of the Madison and Marburg strains were 60 and 63.5 mol % GC, respectively. The taxonomic status of the strains was discussed.     

Physical and physiological dormancy in black henbane (<Emphasis Type="Italic">Hyoscyamus niger</Emphasis> L.) seeds

Aim of this study was to investigate the nature of dormancy in black henbane (Hyoscyamus niger) seeds which have low germination rate under normal laboratory conditions. To do this, before placing the seeds in Petri dishes, they were soaked in 5,10 and 15 mg/L GA; 1,2 and 3% H₂SO₄, 15 mg/L GA + 1% H₂SO₄, 0.01 M KNO₃ solutions, tap water, 40, 50 and 60°C hot water for 30 min. The study was performed under both continuous illumination and darkness in growth chambers to evaluate the effect of light on germination rate. The results showed that H₂SO₄ and GA treatments were the most important factors affecting seed germination and their germination enhancing effects were more evident in darkness. The results also suggested that black henbane seeds exhibit double dormancy involving a hard seed coat and a partially dormant embryo and have a partial dark requirement to germinate.     

Effect of Some Environmental Pollutants on the Superoxide Dismutase Activity in Lemna

Exposure of Lemma sp. to SO₂ resulted in an increased activity of superoxide dismutase. About 3 to 4 fold increase in the activity was observed within 30 minutes after the plants were fumigated with 10 ml/l of SO₂. Paraquat, a well known superoxide generator, doubled the enzyme activity after 1 hour of treatment with 0.1 mM paraquat. Superoxide dismutase activity was also enhanced by cadmium treatment but the response was not immediate. Optimum increase in the activity of enzyme was observed after 4 days of treatment with 40 mg/l of cadmium in the medium. Treatment with H₂O₂ very clearly inhibited the activity of superoxide dismutase in Lemna.     

Catalytic effect of water,water dimer,HCOOH and H2SO4 on the isomerisation of HON(O)NNO2 to ON(OH)NNO2: a mechanism study

ABSTRACT

In this article, we report a theoretical investigation on the role of several catalysts in the isomerisation mechanisms of HON(O)NNO₂ to ON(OH)NNO₂ by theoretical method of CBS-QB3. The isomerisation reactions with catalyst X (X?=?H₂O, (H₂O)₂, HCOOH and H₂SO₄) are multi-hydrogen atom transfer reactions. Compared to the isomerisation mechanisms and rate constant of HON(O)NNO₂ to ON(OH)NNO₂ without catalysts, incorporation of the catalyst X shows different positive catalytic effects on affecting the reaction processes, with the H₂SO₄-assisted reaction being the most favourable. Such different catalytic effects are mainly related to the size of the ring structure in X-assisted transition states and the different values of pK_a and proton affinities for HCOOH and H₂SO₄. Besides, compared with the barrier height of the isomerisation process from HON(O)NNO₂ to ON(OH)NNO₂ with HN(NO₂)₂ and HON(O)NNO₂, the barrier of H₂SO₄-assisted reaction is lower by 9.3 and 4.5?kcal?·mol^?1, meanwhile, the rate constant of H₂SO₄ catalyzed is larger than water and water dimer–assisted by 3–5 and 2–3 orders of magnitude, respectively. So, H₂SO₄-assisted reaction is the most favourable.     

Corn stover pretreatment by inorganic salts and its effects on hemicellulose and cellulose degradation

Inorganic salts, NaCl, KCl, CaCl₂, MgCl₂, FeCl₂, FeSO₄, FeCl₃, and Fe₂(SO₄)₃, were studied as catalysts for the degradation of hemicellulose in corn stover. FeCl₃ significantly increased the hemicellulose degradation in aqueous solutions heated between 140 and 200 °C with high xylose recovery and low cellulose removal, amounting to 90% and <10%, respectively. Hemicellulose removal increased 11-fold when the corn stover was pretreated with 0.1 M FeCl₃ compared to pretreatment with hot water under otherwise the same conditions, which was also 6-fold greater than pretreatment with dilute sulfuric acid at the same pH. Optimum pretreatment conditions were found where the corn stover was pretreated with 0.1 M FeCl₃ at 140 °C for 20 min. Under such conditions, 91% of hemicellulose was removed, and the recovery of monomeric and oligomeric xylose in liquid fraction achieved 89%, meanwhile, only 9% of cellulose was removed.     

Stability of niosomes with encapsulated vitamin D3 and ferrous sulfate generated using a novel supercritical carbon dioxide method

Niosomes were prepared using a novel supercritical carbon dioxide based method to simultaneously encapsulate ferrous sulfate and vitamin D₃ as hydrophilic and hydrophobic cargo, respectively. Vesicle particle size was determined to be bimodal with peak diameters of 1.44?±?0.16?μm and 7.21?±?0.64?μm, with the smaller peak comprising 98.8% of the total niosomal volume. Encapsulation efficiency of ferrous sulfate was 25.1?±?0.2% and encapsulation efficiency of vitamin D₃ was 95.9?±?1.47%. Physical stability of the produced niosomes was assessed throughout a storage period of 21 days. Niosomes showed good physical stability at 20?°C, but storage at 4?°C showed an initial burst release, indicating possible rupture of the niosomal membrane. The Korsmeyer–Peppas equation was used to model the release of ferrous sulfate over time at both storage temperatures.     

模拟SO42-沉降对闽江口淡水感潮野慈姑湿地甲烷排放通量的影响

2015年12月—2016年10月,每月小潮日原位定期向闽江口塔礁洲淡水感潮野慈姑(Sagittaria trifolia L.)湿地施加剂量为60、120 kg S hm~(-2)a~(-1)的K_2SO_4溶液(分别记做S-60和S-120),探讨模拟硫酸根(SO_4~(2-))沉降对河口淡水感潮湿地甲烷(CH4)排放通量及间隙水SO_4~(2-)浓度的影响。对照、S-60和S-120处理组CH_4排放通量年均值分别为(7.88±1.00)mg h~(-1)m~(-2)、(6.55±0.97)mg h~(-1)m~(-2)和(6.66±1.49)mg h~(-1)m~(-2)。在年尺度上,两个高强度模拟SO_4~(2-)沉降处理组均未显著降低闽江口淡水感潮野慈姑湿地CH_4排放通量(P0.05),即高强度SO_4~(2-)沉降不会对河口淡水感潮湿地CH_4排放通量产生类似于其对泥炭湿地和水稻田的显著抑制效应。在年尺度以及秋、冬季,两个施加K_2SO_4溶液处理显著增加了野慈姑湿地10 cm深度土壤间隙水SO_4~(2-)浓度。对于各个处理组,温度较高的夏、秋季CH_4排放通量均显著高于温度相对较低的冬、春季(P0.05)。不同处理组CH_4排放通量均与土壤温度呈显著正相关关系,温度仍然是影响亚热带河口淡水感潮湿地CH_4排放通量的重要环境因子。     

H2 oxidation,O2 uptake and CO2 fixation in hydrogen treated soils

In many legume nodules, the H₂ produced as a byproduct of N₂ fixation diffuses out of the nodule and is consumed by the soil. To study the fate of this H₂ in soil, a H₂ treatment system was developed that provided a 300 cm³ sample of a soil:silica sand (2:1) mixture with a H₂ exposure rate (147 nmol H₂ cm^–3hr^–1) similar to that calculated exist in soils located within 1–4 cm of nodules (30–254 nmol H₂ cm^–3hr^–1). After 3 weeks of H₂ pretreatment, the treated soils had a K_m and V_max for H₂ uptake (1028 ppm and 836 nmol cm^–3 hr^–1, respectively) much greater than that of control, air-treated soil (40.2 ppm and 4.35 nmol cm^–3 hr^–1, respectively). In the H₂ treated soils, O₂, CO₂ and H₂ exchange rates were measured simultaneously in the presence of various pH₂. With increasing pH₂, a 5-fold increase was observed in O₂ uptake, and CO₂ evolution declined such that net CO₂ fixation was observed in treatments of 680 ppm H₂ or more. At the H₂ exposure rate used to pretreat the soil, 60% of the electrons from H₂ were passed to O₂, and 40% were used to support CO₂ fixation. The effect of H₂ on the energy and C metabolism of soil may account for the well-known effect of legumes in promoting soil C deposition.     

In Situ Cultivation of Subsurface Microorganisms in a Deep Mafic Sill: Implications for SLiMEs

An in situ culturing device was incubated within a flowing borehole in a mafic sill at 1.474 km depth in Evander Au mine, South Africa. The device was designed to enrich methanogenic, Fe^{3 +}-reducing and SO₄ ^{2 ?}-reducing microorganisms using acetate, formate, methanol, Fe^{3 +}-citrate and SO₄ ^{2 ?} enriched agar and sand cartridges. At the end of the 33 day incubation geochemical analyses detected elevated H₂, acetate, CH₄ and Fe concentrations and depleted SO₄ ^{2 ?} concentrations. 16S rDNA sequences and PLFA analyses revealed that the microbial community composition of the substrate-bearing cartridges were distinct from that of the original borehole water and the non-substrate-bearing control cartridge. 16S rDNA and dissimilatory sulfite reductase, dsrAB, gene sequences indicated the device successfully targeted SO₄ ^{2 ?} reducing bacteria (SRB), which were not detected in the original borehole water. 16S rDNA sequences also revealed a shift in the microbial community from one relying on H₂ based methanogenesis to one suggestive of H₂ based acetogenesis supporting aceticlastic methanogenesis and SO₄ ^{2 ?} reduction compatible with the subsurface lithoautotrophic hypothesis.     

Stomatal SO2 uptake and sulfate accumulation in needles of Norway spruce stands (Picea abies) in Central Europe

Monthly uptake rates and the annual deposition of gaseous SO₂ via the stomata of six Norway spruce canopies (Picea abies (L.) Karst.) in Germany (Königstein im Taunus, Witzenhausen, Grebenau, Frankenberg, Spessart, Fürth im Odenwald) were calculated (i) from statistical response functions of stomatal aperture depending on meteorological data, and (ii) from the synchronously measured SO₂ immission at these stands. The stomatal response functions had been derived on the basis of thorough stomatal water conductance measurements in the field. Calculations of the SO₂ conductance of spruce twigs and SO₂ uptake rates via stomata need continuously measured complete data sets of the (i) light intensity, (ii) air temperature, (iii) air humidity and (iv) SO₂ concentration in spruce forests from all the year. These data were recorded half hourly in different German spruce forests. The apparent needle water vapour pressure difference and transpiration rates were calculated from meteorological data. Additional use of canopy through flow data in dry years allowed the estimation of the mean stomatal conductance for H₂O and SO₂ of whole spruce canopies. The annual SO₂ uptake of a mean unit needle surface in spruce forests was 32% of the SO₂ uptake rate of exposed needles at the top of spruce crowns. There is significant SO₂ uptake all the year. The mean SO₂ dose at all sites and years received through the stomata was (0.25±0.07) mol SO₂ m^-2 (total needle surface) (nPa Pa^-1)^-1 (annual mean of SO₂ immission; 1 nPa (SO₂) Pa^-1 (air) = 1 ppb) day^-1 (vegetation period per year). Comparison of calculated SO₂ uptake rates into needles with measured SO₄ ^2- accumulation rates in needles from the mentioned sites and additionally from Würzburg, Schneeberg (Fichtelgebirge) and from three sites in the eastern Erzgebirge (Höckendorf, Kahleberg, Oberbärenburg) revealed that oxidative SO₂ detoxification (SO₄ ^2- formation) dominates only at sites with high SO₂ immission and short vegetation periods. Under these conditions 70 to 90% of the annual stomatal SO₂ uptake is detoxified via SO₄ ^2- accumulation in needles. Cations are needed for neutralization of accumulating SO₄ ^2- which are inavailable to support growth. Thus, SO₂ induces a dominant and competitive additional nutrient cation demand, cation deficiency symptoms and enhanced needle loss (spruce decline symptoms) mainly at sites, where the ratio R=(SO₂ immission): (length of the vegetation period) is higher than R=0.07 nPa Pa^-1 day^-1. Correlation analysis of the relative needle loss versus the SO₂-dependent SO₄ ^2- formation rate revealed a significant increase of needle loss at the 98% level (Student). At sites with small SO₂ immission and long vegetation periods (R<0.07 nPa Pa^-1 day^-1) reductive SO₂ detoxification via growth (and/or phloem export of SO₄ ^2-) is not kinetically overburdened. Under these conditions only 30% of the annual SO₂ uptake is detoxified via SO₄ ^2- formation and spruce decline is small or absent. On the basis of the critical value R0.07 nPa Pa^-1 day^-1 recommended SO₂ immission limits can be deduced on a mere ecophysiological basis. These deduced values are close to the proposed SO₂ immission limits of the IUFRO, WHO and the UNECE.     

Growth,net photosynthesis and leaf nutrient status of <Emphasis Type="Italic">Fagus crenata</Emphasis> seedlings grown in brown forest soil acidified with H<Subscript>2</Subscript>SO<Subscript>4</Subscript> or HNO<Subscript>3</Subscript> solution

To obtain basic information for evaluating critical loads of acid deposition for protecting Japanese beech forests, growth, net photosynthesis and leaf nutrient status of Fagus crenata seedlings grown for two growing seasons in brown forest soil acidified with H₂SO₄ or HNO₃ solution were investigated. The whole-plant dry mass of the seedlings grown in the soil acidified by the addition of H₂SO₄ or HNO₃ solution was significantly less than that of the seedlings grown in the control soil not supplemented with H⁺ as H₂SO₄ or HNO₃ solution. However, the degrees of reduction in the whole-plant dry mass and net photosynthetic rate of the seedlings grown in the soil acidified by the addition of H⁺ as H₂SO₄ solution at 100 mg l^–1 on the basis of air-dried soil volume (S-100 treatment) were greater than those of the seedlings grown in the soil acidified by the addition of H⁺ as HNO₃ solution at 100 mg l^–1 (N-100 treatment). The concentrations of Al and Mn in the leaves of the seedlings grown in the S-100 treatment were significantly higher than those in the N-100 treatment. A positive correlation was obtained between the molar ratio of (Ca+Mg+K)/(Al+Mn) in the soil solution and the relative whole-plant dry mass of the seedlings grown in the acidified soils to that of the seedlings grown in the control soil. Based on the results, we concluded that the negative effects of soil acidification due to sulfate deposition are greater than those of soil acidification due to nitrate deposition on growth, net photosynthesis and leaf nutrient status of F. crenata, and that the molar ratio of (Ca+Mg+K)/(Al+Mn) in soil solution is a suitable soil parameter for evaluating critical loads of acid deposition in efforts to protect F. crenata forests in Japan.     

泥炭沼泽湿地关键元素地球化学特征及其对碳排放的影响机制

硫、铁是泥炭沼泽湿地（泥炭地）中重要的生源要素,其参与下的生物地球化学过程对泥炭地碳循环意义重大。选取德国中部两处典型的雨养型泥炭地高海拔样点（TBP）和低海拔样点（TSP）,通过原位采集泥炭剖面孔隙水和可溶性气体等,研究了硫、铁元素等地球化学变化规律,结合DOC、甲烷（CH₄）和二氧化碳（CO₂）浓度分布,探讨其对泥炭地碳排放的影响。研究结果表明：（1） TBP中总还原无机硫（TRIS）浓度随深度先增后减,且上部0-87 cm平均浓度远高于87 cm深度以下,上部硫酸盐还原作用强烈。结合上部亚铁、硫化氢（H₂S）浓度分布,得知该范围内H₂S主要是通过微生物硫酸盐还原作用（BSR）生成,同时H₂S在孔隙水扩散过程中易与亚铁结合为硫化亚铁,进而生成稳定的黄铁矿,这一反应过程在约60 cm处减缓。（2） TBP、TSP两处采样点中DOC与亚铁、硫酸盐均有较强相关性,是由于地下水位的波动影响氧化还原程度以及微生物活性。两处采样点DOC均与亚铁呈显著正相关关系,表明铁氧化物在厌氧环境中被还原溶解产生亚铁,与其结合的有机碳被释放到溶液中从而导致DOC浓度的升高。TBP中DOC与硫酸盐呈显著负相关关系,表明硫酸盐作为电子受体被还原的过程中消耗酸度使pH值升高,增强了其中微生物的活性,DOC浓度由此增加。（3） CH₄与硫酸盐、TRIS浓度在剖面上均呈现相反变化趋势,表明硫酸盐输入的增加以及硫酸盐还原活动均会抑制CH₄生成。CO₂/CH₄均大于4,表明硫酸盐作为替代电子受体会使厌氧条件下碳矿化转向多CO₂和少CH₄生成。此外,亚铁对于CH₄生成一定程度上会起到低促高抑的效果,而对于CO₂的生成的影响较弱。表明硫酸盐对于CH₄和CO₂生成的影响高于亚铁。研究着重探究硫、铁等关键元素地下部生物地球化学过程对碳排放的影响机制,研究结果可为泥炭地碳排放核算提供理论支撑。     

Growth yields and growth rates of Desulfovibrio vulgaris (Marburg) growing on hydrogen plus sulfate and hydrogen plus thiosulfate as the sole energy sources

Desulfovibrio vulgaris (Marburg) was grown on H₂ plus sulfate and H₂ plus thiosulfate as the sole energy sources and acetate plus CO₂ as the sole carbon sources. Conditions are described under which the bacteria grew exponentially. Specific growth rates () and molar growth yields (Y) at different pH were determined. and Y were found to be strongly dependent on the pH. Highest growth rates and molar growth yields were observed for growth on H₂ plus sulfate at pH 6.5 (=0.15h^-1; Y _{SO 4} ^2- =8.3g·mol^-1) and for growth on H₂ plus thiosulfate at pH 6.8 (=0.21h^-1; Y _{S 2}O ₃ ² =16.9g·mol^-1).The growth yields were found to increase with increasing growth rates: plots of 1/Y versus 1/ were linear. Via extrapolation to infinite growth rates a Y _SO4 ^2- /max of 12.2g·mol^-1 and a YS₂O ₃ ^2- /max of 33.5g·mol^-1 was obtained.The growth yield data are interpred to indicate that dissimilatory sulfate reduction to sulfide is associated with a net synthesis of 1 mol of ATP and that near to 3 mol of ATP are formed during dissimilatory sulfite reduction to sulfide.     

Netuptake of sulphate and its transport to the shoot in tobacco plants fumigated with H2S or SO2

In tobacco plants the net uptake of sulphate and its transport to the shoot were determined after cultivation with low, normal, and high sulphate supply. The relative amount of the sulphate taken up that was transported to the shoot was used as a measure of xylem loading. Net uptake of sulphate and its transport to the shoot were low in tobacco plants grown with low sulphate, and high in plants cultivated with high sulphate. Xylem loading, however, was relatively low in tobacco plants grown with high sulphate and relatively high in tobacco plants grown with low sulphate supply. Pre-culture in low sulphate containing nutrient solution also resulted in a high proportion of the absorbed sulphate being transported into the xylem if normal sulphateconcentration was supplied afterwards. Fumigation with H₂S or SO₂ reduced net uptake of sulphate in tobacco plants grown with normal, but not with high sulphate supply. Sulphate transport to the shoots was diminished by H₂S or SO₂ fumigation in tobacco plants grown with normal and high sulphate supply. Also the relative amount of the sulphate taken up that was transported to the shoot was lowered by fumigation with H₂S or SO₂ in tobacco plants grown with normal sulphate supply. Apparently, the diminished sulphate transport to the shoot upon H₂S or SO₂ fumigation can only partially be explained by a smaller sulphate uptake. Sulphur nutrition of tobacco plants also seems to be controlled by xylem loading of sulphate. The possible role of glutathione as a signal regulating sulphur nutrition of tobacco plants upon fumigation with H₂S and SO₂ is discussed.     

Concise synthesis of two trisaccharides related to the cytotoxic triterpenoid saponin isolated from Pithecellobium lucidum

Convergent synthesis of two trisaccharides related to the cytotoxic triterpenoid saponin isolated from Pithecellobium lucidum is reported. The trisaccharides are synthesized in the form of their propargyl glycosides to leave the scope for further glycoconjugate formation through various multi-component reactions. A simple protecting group manipulation is followed using commercially available monosaccharides, d-glucose, d-xylose, d-fucose and l-rhamnose. H₂SO₄ immobilized on silica is used as the Brönsted acid source for the N-iodosuccinimide-mediated thioglycoside activation for stereoselective glycosylations and proved to be a better choice over traditional Lewis acid catalysts such as TMSOTf and TfOH.     

Effect of sodium sulfate on in vitro organogenesis of tobacco callus

Callus of tobacco (Nicotiana tabacum L. cv. Wisconsin 38) was grown on callus-proliferating (CP) and shoot-forming (SF) media with elevated sodium sulfate (Na₂SO₄) concentrations either in the light or dark for more than one year. An increase in Na₂SO₄ concentration resulted in a decrease in callus growth index, an increase in percent dry weight of callus tissues grown on both media, and a decrease in both number of calli forming shoots and number of shoots per callus in SF medium. The CP callus grown in the light spontaneously began to form shoots after the 5th monthly transfer, and spontaneous root formation occured after the 16th transfer in the presence of 0.75 and 1.0% Na₂SO₄. Both water () and osmotic (_s) potentials of the callus increased with increasing Na₂SO₄ concentration; and callus exhibited greater and _s in the light than dark for both CP and SF media.     

Effect of dilute acid pretreatment on the saccharification and fermentation of rye straw

This research shows the effect of dilute acid pretreatment with various sulfuric acid concentrations (0.5–2.0% [wt/vol]) on enzymatic saccharification and fermentation yield of rye straw. After pretreatment, solids of rye straw were suspended in Na citrate buffer or post-pretreatment liquids (prehydrolysates) containing sugars liberated after hemicellulose hydrolysis. Saccharification was conducted using enzymes dosage of 15 or 25 FPU/g cellulose. Cellulose saccharification rate after rye straw pretreatment was enhanced by performing enzymatic hydrolysis in sodium citrate buffer in comparison with hemicellulose prehydrolysate. The maximum cellulose saccharification rate (69%) was reached in sodium citrate buffer (biomass pretreated with 2.0% [wt/vol] H₂SO₄). Lignocellulosic complex of rye straw after pretreatment was subjected to separate hydrolysis and fermentation (SHF) or separate hydrolysis and co-fermentation (SHCF). The SHF processes conducted in the sodium citrate buffer using monoculture of Saccharomyces cerevisiae (Ethanol Red) were more efficient compared to hemicellulose prehydrolysate in respect with ethanol yields. Maximum fermentation efficiency of SHF processes obtained after rye straw pretreatment at 1.5% [wt/vol] H₂SO₄ and saccharification using enzymes dosage of 25 FPU/g in sodium citrate buffer, achieving 40.6% of theoretical yield. However, SHCF process using cocultures of pentose-fermenting yeast, after pretreatment of raw material at 1.5% [wt/vol] H₂SO₄ and hydrolysis using enzymes dosage of 25 FPU/g, resulted in the highest ethanol yield among studied methods, achieving 9.4 g/L of ethanol, corresponding to 55% of theoretical yield.     

Production of bio-fuel ethanol from distilled grain waste eluted from Chinese spirit making process

Distilled grain waste eluted from Chinese spirit making is rich in carbohydrates, and could potentially serve as feedstock for the production of bio-fuel ethanol. Our study evaluated two types of saccharification methods that convert distilled grain waste to monosaccharides: enzymatic saccharification and concentrated H₂SO₄ saccharification. Results showed that enzymatic saccharification performed unsatisfactorily because of inefficient removal of lignin during pretreatment. Concentrated H₂SO₄ saccharification led to a total sugar recovery efficiency of 79.0 %, and to considerably higher sugar concentrations than enzymatic saccharification. The process of ethanol production from distilled grain waste based on concentrated H₂SO₄ saccharification was then studied. The process mainly consisted of concentrated H₂SO₄ saccharification, solid–liquid separation, decoloration, sugar–acid separation, oligosaccharide hydrolysis, and continuous ethanol fermentation. An improved simulated moving bed system was employed to separate sugars from acid after concentrated H₂SO₄ saccharification, by which 95.8 % of glucose and 85.8 % of xylose went into the sugar-rich fraction, while 83.3 % of H₂SO₄ went into the acid-rich fraction. A flocculating yeast strain, Saccharomyces cerevisiae KF-7, was used for continuous ethanol fermentation, which produced an ethanol yield of 91.9–98.9 %, based on glucose concentration.