Development of image analysis techniques as a tool to detect and quantify morphological changes in anaerobic sludge: II. Application to a granule deterioration process triggered by contact with oleic acid

Image analysis techniques are applied to monitor the morphological changes in granular sludge present in an expanded granular sludge blanket (EGSB) reactor fed with oleic acid. Deterioration of granular sludge was monitored along the trial period by measuring the percentage of aggregates smaller than 1 mm (in terms of Feret diameter) either in terms of projected area or in terms of number of aggregates. A good correlation was obtained between these values and the percentage of aggregates smaller than 1 mm were physically sorted and quantified by the volatile suspended solid content. The ratio of total filaments length to cross-sectional area of aggregates defined as LfA, was applied to quantify the dispersion level of the granular sludge, which increased until day 141 and remained almost invariant afterwards. LfA was sensitive to the sludge deterioration process and was able to indicate, with the anticipation of about 1 month, the most significant biomass washout episode that occurred in the trial period. A mechanism of filaments' release, detachment and selective washout was proposed to explain the action of LfA from this viewpoint. The equivalent diameter of the bottom aggregates larger than 1 mm increased with the increase on the amount of long chain fatty acids associated with the biomass by mechanisms of adsorption, precipitation, or entrapment. After a threshold value of about 200 mg COD-LCFA gVSS (COD = chemical oxygen demand; LCFA = long chain fatty acids; VSS = volatile suspended solids), a migration of granular sludge from the bottom to a top-floating layer was evident.     

Advanced monitoring of high-rate anaerobic reactors through quantitative image analysis of granular sludge and multivariate statistical analysis

Four organic loading disturbances were performed in lab-scale EGSB reactors fed with ethanol. In load disturbance 1 (LD1) and 2 (LD2), the organic loading rate (OLR) was increased between 5 and 18.5 kg COD m(-3) day(-1), through the influent ethanol concentration increase, and the hydraulic retention time decrease from 7.8 to 2.5 h, respectively. Load disturbances 3 (LD3) and 4 (LD4) were applied by increasing the OLR to 50 kg COD m(-3) day(-1) during 3 days and 16 days, respectively. The granular sludge morphology was quantified by image analysis and was related to the reactor performance, including effluent volatile suspended solids, indicator of washout events. In general, it was observed the selective washout of filamentous forms associated to granules erosion/fragmentation and to a decrease in the specific acetoclastic activity. These phenomena induced the transitory deterioration of reactor performance in LD2, LD3, and LD4, but not in LD1. Extending the exposure time in LD4 promoted acetogenesis inhibition after 144 h. The application of Principal Components Analysis determined a latent variable that encompasses a weighted sum of performance, physiological and morphological information. This new variable was highly sensitive to reactor efficiency deterioration, enclosing variations between 27% and 268% in the first hours of disturbances. The high loadings raised by image analysis parameters, especially filaments length per aggregates area (LfA), revealed that morphological changes of granular sludge, should be considered to monitor and control load disturbances in high rate anaerobic (granular) sludge bed digesters.     

Quantitative image analysis as a diagnostic tool for monitoring structural changes of anaerobic granular sludge during detergent shock loads

Two shock loads of a commercial detergent (I-150 mg chemical oxygen demand (COD)/L, fed for 56 h; II-300 mg COD/L fed for 222 h) were applied in a lab-scale Expanded Granular Sludge Blanket (EGSB) reactor, fed with 1,500 mg COD/L of ethanol. The impact of the surfactant was assessed in terms of granular sludge morphology, specific methanogenic activity (SMA) in the presence of individual substrates, and reactor performance. COD removal efficiency remained unaffected in the shock I, but 80 h after starting exposure to the shock II, the COD removal efficiency decreased drastically from 75 to 17%. In the first 8 h of operation of shock I, the SMA was stimulated and decreased afterwards, being recovered 5 days after the end of exposure time. Concerning to shock II, the SMA was immediately and persistently reduced during the exposure time, although, the inhibition of SMA in presence of H(2)/CO(2) showed a trend to increase after the exposure time. Acetoclastic bacteria were observed as the most sensitive to the toxic effects of surfactant whereas the hydrogenotrophic bacteria were less affected. The inhibitory effects were dependent on surfactant concentration and exposure time. The ratio filaments length per total aggregates area (LfA) was an early-warning indicator of biomass washout, since it increased 3 and 5 days before effluent volatile suspended solids (VSS) rise, respectively, in shocks I and II.     

Strategies to suppress hydrogen-consuming microorganisms affect macro and micro scale structure and microbiology of granular sludge

Treatment of anaerobic granules with heat and two chemical treatments, contacting with 2-bromoethanesulfonate (BES) and with BES + Chloroform, were applied to suppress hydrogen-consuming microorganisms. Three mesophilic expanded granular sludge bed (EGSB) reactors-R(Heat), R(BES), and R(BES + Chlo)--were inoculated with the treated sludges and fed with synthetic sugar-based wastewater (5 g(COD) L(-1), HRT 20-12 h). Morphological integrity of granules and bacterial communities were assessed by quantitative image analysis and 16S rRNA gene based techniques, respectively. Hydrogen production in R(Heat) was under 300 mL H(2) L(-1) day(-1), with a transient peak of 1,000 mL H(2) L(-1) day(-1) after decreasing HRT. In R(BES + Chlo) hydrogen production rate did not exceed 300 mL H(2) L(-1) day(-1) and there was granule fragmentation, release of free filaments from aggregates, and decrease of granule density. In R(BES), there was an initial period with unstable hydrogen production, but a pulse of BES triggered its production rate to 700 ± 200 mL H(2) L(-1) day(-1). This strategy did not affect granules structure significantly. Bacteria branching within Clostridiaceae and Ruminococcaceae were present in this sludge. This work demonstrates that, methods applied to suppress H(2)-consuming microorganisms can cause changes in the macro- and microstructure of granular sludge, which can be incompatible with the operation of high-rate reactors.     

The performance of a phase separated granular bed bioreactor treating brewery wastewater

This study presents the performance characteristics of a plug flow phase separated anaerobic granular bed baffled reactor (GRABBR) fed with brewery wastewater at various operating conditions. The reactor achieved chemical oxygen demand (COD) removal of 93-96% with high methane production when operated at organic loading rates (OLRs) of 2.16-13.38kg COD m(-3)d(-1). The reactor configuration and microbial environment encouraged the acidogenic dominant zone to produce intermediate products suitable for degradation in the predominantly methanogenic zone. Noticeable phase separation between acidogenesis and methanogenesis mainly occurred at high OLR, involving a greater number of compartments to contribute to wastewater treatment. The highly active nature and good settling characteristics of methanogenic granular sludge offered high biomass retention and enhanced methanogenic activities within the system. The granular structure in the acidogenic dominant zone of the GRABBR was susceptible to disintegration and flotation. Methanogenic granular sludge was a multi-layered structure with Methanosaeta-like organisms dominant in the core.     

Anaerobic granule development for removal of pentachlorophenol in an upflow anaerobic sludge blanket (UASB) reactor

The granulation process using synthetic wastewater containing pentachlorophenol (PCP) in four 1.1 l laboratory scale upflow anaerobic sludge blanket (UASB) reactors was studied, and the anaerobic biotransformation of PCP during the granulation process investigated. After 110 days granular sludge was developed and up to 160 and 180 mg/l of PCP was added into the reactors R1 and R2, respectively, when they were inoculated with acclimated anaerobic sludge from an anaerobic digester of a citric acid plant. The inoculum was predominately composed of bacilli and filamentous bacteria. Granulation did not occur in reactors R3 and R4 which were inoculated with acclimated anaerobic sludge from aerobic sludge of the municipal sewage treatment plant which consisted mainly of cocci. Despite similar bacilli in the granule, the filamentous bacteria from reactor R1 were thicker than those of reactor R2. The granular sludge had a maximum diameter of 2.5 and 2.2 mm, and SMA of 1.44 and 1.32 gCOD/gTVS per day for reactors R1 and R2, respectively. Over 98% chemical oxygen demand (COD) removal rate and 99% of PCP removal rate were achieved when reactors R1 and R2 were operated at PCP and COD loading rates of 150 and 7.5 g/l per day, respectively. H₂-producing acetogens were the dominant anaerobes in the granular sludge.     

Long-term impact of dissolved O(2) on the activity of anaerobic granules

The impact of influent dissolved O(2) on the characteristics of anaerobic granular sludge was investigated at various dissolved O(2) concentrations (0.5-8.1 ppm) in 1- and 5-L laboratory-scale upflow anaerobic sludge bed (UASB)-like anaerobic/aerobic coupled reactors with a synthetic wastewater (carbon sources containing 75% sucrose and 25% acetate). The rate of dissolved O(2) supplied to the coupled reactor was as high as 0.40 g O(2)/L(rx).d, and the anaerobic/aerobic coupled reactors maintained excellent methanogenic performances at a COD loading rate of 3 g COD/L(rx).d even after the reactors had been operated with dissolved O(2) for 3 months. The activities of granular sludge on various substrates (glucose, propionate, and hydrogen) were not impaired, and acetate activity was even improved over a short term. However, after 3 months of operation, slight declines on the acetoclastic activities of granules were observed in the coupled reactor receiving the recirculated fluid containing 8.1 ppm dissolved O(2).Methane yield in the anaerobic control reactor and anaerobic/aerobic coupled reactors revealed that a significant aerobic elimination (up to 30%) of substrate occurred in the coupled reactors, as expected. The presence of dissolved O(2) in the recirculated fluid resulted in the development of fluffy biolayers on the granule surface, which imposed a negative impact on the settleability of granular sludge and caused a slightly higher sludge washout. This research shows that the anaerobic/aerobic coupled reactor can be successfully operated under O(2)-limited conditions and is an ideal engineered ecosystem integrating oxic and anaerobic niches. (c) 1996 John Wiley & Sons, Inc.     

Sedimentological evolution in an UASB treating SYNTHES, a new representative synthetic sewage, at low loading rates

The changes in the sedimentological attributes of the sludge bed in an upflow anaerobic sludge blanket (UASB) reactor fed with a low-strength wastewater mimicking raw domestic sewage were assessed in this study. The reactor was inoculated with 250 ml of granular sludge from a full-scale UASB reactor. The organic loading rate (OLR) varied from 1 to 2 g COD/ld. During the half-year long study, the reactor was operated at hydraulic retention times (HRTs) of 4.8 and 10 h, at 33 degrees C. Sludge sedimentology showed that the original granular sludge experienced serious instability and disintegration, leading to a much finer final grain assemblage, mainly due to substrate transfer limitation and cell starvation at the interior of larger granules. With time, the size uniformity tended to decrease, sphericity tended to increase, the skewness of the granule size distribution became negative, and the kurtosis became peaked and leptokurtic. In spite of the observed size reduction, reactor efficiency increased to a CODtotal removal of 96%. Biomass (sludge) yield was 0.012 g VS/g COD removed. The CH4 content of the biogas was high (up to 96%). This study thus highlights the treatment of a new type of wastewater with the deployment of the UASB reactor. It also reports the evolutionary trend of the biomass particle size distribution, making reference to a classic sedimentological appraisal.     

Aerobic granulation with brewery wastewater in a sequencing batch reactor

Aerobic granular sludge was cultivated in a sequencing batch reactor fed with brewery wastewater. After nine-week operation, stable granules with sizes of 2-7 mm were obtained. With the granulation, the SVI value decreased from 87.5 to 32 mL/g. The granular sludge had an excellent settling ability with the settling velocity over 91 m/h. Aerobic granular sludge exhibited good performance in the organics and nitrogen removal from brewery wastewater. After granulation, high and stable removal efficiencies of 88.7% COD(t), 88.9% NH(4)(+)-N were achieved at the volumetric exchange ratio of 50% and cycle duration of 6h. The average COD(t) and COD(s) of the effluent were 212 and 134 mg/L, respectively, and the average effluent ammonium concentration was less than 14.4 mg/L. Nitrogen was removed due to nitrification and simultaneous denitrification in the inner core of granules.     

Application of the upflow anaerobic sludge bed (UASB) process for treatment of complex wastewaters at low temperatures

The feasibility of the upflow anaerobic sludge bed (UASB) process for the treatment of potato starch wastewater at low ambient temperatures was demonstrated by operating two 5.65-L reactors at 14 degrees C and 20 degrees C, respectively. The organic space loading rates achieved in these laboratory-scale reactors were 3 kg COD/m(3)/day at 14 degrees C and 4-5 kg COD/m(3)/day at 20 degrees C. The corresponding sludge loading rates were 0.12 kg COD/kg VSS/day at 14 degrees C and 0.16-0.18 kg COD/kg VSS/day at 20 degrees C.These findings are of considerable practical importance because application of anaerobic treatment at low ambient temperatures will lead to considerable savings in energy needed for operating the process. As compared with various other anaerobic wastewater treatment processes, a granular sludge upflow process represents one of the best options developed so far. Although the overall sludge yield under psychrophilic conditions is slightly higher than under optimal mesophilic conditions, this doesn't seriously hamper the operation of the process. The extra sludge yield, due to accumulation of slowly hydrolyzing substrate ingredients, was 4.75% of the COD input at 14 degrees C and 1.22% of the COD input at 20 degrees C.     

Anaerobic treatment of raw domestic sewage at ambient temperatures using a granular bed UASB reactor

Results obtained in a 120 liter 2 m high UASB-reactor with raw domestic sewage and using a granular sugar beet waste cultivated seed sludge, reveal the feasibility of this type of anaerobic treatment for domestic sewage. Under dry weather conditions 65-85% COD reduction can be achieved at temperatures in the range of 8-20 degrees C and at hydraulic loads as high as 2 m(3) . m(-3) . day(-1). In the case of heavy rainfall the COD-reduction drops to 50-70% and occasionally, viz.at very low influent COD, even below 50%. The net methane production amounts to 7.1-7.3 m(3) . PE(-1) . year(-1), and the excess sludge production ranges form 5.0-8.6 kg TS . PE(-1) . year(-1). Regarding the results obtained anaerobic treatment of raw sewage not only looks an attractive proposition for tropic areas but also for moderate climatic areas.     

Monitoring granule formation in anaerobic upflow bioreactors using oligonucleotide hybridization probes

The process of granule formation in upflow anaerobic sludge blanket (UASB) reactors was studied using oligonucleotide hybridization probes. Two laboratory-scale UASB reactors were inoculated with sieved primary anaerobic digester sludge from a municipal wastewater treatment plant and operated similarly except that reactor G was fed glucose, while reactor GP was fed glucose and propionate. Size measurements of cell aggregates and quantification of different populations of methanogens with membrane hybridization targeting the small-subunit ribosomal RNA demonstrated that the increase in aggregate size was associated with an increase in the abundance of Methanosaeta concilii in both reactors. In addition, fluorescence in situ hybridization showed that the major cell components of small aggregates collected during the early stages of reactor startup were M. concilii cells. These results indicate that M. concilii filaments act as nuclei for granular development. The increase in aggregate size was greater in reactor GP than in reactor G during the early stages of startup, suggesting that the presence of propionate-oxidizing syntrophic consortia assisted the formation of granules. The mature granules formed in both reactors exhibited a layered structure with M. concilii dominant in the core, syntrophic consortia adjacent to the core, and filamentous bacteria in the surface layer. The excess of filamentous bacteria caused delay of granulation, which was corrected by increasing shear through an increase of the recycling rate.     

Ecophysiology of uncultured filamentous anaerobes belonging to the phylum KSB3 that cause bulking in methanogenic granular sludge

A filamentous bulking of a methanogenic granular sludge caused by uncultured filamentous bacteria of the candidate phylum KSB3 in an upflow anaerobic sludge blanket (UASB) system has been reported. To characterize the physiological traits of the filaments, a polyphasic approach consisting of rRNA-based activity monitoring of the KSB3 filaments using the RNase H method and substrate uptake profiling using microautoradiography combined with fluorescence in situ hybridization (MAR-FISH) was conducted. On the basis of rRNA-based activity, the monitoring of a full-scale UASB reactor operated continuously revealed that KSB3 cells became active and predominant (up to 54% of the total 16S rRNA) in the sludge when the carbohydrate loading to the system increased. Batch experiments with a short incubation of the sludge with maltose, glucose, fructose, and maltotriose at relatively low concentrations (approximately 0.1 mM) in the presence of yeast extract also showed an increase in KSB3 rRNA levels under anaerobic conditions. MAR-FISH confirmed that the KSB3 cells took up radioisotopic carbons from [(14)C]maltose and [(14)C]glucose under the same incubation conditions in the batch experiments. These results suggest that one of the important ecophysiological characteristics of KSB3 cells in the sludge is carbohydrate degradation in wastewater and that high carbohydrate loadings may trigger an outbreak of KSB3 bacteria, causing sludge bulking in UASB systems.     

Treatment of winery effluent with upflow anaerobic sludge blanket (UASB) – granular sludges enriched with Enterobacter sakazakii

Three upflow anaerobic sludge blankets (UASBs) were evaluated for the treatment of winery wastewater: the first was seeded with granular sludge enriched with Enterobacter sakazakii and reached a 90% COD removal within 17 d at hydraulic retention time of 24 h; the second was seeded with brewery granules and achieved 85% COD removal within 50 d, the third was seeded with just sludge and showed the typical problems encountered with conventional sludge seeding and had continuously to be re-seeded. A PCR-based technique was developed for the rapid detection of E. sakazakii in the granular sludge.     

Formation of aerobic granules and their PHB production at various substrate and ammonium concentrations

Aerobic granular sludge rich in polyhydroxybutyrate (PHB) was cultivated in a sequencing batch reactor (SBR) by seeding anaerobic granular sludge. The PHB content in aerobic granules was investigated and the experimental results reveal that both influent chemical oxygen demand (COD) and ammonium concentrations had a significant effect on the morphological characteristics and the PHB production of the aerobic granular sludge. At a COD and ammonium concentration of 750 mg/L and 8.5mg/L, respectively, the PHB content of the granules reached 44%, but their poor settling ability, as evidenced by a high sludge volume index, was observed. This was attributed to the outgrowth of filamentous bacteria on the granule surface. However, an increase in the ammonium concentration resulted in an elevated sludge concentration and a decrease in the PHB content in the granules. In this case, the aerobic granular sludge with a regular and compact structure was formed. The results suggest that, through controlling the COD and ammonium concentrations in the influent, the PHB-rich aerobic granular sludge with good settling ability could be cultivated.     

Challenge of psychrophilic anaerobic wastewater treatment

Psychrophilic anaerobic treatment is an attractive option for wastewaters that are discharged at moderate to low temperature. The expanded granular sludge bed (EGSB) reactor has been shown to be a feasible system for anaerobic treatment of mainly soluble and pre-acidified wastewater at temperatures of 5--10 degrees C. An organic loading rate (OLR) of 10--12 kg chemical oxygen demand (COD) per cubic meter reactor per day can be achieved at 10--12 degrees C with a removal efficiency of 90%. Further improvement might be obtained by a two-module system in series. Stabile methanogenesis was observed at temperatures as low as 4--5 degrees C. The specific activity of the mesophilic granular sludge was improved under psychrophilic conditions, which indicates that there was growth and enrichment of methanogens and acetogens in the anaerobic system. Anaerobic sewage treatment is a real challenge in moderate climates because sewage belongs to the 'complex' wastewater category and contains a high fraction of particulate COD. A two-step system consisting of either an anaerobic up-flow sludge bed (UASB) reactor combined with an EGSB reactor or an anaerobic filter (AF) combined with an anaerobic hybrid reactor (AH) is successful for anaerobic treatment of sewage at 13 degrees C with a total COD removal efficiency of 50% and 70%, respectively.     

Granular tau oligomers as intermediates of tau filaments

Neurofibrillary tangles (NFTs) are pathological hallmarks of several neurodegenerative disorders, including Alzheimer's disease (AD). NFTs are composed of microtubule-binding protein tau, which assembles to form paired helical filaments (PHFs) and straight filaments. Here we show by atomic force microscopy that AD brain tissue and in vitro tau form granular and fibrillar tau aggregates. CD spectral analysis and immunostaining with conformation-dependent antibodies indicated that tau may undergo conformational changes during fibril formation. Enriched granules generated filaments, suggesting that granular tau aggregates may be an intermediate form of tau fibrils. The amount of granular tau aggregates was elevated in prefrontal cortex of Braak stage I cases compared to that of Braak stage 0 cases, suggesting that granular tau aggregation precedes PHF formation. Thus, granular tau aggregates may be a relevant marker for the early diagnosis of tauopathy. Reducing the level of these aggregates may be a promising therapy for tauopathies and for promoting healthy brain aging.     

Granule development and performance in sucrose fed anaerobic baffled reactors

Two 90 L anaerobic baffled reactors were used to study the granulation of sludge and the effect of the organic loading rate and NaHCO3/COD ratios on reactor performance. Furthermore, it was determined whether an anaerobic baffled reactor would promote phase separation and if additive of bentonite or granular active carbon was capable of enhancing granule formation. In order to minimize feed variations, and have a totally biodegradable substrate, a synthetic sucrose substrate was used. Granulation was achieved in both reactors within 75 days. However, the granules from the granular active carbon amended reactor appeared earlier and were larger and more compact. The reactors were maintained at a hydraulic retention time of 20 h during performance study stage. The results showed that when organic loading rate were changed from 2.15 to 6.29 kg COD m(-3)day(-1), chemical oxygen demand (COD) removal was not decreased (91-93%), but a slight increase in effluent COD was observed. It was found that the COD removals were generally good (87-92%) and had not obviously change with the decreasing NaHCO3/COD ratios. From the bacterial distribution and the concentration of volatile fatty acids in four compartments, it was concluded that a separation of phases occurred within the anaerobic baffled reactors.     

Anaerobic degradation of benzoate: batch studies

Response of benzoate along with phenol to different anaerobic inocula has been investigated in batch reactors. In Phase I, the anaerobic biodegradability of benzoate and phenol were evaluated using (a) washed acclimatized granular sludge (WAGS) collected from a passive phenol fed bench-scale up-flow anaerobic sludge blanket reactor (UASBR) and (b) unacclimatized flocculent sludge (UFS) from a UASB based sewage treatment plant (STP). The effect of varying concentrations of benzoate has been investigated in Phase II using acclimatized granular sludge (AGS) from a bench-scale UASBR. Extent of degradation of benzoate was more than the phenol. Increasing benzoate COD from 2500 to 11,700mg/L, resulted in decrease in (i) rate constant, k from 0.79 to 0.11/d and (ii) ultimate biochemical methane potential (microb, g CH4-COD formed/g benzoate COD) from 84% to 60%. Temporal trend conforming to logistic S-curve indicated stressed conditions at higher benzoate concentration. Benzoate degradation was found to be sensitive to nature as well as quantity i.e. food to microorganism (F/M) of inocula used.     

The inhibitory effects and removal of dieldrin in continuous upflow anaerobic sludge blanket reactors

The inhibitory effects and removal efficiency of dieldrin (DLD) in anaerobic reactors were investigated. Anaerobic toxicity assay (ATA) experiments conducted in batch reactors revealed that 30 mg/l DLD had inhibitory effects on the unacclimated mixed anaerobic cultures. Continuous reactor experiments performed in a lab-scale two-stage upflow anaerobic sludge blanket (UASB) reactor system which was fed with ethanol as the sole carbon source, indicated that anaerobic granular cultures could be successfully acclimated to DLD. Chemical oxygen demand (COD) removal efficiencies were 88-92% for the two-stage system. The influent DLD concentration of 10 mg/l was removed by 44-86% and 86-94% in the second stage and overall UASB system, respectively. Biosorption of DLD on granular anaerobic biomass was found to be a significant mechanism for DLD removal in the UASB system. The maximum DLD loading rate and minimum HRT achievable for the first stage UASB reactor were 0.5 mg/lday (76 microg DLD/g VSS.day) and 10 h, respectively, which resulted in the overall COD removal efficiency of 85%.