Evaluation of the Extract-Release Volume Phenomenon as a Rapid Test for Detecting Spoilage in Beef

Ground beef of several grades, obtained fresh and held refrigerated until spoiled, was presented to a test panel for scoring on color, odor, and tactile response (tackiness) as to degree of acceptance. Panel scores were correlated with total bacterial counts, ninhydrin-reactive substances, and ERV (extract-release volume) on the same meat. ERV correlated highest with bacterial counts the largest number of times; tackiness, odor, ninhydrin, and color followed in that order. Correlation between bacterial numbers and organoleptic qualities was best, with tackiness followed closely by odor, and then by color. Correlation between tackiness and odor was high. The degree of correlation between bacterial numbers, tackiness, and ERV was high enough to warrant the use of the ERV phenomenon as a rapid test of microbial quality of beef. An ERV value of 25 under the conditions of the test was supported as a divider between acceptable and unacceptable ground beef.     

Hydration and pH of Microbially Spoiling Beef

S ummary . The extract-release volume (ERV) technique was used to study the relationship between the hydration and pH of ground beef undergoing microbial spoilage at refrigeration temperatures. The ERV of samples of meat at various stages of freshness and spoilage was determined after adjusting their pH values to between 4.5 and 7.0. ERV responded instantly to pH change and, regardless of the microbial quality of the meat, minimum hydration or maximum ERV occurred at pH 5.5. Since most of the decrease in ERV during the spoilage of beef resulted from the increase in hydration of its proteins, it was concluded that the significant correlation noted previously between ERV and the bacterial quality of beef is highly dependent on the increase in pH value of the meat during spoilage.     

The Limulus Lysate Endotoxin Assay as a Test of Microbial Quality of Ground Beef

The Limulus lysate test (LLT) for endotoxin assay has been found to be an excellent, simple and rapid test of microbial quality of refrigerated ground beef. In fresh ground beef held at 5°C for 7–12 d, LLT titres increased from 10²–10⁵ and correlated very highly with extract-release volume (ERV) data and total viable Gram negative counts at both 5° and 30°C. The LLT was negative for fresh beef containing low numbers of bacteria and on aged beef in the absence of increasing numbers of Gram negative bacteria. Of 14 Gram negative meat isolates, all gave a positive LLT while none of eight miscellaneous Gram positive bacteria did. The use of this test provides objective information on the microbial quality of fresh refrigerated ground meats in 1 h. Based upon this study, it is suggested that a 0·1 ml inoculum from a 10³ dilution of good quality ground beef should produce a negative lysate test and thus serve as an additional rapid screening test of meat microbial quality.     

Use of a Titrimetric Method to Assess the Bacterial Spoilage of Fresh Beef

A new method of determining bacterial spoilage in fresh beef is presented. The technique is based upon the fact that as beef undergoes refrigerator spoilage, there is a gradual increase in the production of alkaline substances by the spoilage flora. The level of these substances was measured by titrating meat homogenates to a pH 5.00 end point, employing 0.02 n HCl and an autotitrator. When 23 samples of ground beef from retail stores were tested, an average of 1.32 ml of acid was required for titration of 1 g of fresh beef to pH 5.00, whereas 2.58 ml was required for the same meat at the onset of spoilage. Preliminary data indicate that beef which requires more than 2 ml of 0.02 n HCl/g to lower its pH to 5.00 under the conditions of the test is in some state of incipient spoilage. The statistical correlation between titration values, log bacterial numbers, and extract-release volume was high (P < 0.001). The technique is simple to execute and is highly reproducible, and duplicate samples can be run within 15 min.     

Incidence of Mesophilic Clostrodium Spores in Raw Pork, Beef, and Chicken in Processing Plants in the United States and Canada

The anaerobic film pouch technique was used to quantitate and isolate clostridial spores in 2,358 samples of raw meat (1,078 of chicken, 624 of beef, 656 of pork). Of 19,727 putrefactive anaerobic (PA) sporeformers isolated, 1 was confirmed by mouse protection testing to be Clostridium botulinum type C. This isolate was obtained from a Western Canada chicken sample which contained 5.33 clostridia per gram. These data indicate a very low incidence of botulinal contamination in raw meats at the packing-plant level (0.042% of 2,358 samples) and an almost 20,000:1 ratio of nonbotulinal PA sporeformers to mesophilic C. botulinum spores. The mean level of PA contamination was 2.8 PA sporeformers per gram of meat; 77% of the samples contained three or less PA sporeformers per gram. Small but statistically significant differences in the incidence of clostridial spores were noted for season, geographical region, and type of meat.     

Quantitative Relationship between Alphα-tocopherol and Polyunsaturated Fatty Acids and Its Connection to Development of Oxidative Rancidity in Chicken Skeletal Muscle

Quantitative relationships were investigated between α-tocopherol and either polyunsaturated fatty acids (PUFA) or PUFA > 18:2 (PUFA with three or more double bonds) in chicken dark meat (thigh muscle) and light meat (M. pectoralis profundus). Their effects on the development of oxidative rancidity in precooked meats held at 5°C for 3 days were also investigated. Chicken dark meat had higher concentrations of α-tocopherol (μmol) per gram of PUFA or PUFA > 18 :2 than did chicken light meat. 2-Thiobarbituric acid (TBA) values for the cooked ground meats held at 5°C for 3 days tended to increase at both higher and lower concentrations of α-tocopherol than the concentration of about 1.5 μmol of α-tocopherol per gram of PUFA regardless of the type of chicken skeletal muscle.     

Gamma-Ray Sterilization and Residual Toxicity Studies of Ground Beef Inoculated with Spores of Clostridium botulinum

Inoculated packs of cooked and raw ground beef were sterilized with gamma radiation from cobalt-60. With inocula of 5,000,000 Clostridium botulinum 213B spores per g of cooked ground beef, 3.8 megarad were required for sterilization; in raw ground beef, 3.72 megarad sterilized the meat when inocula of 1,700,000 C. botulinum 213B spores were used per g. Using C. botulinum 62A spores, cooked ground beef inoculated with 5,200,000 spores per g was sterilized with 3.85 megarad; raw ground beef, inoculated with 2,670,000 spores per g, was sterilized with 3.6 megarad. Cans of meat that were considered sterile by lack of culture growth after incubation for at least 6 months and, in some instances, as long as 5 years, were tested for the presence of botulinus toxin. No toxin was found in any meat taken from inoculated packs prepared from C. botulinum 213B spores; however, all cans of meat that had been inoculated with more than 2,670,000 C. botulinum 62A spores per g of meat, contained type A toxin. It was shown that these latter inocula of heat-shocked spores, by themselves, contained sufficient toxin to kill mice. However, more toxin appeared to be present than could be ascribed to the unirradiated spores alone. This finding is discussed.     

Dye Reduction Method for Estimating Bacterial Counts in Ground Beef

A dye reduction method was developed for estimating total aerobic and/or psychrotrophic bacterial counts in ground beef. The method is based on color changes in indicator disks placed on the meat surface.     

Prevalence and antimicrobial resistance of enterococcus species isolated from retail meats

From March 2001 to June 2002, a total of 981 samples of retail raw meats (chicken, turkey, pork, and beef) were randomly obtained from 263 grocery stores in Iowa and cultured for the presence of Enterococcus spp. A total of 1,357 enterococcal isolates were recovered from the samples, with contamination rates ranging from 97% of pork samples to 100% of ground beef samples. Enterococcus faecium was the predominant species recovered (61%), followed by E. faecalis (29%), and E. hirae (5.7%). E. faecium was the predominant species recovered from ground turkey (60%), ground beef (65%), and chicken breast (79%), while E. faecalis was the predominant species recovered from pork chops (54%). The incidence of resistance to many production and therapeutic antimicrobials differed among enterococci recovered from retail meat samples. Resistance to quinupristin-dalfopristin, a human analogue of the production drug virginiamycin, was observed in 54, 27, 9, and 18% of E. faecium isolates from turkey, chicken, pork, and beef samples, respectively. No resistance to linezolid or vancomycin was observed, but high-level gentamicin resistance was observed in 4% of enterococci, the majority of which were recovered from poultry retail meats. Results indicate that Enterococcus spp. commonly contaminate retail meats and that dissimilarities in antimicrobial resistance patterns among enterococci recovered from different meat types may reflect the use of approved antimicrobial agents in each food animal production class.     

Effect of α-tocopherol tissue levels on beef quality

To evaluate meat quality of beef with different α-tocopherol tissue levels, 55 feedlot steers were fed a barley-based finisher diet with four vitamin E supplementation levels (0, 350, 700 and 1400 IU DL-α-tocopheryl acetate/animal per day) for 120 days. Although the increase in oxidation levels overtime was much smaller (P < 0.001) in the high-medium and high groups, α-tocopherol tissue levels did not affect (P > 0.05) pH, proximate analysis, drip and cooking losses, and shear force of steaks. No effect of α-tocopherol tissue levels was found in retail evaluation of steaks after a short ageing time of 6 days, but with 21 days of ageing, a delay in formation of metmyoglobin (P = 0.008) was observed in steaks with higher tissue levels of α-tocopherol. Similar results were found for ground beef (25% fat) prepared from 6-day aged meat. Thus, higher α-tocopherol tissue levels protect ground beef and long-aged steaks from discolouration and lipid oxidation.     

Fate of Free Amino Acids and Nucleotides in Spoiling Beef

Fresh beef allowed to undergo microbial spoilage at 7 C showed decreases in quantity and types of amino acids as well as decreases in nucleotides when the initial number of bacteria per gram was high. When the initial number of bacteria was low, decreases were either not detectable or of low orders. It seems, therefore, that low-molecular-weight compounds of the above type support the growth of beef-spoilage bacteria rather than primary beef proteins. These low-molecular-weight compounds provide the probable sources of ammonia, hydrogen sulfide, and other such compounds associated with beef allowed to spoil at low temperatures.     

Survival of Campylobacter Jejuni/Coli in Ground Refrigerated and in Ground Frozen Beef Liver and in Frozen Broiler Carcasses

Survival of 5 strains of Campylobacter jejuni/coli in ground beef liver stored at 4° C and at –20° C was studied. After 6 days of storage at 4° C the beef liver was spoiled, which was indicated by APG log 7.25 and lactobacilli count log 7.0. During this storage Campylobacter counts decreased only slightly. After 12 weeks of storage at –20° C Campylobacter counts decreased by 2–3 logs in frozen ground beef liver. Survival of 4 strains of C. jejuni/coli on frozen broiler carcasses was also studied. Two inoculation levels, 103–104/g and 104–105/g were used. On frozen broiler carcasses Campylobacter counts decreased by 0.5–2.0 logs during 12 weeks at –20° C.     

Effect of Soy Proteins on the Growth of Clostridium perfringens

Proteins that are used to fabricate imitation foods such as synthetic meats were evaluated for stimulative or inhibitory effects on the growth of Clostridium perfringens. Growth rate and extent were measured in thioglycolate medium without dextrose. This liquid medium contains Trypticase (BBL) which served as the protein control. For comparison, various soy proteins, synthetic meats, beef, turkey, sodium caseinate, and combinations of each were substituted for Trypticase. Meat loaf systems were also employed to determine the effects of protein additives to meat under actual meat loaf conditions. Growth of C. perfringens type A, strain S40, was measured in the respective media at 45 C at a pH of 7.0 and an E(h) of below -300 mv. Viable populations were enumerated by agar plate techniques on Trypticase-sulfite-yeast-citrate-agar incubated anaerobically (90% N(2)-10% CO(2)) for 18 hr at 35 C. When compared to Trypticase, some soy proteins had stimulative effects on the growth of C. perfringens, whereas sodium caseinate and some soy proteins were inhibitory. In liquid medium in which meat or soy meat was the source of protein, there was a marked stimulation by beef, chicken, and soy beef. Soy chicken supported growth at a rate less than observed with Trypticase. Under actual meat loaf conditions, the addition of soy meat or protein additives to beef did not affect the growth of C. perfringens. The addition of protein additives to turkey meat loaves significantly enhanced the rate of growth of C. perfringens. The stimulative effects of some soy proteins are significant in relation to control of foodborne disease.     

ESTIMATION OF MICROBIOLOGICAL QUALITY OF CHILLED BEEF USING AUTOMATED TURBIDIMETRY

Total bacterial counts on chilled beef samples were estimated by the standard plate count method and by an automated turbidimetric system. The latter method is based on product-specific calibration curves constructed by correlating growth curve parameters calculated for the turbidimeter to the log CFU values obtained by plate counts. A total of 74 beef samples was used to construct the calibration curves. Correlation analysis between turbidimetric parameters and plate count values showed that detection time was the best predictor to estimate microbial loads on fresh (r=0.91) and aged beef (r=0.94). Microbial loads for a different set of aged beef samples (n = 37) refrigerated for 7, 9, 10, 17 and 45 days were compared by turbidimetric measurements and plate counts. Mean total viable counts were log 5.92 ± 1.17 and log 5.54 ± 1.28 CFU/mL, respectively. Results showed that total bacterial counts on chilled beef could be estimated accurately from turbidimetric parameters. Furthermore, setting a cut-off value of log 6 CFU/mL allowed to accepting/rejecting samples according to their microbial condition in shorter periods of time compared to the traditional plate count method.     

Origin of Contamination and Genetic Diversity of Escherichia coli in Beef Cattle

The possible origin of beef contamination and genetic diversity of Escherichia coli populations in beef cattle, on carcasses and ground beef, was examined by using random amplification of polymorphic DNA (RAPD) and PCR-restriction fragment length polymorphism (PCR-RFLP) analysis of the fliC gene. E. coli was recovered from the feces of 10 beef cattle during pasture grazing and feedlot finishing and from hides, carcasses, and ground beef after slaughter. The 1,403 E. coli isolates (855 fecal, 320 hide, 153 carcass, and 75 ground beef) were grouped into 121 genetic subtypes by using the RAPD method. Some of the genetic subtypes in cattle feces were also recovered from hides, prechilled carcasses, chilled carcasses, and ground beef. E. coli genetic subtypes were shared among cattle at all sample times, but a number of transient types were unique to individual animals. The genetic diversity of the E. coli population changed over time within individual animals grazing on pasture and in the feedlot. Isolates from one animal (59 fecal, 30 hide, 19 carcass, and 12 ground beef) were characterized by the PCR-RFLP analysis of the fliC gene and were grouped into eight genotypes. There was good agreement between the results obtained with the RAPD and PCR-RFLP techniques. In conclusion, the E. coli contaminating meat can originate from cattle feces, and the E. coli population in beef cattle was highly diverse. Also, genetic subtypes can be shared among animals or can be unique to an animal, and they are constantly changing.     

Survival of Campylobacter jejuni inoculated into ground beef.

Ground beef was inoculated with mixed cultures of Campylobacter jejuni, and the samples were subjected to various cooking and cold-storage temperatures. When samples were heated in an oven at either 190 or 218 degrees C, approximately 10(7) cells of C. jejuni per g were inactivated (less than 30 cells per g) in less than 10 min after the ground beef reached an internal temperature of 70 degrees C. When the samples were held at -15 degrees C over 14 days of storage, the numbers of C. jejuni declined by 3 log10. When inoculated samples were stored with an equal amount of Cary-Blair diluent at 4 degrees C, no changes in viability were observed over 14 days of storage. Twenty-five times as much C. jejuni was recovered from inoculated ground beef when either 10% glycerol or 10% dimethyl sulfoxide was added to an equal amount of ground beef before freezing as was recovered from peptone-diluted ground beef. Twice as much inoculated C. jejuni was recovered from ground beef plus Cary-Blair diluent as was recovered from ground beef plus peptone diluent.     

Fate of Listeria monocytogenes in processed meat products during refrigerated storage.

The fate of Listeria monocytogenes during refrigerated storage was determined on several processed meat products, including ham, bologna, wieners, sliced chicken, sliced turkey, fermented semidried sausage, bratwurst, and cooked roast beef. The meats were surface inoculated with a five-strain mixture of less than or equal to 200 or ca. 10(5) L. monocytogenes cells per package, vacuum packaged, and stored at 4.4 degrees C. Survival or growth of listeriae was determined for up to 12 weeks of storage or until the product was spoiled. The organism survived but did not grow on summer sausage, grew only slightly on cooked roast beef, grew well on some wiener products but not on others, grew well (10(3) to 10(5) CFU/g increase within 4 weeks) on ham, bologna, and bratwurst, and grew exceptionally well (10(3) to 10(5) CFU/g increase within 4 weeks) on sliced chicken and turkey. The rate of growth depended largely upon the type of product and the pH of the product. Growth was most prolific on processed poultry products. The organism generally grew well on meats near or above pH 6 and poorly or not at all on products near or below pH 5. These results indicate the importance of preventing postprocessing contamination of L. monocytogenes in a variety of ready-to-eat meat products.     

Fate of Listeria monocytogenes in processed meat products during refrigerated storage

The fate of Listeria monocytogenes during refrigerated storage was determined on several processed meat products, including ham, bologna, wieners, sliced chicken, sliced turkey, fermented semidried sausage, bratwurst, and cooked roast beef. The meats were surface inoculated with a five-strain mixture of less than or equal to 200 or ca. 10(5) L. monocytogenes cells per package, vacuum packaged, and stored at 4.4 degrees C. Survival or growth of listeriae was determined for up to 12 weeks of storage or until the product was spoiled. The organism survived but did not grow on summer sausage, grew only slightly on cooked roast beef, grew well on some wiener products but not on others, grew well (10(3) to 10(5) CFU/g increase within 4 weeks) on ham, bologna, and bratwurst, and grew exceptionally well (10(3) to 10(5) CFU/g increase within 4 weeks) on sliced chicken and turkey. The rate of growth depended largely upon the type of product and the pH of the product. Growth was most prolific on processed poultry products. The organism generally grew well on meats near or above pH 6 and poorly or not at all on products near or below pH 5. These results indicate the importance of preventing postprocessing contamination of L. monocytogenes in a variety of ready-to-eat meat products.     

Prevalence of Campylobacter spp., Escherichia coli, and Salmonella Serovars in Retail Chicken, Turkey, Pork, and Beef from the Greater Washington, D.C., Area

A total of 825 samples of retail raw meats (chicken, turkey, pork, and beef) were examined for the presence of Escherichia coli and Salmonella serovars, and 719 of these samples were also tested for Campylobacter spp. The samples were randomly obtained from 59 stores of four supermarket chains during 107 sampling visits in the Greater Washington, D.C., area from June 1999 to July 2000. The majority (70.7%) of chicken samples (n = 184) were contaminated with Campylobacter, and a large percentage of the stores visited (91%) had Campylobacter-contaminated chickens. Approximately 14% of the 172 turkey samples yielded Campylobacter, whereas fewer pork (1.7%) and beef (0.5%) samples were positive for this pathogen. A total of 722 Campylobacter isolates were obtained from 159 meat samples; 53.6% of these isolates were Campylobacter jejuni, 41.3% were Campylobacter coli, and 5.1% were other species. Of the 212 chicken samples, 82 (38.7%) yielded E. coli, while 19.0% of the beef samples, 16.3% of the pork samples, and 11.9% of the turkey samples were positive for E. coli. However, only 25 (3.0%) of the retail meat samples tested were positive for Salmonella. Significant differences in the bacterial contamination rates were observed for the four supermarket chains. This study revealed that retail raw meats are often contaminated with food-borne pathogens; however, there are marked differences in the prevalence of such pathogens in different meats. Raw retail meats are potential vehicles for transmitting food-borne diseases, and our findings stress the need for increased implementation of hazard analysis of critical control point (HACCP) and consumer food safety education efforts.     

Effect of various gas atmospheres on the growth and survival of Campylobacter jejuni on beef

Pieces of fresh beef were inoculated with three strains of Campylobacter jejuni. The meat was then allocated to three treatments: (a) vacuum packaged, (b) packaged in an atmosphere of 20% CO2 + 80% N2, and (c) packaged into sterile Petri dishes in anaerobic cultivation boxes, which were filled with a gas mixture of 5% O2 + 10% CO2 + 85% N2. The packaging material in the first two treatments was PA 80/PE 100-PE 100/PA 80/PE 100. The survival of Campylobacter cells was followed at 37 degrees C, 20 degrees C and 4 degrees C for 48 h, 4 days and 25 days, respectively. At 37 degrees C the counts of two Campylobacter strains increased in each package treatment for 48 h. At 20 degrees C and at 4 degrees C the counts of the same two strains decreased by 1 to 2 log units and 0.5 to 1 log unit, respectively, during storage. The survival of the two strains was about the same in all package treatments. The third strain was the most sensitive of the strains studied. At 37 degrees C its numbers increased only in the optimal gas atmosphere; at 20 degrees C the strain was not detectable after 24 to 48 h storage and at 4 degrees C after 4 days storage. The aerobic plate counts were determined for all samples at the same time as Campylobacter counts. The high indigenous bacterial numbers of the meat samples did not appear to have a great effect on the survival or growth of campylobacters.