Direct quantitation and detection of salmonellae in biological samples without enrichment, using two-step filtration and real-time PCR

A new two-step filtration protocol followed by a real-time PCR assay based on SYBR green I detection was developed to directly quantitate salmonellae in two types of biological samples: i.e., chicken rinse and spent irrigation water. Four prefiltration filters, one type of final filter, and six protocols for recovery of salmonellae from the final filter were evaluated to identify an effective filtration protocol. This method was then combined with a real-time PCR assay based on detection of the invA gene. The best results were obtained by subsequent filtration of 100 ml of chicken rinse or 100 ml of spent irrigation water through filters with pore diameters of >40 mum to remove large particles and of 0.22 microm to recover the Salmonella cells. After this, the Salmonella cells were removed from the filter by vortexing in 1 ml of physiological saline, and this sample was then subjected to real-time quantitative PCR. The whole procedure could be completed within 3 h from sampling to quantitation, and cell numbers as low as 7.5 x 10(2) CFU per 100-ml sample could be quantified. Below this limit, qualitative detection of concentrations as low as 2.2 CFU/100 ml sample was possible on occasion. This study has contributed to the development of a simple, rapid, and reliable method for quantitation of salmonellae in food without the need for sample enrichment or DNA extraction.     

Diagnostic Real-Time PCR for Detection of Salmonella in Food

A robust 5′ nuclease (TaqMan) real-time PCR was developed and validated in-house for the specific detection of Salmonella in food. The assay used specifically designed primers and a probe target within the ttrRSBCA locus, which is located near the Salmonella pathogenicity island 2 at centisome 30.5. It is required for tetrathionate respiration in Salmonella. The assay correctly identified all 110 Salmonella strains and 87 non-Salmonella strains tested. An internal amplification control, which is coamplified with the same primers as the Salmonella DNA, was also included in the assay. The detection probabilities were 70% when a Salmonella cell suspension containing 10³ CFU/ml was used as a template in the PCR (5 CFU per reaction) and 100% when a suspension of 10⁴ CFU/ml was used. A pre-PCR sample preparation protocol including a preenrichment step in buffered peptone water followed by DNA extraction-purification was applied when 110 various food samples (chicken rinses, minced meat, fish, and raw milk) were investigated for Salmonella. The diagnostic accuracy was shown to be 100% compared to the traditional culture method. The overall analysis time of the PCR method was approximately 24 h, in contrast to 4 to 5 days of analysis time for the traditional culture method. This methodology can contribute to meeting the increasing demand of quality assurance laboratories for standard diagnostic methods. Studies are planned to assess the interlaboratory performance of this diagnostic PCR method.     

Optimization of a 12-Hour TaqMan PCR-Based Method for Detection of Salmonella Bacteria in Meat

We developed a 12-h Salmonella detection method, based on 8 h of preenrichment, followed by automated DNA extraction and a sensitive real-time PCR. The method was optimized to obtain the highest possible yield of cells and DNA. The growth of different Salmonella strains in various preenrichment media and the effects of adding growth-promoting and selective reagents were explored, taking into account their PCR compatibility. The effects of (i) analyzing larger volumes (1 to 5 ml) from preenriched samples and introducing wash steps prior to DNA extraction, (ii) regulating the amount of paramagnetic particles (increasing it from 60 to 90 μl) in the DNA extraction, (iii) eluting the DNA in reduced volumes (25 or 50 μl rather than 100 μl), and (iv) increasing the PCR template volume (from 5 to 20 μl) were investigated. After 8 h of preenrichment, buffered peptone water yielded the highest number of salmonellae. When analyzing minced meat samples, positive effects of increasing the initial sampling volume from 1 to 5 ml and increasing the amount of paramagnetic particles to 90 μl were observed. However, washing the pellet and eluting the DNA in reduced volumes (25 and 50 μl) had no positive effects and resulted in decreased reproducibility. Increasing the amount of PCR template DNA from 5 to 20 μl improved the threshold cycle value by approximately 2. The improved 12-h PCR method was successfully compared to a reference culture method with 100 minced meat and poultry samples, with a relative accuracy of 99%, a relative sensitivity of 98%, and a relative specificity of 100%.     

Detection of Salmonella enterica Serovar Typhimurium by Using a Rapid, Array-Based Immunosensor

The multianalyte array biosensor (MAAB) is a rapid analysis instrument capable of detecting multiple analytes simultaneously. Rapid (15-min), single-analyte sandwich immunoassays were developed for the detection of Salmonella enterica serovar Typhimurium, with a detection limit of 8 × 10⁴ CFU/ml; the limit of detection was improved 10-fold by lengthening the assay protocol to 1 h. S. enterica serovar Typhimurium was also detected in the following spiked foodstuffs, with minimal sample preparation: sausage, cantaloupe, whole liquid egg, alfalfa sprouts, and chicken carcass rinse. Cross-reactivity tests were performed with Escherichia coli and Campylobacter jejuni. To determine whether the MAAB has potential as a screening tool for the diagnosis of asymptomatic Salmonella infection of poultry, chicken excretal samples from a private, noncommercial farm and from university poultry facilities were tested. While the private farm excreta gave rise to signals significantly above the buffer blanks, none of the university samples tested positive for S. enterica serovar Typhimurium without spiking; dose-response curves of spiked excretal samples from university-raised poultry gave limits of detection of 8 × 10³ CFU/g.     

Rapid Detection of Campylobacter coli, C. jejuni, and Salmonella enterica on Poultry Carcasses by Using PCR-Enzyme-Linked Immunosorbent Assay

Contamination of retail poultry by Campylobacter spp. and Salmonella enterica is a significant source of human diarrheal disease. Isolation and identification of these microorganisms require a series of biochemical and serological tests. In this study, Campylobacter ceuE and Salmonella invA genes were used to design probes in PCR-enzyme-linked immunosorbent assay (ELISA), as an alternative to conventional bacteriological methodology, for the rapid detection of Campylobacter jejuni, Campylobacter coli, and S. enterica from poultry samples. With PCR-ELISA (40 cycles), the detection limits for Salmonella and Campylobacter were 2 × 10² and 4 × 10¹ CFU/ml, respectively. ELISA increased the sensitivity of the conventional PCR method by 100- to 1,000-fold. DNA was extracted from carcass rinses and tetrathionate enrichments and used in PCR-ELISA for the detection of Campylobacter and S. enterica, respectively. With PCR-ELISA, Salmonella was detected in 20 of 120 (17%) chicken carcass rinses examined, without the inclusion of an enrichment step. Significant correlation was observed between PCR-ELISA and cultural methods (kappa = 0.83; chi-square test, P < 0.001) with only one false negative (1.67%) and four false positives (6.67%) when PCR-ELISA was used to screen 60 tetrathionate enrichment cultures for Salmonella. With PCR-ELISA, we observed a positive correlation between the ELISA absorbance (optical density at 405 nm) and the campylobacter cell number in carcass rinse, as determined by standard culture methods. Overall, PCR-ELISA is a rapid and cost-effective approach for the detection and enumeration of Salmonella and Campylobacter bacteria on poultry.     

Development and Evaluation of a Blood Culture PCR Assay for Rapid Detection of Salmonella Paratyphi A in Clinical Samples

Background

Enteric fever remains an important cause of morbidity in many low-income countries and Salmonella Paratyphi A has emerged as the aetiological agent in an increasing proportion of cases. Lack of adequate diagnostics hinders early diagnosis and prompt treatment of both typhoid and paratyphoid but development of assays to identify paratyphoid has been particularly neglected. Here we describe the development of a rapid and sensitive blood culture PCR method for detection of Salmonella Paratyphi A from blood, potentially allowing for appropriate diagnosis and antimicrobial treatment to be initiated on the same day.

Methods

Venous blood samples from volunteers experimentally challenged orally with Salmonella Paratyphi A, who subsequently developed paratyphoid, were taken on the day of diagnosis; 10 ml for quantitative blood culture and automated blood culture, and 5 ml for blood culture PCR. In the latter assay, bacteria were grown in tryptone soy broth containing 2.4% ox bile and micrococcal nuclease for 5 hours (37°C) before bacterial DNA was isolated for PCR detection targeting the fliC-a gene of Salmonella Paratyphi A.

Results

An optimized broth containing 2.4% ox bile and micrococcal nuclease, as well as a PCR test was developed for a blood culture PCR assay of Salmonella Paratyphi A. The volunteers diagnosed with paratyphoid had a median bacterial burden of 1 (range 0.1–6.9) CFU/ml blood. All the blood culture PCR positive cases where a positive bacterial growth was shown by quantitative blood culture had a bacterial burden of ≥ 0.3 CFU/ ml blood. The blood culture PCR assay identified an equal number of positive cases as automated blood culture at higher bacterial loads (≥0.3 CFU/ml blood), but utilized only half the volume of specimens.

Conclusions

The blood culture PCR method for detection of Salmonella Paratyphi A can be completed within 9 hours and offers the potential for same-day diagnosis of enteric fever. Using 5 ml blood, it exhibited a lower limit of detection equal to 0.3 CFU/ml blood, and it performed at least as well as automated blood culture at higher bacterial loads (≥0.3 CFU/ml blood) of clinical specimens despite using half the volume of blood. The findings warrant its further study in endemic populations with a potential use as a novel diagnostic which fills the present gap of paratyphoid diagnostics.     

Comparison of Pathogen DNA Isolation Methods from Large Volumes of Whole Blood to Improve Molecular Diagnosis of Bloodstream Infections

For patients suffering from bloodstream infections (BSI) molecular diagnostics from whole blood holds promise to provide fast and adequate treatment. However, this approach is hampered by the need of large blood volumes. Three methods for pathogen DNA isolation from whole blood were compared, i.e. an enzymatic method (MolYsis, 1–5 ml), the novel non-enzymatic procedure (Polaris, 1–5 ml), and a method that does not entail removal of human DNA (Triton-Tris-EDTA EasyMAG, 200 µl). These methods were evaluated by processing blood spiked with 0–1000 CFU/ml of Staphylococcus aureus, Pseudomonas aeruginosa and Candida albicans. Downstream detection was performed with real-time PCR assays. Polaris and MolYsis processing followed by real-time PCRs enabled pathogen detection at clinically relevant concentrations of 1–10 CFU/ml blood. By increasing sample volumes, concurrent lower cycle threshold (Ct) values were obtained at clinically relevant pathogen concentrations, demonstrating the benefit of using larger blood volumes. A 100% detection rate at a concentration of 10 CFU/ml for all tested pathogens was obtained with the Polaris enrichment, whereas comparatively lower detection rates were measured for MolYsis (50–67%) and EasyMAG (58–79%). For the samples with a concentration of 1 CFU/ml Polaris resulted in most optimal detection rates of 70–75% (MolYsis 17–50% and TTE-EasyMAG 20–36%). The Polaris method was more reproducible, less labour intensive, and faster (45 minutes (including Qiagen DNA extraction) vs. 2 hours (MolYsis)). In conclusion, Polaris and MolYsis enrichment followed by DNA isolation and real-time PCR enables reliable and sensitive detection of bacteria and fungi from 5 ml blood. With Polaris results are available within 3 hours, showing potential for improved BSI diagnostics.     

Quantification of Campylobacter spp. in Chicken Rinse Samples by Using Flotation prior to Real-Time PCR

Real-time PCR is fast, sensitive, specific, and can deliver quantitative data; however, two disadvantages are that this technology is sensitive to inhibition by food and that it does not distinguish between DNA originating from viable, viable nonculturable (VNC), and dead cells. For this reason, real-time PCR has been combined with a novel discontinuous buoyant density gradient method, called flotation, in order to allow detection of only viable and VNC cells of thermotolerant campylobacters in chicken rinse samples. Studying the buoyant densities of different Campylobacter spp. showed that densities changed at different time points during growth; however, all varied between 1.065 and 1.109 g/ml. These data were then used to develop a flotation assay. Results showed that after flotation and real-time PCR, cell concentrations as low as 8.6 × 10² CFU/ml could be detected without culture enrichment and amounts as low as 2.6 × 10³ CFU/ml could be quantified. Furthermore, subjecting viable cells and dead cells to flotation showed that viable cells were recovered after flotation treatment but that dead cells and/or their DNA was not detected. Also, when samples containing VNC cells mixed with dead cells were treated with flotation after storage at 4 or 20°C for 21 days, a similar percentage resembling the VNC cell fraction was detected using real-time PCR and 5-cyano-2,3-ditolyl tetrazolium chloride-4′,6′-diamidino-2-phenylindole staining (20% ± 9% and 23% ± 4%, respectively, at 4°C; 11% ± 4% and 10% ± 2%, respectively, at 20°C). This indicated that viable and VNC Campylobacter cells could be positively selected and quantified using the flotation method.     

Multicenter Validation of the Analytical Accuracy of Salmonella PCR: towards an International Standard

As part of a major international project for the validation and standardization of PCR for detection of five major food-borne pathogens, four primer sets specific for Salmonella species were evaluated in-house for their analytical accuracy (selectivity and detection limit) in identifying 43 Salmonella spp. and 47 non-Salmonella strains. The most selective primer set was found to be 139-141 (K. Rahn, S. A. De Grandis, R. C. Clarke, S. A. McEwen, J. E. Galán, C. Ginocchio, R. Curtiss III, and C. L. Gyles, Mol. Cell. Probes 6:271-279, 1992), which targets the invA gene. An extended determination of selectivity by using 364 strains showed that the inclusivity was 99.6% and the exclusivity was 100% for the invA primer set. To indicate possible PCR inhibitors derived from the sample DNA, an internal amplification control (IAC), which was coamplified with the invA target gene, was constructed. In the presence of 300 DNA copies of the IAC, the detection probability for primer set 139-141 was found to be 100% when a cell suspension containing 10⁴ CFU/ml was used as the template in the PCR (50 CFU per reaction). The primer set was further validated in an international collaborative study that included 16 participating laboratories. Analysis with 28 coded (“blind”) DNA samples revealed an analytical accuracy of 98%. Thus, a simple PCR assay that is specific for Salmonella spp. and amplifies a chromosomal DNA fragment detected by gel electrophoresis was established through extensive validation and is proposed as an international standard. This study addresses the increasing demand of quality assurance laboratories for standard diagnostic methods and presents findings that can facilitate the international comparison and exchange of epidemiological data.     

PCR Detection of Salmonella enterica Serotype Montevideo in and on Raw Tomatoes Using Primers Derived from hilA

Salmonellae have been some of the most frequently reported etiological agents in fresh-produce-associated outbreaks of human infections in recent years. PCR assays using four innovative pairs of primers derived from hilA and sirA, positive regulators of Salmonella invasive genes, were developed to identify Salmonella enterica serotype Montevideo on and in tomatoes. Based on examination of 83 Salmonella strains and 22 non-Salmonella strains, we concluded that a pair of hilA primers detects Salmonella specifically. The detection limits of the PCR assay were 10¹ and 10⁰ CFU/ml after enrichment at 37°C for 6 and 9 h, respectively. When the assay was validated by detecting S. enterica serotype Montevideo in and on artificially inoculated tomatoes, 10² and 10¹ CFU/g were detected, respectively, after enrichment for 6 h at 37°C. Our results suggest that the hilA-based PCR assay is sensitive and specific, and can be used for rapid detection of Salmonellae in or on fresh produce.     

Enhancement of Immunohistochemical Detection of Salmonella in Tissues of Experimentally Infected Pigs

Salmonella Typhimurium is one of the main pathogens compromising porcine and human health as well as food safety, because it is a prevailing source of foodborne infections due to contaminated pork. A prominent problem in the management of this bacteriosis is the number of subclinically infected carrier pigs. As very little is known concerning the mechanisms allowing Salmonella to persist in pigs, the objective of this study was to develop an immunohistochemical approach for the detection of salmonellae in tissue of pigs experimentally infected with Salmonella Typhimurium. Samples were obtained from a challenge trial in which piglets of the German Landrace were intragastrically infected with Salmonella enterica serovar Typhimurium DT104 (1.4-2.1×10¹⁰ CFU). Piglets were sacrificed on days 2 and 28 post infection. Tissue samples of jejunum, ileum, colon, ileocecal mesenteric lymph nodes (Lnn. ileocolici), and tonsils (Tonsilla veli palatini) were fixed in Zamboni’s fixative and paraffin-embedded. Different immunohistochemical staining protocols were evaluated. Salmonella was detected in varying amounts in the tissues. Brown iron-containing pigments in the lymph nodes interfered with the identification of Salmonella if DAB was used as a staining reagent. Detergents like Triton X-100 or Saponin enhanced the sensitivity. It seems advisable not to use a detection system with brown staining for bacteria in an experimental setup involving intestinal damage including haemorrhage. The use of detergents appears to result in a higher sensitivity in the immunohistochemical detection of salmonellae.Key words: Swine, immunohistochemistry, histochemistry, bacteria, detection limit     

A real-time PCR for the detection of Salmonella Enteritidis in poultry meat and consumption eggs

A robust duplex 5' nuclease (TaqMan) real-time PCR was developed and in-house validated for the specific detection of Salmonella enterica subspecies enterica serovar Enteritidis in whole chicken carcass rinses and consumption eggs. The assay uses specifically designed primers and a TaqMan probe to target the Prot6e gene located on the S. Enteritidis specific 60-kb virulence plasmid. As an internal amplification control to monitor Salmonella DNA in the sample, a second primer/TaqMan probe set detects simultaneously the Salmonella specific invA gene. The assay identified correctly 95% of the 79 Salmonella Enteritidis strains tested comprising 19 different phage types. None of the 119 non-Enteritidis strains comprising 54 serovars was positive for the Prot6e gene. The assay detection probability was for 10(2) or more genome equivalents 100% and for 10 equivalents 83%. A pre-PCR sample preparation protocol including a pre-enrichment step in buffered peptone water, followed by DNA extraction was applied on low levels of artificially contaminated whole chicken carcass rinses and eggs from hens as well as 25 potentially naturally contaminated chickens. The detection limit was less than three CFU per 50 ml carcass rinse or 10 ml egg. The sensitivity and specificity compared to the traditional culture-based detection method and serotyping were both 100%. Twenty-five potentially naturally contaminated chickens were compared by the real-time PCR and the traditional cultural isolation method resulting in four Salmonella positive samples of which two were positive for the Prot6e gene and serotyped as S. Enteritidis. We show also that Salmonella isolates which have a rough lipopolysaccharide structure could be assigned to the serovar Enteritidis by the real-time PCR. This methodology can contribute to meet the need of fast identification and detection methods for use in monitoring and control measures programmes.     

Ability of Shiga Toxin-Producing Escherichia coli and Salmonella spp. To Survive in a Desiccation Model System and in Dry Foods

In order to determine desiccation tolerances of bacterial strains, the survival of 58 diarrheagenic strains (18 salmonellae, 35 Shiga toxin-producing Escherichia coli [STEC], and 5 shigellae) and of 15 nonpathogenic E. coli strains was determined after drying at 35°C for 24 h in paper disks. At an inoculum level of 10⁷ CFU/disk, most of the salmonellae (14/18) and the STEC strains (31/35) survived with a population of 10³ to 10⁴ CFU/disk, whereas all of the shigellae (5/5) and the majority of the nonpathogenic E. coli strains (9/15) did not survive (the population was decreased to less than the detection limit of 10² CFU/disk). After 22 to 24 months of subsequent storage at 4°C, all of the selected salmonellae (4/4) and most of the selected STEC strains (12/15) survived, keeping the original populations (10³ to 10⁴ CFU/disk). In contrast to the case for storage at 4°C, all of 15 selected strains (5 strains each of Salmonella spp., STEC O157, and STEC O26) died after 35 to 70 days of storage at 25°C and 35°C. The survival rates of all of these 15 strains in paper disks after the 24 h of drying were substantially increased (10 to 79 times) by the presence of sucrose (12% to 36%). All of these 15 desiccated strains in paper disks survived after exposure to 70°C for 5 h. The populations of these 15 strains inoculated in dried foods containing sucrose and/or fat (e.g., chocolate) were 100 times higher than those in the dried paper disks after drying for 24 h at 25°C.     

Detection of Small Numbers of Campylobacter jejuni and Campylobacter coli Cells in Environmental Water, Sewage, and Food Samples by a Seminested PCR Assay

A rapid and sensitive assay was developed for detection of small numbers of Campylobacter jejuni and Campylobacter coli cells in environmental water, sewage, and food samples. Water and sewage samples were filtered, and the filters were enriched overnight in a nonselective medium. The enrichment cultures were prepared for PCR by a rapid and simple procedure consisting of centrifugation, proteinase K treatment, and boiling. A seminested PCR based on specific amplification of the intergenic sequence between the two Campylobacter flagellin genes, flaA and flaB, was performed, and the PCR products were visualized by agarose gel electrophoresis. The assay allowed us to detect 3 to 15 CFU of C. jejuni per 100 ml in water samples containing a background flora consisting of up to 8,700 heterotrophic organisms per ml and 10,000 CFU of coliform bacteria per 100 ml. Dilution of the enriched cultures 1:10 with sterile broth prior to the PCR was sometimes necessary to obtain positive results. The assay was also conducted with food samples analyzed with or without overnight enrichment. As few as ≤3 CFU per g of food could be detected with samples subjected to overnight enrichment, while variable results were obtained for samples analyzed without prior enrichment. This rapid and sensitive nested PCR assay provides a useful tool for specific detection of C. jejuni or C. coli in drinking water, as well as environmental water, sewage, and food samples containing high levels of background organisms.     

SYBR Green Real-Time PCR-RFLP Assay Targeting the Plasmodium Cytochrome B Gene – A Highly Sensitive Molecular Tool for Malaria Parasite Detection and Species Determination

A prerequisite for reliable detection of low-density Plasmodium infections in malaria pre-elimination settings is the availability of ultra-sensitive and high-throughput molecular tools. We developed a SYBR Green real-time PCR restriction fragment length polymorphism assay (cytb-qPCR) targeting the cytochrome b gene of the four major human Plasmodium species (P. falciparum, P. vivax, P. malariae, and P. ovale) for parasite detection and species determination with DNA extracted from dried blood spots collected on filter paper. The performance of cytb-qPCR was first compared against four reference PCR methods using serially diluted Plasmodium samples. The detection limit of the cytb-qPCR was 1 parasite/μl (p/μl) for P. falciparum and P. ovale, and 2 p/μl for P. vivax and P. malariae, while the reference PCRs had detection limits of 0.5–10 p/μl. The ability of the PCR methods to detect low-density Plasmodium infections was then assessed using 2977 filter paper samples collected during a cross-sectional survey in Zanzibar, a malaria pre-elimination setting in sub-Saharan Africa. Field samples were defined as ‘final positive’ if positive in at least two of the five PCR methods. Cytb-qPCR preformed equal to or better than the reference PCRs with a sensitivity of 100% (65/65; 95%CI 94.5–100%) and a specificity of 99.9% (2910/2912; 95%CI 99.7–100%) when compared against ‘final positive’ samples. The results indicate that the cytb-qPCR may represent an opportunity for improved molecular surveillance of low-density Plasmodium infections in malaria pre-elimination settings.     

Specific detection and confirmation of Campylobacter jejuni by DNA hybridization and PCR.

Conventional detection and confirmation methods for Campylobacter jejuni are lengthy and tedious. A rapid hybridization protocol in which a 1,475-bp chromogen-labelled DNA probe (pDT1720) and Campylobacter strains filtered and grown on 0.22-micron-pore-size hydrophobic grid membrane filters (HGMFs) are used was developed. Among the environmental and clinical isolates of C. jejuni, Campylobacter coli, Campylobacter jejuni subsp. doylei, Campylobacter lari, and Arcobacter nitrofigilis and a panel of 310 unrelated bacterial strains tested, only C. jejuni and C. jejuni subsp. doylei isolates hybridized with the probe under stringent conditions. The specificity of the probe was confirmed when the protocol was applied to spiked skim milk and chicken rinse samples. Based on the nucleotide sequence of pDT1720, a pair of oligonucleotide primers was designed for PCR amplification of DNA from Campylobacter spp. and other food pathogens grown overnight in selective Mueller-Hinton broth with cefoperazone and growth supplements. All C. jejuni strains tested, including DNase-producing strains and C. jejuni subsp. doylei, produced a specific 402-bp amplicon, as confirmed by restriction and Southern blot analysis. The detection range of the assay was as low as 3 CFU per PCR to as high as 10(5) CFU per PCR for pure cultures. Overnight enrichment of chicken rinse samples spiked initially with as little as approximately 10 CFU/ml produced amplicons after the PCR. No amplicon was detected with any of the other bacterial strains tested or from the chicken background microflora. Since C. jejuni is responsible for 99% of Campylobacter contamination in poultry, PCR and HGMF hybridization were performed on naturally contaminated chicken rinse samples, and the results were compared with the results of conventional cultural isolation on Preston agar. All samples confirmed to be culture positive for C. jejuni were also identified by DNA hybridization and PCR amplification, thus confirming that these DNA-based technologies are suitable alternatives to time-consuming conventional detection methods. DNA hybridization, besides being sensitive, also has the potential to be used in direct enumeration of C. jejuni organisms in chicken samples.     

Enumeration of Escherichia coli Cells on Chicken Carcasses as a Potential Measure of Microbial Process Control in a Random Selection of Slaughter Establishments in the United States

To evaluate whether the number of Escherichia coli bacteria in carcass rinses from chicken slaughter establishments could be monitored for the purpose of microbial process control, we drew a random sample from 20 of 127 large USDA-inspected operations. In 2005, every 3 months, two sets of 10 carcass rinses, 100 ml each, were collected from establishments, netting 80 sample sets from the rehang and postchill stages. E. coli and Campylobacter numbers and Salmonella prevalence were measured. Mixed-effect models were used to estimate variance of mean log₁₀ E. coli cell numbers of 10-carcass rinse sample sets. Relationships between E. coli and Campylobacter and Salmonella were examined. For 10-carcass rinse sets, at both the rehang and postchill stages the mean log₁₀ E. coli CFU/ml fit the logistic distribution better than the normal distribution. The rehang overall mean log₁₀ E. coli was 3.3 CFU/ml, with a within-sample set standard deviation of 0.6 CFU/ml. The overall postchill mean log₁₀ E. coli was 0.8 CFU/ml, with 13 establishments having mean log₁₀ E. coli CFU/ml values of less than 1.0 and 7 having mean values of 1.2 or more. At the midpoint separating these establishments, a mean log₁₀ E. coli CFU/ml of 1.1, the within-sample set standard deviation was 0.5 CFU/ml, with smaller standard deviations as means increased. Postchill sample sets with mean log₁₀ E. coli counts less than or equal to 1.1 CFU/ml had lower overall prevalence of Salmonella and mean log₁₀ Campylobacter CFU/ml than sample sets with higher means. These findings regarding reductions in E. coli numbers provide insight relevant to microbial process control.Regulatory food microbiology standards are defined and enforced with the intent of protecting public health and maintaining consumer confidence in the safety of the food supply. Resource demands (22) and legal constraints (21) have hindered the U.S. Department of Agriculture (USDA) from enforcing its current Salmonella performance standard (3). For this reason, in 2004 the USDA requested guidance from its national scientific advisory committee on the possible use of E. coli numbers to monitor sanitary conditions during poultry slaughter (12). The committee acknowledged that, if valid, such a performance standard could facilitate inspection of slaughter processing establishments. The committee recommended studies to define how E. coli numbers vary in poultry carcass rinses during poultry processing by processing stage, time of year, and geographic region and with respect to food-borne pathogens.The widespread presence and high numbers of generic E. coli bacteria on poultry entering the slaughter establishment (2, 5, 14) are suitable characteristics for an indicator organism used to monitor microbial control processes. The ease and lower cost (5, 13) of E. coli enumeration also allow more observations than can be made when comparable resources are allocated for Campylobacter or Salmonella testing (15).Regulatory agencies and food manufacturers have recognized the potential utility of E. coli numbers as a measure of slaughter process control. For example, USDA''s hazard analysis and critical control point rule (3) specifies two criteria for evaluating process control: establishments are to maintain less than 100 CFU of E. coli per ml in 80% of poultry carcass rinses and never exceed 1,000 CFU/ml. Surveys have been performed to define precise E. coli performance criteria for poultry (5), to monitor microbial reduction during slaughter processing (6), and to validate interventions to reduce microbial numbers on poultry (20).If generic E. coli numbers on poultry carcasses fit a parametric distribution, with a predictable mean and standard deviation, then carcasses could be monitored using a statistical process control plan. For example, if E. coli numbers decrease by an acceptable amount during processing to a reasonable level, then the process could be considered to be under control. Or a plan could be designed to monitor for acceptable occurrences of small, medium, and large deviations above a target E. coli number (7). If relationships were found between E. coli and Campylobacter numbers during chicken slaughter as well as Salmonella prevalence, they would further support the use of E. coli numbers as a measure of process control.This study of a random sample of 20 large chicken slaughter operations located throughout the United States measured microbial numbers at two processing line locations. Once a quarter, 10 carcass rinse samples were collected from both the post-feather-pick (rehang) and postchill locations. Rinses were examined to estimate mean Salmonella prevalence and E. coli and Campylobacter numbers by location within establishments. The primary objective was to assess whether the reduction in E. coli numbers between the rehang and postchill stages or numbers at the postchill location might have utility as a measure of process control during chicken slaughter. A related objective was to estimate values of parameters that could be used to design statistical process control plans (7).     

Simultaneous and rapid detection of enteric pathogens from raw milk by multiplex PCR

Enteroinvasive Escherichia coli (EIEC), heat-labile enterotoxin (LT) E. coli, Shigella spp., and Salmonella spp. are common enteric pathogens, which cause food-borne diseases if consumed in contaminated milk products. The rapid and reliable methods for detecting are imperative for reduction in hazard of infection. In this study, we selected primers, optimized the polymerase chain reaction (PCR) conditions, and analyzed the sensitivity and specificity of the multiplex PCR assay to screen raw milk from these enteric bacteria. Furthermore, EIEC, LT-E. coli, Shigella spp., Salmonella spp., and 11 non-targeted pathogenic strains were performed for the specificity of the multiplex PCR. Specific bands showed in EIEC, LT-E. coli, Shigella spp., and Salmonella spp. but no bands showed in other 11 pathogenic strains. The sensitivity of multiplex PCR was relatively high, was rounded to 200 CFU/ml (Shigella spp. and EIEC), 320 CFU/ml (Salmonella spp.), and 100 CFU/ml (LT-E. coli). This method for simultaneous and rapid detection of enteric pathogens (EIEC, LT-E. coli, Shigella spp., and Salmonella spp.) in raw milk showed high sensitivity and specificity, and led to faster track to report results.     

Simple Detection Methods for Antinutritive Factor β-ODAP Present in Lathyrus sativus L. by High Pressure Liquid Chromatography and Thin Layer Chromatography

Lathyrus sativus L. (Grass pea) is the source for cheap and nutritious food choice in drought and famine susceptible zones in greater part of North India and Africa. The non-protein amino acid β-N-oxalyl-L-α,β-diaminopropionic acid (β-ODAP) has been known for decades for its potent neurotoxic effect, causing irreversible neurodegenerative disease “neurolathyrism”, present in both seed and leaf of Lathyrus sativus L. and other species in varying proportions. It is crucial to establish a rapid as well as reliable detection methodology for β-ODAP content in various Lathyrus plants. Currently available HPLC based methods involve multi-step derivatization of the sample. To overcome this, we have developed β-ODAP analysis method by HPLC without any prior derivatization. This method is statistically significant in the range of 2 to 100μg/ml and exhibited linear response with r ² > 0.99. Limit of detection and quantitation of the later method was determined to be 5.56 μg/ml and 16.86 μg/ml, respectively. In addition to this, a TLC based method has also been developed. The limit of detection of β-ODAP is 0.6μg and for its substrate, L-1,2-diaminopropionic acid is 5μg. Both HPLC and TLC methods were validated by conducting in-vitro bioconversion test to detect the presence of biocatalyst in plant extract. This method is economical, rapid and simple.     

Rapid Sample Processing for Detection of Food-Borne Pathogens via Cross-Flow Microfiltration

This paper reports an approach to enable rapid concentration and recovery of bacterial cells from aqueous chicken homogenates as a preanalytical step of detection. This approach includes biochemical pretreatment and prefiltration of food samples and development of an automated cell concentration instrument based on cross-flow microfiltration. A polysulfone hollow-fiber membrane module having a nominal pore size of 0.2 μm constitutes the core of the cell concentration instrument. The aqueous chicken homogenate samples were circulated within the cross-flow system achieving 500- to 1,000-fold concentration of inoculated Salmonella enterica serovar Enteritidis and naturally occurring microbiota with 70% recovery of viable cells as determined by plate counting and quantitative PCR (qPCR) within 35 to 45 min. These steps enabled 10 CFU/ml microorganisms in chicken homogenates or 10² CFU/g chicken to be quantified. Cleaning and sterilizing the instrument and membrane module by stepwise hydraulic and chemical cleaning (sodium hydroxide and ethanol) enabled reuse of the membrane 15 times before replacement. This approach begins to address the critical need for the food industry for detecting food pathogens within 6 h or less.