Comparative enzymatic hydrolysis of pretreated spruce by supernatants, whole fermentation broths and washed mycelia of Trichoderma reesei and Trichoderma atroviride

Cellulase and beta-glucosidase production on steam pretreated spruce (SPS) with Trichoderma reesei Rut C30, Trichoderma atroviride TUB F-1505 and TUB F-1663 was investigated. The enzymes were compared in term of activity, temperature optima and hydrolytic capacity. The T. atroviride cellulases proved to have lower temperature optima for filter paper activity (FPA) assay (50 degrees C) and for hydrolysis of SPS (40 degrees C) than the Rut C30 enzymes (60 degrees C for FPA and 50 degrees C for hydrolysis). Due to high levels of extracellular beta-glucosidases, the T. atroviride enzyme supernatants hydrolyzed the washed SPS to glucose more efficiently than the enzymes produced by T. reesei. On the other hand, when the whole fermentation broths were used instead of the supernatants, thus the mycelium bound enzymes were also present, the hydrolytic capacity of T. reesei Rut C30 was enhanced by approximately 200%, while an improvement of only 15% was observed in case of the T. atroviride isolates.     

青蒿内生真菌分离、分子鉴定及深绿木霉对青蒿的促生作用研究

为从青蒿(Artemisia annua L.)内生真菌中筛选有促生作用的菌株,用组织分离法从青蒿侧枝中分离内生真菌并进行分子鉴定,对其中1株真菌深绿木霉对青蒿幼苗的促生作用进行了研究。结果表明,从青蒿侧枝中获得23株内生真菌,鉴定出16种,以炭疽菌属占优势。深绿木霉发酵液对青蒿种子发芽和幼苗生长具有显著抑制作用;深绿木霉液体发酵菌丝体在4-5月对青蒿幼苗生长具有显著的促进作用,但7月以后没有明显促进作用。因此,深绿木霉可作为青蒿苗肥,与化肥配合可施用于成株。     

Generation and identification of DNA sequence flanking T-DNA integration site of Trichoderma atroviride mutants with high dichlorvos-degrading capacity

A protocol for efficient Agrobacterium tumefaciens-mediated transformation (ATMT) of biocontrol fungus Trichoderma atroviride strain T23 was developed to construct mutants with improved dichlorvos-degradation ability. A transformation frequency of 5 × 10⁻⁶ was achieved. Among 110 genetically stable T-DNA transformants of T. atroviride T23, two transformants, AMT-12 and AMT-28, confirmed by Southern blot analysis to have single-copy inserts of T-DNA, showed an increase in dichlorvos-degradation ability of more than 10% compared to that of the wild type, exhibited similar tolerance to the pesticide, but lower spore formation ability. Five transformants exhibited a reduction in degradation of more than 70%, exhibited wild-type spore formation, and tolerated up to 800 μg/mL of dichlorvos. The left-flanking sequence of the insertion site in AMT-12 was cloned as a 1845-bp fragment and shown to have 89% identity to the DNA from T. atroviride IMI 206040; however, the involvement of this DNA in dichlorvos degradation remains still to be determined. This study can promote both a more efficient isolation of DNA sequence flanking T-DNA integration site in T. atroviride mutants and a more rational utilization of these transformants in dichlorvos degradation.     

Simultaneous saccharification and fermentation of cellulose: effect of β- -glucosidase activity and ethanol inhibition of cellulases

Compared with saccharification in the absence of yeast, simultaneous saccharification and fermentation (SSF) using Trichoderma cellulases and Saccharomyces cerevisiae enhanced cellulose hydrolysis rates by 13–30%. The optimum temperature for SSF was 35°C. The requirement for β- -glucosidase (β- -glucoside glucohydrolase, EC 3.2.1.21) in SSF was lower than for saccharification: maximal ethanol production was attained when the ratio of the activity of β- -glucosidase to filter paper activity was 1.0. Ethanol inhibited cellulases uncompetitively, with an inhibition constant of 30.5 gl ⁻¹, but its effect was less severe than that of an equivalent concentration of cellobiose or glucose. No irreversible denaturation of cellulases [1,4-(1,3;1,4)-β- -glucan 4-glucanohydrolase, EC 3.2.1.4] by ethanol was observed.     

Effect of culture medium composition on Trichoderma reesei’s morphology and cellulase production

The objective of this study was to determine how fungal morphology influences the volumetric cellulase productivity of Trichoderma reesei cultured in four media with lactose and lactobionic acid as fed-batch in a 7 L stirred tank bioreactor. The use of a cellulose–yeast extract culture medium yielded the highest enzyme production with a volumetric enzyme activity of 69.8 U L⁻¹ h⁻¹, and a maximum fungal biomass of 14.7 g L⁻¹. These findings were associated with the following morphological characteristics of the fungus: total mycelia was 98% of total mean projected area, mean hyphae length of 10 mm, mean hyphae volume of 45.1 mm³, mean hyphae diameter of 7.9 μm, number of branches 9, and number of tips per hypha 29. A positive correlation was found between the total mycelia, the number of tips and the volumetric enzyme productivity, indicating the weight of these variables on the enzyme productivity.     

Degradation of low rank coal by Trichoderma atroviride ES11

A new isolate of Trichoderma atroviride has been shown to grow on low rank coal as the sole carbon source. T. atroviride ES11 degrades ∼82% of particulate coal (10 g l⁻¹) over a period of 21 days with 50% reduction in 6 days. Glucose (5 g l⁻¹) as a supplemented carbon source enhanced the coal solubilisation efficiency of T. atroviride ES11, while 10 and 20 g l⁻¹ glucose decrease coal solubilisation efficiency. Addition of nitrogen [1 g l⁻¹ (NH₄)₂SO₄] to the medium also increased the coal solubilisation efficiency of T. atroviride ES11. Assay results from coal-free and coal-supplemented cultures suggested that several intracellular enzymes are possibly involved in coal depolymerisation processes some of which are constitutive (phenol hydroxylase) and others that were activated or induced in the presence of coal (2,3-dihydrobiphenyl-2,3-diol dehydrogenase, 3,4-dihydro phenanthrene-3,4-diol dehydrogenase, 1,2-dihydro-1,2-dihydroxynaphthalene dehydrogenase, 1,2-dihydro-1,2-dihydroxyanthracene dehydrogenase). GC-MS analysis of chloroform extracts obtained from coal degrading T. atroviride ES11 cultures showed the formation of only a limited number of specific compounds (4-hydroxyphenylethanol, 1,2-benzenediol, 2-octenoic acid), strongly suggesting that the intimate association between coal particles and fungal mycelia results in rapid and near-quantitative transfer of coal depolymerisation products into the cell. An erratum to this article can be found at     

里氏木霉翻转酶DRS2对木质纤维素降解酶基因表达及分泌的影响

[目的]本研究以工业生产菌株里氏木霉为研究对象,鉴定翻转酶基因drs2对其纤维素酶表达及分泌的影响.[方法]首先通过BLAST序列比对,从里氏木霉中鉴定出翻转酶基因drs2,并通过同源重组的方法在里氏木霉中构建了drs2基因的敲除菌株△drs2.对△drs2菌株及其对照株在不同碳源上的生长发育、蛋白分泌、纤维素酶及半纤...     

多靶向沉默里氏木霉碳代谢阻遏物对纤维素酶活性和表达的调控研究

【目的】构建多靶向siRNA表达载体对里氏木霉碳阻遏抑制因子CRE1、CRE2、CRE3和CRE4进行同时多靶向siRNA干扰,以研究其对里氏木霉纤维素酶基因表达的调控作用。【方法】根据此前研究筛选出沉默cre1、cre2、cre3和cre4基因的4个最佳siRNA序列,设计并构建了A多靶向表达载体,另根据cre1、cre2、cre3和cre4基因中所含有的5个共有序列设计并构建了B多靶向表达载体,将两者转化至里氏木霉QM9414。经筛选后分别在48 h和120 h对各转化子进行纤维素酶酶活力测试(CMC活力测试和滤纸酶酶活力测试)及利用qPCR检测相关基因的表达。【结果】通过RT-qPCR测定结果表明,两种表达载体均可同时抑制里氏木霉的分解代谢物阻遏基因cre1、cre2、cre3和cre4的表达,纤维素酶活力比出发菌株明显升高,多靶向抑制菌株的CMC酶活和滤纸酶活比出发菌株平均提高了1.95倍和2.66倍。纤维素酶基因cbh1和egl1的表达水平比出发菌株也有明显提升,平均提高了3.83倍和3.95倍。纤维素酶相关基因xyr1的表达水平与出发菌株相比也明显上升,平均提高了2.78倍。【结论】多靶向沉默里氏木霉的碳代谢阻遏蛋白有利于解除葡萄糖效应,提高非还原糖的利用,从而提高纤维素酶的产量,使纤维素酶的表达得到更大的提升,为里氏木霉表达纤维素酶在分解代谢物阻遏基因调控方面提供了实验依据和新的技术思路。     

Biocontrol of Sclerotinia lettuce drop by Coniothyrium minitans and Trichoderma hamatum

Fungal isolates, with known activity against Sclerotinia spp. in laboratory assays, were tested for their ability to control Sclerotinia minor in four field experiments (1998–2000). In the first experiment, eight fungal isolates (Trichoderma hamatum LU595, LU593, LU592, Trichoderma virens LU555 and LU556, Coniothyrium minitans LU112, Clonostachys rosea LU115 and Trichoderma rossicum LU596) were evaluated by incorporating spore suspensions into transplant potting mix and planting lettuce seedlings into a S. minor infested field site. At harvest, Trichoderma hamatum LU595, LU593, T. virens LU555 and C. minitans LU112 reduced disease by 30–50% compared with the untreated control under very high disease pressure (100%). In further field experiments C. minitans LU112 and T. hamatum LU593, applied as maizemeal–perlite soil amendments or incorporated into the potting mix, reduced S. minor disease over a range of disease pressures (29–91%). Disease control was equivalent or greater than that achieved with the standard carbendazim fungicide treatment. Both isolates were shown to effectively colonize the lettuce rhizosphere and surrounding soil and this colonization may have protected the roots from infection by S. minor. Multiple applications of C. minitans LU112 or T. hamatum LU593 formulations gave no added disease control compared with a single application at planting. Commercial formulations of both C. minitans LU112 and T. hamatum LU593 applied as transplant treatments, solid substrate soil amendments or as a spore drench gave consistent disease control and are currently being developed further.     

Saccharification of Kans grass using enzyme mixture from Trichoderma reesei for bioethanol production

Bioethanol is one of the alternatives of the conventional fossil fuel. In present study, effect of different carbon sources on the production of cellulolytic enzyme (CMCase) from Trichoderma reesei at different temperatures, duration and pH were investigated and conditions were optimized. Acid treated Kans grass (Saccharum sponteneum) was subjected to enzymatic hydrolysis to produce fermentable sugars which was then fermented to bioethanol using Saccharomyces cerevisiae. The maximum CMCase production was found to be 1.46 U mL⁻¹ at optimum condition (28 °C, pH 5 and cellulose as carbon source). The cellulases and xylanase activity were found to be 1.12 FPU g⁻¹ and 6.63 U mL⁻¹, respectively. Maximum total sugar was found to be 69.08 mg/g dry biomass with 20 FPU g⁻¹ dry biomass of enzyme dosage under optimum condition. Similar results were obtained when it was treated with pure enzyme. Upon fermentation of enzymatic hydrolysate, the yield of ethanol was calculated to be 0.46 g g⁻¹.     

Standardization of the filter paper activity assay for solid substrate fermentation

The conditions of the filter paper activity (FPA) assay were standardized for solid substrate fermentation (SSF). The FPA is a relative measure of the overall cellulose hydrolysing capacity of microbial cellulase preparations, thus reliable and comparable data may be obtained only under standardized conditions. The standardization developed for submerged fermentation (SF) cannot be translated directly to SSF. In SSF, the FPA is strongly dependent on the extraction volume and on the dilution of the enzyme in the assay. The optimal extraction volume was substrate dependent in SSF of corn fiber, spent brewing grains and wheat straw for cellulase production by Trichoderma reesei Rut C30. Other cellulolytic enzyme assays (endoglucanase, beta-glucosidase and xylanase) were much less sensitive to the extraction volume.     

Optimization of cellulase production in batch fermentation byTrichoderma reesei

Maximum cellulase production was sought by comparing the activities of the cellulases produced by differentTrichoderma reesei strains andAspergillus niger. Trichoderma reesei Rut-C30 showed higher cellulase activity than otherTrichoderma reesei strains andAspergillus niger that was isolated from soil. By optimizing the cultivation condition during shake flask culture, higher cellulase production could be achieved. The FP (filter paper) activity of 3.7 U/ml and CMCase (Carboxymethylcellulase) activity of 60 U/ml were obtained from shake flask culture. When it was grown in 2.5L fermentor, where pH and DO levels are controlled, the Enzyme activities were 133.35 U/ml (CMCase) and 11.67 U./ml (FP), respectively. Ammonium sulfate precipitation method was used to recover enzymes from fermentation broth. The dried cellulase powder showed 3074.9 U/g of CMCase activity and 166.7 U/g of FP activity with 83.5% CMCase recovery.     

Rapid purification method for the 26S proteasome from the filamentous fungus Trichoderma reesei

We have developed a fast and simple two column chromatographic method for the purification of the 26S proteasome from the filamentous fungus Trichoderma reesei that simplifies the overall procedure and reduces the purification time from 5 to 2.5 days. The combination of only the anionic exchange POROS^® HQ column (Applied Biosystems) together with a size exclusion column has not been used previously for proteasome purification. The purified complex was analysed further by two-dimensional electrophoresis (2DE) and examined by transmission electron microscopy (TEM). A total of 102 spots separated by 2DE were identified by mass spectrometry using cross-species identification (CSI) or an in-house custom-made protein database derived from the T. reesei sequencing project. Fifty-one spots out of 102 represented unique proteins. Among them, 30 were from the 20S particle and eight were from the 19S particle. In addition, seven proteasome-interacting proteins as well as several non-proteasome related proteins were identified. Co-purification of the 19S regulatory particle was confirmed by TEM and Western blotting. The rapidity of the purification procedure and largely intact nature of the complex suggest that similar procedure may be applicable to the isolation and purification of the other protein complexes.     

Action of acetylxylan esterase from Trichoderma reesei on acetylated methyl glycosides

Substrate specificity of purified acetylxylan esterase (AcXE) from Trichoderma reesei was investigated on partially and fully acetylated methyl glycopyranosides. Methyl 2,3,4-tri-O-acetyl-β-

Full-size image

-xylopyranoside was deacetylated at positions 2 and 3, yielding methyl 4-O-acetyl-β-

Full-size image

-xylopyranoside in almost 90% yield. Methyl 2,3-di-O-acetyl β-

Full-size image

-xylopyranoside was deacetylated at a rate similar to the fully acetylated derivative. The other two diacetates (2,4- and 3,4-), which have a free hydroxyl group at either position 3 or 2, were deacetylated one order of magnitude more rapidly. Thus the second acetyl group is rapidly released from position 3 or 2 after the first acetyl group is removed from position 2 or 3. The results strongly imply that in degradation of partially acetylated β-1,4-linked xylans, the enzyme deacetylates monoacetylated xylopyranosyl residues more readily than di-O-acetylated residues. The T. reesei AcXE attacked acetylated methyl β-

Full-size image

-glucopyranosides and β-

Full-size image

-mannopyranosides in a manner similar to the xylopyranosides.     

Further support for fed-batch production of gellulases

Summary New data for the fed-batch production of cellulases usingTrichoderma reesei Rut. C-30 give additional motivation for this mode of culture as a result of simultaneously high enzyme titres (31 IU FPA/mL), productivities (160 IU FPA L^–1 h^–1) and yields (477 IU FPA/g cellulose). These results also indicate a strong potential for even further improvements through the optimization of feeding policies.     

Production of cellulases in batch culture using a mutant strain of Trichoderma reesei growing on soluble carbon source

Trichoderma reesei Rut-C30 is a highly derepressed mutant which synthesised active cellulases in culture media containing glucose and lactose as the only carbon sources. The maximum biomass, filter paper and specific filter paper activities for cell growth on 20 g glucose l^–1 were 20 g dry cell wt l^–1, 1.9 FPU ml^–1 and 4.8 FPU mg^–1 protein respectively, while on 40 g glucose l^–1 were 25 g dry cell wt l^–1, 4.5 FPU ml^–1 and 6.2 FPU mg^–1 protein, respectively. This strain had a higher specific filter paper activity (6.2 FPU mg^–1 protein) than was produced by other T. reesei mutants (3.6 FPU mg^–1 protein).     

In vitro evaluation of combination of Trichoderma harzianum and chitosan for the control of sapstain fungi

In vitro assays were undertaken to evaluate the control of two sapstain fungi, Leptographium procerum and Sphaeropsis sapinea by a combination of chitosan or chitosan oligomer and an albino strain of Trichoderma harzianum. Spore germination and hyphal growth of the test fungi were assessed on media amended with chitosan or chitosan oligomer with and without T. harzianum using either simultaneous inoculation with test fungus or inoculation 1, 2, or 3 days after pre-infection with test fungus.There was no mycelial growth of the test fungi regardless of chitosan concentrations used when either L. procerum or S. sapinea was simultaneously inoculated with T. harzianum. However, the dose–response of chitosan or chitosan oligomer on the test fungi was apparent when T. harzianum was not simultaneously inoculated with test fungus but introduced later. There was a greater growth reduction at higher concentrations (0.075–0.1% v/v) of chitosan, and overall chitosan oligomer was more effective than chitosan aqueous solution.Chitosan alone was able to restrict or delay the germination of spores but the combination of chitosan and T. harzianum inhibited spore germination and hence colony formation of test fungi regardless of time delay.     

Cloning, sequencing and enhanced expression of the Trichoderma reesei endoxylanase II (pI 9) gene xln2

The Trichoderma reesei xln2 gene coding for the pI 9.0 endoxylanase was isolated from the wild-type strain QM6a. The gene contains one intron of 108 nucleotides and codes for a protein of 223 amino acids in which two putative N-glycosylation target sites were found. Three different T. reesei strains were transformed by targeting a construct composed of the xln2 gene, including its promoter, to the endogenous cbh1 locus. Highest overall production levels of xylanase were obtained using T. reesei ALK02721, a genetically engineered strain, as a host. Integration into the cbh1 locus was not required for enhanced expression under control of the xln2 promoter.     

Induced proteome of Trichoderma harzianum by Botrytis cinerea

As a notable biocontrol agent, Trichoderma harzianum can antagonize a diverse array of phytopathogenic fungi, including Botrytis cinerea, Rhizoctonia solani and Fusarium oxysporum. Elucidating the biocontrol mechanism of T. harzianum in response to the pathogens enables it to be exploited in the control of plant diseases. Two-dimensional gel electrophoresis (2-DE) was performed to obtain secreted protein patterns of T. harzianum ETS 323, grown in media that contained glucose, a mixture of glucose and deactivated B. cinerea mycelia, deactivated B. cinerea mycelia or deactivated T. harzianum mycelia. Selected protein spots were identified using liquid chromatography–tandem mass spectrometry (LC–MS/MS). Ninety one out of 100 excised protein spots were analyzed and some proteins were sequence identified. Of these, one l-amino acid oxidase (LAAO) and two endochitinases were uniquely induced in the media that contained deactivated B. cinerea mycelia as the sole carbon source. Activities of the cell wall-degrading enzymes (CWDEs), including β-1,3-glucanases, β-1,6-glucanases, chitinases, proteases and xylanases, were significantly higher in media with deactivated B. cinerea mycelia than in other media. This finding suggests that the cell wall of B. cinerea is indeed the primary target of T. harzianum ETS 323 in the biocontrol mechanism. The possible roles of LAAO and xylanase were also discussed.     

Growth of Trichoderma reesei RUT C-30 in stirred tank and reciprocating plate bioreactors

A series of fed-batch experiments at different agitation speeds were performed using the industrially important strain Trichoderma reesei RUT C-30 in two different bioreactors to understand the close relationship that exists between the shear field within a bioreactor, the morphology of the microorganism, the rheology of cultivation broth, and the process performance. The two bioreactors, stirred tank bioreactor (STB) and reciprocating plate bioreactor (RPB), are characterized by a significantly different shear field to which microorganisms are exposed. Highest biomass concentration (ca. 15 g l⁻¹) was obtained at higher agitation rates in both bioreactors due to better oxygen supply. However, better filter paper activities per mg of protein were obtained at lower agitation in both bioreactors. In both bioreactors, young and healthier fungi in the batch phase were not affected by shear even at higher agitation rates. However, during the fed-batch phase, higher degree of fragmentation of clump morphology at high agitation intensity was confirmed by image analysis. Also, the rheological analysis showed an increase in apparent viscosity during the batch phase and early fed-batch phase due to the increase in the biomass concentration. During the late stages of cultivation, the apparent viscosity decreased due to cell lysis and spore formation.