Kinetic modeling of Candida shehatae ATCC 22984 on xylose and glucose for ethanol production

Candida shehatae ATCC 22984, a xylose-fermenting yeast, showed an ability to produce ethanol in both glucose and xylose medium. Maximum ethanol produced by the yeast was 48.8?g/L in xylose and 52.6?g/L in glucose medium with ethanol yields that varied between 0.3 and 0.4?g/g depended on initial sugar concentrations. Xylitol was a coproduct of ethanol production using xylose as substrate, and glycerol was detected in both glucose and xylose media. Kinetic model equations indicated that growth, substrate consumption, and product formation of C. shehatae were governed by substrate limitation and inhibition by ethanol. The model suggested that cell growth was totally inhibited at 40?g/L of ethanol and ethanol production capacity of the yeast was 52?g/L, which were in good agreement with experimental results. The developed model could be used to explain C. shehatae fermentation in glucose and xylose media from 20 to 170?g/L sugar concentrations.     

休哈塔假丝酵母转化木糖和葡萄糖为乙醇的发酵转录谱

[目的]探究木糖发酵典型菌株休哈塔假丝酵母在己糖和戊糖发酵中的转录谱及差异,筛选出与木糖利用和乙醇发酵代谢途径及调控相关的关键性酶和功能蛋白质基因.[方法]应用新一代高通量测序技术454 GS FLX Titanium分别构建了休哈塔假丝酵母木糖、葡萄糖发酵的cDNA文库,并进行De novo转录组的表达序列标签大规模测序和序列比较分析,进而挖掘出该酵母中参与木糖代谢和乙醇发酵的相关基因.[结果]分别对木糖和葡萄糖发酵样本进行二分之一RUN测序并各自得到60万条reads,序列平均长度400 bp.共拼接得到7250条(木糖)和7168条(葡萄糖)contigs,并利用BLAST对木糖样品和葡萄糖样品中的2421个基因(contig)和2456个基因(contig)进行了功能注释和GO分类.通过两个文库间的序列对比分析,共发现158个基因属于差异表达状态(P＜0.05).基于经典的糖酵解及乙醇发酵途径筛选出与木糖乙醇发酵相关的候选基因,并且比较分析其转录水平的差异.[结论]基于大规模转录谱测序和比较分析首次筛选出休哈塔假丝酵母中参与木糖代谢和乙醇发酵的基因群,可为后续的分子生物学及代谢调控研究提供基础数据.     

休哈塔假丝酵母HDYXHT-01利用木糖生产乙醇的发酵工艺优化

采用Plackett-Burman (PB) 方法和中心组合设计 (Ccentral composit design,CCD) 对休哈塔假丝酵母Candida shehataeHDYXHT-01利用木糖发酵生产乙醇的工艺进行优化。PB试验设计与分析结果表明：硫酸铵、磷酸二氢钾、酵母粉和接种量是影响木糖乙醇发酵的4个关键因素,以乙醇产量为响应目标,采用CCD和响应面分析法 (Response surface methodology,RSM),确定了木糖乙醇发酵的最佳工艺为：硫酸铵1.73 g/L、磷酸二氢钾3.56 g/L、酵母粉2.62 g/L和接种量5.66％,其他发酵条件为：木糖80 g/L,MgSO4·7H2O 0.1 g/L,pH 5.0,培养温度30 ℃,装液量100 mL/250 mL,摇床转速140 r/min,发酵时间48 h,在该条件下发酵液中乙醇产量可以达到26.18 g/L,比未优化前提高了1.15倍。     

The vitamin requirements of Candida shehatae for xylose fermentation

Abstract The vitamin requirements of a strain of Candida shehatae for the fermentation of d -xylose was determined using a statistical procedure with a 2³ factorial design. Biotin as well as thiamine exerted a dramatic stimulatory effect on the rate of ethanol production, coupled with a significant improvement in the ethanol yield. The greatest enhancement of the fermentation was found in the presence of both these vitamins. Pyridoxine exerted only a minor effect, but was essential for complete substrate utilization in the absence of either biotin or thiamine. Only biotin caused a significant increase in the growth rate.     

Effect of controlled oxygen limitation on Candida shehatae physiology for ethanol production from xylose and glucose

Carbon distribution and kinetics of Candida shehatae were studied in fed-batch fermentation with xylose or glucose (separately) as the carbon source in mineral medium. The fermentations were carried out in two phases, an aerobic phase dedicated to growth followed by an oxygen limitation phase dedicated to ethanol production. Oxygen limitation was quantified with an average specific oxygen uptake rate (OUR) varying between 0.30 and 2.48 mmolO₂ g dry cell weight (DCW)^?1 h^?1, the maximum value before the aerobic shift. The relations among respiration, growth, ethanol production and polyol production were investigated. It appeared that ethanol was produced to provide energy, and polyols (arabitol, ribitol, glycerol and xylitol) were produced to reoxidize NADH from assimilatory reactions and from the co-factor imbalance of the two-first enzymatic steps of xylose uptake. Hence, to manage carbon flux to ethanol production, oxygen limitation was a major controlled parameter; an oxygen limitation corresponding to an average specific OUR of 1.19 mmolO₂ g DCW^?1 h^?1 allowed maximization of the ethanol yield over xylose (0.327 g g^?1), the average productivity (2.2 g l^?1 h^?1) and the ethanol final titer (48.81 g l^?1). For glucose fermentation, the ethanol yield over glucose was the highest (0.411 g g^?1) when the specific OUR was low, corresponding to an average specific OUR of 0.30 mmolO₂ g DCW^?1 h^?1, whereas the average ethanol productivity and ethanol final titer reached the maximum values of 1.81 g l^?1 h^?1 and 54.19 g l^?1 when the specific OUR was the highest.     

Fermentation of xylose and rice straw hydrolysate to ethanol byCandida shehatae NCL-3501

Candida shehatae NCL-3501 utilized glucose and xylose efficiently in batch cultures. The specific rate of ethanol production was higher with mixtures of glucose and xylose (0.64–0.83 g g^–1 cells d^–1) compared to that with individual sugars (0.38–0.58 g g^–1 cells d^–1). Although the optimum temperature for growth was 30°C, this strain grew and produced appreciable levels of ethanol at 45°C. A stable ethanol yield (0.40–0.43 g g^–1 substrate utilized) was obtained between 10 g L^–1 and 80 g L^–1 of initial xylose concentration. Conversion efficiency was further improved by immobilization of the cells in calcium alginate beads. Free or immobilized cells ofC. shehatae NCL-3501 efficiently utilized sugars present in rice straw hemicellulose hydrolysate, prepared by two different methods, within 48 h. Ethanol yields of 0.45 g g^–1 and 0.5 g g^–1 from autohydrolysate, and 0.37 g g^–1 from acid hydrolysate were produced by free and immobilized cells, respectively.     

Adaptation of Candida shehatae and Pichia stipitis to wood hydrolysates for increased ethanol production

Summary Candida shehatae ATCC 22984 and Pichia stipitis CBS 5776 were tested for ethanol production from xylose, glucose-xylose mixtures, and aspen wood total hydrolysates. Adaptation of these yeasts to wood hydrolysate solutions by recycling resulted in improved substrate utilization and ethanol production. Compared to the non-adapted cultures, recycled C. shehatae and P. stipitis in aspen hydrolysate increased g ethanol/g sugar consumed from 0.39 and 0.41 to 0.45 and 0.47; while ethanol production from a 70:30 glucose-xylose solution (total sugars 140 g/L) was 45 g/L in 24 h and 60 g/L in 72 h with the adapted yeasts compared to 15 g/L and 28 g/L in the same times with the parent strains.     

Viability of Candida shehatae in D-xylose fermentations with added ethanol

Ethanol was added at concentrations of 25 and 50 g/L to active cultures of Canida shehatae under oxygen-limited (fermentative) conditions. Added ethanol completely inhibited grwoth and fermentation of D-xylose by C. shehatae. Cultures with added ethanol rapidly declined in cell viability as measured by plate counts and methylene blue staining. The rate of decline in cell viability was dependent on the amount of added ethanol. Over the course of the fermentation, cell viability, as measured by plate counts, was significantly lower in all experiments (with or without ethanol addition) compared with the viability measurements by methylene blue staining. Thus, data from the plate counts provided a more sensitive measure of the toxic effects of added ethanol and long-term anaerobiosis on C. shehatae growth/fermentation. Mean cell volume and total cell volume declined in fermentations with added ethanol. (c) 1992 John Wiley & Sons, Inc.     

Effect of nitrogen sources on oxidoreductive enzymes and ethanol production during D-xylose fermentation by Candida shehatae.

The effect on D-xylose utilization and the corresponding xylitol and ethanol production by Candida shehatae (ATCC 22984) were examined with different nitrogen sources. These included organic (urea, asparagine, and peptone) and inorganic (ammonium chloride, ammonium nitrate, ammonium sulphate, and potassium nitrate) sources. Candida shehatae did not grow on potassium nitrate. Improved ethanol production (Y(p/s), yield coefficient (grams product/grams substrate), 0.34) was observed when organic nitrogen sources were used. Correspondingly, the xylitol production was also higher with organic sources. Ammonium sulphate showed the highest ethanol:xylitol ratio (11.0) among all the nitrogen sources tested. The ratio of NADH- to NADPH-linked D-xylose reductase (EC 1.1.1.21) appeared to be rate limiting during ethanologenesis of D-xylose. The levels of xylitol dehydrogenase (EC 1.1.1.9) were also elevated in the presence of organic nitrogen sources. These results may be useful in the optimization of alcohol production by C. shehatae during continuous fermentation of D-xylose.     

The effect of aeration on xylose fermentation by Candida shehatae and Pachysolen tannophilus

Summary The ability of a Candida shehatae and a Pachysolen tannophilus strain to ferment D-xylose to ethanol was evaluated in defined and complex media under different levels of aeration. Aeration enhanced the ethanol productivity of both yeasts considerably. C. shehatae maintained a higher fermentation rate and ethanol yield than P. tannophilus over a wide range of aeration levels. Ethanol production by C. shehatae commenced during the early stage of the fermentation, whereas with P. tannophilus there was a considerable lag between the initiation of growth and ethanol production. Both yeasts produced appreciable quantities of xylitol late in the fermentation. P. tannophilus failed to grow under anoxic conditions, producing a maximum of only 0.5 g · l^-1 ethanol. In comparison, C. shehatae exhibited limited growth in anoxic cultures, and produced ethanol much more rapidly. Under the condition of aeration where C. shehatae exhibited the highest ethanol productivity, the fermentation parameters were: maximum specific growth rate, 0.15 h^-1; maximum volumetric and specific rates of ethanol production, 0.7 g (l · h)^-1 and 0.34 g ethanol (g cells · h)^-1 respectively; ethanol yield, 0.36 g (g xylose)^-1. The best values obtained with P. tannophilus were: maximum specific growth rate, 0.14 h^-1; maximum volumetric and specific rates of ethanol production, 0.22 g (l · h)^-1 and 0.07 h^-1 respectively; ethanol yield coefficient, 0.28. Because of its higher ethanol productivity at various levels of aeration, C. shehatae has a greater potential for ethanol production from xylose than P. tannophilus.     

Conversion of xylose to ethanol under aerobic conditions by Candida tropicalis

Summary Candida tropicalis converts xylose to ethanol under aerobic, but not anaerobic, conditions. Ethanol production lags behind growth and is accelerated by increased aeration. Adding xylose to active cultures stimulates ethanol production as does serial subculture in a medium containing xylose as a sole carbon source.Maintained in cooperation with the University of Wisconsin, Madison, Wis.     

Influence of oxygen on ethanol and xylitol production by xylose fermenting yeasts

The behaviour of Pichia stipitis, Pachysolen tannophilus, Candida shehatae and Candida parapsilosis was investigated to select the most suitable yeast to convert xylose either to ethanol or to xylitol, with little or no formation of by-products. The aeration rate was used as a variable parameter. P. stipitis and C. parapsilosis were the most effective producers or ethanol and xylitol, respectively, both reaching productivities at very low levels of oxygenation. With P. stipitis, better ethanol productivity was attained under microaerobic conditions (K_La = 4·8 h⁻¹) while with C. parapsilosis high yields and rates of xylitol production were detected at K_La values of about 16·3 h⁻¹. P. tannophilus and C. shehatae showed lower performances under all conditions used while changes in oxygenation modified the ratio of ethanol to xylitol produced by these yeasts, suggesting that they are more dependent on the oxygen power input than P. stipitis and C. parapsilosis. The influence of oxygen transfer rates on ethanol and xylitol formation with the best producers is discussed.     

Purification, characterization, and amino terminal sequence of xylose reductase from Candida shehatae.

D-Xylose is a major component of the carbohydrates derived from agricultural residues and forest products. Among more than two hundred known xylose-utilizing yeasts, only a few species are known to be able to ferment xylose anaerobically. Candida shehatae is one of such xylose-fermenting yeasts. Xylose reductase (E.C. 1.1.1.21) is a key enzyme responsible for xylose metabolism in xylose-utilizing as well as xylose-fermenting yeasts. In this paper, we report the development of a convenient and reliable procedure for the purification of xylose reductase from C. shehatae to near homogeneity. The amino acid composition and N-terminal sequence of the enzyme have also been analyzed. C. shehatae seems to contain only a single xylose reductase, but the enzyme has a dual coenzyme specificity for both NADPH and NADH. The enzyme is remarkably stable at room temperature and 4 degrees C.     

Construction of a recombinant yeast strain converting xylose and glucose to ethanol

Candida shehatae gene xyl1 and Pichia stipitis gene xyl2, encoding xylose reductase (XR) and xylitol dehydrogenase (XD) respectively, were amplified by PCR. The genes xyl1 and xyl2 were placed under the control of promoter GAL in vector pYES2 to construct the recombinant expression vector pYES2-P12. Subsequently the vector pYES2-P12 was transformed into S. cerevisiae YS58 by LiAc to produce the recombinant yeast YS58-12. The alcoholic ferment indicated that the recombinant yeast YS58-12 could convert xylose to ethanol with the xylose consumption rate of 81.3%. __________ Translated from Microbiology, 2006, 33(3): 104–108 [译自:微生物学通报]     

Construction of a recombinant yeast strain converting xylose and glucose to ethanol

Candida shehatae gene xyll and Pichia stipitis gene xyl2,encoding xylose reductase (XR) and xylitol dehydrogenase (XD) respectively,were amplified by PCR.The genes xyl1 and xyl2 were placed under the control of promoter GAL in vector pYES2 to construct the recombinant expression vector pYES2-PI2.Subsequently the vector pYES2-P12 was transformed into S.cerevisiae YS58 by LiAc to produce the recombinant yeast YS58-12.The alcoholic ferment indicated that the recombinant yeast YS58-12 could convert xylose to ethanol with the xylose consumption rate of 81.3%.     

Detoxification of sugarcane bagasse hydrolysate improves ethanol production by Candida shehatae NCIM 3501

Sugarcane bagasse hydrolysis with 2.5% (v/v) HCl yielded 30.29g/L total reducing sugars along with various fermentation inhibitors such as furans, phenolics and acetic acid. The acid hydrolysate when treated with anion exchange resin brought about maximum reduction in furans (63.4%) and total phenolics (75.8%). Treatment of hydrolysate with activated charcoal caused 38.7% and 57.5% reduction in furans and total phenolics, respectively. Laccase reduced total phenolics (77.5%) without affecting furans and acetic acid content in the hydrolysate. Fermentation of these hydrolysates with Candida shehatae NCIM 3501 showed maximum ethanol yield (0.48g/g) from ion exchange treated hydrolysate, followed by activated charcoal (0.42g/g), laccase (0.37g/g), overliming (0.30g/g) and neutralized hydrolysate (0.22g/g).     

Identification of salivary components that induce transition of hyphae to yeast in Candida albicans

Candida albicans , the major human fungal pathogen, undergoes a reversible morphological transition from single yeast cells to pseudohyphae and hyphae filaments. The hyphae form is considered the most invasive form of the fungus. The purpose of this study is to investigate the effect of saliva on hyphae growth of C. albicans. Candida albicans hyphae were inoculated in Roswell Park Memorial Institute medium with whole saliva, parotid saliva or buffer mimicking the saliva ion composition, and cultured for 18 h at 37 °C under aerobic conditions with 5% CO₂. Whole saliva and parotid saliva induced transition to yeast growth, whereas the culture with buffer remained in the hyphae form. Parotid saliva was fractionated on a reverse-phase C8 column and each fraction was tested for inducing transition to yeast growth. By immunoblotting, the salivary component in the active fraction was identified as statherin, a phosphoprotein of 43 amino acids that has been implicated in remineralization of the teeth. Synthetically made statherin induced transition of hyphae to yeast. By deletion of five amino acids at the negatively charged N-terminal site (DpSpSEE), yeast-inducing activity and binding to C. albicans were increased. In conclusion, statherin induces transition to yeast of C. albicans hyphae and may thus contribute to the oral defense against candidiasis.     

休哈塔假丝酵母发酵木糖制乙醇过程研究

木质纤维素原料水解产物的主要成分是葡萄糖和木糖,其中葡萄糖很容易发酵,致使木糖成为木质纤维素发酵的关键,休哈塔假丝酵母(Candida shehatae)1766是自然界木糖发酵性能较好的天然酵母之一。研究了发酵温度、发酵时间、接种量、初始pH值、摇床转速等因素对休哈塔假丝酵母1766发酵木糖生产乙醇的影响,由正交试验初步确定了休哈塔假丝酵母发酵木糖制乙醇工艺的适宜条件为好氧条件,发酵时间为2d,发酵温度为28℃,摇床转速为150r/min,初始pH值为5,此时乙醇收率最高可达68.62%。     

Temperature profiles of growth and ethanol tolerance of the xylose-fermenting yeasts Candida shehatae and Pichia stipitis

Summary The effect of different ethanol concentrations on the growth of Candida shehatae and Pichia stipitis with xylose as substrate was evaluated in a temperature gradient incubator. The upper limit of the temperature profiles of ethanol tolerance of both yeast strains were similar, although P. stipitis appeared to have a slightly higher ethanol tolerance in the higher temperature range. An increase in the ethanol concentration severely depressed the maximum growth temperature, and also increased the minimum growth temperature slightly. The ethanol tolerance limit of 46–48 g·l^-1 occurred within a narrow temperature plateau of 11 to 22° C. The low ethanol tolerance of these pentose fermenting yeasts is detrimental for commercial ethanol production from hemicellulose hydrolysates.